How many problems does the 2023 HYUNDAI Santa Fe have?

The 2023 HYUNDAI Santa Fe currently has 157 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2023 HYUNDAI Santa Fe?

The most common problems reported for the 2023 HYUNDAI Santa Fe are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2023 HYUNDAI Santa Fe problem data come from?

All problem and complaint data for the 2023 HYUNDAI Santa Fe comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2023 HYUNDAI Santa Fe Problems

UNKNOWN OR OTHER

26 complaints

The horn has broken 4 times. I was told that it is a design defect in the car and there is no permanent fix. Water gets in to the horn when it rains and because of the location of the horn it would have to be moved to fix it. Hyundai is aware of this safety issue and has not issued a recall because there is no permanent fix. They are supposed to be buying back my car but are dragging their feet. I'm sure this is an issue in more than just my car and it's very unsafe for the horn to just stop working.

Dec 11, 2025

Horn has needed to be replaced twice. Stops working for no apparent reason.

Nov 18, 2025

The sunroof on my 2023 Santa Fe exploded.

Nov 10, 2025

Injuries: 1

Vehicles' charging side deck will heat up any phone we put in to charge inside that slot. We brought this to the dealers attention a couple times but they stated I needed to pay a service fee to have it looked at. It began happening a few weeks after we purchased the vehicle. We have not used the port ever since.

Oct 11, 2025

I have had 6 car appointments and on my 3rd horn replacement in this car. It goes completely out and it is a safety hazard to not have any horn. It loses both the high and low pitch horn

Oct 01, 2025

+ 21 more complaints for this component

POWER TRAIN

16 complaints

The vehicle cannot pick up speed, and it is displaying the DTC- P1C2D03. This is similar to the issues that led to "Safety Recall 236 to repair a condition involving the 8-Speed Dual-Clutch Transmission (DCT) system" in earlier model years (till 2022) for certain Hyundai and Kia vehicles. NHTSA should issue a recall for 2023 model years also as Hyundai has not addressed this issue to the fullest extent in 2023 model years.

Dec 10, 2025

There was a recall on the 21-22 santa fe for a issue with the transmission oil pump failure. I have a 23 which is not part of the recall but this is exactly what happened to me and now the transmission has failed completely with 68,000 miles

Jun 15, 2025

Transmission caused vehicle to loose speed on grade posted speed 70mph I could not get over 35 Transmission stuck in 3 gear or would stay in 8th gear unable to gain speed almost got rear-ended vehicle has a 8 speed automatic transmission it will not shift properly loss of power account improper gear for speed

May 05, 2025

When accelerating from a stop, my car will not go over 20 mph. It just revs up like it’s not changing gears . I have to pull over and park it. It runs fine afterwards. This does not happen all the time. Usually it happens once a month. It’s been to the dealership 3 times. They drive it around the block and tell us that they can’t replicate the problem. Therefore, they don’t troubleshoot anything and return the car to me. I’m truly scared to drive it. I wrecked twice at a red light intersection.

Apr 23, 2025

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The contact stated that the failure reoccurred, and the vehicle was towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 55,917.

Mar 12, 2025

+ 11 more complaints for this component

ENGINE

13 complaints

Was driving at 10 MPH on highway car began to cut out run rough and produce an extremely pungent smell of gasoline.. then stalled.. vehicle serviced and low pressure fuel injector had a leak causing fuel to spill onto the vehicles starter causing it to fail as well.. both were replaced under warranty by dealer. Highly concerned about fuel leaking from injector system onto a hot engine and electrical components and the aerosolized fuel. Police advised not to start vehicle due to fuel leaking and smell.

Oct 29, 2025

My 2023 Santa Fe Limited has 3,000 mils on it. At least four times it had low speed hesitation (lags then revs up for a few seconds). It’s a problem with the DCT (Dual Clutch Tranny) Hesitation pulling onto a highway poses a significant risk of a faster car colliding into my car. I called my car dealer and the service manager said they know they are having problems with this. He said they tried everything to remedy the problem but, there is no solution. They said the only way not to have the problem is to get a different car!!! Hyundai should have a recall on this hesitation matter before someone gets injured or killed. It’s a safety issue. The last time it happened will be the date of my incident report.

Sep 29, 2025

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the first of five times that it has happened.

Jul 07, 2025

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the SECOND of five times that it has happened.

Jul 07, 2025

While driving the engine dropped to 10 mph and would not respond to the pedal inputs. It is available for inspection. Dropping to 10 mph in traffic on a roadway doing 70 mph or even 35 puts everyone on the roadway in danger. The problem was not reproduced but was comfirmed by the dealer who inspected and serviced it. There was no warning before it happened but the dash displayed many warnings and even sent out an email when the engine failed. This was the THIRD of five times that it has happened so far.

Jul 07, 2025

+ 8 more complaints for this component

ELECTRICAL SYSTEM

8 complaints

Both horns on my 2023 Hyundai Santa FE have failed 3 times. The first set was covered under warranty (3/24), the second set cost $499.64 (3/25). Now both horns are nonfunctional after just being replaced this Spring. After reviewing many complaints on the Hyundai community form, it is very obvious there is a major issue with their horns ( and not just the Santa Fe model). Twice this week I was in need of my horn to alert other drivers but instead had to make quick maneuvers to avoid an incident. My vehicle currently cannot pass a state inspection.

Dec 17, 2025

At stop sign and car with auto start stop on and at the time of releasing the brake, car was not able to start engine. Car had to be shifted to parking position to start engine.

Nov 21, 2025

horn has stopped working. Seems to be a systemic issue when looking online in Forums etc... I have scheduled the problem to be fixed and it is not a fuse issue. It will be a month before the dealership is able to get me in to assess the problem. This is a safety related issue and this needs to be addressed with the manufacturer.

Sep 05, 2025

horn has stopped working twice. Had it replaced under warranty in January of 2024. Same incident happened where horn of vehicle does not work. Seems to be a systemic issue. This is a safety related issue and this needs to be addressed with the manufacturer.

Aug 28, 2025

Every time it rains, one of the dual tone horns will fail. I have had the horn replaced 2 times. I am beginning to have a problem with the horn again after this last rain. It is a matter of time before it fails completely after a rain and becomes unusable. I feel this is a significant warning feature that MUST be reliable.

Feb 13, 2025

+ 3 more complaints for this component

FORWARD COLLISION AVOIDANCE

7 complaints

On two occasions, once at 70mph and once at 45mph vehicle suddenly lost power and displayed warning to check collision system, there were no vehicles close enough to warrant this. I had to limp the car to the side of the road as safely as possible and shut car off, wait a few minutes and restart vehicle to clear error and allow proper power/ acceleration again.

Aug 07, 2025

Emergency brakes engage while driving for no apparent reason. This has happened on several occasions over the last 6 months.

Dec 03, 2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at various speeds, the Emergency Braking System was erroneously activated, causing the vehicle to abruptly stop in the middle of the road. During the failure, the message "Emergency Braking System Engaged" was displayed. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was not contacted regarding the failure. The failure mileage was unknown.

Jul 15, 2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving at various speeds, the Forward Collision Avoidance system erroneously activated, causing the braking system to activate and the vehicle to veer to the left. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer on several occasions due to the failure however, a cause for the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 1,000.

