2003 VOLKSWAGEN EuroVan Problems

Complaints Reported

Complaints by Component

ENGINE AND ENGINE COOLING

5 complaints

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN EUROVAN. WHILE THE VEHICLE WAS PARKED OR IDLING, THERE WAS A STRONG ODOR. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A LEAK IN THE MANIFOLD, WHICH CAUSED EXHAUST FUMES TO ENTER THE VEHICLE THROUGH THE AIR INTAKE. THE MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 92,000. THE VIN WAS NOT AVAILABLE. ..UPDATED 08/22/17 *BF *TR

Jan 03, 2017

I HAVE A 2003 RIALTA QD. TWO DAYS AGO IN A VERY REMOTE AREA MY RADIATOR FAN EXPLODED AND TORE UP THE SHROUD, RADIATOR, HOSES AND BELT. I UNDERSTAND THESE FANS HAVE BEEN A PROBLEM AND ARE ON BACKORDER AROUND THE COUNTRY. I GUESS THIS IS A VW PROBLEM. THERE HAS BEEN A RECALL ON PRIOR YEARS BUT WHY HASN'T THERE BEEN A RECALL ON OTHER MODEL YEARS AS IT APPEARS THIS IS AN ONGOING PROBLEM? IF I HAD OPENED THE HOOD IT IS VERY POSSIBLE THAT I COULD HAVE BEEN BURNED, BLINDED OR WORSE.

Aug 20, 2011

ENGINE FROZE 1 MILE AFTER THE OIL LIGHT CAME ON. NO SMELLS, WARNING LIGHTS, NOISES BEFORE THE OIL LIGHT CAME ON. THE OIL LIGHT CAME ON FOR THE FIRST TIME EVER THEN I DROVE TO THE NEAREST GAS STATION. CHECKED THE OIL, AND IT WAS DRY. PUT IN A QUART OF OIL AND DROVE IT TO SEE IF LIGHT WOULD GO OFF - IT LOCKED A COUPLE BLOCKS AFTER THAT. WHY DIDN'T THE OIL LIGHT COME ON SOONER? THE OIL LEVEL WAS VERY LOW , ENOUGH TO MAKE THE ENGINE FREEZE. WHY DIDN'T THE OIL LIGHT COME ON SOONER? *AK

Jan 24, 2006

ON SEPT. 22ND, 2005, OUR 2003 VW EUROVAN BROKE DOWN ON THE SIDE OF THE ROAD. WE HAD IT TOWED TO OUR LOCAL DEALERSHIP, ROGER JOBS VW IN BELLINGHAM, WA. A FEW DAYS LATER, I WAS INFORMED BY THE SERVICE DEPARTMENT, THAT THE CAUSE OF THE BREAKDOWN WAS THAT THE OIL FILTER CAP HAD SPLIT, CAUSING ALL THE OIL TO DRAIN OUT, RUINING THE ENTIRE ENGINE WITHIN MOMENTS. FIVE VW EXPERTS EMPLOYED WITH OR ASSOCIATED WITH ROGER JOBS VW (ANGELA MATTIX THE SERVICE ADVISER, PETER DRAKE THE SERVICE MANAGER, DISTRICT REPRESENTATIVE JUAN GARCIA, AND TWO TECHNICIANS, BOB GORSUCH AND PAUL TIEGROB), UNANIMOUSLY AGREE AND ARE UNEQUIVOCALLY CERTAIN, THAT BASED ON THEIR EXPERIENCE AND WISDOM, THE OIL FILTER CAP SPLITTING WAS DUE TO AN OVER TIGHTENING OF THE CAP BY THE SELLING DEALERSHIP (PACIFIC VW), AND, WAS NOT THE RESULT OF, AS CLAIMED BY PACIFIC VW AND SUPPORTED BY VW OF AMERICA, A STONE FLYING UP UNDERNEATH THE CAR, WHICH WOULD CLASSIFY IT AS DAMAGE DUE TO ENVIRONMENTAL CAUSES, THEREBY EXCLUDING IT FROM COVERAGE UNDER THE LIMITED NEW VEHICLE WARRANTY. AS POINTED OUT BY THE FIVE VW EMPLOYEES LISTED ABOVE, THE UNDERSIDE OF THE VEHICLE IS STRONGLY PROTECTED AGAINST SUCH OCCURRENCES WITH MULTIPLE LAYERS OF HARD PLASTIC SHIELDS, ALL OF WHICH SHOW NO SIGN WHATSOEVER OF ANY KIND OF ENVIRONMENTAL DAMAGE. THEY ALSO CONFIRMED THAT THE OIL FILTER IN THE CAR WAS A FACTORY VW OIL FILTER. WE BOUGHT THE CAR (ALONG WITH A FULL WARRANTY) DIRECTLY FROM PACIFIC VW IN SOUTHERN CALIFORNIA IN THE SPRING OF 2004. ACCORDING TO THE EXPERT OPINION OF FIVE VW EMPLOYEES, IT''S CLEAR, THAT THE FAILURE OF THE OIL FILTER CAP WAS DUE TO FAULTY SERVICE ON THE PART OF PACIFIC VW, AND WAS NOT DAMAGE DUE TO ENVIRONMENTAL CAUSES. *NM

