How many problems does the 2022 HYUNDAI Santa Fe have?

The 2022 HYUNDAI Santa Fe currently has 155 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2022 HYUNDAI Santa Fe?

The most common problems reported for the 2022 HYUNDAI Santa Fe are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2022 HYUNDAI Santa Fe problem data come from?

All problem and complaint data for the 2022 HYUNDAI Santa Fe comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2022 HYUNDAI Santa Fe Problems

POWER TRAIN

30 complaints

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving approximately 20 MPH, the vehicle failed to properly accelerate, as if the transmission was stuck in high gear. The vehicle was taken to an independent mechanic, where it was diagnosed with transmission failure. The contact believed that the failure was associated with Manufacturer Recall: 236. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 98,300.

Dec 18, 2025

The contact owns a 2022 Hyundai Santa Fe. The contact stated that after starting the vehicle, the warning message "Shifter Malfunction - Service Immediately" was displayed, and the gear shifter failed to shift from park(P), rendering the vehicle undriveable. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet notified of the failure. The failure mileage was 61,000.

Aug 27, 2025

The Vehicle Trim is "Calligraphy" which comes with an 8 Speed Dual Clutch Transmission. This Transmission is Faulty and i already swapped 4 Transmissions under warranty under 55k Miles. (3 refurbished last one Brand new all having same issue) The Manufacturer *does not* want to admit that this is a Manufacturing Defect. (i opened a ticket #[XXX] with Hyundai Corporate office) The Vehicle surges forward when in "Park" which should not happen and I'm afraid it might result in a bigger risk. There are no fault codes or errors. It is a documented issue with multiple owners and discussed on Forums. This issue is unique to this manufacturer as no other DCT's (some of witch i owned in the past) experience such an issue (as far as i know). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jun 19, 2025

Description of problem: The Transmission will disengage while driving, allowing the car to 'coast' as if in neutral. The problem sometimes occurs at red lights, where the vehicle remains stationary for a brief period and then corrects itself as if nothing happened. I noticed the "D" character flashing on the dashboard when the issue occurred, indicating a problem. The engine will rev, but the car will not move. The vehicle spent about two weeks at the dealership (Hyundai of New Port Richie, FL), but they were unable to find an issue after conducting over 80 miles of test driving. The last incident occurred on June 8, 2025, only days after I had removed the vehicle from the repair shop due to this problem. When pulling into my son's driveway, the car's engine revved to about three thousand RPM, and the vehicle rolled backward, out of his driveway, and into crossing traffic. Luckily, the pickup truck on the street was able to stop before hitting my vehicle, which was now sitting in his lane of traffic. I looked down at the dashboard, and the car was still in "D" but would not move forward. After a few seconds, the transmission re-engaged and moved forward again as if nothing had happened. I DID NOTHING AND THE CAR RECOVERED BY ITSELF! I returned the vehicle to the dealership for further investigation on June 9, 2025, and am driving a rental. Summary: This car is unpredictable and unsafe in this condition. Someone could drive this car for days without experiencing an issue, but it does happen when you least expect it! I use this vehicle for local travel only, about twenty-mile trips.

Jun 09, 2025

I took my vehicle in on 2/03/25 for a back up camera recall and to have my transmission checked due it not shifting correctly. I was called within two hours and told the transmission needed to be replaced. Weeks later they called and told me they had good news and bad news, the transmission was replaced, however it would not work. They replaced the transmission for the second time and had me pick up the vehicle on April 17th. I picked the car up and immediately went back in and told her it was not shifting right. They told me to drive it home and see how it did and they would have the service advisor reach out. On the way home, the car was at 5000RPM at 60mph. It was not shifting. The check engine light came on the next day. The car was taken back and I was told on April 21st the transmission needed to be replaced again. I was called on April 7th and told that there was a wire they needed to check that went from the transmission to the pcm and they were going to check it and see if that would fix it. That is 3 total transmissions that have been in this 2022 vehicle. The vehicle is unsafe to drive and Hyundai corporate is not doing anything to help.

May 15, 2025

+ 25 more complaints for this component

UNKNOWN OR OTHER

16 complaints

I purchased my 2022 Hyundai Santa Fe Hybrid brand new and in three years, both horns (high and low) have stopped working every year. I have had the horns replaced in March 2023, January 2024 and as I type this complaint, both horns are out again. It is a serious safety issue driving a vehicle without a horn. There is no warning that the horn is going to stop working; and I have discovered the malfunction while driving when I needed to alert another driver before we potentially collided. It has also been extremely inconvenient for me to take off work to take the car in for more service. What's more frustrating is I was told by a service manager that they (Hyundai USA) are aware of the defect with these particular horns but has chosen to continue to replace the defective horns with more defective horns. Now I drive an unsafe vehicle until I can take off work again to have my horns replaced with parts that will last for one year, if I'm lucky. I am asking for some assistance with this matter since it is clear that Hyundai USA has not made it a priority to solve this ongoing safety problem for all its customers who are having the same issue. Thank you.

Nov 30, 2025

The horn has completely failed for the 4th time. Dealer is now stating it is not covered as mileage is over 60k.

Aug 19, 2025

Backup camera no longer works

Jun 06, 2025

The car horn failed to work when I went to use it around April 20, 2025. I first noticed it while stopped at a traffic light and the car in front of me failed to advance for several seconds at the green light. Then I noticed a car drifting over the line in oncoming traffic and was unable to use the horn to alert the driver. As I drive with my toddler granddaughter in the car, I needed the vehicle fixed ASAP. My independent car mechanic had to replace 2 horns (Hi tone Horn and Lo Tone Horn). Today I came to know of a Hyundai Forum and did a search on car horns. Apparently, this is a known failure for many years. Some owners have had the horn replaced as many as 3 times. I since have requested reimbursement from Hyundai, but they refused because I didn't take it to a Hyundai dealership. There were no warning lamps or messages.

May 01, 2025

The horn on this. vehicle has been replaced 4 times in 2.5 years. It has failed and on three occasions I nearly hit a pedestrian and other vehicles. I asked my service representative, John King, of Lia Hyundai in Albany NY if there is a recall on this issue. He said no. I researched this problem and found that this is a widespread problem with Hyundai. I feel strongly that eventually someone will be seriously injured or worse in Hyundai does not recognize this problem.

Mar 02, 2025

+ 11 more complaints for this component

ENGINE

16 complaints

My Santa Fe limited 2022, has stopped running while traveling at 50 to 60 miles per hour on 3 different occasions. Car has 19000 miles and incidents have occurred over past 10000 miles.

Jul 19, 2025

The contact owns a 2022 Hyundai Santa Fe. The contact stated that on two occasions while driving at approximately 25 MPH, the vehicle lost motive power. On the second occasion, the vehicle was steered to the side of the road and restarted. The vehicle was taken to a dealer where the failure was not able to be replicated. The manufacturer was notified of the failure. The failure mileage was approximately 10,000.

Aug 08, 2024

The vehicle shuts off completely when stopped at a stop sign, traffic light, or parking space. This has occurred multiple times. Hyundai can not find the problem after multiple times in the shop. The last time it occurred I was in the middle of a busy intersection and was almost broadsided.

Jul 30, 2024

I was driving in the freeway and all of a sudden my engine power became week. I try to step accelerator but it did not cooperate.

May 04, 2024

On 10/31 I loss power while on the freeway for the 2nd time since August. The car was assessed and fixed according to the dealership. My car threw a 2nd code which was cleared and not fixed due to not showing issues according to the dealership. I got my car back in mid November. I immediately complained that I still had a rough idle and was told my car was fine by the manager via service rep. On 11/28 my car loss power on the freeway again for the 3rd time since August. According to the codes, all my cylinders are failing one by one. This is a huge safety concern. The dealership could care less.