Nov 29, 2023

When traveling along the front collision warning system is triggered even though nothing is around the vehicle. The car remains running, but there is no response from the gas pedal. I have to coast to the side if possible or stop and turn on flashers (very dangerous on interstate highway). Once safely stopped, turning off the car and then starting again reboots the system and it runs fine until it happens again randomly. The check engine light stays on for a day, but does not light up the next morning. The dealership does diagnostics, but nothing shows up as wrong. It happens so fast there is no way to take a picture or video before the warning disappears. So far I have been lucky as this has happened at least 6 times. It is dangerous and I am terrified someone will not see flashers and run into me at highway speeds.

Nov 02, 2023

+ 2 more complaints for this component

SERVICE BRAKES

6 complaints

The vehicle front brake disks are not compatible for this vehicle. The action of braking causes heating of the disks. The disks warp due to the heat. The result is when braking at highway speeds, the entire front end vibrates excessively. This is unsafe in wet or snowy conditions as this greatly decreases the braking efficiency. The first time this was observed the vehicle had 22,000 miles and the dealership machined the rotors. The second time it happened at vehicle mileage of 32,000. Once again the rotors were 'machined' by the dealership. The action of braking at highway speeds and the resulting front end vibrations is a troublesome event. If this occurs a third time, I will try to find and install non-Hyundai disks.

Oct 31, 2025

While driving to work today [XXX] on or around [XXX] on [XXX] from Riverview to downtown Tampa while doing about 68 MPH, my emergency brake deployed for about 6 seconds. The whole vehicle shook. There were no other vehicles around. Quite scary. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jul 29, 2025

Brake rotors warped. Beginning at approximately 5k miles, the steering began exhibiting a juddering upon applying braking. Over time, the juddering became more pronounced. At approximately 15k miles, I took the vehicle to the dealer. The dealer confirmed that the brake rotors were warped. The defective brake components put my safety at risk, as well as the safety of my passengers and others traveling on the road by impairing my ability to safely stop the vehicle and impairing my ability to safely operate the vehicle while braking. There were no safety lights or warnings. I am aware that there has been a technical service bulletin for this exact issue for this model/year vehicle. Neither Hyundai nor the dealer ever altered me to the possibility that the brake rotors might warp due to defective components. Hyundai has thus far refused to cover the full cost of repairs, totaling over $1,400.00.

Oct 23, 2024

Whilst driving the vehicle a number of warning lights appeared on the dashboard. This occurred after the vehicle was brought to a stop at a stop sign. There were no outside influences before or after the warnings began. The vehicle remained operable and was driving back to our residence approximately 1 mile away. I made an appointment with the local dealership to investigate the issue. The appointment was made for the following day. Whilst driving the vehicle to vehicle to the dealership on the following day the brakes became temporarily inoperable forcing me to leave the road and hit the right hand kerb. After pumping the brake pedal several times the brakes re-engaged and I was able to stop the vehicle. The dealership have explained that a rear wheel speed sensor (ABS) had failed and was sending messages to the the braking system which made the braking system inoperable. The dealership replaced the sensor and at this time the vehicle is operating as expected.

Mar 07, 2024

This hard brake peddle pressure issue started out immediately on an occasional basis but now occurs almost every morning on first start of the day. Press on the brake pedal - it's very hard to deflect - and if you don't overpower it to deflect the pedal enough to activate the brake lights, it won't start. Once you get it started the first time, brake operation will be normal for the rest of the day. A specialty maintenance blog has covered this issue comprehensively. The Hyundai Maintenance website is apparently aware of this potential problem. According to [XXX] , it is likely caused by a malfunctioning brake booster or vacuum leak and recommends taking the vehicle to your dealer for diagnosis and repairs. This is apparently a common problem across multiple Hyundai models since there are several threads on this subject on [XXX] : [XXX] [XXX] [XXX] [XXX] [XXX] I took my vehicle to the dealer where I purchased it and left it with them for a couple of days, Said they had thoroughly tested the vacuum line and found no leaks or problems and that the vehicle was performing as designed. Don't know how serious this is, but I have concerns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Dec 17, 2023

+ 1 more complaint for this component

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

6 complaints

I was travelling at 50mph a car pulled in front of me and stopped unexpetedly. I braked hard. My car began to slow, but the brake pedal went to the floor and did not slow, AFter a few seconds, the brake pedal came up from the floor and braking was resumed. I held the pedal to the floor the whole time trying to stop. It was as though the braking system failed and recovered. There was no pulsing felt on the brake pedal typical of ABS working. After my car resumed braking thte collision avoidance system took over and the car stopped just inches from the stopped car in front of me. I had just taken the car in for dealer service at 24,200 and everything was supposedly checked out as required by maintenance. I have contacted Hyundai but have not gotten a response yet.

Sep 02, 2025

In January, 2024, my vehicle (2023 Hyundai Santa Fe) started shuddering when brakes were applied at high speed, on quick or hard stops, in stop and go traffic, and especially going downhill. I had only been driving the vehicle for about 5 months. I took the vehicle to an independent mechanic, who explained that my front rotors had burn spots. He recommended that I have them resurfaced. I did not want to pay for the problem to be fixed when I believed it was a factory defect and should be covered by warranty. I asked the Mission Hills Hyundai dealership Service Department to investigate and correct the problem, because I felt that my family's safety was jeopardized by faulty brakes. They showed me the burn spots on the front rotors and recommended resurfacing. They said I could wait for the pads to wear down and do the resurfacing at the same time as the pad replacement. Their estimate for resurfacing was higher than the one from my mechanic. I found a Hyundai Technical Service Bulletin, Number 23-BR-004H, which described the exact defects of my vehicle. I returned to the dealership with the TSB in February, 2024. They replaced the two defective front rotors and front disc pads at no charge. The shuddering was no longer evident, and I thought the problem was resolved. However, 10 months later in December, 2024, I once again experienced the shuddering while braking on the freeway while going downhill and when slowing for stops from high speed. Since I had been told that the new rotors and pads were covered by warranty for 5 years or 60,000 miles, I returned to the dealership on 1/16/25 and asked them to evaluate the brakes again. They said that the front rotors again had burn spots. They once again recommended resurfacing at a cost of $249. I reminded them that there was a warranty on the new parts, they claimed that the only warranty was for the original parts that had been replaced. They agreed to resurface no charge. Please investigate and respond to my complaint.

Jan 17, 2025

Unknown issue, but the car has auto braked 2x on the interstate going 65mph. No cars were around me nor any objects in the road. It stated auto braking and sensors going off. Resolved itself within 60 seconds, but did almost cause me to be rear ended because a tractor trailer was quickly approaching me.

Apr 30, 2024

Upon braking hard and suddenly due to being cutoff on the interstate, it felt as if the antilock brakes did not properly engage but rather grabbed/grinded/scraped. Only when I let off the brake did they disengage. This happened the first time within 2 months of owning the car and with less than 2k miles on it, at highway speeds (65-70 MPH) and this sensation has happened probably 4 times in the 7 months I have owned the car under various scenarios of stopping quickly. In addition, it recently happened when driving 25-30 MPH and coming to a normal stop approaching a stop sign - where it felt as if the brake on the front passenger tire grabbed/grinded/scraped (but not on the 3 other tires). I have taken the car back for inspection at the dealer twice, neither time have they found any issues. In addition, one evening the stability control light flickered, sounded as if the dash was frying/sizzling with no reason - roads were not wet, no leaves, grass or other debris, etc. and speed was 25-30 - this happened twice within 3 miles. Dealer found no issue with car after performing visual inspection of wiring, check of system for code errors, nor driving test to reproduce issue. Had the brakes failed, I could have been in an accident causing serious harm to me/my passengers or whomever I could have hit. I believe the ABS system needs to be replaced or reprogrammed but the dealer refuses to acknowledge a problem exists. Online forums indicate similar (and worse) issues, also with people stating they cannot get a dealer to resolve their problems. This is a serious malfunction of either the electric or braking system in some capacity and should be fixed before people are severely injured or killed.

