2002 VOLVO VN Recalls

Recalls Found

All Recalls

Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."

NHTSA 12V510000

Report Date

18/10/2012

Component

SEAT BELTS

Manufacturer

Volvo Trucks North America

Consequence: In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.

Remedy / Corrective Action

Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.

ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS WITH VOLVO B-RIDE REAR SUSPENSION, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT COULD BREAK ALLOWING THE AFFECTED AXLE TO SHIFT OUT OF ALIGNMENT.

NHTSA 02V317000

Report Date

25/11/2002

Component

SUSPENSION:MULTIPLE AXLE

Manufacturer

VOLVO TRUCKS NORTH AMERICA INC

Consequence: THIS CONDITION COULD RESULT IN LOSS OF AXLE STABILITY, INCREASING THE RISK OF A CRASH.

Remedy / Corrective Action

DEALERS WILL REPLACE THE UPPER AXLE SEAT ON BOTH REAR DRIVE AXLES. OWNER NOTIFICATION BEGAN JANUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.

NHTSA 04V457000

Report Date

17/09/2004

Component

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Manufacturer

VOLVO TRUCKS NORTH AMERICA, INC.

Consequence: IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.

Remedy / Corrective Action

DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

ON CERTAIN TRUCKS, A MALFUNCTION IN THE SOLENOID VALVE MAY ALLOW AIR TO BE RELEASED TO FIFTH WHEEL LATCH WHEN THE PARK BRAKE IS ENGAGED.

NHTSA 04V315000

Report Date

02/07/2004

Component

TRAILER HITCHES:FIFTH WHEEL ASSEMBLY

Manufacturer

VOLVO TRUCKS NORTH AMERICA, INC.

Consequence: THIS CONDITION COULD CAUSE THE FIFTH WHEEL LATCH TO RELEASE INADVERTENTLY WHEN THE PARK BRAKE IS ENGAGED, CREATING THE POTENTIAL FOR LOSS OF THE TRAILER. A CRASH COULD OCCUR WITHOUT PRIOR WARNING.

Remedy / Corrective Action

DEALERS WILL ADD AN ADDITIONAL SOLENOID VALVE IN SERIES WITH THE EXISTING PNEUMATIC CIRCUIT FOR THE FIFTH WHEEL AIR RELEASE. THE RECALL BEGAN ON AUGUST 9, 2004. OWNERS SHOULD CONTACT VOLVO AT 1-800-528-6586.

ON CERTAIN HEAVY-DUTY CLASS 8 TRUCKS, THE ASSEMBLED ENGINE PRE-HEATER JUMPER WIRING HARNESS WAS INCORRECTLY ASSEMBLED.

NHTSA 04V077000

Report Date

13/02/2004

Component

ENGINE AND ENGINE COOLING

Manufacturer

VOLVO TRUCKS NORTH AMERICA, INC.

Consequence: THE ENGINE PRE-HEATER COULD OVERHEAT RESULTING IN DAMAGE TO THE PRE-HEATER AND OTHER ENGINE HEAT SENSITIVE COMPONENTS NEAR THE PRE-HEATER AND THE ABILITY TO RE-START THE ENGINE COULD BE COMPROMISED, INCREASING THE RISK OF A CRASH.

Remedy / Corrective Action

DEALERS WILL REPAIR THE AFFECTED CIRCUITS IN THE JUMPER WIRING HARNESS CONNECTOR. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.

⭐

4.9/5.0

22 reviews

Frequently Asked Questions

How many recalls does the 2002 VOLVO VN have?

The 2002 VOLVO VN currently has 5 recalls according to NHTSA records. All recall information is sourced directly from the National Highway Traffic Safety Administration database.

Are 2002 VOLVO VN recalls free to fix?

Yes! All safety recalls for 2002 VOLVO VN vehicles must be repaired free of charge by authorized dealers, regardless of vehicle age or mileage. Contact your local VOLVO dealer to schedule a recall repair.

How do I check if my 2002 VOLVO VN has open recalls?

You can check for open recalls by entering your VIN (Vehicle Identification Number) in our VIN decoder tool. The 17-character VIN can be found on your vehicle registration, insurance card, or on the driver's side dashboard visible through the windshield.