Nov 30, 2023

+ 11 more complaints for this component

FUEL/PROPULSION SYSTEM

6 complaints

The fuel injectors have repeatedly failed. I am on my third replacement

Dec 11, 2025

While traveling out of state, my 2022 Hyundai Santa Fe (2.5L) experienced a sudden loss of power and rough running during acceleration to pass; check engine light came on. Independent shop pulled code P0302 (cylinder 2 misfire). Vehicle became unsafe to drive and was left at a Hyundai dealer in Indiana. I later learned Hyundai issued TSB 25-FL-001H (Jan 2025) for 2.5L GDI injector internal filter breakage that causes misfires and directs replacing all four injectors. Parts were quoted up to three weeks on backorder. This sudden power loss during highway passing presents a safety risk (inability to accelerate/merge). Vehicle is under 60,000 miles.

Aug 18, 2025

Vehicle failed to accelerate while operating on the highway. Pulled over and shut vehicle off and smelled gas. Vehicle would not stay started. Towed to dealer and was told it was a defective fuel injector. All injectors were replaced. Apparently this is a known problem. This could have been extremely dangerous if I wasn’t able to pull over. Hyundai should issue a recall to replace these defective parts.

Jul 23, 2025

3rd time having the same engine issue where the fuel injector keeps going out. Once in February then again in April now again in Jan. The car shakes violently and unsafe to drive even when at a standstill.

Feb 01, 2025

I filled up my gas tank and the digital guage was on 266 miles. After I filled up, it was the exact same mileage on the dashboard. It did not move after putting in about 4-5 gallons of gas.

May 06, 2024

+ 1 more complaint for this component

ENGINE,FUEL/PROPULSION SYSTEM

6 complaints

A few days before the complete engine failure the car became very jerky on the throttle response I would slowly add throttle and the car would jump all over the place with RPMs and felt extremely jerky when shifting gears. At one point the engine downshifted past redline when decelerating off the highway. The day of the engine failure I was accelerating up hill after leaving a stop sign. Around 25 mph the throttle stopped responding and the engine went to idle around 800 rpm. The car started violently shaking and sounding like it was running on 3 cylinders. I tried the throttle again and nothing happened. At this time I was slowing to a stop on the hill while still in lane being unable to get out of lane to the shoulder. Upon coming to a stop the vehicle continued to shake and eventually the engine stalled while keeping the electric on. At this point there was never any lights on the dash board to indicate a fault. Upon attempting to restart the engine it turned over 3 times and eventually started all while violating shaking and eventually stalling again. The third time attempting to start it did not turn over. At this point I was stuck in lane and needed to call the police to come and assist me because I was unable to move the vehicle under its own power putting my life in danger. Upon taking getting it towed to a dealership they said it was a fuel injector fault.

Jun 16, 2025

Was traveling on [XXX] near Reston, VA when the Santa Fe engine started missing and losing power and check engine light came on. Vehicle was towed to dealer and repaired on 04/26/24 Mileage was 36285. The repair order says it was fuel injector for cylinder #1. The second time the same thing happened was on [XXX] near Haymarket, VA. The date was [XXX], mileage was 36577. The engine started missing lost power and check engine light came on. Vehicle taken to dealer for repaired. They replaced injector #2. The third time was about [XXX] mileage about 51000. Was traveling near Haymarket, VA. Engine started to miss, decrease in power, check engine light came on. Vehicle was towed to dealer. Inspection of the engine revealed injector #3 was malfunctioning and they needed to replace it but could not get the injector for it from Hyundai. The vehicle has been setting at the dealer since then with no idea when it will be repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jun 05, 2025

Was driving on the highway while it was in cruise control and on several occasions when trying to accelerate the vehicle would jerk aggressively and struggle to accelerate. It did this about 3 times on my way to my destination. Took it in and they said they couldn’t find anything wrong with it nor could they replicate the issue. No work was on done on it.

Jul 03, 2024

The car has been taken to the dealer multiple times for not accelerating out of 1st gear when starting up, and also for shuddering at high speeds. We have been stranded, hundreds of miles from home on 2 occasions, first with less than 30,000 miles because the spark plugs needed to be replaced. And the second occasion, also hundreds of miles from home, because the car failed on the highway and limped into a dealership, where one of the fuel injectors was replaced at approx 50,000 miles. The mechanic at this dealership voiced his concerns that these were the original fuel injectors, He said he was aware of the problem, but was only permitted to replace one of the fuel injectors. The car continues to shudder at occasionally, and refuses to shift out of 1st gear at odd times. We have tried to get Hyundai to replace the fuel injectors, but they refuse. I would like this to be serve as a record of our problems so that others can be aware of a problem that exists with these cars. This is a safety issue, as if the car will not accelerate on a highway or crossing a road, it is possible to have an accident. Also, having the car fail on a remote highway is also a safety issue.

Jan 31, 2024

Vehicle check engine light came On while driving and vehicle began misfiring. Vehicle was in the shop and injector was found defective. Vehicle again had same issue but intermittently and wife would have to pull over and shut down the car to be able to drive it safely home. Dealership tried blaming bad gas which was purchased a mile from dealership. Within 50 miles vehicle began acting the exact same way and Hyundai dealership says injector needs replaced but blaming contamination not a known issue Hyundai has with injectors. Found multiple instances of same issue and same made up issue of contaminated gasoline even at the same dealership I went to. Faulty injectors make the vehicle unsafe when traveling at highway speeds on busy highways.

Oct 11, 2023

+ 1 more complaint for this component

FORWARD COLLISION AVOIDANCE

5 complaints

The vehicle has activated it emergency breaking feature several times now on the last couple of months witouth any reason to do so. Presenting a major risk for the occupants and to other vehicles on the roads.

Dec 03, 2025

Front radar system continues to not work without having damaged caused. Makes cruise control not work. Forward collision not work, etc.

Jun 19, 2024

On several occasions now The vehicle is engaging the automatic emergency braking system for no reason. Several times I have been driving on the highway without a car in front of me and it engages the automatic emergency braking system. This has caused me to almost be rear-ended because my vehicle slammed on the brakes. I have almost been in several accidents now due to the automatic emergency braking activating for no reason and cars almost hitting me.

Sep 21, 2023

On three separate occasions over 18 months, the car has entered into front collision avoidance mode by unexpectedly swerving the vehicle and braking. Twice I was on the tollway doing 70 mph on a 4 lane expressway and I drove in between two tractor/trailer semis. When I reached mid point, the car braked heavy on it's own and swerved first the right, then to left. In each incident, not only did it scare the hell out of me, I thanked god I avoided a major accident from crashing into the trucks and or being hit from behind. In the third incident (date of this complaint) I was driving over train tracks on two lane road at about 35-40 mph, there were yellow black traffic barriers dividing the narrow roadway at the tracks and the car suddenly braked and swerved, nearly getting me rear ended and putting me down into the culvert around the tracks. In each incident it was difficult to take control of the car back from the collision avoidance.

Jul 05, 2023

The contact owns a 2022 Hyundai Santa Fe. The contact stated while driving at various speeds, the vehicle experienced phantom braking with the Emergency Braking message displayed. Additionally, the vehicle lost motive power while driving. The manufacturer was made aware of the failure and had the vehicle towed to the dealer; however, no failure was found. The vehicle was not repaired. The failure mileage was approximately 38,955.