Nov 21, 2023

I was driving on the highway and the car phantom emergency braked for no reason at all.

Jun 23, 2023

+ 1 more complaint for this component

VISIBILITY/WIPER

6 complaints

On Saturday Morning (August 9th), I was driving this car with my family on I-495 heading to the shopping mall. The SunRoof glass broke suddenly without any impact from outside. I was so alarmed and exited the road and checked it. There was a crack in the front side glass. I drove back home and found that they had exploded and scattered. I drove a car to the Hyundai Car service center to claim it, but they ignored me. I claimed this on the Hyundai America site, but the answer is that they won't fix this under the warranty. This is a panoramic sunroof, and it should support our family in the car accident. But it is easily exploded without any impact from outside. It is a safety-critical issue, but Hyundai doesn't take care of this issue.

Aug 21, 2025

The windshield showed a semi circular crack on the upper center directly below the rear view mirror cluster. It happened during a day of exceptional heat there is no indication of impact and the crack is symmetrical.The plastic cover of the rear view mirror broke simultaneously with the appearance of the windshield crack.

May 19, 2025

Vehicle sun/moon roof exploded/shattered while driving on the highway with no apparent external cause. Sunroof was closed, driving middle lane, slightly below speed limit. Fortunately the material blind was closed otherwise the glass could have struck the occupants. Drove to manufacturer dealership who insisted it was a stone and not a manufacturer defect and to claim through insurance, which means a $1000 excess. I know this happens on various vehicles, noted on many forums.

Sep 18, 2024

About three weeks after we bought the SUV, a small rock hit the windshield while we were driving on the freeway, causing a quarter-sized crack. We had it repaired. A week later, two more tiny chips appeared on the windshield. We didn't even notice anything hitting the windshield, and we only drove it on city roads with normal road conditions. The windshield seems to have very soft glass and gets cracked or chipped very easily in regular driving conditions. We've never encountered windshields this weak in our 20 years of driving experience. We feel it poses a potential visibility hazard for the drivers.

Dec 02, 2023

Windshield cracks

Feb 26, 2023

+ 1 more complaint for this component

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

3 complaints

Horn has failed 4 times

Nov 19, 2025

Horn No longer works in vehicle - A major safety issue

Oct 05, 2025

The car loses power. The battery and key ignition light keep coming on. A message displays auto engine off. Please shift to n or p and start engine manually. After communicating and showing video proof of the incident, the dealership replaced the alternator and battery. The issues started around 5000 miles. The infotainment system lags and the car lags. Sometimes I am left on the road because the case refuses to cut on or off.

Apr 27, 2025

VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

3 complaints

The vehicle's software was updated on Oct 21, 2025. The software has serious flaw. When driving on slight incline on the passing lane the vehicle will apply the brakes without warning. This has happened 3 times. At times, when vehicles were following me they also had to apply the brakes unexpectedly. Had they not applied their brakes, they would have rear ended me at highway speeds. I also recall that there were no vehicles either in front or to the right ahead of me when it occurred. Also there was a guardrail on the left side of the highway at the time. This did not occur with the previous installed software. Every time this happened, the vehicle was in cruise control and driver assist was ON to keep vehicle in the lane.

Oct 31, 2025

Occasionally the cruise control when accelerating will exceed the set speed and continue to climb and I will be going 20 miles faster than the set speed and climbing. The only way to sop this is to turn cruise off, slow down and restart. My thought is it happens after I have disengaged the cruise and then when safe reengage which is done by pressing the switch straight down. In my previous vehicles I would push the control up. I may be doing this by accident and giving the system an unknown command. Whatever I am doing to create tis situation is too easy to do and creates a safety issue. this has happened multiple times.

Sep 22, 2023

Driving on highway with cruise control selected to 80 mph. Left signal is applied to travel to left lane to pass a semi trailer. When the vehicle is half way into the left lane, the automatic system applies hard braking even though the semi trailer has not been detected as too close. Vehicle slowed to 74 to 75 mph before cruise control was turned off. Vehicle behavior is a total surprise to vehicles following since the braking is unexpected on a clear road. Repeated the symptoms several times. This braking does not occur if the vehicle ahead in the right hand lane is an automobile. This only occurs if it is a large vehicle such as a semi. Moving quickly or slowly to the passing lane affects the total time the braking is applied. The slower the movement, the longer the braking is applied. Repeated this behavior at 75 mph and 70 mph with similar results.

Jun 02, 2023

SEAT BELTS

3 complaints

I was in a car accident on September 30, 2025. I was hit from behind by a dump truck and was pushed into the car in front of me. My seat belt in my Santa Fe did not tighten, and my head hit the steering wheel. There is something wrong with the seat belts. I was going to take it to the dealer to check after repairs, but my car is a total loss. Just wanted you to know the seat belts failed, and it could happen to others who own this type of vehicle. The air bag did not deploy, but my understanding is that the car has to be going a certain speed.

Oct 16, 2025

Crash: 1

Injuries: 1

Driver and passenger seatbelts not always latching or becoming unlached while driving

Sep 26, 2025

The seat belt in the middle seat of the second row did not work. And it was not fastened. So when braking, my child was thrown toward the center console. I think it's a big safety issue if the seat belt doesn't work.

Nov 05, 2024

STRUCTURE

3 complaints

The sunroof glass violently shattered/exploded while driving the vehicle. The manufacturer claims the window meets current standards and is not defective. The curtain or fabric cover was extended covering the glass panel otherwise the driver would have been covered with broken glass.

Jan 17, 2025

Sunroof exploded at highway speed glass was contained by interior fabric. Sounded like tire or gun shot . Was able to stop but frightened. Took to dealer and left it. Car has less than 3500 miles on it.

Mar 15, 2024

4/27/23 - Panoramic sunroof exploded going over a bridge. Front glass panel only. No advance warning. Shade was closed and no glass entered cockpit. Local PD responded and saw no evidence of impact or criminal activity. Vehicle is at local dealership for warranty repairs.

Apr 28, 2023

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

3 complaints

While travelling at highway speed, attempted to accelerate to pass slow traffic. Rather than accelerating, the car hunted for a gear, and wouldn't shift properly. The car downshifted but engine would not go beyond 4000 RPM and speed remained the same. This has happened multiple times. By unexpectedly not accelerating, this created a risky situation by not allowing car to pass slower traffic as expected creating a potentially dangerous situation. (Video of one of the instances exists). No warning lamps, messages or symptoms occurred up to that point. Car was brought to dealer but since no codes were contained in the computer, they said there was no trouble found.

Dec 27, 2024

Automobile approached and stopped at stop sign. When accelerator pressed to continue, car remained in place, shuddering (as if transmission were slipping),and making significant noise. Car would not shift out of gear, nor move. Operator shut off car and then restarted car. Car started normally and was in park without shuddering. Expectations at busy intersection was that it was my turn to move and did not do so, creating doubt on what my car might do next. Traffic flow was briefly confused and some drivers honked and were unsure what they should do. This could have caused an accident with an impatient driver re-ending my car, or with others going through the intersection "out of turn" and unclear on my situation. No lights or other warnings were displayed before this incident. It has not re-ocurred. I brought into the dealer who had no other reports of this type of behavior.