Nov 28, 2005

ON 01/09/03 I PURCHASED A 2003 VW EUROVAN & ON 01/18/09 MY ENGINE LIGHT CAME ON. ON 01/20/03 I WAS TOLD I HAD FAULTY COILS. I WAS TOLD THAT THE TWO COILS THAT FAILED WERE GOING TO BE REPLACED, BUT WITH THAT CAME A WARNING THAT I HAVE A TOTAL OF 6 COILS. WHEN I PICKED UP MY PARTIALY FIXED VAN I WAS TOLD " HOPEFULLY WE CAN REPLACE ALL YOUR COILS BEFORE THIS HAPPENS TO YOU AGAIN." WHEN I CONTACTED VW DIRECTLY THEY INFORMED ME THAT THIS WAS A LARGE PROBLEM THEY WERE HAVING COMPANY WIDE & AT THIS TIME THEY WERE ONLY REPLACING THE FAILED FAULITY COILS. AT THE DEALERSHIP WHEN I ASKED IF THIS COULD CAUSE ENGINE DAMAGE I WAS TOLD "IT COULD".I WAS SOLD A NEW CAR WITHOUT THE KNOWLADGE OF SERIOUS FAULTY PROBLEMS THAT VW CLEARLY KNEW ABOUT. I WOULD LIKE MY NEW CAR TO NOT HAVE ANY KNOWN DEFECTS. ALL 6 COILS SHOULD BE REPLACE, FOR THE SAFTY OF MY CHILDREN, MY HUSBAND, & MYSELF.

Jan 23, 2003

SEATS

2 complaints

WHILE DRIVING ON CITY STREET, THE PASSENGER SEAT HEATER CAUGHT THE SEAT ON FIRE BURNING SEAT COVER, AND PASSENGER'S COAT, FLEECE VEST AND SCALDING BACK OF PASSENGER. THERE WAS NOT A CRASH, BUT THIS EVENT COULD HAVE BEEN MORE SEVERE IF IT HAD BEEN THE DRIVER OR IF MORE SIGNIFICANT INJURY TO PASSENGER. WE WERE VERY CONCERNED ABOUT THIS EVENT BECAUSE OF SAFETY AND LOSS OF PERSONAL PROPERTY AND INJURY. WE IMMEDIATELY CONTACTED OUR LOCAL VOLKSWAGEN DEALERSHIP WHO TOOK PHOTOS AND COMMENTED THAT "THIS SHOULD NOT HAPPEN REGARDLESS OF AGE OF OUR VEHICLE AND WE WILL ADDRESS THIS RIGHT AWAY". WE CONTACTED VOLKSWAGEN'S ONLINE CUSTOMER CARE SERVICE VIA EMAIL AS ADVISED BY OUR LOCAL DEALERSHIP. AFTER A FEW EMAIL EXCHANGES, VOLKSWAGEN FINALLY COMMENTED THAT THIS EVENT IS NOT THEIR RESPONSIBILITY BECAUSE OF THE AGE AND MILEAGE OF THE VEHICLE. WE ARE MOST CONCERNED ABOUT THE SAFETY OF THE VEHICLE. VOLKSWAGEN COMMENTED THAT THIS EVENT IS STRICTLY A WARRANTY ISSUE AND CONSIDERING THE AGE AND MILEAGE OF THE VEHICLE, THERE ARE NO APPLICABLE WARRANTIES. VOLKSWAGEN COMMENTED FURTHER THAT IF WE WANT TO ENSURE SAFETY OF THE SEAT HEATERS OR OTHER ASPECTS OF THE VAN, WE MUST SCHEDULE AN APPOINTMENT WITH THE DEALER AND WE WILL BE RESPONSIBLE FOR THE COST OF THE DIAGNOSTICS AND ALL REPAIRS. *TR