May 04, 2023

ELECTRICAL SYSTEM

5 complaints

Vehicle experienced a spontaneous interior fire while parked and turned off. No collision, no injuries. Fire originated under the driver-side lower dash/kick panel near the fuse/BCM wiring, then spread into the driver door harness/trim. Exterior body and engine bay show no impact or external origin. Details: Heavy charring/melt concentrated at lower dash/junction area with upward/sideways spread along wiring paths; interior plastics, dash switches, and door wiring damaged. Vehicle was unoccupied. Aftermarket: No hardwired accessories in the origin zone. A dashcam was powered via center console USB/12V with a small battery pack (not connected to the under-dash fuse block). Status: Towed to [Dealer, City/State]; Hyundai Corporate Case #XXX opened. Insurance comprehensive fire claim opened; origin-and-cause inspection pending. Request: NHTSA investigation into potential electrical/wiring defect in driver lower dash/door-harness area on this model/year; safety risk of parked, unattended fires. Photos/videos available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Nov 14, 2025

Fire: 1

The horns stopped working, and this is a safety item since it’s the only way to notify another vehicle or pedestrian if they will be hit by my car. Another day, a car came out of the parking lot and almost hit my car. I was only able to avoid that accident because I reversed quickly. I took my car to the dealership, and it was confirmed that the horns are not working. To fix this issue, I need to replace them. But since my car is out of warranty, I will need to pay for this service. On 07/14/2025, I called Hyundai (Case number 4117-7538) to request the application of an extended warranty that they started to offer for the 2021-2025 model year Elantra (Z03). Since my car is the 2022 model year Santa Fe, they did not accept my request. I noticed that on several websites, Hyundai car owners are complaining about their car horns. Just the fact that Hyundai started to provide an extended warranty for a different model, but in the same year range as my car, confirms that they are having issues with this part. I just know about this extended warranty because I also have an 2024 elantra hybrid, that is covered by it (as you can see on the uploaded letter).

Jul 14, 2025

The integrated thermal monitor is stuck. When I took it to Ken Vance Hyundai today, they said it is a common issue and if left unfixed. It would blow the engine.

Dec 23, 2024

The back doors should unlock when the SUV is put in park or the motor is turned off. However, it does not unlock over 25% of the time. This means the back doors can not be opened from the outside or inside. People in the back cannot get out unless the doors are manually unlocked from the control panel in the front. This is a real safety issue if there was an accident and the people are trapped in the car. This issue has been reported to the dealer for almost two years. They have not been able to fix the issue. I have reported this problem to Hyundai National Consumer Affairs (case # [XXX]) asking for their help. I ask if this falls under the lemon law since it can not be fixed and is safety issue. I was informed they could not help me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Nov 19, 2024

The contact owns a 2022 Hyundai Santa Fe. The contact stated that the vehicle was not able to start. Triple A towing company was not able to jumpstart the vehicle, and the vehicle was towed to the dealer. The dealer was not able to duplicate the failure however, the mechanic replaced the battery. The contact stated that the failure recurred. Triple A was made aware of the failure but was unable to jumpstart the vehicle. The vehicle was towed to the dealer however, the dealer could not duplicate the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 209.

Apr 15, 2022

VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

3 complaints

Vehicle began to display Front collision avoidance system error/ radar blocked. This also disabled the 'smart' cruise control features. This happened any time the cruise control was engaged and we encountered traffic. The unit was in the dealer's service department for a week, and the front radar module was replaced and reprogrammed under warranty.

Sep 23, 2025

I was driving at approximately 65 MPH using the advanced cruise control system. Randomly, the system disengaged and I started getting 2 MIL warnings on my console. MIL warning 1) was "Check Forward Safety System" and 2) warning the advanced cruise control parameters are not met due to warning 1. A few minutes later, I received a message on my Hyundai Blue Link app showing DTC C162078. After researching this DTC, I found that there are hundreds, if not thousands, of other drivers that experienced this same/similar situation -- unexpected loss of advanced safety features and smart cruise control features. In fact, Hyundai published a technical bulletin for another model with the same issue. The loss of these functions places an unexpected safety risk to the driver if this issue occurs when there is other traffic present. My vehicle was involved in a frontal accident once about 1.5 years ago and this issue has never occurred. This is the first instance of this issue since I purchased the vehicle brand new from the dealer.

Apr 27, 2025

Hi Team, Issue 1: unexpected Acceleration: Recently I found that is there is unexpected additional acceleration when I press gas pedal initially after changing gears from P to D. I am setting up an appointment with dealer to report and investigate this issue. My Car has only around 13000 miles on it. This issue was initially observed when one morning when i headed somewhere there is unexpected acceleration when I slightly press gas pedal. Issue 2: The Advanced Driver Assistance Systems (ADAS) doesn't work properly when set to adaptive cruise control. It doesn't slow down /stop when getting close to cars parked at signal specially as slight curvy roads.

Mar 24, 2023

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

3 complaints

Bought Car in 2022 when COVID was still a problem. I had problems with the LED screen on the dash turning off. It did come back after about 10-15 minutes. I had to pull over to the side of the road in the meantime. I brought my car in and no problem was found. I was told that there was no way they could order a $6,000 part if they could not reproduce the problem. I still have had this problem periodically, but it does not last as long. This can be a safety risk when the screen goes out when driving. My check engine light has gone off many time in the 3 yrs and 7 months of me owning the vehicle. I am asked if the light is blinking when this occurs. If I said 'no', I was told 'then you don't have to worry'. I had my car in to evaluate the engine light on, and was told not to worry that no code showed up (I did not get a service record if they didn't find any thing, despite me asking). The very next day I was stranded on a busy Hwy. My car was towed to the shop. I barely got off the Hwy as one of my fuel injectors was bad. I was 45 min from my home and the check engine light went on. I started driving home and called the service dept. I was told that as long as the light was not blinking, it would be ok, and I tomorrow I should call for an appt if it is still on. My car started to act up when I was nearing my home, but it was drivable. The next morning the light was still on. I did not feel safe driving it around and felt it was another fuel injector. I was driving my car to the shop and the car was slowing down a little at a time. By the time I was about 1/2 mile from the shop, my car was only going 14 miles per hour. I was driving on the side of the hwy with my flashing lights on. Very unsafe. I know that I have a lemon for a car, but not taken seriously, that is a PROBLEM. I have had many more times that my engine light was on and would bring it in for an evaluation. Sometimes things were found, other times not. I am concerned about that lack of concern.