Dec 27, 2024

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 50-65 MPH, the vehicle stalled and decelerated to a complete stop with several unknown warning lights flashing on the instrument panel. The vehicle was restarted and operated normally. The contact drove the vehicle to the dealer where several fault codes were reset. The contact continued to experience the failure and returned to the dealer where the dealer replaced the throttle assembly and later replaced a front camera with a hard code. However, the contact stated the failure persisted. The vehicle was with the dealer but was not repaired. The manufacturer was also notified of the failure and provided the contact with a case number and a case manager to assist with the failure. The approximate failure mileage was 1,700.

Feb 26, 2024

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

3 complaints

First- it has been reported to dealer at least twice when car was in for other service. They said they could not reproduce. When speeding back up from a stop on near stop, especially in a right turn, the engine will not accelerate. After a second or two it finally takes off. During this time, I fear getting hit by another vehicle, either from behind or to the side. It is very scary and puts me and my passengers at great risk! There was no warning indication at all. The date mentioned was the most recent time, but the issue has been happening since the car was brand new. Again, NO help from the dealer.

Dec 04, 2024

There is an extreme amount of hesitation/delay from when you depress the accelerator and when the vehicle accelerates. I have had multiple incidences (both from a complete stop and while already moving) where I depress the accelerator and there is a concerning amount of lag time before the vehicle initiates movement. This has almost led to multiple accidents. This defect happens in all drive modes. This issue appears to have gotten worse over the time we have owned the vehicle. We did not notice this issue earlier on. We bought the vehicle brand new in Dec. 23.

Jul 06, 2024

Several times lately of extended crank. Saturday evening, car had been parked for 4 hours, did remote start and had extended crank of about 2 seconds. Car ran for about 3 minutes before we left. We left home and hit main road, tried to accelerate and vehicle seemed to go into limp mode. Would keep cutting the fuel out if tried to accelerate even above 40 mph. No check engine light came on. Put in neutral, could not get above about 3500 rpm. Vehicle was in smart mode where decides which mode to be in (normal, fuel economy or sport), when would try to accelerate it would try to change to sport as it knew power was not there. Was on a 6 lane highway and could not get up to speed. Finally was able to pull to side of road, shut engine off, waited a few seconds, restarted and issue went away, still no check engine light. I have contacted my local dealer, they said they have seen on another vehicle, was not sure of outcome, having service manager call me. Lots of complaints online forums of similar issues.

Jun 24, 2024

POWER TRAIN,SERVICE BRAKES

2 complaints

Front brake failure at 3k miles. Rotors warped so badly they failed to properly stop the vehicle. Vehicle shaking immensely Transmission failure at 11k miles. While vehicle is in Drive mode the transmission is stuck in first gear and will not shift. The tachometer was redlining at 6k I had to use the paddle shifters to get the transmission to shift. I was driving the vehicle as a manual transmission when I own an automatic.

May 19, 2025

Car was purchased January 21st had 3000 mile on it when service was needed for these issues. On march 23rd as I started driving my car wouldn't go above 30 mph, when pressing on the gas pedal the car wouldn't accelerate, the rpm gage would go to 4 but engine wouldn't make noise car wouldn't speed up. I put the car in park and back in drive with no improvement. I pulled off at a gas station restarted the car and it was fine. During this time the auto on off button was orange on the cluster which I had never seen it that color before. Was looked at by the dealer but wasn't reproducible. Not sure the cause, but safety was in jeopardy due to not being able to go with speed of traffic. Also a couple weeks after purchase brakes began to squeal, took car to dealer on march 28th was told brake pads were sanded and cleaned, upon leaving dealer brakes continued to squeal, car is now back at dealer, supposedly needing front rotors and pads replaced. Dealer won't drive car until rotors replaced. Safety was in jeopardy cause of possible brake failure and resulting accident.

May 09, 2023

LANE DEPARTURE

2 complaints

Vehicle does not detect motorcycles in the blind spot. I did not look over my shoulder and began moving left with a turn signal when I glimpsed a motorcycle next to my vehicle. The motorcycle quickly swerved to the left and I returned to the right lane.

Feb 02, 2024

when driving in the rain, the driver side (left) blind spot is not functional. When the right turn signal is used, the camera shows the right side of the car and the triangle on the right mirror lights up if there is vehicle in the blind spot. In the rain, the camera lens is as clear as when it is not raining. when the left turn signal is used, due to poor aerodynamics, there is a large drop of water on camera lens which prevents driver from seeing the blind spot on the left side. The large drop of water is displayed on the dash instead of the left side of the vehicle.

Jul 23, 2023

STEERING,ELECTRICAL SYSTEM,ENGINE

2 complaints

May 5th 2023 my car was broken in to.The back passenger window was broken out and the steering column was tour out .The car was undrivable. The car was towed May 18th to Nalley Hyundai.I just got my car back today Aug 11. I understand Hyundai is suing TikTok I was given a number.She said when they go to court.When .

Aug 11, 2023

Driving at 25 mph and the vehicle alerted "shift to neutral" and came to a complete stop and stalled. Had no warning, couldn't even pull to side of road. Could not start again and had to be towed.

Jul 19, 2023

ELECTRICAL SYSTEM,ENGINE,FORWARD COLLISION AVOIDANCE

1 complaint

On a clear road a sencor comes on detect comes on says detection collision. The breaks come on when you are traveling on interstate or two lane roads. When you are traveling 75 mph and breaks come on all of a sudden on the highway. We are lucky we never got hit in the back of the car going that fast. We will stop 75 to 35 mph in 10 seconds.

Dec 08, 2025

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

1 complaint

Component/System: Automatic Emergency Braking / Forward Collision-Avoidance (AEB/FCA) system and/or Electronic Parking Brake (EPB). The vehicle is available for inspection upon request. What happened: While driving my 2023 Hyundai Santa Fe (VIN: XXX) at highway speeds, the vehicle suddenly and aggressively applied the emergency braking system on two separate occasions within the same day (approximately 45–60 minutes apart). In both instances, the red emergency braking warning lights illuminated on the dashboard, and a warning sound activated. There were no vehicles, obstacles, or hazards in front of me either time. The braking was forceful and abrupt, causing rapid deceleration at highway speed. Both events occurred under normal, clear driving conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Safety risk: My safety and the safety of other drivers were put at significant risk. Sudden unintended braking at highway speeds can easily lead to a rear-end collision since the deceleration was not caused by driver input and gave no warning. Reproduction / dealer confirmation: The dealer has not been able to reproduce the issue, and no diagnostic trouble codes have been found so far. The vehicle is currently at the dealership for inspection. Inspection: The vehicle has been inspected by the Hyundai dealership, but the cause has not been identified. No manufacturer field engineer, police, or insurance inspection has taken place yet. Warning lamps / prior symptoms: During the failures, the red emergency braking indicator and audible warning activated immediately when the brakes engaged. There were no warning lights or symptoms prior to either event. Assessment: Cause UNKNOWN. The problem appears to be an intermittent malfunction of the Automatic Emergency Braking system, forward collision sensors, or related braking components. No diagnostic codes were stored. This is a serious safety issue that occurred twice within one hour and could easily result in a collision.

