How many problems does the 2001 HYUNDAI Santa Fe have?

The 2001 HYUNDAI Santa Fe currently has 212 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2001 HYUNDAI Santa Fe?

The most common problems reported for the 2001 HYUNDAI Santa Fe are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2001 HYUNDAI Santa Fe problem data come from?

All problem and complaint data for the 2001 HYUNDAI Santa Fe comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2001 HYUNDAI Santa Fe Problems

SUSPENSION

58 complaints

The rear trailing arm cracked in half causing my wife to run off the road11

Nov 10, 2021

Crash: 1

The contact's friend owns a 2001 Hyundai Santa Fe. The contact stated that while a friend was driving at approximately 55 MPH, the vehicle began to veer off to the right without warning and the driver began losing control of the vehicle. Despite the failure, the contact's friend was able to drive the vehicle to her home at slow speeds. Another friend was able to inspect the vehicle and discovered that the rear passenger’s side trailing arm had fractured due to severe corrosion. Upon investigation, the contact discovered NHTSA Campaign Number: 09V123000 (Suspension) which he linked to the failure. The dealer and the manufacturer were both notified of the failure and he was informed that his vehicle was not under recall. The vehicle had yet to be repaired. The failure mileage was unknown.

Aug 24, 2021

MY WIFE WAS ACCELERATING TO 45 MPH, THE VEHICLE BEGAN TO SWERVE LEFT TO RIGHT RAPIDLY. THERE WAS NO WARNING INDICATOR ILLUMINATED. SHE COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. SHE NOTICED THAT THE REAR PASSENGER SIDE WHEEL WAS ALMOST TOUCHING THE INSIDE OF THE REAR FENDER. SHE WAS ABLE TO LIMP IT ABOUT A MILE HOME TO DRIVEWAY. SHE CONTACTED HYUNDAI & THEY TOLD HER TO TOW IT TO CLOSEST HYUNDAI DEALERSHIP & REAP SUSPENSION PROBLEM WILL BE FIXED UNDER RECALL. AFTER WE PAID TO HAVE IT TOWED TO DEALERSHIP IT WAS DIAGNOSED THAT THE REAR TRAILING ARM WAS CORRODED AND ALMOST BROKEN & NEEDED TO BE REPLACED. THE DEALER SERVICE TECHNICIAN CALLED MY WIFE THE NEXT DAY TO INFORM HER THAT HER SANTA FE REAR TRAILING ARMS HAD NOT BEEN REPLACED BY HYUNDAI. SHE IMMEDIATELY CALLED HYUNDAI TO SPEAK WITH PERSON THAT TOLD HER TO HAVE IT TOWED TO DEALERSHIP. HYUNDAI OPENED A CASE NUMBER FOR HER SANTA FE. HYUNDAI CALLED BACK COUPLE DAYS LATER SAYING THEY HAD RESEARCHED HER SANTA FE UNDER RECALL CAMPAIGN 090 AND THAT IT DID NOT QUALIFY BEING THAT IT HAD NOT REGISTERED WITHIN THE 20 SALT BELT STATES REQUIRED FOR RECALL. HYUNDAI CASE WORKER SAID THEY WERE NOT GOING TO REPAIR THE SANTA FE UNDER RECALL.& HYUNDAI WAS CLOSING THE CASE. AFTER A VERY EXTENSIVE SEARCH ON THE SANTA FE FRAME CORROSION RECALL SHE DISCOVERED THAT THE FRAME CORROSION RECALL HAD BEEN EXPANDED TO INCLUDE EVERY SANTA FE WITHIN THE 50 STATES, ALTHOUGH HYUNDAI DID NOT SEND NOTICES TO ANYONE UNLESS THE SANTA FE HAD BEEN REGISTERED IN THE 20 SALT BELT STATES. WITH THIS NEW INFO SHE HAS BEEN TRYING TO CONTACT THE HYUNDAI CASE WORKER TO RE-OPEN HER CASE. AS IT STANDS HER SANTA FE WAS TOWED TO HYUNDAI DEALERSHIP WHERE IT SITS IN BACK LOT UNTOUCHED & UNDRIVEABLE. AFTER CLOSER LOOK AT TRAILING ARMS BOTH SIDES ARE RUSTED COMPLETELY OUT.

Jan 10, 2021

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE CONTACT HEARD AN ABNORMAL POPPING SOUND COMING FROM THE REAR OF THE VEHICLE. THE CONTACT DROVE BACK TO HER RESIDENCE WHERE HER HUSBAND INSPECTED THE VEHICLE. THE CONTACT'S HUSBAND DISCOVERED CORROSION ON THE REAR CONTROL ARM. DUE TO THE CORROSION, THE DRIVER'S SIDE REAR CONTROL ARM FRACTURED. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT LINKED HER FAILURE TO NHTSA CAMPAIGN NUMBER: 09V123000 (SUSPENSION) HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000. *LN*JB

May 18, 2020

OUR MECHANIC HAS IDENTIFIED SIGNIFICANT CORROSION TO THE DRIVER'S SIDE REAR TRAILING ARM, A SAFETY AND OPERATIONAL VULNERABILITY CONSISTENT WITH NHTSA SAFETY RECALL NOTICE 09V123000. THE NHTSA SAFETY RECALL OBSERVES THE DANGER OF THE REAR TRAILING ARM FRACTURING, AND INCREASING THE RISK OF A VEHICLE CRASH. WE HAVE CONTACTED THE LOCAL DEALERSHIP AND THE MANUFACTURER, HYUNDAI, ABOUT THE SAFETY VULNERABILITY, RESULTING FROM THE LATENT MANUFACTURING WEAKNESS. AS DETAILED IN THE ATTACHED FILE. THE DEALER SERVICE DEPARTMENT IS INDIFFERENT TO THE FAULTY VEHICLE PART AND SAFETY VULNERABILITY, AND NO RESPONSE HAS BEEN RECEIVED FROM THE MANUFACTURER. WE ARE ATTACHING PHOTOS OF THE REAR TRAILING ARM CORROSION CONSISTENT WITH THE MANUFACTURING FAILURE IDENTIFIED IN THE NHTSA SAFETY RECALL.

Dec 21, 2019

+ 53 more complaints for this component

ENGINE AND ENGINE COOLING

27 complaints

CRANKSHAFT SENSOR FAILURE 2001 SANTA FE 4 CYL. WHILE DRIVING VEHICLE STALLED. *TR

Sep 19, 2010

MY 01 HYUNDAI SANTA FE DOWNSHIFTS WHILE ON THE HIGHWAY WITH A LOUD POP AND DECELERATES THE VEHICLE SUBSTANTIALLY CAUSING A TRAFFIC/SAFETY HAZARD. THIS IS CORRECTED MOMENTARILY WHEN I STOP AND RESTART THE ENGINE AS IF IT RESETS SOMETHING, THEN OF COURSE WHEN I GET BACK ON THE HIGHWAY IT DOES IT ALL OVER AGAIN. OTHER 01 SANTA FE OWNERS SUFFER THE SAME DANGEROUS CIRCUMSTANCES. WHY NOT RECALL THE VEHICLE TO CORRECT THIS ISSUE? THIS IS AN ACCIDENT WAITING TO HAPPEN. *TR

Jul 28, 2009

WHILE DRIVING AT 30MPH (2001 SANTA FE), I FELT A BIG JERK WHICH I NEVER FELT IT BEFORE WITH THIS CAR. AFTER THAT I MADE A RIGHT TURN AND MY CAR SUDDENLY STOPPED AND CHECK ENGINE LIGHT COMES ON. WHEN I RE-STARTED THE CAR, IT STARTED FINE. *TR

Jul 31, 2008

CRANKSHAFT SENSOR FAILED ON MY 2001 4 CYLINDER HYUNDAI SANTA FE. THE CAR SUDDENLY STALLED AND WOULD NOT RESTART. I WAS DRIVING ON BUSY STREET IN THE WINTER EVENING AND, AT THE TIME, WAS ON CRUTCHES AND UNABLE TO NAVIGATE ON FOOT. I WAITED IN 20 DEGREE WEATHER FOR ABOUT 45 MINUTES UNTIL A POLICE PERSON RESCUED ME. *TR

Jul 07, 2008

2001 SANTA FE 4 CYLINDER REPEATEDLY STALLED, WOULDN'T START. DEALERSHIP WHERE PURCHASED HAD CAR FOR 2 FULL DAYS, COULDN'T FIND THE PROBLEM. PRIVATE MECHANIC REPLACED CRANKCASE SENSOR, PROBLEM SOLVED. FAULTY CRANKCASE SENSOR SUBJECT OF RECALL FOR 6 CYLINDER ENGINE ON SAME MODEL. *NM

May 03, 2006

+ 22 more complaints for this component

ELECTRICAL SYSTEM

21 complaints

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CRANKSHAFT POSITION SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V030000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.

Mar 24, 2016

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTE FE. THE CHECK ENGINE LIGHTS ILLUMINATED AND THE VEHICLE WILL NOT SHIFT PROPERLY. WHILE DRIVING 55 MPH AND SHIFTING GEARS,THE GEAR STUCK FROM FOURTH TO THIRD GEAR. THE CONTACT TURNED THE VEHICLE OFF. THE VEHICLE OPERATED NORMALLY ONCE IT WAS RESTARTED. THE FAILURE USUALLY OCCURRED DURING RAINY OR DAMP CONDITIONS. THE DEALER INFORMED THE CONTACT THAT THE FAILURE WAS DUE TO A CRACKED CRANKSHAFT. THE VEHICLE WAS INSPECTED, AND THE CRANKSHAFT WAS REPLACED ON MARCH 30, 2004. AFTER THE CRANKSHAFT WAS REPLACED THERE WERE NO OCCURRENCES UNTIL MAY 2005 AND AUGUST 2005, WHEN THE COIL WAS REPLACED. THE VEHICLE OPERATED NORMALLY UNTIL NOVEMBER 2006. THE CURRENT AND FAILURE MILEAGE WAS 88,000.*AK THE CONSUMER HAS PROVIDED A RECALL FOR THE ELECTRICAL SYSTEM PERTAINING TO THE CRANKSHAFT POSITIONER AND INVOICES FOR THE REPAIRS. THE DEALER STATED THAT THE SPEED SENSOR HAS BEEN REPLACED. UPDATE 5/3/07*TR

Feb 26, 2007

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH ON THE HIGHWAY, THE VEHICLE STALLED WITHOUT WARNING. IT WAS MANEUVERED OFF THE ROAD AND TOWED TO THE DEALER WHO REPLACED THE CRANK SHAFT POSITION SENSOR. THERE WAS A NHTSA RECALL, # 03V030000, REGARDING THE ELECTRICAL SYSTEM; STARTER ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