Aug 12, 2025

On Monday nite returning Tuesday Morning I was coming home from work and I noticed my engine light is on and car is not running properly. I had to drive slower than normal at 12:30 AM I can usually drive the expressway but I am glad I didn’t .I live in Detroit Mi My employer which is Amazon is located in Romulus Michigan so I took [XXX] to [XXX] that when I notice my automobile was not driving as usual so I pull over and I notice my check engine light was on so I restarted my car several and it still was on so I Prayed and drove slow all the way home Thank God I made safely my auto have 7100 miles on it I had one oil change the next one is due at 10,000 miles. So the next morning I was at dealership when it opened and met with the manager at Lafountain Hyundai on Telegraph in Dearborn Mi He tried to diagnose my car and showed but it didn’t work so he told me to take it to Lafountain Dealership in Livonia I arrived and they told me their were backed for three weeks And couldn’t get a appt and when I do I will have to leave like everyone else and I saw all those cars mine just sitting so I ask the reception and she had no answer after I explain so I tried Hyundai Corporate office no answer so I been read all the trouble shooting information but that wouldn’t help because is slipping so I came home and back on the internet and began reading other comment. I can’t leave my car I need to go to work how am going there buses do run out there and I don’t have any other Transportation so my car will just until someone helps me Thank you for excepting my complaint please help me I am losing money how can I pay for my car with no money. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jul 02, 2024

We have had already had two issues with our Hyundai Santa Fe that we purchased new from a dealer on 5/21.The first malfunction happened on 7/23. While driving, we had several messages come across the dashboard warning that some sensors were not working properly. We then had the warning light, front collision light, the traction control light, the abs light, the auto hold and the emergency brake all light on the dash. We also lost the blind spot sensor on the side mirrors. Called the dealer and took the car in. Two days later was told it was a wheel sensor and all should be good. Then on 8/31, while merging onto a highway, I pressed the accelerator and although the engine revved, the car did not increase in speed. Luckily the car behind me was able to swing around me and I put on my hazards and pulled to side of the road. I turned the car off, restarted it and pulled out. Five miles down the road, while in traffic, the same issue occurred, but after about thirty seconds or so, the car jerked and picked up speed, Back to the dealer it goes and they called to tell me that they cannot replicate it and there are no diagnostic codes showing. They are going to keep it for a few more days to do some more diagnostic testing, but don't know what the issue is. This is a brand new car -

Sep 03, 2022

FUEL SYSTEM, GASOLINE

3 complaints

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while her son was driving 20 MPH, the vehicle failed to accelerate as needed. An unknown warning light was illuminated. The vehicle was towed to the dealer, who determined that the fuel injectors needed to be replaced, but the parts were on backorder. The vehicle was then towed to a second dealer, AutoNation Hyundai Mall of Georgia (3445 Buford Dr, Buford, GA 30519), who determined that the fuel injectors needed to be replaced and informed the contact that parts were still on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 30,000.

Jun 09, 2025

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed. The dealer replaced the high pressure fuel injector pipe, the Gasoline Direct Injection(GDI) fuel injector on cylinder 3, the high pressure fuel pipe, the combustion seal ring, the K bolt, and other unknown parts. The vehicle was repaired under warranty. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

Nov 05, 2024

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with the check engine and oil warning lights illuminated. The vehicle was towed to the dealer where it was diagnosed that there was 1/3 amount of water in the fuel tank, causing damage to the fuel injector. The dealer informed the contact that the fuel injector needed to be replaced; however, the part was not covered under warranty. The vehicle was not repaired. The contact stated that she had received a copy of the state inspection notice that it had passed for clean fuel from the gas station where she refueled. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 11,000.

Aug 03, 2022

POWER TRAIN,ENGINE

3 complaints

While driving the car keeps Jenkins, and on the dash board it cane up have your power train checked. My vehicle has been in the shop 4 times since February over 30 days twice. My vehicle is still currently in the shop at the dealership. They refuse to check my power train area, and keep telling me 2 of the cylinders are backfiring

Jun 06, 2025

My vehicle has been having repeated issues within 2.5 years of my purchase. Initially it was the transmission and Hyundai service center with poor customer service kept the car for almost 20-25 days before replacing the vehicle. Now, I have picked up the vehicle for less than a week and I get another Powertrain DTC code P030100 and check engine light on. Hyundai service centers are worst in the country, very poor customer service. I have to take my caribou 100 miles away to a different service center because the in town service center wouldn’t even look at the car and says has no appointment. I have to drive the car for about 100 miles with engine light on which poses a major risk to the car and myself to even ben able to get the car service done under warranty. The company advertises best warranty in the industry but makes it hard to fix the vehicle under warranty. Please stay away from buying an Hyundai in future. Thank you.

Aug 18, 2024

The contact owns a 2022 Hyundai Santa Fe. The contact stated that on multiple occasions while driving approximately 25-40 MPH, the RPM increased to 5,000 however, the vehicle failed to respond. The contact was turned off and restarted the vehicle. No warning lights were illuminated. The contact called the local dealer and was advised to schedule an appointment to have the vehicle diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 9,000.

Oct 17, 2022

VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

3 complaints

Middle of May 2024 car begins to feel like it's shifting when accelerating and stopping. Nothing found by Hyundai Service Dept. Lakeland. On apx. [XXX] while driving stepped on gas pedal and felt no power. Kept pumping the pedal & car started jerking. Managed to get to light and get in left lane to turn into plaza honking horn. Car slid to a stop at entrance. On apx. [XXX] my husband was driving home and same thing happened. Managed to slide car into our driveway. Both times the car had to be towed to dealership. Two fuel injectors have been changed and when I asked them to change other two they said warranty would not allow. Worst case scenario is if this happens on the interstate traveling at 75 miles per hour. Not only could we be killed but others. Both times there was no warning lights or any other warning. The car just started jerking and lost power. It can very well cause a car to rear end us and a multiple car chain reaction hurting or worse killing others. I am filled with anxiety every time I take the car out for errands. I also saw a similar incident reported in the Better Business Bureau here in Tampa by another person. I reported my incident to Hyundai Corporation by phone and email and asked the rep to reported it to her superiors to see if they could just please let the dealership replace my other two fuel injectors & I was told they could do nothing. The dealership has told me several times the injectors must fail before they can replace. Apparently, the cost of the injectors is more than someone's life. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Aug 25, 2024

Ref NHTSA TRACKING # 11557625 Vehicle broke down again within 5K miles and 45 days of prior repair referenced in above case. Similar conditions, highway speed, bucking and vibrating, loss of speed control, no warning. Subsequent repair confirmed same issue (fuel injector) as original breakdown/repair and my initial notification to NHTSA.

Dec 08, 2023

Vehicle began to shake, buck and emit a grinding noise while traveling on highway resulting in loss of speed control and associated fear. Check engine light appeared simultaneously. No prior indication of a problem. Managed to limp to next exit via shoulder. Had car towed to dealer as warranty was still in effect. Problem was diagnosed as fuel injector failure and repaired. Learned it is a common, recurring issue with Hyundai 4 cylinder engine. Not unusual to have multiple failures per vehicle. Hyundai is only authorizing repair/replacement upon individual failures, not pre-emptive even though common and recurring. Confirmed this is a common, recurring issue across Hyundai via our local mechanic and internet info. Vehicle has now experienced a second failure and is being towed to dealer.

Nov 30, 2023

POWER TRAIN,ELECTRICAL SYSTEM

2 complaints

The contact owns a 2022 Hyundai Santa Fe. The contact stated that intermittently, the gear shifter was inoperable, and the message "Gear Shift Malfunction" was displayed. The contact stated that the failure required that the vehicle be turned, which automatically engaged the parking brake. The contact stated that upon pressing the Start button, and then depressing the brake pedal, the contact was able to move the gear shifter to park(P) and to the other gears. The vehicle was taken to the dealer, where it was diagnosed that the wiring was open between the transaxle, the rain switch, and the shift control unit. The dealer replaced the wiring. Upon test-driving the vehicle, the dealer noticed that the vehicle was still experiencing abnormal vibrations. The dealer recommended that the transmission be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 98,000.

Dec 18, 2025

I have had to have a problem with my power teain worked on at two different Hundia dealership I am having an issue where the horn just stops blowing and that isvery dangerous. After switching off and restarting the horn will work again.