Nov 14, 2025

ELECTRICAL SYSTEM,ENGINE

1 complaint

On [XXX] in Rehoboth, DE, my 2023 Hyundai Santa Fe experienced a sudden and complete power failure while reversing out of a parking spot. All electrical systems shut down—including propulsion, dashboard lights, and emergency brake—causing the vehicle to roll backward into oncoming traffic. No warning lights appeared beforehand. After about an hour, power returned on its own. A passing police officer witnessed the situation and a report was filed with the Rehoboth Beach Police Department. On September 6th, Hyundai service performed a diagnostic scan of the engine and transmission systems. No fault codes were found, and the issue could not be replicated. After sitting overnight, the vehicle restarted normally and passed a road test. The dealership documented the incident but returned the vehicle without repair, stating: “Cannot duplicate concern at this time.” I was advised to tow the vehicle in if the issue recurs and, if rolling occurs again, to use a wheel chock. I purchased this vehicle new in 2023. It has only 40,000 miles and is covered under a 10-year bumper-to-bumper warranty. A failure of this magnitude—especially during a basic maneuver like reversing—poses a serious safety risk. Despite the dealership’s inability to replicate the issue, I do not feel safe operating the vehicle until the root cause is identified and resolved. I am currently in the process of escalating to Hyundai corporate for further investigation, including a buyback review, replacement evaluation, or extended diagnostic protocol. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sep 12, 2025

UNKNOWN OR OTHER,VISIBILITY/WIPER

1 complaint

AC evaporator drain design problem June, 2024 approx. 3500 miles under warranty, AC evaporator drain line backed up into the passenger front right. Brought it to service - they unclogged and drained the line at no charge. June 2025 approx. 12,K miles under warranty, AC drain backed up again. The excess water drained onto my feet as a passenger and collected under the front seat, saturating the rug area, potentially causing additional mildew and respiratory causing irritation. Service required an appointment. drained it charged $88. Filed a complaint incl Hyundai Motors ; was told the $88 charge was irreversible - cause was weather. The CAR HEALTH HAZARD seems to stem from a major design flaw The air intake is in the windshield wiper cowl resulting in wet tree and leaf debris , bird droppings, etc collect even when the car is not in use. Thus, when heat or air conditioning is activated, air comes in through the air intake and then through the difficult to acces filter recessed behind the glove box , then into the passenger area When the AC drain hose is plugged, it backs up through the dirty filter and then out, to accumulate under the passenger seat allowing more mildew. Re:My 2024 mile blockage, the water was drained, but the filter was not mentioned. In 2025 with the $88 bill, the water was drained no mention the filter. Draining the water does not correct the problem. It should be required at every service the l drain hose is checked, water drained. and filter changed at no charge until a design correction to cover the cowling or an interim solution is installed We lnotice that we have sporadic respiratory problems in the first of miles of riding in all the car From Hyundai Motor America - We expect reimbursement for the $88 service charge. Warranty draining the water and new filter annually. and an NHTSB approved fix of the problem and an NHTSB approved redesign of future models

Aug 22, 2025

POWER TRAIN,FUEL/PROPULSION SYSTEM

1 complaint

From a complete stop when pressing the accelerator, the vehicle does nothing. This can last 1 second or in longer episodes it can last 4-5 seconds. No lights on the dash. It’s random and happens sporadically. But when it’s bad, you have enough lag to count to 5 and turn on the hazards

Aug 06, 2025

VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

1 complaint

At 22000 miles wheel speed sensor went out, all control system shut down and car became unstable. At 44000 miles fuel injector went out, was driving on freeway and car started shaking and losing power, then in parking lot would not start at all, had to be towed to dealer. This is way to many breakdowns for a car with such low mileage.

Aug 05, 2025

EXTERIOR LIGHTING,STRUCTURE,VISIBILITY/WIPER

1 complaint

My wife was parking the car at carport, all of sudden unintended acceleration happened and hit through the wall. The damage on the car was $12478.57 and damaged the wall and storage on both sides of carport. My wife is scared to drive this car.

Jun 11, 2025

Crash: 1

UNKNOWN OR OTHER,BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE

1 complaint

On May 15th, I was involved in a serious accident caused by a malfunction in a rental vehicle provided by Enterprise a 2023 Hyundai Santa Fe. After reversing into a parking spot, I placed the vehicle in “Park” and exited the car to retrieve belongings from the trunk. My young son remained in the back seat. To my shock, the vehicle suddenly began to move on its own despite being in “Park.” I immediately ran to the driver’s side and jumped back into the vehicle in an attempt to stop it. I pressed the brake pedal multiple times, but the car would not respond. I also pressed the “Park” button repeatedly, yet the vehicle continued to move uncontrollably. The steering wheel was unresponsive, and I was unable to redirect the vehicle or bring it to a stop. The car ultimately crashed into two other vehicles. During the collision, one of the vehicles pinned my left leg in its door, causing physical injury. I am now dealing with both physical and emotional trauma as a result. To be clear, this incident occurred on a flat surface. No airbag deployed upon impact, and there were no warning signs or alerts from the vehicle beforehand which is highly concerning, especially for a modern electric/hybrid vehicle. This car presents a major safety hazard and, in my opinion, should be recalled and removed from service immediately before it causes a fatality. I have contacted Enterprise multiple times to report this issue and urge them not to rent this vehicle to anyone else.

May 29, 2025

Crash: 1

Injuries: 1

UNKNOWN OR OTHER,ENGINE

1 complaint

On [XXX] I was on [XXX] in Houston, TX southbound in the Woodlands area when my vehicle warning light for overheating went on. I pulled over on [XXX] and contacted Vehicle Assistance and the vehicle was towed to my dealer, Northwest Houston Hyundai. There was damage to a tube in front of the radiator and a/c condenser. The damage to the tube was approximately 1/16 of an inch in diameter and supposedly was caused by debris entering through the front grille which is designed like a large egg carton. The dealer spokesperson informed me that they had seen many vehicles like mine (2023 Santa Fe) with the same type of damage. I have been trying to settle this with Hyundai but they feel it is normal road damage and that the wide open grille design that allows it is not their problem. I can't even get them to approve a third party screen to protect the engine radiator from further design. They will not answer the question as to whether or not installing this item will void the warranty or not. It's dangerous to break down on a manor highway in a manor city particularly for us senior citizens. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

May 23, 2025

POWER TRAIN,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

1 complaint

Early March 2025 the vehicle was put car in park, got out of car to close yard gate, turned around to walk back to car but car was rolling forward and hit the flat bed trailer causing approximately $5000 in damage. It was put in park before getting out but jumped gear before getting back in. Another common problem is slamming the emergency brake on when attempting to drive. Was at a red lite left turn stop sign with foot on the brake. When the light turned green took foot off brake & put foot on accelerator to go forward, the car slammed the emergency brake on. This has happened approx 6 times in the 1-1/2 years of ownership.

May 19, 2025

Crash: 1

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

1 complaint

On [XXX], a 2023 Hyundai Santa Fe SEL (VIN: [XXX] ) spontaneously caught fire ~8 hours after parking, per fire report (Walla Walla Fire Dept.). The fire destroyed the hyundai santa fe sel engine compartment and totaled 5 vehicles with a total value of over $400,000 not including personal property to the parties involved. I was not the Hyundai’s renter/operator; the vehicle was rented by a third party from Enterprise. Despite no active recall for this VIN, the vehicle contained: Mando ABS module, Mando EPS module similar to known defective parts of the same year, and Hyundai Mobis tow hitch harness, all of which have known defect/recall history in similar make/Model equivalent vehicles. This case may involve VIN exclusion errors or latent product defects similar to recent defects INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

May 08, 2025

Fire: 1

UNKNOWN OR OTHER,BACK OVER PREVENTION

1 complaint

My car won’t shift on the highway and all of a sudden I can’t drive more than 40mph. It also has not wanted to let me press on the gas and make it go as I’m driving bc Its jerking 4 or 5 times before it’ll register and go. Also, not too long ago, I was in a parking lot and went to leave and my car never notified me that there was a huge pillar next to me and I crashed into it, it was in my blind spot and couldn’t see it. My car has had many many other issues in which I can’t list, but I truly bought a lemon.