Oct 23, 2006

MY 2001 HYUNDAI SANTA FE HAD A VERY BAD ODOR LIKE WIRES WERE BURNING IN THE VEHICLE. WHEN THAT OCCURRED MY POWER DOOR LOCKS WOULD NOT WORK AND MY REAR WIPER WOULD NOT WORK. THE SMELL WAS SO BAD I HAD TO LOWER ALL THE WINDOWS SO I WOULD NOT PASS OUT. I STOP TO CHECK IF THERE WAS A FIRE. I TOOK IT TO THE DEALER WHO SAID THEY COULD NOT FIND ANY PROBLEM, BECAUSE IT DID NOT OCCUR WHEN THEY CHECKED IT. I WAS TOLD TO BRING THE CAR BACK IMMEDIATELY WHEN IT HAPPENS AGAIN. I WAS WONDERING IF THERE WERE ANY SIMILAR PROBLEMS WITH 2001 SANTA FE'S. *JB

Apr 05, 2006

DT:THE CONTACT STATED THE CPS CAPACITOR THAT IS WITH THE CRANK SHAFT POSITION SENSOR IS NOT WORKING PROPERLY AND AS A RESULT THE VEHICLE STALLED ON THE FREEWAY. THE DEALERSHIP RAN A DIAGNOSTIC TEST AND THIS PROBLEM CAME UP AS A CRITICAL CODE. THE CONSUMER FOUND NHTSA RECALL 03V030000 FOR THIS PROBLEM BUT THE DEALERSHIP TOLD HER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK UPDATED 2/7/2006 - *NM

Nov 07, 2005

+ 16 more complaints for this component

POWER TRAIN

14 complaints

OIL LIGHT CAME ON .SO I CARRY TO THE PEOPLE THAT DID MY OIL CHANGE THEY CHECKED IT OUT THEY DID NOT SEE WHERE IT WAS LEAKING FROM. THEY REFILL IT AND THEN THE LIGHT CAME ON AGAIN ,SO THIS TIME I CARRY IT TO THE DEALER ON THAT MONDAY THEY GAVE ME AN APP. FOR THAT WEDNESDAY THE 13TH KEPT IT OVERNITE AND RETURNED BACK THE 14TH MAN IN PARTS DEPT SAID IT WAS BLOWING OUT THE TAIL PIPE. NO LEAKS ON THE GROUND. OIL LIGHT CAME ON AGAIN AND NOW THEY SAID THE B.B.B.SAID MY CAR IS TO OLD AND THAT THE PEOPLE THAT DID MY OIL CHANGE DID NOT PUT OIL IN ,WHICH IS A LIE. START TO BURN OIL AT LITTLE OVER 85000 MILE. I CARRY IT TO THE DEALER AND THEY SAID THEY FIXED IT BUT THEY DID NOT. *TR

Nov 14, 2008

VEHICLE- HYUNDAI SANTA FE 2001 2.4L 58000 MILES SUDDEN CLUTCH FAILURE DUE TO EXCESSIVE SLIPPAGE CAUSED BY HYDRAULIC PROBLEM IN THE CLUTCH SLAVE CYLINDER. INTERNET RESEARCH INDICATES THIS IS A PERVASIVE PROBLEM WITH HYUNDAI CLUTCHES IN GENERAL. MANUFACTURER APPARENTLY IS IGNORING THE PROBLEM. IN EXCESS OF $2000 IN QUOTED REPAIRS. *JB

Jun 29, 2006

I HAVE THE SAME COMPLAINT AS MANY SANTA FE OWNERS. PROBLEMS OF ACCELERATION AT 40, ALONG WITH SHIFTING ISSUES. ON SEVERAL TRIPS TO THE DEALER, LEAVING THE CAR THERE FOR SOMETIMES 7-15 DAYS AT A TIME. IT HAS HAD 4 THROTTLE POSITION SENSORS, AN ALTERNATOR AND 2 BATTERIES. MY MILEAGE IS 100,386 AND THE VEHICLE NEEDS 3000.00 WORTH OF TRANSMISSION WORK. HYUNDAI SIMPLY STATES MY VEHICLE IS OUT OF WARRANTY AND THESE ISSUES DO NOT HAVE ANYTHING TO DO WITH MY TRANSMISSION. I HAVE A SIGNED STATEMENT FROM THE TRANSMISSION SHOP MANAGER THAT STATES A TPS PROBLEM ABSOLUTELY WILL AFFECT THE TRANSMISSION. *NM

Sep 16, 2005

MY CAR IS A 2001 4-CYLINDER 5-SPEED MANUAL TRANSMISSION. THE ENGINE IS TOO SMALL FOR THE CAR'S WEIGHT. I HAD TO HAVE THE CLUTCH REPLACED AFTER ONLY 24,000 MILES, WHICH WAS NOT COVERED UNDER THE WARRANTY (COST WAS OVER $1000). THE DEALER INSISTED THAT I CAUSED THE PROBLEM BY "BAD DRIVING". I HAVE DRIVEN A STICK FOR WELL OVER 12 YEARS, AND NEVER HAD TO REPLACE A CLUTCH ON ANY OTHER CAR. *JB

Aug 01, 2005

DT: 2001 HYUNDAI SANTA FE HAS AUTOMATIC/STANDARD TRANSMISSION WHICH WOULD DOWNSHIFT ON ITS OWN. THE CONSUMER FIRST NOTICED THIS PROBLEM WHEN GETTING ONTO THE HIGHWAY AND THE VEHICLE WOULDN'T SHIFT OUT OF THIRD GEAR. WHEN CONSUMER EXITED THE HIGHWAY HE NOTICED HE ONLY HAD SECOND AND THIRD GEARS. HE SHUT THE VEHICLE OFF AND RESTARTED IT AND THE VEHICLE OPERATED NORMALLY. *AK

Jul 22, 2005

+ 9 more complaints for this component

STRUCTURE

10 complaints

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR AN OIL CHANGE, IT WAS DIAGNOSED THAT THE SUBFRAME FAILED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 126,000.

Apr 12, 2017

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING 55 MPH, THE VEHICLE VEERED TO THE RIGHT AND THE STEERING WHEEL SEIZED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,592.

Dec 29, 2014

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED AND CAUSED DAMAGE TO THE FRONT TIRES. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Nov 17, 2014

DRIVING STRAIGHT ON HIGHWAY AT ABOUT 55 MPH. CAR HOOD BLEW WIDE OPEN AND WAS LAYING UP, OVER MY WINDSHIELD. LEFT ME ALMOST BLINDED; ABLE TO SEE OUT A SMALL OPENING, ABOUT 2-4 INCHES AT BOTTOM OF WINDSHIELD WHERE HOOD IS RAISED UP BY HINGES. WAS ABLE TO GET TO SHOULDER OF ROAD SAFELY. BOTH HOOD LATCH AND SAFETY LATCH FAILED. CAR IS IN EXCEPTIONALLY GOOD CONDITION EXCEPT FOR MY NOW BENT AND DAMAGED HOOD. I AM VERY LUCKY TO BE ALIVE. THANK YOU G-D. I HAVE ALSO REPORTED THIS HOOD FAILURE TO HYUNDAI MOTOR COMPANY. HOPE THIS HELPS TO PREVENT SOMEONE FROM GETTING SERIOUSLY INJURED OR KILLED. *TR

Jan 17, 2012

AFTER TURNING A CORNER @ 15 MPH I HAD TO LEAVE THE STEERING WHEEL AT THE 9 O-CLOCK POSITION IN ORDER TO DRIVE STRAIGHT. I NOTICED THE VEHICLE PULLING TO THE RIGHT. I THOUGHT I HAD AN ALIGNMENT PROBLEM SO I SCHEDULE AN APPOINTMENT AT THE LOCAL TIRE REPAIR SHOP. ONCE THEY LIFTED THE VEHICLE UP FOR INSPECTION THEY NOTICED THAT THE SUBFRAME HAD RUSTED THROUGH AND BROKE. AFTER SPEAKING WITH THE MECHANIC I FELL VERY FORTUNATE THAT I WAS NOT DRIVING ON THE HIGHWAY AT THE TIME OF THE FAILURE. AFTER FURTHER INVESTIGATION ON THE INTERNET I FOUND THAT THE 2001 HYUNDAI SANTA FE IS CURRENTLY BEING INVESTIGATED FOR THIS EXACT PROBLEM SO I CALLED THE LOCAL DEALERSHIP. THE DEALERSHIP STATED I WAS THE 3RD VEHICLE THEY HAVE REPAIRED FOR THIS PROBLEM. THE DEALERSHIP IS MAKING THE NECESSARY REPAIRS WITH NO COST TO ME. I FELL THAT ALL 2001 SANTA FE'S SHOULD BE RECALLED FOR AN INSPECTION AT THE LEAST. WE SHOULD NOT BE WAITING FOR A SEVERE ACCIDENT BEFORE THE NECESSARY STEPS ARE TAKEN. THERE ARE ONLY 30,000 PEOPLE LIVING IN THE TOWN WHERE I HAD MY VEHICLE TAKEN FOR SERVICE, 3 REPAIRS WOULD INDICATE TO ME THAT OVER THE ENTIRE USA THERE ARE A LOT MORE VEHICLES WITH THE SAME PROBLEM. *TR

Mar 24, 2009

+ 5 more complaints for this component

STEERING

7 complaints

DRIVING ON EXPRESSWAY PLASTIC GARBAGE BAG FLEW UNDER CAR CATCHING ON POWER STEERING LINES WHICH BROKE DUE TO RUST CORROSION. ONLY ONE LINE BROKE BUT REPLACED BOTH LINES AS PRECAUTION. HARD TO HAVE THE CAR TOWED. TOTAL COST $444.07 ( 277.15 PARTS + 166.92 LABOR- AAA MEMBERSHIP). MICHIGAN WINTERS! *TR

Nov 14, 2011

2001 HYUNDAI SANTA FE POWER STEERING LINES AND BRAKE LINES COMPLETELY RUSTED THROUGH. THERE IS A RECALL FOR THE SUSPENSION. MAKES SENSE IF THEY DIDN'T PROTECT THAT PROPERLY, THEN THEY DIDN'T PROTECT THESE LINES PROPERLY. CAN NOT STOP VEHICLE. CAN NOT STEER VEHICLE. *TR

Oct 01, 2010

2001 SANTA FE AT ABOUT 50,000 MILES, FRONT DRIVER SIDE BALL JOINT CAUSED STEERING PROBLEM MARCH 2006, PART REPLACED. THEN MARCH 2009 FRONT PASSENGER SIDE BALL JOINT BROKEN, AS BEFORE PART REPLACED. IN BOTH CASES THE STEERING CAUSED THE CAR TO PULL SEVERLY TO THE RIGHT. *TR

Apr 18, 2010

I HAD FAILURE OF THE REAR TRAILING ARM ON MY 2001 SANTA FE. ON THE HIGHWAY IN THE RAIN. I HAVE YET TO BE NOTIFIED OF THIS RECALL BY THE HYUNDAI CORPORATION. WHY? THIS RECALL IS 6 MONTHS OLD AND THIS IS THE FIRST I HEAR ABOUT IT. HOW MANY OTHERS DON'T KNOW? THIS COMPANY HAS BEEN SLOW TO RESPOND. *TR

Oct 21, 2009

THIS VEHICLE IS AN "ALL WHEEL DRIVE". THE VEHICLE'S TRANSMISSION UNEVENLY DISTRIBUTES POWER AT AROUND 35-40 MPH - CAUSING THE VEHICLE TO PULL DANGEROUSLY TO THE RIGHT. THIS "JERK" OF POWER TO THE RIGHT OCCASIONALLY CAUSES ME TO ALMOST SWERVE OUT OF MY LANE OF TRAFFIC!! *JB

Nov 11, 2004

+ 2 more complaints for this component

VEHICLE SPEED CONTROL

6 complaints

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE RPMS INCREASED EXCESSIVELY AND THE VEHICLE INDEPENDENTLY ACCELERATED TO OVER 100 MPH WHILE THE BRAKE WAS DEPRESSED. THE CONTACT WAS ABLE TO STOP THE VEHICLE AND HAD IT TOWED TO A LOCAL MECHANIC. A DIAGNOSTIC WAS PERFORMED AND THE FAILURE WAS LOCATED AT THE CRUISE CONTROL CABLE. THE MECHANIC RE-CRIMPED THE CRUISE CONTROL CABLE AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 150,000. THE VIN WAS NOT AVAILABLE.