Nov 18, 2013

Fire: 1

Injuries: 1

I HAVE A 2003 VOLKSWAGEN PASSAT WAGON WITH LEATHER, HEATED SEATS. I JUST NOTICED A HOLE IN THE SEAT THAT IS CLEARLY BURNT THROUGH FROM UNDERNEATH. I CALLED MY VW SERVICE DEPARTMENT AND WAS INFORMED THAT THERE WAS NO RECALL ON THIS PART. *JB I AM UNABLE TO TELL WHAT LED TO THE FAILURE OF THIS PART ASIDE FROM USING THE SEAT HEATERS ON COLD MORNINGS. THE HOLE BURNED IN THE SEAT IS ROUGHLY THE SIZE OF A QUARTER. FORTUNATELY, I WAS NOT BURNED WHEN THIS OCCURRED. I BELIEVE THIS POSES A TREMENDOUS SAFETY RISK. VOLKSWAGEN HAS DONE NOTHING TO CORRECT THIS AS OF YET. *JB

Feb 11, 2006

STRUCTURE,LATCHES/LOCKS/LINKAGES

2 complaints

THE SIDE DOOR LATCH WON'T LATCH WHEN THE TEMPERATURE DROPS BELOW FREEZING. SO THE DOOR, WHICH IS ON SLIDERS, WILL JUST SWING OPEN WHILE DRIVING UNLESS YOU HAVE IT BUNGEE-CORDED. IT WILL ONLY LATCH WHEN THE TEMPERATURE RISES OR AFTER YOU PARK IT IN A HEATED GARAGE. THIS IS A PERSISTENT PROBLEM WITH VOLKSWAGEN EUROVAN OWNERS - AT LEAST THAT SEEMS APPARENT AFTER READING BLOGS ON THE INTERNET. NO ONE AT THE VOLKSWAGEN DEALERSHIPS I TALK TO SEEM TO KNOW HOW TO FIX THE PROBLEM THOUGH THEY SEEM FAMILIAR WITH IT. IT IS REALLY DANGEROUS AND LAME THAT VOLKSWAGEN HAS NOT ADDRESSED THIS ISSUE. WE HAVE EXPERIENCED THIS PROBLEM ONLY IN THE PAST TWO WINTERS - BEFORE THAT, WE ONLY DROVE THE CAR IN THE SUMMER. NOW IT IS SO BAD IT'S PRETTY MUCH NEVER CLOSED NOW THAT IS WINTER. AND NO ON WE HAVE BROUGHT THE CAR TO CAN FIX IT. *TR