Apr 15, 2025

AIR BAGS,FORWARD COLLISION AVOIDANCE

1 complaint

I had adaptive cruise control on and debris hit my windshield and I went into the rumble strip and eventually into the guard rail where the car essentially pingponged from there until it eventually stopped when the metal hit the front. It appears the emergency brake did not activate and the lane keep did not activate. My air bags did not deploy.

Mar 20, 2025

Crash: 1

Injuries: 1

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

The car has shut down unexpectedly for at least six times while driving at roads and highways. When this happens, engine stalls and nothing works and all alarms and check lights turn on and activated. Driver has to pull the car to the roadside which cannot be imagined when in a highway with all cars driving at 65-70mpH and the car suddenly slows down to stop. The other problem is that when the car is turned off and on again, all alarm and faults go away, and it can be driven again! It clears all safety and alarm checks and lights and behaves like nothing has happened. Car was bought on June2023. The first incident happened on Aug2023 and the next one on Sep2023. The next incidents on Feb2024, Sep2024, Nov2024 and the most recent on March 2025. The car has taken to the Sport Durst Hyundai dealership (Durham, NC) after incidents, however dealership did not perform any repairs in first four times claiming they could not duplicate the incident! (service reports attached for 3) After the third incident, we opened a case with Hyundai company trying to invoke the Lemon law, but our request did not go through despite all evidence we provided. Shamefully, their final suggestion to us was to sell the car! This was around March/Apr 2024. (Final decision letter attached) On fifth time, the driver did not shut down the car and towed it to the dealership while leaving electrical system on. They checked the car and claimed they found the cause and changed a part from car claiming it has been fixed. This was on Nov.2024. At the time we did not notice but, apparently that was a lie to make us quiet. The last time (sixth time) the same incident happened on [XXX]. The car was towed to dealership and is left there. We do have all screenshots from engine failures, although the dealership tried to wipe the history at some point. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mar 13, 2025

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM,FORWARD COLLISION AVOIDANCE

1 complaint

The accelerator stuck and the vehicle crashed. The vehicle is totaled. It happened [XXX]. No one has yet inspected the vehicle. I notified Hyundai about 5 days ago. The phone number of the towing company is 516 433 1011. The following link is a YouTube video of the accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Feb 24, 2025

Crash: 1

Fire: 1

Injuries: 2

WHEELS,SERVICE BRAKES

1 complaint

I purchased my 2023 Santa Fe brand new off the show room floor in Jan 2024. After about 6k miles when braking on the highway the entire vehicle would shudder and shake including the steering wheel. I took it into the dealership where I was informed this is a KNOWN ISSUE with this year/make/model with the rotors. They claimed they would turn the rotors but if the issue persists they would replace them. About 2k miles later (apx 2 months) the shuddering happened AGAIN. So I made an apt to get them replaced where the new service tech tried to tell me again this is a KNOWN ISSUE but now I would be responsible for a $250 replacement of the rotors. I refused to pay as they are within the 12k or 1 year warranty and they refused to replace them. That service tech also said the day prior he had to deliver that news to 4 OTHER patrons about the replacement of their rotors. I feel extremely unsafe in this vehicle and the issue is still not fixed as I have a claim in process with the manufacture directly. The claim was put in on 12/7/24 where I was told I would be contacted within 2-3 BUSINESS DAYS by a manager due to my claim being escalated. It is now 12/15/24 and still NO CONTACT from Hyundai. The vehicle shuddering is increasingly worse and worse and I feel very unsafe in this suv.

Dec 15, 2024

POWER TRAIN,STEERING

1 complaint

Shuddering Issue with Current Vehicle: - Problem: Progressive shuddering during take-off, accelerating, slowing down, and braking uphill.

Dec 07, 2024

SERVICE BRAKES, HYDRAULIC

1 complaint

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while his wife was driving at approximately 65 MPH and depressing the brake pedal to slow for a vehicle that had passed and switched into the lane she was driving, the vehicle was shuddering. The contact stated that as soon as she had stopped depressing the brake pedal the shuddering ceased. The contact stated there was no warning light illuminated. The contact stated that the shuddering when the brake pedal was depressed was intermittent but was recurring at various speeds while slowing down. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 18,756.

Oct 24, 2024

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

1 complaint

Currently have 518 Diagnostic History Codes (DTC)in memory. Additionally, I have 3 Active DTC’s. The codes are: DTC C160C87 DTC System CHASSIS DTC Sub System LKAS, and DTC C160C87 DTC System CHASSIS DTC Sub System SCC, and DTC C163881 DTC system CHASSIS DTC Sub System SCC FIRST OCCURRENCE: during actual assembly in Montgomery, AL plant. I have asked three Hyundai Service dealers for help. All have tried. Noting noted that contributes to the issues above. At first, my dealer replaced the front camera. Was told it was a heating issue. I have contacted Hyundai BLUELINK service for help. An information report was filed, TWICE. The first report I received feedback that Hyundai’s engineers had corrected the issue. On the following day, the codes returned. A second concern was filed with Hyundai BLUELINK. Hyundai Motor America Case#: [XXX] to wit: “Thank you for contacting Hyundai Motor America. We are in receipt of your e-mail and one of our representatives will get back to you shortly. Sincerely, Hyundai Motor America” Is my vehicle going to fail and cause me injury while operating it on an Interstate highway? This is quite concerning as I drive my car. All I want from Hyundai is to get this issue repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Oct 23, 2024

UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

1 complaint

The forward collision warning system engages and slows the car, often very abruptly, when on the highway and only when cruise control is on. It happens after we have been on the highway for a few hours, thus the dealer cannot reproduce the incident. It happens a few times on every road trip and is very disturbing when there are no other vehicles or obstacles in the road or nearby. We have reported this to the dealer several times and they can find nothing wrong. I provided a photo to the dealer of the dashboard showing the cruise control on, the forward collision system DISENGAGED, and the forward collision warning activated. Dealer states they have recalibrated the system but can replace no parts unless a part is found to be faulty. The latest suggestion yesterday from the dealer was to "get out" of the car before the issue gets worse.

Sep 20, 2024

POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

I was driving the car moving in reverse to exit my driveway. I placed the car in Park and while the engine was running I exited the car. Upon exiting the car, the car immediately started to roll forward and crashed through my garage door leveling it to the ground. The car continued moving forward into the garage and came to a stop blocked by built in shelving at the back end of the garage. I could have been injured had the car started to roll while I was exiting the car or had some been in front of the car. No warning lamps or messages prior to the incident. The car has a safety feature if moving in Drive or Reverse and the driver door is opened the car shifts into Park. That feature failed. The car was inspected by a Hyundai dealer and claim no error codes found and dismissed any other information as provided in this report

Sep 18, 2024

Crash: 1

ELECTRICAL SYSTEM,WHEELS,ENGINE

1 complaint

Driving up steep hill to my mom’s house car would not drive up, as it hesitated I pressed gas pedal to no avail. I turned off car, got out & nothing was blocking me. Turned car back on & accelerated, this time it went forward.