Jan 23, 2013

I AM WRITING IN REGARDS TO A PROBLEM WITH A 2001 HYUNDAI SANTA FE. I BORROWED THE CAR FROM MY GIRLFRIEND TO RUN AN ERRAND. BEING 6 FOOT TALL AND HAVING A SIZE 13 FOOT I MUST SAY THE CAR WASN'T VERY COMFORTABLE EVEN WITH THE DRIVERS SEAT ALL THE WAY BACK. IT SEEMED TO RESPOND AND HANDLE SMOOTHLY BUT AS I EASED ON THE BRAKE TO SLOW FOR A RAILROAD CROSSING, THE TOE OF MY WORK BOOT BECAME WEDGED BETWEEN THE BRAKE PEDAL AND THE ACCELERATOR. THE VEHICLE SUDDENLY LAUNCHED LIKE A ROCKET AND MY IMPULSE WAS TO PRESS ON THE BRAKE PEDAL WITH MY FREE (LEFT) FOOT. THIS ONLY DEPRESSED THE ACCELERATOR FURTHER TO THE FLOOR AND THE CAR CONTINUED TO SPEED OUT OF CONTROL. IT WENT FROM 30 MPH TO NEARLY 90 MPH IN A VERY SHORT PERIOD OF TIME AND IN A MOMENT OF CLARITY I REACHED FOR THE IGNITION KEY. I SWITCHED THE IGNITION OFF LOSING ALL POWER STEERING AND BRAKING CAPABILITIES BUT WAS ABLE TO BRING THE VEHICLE TO A STOP WITHOUT INCIDENT. AT THIS POINT I WAS ABLE TO FREE MY RIGHT FOOT FROM IT'S TRAPPED POSITION BETWEEN THE TWO CONTROL PEDALS AND SAT IN A STATE OF SHOCK. IT WAS 2 DAYS LATER THAT I REALLY CAME BACK TO A SOMEWHAT LOGICAL STATE OF MIND AND DECIDED TO DO SOME RESEARCH AND HOPEFULLY ALERT OTHER DRIVERS TO THIS POTENTIAL DEADLY PROBLEM. MUCH TO MY HORROR, I FIND THAT I'M NOT THE FIRST ONE TO EXPERIENCE THIS AND BEING MECHANICAL MYSELF CAN SEE THAT THESE CARS ARE NOT DESIGNED BY 6 FOOT ENGINEERS WITH SIZE 13 BOOTS. I FOUND A SIMILAR COMPLAINT ON THE ABOUTAUTOMOBILE.COM FORUM WHILE SEARCHING THE 2001 SANTA FE ( COMPLAINT NUMBER 754795) AND AGREE THAT THESE VEHICLES HAVE A SERIOUS DESIGN FLAW IN THE PROXIMITY OF THE BRAKE / ACCELERATOR PEDAL CONFIGURATION. FOR A PERSON OF MY STATURE, THEY CAN BE POTENTIAL DEATH TRAPS ! *TR

Feb 05, 2009

TL*THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IDLING AND AS THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE DRAMATICALLY ACCELERATED. THE RPM'S SURGED TO APPROXIMATELY 3,000. THE DEALER COULD NOT DUPLICATE THE FAILURE OR PROVIDE A SUFFICIENT REMEDY. AS OF OCTOBER 8, 2008, THE VEHICLE HAS NOT BEEN PROPERLY REPAIRED. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 90,000.

Oct 08, 2008

I WAS COMING TO A RED LIGHT AND LET OFF THE GAS TO COAST BEFORE PUTTING ON MY BRAKES(MY DAD TAUGHT ME WELL TO DO THIS INSTEAD OF BEING A QUICK BRAKER TO MAKE MY BRAKES LAST LONGER). AT ABOUT 25MPH MY CAR BEGAN TO ACCELERATE BACK UP TO 30, THEN 35, THEN 40. I PANICKED. I PRESSED THE BRAKES VERY HARD BUT THE RPM'S WERE STILL RISING AND I COULD HEAR THE ENGINE STILL ACCELERATING. I TRIED PUTTING IT INTO PARK, NO LUCK. I THEN TURNED THE CAR OFF WHILE IN PARK. SCARY!!!! MY KIDS WERE WITH ME. HAD I NOT BEEN ABLE TO STOP WE'D HAVE BEEN KILLED WHILE PLOWING INTO CROSS TRAFFIC TRAVELING AT 55MPH OR MORE! AFTER RESTARTING THE CAR, IT SEEMED BETTER. THEN 5 MILES DOWN THE ROAD IT DID IT AGAIN. I DROVE IT BACK HOME (8MILES) WITH NO INCIDENT. 2 DAYS LATER WHILE DRIVING MY SON HOME FROM SCHOOL, THIS EPISODE REPEATED 4 TIMES. WITH EACH "RESTART" IT BECAME MORE DIFFICULT TO START THE CAR AND I HAD TO WAIT (YES, IN TRAFFIC) 5 MINUTES BEFORE STARTING THE CAR AGAIN. I NEEDED TRANSMISSION WORK, TOOK IT IN, $2000 REBUILD. TOLD THEM ABOUT THE ISSUE AND THEY COULD FIND NOTHING BUT HOT MAYBE AFTER THE TRANSMISSION WORK WAS DONE IT WOULD RESOLVE. NOT A CHANCE. THEY ARE STUMPED AS TO WHAT'S WRONG. THEY'VE CHECKED THE THROTTLE BODY AND PARTS. NO CODES COME UP. THEY'VE UNHOOKED THE CRUISE CONTROL. MY HUSBAND DROVE IT HOME THIS PAST WEEKEND SO A FRIEND COULD LOOK AT IT AND SEE WHAT HE THOUGHT AND MY HUSBAND WAS DRIVING ON A LONG STRETCH OF ROAD WITH NO STOPS AND THE CAR WAS DRIVING AT 50MPH WITH HIM NOT PUSHING THE GAS PEDAL. HELP!!! THIS IS GOING TO HURT OR KILL SOMEBODY. *TR

Dec 17, 2007

THROTTLE STUCK ON VEHICLE IN A FAST IDLE POSITION. CONTROL OF VEHICLE WAS MAINTAINED BY USE OF FOOT BRAKE. VEHICLE HAD 23020 MILES AND IS A GLS WITH ALL WHEEL DRIVE, DATE OF MANUFACTURE WAS 13 JAN 01. NO INJURIES, NO PROPERTY DAMAGE. DEALER REPLACED CRUISE CONTROL CABLE AND STATED THAT THE CAUSE WAS THAT THE CABLE WAS MISROUTED. ACCORDING TO DEALER THE CABLE SHOULD NOT HAVE BEEN ROUTED THROUGH A METAL CLIP AT RIGHT REAR OF SURGE TANK/INTAKE MANIFOLD. THIS CLIP IS ADJACENT TO THE CLIP USED TO SECURE THE GAS PEDAL CABLE. THE REPLACEMENT CABLE APPEARS TO BE SHORTER THAN THE ORIGINAL CABLE AS IT IS NOT LONG ENOUGH TO BE PLACED IN THE METAL CLIP. THE REPLACEMENT CABLE USED WAS PART #96430-26110 AND HAS A YELLOW LABEL WITH "TO2" ON IT.

Apr 03, 2003

+ 1 more complaint for this component

SUSPENSION,STRUCTURE

5 complaints

I HAD BEEN DRIVING THE VEHICLE HOME AND NOTICED THE CAR WAS RUBBING AGAINST THE CAR. THE SUBFRAME HAS RUSTED SO MUCH THAT I CAN'T DRIVE IT. HAD TAKEN THE VEHICLE TO FIRESTONE. THEY SAID NOT TO DRIVE IT AND YOU SHOULD HAVE IT TOWED TO OUR HOUSE. THEY SAID THE TIRE WOULD FALL OFF OR WORSE. THEY WOULDN'T TOUCH IT. SO I HAD IT TOWED TO THE HYUNDAI DEALERSHIP. THEY TOLD ME THAT TO REPLACE THE SUB FRAME IN THE FRONT ON THE DRIVER'S SIDE, IT WOULD COST $2000. WHEN I TOWED THE VEHICLE TO HYUNDAI, THEY SAID IT COULD COST UP TO $5000. I COULDN'T AFFORD TO FIX IT. I THEN TOWED IT HOME AND IT IS SITTING IN MY GARAGE. I WISH I WOULD HAVE KNOW ABOUT THIS PROBLEM BEFORE I BOUGHT.

Dec 10, 2017

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SUSPENSION AND SUBFRAME THAT THE SUSPENSION WAS MOUNTED TO WAS SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE SUBFRAME AND SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 184,215.

