2010 VOLKSWAGEN Routan Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
239
Complaints Reported
Complaints by Component
ELECTRICAL SYSTEM
95 complaints
The contact was helping her friend who owns a 2010 Volkswagen Routan. The contact stated while driving at approximately 35 MPH, the vehicle stalled. The contact stated that the check engine and stability control warning lights were illuminated. The contact stated that the failure was a recurring failure. The contact had taken the vehicle to a local dealer and was informed that the vehicle was built by another manufacturer. The contact was then referred to another dealer. The contact was advised by the 2nd dealer that the vehicle should be taken back to the first dealer. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 11V151000 (Electrical System). The manufacturer was not informed of the failure. The failure mileage was approximately 100,000.
Apr 07, 2025
On 01/24/25 around 9pm I was leaving a friend house headed home. I took the i76 route home because it's faster. As I'm getting off on my exit, coming up on the first stop sign I start pressing down on the break pedal and all of a sudden the car engine shuts off and comes to a sudden seizure like halt. I put on my hazards lights instantly, put the car in park and proceeded to to start the car again. After like 10 failed start attempts. I decided to give it a rest and that's when I realized that there key would not come out the ignition, I had to turn the ignition back and forth twice before it was released. After that I waited about 25 minutes, and have it another shot but this time I stepped on the gas while attempting to start the car and it came back on. I went home parked and since that day the car won't turn over but everything still comes on. There are no codes, showing, no damage to the car at all it's still pretty much new. Vw says there nothing they can do because my vin is not on the recall list but I'm literally experiencing the same mechanical issued that are listed on the recall for my exact model. Can someone please offer me a solution that doesn't involve me paying for an issue that is listed on recall for free repair!!!!!
Jan 29, 2025
The key for the key switch is loose and can fall out in any position. Can come out in the off ; start; run; all positions. The van falls within the right timeline for the key switch replacement recall; but I am told it does not have the right vin #. Can you explain to me why I can not get my defected switch replaced and others can? My vin number does not determine if the switch is bad?
Apr 21, 2023
While driving the car the car shut off causing an issue with the steering and brakes. This is the second time this has happened. in trying to duplicate the issue, with the car in park and running we were able to duplicate it by wiggling the key fob while it is in the switch. We were able to do this 3x. We search out a recall notice for our year, make and model related to this issue. When we called our VW dealer we were informed that our vehicle does not have any open recalls. We contacted VW customer service and we were told the same. Our particular VIN was built in the middle of recalls related to this exact issue and no previous repairs were done. The customer service Rep could not see a reason why ours is not covered but that they go strictly by the VIN. Our vehicle was built 03/2010 and the recall numbers we are reading are 15V194000 and 11V151000. We are experiencing the same issue and our vehicle was built within the recall period so I want to understand why ours is not part of the recall for this issue.
Dec 21, 2022
We bought the 2010 Volkswagen Routtan on July 2021, the engine shutts off suddenly. We took it to the dealer and no one knows what the problem is. I was checking the value of the car and found a safety recall in June 2011 and another recall on 04/01/2015 We don't know if they took the vehicle to fix the problem. There has been 2 safety recalls NHTSA CAMPAING 15v194000 on April 2015 and the one on March 2011 NHTSA CAMPAING 11v151000 both has to Do with the ELECTRICAL SYSTEM:IGNITION:SWITCH
Oct 14, 2022
+ 90 more complaints for this component
ENGINE
20 complaints
The contact owns a 2010 Volkswagen Routan. The contact stated that the vehicle was started and driven to her destination; however, after arriving at her destination she attempted to shut off the vehicle, but the vehicle remained running. The contact stated that she disconnected the battery to shut off the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,000.
Jul 13, 2023
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED WHILE DRIVING 70 MPH, THE KEY DISENGAGED FROM THE IGNITION AND THE VEHICLE STALLED. THE CONTACT STATED THAT SEVERAL UNKNOWN WARNING LIGHTS WERE ILLUMINATED. THE CONTACT STATED RESTARTED THE VEHICLE AND PROCEEDED TO HIS DESTINATION. THE VEHICLE WAS TAKEN TO HARPER VOLKSWAGEN LOCATED AT 9901 KINGSTON PIKE, KNOXVILLE, TN 37922, (865) 691-0393, WHERE THE DEALER WAS MADE AWARE OF THE FAILURE. ADDITIONALLY, ON SEVERAL OCCASIONS, THE CONTACT WAS UNABLE TO TURN THE VEHICLE OFF. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.*DT*JB*DT*JB
May 26, 2020
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHILE DRIVING 35-40 MPH ON THE HIGHWAY, THE VEHICLE STALLED AND THE ENGINE SEIZED WITHOUT WARNING. THE CONTACT HAD TO IMMEDIATELY MOVE THE VEHICLE OVER TO THE SHOULDER. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO BOBBY BECKS VOLKSWAGEN (893 S STEMMONS FWY, LEWISVILLE, TX 75067, (855) 315-4505) TO BE DIAGNOSED, BUT THE COMPUTER COULD NOT READ THE CODES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.