Jul 21, 2024

WHEELS

1 complaint

Tire inside sidewall blew out on rear right tire. No curb, no pothole. 40mph speed

Jun 19, 2024

TIRES

1 complaint

I was driving at around 11 a.m. on a city road at about 30 miles per hour when front passenger tire suddenly popped and car began to swerve almost colliding with vehicle in adjacent lane. The TPMS alert showed up on dashboard after the tire popped. There were no potholes or any objects that the car hit. The car along with tires had been inspected during routine maintenance at the dealer five days prior to this incident and no issues were found on tires or any lights on the dashboard. There were also no symptoms leading up to the tire suddenly popping. I contacted the manufacturer who referred me to an authorized center. After submitting the claim at the authorized center, they provided a replacement 255/45R20 at 50 percent discount.

May 24, 2024

ENGINE AND ENGINE COOLING,STRUCTURE

1 complaint

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the vehicle was overheating while driving. Additionally, the contact stated that upon noticing that coolant was leaking onto the ground, he opened the hood and discovered that coolant was leaking from the radiator. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that a foreign object had struck the radiator, causing coolant to leak into the engine compartment. The dealer informed the contact that a failure caused by a foreign object was not covered under warranty. The vehicle was not repaired. The contact stated that upon examining pictures of the failure provided by the dealer, he noticed that there were rocks stuck in and near the radiator. The contact determined that the large gaps of the front grill were allowing foreign objects to strike the radiator. The manufacturer was notified of the failure and a case was opened; however, the case was later closed. The failure mileage was approximately 11,591.

May 07, 2024

FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

1 complaint

I've been driving in Arizona on southbound [XXX] just south of [XXX] and noticed an issue that is very odd. I have a 2023 Hyundai Santa Fe that has Highway Driving Assist that does both speed control and distance from the vehicle ahead of me and Lane Keeping Assist. After I pass [XXX], but before an overpass for [XXX], my vehicle, if those systems are on, goes haywire and all those safety systems turn off. I have experienced it on at least 3 of the lanes on that stretch. It happens both early in the am and later regardless of sun. It doesn't happen on northbound. As more cars have these features, this interference should be looked in to. I have not experienced this on any other of our highways. Here's a link to the the rough location. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

May 03, 2024

Carry Handle, Shell, Base,Chest Clip, Buckle, Harness

1 complaint

The harness does not stay tight on the child’s chest. The harness was adjusted to the correct fit, when pulled to check the tightness the harness does not stay taught. It releases without pushing the release button

Mar 30, 2024

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

1 complaint

I have taken my vehicle back into the dealership because my car will sometimes unlock itself, I am constantly having to check the doors to make sure they are still locked and most of the time it has unlocked itself. Most of the time I hear it unlocking as I am walking away. It is very disturbing. It also beeps as if another vehicle is going to crash into me and most of the time there aren't any vehicles anywhere near me. The phone charger does not work, i have been having issues with this from the beginning. The steering wheel also says I have to put my hands on the wheel when I have them on the wheel. I have a video of the car going a lot of rpms and it barely moved, a golf cart passed me up. The car also locks up sometimes when I am backing up. I drive my parents to San Antonio for their Dr. appointments and am a little fearful of staying stranded either direction. My father is very ill and I am their driver. The dealer insists my car is the only one having these issues but I have read on reddit and other platforms of other Santa Fe's with similar issues. These issues do not occur ALL THE TIME, but this does occur at the most inconvenience time.

Mar 12, 2024

VISIBILITY

1 complaint

The contact owns a 2023 Hyundai Santa Fe. The contact stated while driving 70 MPH, the panoramic sunroof exploded. The panoramic sunroof glass and the shades were closed. No warning light was illuminated. The vehicle was taken to the dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 9,100.

Mar 05, 2024

EXTERIOR LIGHTING,UNKNOWN OR OTHER

1 complaint

Incident: I have been almost rear ended numerous, numerous times despite having my turn signal on an appropriate distance from my turning point. Safety Issue: The rear signal lights are small and are only located on the bumper. The location of these signal lights are way too low for most driver's to even notice them! The signal lights also look like reflectors on the rear bumper especially in broad day light, making the detection of a signal even more difficult! I do like the Santa Fe, it is my second one, but had I known that the turn signal lights were located where they are, I would have NEVER purchased this vehicle as the risk of getting rear ended is too high.

Feb 16, 2024

POWER TRAIN,ENGINE

1 complaint

While merging into the highway at approximately 49 to 52 mph, acceleration was applied to merge into the highway between moving vehicles. The vehicle responded by greatly increasing the rpm but not applying the power to the wheels. The engine revved up with very little acceleration. After 5 to 8 seconds, the power was finally transferred to the wheels and the vehicle sped up. The vehicle behind me had to apply the brakes since I basically cut them off. This was the second incident of this type.

Feb 02, 2024

UNKNOWN OR OTHER,VISIBILITY

1 complaint

Sunroof exploded while traveling at highway speeds causing glass to fall into the cabin. No impact from rocks, just exploded out of nowhere. Massive loud explosions sound

Dec 28, 2023

POWER TRAIN,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

1 complaint

This same scenario has happened 3 times since I purchased this vehicle - first event at mileage of 6273, 2nd event @ 7586 miles, and 3rd event @ 12,506 miles. All events were the same - while driving, dash board light start to flash and the vehicle looses all ability to accelerate. For each event, we have been able to coast out of traffic, turn the car off & restart. Once the car is restarted the acceleration works again, but the check engine light remains on along with an error code of P065312 Possible Power Train Issue. We have been very fortunate each time that we were on a road where we were able to coast out of traffic, but if this happened on a busy Interstate or Hwy traveling at high speeds we could have been rear-ended. The vehicle has been to the dealership twice for service and no problems have been found. The vehicle will be returned to the dealership tomorrow for 3rd service attempt.

Dec 19, 2023

VISIBILITY/WIPER,VISIBILITY

1 complaint

Windshield started to crack after 150 miles on the car from driver side spreading across whole line of sight. No visible or audible rock hit the windshield

Dec 16, 2023

EXTERIOR LIGHTING

1 complaint

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving at night with the low beam headlights illuminated, there was a dark shadow present in the top section of the illuminated light field causing a visibility hazard to the driver. The vehicle was taken to the local dealer who confirmed the issue was present but informed the contact that the headlights were operating as intended. The manufacturer was made aware of the issue. The failure mileage was 10.

Nov 17, 2023

ENGINE,ENGINE AND ENGINE COOLING

1 complaint

The contact owns a 2023 Hyundai Santa Fe. The contact stated that on two separate occasions while driving at approximately 65 MPH, the vehicle decelerated. The check engine warning light illuminated, and a message displayed on the infotainment screen indicating “Engine System Emergency, Take Vehicle to the Nearest Dealer”. The contact was able to veer the vehicle into a parking lot where it was idled. The vehicle was then taken to the dealer where the contact was informed that no appointments were available; however, the technician used a code reader that retrieved message: “5 Volts drop to the ECM”. The contact stated that the technician then pressed the START/STOP button to restart the vehicle and reset the check engine warning light. The contact stated that he was able to drive the vehicle back to his location where he parked the vehicle. The following day he restarted the vehicle however, the failure recurred. The dealer was notified of the failure and the contact was advised that if the check engine warning light was not illuminated there was no need to have the vehicle diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, but no further assistance was provided. The failure mileage was approximately 1,108.

Oct 16, 2023

SERVICE BRAKES, AIR,ELECTRICAL SYSTEM

1 complaint

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving approximately 35 MPH, the downhill assist, traction control, auto stop, blind spot, and ABS warning lights illuminated. The contact was able to pull over and called the local dealer and was informed that the vehicle was safe to drive. While driving at an undisclosed speed, the brakes independently activated. The vehicle was taken to the local dealer, where it was diagnosed that the wheel speed sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 2,000.