Mar 11, 2016

BECAME 2ND OWNER IN JUNE 2005. IN MARCH 2010, HYUNDAI RECALLED VEHICLE FOR SUSPENSION COMPONENT RUSTING/CORROSION, SPECIFICALLY REAR TRAILING ARMS & FRONT SUB-FRAME. [ HYUNDAI HAS HAD NUMEROUS (8-9 ??) SIMILAR SUSPENSION RECALLS OVER THE PAST 5 YEARS FOR ELANTRA, SONATA, TIBURON, AZERA AND OTHER MODELS.] IN MARCH 2010, RESPONDING TO RECALL, VEHICLE TAKEN TO AUTHORIZED HYUNDAI DEALER, WHERE DEALER ELECTED TO REPAIR, RATHER THAN REPLACE AFFECTED FRONT AND REAR SUSPENSION COMPONENTS. THE PRESCRIBED RECALL REPAIR CONSISTED OF DRILLING (DRAIN) HOLES IN ALL FRONT & REAR SUSPENSION COMPONENTS, REMOVING EXCESS RUST FROM INSIDE COMPONENTS, THEN SPRAYING WITH ANTI-CORROSIVE WAX. AUGUST 7, 2013, RIGHT REAR TRAILING ARM FAILED DUE TO CONTINUED EXCESSIVE CORROSION, CAUSING STEERING LOSS AND NEAR WHEEL COLLAPSE. HYUNDAI DEALER REVEALED CAUSE OF SUSPENSION FAILURE. HYUNDAI CORROSION SPECIALIST CONCLUDED THAT HYUNDAI WOULD REPLACE BOTH REAR TRAILING ARMS ONLY (NOT FRONT SUB-FRAME COMPONENTS, WHICH ARE ALSO EXCESSIVELY RUSTED/CORRODED), BUT THAT BECAUSE OF VEHICLE'S 10+ YEAR AGE, OWNER WOULD BE RESPONSIBLE FOR ALL "INCIDENTAL AND RELATED SUSPENSION PARTS AND LABOR" EXPENSES INCURRED WHILE THE REAR TRAILING ARM REPLACEMENTS WERE BEING MADE. I AM APPEALING THIS HYUNDAI DECISION TO NHTSA BECAUSE THE REPAIR THAT HYUNDAI ELECTED TO PERFORM (VS A FULL COMPONENTS REPLACEMENT) IN MARCH 2010, WHEN VEHICLE WAS ONLY 9 YEARS OLD, HAS PROVEN TO BE TOTALLY INEFFECTIVE, AND THAT OWNER HAS NOT CONTRIBUTED, IN ANY WAY, TO THIS SUSPENSION DEFECT. GIVEN HYUNDAI'S CORROSION VULNERABILITIES, THEIR INABILITY TO EFFECT A REPAIR IN 2010, AND THE OWNER'S NON-CONTRIBUTORY ROLE HERE, HYUNDAI SHOULD NOW REPLACE ALL FRONT & REAR SUSPENSION COMPONENTS, AS THEY SHOULD HAVE IN 2010, AT NO COST TO THE OWNER. *TR

Sep 12, 2013

MY 2001 SANTE FE WAS MAKING " CREAKING" NOISE BY THE PASSENGER SIDE REAR TIRE. I MADE AN APPOINTMENT FOR IT, BUT BEFORE THE APPOINTMENT I HEARD A LOUD THUD AND LOST CONTROL OF THE VEHICLE. FORTUNATELY I WAS ONLY GOING 35 MPH AND WAS ABLE TO SKID INTO A DRIVEWAY. THE REAR CONTROL ARM SNAPPED OFF DUE TO AN EXCESSIVE AMOUNT OF RUST. THE OTHER SIDE IS ALMOST RUSTED THROUGH. THE REPAIR SHOP HAD NEVER SEEN ANYTHING LIKE IT BEFORE. *TR

Aug 05, 2008

FOR A FEW DAYS PRIOR TO THE INCIDENT, I THOUGHT I NEEDED TO HAVE THE BRAKES REPLACED ON THIS VEHICLE. EVERYTIME I APPLIED THE BRAKES, THE CAR WOULD SWERVE A LITTLE; THEN THERE WOULD BE A "THUMP" AT THE REAR OF THE CAR. ON THE DAY OF THE INCIDENT, THERE WAS A SIGNIFICANT NOISE AT THE REAR OF THE CAR, SO I LOOKED IN THE BACK STORAGE AREA THINKING SOMETHING WAS ROLLING AROUND-FOUND NOTHING. I CONTINUED DRIVING A FEW MILES, HEARING THE THUMPING NOISE AGAIN, I STOPPED AND LOOKED UNDERNEATH THE THE REAR OF THE VEHICLE THINKING THE SPARE TIRE BRACKET WAS BROKEN--SAW NOTHING. LATER IN THE DAY, AS I TURNED RIGHT THERE WAS A LOUD NOISE AT THE REAR. I TOLD MYSELF TO DRIVE SLOWLY--AND THEN THE RIGHT REAR TIRE BROKE CAUSING ME TO LOSE CONTROL OF THE CAR. FORTUNATELY FOR MYSELF, OTHER DRIVERS AND HYUNDAI I WAS DRIVING SLOW. THE CAR WAS FLATBEDDED TO THE HYUNDAI DEALER, WHO TOLD ME THAT THE REAR TRAILERING ARM "SNAPPED" OFF DUE TO AN IMPACT. THE SERVICE MANAGER STATED THAT HE HAD NEVER SEEN ANYTHING LIKE THAT AND WANTED TO WAIT FOR THE COMPANY REP BEFORE DECIDING WHAT TO DO. THE REP INSISTED THAT RUST HAD NOTHING TO DO WITH THE PART BREAKING AND THAT I NEEDED TO PAY 1100.00 FOR THE REPAIR (WHICH INCLUDED A NEW BRAKE LINE AND SHOCK DUE TO THE FAULTY PART) THE DEALERSHIP THEN DID NOT WANT TO GIVE ME THE PART BECAUSE IT WAS "TOO RUSTY" TO PUT IN THE CAR. THIS SEEMS TO BE THE 4TH VEHICLE REPORTING THE SAME PROBLEM. I DO HAVE THE PART AND WILL BE GOING TO THE LOCAL NEWS MEDIA TO COMPLAIN ABOUT THE SAFETY ISSUE NOT BEING ADDRESSED BY THE COMPANY. *TR

Jan 25, 2008

SERVICE BRAKES, HYDRAULIC

5 complaints

AS I BACKED OUT OF THE DRIVEWAY MY FRONT BRAKES FAILED. THE FRONT DRIVER BRAKE PAD HAD SEPARATED FROM THE BRAKE ASSEMBLY . THE PAD WAS ON THE DRIVEWAY. INSPECTION REVEALED THAT THE BONDING AGENT HAD FAILED. THE JENKINS HYUNDAI OF BRADENTON CONFIRMED THE DEFECT IN THE BONDING AGENT-BUT STATED THAT THE BRAKING SYSTEM IS NOT COVERED BY HYUNDAI WARRANTY. ALL BRAKE PADS WERE REPLACED. I RETAINED THE DEFECTIVE BRAKE PAD. *TR UPDATED 02/01/10.*JB UPDATED 03/08/10 *BF UPDATED 04/29/10.*JB

Oct 29, 2008

DT*:THE CONTACT STATED WHILE DEPRESSING THE BRAKE PEDAL AT HIGHWAY SPEEDS THE VEHICLE VIBRATES DUE TO THE ROTORS BEING WARPED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE FRONT BRAKES WERE REPLACED. SINCE THE REPLACEMENT THE CONTACT BEGAN TO HAVE THE PROBLEM WITH THE VEHICLE VIBRATING. IT HAS BEEN TAKEN TO THE DEALERSHIP A TOTAL OF THREE TIMES. THE FIRST TIME BOTH FRONT ROTORS WERE TURNED. THE SECOND TIME THE FRONT PASSENGER ROTORS WERE RESURFACED. THE LAST TIME THE FRONT PASSENGER ROTOR WAS WARPED HOWEVER THE DEALERSHIP RESURFACED THE FRONT DRIVER AND PASSENGER SIDE ROTORS. THE ROTORS HAVE BEEN RESURFACED THREE TIMES IN THE LAST THIRTEEN MONTHS. THE DEALERSHIP DETERMINED THIS IS DUE TO THE WAY THE CONTACT DRIVES THE VEHICLE. THE CONTACT CLAIMED DEALER REPLACED ROTORS ON 04/18/2006, AND TURNED THEM 3 TIMES IN 13 MONTHS.

Apr 10, 2006

WHILE DRIVING AND UNDER ANY BRAKING CONDITIONS WHEN DEPRESSING THE BRAKES BRAKE PEDAL IS DELAYED, RESULTING IN EXTENED STOPPING DISTANCE.*AK

Jan 14, 2004

WHILE PULLING OUTSIDE OF DRIVEWAY. WITHOUT PRIOR WARNING, BRAKE PEDAL WAS STUCK TO THE FLOOR. CONSUMER WILL FILL IN ADDITIONAL INFORMATION. *AK

May 20, 2002

WHEN APPLYING BRAKES BRAKING DISTANCE IS NOT WHAT IT SHOULD BE. CONSUMER REARENDED A VEHICLE WHILE GOING ABOUT 10 MPH, HAD APPLIED BRAKES, ABS MADE NOISE, AND VEHICLE CONTINUED TO SLIDE FORWARD. DEALER TOLD CONSUMER SHE JUST NEEDED TO GET USED TO ABS BRAKES. PLEASE ADD ADDITIONAL INFORMATION. *AK

Mar 13, 2001

Crash: 1

FUEL/PROPULSION SYSTEM

4 complaints

WHEN GETTING GAS, THE PUMP ALWAYS 'CLICKS OFF' WHEN IM PUMPING GAS. DOES NOT MATTER HOW FULL. THE ONLY WAY TO ENSURE A FULL TANK IS TO CONTINUE PUMPING UNTIL GAS COMES OUT THE TOP OF THE FILLER NECK. THIS USUALLY MEANS OVERRIDING AS MANY AS 50 PUMP 'CLICK OFFS'. I HAVE SEEN OTHER SANTA FE OWNERS COMPLAINING ABOUT THE SAME PROBLEM OBVIOUSLY THIS IS A MANUFACTURING FLAW & NEEDS TO BE FIXED. THIS METHOD OF GETTING A FULL TANK IS NOT DESIRABLE AND WHAT'S THE POINT OF HAVING A 17 GALLON GAS TANK IF IT TAKES 45MINUTES TO FILL UP. THANK YOU.

Oct 21, 2019

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT NOTICED A FUEL ODOR INSIDE AND OUTSIDE THE VEHICLE. WHEN RE-FUELING, THE FUEL LEAKED OUT OF THE FUEL TANK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Feb 07, 2017

V EHICLE CAUGH T ON FIRE IN MOTION CLAIM NUMBER 870190.

Mar 14, 2016

Fire: 1

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE REFUELING, FUEL LEAKED FROM THE FUEL TANK. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE MECHANIC CONFIRMED THAT THE FUEL TANK TUBE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.

May 30, 2012

FUEL SYSTEM, GASOLINE

3 complaints

TL*THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PARKED, HE NOTICED A FUEL ODOR. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE FUEL TANK AND STRAPS WERE CORRODED. THE CONTACT CALLED THE MANUFACTURER WHO TOOK A COMPLAINT BUT OFFERED NO FURTHER ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 92,000.