Dec 14, 2024

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

2 complaints

Vehicle purchased 9/1/24 from Courtesy Hyundai of Tampa. Dealership failed to file registration/tags until 10/4/24. 7/12/25: Vehicle experienced involuntary acceleration and braking, resulting in impact with my mother’s home. 7/16/25: Dealer issued written report stating vehicle was operating normally and documented a recall-related display/audio/camera software update. 8/14/25: Hyundai engineering inspection performed without my knowledge. No report has ever been released. 8/27/25: Hyundai issued corporate denial, blaming driver error and stating braking/acceleration systems were normal. 12/5/25: Second involuntary braking incident at highway speed on I-275. Five uncommanded braking events over ~20 miles. Service Manager stated failure was due to sensor/camera malfunction and instructed that the vehicle should not be driven and to tow immediately. Despite this, the vehicle had been released into roadway operation. VIN lookup shows an open, unrepaired federal recall (24V879000 / Recall 271) for the rearview camera system, marked Recall Incomplete, despite the dealer’s documentation that recall-related camera/software work was completed on 7/16/25. BBB Auto Line denied my claim only because the vehicle was outside Florida Lemon Law eligibility. No safety determination was made. Hyundai released no engineering, sensor, or camera data despite an engineering inspection. This vehicle has experienced repeated involuntary braking and acceleration at highway speed, involving braking, camera, and automatic emergency braking systems, creating a serious risk of loss of control, collision, injury, or death. Despite repeated failures, contradictory diagnostics, withheld engineering data, and an open federal recall, the vehicle was released back into public roadway operation. I request that NHTSA formally investigate this safety defect.

Dec 08, 2025

Crash: 1

Phantom emergency braking occurred on two separate occasions a few months apart while traveling at 50-60 MPH for no reason. Almost rear ended. Flashing red zigzag alert stating “Emergency Braking”. Vehicle towed to dealership for inspection and diagnostics. Afraid to drive on freeway or highway. Dealership unable to reproduce or solve issue first time. Now at another dealership for inspection.

Nov 15, 2023

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

2 complaints

Horn stopped working

Oct 22, 2025

I have a 2022 santa fe xrt within the 1st yr of owing in 2022 the horn stopped working in the winter. Went to dealership told it was known issue they replaced it. A few months later into following year still winter went out again they fixed again stating my car has 2 horns and both failed. So far 2022 and 2023 2 times. Fast forward to earlier in 2024 beginning of year horn failed again took to dealer expressed my concern of this is a safety and inconvenience issue they apologized but no recall yet. Now it's almost 2025 and I will be taking my car back to the dealership this weekend for yet another time due to the horn not working at all. I've found out my horn has not worked due to driving and a vehicle almost colliding into my lane and went to honk horn and nothing. A separate time a person has cut out in front of me almost causing an accident and all I could do is to lock up my breaks and swerve hope they see me and don't get hit could not beep to warn them. I bought the car brand new in 2022 feb and I have had the horn replaced 4 to 5 times and they still are staying no recall this is ridiculous.

Dec 13, 2024

STRUCTURE

2 complaints

Fuel access door does not open correctly. Fuel door does not have a lock or a require pressing of a button to open; you would normally just 'push' on closed door to make it pop open. Over the past (3) months, this has not always been working. Sometimes it requires multiple high-pressure pushes (or a light bump) for door to open. On other occasions, unlocking the vehicle (all doors) and not just the driver's door that unlocks when exiting the vehicle has somehow contributed to getting the fuel door open. Multiple online Hyundai Santa Fe forums make mention of the fuel door being a widespread issue and suggest requiring replacement of an actuator in fuel door by dealership or prying the fuel door open with a screwdriver. Prying door open, in my opinion, is not an option because of potential damage to door and painted surfaces around the fuel door.

Sep 12, 2025

Automatic lift gate not functioning correctly ( maybe during hotter months). Door handle not responsive at times

Mar 28, 2023

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE

2 complaints

Vehicle will stall out while driving at speeds Loss of braking capability and steering capabilities all lost when this happens. Vehicle will roll until stop. No control to steer or brake

Jun 26, 2025

The car completely shut off in the middle of driving and I was unable to put the car into park or use the emergency brake and hazard lights because all of the controls are electronic. The lack of mechanical safety features is a danger.

Jul 29, 2024

BACK OVER PREVENTION

2 complaints

The contact owns a 2022 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 24V879000(Back Over Prevention); however, the part to do the repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The contact had not experienced a failure. Parts distribution disconnect.

Jun 12, 2025

Backed into something at my son's school due to inoperable rear collision sensor, causing damage to the lift gate. there were/are no warning messages. My husband almost hit a car backing out of our driveway due to same issue. We are taking the car to the dealer for inspection

Jul 17, 2023

Crash: 1

UNKNOWN OR OTHER,VISIBILITY/WIPER

2 complaints

this was a CERTIFIED vehicle i purchased. i dont believe it was certified because after returning it after -3- weeks because the windshield wipers werent working properly. after they looked at it the dealership told me that whoever put the windshield in it broke part of the windshield wiper connections and also ruined the calibration on certain safety features, and broke the windshield itself. this was not caught on their CERTIFICATION process and just put out on the lot to sell. they expected me to pay 1/2 of the expense for which i refused.

May 05, 2025

This is the second time my windshield has received a small chip and it spreads to the nearest end of the windshield then within 24 hours spreads across windshield

Aug 02, 2023

VEHICLE SPEED CONTROL

2 complaints

Vehicle would not shift when accelerating on gas pedal while driving, rpm’s went up to 5,000. Had the car towed to closest dealership and they haven’t looked at it. They stated they are unable to assist me with a rental car. I am home alone with 2 children and cannot go to work. There is a transmission recall on the 2022 Hyundai Santa Fe with the exact problems the car has been having. Recall #236, campaign #22V746000. I called the recall consequences customer service # and they stated they were unable to help me until the dealership looked at it. The problem started in fall of 2024 and I took it into the dealership first on 11/5/24 and again when it continued the problem 11/14/24. The 11/14/24 visit they performed a software update and the car shifted smoother in Smart Drive Mode only. On Friday, 3/14/25, while driving home from work, the car would not shift at all when pressed the gas turning into traffic. I turned on my hazard lights and pulled into a parking lot. I called roadside assistance and had the vehicle towed to the dealership.

Mar 17, 2025

The contact owns a 2022 Hyundai Santa Fe. The contact stated there was an engineering speed control fault while driving approximately 65 MPH. The contact stated that the smart cruise control rode the brakes while going downhill and destroyed the rotors. There were no warning lights illuminated. The vehicle was taken to the local dealer and to be diagnosed. The dealer turned the rotors; however, the contact stated that if the cruise control was activated, it would destroy the rotors. The manufacturer was notified of the failure. The approximate failure mileage was 2,500.

Jun 01, 2022

UNKNOWN OR OTHER,ENGINE

2 complaints

On November 28 2023, I was pulling onto a small highway when an alarm went off, car stopped (engine off) as other cars were coming towards me. The message displayed was "autostop is off. Shift to P or N and start engine manually". Because the alarm was so loud and I was concerned, I snapped a picture which will be attached. I immediately pushed start button and was able to get out of the way. I had not turned the Idle Start Stop (ISS) button to off - so supposedly it was on. (You have to push this button to turn ISS off. This happened twice until I was able to get to service department. After much time (and using a loaner car) Hyundai agreed to provide a new battery because of its health. This happened again. I took the car back and the manager showed me a technical service bulletin - regarding my car - "Rough Shift and Hesitation Improved Logic". This didn't sound like Idle Start Stop bulletin but I was assured it was (attached). Though the stall has not occurred since, the ISS icon at times just isn't there. My dealer is communicating with Hyundai to try to keep my car again and provide a loaner. I am reporting this because many others on Hyundai Forums are describing the same incidents. Yet I haven't seen anyone mention the Technical Service Bulletin, even though many have taken this problem to their dealer. To me this needs to be considered for a recall. I had a daughter and grand daughter in my car and had no idea what to do with cars approaching. Fortunately, just pushing start worked. I have read the manual and know what is required for ISS to work. All requirements were net. It is possible the TSB has fixed stall issue so I am mainly reporting for other drivers.