Jul 27, 2023

AIR BAGS

1 complaint

I was recently involved in a front side swipe accident where a person ran a red light and hit me while I was passing through an intersection. The impact was all in the front of the vehicle where the air bag had deployed. The air bag caught on fire within seconds after it had deployed. Thankfully I was conscious to where I was able to unbuckle my seat belt quickly and someone came to my aid quickly enough to where I was able to exit the vehicle safely.

Jul 08, 2023

Crash: 1

Fire: 1

Injuries: 1

UNKNOWN OR OTHER,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

1 complaint

Over the last Tom th, I have encountered some pretty scary issues with my brand new Santa Fe purchased in April. Last week, while driving, after I turned on adaptive cruise control, the system alerted me that “smart crusade control conditions weren’t met” and kept trying to engage the front left brake — this occurred three days in a row. After turning off the smart cruise control and entering residential roads, the front left brake tried to engage in a manner that seemed consistent with ABS issue. I brought car in two days later to Dublin Hyundai and they said they couldn’t find anything wrong with it. I picked the car up yesterday morning and then last night while driving on the highway, it alerted me that I need to “check highway drive assist system” and a warning light came up. After about 5 minutes, the car jerked me incredibly hard to the left on the freeway and then athe light turned off. Then two days ago, I was driving my car on the highway the car randomly said “emergency braking system activated” twice, while going 70 on the freeway in the middle of nowhere. This was while driving safely and no cars nearby either time. I looked online and it appears this is a problem that’s occurred in many Santa Fe’s, so there is clearly an issue with manufacturing (which I’m assuming is the same case as the previous issues I’ve run into).

Jul 06, 2023

TRAILER HITCHES

1 complaint

2023 HYUNDAI SANTA FE- Consumer states: I saw the notice on TV regarding a recall on my specific vehicle for the trailer hitch issue. I immediately contacted my local Hyundai dealership and scheduled an appointment. The Service Department concluded that my vehicle was included in the recall, I was told that they had not yet received a recommendation from Hyundai on a remedy for this fire hazard. My invoice indicates "your vehicle does have a Genuine Hyundai Towing hitch and 4-pin harness installed, there is currently no remedy available however you can continue driving the vehicle, but it is recommended that you park the vehicle outside until a remedy has been performed.April, 2023, I called the Hyundai Corporate Office and was assigned a case manager, Rohan. I suggested that Hyundai buy back the vehicle, with 5000 miles on it, because if I cannot tow my boat, it's useless to me, and also because I cannot park the vehicle in my heated 3 car attached garage. Rohan said he would try to find a local business to install a new hitch. I would have pay for it and submit the bill to Hyundai for reimbursement. The next time I heard from Rohan, he instructed me to find a local business to install the hitch. I did contact a couple local businesses and they all indicated that they wanted nothing to do with the Hyundai recall. My question to Rohan was, if he thought a private business could do the fix, why hadn't Hyundai come up with a timely fix, given the potential devastation that the outcome could have if a fire did occur. At the end of April, 2023, Rohan stopped accepting and responding to my calls. I believe that Hyundai has failed to timely remedy the towing hitch issue which, according to Hyundai, may ignite a fire even with the ignition turned off. Hyundai has known that these issues existed well before it was announced on TV in March, 2023 but did not officially notify the owners of the vehicles until the end of May, 2023. It is very unnerving driving this vehicle knowing this is the one that could catch fire anywhere, anytime! This should be considered for a Class Action Law Suite or a Wisconsin Lemon Law Case.

Jun 26, 2023

VEHICLE SPEED CONTROL

1 complaint

The contact owns a 2023 Hyundai Santa Fe. The contact stated that the RPM would be elevated while the vehicle was idling. The failure recurred while the brake pedal was depressed. There were no warning lights illuminated. The failure recurred approximately 3-4 times within 30 days. The failure recurred approximately 15 times within 6 months of owning the vehicle. The contact took the vehicle to the dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 12.

Jun 05, 2023

POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES

1 complaint

2023 Hyundia Santa Fe bought brand new from the dealership. During the course of the last month and a half the vehicle has done things with unknown origin. The panic alarm will randomly go off when the vehicle is turned off, no one is in it, or even near it. By locking the vehicle with the remote, the alarm will tend to go off about 20-30 seconds after the vehicle is locked and will sometimes not stop until the vehicle is restarted. The transmission will shift very roughly almost to the point that it feels like you are driving a manual transmission vehicle. The transmission lags in gears between 60-70 miles per hour and you feel a very rough back and forth shifting with in the transmission. Next the emergency break would engaging and then not releasing or reengaging when parked on a hill, flat service or anywhere. The break light on the dash would light up, blink, then it would go off, making it unknown if the emergency break was acting engaged or not. The dealership I purchased it from did replace the EMS module along with breaks and rotors on the vehicle. The auto shut off or the idle shut off will also randomly work, and not work. it will cut on and off even if the button is pressed to shut it off or prevent it from coming on. Now the air condition, along with the heat and heated seats has started to not work, randomly cut on, will not cut off etc. While driving i have had the heated seats turn on, along with the heat and not go off, nothing would cut off until the vehicle was physically turned off and restarted. No codes have ever been displayed or found by the dealership.

Apr 25, 2023

FUEL/PROPULSION SYSTEM,POWER TRAIN

1 complaint

Stopped at left turn lane light. Light turns green and vehicle engine revolutions increase as I press on gas pedal but car does not move. Cars behind me lean on their horns and take evasive maneuvers to go around me. Car finally goes very slowly and transmission disengages in middle of left turn leaving vehicle in middle of intersection with oncoming traffic. Luckily everyone stopped and vehicle very slowly moved through the intersection to side of road. Vehicle is brand new and in my possession less than 48 hours. Vehicle is at dealership for troubleshooting.

Apr 18, 2023

BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE

1 complaint

I bought this Lemon on 1/14/2023. The front collision detection doesn't brake to avoid collision. The Emergency brake will engage on it's own, and it has to be manually disengaged. The parking assist feature will automatically disengage and is unable to engage it. The middle seat in the back seat headrest obstructs a major portion of the rear window, obstructing the driver's view. It is not the headrest pictured in the Owner's Manual. It has been in the shop twice. It has been in the shop for 10 days and counting of the 34 days I have owned this lemon of a vehicle. The car was taken to the dealer for repairs but consumer was told the vehicle functioned properly. The consumer stated the car was still malfunctioning so vehicle was taken back to dealer for repairs and still being assessed.

Feb 21, 2023

VEHICLE SPEED CONTROL,VISIBILITY/WIPER,FORWARD COLLISION AVOIDANCE

1 complaint

I purchased this SUV new and noticed an issue with the automatic intermittent wipers. The dealership has replaced the windshield sensor and issue is now unreliable at best. Service department told me to simply wipe the sensor off or pour water onto the sensor to get the wipers to work. That seems to work for about 3 wipes and then stops again. Also, the driver seat changes position by itself while driving, and the advanced cruise control failed to provide any braking and almost caused me to rear end a stopped car in freeway traffic. Additionally the advanced braking system does not work at all... I had the salesman check the settings and they are turned on, but do not provide any braking function. The alert system does provide a warning if a car turns a corner in front of me, but fails to take any action.

Dec 23, 2022

2023 HYUNDAI Santa Fe Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2023 HYUNDAI Santa Fe have?

What are the most common problems with 2023 HYUNDAI Santa Fe?

Where does this 2023 HYUNDAI Santa Fe problem data come from?

Other Years - HYUNDAI Santa Fe

Other HYUNDAI Models

Similar Brands