Apr 23, 2019
CAR SHUTS OFF WHILE DRIVING
Feb 20, 2019
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT CALLED ON BEHALF OF THE DRIVER. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE DRIVER WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. THE VEHICLE WAS TAKEN TO GURLEY LEEP AUTOMOTIVE GROUP (LOCATED AT 5302 GRAPE RD, MISHAWAKA, IN 46545, (574) 272-0990), BUT WAS NOT DIAGNOSED OR REPAIRED. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 89,000. *TT CONSUMER STATED SHUTS OFF WITHOUT WARNING. *JB
Oct 15, 2018
+ 15 more complaints for this component
POWER TRAIN
13 complaints
MY CAR RECENTLY STARTED HAVING ISSUES SHIFTING INTO THE NEXT GEAR. TYPICALLY HAPPENS WHEN I HAVE BEEN DRIVING FOR A WHILE. ALL OF A SUDDEN IT WILL GET STUCK IN A GEAR AND IT WON'T SHIFT. THE CAR CAN BE IN MOTION OR EVEN STATIONARY (STOP LIGHT) WHEN IT HAPPENS. *TR
Jun 30, 2020
AROUND 108000 MILES, MY 2010 ROUTAN AUTOMATIC TRANSMISSION STARTED JERKING INTO GEARS 2, 3, 4. SOMETIMES IT SHIFTS SMOOTHLY BUT MORE OFTEN IT'S HARD ENOUGH TO JERK ALL PASSENGERS WHILE DRIVING. I HAVE TRIED ECO MODE WITH SAME RESULTS. DRIVING NORMAL IT SEEMS TO BE WORSE THAN WHEN SPEEDING UP QUICKLY. 3RD GEAR IS THE WORST AND IS HARD ENOUGH TO THROW YOU FORWARD CAUSING YOU TO SWERVE SOMETIMES. IT'S THE SAME RESULTS IN TOWN, ON HIGHWAY, AND IN STOP AND GO TRAFFIC. NOW HAS 129000 MILES AND GETTING WORSE. THERE ARE OTHER TIMES IT FEELS LIKE IT DIDN'T WANT TO SHIFT UP AND WOULD OVER REV BEFORE SHIFTING UP. *TR
May 07, 2020
I WAS DRIVING ON I 66 IN VIRGINIA AND GOT STUCK IN TRAFFIC DUE TO AN EARLIER ACCIDENT. CAR WENT FOR ABOUT A MILE IN STOP AND GO TRAFFIC, WHEN SUDDENLY THE CAR STARTED TO REV UP AND JUMPED INTO GEAR TO MOVE FORWARD. I THOUGHT MAYBE SOMETHING WAS STUCK, SO I PUT INTO PARK AND TURNED THE ENGINE OFF, AND RESTARTED IT. IT DID IT AGAIN AFTER DOING IT FOR ABOUT 5 TIMES, I WAS ABLE TO GET OVER TO THE SIDE OF THE HIGHWAY. I CALLED A TOW TRUCK AND HAD IT TAKEN TO MY MECHANIC. HE TOLD ME THAT I NEED A NEW TRANSMISSION. MY CAR HAD 135000. MILES ON IT. NO WARNING LIGHTS AT ALL CAME ON. MY MECHANIC HAD JUST FIXED IT TWO WEEKS BEFORE FOR THE HEATER HOSE CRACKING AFTER BEING REPLACED A YEAR AGO.
Sep 19, 2019
VEHICLE STATIONARY IN PARK. GEAR SLIPPED AND CAR DROVE BACKWARDS DOWN THE HILL, STOPPED, THEN SLIPPED INTO DRIVE AND DROVE ITSELF INTO LAKE. MY DOG CRATED IN BACK. SHE DROWNED. INCLINE WAS SLIGHT. GRAVEL. ASHE COUNTY PARK JEFFERSON NC. I WAS OUTSIDE THE CAR TRYING TO CRATE MY OTHER DOG WHEN THIS HAPPENED.