Jan 28, 2012

PASSENGER SIDE SLIDING DOOR DOES NOT LATCH FULLY, AND MAY NOT LOCK/UNLOCK, OR LATCH, AT ALL, AT TEMPERATURES BELOW 30 DEGREES FAHRENHEIT. EXTERIOR HANDLE STICKS AND DOES NOT OPERATE AT TEMPERATURES BELOW 30 DEGREES FAHRENHEIT. THIS PROBLEM MAY OCCUR TO A LESSER DEGREE AT TEMPERATURES AS HIGH AS 40 DEGREES. THIS PRESENTS A HAZARD OF THEFT/VANDALISM FOR PARKED CARS, AND MAY ENDANGER CHILD PASSENGERS, OR OTHER VEHICLES DUE TO OBJECTS FALLING FROM AN OPENED (UNLATCHED) DOOR. DOCUMENTATION OF EXTENSIVE COMMUNITY EXPERIENCE WITH THIS DEFECT MAY BE FOUND AT HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?2967817. *TR

Jan 31, 2011

SEAT BELTS

2 complaints

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN EUROVAN. THE CONTACT NOTICED THAT THE REAR, MIDDLE SEAT BELT BUCKLE HAD BROKEN INTO SEVERAL PIECES. IN ADDITION, THE REAR DRIVERS SEAT BELT WOULD NOT CONNECT TO THE BASE BUCKLE HOUSING. THE MANUFACTURER WAS CONTACTED BUT WOULD PROVIDE NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 150000.

May 06, 2010

THE PASSENGER SEAT BELT LOCKS UP AND DOES NOT EXTEND ONCE LOCKED UP. ONE HAS TO UNDO AND REEL IT BACK IN AND TRY AGAIN TO PULL IT OUT. IF IT MAKES A WHIRRING SOUND AS IT IS PULLED OUT, IT WILL LOCK UP AGAIN. THIS HAS HAPPENED TO TWO OF OUR VW EUROVANS - A 1999 AND A 2003 - SO I AM ASSUMING IT MIGHT BE A COMMON PROBLEM. *TR

Dec 13, 2008

SUSPENSION,WHEELS

1 complaint

HIT A POT HOLE ON HI-WAY AT APPROX. 70 MPH CAUSING RIGHT REAR WHEEL HUB ASSEMBLY DAMAGE. THE WHEEL BEARING OVERHEATED AND STARTED FIRE ALONG SIDE OF ROAD. THE REAR HUB ASSY. AND WHEEL WHERE NEVER RECOVERED. CLARE FIRE DEPT. AT 207 W. FIFTH ST., CLARE, MICHIGAN 48617 INCIDENT REPORT #19-000168 WAS FILED ABOUT AUGUST 22 2019

Oct 05, 2020

Fire: 1

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

THE HEATING ELEMENTS IN THE SEAT WHICH HEAT THE SEAT WHEN TURNED ON (SEAT HEATERS) CAUGHT FIRE AND BURNED THROUGH THE SEAT, ALMOST BURNING MY BACKSIDE. CAR WAS STATIONARY. WARMING UP THE ENGINE FOR ABOUT 8 MINUTES IN THE MORNING BEFORE DRIVING TO WORK.

Jun 18, 2017

Fire: 1

ENGINE

1 complaint

DRIVING ABOUT 30 MPH, STRAIGHT AND LEVEL DOWN MAIN STREET IN WOODLAND PARK , CO AND EXPERIENCED A LOUD POP, NOISE AND VIBRATION. ENGINE LURCHED TO A STOP. HARD TO CONTROL VEHICLE. WE STOPPED IMMEDIATELY. WE THOUGHT WE HAD HIT SOMETHING. TURNED OUT THE COOLING SYSTEM FAN BLADES DISINTEGRATED. PIECES (SCHRAPNEL) PUNCTURED RADIATOR, HOSES AND BELTS. FIRE AND POLICE HAD TO RESPOND DUE TO POSSIBLE FIRE AND FLUID LEAKING. VEHICLE TOWED TO GARAGE. SAME PROBLEM AS EARLIER RECALLS 1998-2000 AND 2013 (?). VW REFUSES TO PAY FOR REPAIR.