Nov 29, 2010

WHEN GETTING GAS, THE PUMP ALWAYS 'CLICKS OFF' WHEN TANK IS 1.5-2 GALLONS FROM BEING FULL. THE ONLY WAY TO ENSURE A FULL TANK IS TO CONTINUE PUMPING UNTIL GAS COMES OUT THE TOP OF THE FILLER NECK. THIS USUALLY MEANS OVERRIDING AS MANY AS 50 PUMP 'CLICK OFFS'. ON THE EDMUNDS CHAT ROOM I HAVE SEEN OTHER SANTA FE OWNERS COMPLAINING ABOUT THE SAME PROBLEM SO I BELIEVE THIS IS A DESIGN FLAW WITH THE VEHICLE. BY THE WAY, I HAVE YET TO FIND ANY GAS STATION WHERE THIS DOES NOT OCCUR. OBVIOUSLY, THIS METHOD OF GETTING A FULL TANK IS NOT DESIRABLE BUT WHAT'S THE POINT OF HAVING A 17 GALLON GAS TANK IF IT WILL ONLY TAKE 15 GALLONS OF GAS? THANK YOU.*AK

Aug 13, 2001

AIR INTAKE IS LOCATED LOW IN ENGINE COMPARTMENT. IN RAINY WEATHER WATER GETS INTO INTAKE AND SHORTS THE MASS AIR SENSOR.*AK

Mar 07, 2001

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

3 complaints

WHILE BEING IN PARK - ENGINE WILL SURGE - RPMS JUMP TO ABOUT 6,000 AND ACCELERATES LIKE IT WANTS TO GO. I WILL PUT CAR IN DRIVE AND RPMS COME DOWN BUT STILL WANTS TO ACCELERATE. THIS SAME THING HAPPENS EVEN AT STOP SIGN - WITH FOOT ON BRAKE. CAR UNINTENTIONALLY ACCELERATES ON ITS ON ONCE FOOT COMES OFF BRAKE. CHECK ENGINE LIGHT MAY OR MAY NOT BE ON. VERY SCARY SITUATION AND ALMOST SCARED TO DRIVE IT. THIS HAPPENS EVERY NOW AND THEN BUT LATELY IT HAS BEEN GOING ON FOR SEVERAL DAYS. NOTICED THE PROBLEM ABOUT 3 MONTHS AGO. *TR

Feb 24, 2010

AT APPROXIMATLELY 50-60 MPH THE CAR HAS A ENGINE MISS. CAR LOSES POWER THAT CAN LAST FOR A SECOND OR MORE. PROBLEM IS A INTERMITTENT ONE. I HAVE HAD IT TO THE DEALER AT LEAST 5 TIMES. THEY HAVE REPLACED THE COMPUTER AND THE MASS AIR SENSOR BUT THE PROBLEM STILL HAPPENS. IT SEEMS TO HAPPEN MORE WHEN THE TRUCK IS UNDER LOAD IE: GOING UP A HILL, PASSING. *AK

Dec 05, 2001

WHILE DRIVING WOULD NOTICE FUMES ENTERING VEHICLE. TOOK VEHICLE TO DEALERSHIP, MECHANIC INDICATED THAT A SHORT IN IGNITION SYSTEM WAS CAUSING PROBLEM. ALSO, HAD ENTIRE CATALYTIC CONVERTER SYSTEM REPLACED.*AK

May 11, 2001

Fire: 1

POWER TRAIN,VEHICLE SPEED CONTROL

3 complaints

MY CAR LURCHED (DUE TO TRANSMISSION) OUT INTO THE MIDDLE OF A MAIN ROAD AND LURCHED ALMOST INTO ANOTHER CAR AT A SEPARATE TIME, AND NOW THE SPEEDOMETER DOESN'T WORK. *AK

Feb 12, 2002

WHEN THE VEHICLE REACHS APPROXIMATELY 40 MPH, THE VEHICLE BUCKS, STUTTERS, HESITATES, DOWNSHIFTS FOR A FEW SECONDS. WHEN THE PROBLEM OCCURS IT IS LIKE YOU ARE TAKING YOUR FOOT OFF THE ACCELERATOR AND THEN PUTTING YOUR FOOT BACK ON. WE NO LONGER FEEL SAFE IN THE VEHICLE AND ITS ONLY A MATTER OF TIME BEFORE THE TRANSMISSION BREAKS LEAVING US STRANDED OR EVEN WORSE CAUSING A FATAL ACCIDENT. AMERICAS BEST WARRANTY IS A MEANINGLESS SLOGAN WHEN A COMPANY CHOOSES TO DENY THAT THERE IS A SERIOUS AND DANGEROUS DEFECT IN A VEHICLE.*AK

Jul 09, 2001

WHILE DRIVING VEHICLE WILL JERK FORWARD , ACCELERATOR PEDAL WHEN DEPRESSED WILL SLOW DOWN. AFTER A FEW MINUTES, ACCELERATOR WILL RESPOND AGAIN. DEALER REPLACED TRANSMISSION, DID NOT REMEDY. CURRENTLY, DEALER INSISTED IT WAS A SOFTWARE PROBLEM. *AK

Mar 30, 2001

STEERING,SUSPENSION,WHEELS

2 complaints

I live in Roy city utah and i drive a santa fe 2001 and my trailing arm in the rear driver side snaped while i was going 45 mph. when i took it in to a shop to have it looked at they said that my trailing arm had snaped do to the rust corrision under the car. I know that there are recalls on the santa fe for the rear suspention trailing arms but only if you live in a salt belt state and utah is not one of those states and i think it should be because of the salt we use on our roads as well as i live 20 mins from the great salt lake . i have bearly had my car 5 months befor it broke i paid 2000.00$ for it. i guess i didnt fully understand the saltbelt state thing and i called young hayndai in ogden utah and they called a tow truck and had my car towed to the dealer ship they had it like 12 days or something befor they diganosed it. when they said that its not on recal because of the salt belt state thing they are trying to charg me 274.00$ just for them to tell me what i already knew was wrong with it and for the towtruck. because of my broken car i just had lost 2 highpaying jobs and i have no money to pay the dealership so they said that i cant have my car till i pay them then they said that they can only hold my car for 10 days . idont know what to do cause my santa fe was not only my only ride but its where i lived. so now im back to sleeping in the street and i dont know where or what the dealership has done with my car. please help me and order a recall on my santa fe because of the rust from living utah and all the salt here. Thanks for your time.

Mar 26, 2023

WHILE DRIVING HOME WITH FAMILY IN VEHICLE THE CONTROL ARMS BROKE, BALL JOINTS BROKE AND THE SWAY BAR BROKE.

May 19, 2015

STEERING,SUSPENSION,STRUCTURE

2 complaints

The contact owns a 2001 Hyundai Santa Fe. The contact stated that on separate occasions while driving at undisclosed speeds, the steering wheel became difficult to maneuver. The vehicle was towed to Marco’s body shop where it was diagnosed that both struts, new tires, front passenger side wheel cylinder, wheel mount, tie rod, and wheel bearings needed to be replaced. The contact stated that the mechanic noticed that the driver’s side cross member had fractured and needed to be replaced. Additionally, the contact stated that the subframe was corroded. The vehicle was not repaired. The dealer was notified of the failure and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and the contact was provided a case number and advised to take the vehicle to the dealer at a different location. The failure mileage was 140,000.

Jan 10, 2023

SUBFRAME/ENGINE CRADLE ROT TO POINT OF SEPARATION, LOSS OF STEERING AND VEHICLE CONTROL. MY NEWLY LICENSED GRAND-DAUGHTER TOOK IT FOR A SHORT ABOUT TOWN DRIVE, NOT GETTING MORE THAN A QUARTER MILE BEFORE THE WHEEL SNAPPED OUT OF HER HANDS AND THE VEHICLE HEADED FOR THE CENTER LINE. SHE MANAGED TO GET IT TO THE SIDE OF THE ROAD. BOTH FRONT WHEELS WERE IN DIFFERENT DIRECTIONS, MOVEMENT FORWARD WAS SLOPPY. AWEFUL NOISES COMING FROM BELOW. FLUIDS LEAKING. I KNEW THERE WAS RUST UNDERNEATH BUT NOT SUCH GREATLY WEAKENED PARTS. IMG_6087.JPG

Jan 01, 2017

VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

GAS PUMP PROBLEM KEEPS CLICKING AND I'VE REPLACE MANY PARTY BUT STILL LIKE ITS FULL OF GAS BUT I BE ON EMPTY.CAR ALSO JERKS LIKE I'VE BEEN REAR ENDED WHILE DRIVING LIKE IT HAS TRANSMISSION PROBLEMS AND I'VE REPLACE TRANSMISSION 2 TIMES. GEARS ONLY WORK MANUAL IT'S LIKE THE CAR HAS A MIND OF ITS OWN .ALSO MY TIRE FLEW OFF MY CAR ON THE BACK AND HAD TO TAKE TO DEALER SHIP AND THEY WAS SAYING IT'S SOME PROBLEM THEY CAN'T HELP .

May 25, 2020

WHEN APPROACHING A STOP (<5MPH) AND BRAKING, THE CAR ENGAGES IN UNINTENDED ACCELERATION. THE ENGINE WILL TACH TO OVER 3000 RPM AND IF YOU ARE NOT HARD ON THE BRAKES, THE CAR WILL ACCELERATE. AT LEAST ONE TIME THE CAR HAD TO BE PUT INTO NEUTRAL AND THE IGNITION TURNED OFF TO KEEP THE CAR UNDER CONTROL. *TR

Jun 24, 2012

POWER TRAIN,UNKNOWN OR OTHER

2 complaints

THERE'S A REALL ON THIS VEHICLE THAT I JUST PURCHASED THE DESCRIPTION SAYS: FRONT COIL SPRING PROTECTOR INSTALLATION HOW CAN THIS ISSUE BE RESOLVED? THIS ISSUE SHOULD BEEN TAKING CARE OF AND REPORTED TO YOU GUYS BUT OBVIOUSLY IT HASN'T. SO I NEED TO KNOW IS IT STILL AVAILABLE TO BE FREE OF CHARGE OR DO I HAVE TO COME OUT OF POCKET TO GET THIS REPAIRED? OR CAN I STILL GO TO A HYANDAI DEALER FOR FREE REPAIRS? I'M NOT SURE OF THE NOTIFICATION DATE. SO IN THE BOX BELOW I'LL PUT THIS YEAR AND DATE

Mar 10, 2020

SPPEDOMETER OUT BY 7.75% , O2 WAS A RECALL NEVER CONTACTED BY MFG HYUNDAI REPLACING WHEN OWNERS STOP IN FOR SERVICE, ALSO OWNERS ON SANTA FE FORUM HAVING ALTERNATOR PROBLEMS NUMEROUS ALTERNATORS BEING REPLACED (ECU REPROGRAMMING)ON CASE BY CASE BASIS?