Jul 23, 2024

On Friday the 7th of April while driving about 40 miles/hr my car lost power in traffic. I pushed gas pedal all way to floor to no avail. Then I was able to get it to move at about 20m/hr for short distance and it cut out and engine lite on as well as a horrible smell like something was burning. It had to be towed into dealer.

Apr 10, 2023

TIRES

2 complaints

See attached document from complainant

Oct 11, 2023

The contact called on behalf of her daughter who owns a 2022 Hyundai Santa Fe equipped with Kumho Tires, Tire Line: Crugen Premium, Tire Size: 235/60/R18, DOT Number: 000CMYANH. The contact stated that while the vehicle was parked, the rear passenger’s side tire became deflated. The tire was replaced with the spare and the vehicle was taken to a tire retailer and the contact was informed that the other tires had low tread and needed to be replaced. The tires were not replaced. The contact stated that the manufacturer was sent an email and she was awaiting a reply. The manufacturer was not notified of the failure. The approximate failure mileage was 10,000. The VIN was not available.

Mar 08, 2023

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

2 complaints

I was driving the vehicle my pregnant wife and 1 year old baby were in the car with me. Car started shaking and i was loosing speed right before getting off the freeway. There was a very strong smell of gas as if it was leaking but it was not. I have an appointment to be checked at the dealership Wednesday August 16th. This is the second time something like this happens while driving in the freeway.

Aug 14, 2023

My car has stalled and shut down and locked up completely while I was driving the vehicle for the 4 th time Thanksgiving Day. I was petrified! I called service at the dealership and they wanted to charge me. The car isn’t even a year old! What is Hyundai going to do about this?

Nov 26, 2022

VISIBILITY/WIPER

2 complaints

The front windshield wiper mechanism failed to work twice during a build up of snow/ice on the windshield. The first incident was while starting up the car in my driveway. I had to scoop out and scrape the snow from around the bottom of the arm of the wipers. After working on it for a couple of minutes, the wipers started working. The second time they completely stopped working was while I was driving on a 45 MPH road. Heavy, wet snow from the roof had slid down onto my windshield. I could not see because the wipers stopped working. I had to pull over to the side and physically scoop out the snow with my hand that was around the wiper arms at the bottom of the windshield, half under the hood. It was extremely difficult to get to it. I had to do this twice to get the wipers to start working again. I saw yesterday that there is a recall for this exact issue on 100,000+ Palisades. I am reporting this to the Hyundai Dealership from which we bought the vehicle last year. There were no warnings, lights, signs to indicate the wiper failure.

Mar 24, 2023

Driving highway speed. Nice, clear day. No trucks or vehicles within 1/4 mile. No impact to windshield. Stress fracture started on passenger side of front windshield. Initial three inch fracture has expanded to over 12 inches

Feb 23, 2022

SERVICE BRAKES

2 complaints

Stopped at a red light when the brake pedal depressed to the floor causing the vehicle to move forward from still being in gear. (No loss of brake fluid) It caused me to be involved in an accident. The investigating officer (police) tried the brakes, when he first tried the brake pedal was high and working, but then suddenly depressed to the floor for him as well. the vehicle needed to be towed to repair shop.

Mar 09, 2023

Crash: 1

The vehicle is exhibiting heat spots on the rotors causing shaking while braking and making the vehicle not stop as designed or even reasonably safe. The issue first started at 7000 miles and became very undrivable by 9000 miles. The dealer turned the rotors at that time. Now the vehicle has 16000 miles and the issue has come back. I know of multiple others with the same issue including 1 family member with the same vehicle and year and multiple people on the hyunda forums. The service tech at the dealer said they see seeing this a lot now. Hyundai doesn't want to fix the issue any longer and it's still under warranty. The braking system is not sufficient for the size of the vehicle.

Oct 18, 2022

POWER TRAIN,VEHICLE SPEED CONTROL

2 complaints

I was operating the vehicle at a rate of 35-45 mph while getting on a highway ramp. As I merged and attempted to accelerate, the vehicle downshifted into 2nd gear itself and suddenly dropped in speed. This same incident has taken place multiple times in the past two weeks. Today I was able to catch it on video.

Dec 22, 2022

The contact owns a 2022 Hyundai Santa Fe. The contact stated that upon the start of her vehicle while at a gas station, the vehicle initially failed to accelerate upon the depression of the accelerator pedal. The contact repeatedly tapped on the accelerator pedal as the vehicle abruptly accelerated at a high rate of speed. The contact immediately depressed the brake pedal before crashing into a pole. The contact also stated that the same failure occurred while in a parking lot which resulted in the vehicle crashing into a handicapped parking sign which damaged the sign. A police report was not filed, the contact was not injured, and the contact was able to drive away from the scene. The contact then took the vehicle to the dealer where they diagnosed the vehicle with a transmission failure. The contact later discovered that the vehicle was placed under NHTSA Campaign Number: 22V746000 (Power Train) which she linked to her failure. The manufacturer had yet to be notified of the failure. The vehicle had been repaired under recall. The failure mileage was unknown.

Dec 15, 2022

Crash: 1

WHEELS,SERVICE BRAKES,ENGINE

1 complaint

Ever since I bought by car in 2022 brand new the car has been shaking when I press on the brakes going around 70 mph. I took the car multiple times to the dealership and all they do is resurface the rotos. One time they refused to even look at the car so I called corporate and they got the dealership to do the same thing as before. But still the car shakes. I called corporate and they said to take to dealership to once again get the rotos resurfaced (how many times are they planning to resurface the damn rotors?) I took to dealership because the car was saying it was overheating. They ended up changing the thermostat or something related to it. And I asked them to once again look at the rotors because of the issue. The guy came back and said “we didn’t look at your rotors but you need brakes and that’s $500”. They refused to guarantee me if doing the break job will fix my issue. And I’m fed up. I looked online and as it turns out, the Santa Fe’s have a lot of possible manufacture defects. Such as: -Breaking System (Shudder / Vibration Common Issue) -Cooling System (Common Failures) - Suspension & Steering Components -AWD / Drivetrain (If AWD) -Electronics & Software - TSB (Technical Service Bulletin) Audit - Turbo oil-supply pipe crack / oil leak risk -Fuel-system pipe / fuel-rail hose leak (on certain turbo models -Transmission oil-pump / transmission-system recall (power-train issues) -Rear-view / backup-camera defect (visibility / electronics issue) (this actually did happen to me and they fixed it, but they denied it was a recall when I asked if this was common. So they lied) -Trailer-hitch wiring harness fire-risk recall And possibly more issues I’ve yet to come across other owners having. These are pretty serious issues. Some causing even the car to catch fire. This is extremely worrisome and I need peace of mind. Please help me out Thank you for your time

Dec 01, 2025

ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER

1 complaint

On [XXX] at [XXX], my [XXX] daughter was locked inside my 2022 Hyundai Santa Fe (VIN: [XXX] ) while holding the Smart Key fob in the back seat. She pressed the lock button, and the vehicle completely locked — with her and the key fob still inside. This violates the Smart Key safety feature described in Hyundai’s owner’s manual, which says the car should not lock if the key is inside. That system failed. There were no warning lights or alerts. I had no way to unlock the doors. I experienced a full panic attack. I feared my child could die from heat exposure. I was forced to break the rear window to rescue her. I was terrified the glass might injure her, but I had no choice. Since then, I have been emotionally traumatized and avoid driving out of fear it will happen again. To my knowledge, this has not yet been inspected by a dealer or Hyundai. I am reporting this because the Smart Key locking system failed in a dangerous way that put my child’s life at risk. This system should be investigated for defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

May 31, 2025

STEERING,FUEL/PROPULSION SYSTEM

1 complaint

Steering made clicking sounds when turning. Injectors caused the car to run very rough!