Aug 03, 2016

UNKNOWN OR OTHER

1 complaint

THE COVER OF THE COMPONENTS UNDERNEATH THE STEERING WHEEL FELL OFF WHILE DRIVING ON A HIGHWAY. IT LANDED RIGHT ON TOP OF THE BRAKE PEDAL AND GAS PEDAL. AT FIRST I DIDN'T REALIZE WHAT HAPPENED, I JUST BECAME AWARE THAT SOMETHING WAS BLOCKING MY FOOT FROM REACHING THE BRAKE PEDAL. FORTUNATELY THIS DID NOT RESULT IN AN ACCIDENT, THANKS TO A FRONT SEAT PASSENGER WHO WAS ABLE TO LOOK DOWN AT MY FEET TO SEE WHAT THE PROBLEM WAS AND PULL THE COVER AWAY. BUT IF IT HAD HAPPENED AT A TIME WHEN I NEEDED IMMEDIATE BRAKE ACCESS, I WOULDN'T HAVE BEEN ABLE TO STOP. PLEASE SEE PHOTO OF THE COVER. THIS PHOTO WAS TAKEN AFTER I WAS ABLE TO STOP. THE COVER IS SITTING ON A SEAT; IT IS NOT IN ITS NORMAL INSTALLED OPSITION.

Jan 17, 2016

ELECTRICAL SYSTEM,SEATS

1 complaint

FAULTY SEAT HEATER IN DRIVERS SEAT CAUSED FIRE INSIDE THE VEHICLE. IT IS A 2003 VOLKSWAGEN EUROVAN. IT WAS WARMING IN THE DRIVEWAY OF OUR HOME BECAUSE OF RECENT ICE STORM. WE MANAGED TO PUT THE FIRE OUT AND IT WAS CONTAINED TO THE ONE SEAT BUT THE SEAT IS BADLY DAMAGED AND THE INTERIOR OF VAN SMELL OF BURNED WIRING. *TR

Feb 17, 2011

Fire: 1

POWER TRAIN

1 complaint

TL*THE CONTACT OWNS A 2003 VOLKSWAGEN EUROVAN. THE TRANSMISSION WAS REPLACED WITHIN SIX YEARS AT 40,000 BY THE DEALER PER THE WARRANTY. THE SECOND TRANSMISSION WAS NOT WARRANTED AND VOLKSWAGEN WANTS HER TO PAY FOR $5,300. THERE WERE NO RELATED RECALLS. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 119,000.

Dec 03, 2009

ENGINE AND ENGINE COOLING,POWER TRAIN

1 complaint

VARIOUS PROBLEMS WITH 2003 GLX. *MR THE CONSUMER EXPERIENCED PROBLEMS WITH THE TRANSMISSION. THE MECHANICS SUGGESTED THAT NOTHING WAS WRONG WITH THE VEHICLE. THERE WAS AN INCIDENT WHERE THE ENGINE LIGHT HAD COME ON, THE VEHICLE STARTED SPUTTERING AND THE TRANSMISSION STARTING SHIRTING ERRATICALLY. AFTER THREE ATTEMPTS TO FIX THE PROBLEM, THE VEHICLE STILL DID NOT WORK PROPERLY. THE TRANSMISSION WOULD ERRATICALLY MIS-SHIFT AND OR BUCK. (MODEL/GLX) *SC

Aug 09, 2004

EQUIPMENT

1 complaint

NO CERTIFICATION LABELS AND INSTRUCTIONS ON AIR PRESSURE FOR THE FRONT AND REAR TIRES. DEALER STATED ,CALL THE MANUFACTURER, BUT AT THE SAME TIME CAN INFLATE FRONT TIRES AT 28 POUNDS, AND REAR TIRES AT 32 POUNDS. *AK

Aug 25, 2003

⭐

4.9/5.0

108 reviews

Frequently Asked Questions

How many problems does the 2003 VOLKSWAGEN EuroVan have?

The 2003 VOLKSWAGEN EuroVan currently has 19 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2003 VOLKSWAGEN EuroVan?

The most common problems reported for the 2003 VOLKSWAGEN EuroVan are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2003 VOLKSWAGEN EuroVan problem data come from?

All problem and complaint data for the 2003 VOLKSWAGEN EuroVan comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.