Aug 26, 2002

SUSPENSION,WHEELS

2 complaints

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 2 MPH, THE REAR DRIVER SIDE WHEEL LEANED INWARD INTO THE VEHICLE. IN ADDITION, THE CONTACT NOTICED THAT THE REAR COIL SPRING OF THE SUSPENSION WAS RUSTED AND CORRODED. FRIENDSHIP HONDA IN JOHNSON CITY, TENESSEE WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 108,000. *TT JOHNSON CITY HYUNDAI REPAIRED FOR FREE. TRADED IT IN 12/29/17. UPDATED 8/14/18*JB

Nov 24, 2017

TL*THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 25-30 MPH ON A GRAVEL ROAD DURING RAINY WEATHER CONDITIONS THE REAR PASSENGER SIDE TIRE CAME OFF. THE CONTACT DROVE ONTO THE EMERGENCY LANE. HE CALLED THE DEALER WHERE HE PURCHASED THE VEHICLE AND IT WAS TOWED TO THE DEALER. THE VEHICLE WAS PRE-OWNED AND PURCHASED IN APRIL 2010. THE CONTACT STATED THAT THE DEALER PUT THE WRONG LUG NUTS ON THE TIRE. AFTER THE LUG NUTS WERE REPLACED A WEEK LATER THE BALL JOINTS ON THE PASSENGER AND DRIVER SIDE FAILED. HE ALSO STATED THAT THE TRAILING ARMS ON THE REAR DRIVER'S SIDE WERE COVERED WITH RUST AND BROKE IN HALF. MOST OF THE REPAIRS WERE MADE TO THE VEHICLE. THE BODY SHOP IS REPAIRING TIRE FAILURE AND THE REAR FENDER. THE FAILURE MILEAGE WAS 121,000 THE CURRENT MILEAGE WAS UNKNOWN. UPDATED 01/06/11. *LJ UPDATED 02/28/11

Sep 21, 2010

UNKNOWN OR OTHER

2 complaints

THE EXTERIOR PAINTING ON MY VEHICLE IS OF POOR QUALITY. ABOUT 4 YEARS AGO, THE PAINT STARTED OXIDIZING IN MULTIPLE AREAS SUCH AS THE HOOD & ROOF- INITIALLY IN SMALL AREAS, BUT HAS NOW SPREAD TO COVER MOST OF THESE AREAS. I WAXED THE CAR AT LEAST 2X PER YEAR. THE PAINT JUST DOES NOT APPEAR TO HAVE BEEN OF A HIGH QUALITY. *TR

Apr 08, 2015

ON GOING PROBLEMS WITH MY HYUNDAI SANTA FE. I HAVE HAD TO TAKE MY CAR BACK 16 DIFFERENT TIMES, 7 TIMES SINCE THE FLORIDA LEMON LAW EXPIRED. EACH PROBLEM HAS BEEN REPAIRED UNDER WARRANTY, BUT WITH THE ONGOING PROBLEMS I ASKED HYUNDAI TO COMPENSATE ME. I WAS TOLD THE LEMON LAW HAS EXPIRED AND THEY WILL DO NOTHING TO HELP. *LA

Oct 23, 2003

ELECTRICAL SYSTEM,ENGINE

2 complaints

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. ON A SECOND OCCASION, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 163,000. UPDATED 03/24/15*LJ

Dec 31, 2014

TL*THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE ENGINE STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000. DJR

Sep 19, 2014

FUEL SYSTEM, OTHER

2 complaints

2001 HYUNDAI SANTE FE. WHEN FILLING THE GAS TANK, THERE SEEMS TO BE SOME SORT OF VENTING PROBLEM THAT CAUSES OVERFLOW OF GASOLINE DOWN THE SIDE OF THE VEHICLE. THIS OCCURS EVERY TIME I FILL UP AT ANY GAS STATION UNLESS I AM VERY CAREFUL AND FILL THE TANK VERY VERY SLOWLY. EVEN THEN IT SOMETIMES OVERFLOWS. BASICALLY, IT SEEMS AS THOUGH A PRESSURE IS BUILT UP WITHIN THE TANK AND WHEN THE GAS PUMP CUTS OFF, IT IS TOO LATE. THE CAR SEEMS TO SORT OF "VOMIT" ABOUT A CUP OR SO OF GAS OUT OF THE FILLER HOLE AND DOWN THE SIDE OF THE VEHICLE AND ONTO THE GROUND. IT SEEMS VERY DANGEROUS TO ME AND SCARES ME. AS A RESULT, I ALWAYS HAVE TO FILL UP VERY CAREFULLY AND FILL THE TANK AS SLOWLY AS POSSIBLE ONCE IT IS OVER ABOUT HALF FULL. I'M AFRAID THIS COULD RESULT IN A FIRE AT THE GAS STATION. *JB

Mar 25, 2006

TAKE A LOOK AT WHERE THE OIL FILTER IS AT ON THE 2001 HYUNDAI SANTE FE'S. THE OIL FILTERS ARE VERY WEAK AND CAN BUST EASILY. ALL IT TAKES IS A BIG ROCK OR ANY FOREIGN OBJECT TO HIT IT ON THE ROAD AND ALL YOUR OIL IS OUT. THE FILTERS ARE RIGHT IN THE FRONT AND ARE OPEN TO ANY OBJECTS.*AK

Sep 08, 2003

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

The suv stalls while driving. This has happened multiple time. While driving, driving slow, taking a u turn. The battery, alternator, starter, power steering pump, water pump, rack and pinion, timing belt, serpentine belt, idler pulley, harmonic balancer, front axles, shocks, struts, some sensors, spark plugs/wires, gaskets, and many other parts are replaced in the last year. Don't know what is wrong but it is scary when it stalls suddenly.

Jul 17, 2022

SUSPENSION,UNKNOWN OR OTHER

1 complaint

I HAVE BEEN HEARING A CLANKING SOUND SINCE I HAVE BOUGHT THE VEHICLE USED MID NOVEMBER 2019 . THE SOUND SEEMS TO BE COMING FROM THE BACK PASSANGER SIDE WHEEL AREA IT APPEARS TO BE GETTING WORSE AND FEELS LIKE THE BACK PASSANGER SIDE WHEEL IS ABOUT TO FALL OFF ANYTIME THE VEHICLE IS IN MOTION .AND LOOKS VERY RUSTED OUT

Dec 07, 2019

SUSPENSION,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT BOTH FRONT COIL SPRINGS FRACTURED WITHOUT WARNING AND HAD BEEN REPLACED BY THE DEALER (HYUNDAI EAST, 11200 E CENTRAL AVE, WICHITA, KS 67206, (316) 977-7800). IN ADDITION, WHILE DRIVING AT A LOW RATE OF SPEED, THE REAR LOWER CONTROL ARM FRACTURED ON THE DRIVER'S SIDE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT EXPERIENCED A FAILURE WITH THE CRANKSHAFT SENSOR. THE MANUFACTURER INDICATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL CAMPAIGNS. THE VEHICLE CONTINUED TO EXHIBIT THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Apr 11, 2018

SUSPENSION,FUEL/PROPULSION SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 40 MPH, THE REAR OF THE VEHICLE SWAYED. THE CONTACT NOTICED THAT THE REAR END WAS LOWER THAN NORMAL. A CERTIFIED MECHANIC STATED THAT THE REAR-TRAILING ARM AND STRUTS WERE RUSTED. THE VEHICLE WAS TOWED TO THE DEALER AND REPAIRED. THE DETAILS OF THE REPAIR WERE UNKNOWN. THE CONTACT ALSO MENTIONED THAT THE FUEL TANK WAS PREVIOUSLY REPLACED DUE TO RUST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

Oct 08, 2014

ENGINE

1 complaint

TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING UPHILL AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHUTTER AND FAILED TO ACCELERATE. THE CONTACT WAS ALERTED THAT THE SUBFRAME WAS ON FIRE. THE CONTACT IMMEDIATELY SHUT OFF THE ENGINE AND EXITED THE VEHICLE. AN ONLOOKER ASSISTED WITH EXTINGUISHING THE FIRE WITH WATER. THE FIRE WAS EXTINGUISHED BY THE TIME THE FIREFIGHTERS ARRIVED. NEITHER THE FIRE DEPARTMENT INVESTIGATOR NOR THE INSURANCE INVESTIGATOR WERE ABLE TO IDENTIFY THE CAUSE OF THE FAILURE. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

Aug 28, 2014

Fire: 1

AIR BAGS

1 complaint

TL* THE CONTACT OWNS 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE AIR BAG SENSOR WOULD NOT DETECT A PASSENGER IN THE SEAT AND ACTIVATE THE AIR BAG. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT AND WOULD ACTIVATE ONLY WHEN CERTAIN PERSONS WERE SEATED IN THE PASSENGER SEAT. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND ADVISED THAT THERE WERE NO FAILURES WITH THE AIR BAG. THE CONTACT WAS CONCERNED BECAUSE WHEN THEIR SPOUSE OF 100 POUND WAS SEATED IN THE PASSENGER SEAT, THE AIR BAG WOULD NOT ACTIVATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 50,000 AND THE FAILURE MILEAGE WAS 10,000.

Jun 22, 2012

WHEELS

1 complaint

ON THREE SEPARATE OCCASIONS SINCE 2006 THE LUG NUTS HAVE COME LOOSE ON THE DRIVER SIDE FRONT WHEEL. EACH TIME THERE HAD BEEN SOMEONE DIFFERENT ROTATING THE TIRES. OWNER, DEALER, TIRE SHOP. EVERY TIME IT HAS BEEN THE FRONT DRIVER SIDE. NONE OF THE OTHER WHEEL POSITIONS HAVE COME LOOSE. THE LAST INSTANCE WAS 12/7/2011, THE LAST TIME THE TIRES WERE REMOVED OR REPLACES WAS 4/19/2011 AT THE HYUNDAI DEALERSHIP TOPEKA. *TR

Dec 08, 2011

LATCHES/LOCKS/LINKAGES,EQUIPMENT

1 complaint

2001 HYUNDAI SANTA FE. CONSUMER STATES WHILE TRAVELING THE HOOD FLEW UP AND SMASHED THE WINDSHIELD *TGW THE CONSUMER STATED THE SAFETY RELEASE HOOD RUSTED OUT, ALSO THE PIECE THAT HELD THE SPARE TIRE RUSTED OUT. THE SPARE TIRE IS NOW HOUSED IN THE BACK OF THE VEHICLE. *JB

Jan 20, 2011

POWER TRAIN,AIR BAGS,SEAT BELTS

1 complaint

TL*THE CONTACT HAD A 2001 HYUNDAI SANTE. THE CONTACT WAS DRIVING 35 MPH DOWN A 60 DEGREE INCLINE WHEN THE 4 WHEEL DRIVE SHIFTED OUT OF GEAR ON ITS OWN. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A GUARD RAIL AND LIGHT POLE. THE SEATBELT DID NOT LOCK AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISK SINCE THE SEAT BELTS AND AIR BAGS MALFUNCTIONED WHEN THE CRASH OCCURRED. THE FAILURE MILEAGE WAS 154,000.