May 21, 2025

ELECTRICAL SYSTEM,BACK OVER PREVENTION

1 complaint

The reverse camera system did not come on when reversing. It could lead to someone like a child getting hurt if they’re walking behind the vehicle. The problem was reproduced by the dealer and serviced for this issue. They confirmed it was the same problem as the recall. There is a recall for 2022 Hyundai Santa Fe’s that were manufactured in the Alabama plant. This is where my car was manufactured. For some reason, it was not included in the VINs that were recalled.

Apr 08, 2025

SEATS

1 complaint

When reaching between the seats to get a dropped item hand gets stuck on a sharp edge and cannot be pulled out. This happened to me once while driving and to my diluaghters very small hand while parked. Assistance was needed to dislodge hand.

Jan 09, 2025

POWER TRAIN,FUEL/PROPULSION SYSTEM

1 complaint

Three fuel injectors out of four have failed in a year’s time frame. Car shakes, stalls, hesitates, and is dangerous to drive. Waiting for fourth injector to fail.

Dec 29, 2024

VEHICLE SPEED CONTROL,ENGINE

1 complaint

My vehicle made 3 ringing sounds and began to decelerate from 67mph to 0 in less than 2 minutes. I had to pull over quickly to avoid getting rear ended. This incident happened twice already. I took it in to the dealer and they were not able to recreate what happened. This occurrence happened 2weeks ago.

Oct 05, 2024

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

When you go from drive to park it doesn't go into park. If you try to go to park to reverse it won't go into reverse. Has happened 3 times. Have take it in to dealership and found nothing.

Aug 12, 2024

STEERING,SERVICE BRAKES,ENGINE

1 complaint

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle lost power steering functionality and the vehicle was difficult to steer. The brake pedal was depressed; however, the vehicle failed to stop as intended. In addition, several unknown warning lights were illuminated. The contact stated that the vehicle was almost involved in three crashes due to the failure. The contact had to drive the vehicle onto a curb to avoid a crash on one occasion. The contact stated that during the failure, the rear hatch switch became inoperable. The vehicle was taken to the dealer on several occasions; however, the failure could not be duplicated. The dealer replaced several unknown sensors; however, the failure reoccurred. The contact stated that the failure had occurred six times. The contact stated that the vehicle was towed to the dealer after the first failure due to the steering failure. The manufacturer was made aware of the failure. The contact stated that the vehicle was at the dealer and scheduled for an inspection by the manufacturer’s engineer. The failure mileage was approximately 17,500.

May 20, 2024

POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

Engine light comes on and car starts jerking or when I start the car it does it and jerks and drives 5 mph. Cruise control jerks when using it and the sensors go off for no reason.

Mar 24, 2024

POWER TRAIN,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

1 complaint

While driving I could not accelerate over 35 mph on the freeway this has happened at 10 times now. While driving my parking brake will come on causing me to stop immediately. This is a huge safety risk not only to me but the people in my car or driving around me. My vehicle has been brought to dealerships multiple times and nothing has been done they can’t find the problem.

Mar 20, 2024

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

[XXX] Driving down road car began shaking, driving rough and wouldn't pick up speed. Check engine light came on with code P030400/POWERTRAIN/EMS/Odometer 46,056. Car towed to Hyundai in Gainesville, GA. Tech found Cylinder 4 misfire and Cylinder 4 was replaced. [XXX] Driving down Highway and car began shaking, driving rough and wouldn't pick up speed ,again. Check engine light with code P030300/POWERTRAIN/EMS/Odometer 47,176. Car driven to Hyundai in Gainesville, GA. Tech found Cylinder 3 misfire and Cylinder 3 was replaced. [XXX] Driving down highway and check engine light came on. Car was running okay. Code P219CFO/POWERTRAIN/EMS/Odometer 47,315. Car was driven to Hyundai in Gainesville, GA for diagnosis. Tech found Cylinder 1 Air-fuel ration imbalance, [XXX] internal GDI injector leakage and parts were ordered. Replaced 2 fuel injectors, high pressure fuel pipe and 2 rail bolts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mar 18, 2024

POWER TRAIN,UNKNOWN OR OTHER

1 complaint

3 different times in last 3 weeks the car seems to lose power while I’m driving. It will not go above 35-40mph even though I’m trying to accelerate. No warning messages. I had to go slow with my hazards on until it eventually slowly returns to speed. Very scary on the highway.

Feb 18, 2024

STRUCTURE,FORWARD COLLISION AVOIDANCE

1 complaint

automatic parking brake does not engage. Brake is totally not functional

Dec 06, 2023

UNKNOWN OR OTHER,ELECTRICAL SYSTEM

1 complaint

The horn is not working. I looked on google and it says that the manufacturer does not know about the problem and other cars are not working.

Oct 31, 2023

UNKNOWN OR OTHER,VISIBILITY

1 complaint

While driving on the freeway yesterday, my sunroof exploded above me. There was no rock or any evidence of anything hitting my car roof to make it explode it just happened out of no where.

Oct 30, 2023

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,ENGINE

1 complaint

I had previously filed a complaint and received an issue number 11494975 I have not been able to retrieve any information related to this number. In any event I am constantly having problems with acceleration, stalling, the car puts itself in Neutral, and on occasion has completely turned itself off at a light or while driving. I do have a video of the acceleration problem and revived an email back from Laura Nelson. This is a very serious safety issue. Hyundai is not responding to following up. I also took it to an outside mechanic to put in the computer and got a general code so there is a problem somewhere. Thank you Susan Piller

Jul 17, 2023

STRUCTURE,VISIBILITY

1 complaint

On FRI 30JUN23 while driving across country in out 2022 Hyundai Santa Fe with a panoramic sun roof with our daughter, who was on her first trip after battling brain cancer, experienced the unthinkable. Wile driving down the highway states away from home we heard a deafening explosion with glass raining inside the vehicle almost causing us to veer off the road. Upon expecting the source of the glass in was discovered that the sunroof had exploded. Were lucky to have had the shade closed at the time of the incident preventing glass to fly in the face of my daughter who was sitting in the back seat. The incident left us stranded at a Hyundai dealer in Fayetteville Arkansas forcing us to rent a vehicle to complete our tip while waiting for repairs. We were informed by the dealer that this is a known issue and to keep a window cracked to prevent pressure from building up in the vehicle. This is a searious safety issue that needs to be addressed.

Jul 16, 2023

POWER TRAIN,FORWARD COLLISION AVOIDANCE

1 complaint

First the check engine light was on and the vehicle was vibrating really bad and making a loud sound. Took it to the Hyundai dealership which claimed to repair the issue. While on my home from the dealership ( Hyundai of Slidell), which was almost hours away, the vehicle lost power while driving. Later, multiple lights were illuminated on the dashboard including the epb, auto hold, forward collision, blind spot, check engine, and oil light. The vehicle is currently back at the dealership. Hyundai has been notified numerous times about the issue. This is a safety issue that needs to be resolved. Although there are no current recalls for this issue everything Im experiencing with my vehicle are the same issues reported in previous recalls.