Feb 17, 2010

Crash: 1

Injuries: 1

STEERING,SUSPENSION,CHILD SEAT,EQUIPMENT ADAPTIVE/MOBILITY

1 complaint

I BOUGHT THIS CAR USED FROM CAR MART LESS THAN A YEAR AGO.FIRST MY STEERING WAS VERY SHAKY. IT GOT RAPIDLY WORSE. I WENT THROUGH 3 SETS OF NEW TIRES IN ONE YEAR PLUS 2 ALIGNMENTS. I RECENTLY HAD TROUBLE AGAIN AND MY CAR IS IN THE HYUNDAI DEALERSHIP IN FAYETTEVILLE. FIRST THE BEARINGS WERE RUSTED IN. BOTH BALL JOINTS WERE NEARLY OUT. THE CONTROL ARM IS GOING OUT. THE STEERING LINKAGE AND THE CRADLE ABOVE THE DRIVELINE IS RUSTED AND FALLING APART LITERALLY. THE EXHAUST SYSTEM THE CADILLAC CONVERTER IS RUSTED APART FOR THE THIRD TIME. THE SPARE TIRE HOLDER WAS RUSTED CLOSED AND HAD TO BE BROKE OFF TO GET MY SPARE OUT. ALSO THE REAR SEAT BELT JUST STOPPED WORKING . TALK ABOUT A BAD DAY. *TR

Oct 07, 2009

SEATS

1 complaint

VEHICLE SEAT BACK DOES NOT STAY LOCKED, 2ND ROW. CHILD SEAT MUST BE INSTALLED IN THIS SEATING POSITION. VEHICLE SEAT BACK DOES NOT STAY ENGAGED IN ANY UPRIGHT POSITION. *TR

Aug 28, 2009

EXTERIOR LIGHTING

1 complaint

THE HEADLIGHT ASSEMBLIES ON MY 2001 HYUNDAI SANTA FE HAVE FADED OVER TIME FROM THE SUN. THE SUN HAS FADED THE LIGHT ASSEMBLIES SO MUCH, THE AMOUNT OF LIGHT VISIBLE THROUGH THE ASSEMBLY IS GREATLY REDUCED. I CONSIDER THIS A SAFETY ISSUE, DUE TO THE WAY THE AMOUNT OF LIGHT COMING THROUGH THE ASSEMBLY IS GREATLY REDUCED DUE TO THE FADING OF THE PLASTIC BY THE SUN. *TR

Aug 06, 2009

SERVICE BRAKES, HYDRAULIC,ELECTRONIC STABILITY CONTROL (ESC),TRACTION CONTROL SYSTEM

1 complaint

WHILE BRAKING NORMAL TO LIGHT PRESSURE FROM 25-5MPH ON DRY PAVED ROAD, ABS SYSTEM WILL TURN ON AND GREATLY INCREASE STOPPING DISTANCE. THERE HAS BEEN MORE THAN ONE INSTANCE THAT I HAVE NOT BEEN ABLE TO STOP BEFORE A STOP LIGHT OR STOPPED TRAFFIC. THERE ARE NO ABS CODES OR ABS IDIOT LIGHTS ON IN THE DASH WHICH INDICATE THAT ANYTHING IS WRONG. SAFETY IS A LARGE CONCERN. BROUGHT VEHICLE TO DEALER AND NO ISSUE WAS FOUND, WITHOUT BEING REQUESTED TO PAY $1500+ FOR AN ENTIRE NEW ABS. THIS WAS AFTER THEY TOLD ME THEY COULDN'T FIND SOURCE TO THE PROBLEM. I SEE THIS A COMMON PROBLEM ON MANY FORUMS AND THERE IS A RECALL ON 2003-2005 SANTA FE'S FOR A SAME/SIMILAR ISSUE. *TR

Jun 21, 2009

STRUCTURE,WHEELS

1 complaint

WHILE DRIVING MY 2001 HYUNDAI SANTA FE IN THE EVENING ON THE SOUTHERN STATE PARKWAY (55 MPH, LEFT LANE, PKWY TRAFFIC HEAVY BUT MOVING WELL), STEERING SUDDENLY BEGAN TO SHIMMY, FOLLOWED BY GRINDING NOISE EMANATING FROM RIGHT FRONT WHEEL. ASSUMED A FLAT, PULLED FOOT OFF GAS PEDAL, PUT HAZARD LIGHTS ON AND BEGAN TO PULL OVER TO RIGHT LANE. STEERING ALMOST IMPOSSIBLE TO CONTROL AS STEERING WHEEL WAS WHIPPING FROM RIGHT TO LEFT, GRINDING NOISE INCREASED - AS I SLOWED ENOUGH TO PULL ONTO DIRT SHOULDER, RIGHT FRONT OF CAR COLLAPSED, RIGHT FRONT WHEEL BROKE OFF AND BOUNCED ACROSS 3 LANES OF TRAFFIC BEFORE LANDING ON OPPOSITE SHOULDER OF PARKWAY. THAT THE WHEEL DIDN'T FLY OFF WHILE DRIVING AT FULL 55 MPH AND WHEN IT DID FAIL, THAT IT BOUNCED BETWEEN ONCOMING CARS, AND DID NOT HIT ONE OF THEM AND CAUSE AN ACCIDENT, WAS ASTOUNDING. THIS OCCURRED WITHOUT ANY PRIOR HINT OF A PROBLEM, MY CAR IS WELL MAINTAINED AND SERVICED ON A REGULAR BASIS. ACCORDING TO MY MECHANIC, THE WHEEL LITERALLY RUSTED OFF - HE HAS NEVER SEEN ANYTHING LIKE THIS. MECHANIC STATES 3 OTHER WHEELS HAVE MORE RUST THAN HE HAS EVER SEEN ON A VEHICLE, HOWEVER, HE DIDN'T FEEL THERE WAS DANGER OF AN IMMEDIATE FAILURE. *TR

Feb 03, 2009

VISIBILITY

1 complaint

THE BACK WINDOW OF MY 2001 HYUNDAI SANTA FE JUST BLEW OUT LAST NIGHT, NO ACCIDENT. *TR

Jan 21, 2009

SUSPENSION,ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,EQUIPMENT

1 complaint

SUSPENSION /CHECK ENGINE LIGHT /LOWER BALL JOINT: DEALER REPLACE @54,353 MILES, LOWER ARM IN 2004 AND 8/2006 REPLACEMENT IS NEEDED I HAVE TAKEN MY 2001 SANTA FE TO DEALER 8 PLUS TIMES FOR CHECK ENGINE LIGHT AND WAS TOLD FOUND TETHER ON GAS CAP NOT LETTING CAP CLOSE TIGHT ENOUGH /MOVED TETHER AND RAN EVAP TEST AND CHECK OUT OK . I WAS TOLD CAP LOOSE 8 PLUS TIMES THIS PROBLEM IS ON GOING. RETURN TO DEALER FOR JERK TRANSMISSION ISSUES I HAVE TO PUSH THE ACCELERATOR PEDAL TO THE FLOOR AND IT TAKES OFF SLOW AND ONCE GETS POWER THE CAR JERKS STARTS AS IF THE GEARS OR NOT SWITCHING OVER. DEALER SAID DO THE PRESSURE IN GAS CAP AND GAS CAP NOT CLOSED TIGHT ENOUGH EVAL TEST WAS DONE. BACK AT DEALER AFTER ROAD TRIP MY CAR WAS RUNNING AFTER BEGIN PARKED WITH A/C RUNNING AND I TURN CAR OFF AND CAR WOULD NOT START THOUGHT MAY BATTERY CHECK AND NO WATER WAS IN BATTERY I PUT WATER IN BATTERY AND LET CAR SIT FOR ABOUT HOUR AND CAR RESTARTED BACK AT DEALER EXPLAIN THIS ISSUE MY BATTERY WAS REPLACE I WAS TOLD FACTORY BATTERY WASN'T STRONG ENOUGH WAS FOR SANTA FE THIS IS 3RD BATTERY WITH IN FIVE YEARS. *NM

Aug 19, 2006

ENGINE AND ENGINE COOLING,EQUIPMENT

1 complaint

ON MAY 7TH MY CAR WAS TOWED INTO THE MAXON DEALERSHIP WITH COMPLAINTS OF CLUNKING NOISE UNDER THE HOOD AND LOST OF POWER. THE SERVICE ON MY VEHICLE WAS COMPLETED ON MAY 9TH. I WAS TOLD THAT I NEEDED TO REPLACE MY DRIVER BELTS AND A COMPUTERIZED PROBLEM WAS THE CAUSE OF POWER. ON MAY 28TH (MEMORIAL DAY WEEKEND) WHILE COMING HOME FROM VIRGINIA I SUDDENLY LOST STEERING POWER ON INTERSTATE 95 IN MARYLAND. I HAD MY THREE CHILDREN IN THE CAR ALONG WITH MY COUSIN AND HER DAUGHTER. WE WERE ALL VERY SCARED! MY CAR WAS THEN TOWED TO THE HYUNDAI DEALERSHIP IN LAUREL, MD. I RECEIVED A CALL FROM THE SERVICE ADVISOR WHO ADVISED ME THAT WHEN MY DRIVER BELTS WERE REPLACED THEY WERE TOO TIGHT WHICH IN TURN CRACKED MY PULLEY AND DAMAGE MY POWER STEERING PUMP. HE ADVISED ME THAT THE BOTH WILL HAVE TO BE REPAIRED AND THAT A TENSIONER WILL BE ADDED. I CONTACTED MAXON HYUNDAI, WHO SIMPLY STATED " THE REPAIRS WILL BE DONE UNDER MY WARRANTY" END OF STORY. WE AND MY FAMILY COULD HAVE LOST OUR LIVES IN AN INSTANT BECAUSE OF THE TECHNICIANS ERROR AND FOR MAXON TO NOT RECOGNIZE THAT ERROR IS A MAJOR PROBLEM. I WAS NOT OFFERED TO BE REIMBURSED FOR THE ORIGINAL REPAIRS MADE, NOR DID THEY OFFER TO REIMBURSED FOR THE COST OF THE RENTAL, NOR DID THEY OFFER TO BRING MY CAR FROM MARYLAND TO NEW JERSEY, THEY OFFERED ME NOTHING. MY CAR HAS BEEN TO THEM ON NUMEROUS OCCASIONS AND ALWAYS SEEM TO GO BACK WITHIN TWO MONTHS FOR THE SAME PROBLEM. DO THE OWNERS OF MAXON REALIZE HOW PRECIOUS A LIFE IS? MY LIFE AND THE LIVES OF MY CHILDREN WERE SPARED THIS TIME, BUT WHAT HAPPENS TO THEIR NEXT CUSTOMER WHERE THEY DECIDE TO CUT CORNERS? *NM

May 30, 2006

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

DT: THE CONTACT STATED THAT WHILE PARKING PUT THE VEHICLE IN REVERSE THEN DRIVE AND THE TACHOMETER WENT TO THE RED ZONE. ALTHOUGH THE CONTACT'S FOOT WAS ON THE BRAKE THE VEHICLE MOVED APPROXIMATELY 15 FEET FORWARD IN 30 SECONDS. THEN, HE THEN THE VEHICLE OFF AND BACK ON, AND THE PROBLEM WAS GONE. THIS REPEATED A WEEK LATER. HE HAD THE VEHICLE TOWED TO THE DEALERSHIP, WHO DETERMINED THAT THE BATTERY WAS RUN DOWN AND NEEDED TO BE REPLACED. THE DEALERSHIP WAS UNABLE TO DIAGNOSE THE CAUSE OF THE PROBLEM. THEY RULED OUT A CRUISE CONTROL BECAUSE IT HAS NEVER BEEN USED. *AK UPDATE 1/4/2006 - *NM

Dec 14, 2005

LATCHES/LOCKS/LINKAGES

1 complaint

THE LATCH ON MY LEFT BACK PASSENGER DOOR IS LOOSE. IT LOOKS AS IF THE DOOR IS NOT CLOSED ALL THE WAY. THE SCREWS THAT HOLD THE LATCH IN PLACE INSIDE THE CAR IS LOOSE. I HAVE HAD TO TIGHTEN IT WITH A SCREW DRIVER SEVERAL TIMES. I HAVE CHILDREN RIDING IN THE BACK SEAT OF MY CAR AND IF THAT LATCH EVER CAME TOTALLY OFF IT WOULD BE DISASTROUS. *JB

Dec 17, 2004

SUSPENSION,POWER TRAIN

1 complaint

WHILE DRIVING AT 25 MPH, THE CONSUMER HEARD A SCREECHING SOUND THAT WAS FOLLOWED BY A LOUD BUMPING NOISE. THE VEHICLE SOON STALLED AND WOULD NOT RESTART. THE DEALER EXAMINED THE VEHICLE AND DETERMINED THAT THE FOUR WHEEL DRIVE TRANSFER CASE NEEDED REPLACEMENT. *AK THE BALL JOINT AND THE FRONT WHEEL BEARING WAS REPLACED. *SC *JB

Aug 19, 2004

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

WHILE DRIVING VEHICLE SUDDENLY LOST POWER AND IDLED. DEALERSHIP SERVICED VEHICLE 5 TIMES AND REPLACED IGNITION COIL, MASS AIR FLOW SENSOR, AND 2 OTHER COMPONENTS. BUT THE FAILURE STILL RECURRED. ALSO, VEHICLE WAS SERVICED 3 TIMES FOR BRAKE FAILURE. BRAKE PADS AND ROTORS WERE REPLACED TWICE. BUT GRINDING CONTINUED. *AK

May 24, 2004

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY

1 complaint

ALTERNATOR/BATTERY PROBLEMS: LIGHTS DIM, WINDSHIELD WIPER DELAY CHANGES SPEED, ELECTRIC WINDOWS SLOW AT TIMES.*AK

Nov 08, 2003

STEERING,SUSPENSION,POWER TRAIN,STRUCTURE

1 complaint

VEHICLE RATTLES AND SHAKES WHEN DRIVING IN CITY. NOISE APPEARS TO COME UNDER THE CARRIAGE. TAKEN SEVERAL TIMES TO THE DEALER AND THEY ARE UNABLE TO LOCATE THE SOURCE OF THE PROBLEM. HAVE A WRITTEN COMPLAIN WITH HYUNDAI.*AK

Nov 08, 2003

EQUIPMENT

1 complaint

WE HAVE APPROX. 90,000 MILES ON OUR SANTA FE AND HAVE HAD A/C TROUBLE OFF AND ON THE PAST YEAR. WE HAVE SPENT OVER $2000.00 WHILE THE DEALERSHIP AND A PRIVATELY OWNED A/C SHOP REPLACED VARIOUS PARTS. I AM AWAITING A RESPONSE FROM HYUNDAI AS TO WHAT THEY WILL DO TO RESOLVE THIS SITUATION. WE HAVE ALSO HAD THE STRAP ON THE BACK SEAT BREAK, THE PAINT IS PEALING OFF AT THE BOTTOM OF THE VEHICLE, THE LIGHTS/RADIO/AIR CONDITION ALL DIM WHEN VEHICLE STOPS OR HITS A BUMP IN THE ROAD.*AK

Aug 20, 2003

POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,EQUIPMENT

1 complaint

NAR 05/21/2003 *MR WITH OUT NOTIFICATION THE CONSUMERS PURCHASED THE VEHICLE BRANDED AS A LEMON. PROBLEMS OCCURRED WITH THE TRANSMISSION, AIR CONDITIONER COMPRESSOR, HEADLIGHT DIMMERS, AND ELECTRICAL SYSTEM WAS FAULTY. THEY'RE REQUESTING THE DEALERSHIP TO BUY BACK THE VEHICLE. *CB

May 21, 2003

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

ENGINE CHECK LIGHT STAYS ILLUMINATED ON DASHBOARD.. VEHICLE STALLS OUT EVEN WHEN THE AIR CONDITIONER IS TURNED ON. ALSO, LATELY THE VEHICLE IS USING ALOT OF GAS AND IS PULLING. VEHICLE HAS STARTED TO HESTITATE WHEN ACCELERATING OR BRAKING. DEALER WAS INFORMED. PLEASE PROVIDE MORE INFORMATION.*AK

Jun 28, 2002

ELECTRICAL SYSTEM,EQUIPMENT

1 complaint

WHEN THE PROBLEM HAPPENED THE FIRST TIME, THE RADIO STARTED TURNED OFF BY ITSELF. I WAS IN THE PARKING LOT OF A STORE. I WENT IN AND DID MY SHOPPING AND THEN WENT TO ANOTHER STORE. WHEN I GOT DONE AT THE 2ND STORE, THE CAR WOULDN'T START. I HAD SOMEONE GIVE ME A JUMP START AS THE ROAD SIDE ASSISTANCE WAS GOING TO TAKE 3 HOURS. I DROVE THE CAR TO THE DEALERSHIP AND DROPPED IT OFF. THAT WAS A SATURDAY AND THEY WERE ALREADY CLOSED. BY THE TIME THEY LOOKED AT IT ON MONDAY, THE CAR STARTED. THE 2ND TIME IT HAPPENED, I WAS ON MY LUNCH BREAK. THE RADIO STARTED TO GO OFF BY ITSELF AGAIN AND THE INTERIOR LIGHTS BEGAN TO DIM OUT. I DROVE IT AGAIN TO THE DEALERSHIP SO THEY COULD SEE WHAT IT WAS DOING. THEY SAID IT WAS THE ALTERNATOR. THEY REPLACED THE ALTERNATOR AND 5 DAYS LATER IT BEGAN AGAIN. I WAS STOPPED AT A STOP LIGHT WHEN MY RADIO TURNED OFF AND THE LIGHTS DIMMED OUT AGAIN. THE CAR WAS WANTING TO STALL OUT AGAIN. WHEN I TURNED IT OFF, IT WOULDN'T START AGAIN. THEY REPLACED THE BATTERY. ANOTHER 5 DAYS LATER, IT HAPPENED AGAIN. THEY REPLACE THE ALTERNATOR AND THE BATTERY. IT WAS IN THE SHOP A TOTAL OF 4 TIMES. THEY SAID THE UPGRADED ALTERNATOR AND THE GEL BATTERY THEY INSTALLED WILL KEEP IT FROM HAPPENING AGAIN, BUT SAID THE TEXAS HEAT IN AUGUST HAD SOME EFFECT ON IT. WE WILL SEE WHAT HAPPENS AGAIN IN AUGUST. SO FAR SO GOOD. I JUST WANTED TO REPORT IT AND JUST FOUND OUT WHERE TO DO IT.*AK

Apr 18, 2002

EQUIPMENT,UNKNOWN OR OTHER

1 complaint

CHECK ENGINE LIGHT HAS COME ON AND OFF FOR A PERIOSD OF TWO WEEKS WHEN DEALER CHECKED NOTHING WRONG, AND NOW THE RADIO PAUSES WHILE PLAYING.*AK

Feb 25, 2002

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

VEHICLE HESTITATES ON ACCELERATION,AND CUTS OFF. HARNESS, THROTTLE BODY, THROTTLE BODY SENSOR, COMPRESSOR, EGR GASKET, PLUGS, VALVES, ETC., ALL REPLACED. PROBLEM STILL EXISTS. MANUFACTURER AND DEALERSHIP CAN'T FIX PROBLEM. THEY HAVE HAD NO OTHER COMPLAINTS OF THIS PROBLEM, PER STEVE HICKMAN (MAN. REP) AND DEALERSHIP. AFTER REPLACING HARNESS, STEVE HICKMAN ASSURED ME THAT THE VEHICLE WOULD BE FIXED, THE VEHICLE STILL CUTS OFF AND THE RPM BOUNCES UP AND DOWN WHILE THE TRUCK IS BUCKING AND THEN IT WILL CUT OFF!! SERIOUS SAFETY HAZARD!! *AK (DOT NUMBER: HMA010900 TIRESIZE: P225/70-16)

Oct 24, 2001

SERVICE BRAKES, HYDRAULIC,AIR BAGS

1 complaint

I WAS INVOLVED IN A AUTO ACCIDENT IN WHICH ANOTHER CAR HIT ME IN THE FRONT CENTER OF MY CAR AND THEIR FRONT RIGHT. MY SPEED WAS 40 MILES BEFORE BRAKES APPLIED THEIR SPEED WAS ABOUT 15. MY AIR BAGS DID NOT DEPLOY BUT THEIRS DID. BOTH FIRE AND RESCUE PERSONAL VOICE CONCERN ABOUT THE NON DEPLOYMENT OF AIRBAGS WITH VISUAL DAMAGE TO VEHICLE.*AK

Feb 10, 2001

Crash: 1

Injuries: 1

2001 HYUNDAI Santa Fe Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2001 HYUNDAI Santa Fe have?

What are the most common problems with 2001 HYUNDAI Santa Fe?

Where does this 2001 HYUNDAI Santa Fe problem data come from?

Other Years - HYUNDAI Santa Fe

Other HYUNDAI Models

Similar Brands