Jun 22, 2023

POWER TRAIN,VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

Backed out of my driveway yesterday morning on way to work, 5/17/23. Driving down my street approx 15 mph to stop sign. As i approached stop sign I pressed on my brakes to stop and my car would not stop, it immediately accelerated and proceeded toward my neighbors house which was directly in front of me. I kept hitting the brakes and it would not stop. I was able to steer away from the home, went up the curb/lawn hit a couple of cable boxes and finally hit a pretty large oak tree on the same neighbors lawn. the car was still running on impact. Had major damage done to automobile (tire blow out/rim dented/front end damage) luckily i was in my neighborhood where the speed limit is 20mph. I had the car towed to Hyundai dealership and am waiting upon inspection and the result of what caused the accident. As of now they have not given me a diagnoses. they keep wanting to say it was driver error, which is completely incorrect. I did obtain a video from my neighbor which doesn't quite show what happened but the sound on the video you can hear the engine accelerate and than right after you can hear the crash impact. I do not want to drive this suv I do not feel safe whether they fix it or not.

May 18, 2023

Crash: 1

VISIBILITY

1 complaint

The contact owns a 2022 Hyundai Santa Fe. The contact stated while having the vehicle washed, the contact became aware that the front panoramic shield of the sunroof glass was cracked. The vehicle was taken to the dealer and the dealer stated that there were no recalls for the failure. The dealer provided no assistance. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 5,480. The contact noted that the failure mileage was 4,865 after coming home from the dealer. The vehicle is scheduled for repair upon waiting for the parts to come in.

Apr 07, 2023

TIRES,ELECTRICAL SYSTEM

1 complaint

The contact owns a 2022 Hyundai Santa Fe. The contact stated that since purchasing the vehicle, the horn was inoperable. Additionally, the TPMS was offering an incorrect reading. The contact took the vehicle to the local dealer and the contact was informed that nitrogen needed to be used while inflating the tires. The vehicle was repaired but continued to experience the failure. The manufacturer had not been informed of the failure. The failure mileage was approximately 3,000

Dec 30, 2022

STEERING,SUSPENSION

1 complaint

On delivery the vehicle pulled to the left on the highway. Vehicle returned to dealer next day and 4 wheel alignment supposedly done. Car no longer pulled to left. Vehicle seemed very unstable in wet weather but owner assumed it was ok. At 3000 miles owner discovered all 4 tires wearing severely while adjusting tire pressures. Called dealer and dealership wanted a month to get back into service dept. Took vehicle to a local tire dealership for wheel alignment check. Front tires toe was -2 degrees. Rear tires plus 1.7 degrees. Owner parked vehicle when driving in icy weather became too dangerous as vehicle would try to spin out without driver input. Alignment assumed to be off from factory and dealer staff only corrected what they thought was wrong with front tires instead of doing a full re-alignment.

Dec 23, 2022

POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

1 complaint

3rd and worse instance where had loss of power. While trying to accelerate onto the highway my vehicle would not do over 30mph (highway is 60mph zone). No lights illuminated on dash that there was any issue. Impeded traffic until I could pull over. This was VERY dangerous, I was lucky to not be rearended while trying to merge on highway. Dealer has had my vehicle for a week not being able to reproduce event. No codes in computer and unable to locate any recalls.

Oct 23, 2022

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

1 complaint

We have a 2022 Hyundai Santa Fe with less than 17,000 miles. We pulled into the left turn lane at an intersection. When we stopped for a red light, the vehicle abruptly shut down all power with no warning. We tried to restart the car and nothing would work. We tried the hazard warning flashers and they did not work. Our vehicle was completely dead with no dash lights, no infotainment screen, we could not put the car in park or drive. We could not activate the emergency brake. It was as if the battery was disconnected. We were sitting in the travel lane of a very busy multi-lane roadway with no way to exit the vehicle unless we allowed it to become an errant vehicle. If my husband took his foot off the brake, the vehicle would have rolled backwards down the hill where we were stopped. After several light cycles, we were able to get a break in traffic and he was able to let the vehicle roll backwards and steer the car into a small roadside parking lot. I was able to find someone in an adjacent business who gave us a wooden chock to put under the tire so he could take his foot off the brake and prevent the car from reentering back into traffic. We called Roadside Assistance and tried unsuccessfully to restart the vehicle numerous times over the 2 1/2 hours while we were waiting for the tow truck. The tow truck driver came and was able to jump start the vehicle. This has now happened a total of 4 times in the last 4 months. The dealerships can not recreate the problem and there are no diagnostic codes because the vehicle dies abruptly. Hyundai Customer Service refuses to do anything to help with this issue because there are no codes and the tech can't recreate the issue. We can not drive this vehicle because when it happens it is very sudden and gives no warning. This could be a serious safety issue when the vehicle shuts down in the travel lane and we are unable to get out of the vehicle, activate emergency flashers or even put the car in park.

Aug 29, 2022

AIR BAGS

1 complaint

Front air bag did not deploy in accident. I was rearended in stopped position at 55+MPH by a SUV that pushed me forward causing front end collision with the stopped car in front of me. Front, rear and back passenger damage with intrusion. Towed to dealer. Bought new from Watermark Ford, Marion, IL ~3 months ago, no recalls, no other accidents. I sustained neck, head and arm injuries requiring immediate medical attention. Crash report with Illinois State Police. Auto insurance has full details and adjuster inspecting. I have pics of my vehicle and the ones causing damage.

Jul 29, 2022

Crash: 1

Injuries: 1

VISIBILITY,UNKNOWN OR OTHER

1 complaint

We purchased my 2022 Hyundai Sante Fe in July of 2021. I had about 5000 miles on the vehicle at the time. On October 15th I was driving down a 2 lane road and heard a pop, I didn't think much of it, thought it might have been an acorn that fell on my roof as the area I live in is very treesy. Later that evening when we got back in the car to leave, we noticed the windshield was cracked, probably about a six inch area. I told my husband earlier that day I heard the popping noise but did not see anything actually fly up and hit the windshield. So we proceeded to call the insurance company who told us the entire windshield would need to be replaced. We were responsible for our $500 deductible. The repair shop contacted every Hyundai dealership in the southeast region only to find out the windshields were on backorder until Oct. 31st. (red flag) In the meantime the crack has spread all the way across the windshield. We found it odd that windshields would be on backorder so we googled "Hyundai Sante Fe cracked windshields" and we were floored at the amount of stories out there with the same exact problem, not only with the Sante Fe but other Hyundai SUV models as well. I just wanted to bring this to your attention because I feel the windshields are defective and unsafe. I don't know how many people this has to happen to before Hyundai acknowledges the issue. Even if it were an acorn that fell, it should not have done the damage that it did. I still feel it was spontaneous as I did not see anything actually hit or bounce off the windshield. So here we are still waiting on the windshield to arrive at the repair shop and out $500.

Nov 01, 2021

AIR BAGS,SEATS

1 complaint

When my wife sits in the passenger seat the seat is so low she cannot see over the dashboard. When she uses a cushion the air bag off light goes on indicating she is not protected from collision. This is an obvious safety issue which my dealer claims to know nothing about and has no solution. Please contact Hyundai and have them address this issue. Thanks, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Oct 28, 2021

2022 HYUNDAI Santa Fe Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2022 HYUNDAI Santa Fe have?

What are the most common problems with 2022 HYUNDAI Santa Fe?

Where does this 2022 HYUNDAI Santa Fe problem data come from?

Other Years - HYUNDAI Santa Fe

Other HYUNDAI Models

Similar Brands