Dec 14, 2017
AUTOMATIC TRANSMISSION CHANGE OF GEARS JERKS THE VEHICLE DURING 1-3 GEARS. IN ECO MODE SAME JERKING OF TRANSMISSION. VW STATES IT IS A TOWN AND COUNTRY PROBLEM THAT A CHRYSLER DEALERSHIP MUST RE-CODE THE TRANSMISSION.
Sep 12, 2017
+ 8 more complaints for this component
ELECTRICAL SYSTEM,ENGINE
10 complaints
The contact's son owns a 2010 Volkswagen Routan. The contact stated that the vehicle would intermittently fail to start after multiple attempts, with several unknown warning lights illuminated. The contact called the dealer and was informed that they no longer serviced the model vehicle. The vehicle was then taken to an independent mechanic however, the mechanic was unable to determine the cause of the failure. The manufacturer was notified of the failure and informed her that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 95,000.
Mar 28, 2023
NHTSA CAMPAIGN ID NUMBER: 11V151000. MY CAR SHUTS OFF WHILE DRIVING IT. IT GOES INTO AUXILIARY YOU NEED TO SAFELY PULL IT TO THE SIDE OF THE ROAD AND RESTART IT. THIS HAS OCCURRED MULTIPLE TIMES. EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF. AN ENGINE SHUTTING OFF SUDDENLY WHILE DRIVING COULD INCREASE THE RISK OF A CRASH.
Sep 04, 2018
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHEN THE IGNITION KEY WAS TURNED TO THE ON POSITION, A TICKING SOUND EMITTED FROM THE VEHICLE AND IT FAILED TO START. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 11V151000 (ELECTRICAL SYSTEM) AND 15V194000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 90,000.
Apr 26, 2017
WHILE DRIVING IN LOW GEARS (2ND, 3RD) CAR WILL STALL OUT. POWER STEERING AND POWER BRAKES NO LONGER FUNCTIONING, MAKING THE CARE VERY DIFFICULT TO MANUEVER. THIS IS ESPECIALLY SCARY WHILE DRIVING IN SNOW/ICE. MAKING WITH EVEN MORE DANGEROUS IS STALLING WHILE ON BACK ROADS OR CURVES, IF I'M STALLED IN THE MIDDLE OF THE ROAD, ANOTHER CAR MIGHT NOT BE ABLE TO STOP AND RUN INTO ME. JERKING MOVEMENTS ARE ALSO OCCURING WHEN DRIVING AT LOW SPEEDS WHEN NOT ACCELERATING, LIKE CAR IS GOING TO STALL. VIN IS NOT INCLUDED IN RECALL, BUT IT IS THE SAME PROBLEM THAT WAS RECALLED ON OTHER 2010 ROUTANS.
Feb 01, 2016
TL*THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTON. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE ENGINE WOULD SHUT OFF WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT MENTIONED THAT THE VEHICLE WAS EXHIBITING THE SAME FAILURES AS MENTIONED IN RECALL NHTSA CAMPAIGN NUMBER: 11V151000 (ELECTRICAL SYSTEM). HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000.
Feb 11, 2015
+ 5 more complaints for this component
UNKNOWN OR OTHER
7 complaints
MY CAR STOPPED WORKING. THE LIGHTS WOULD COME ON BUT THE CAR WOULDN'T START. WE TEST THE BATTERY AND AULTINATOR, FUSE AND STARTER. WE COULD NOT FIND THE PROBLEM. WE RESEARCHED AND FOUND THAT THERE IS A RECALL ON THE VAN FOR THE PROBLEM. I CALLED THE VOLKSWAGEN COMPANY AND GAVE THEM MY VIN NUMBER AND THEY HAD A DEALERSHIP TO HANDLE THE PROBLEM. AFTER A FEW DAYS THEY CALLED ME AND STATED THAT THERE IS A $600.00 CHARGE FOR THE PROBLEM TO BE FIX. I TOLD THAT IT WAS A RECALL ON THE VAN BUT HE STATED THAT MY VIN NUMBER DOESN'T MATCH. THERE IS A RECALL ON THE VOLKSWAGEN ROUTAN 2010 FROM OCTOBER 2019 TO JUNE 2020. MINE IS MANUFACTURED IN APRIL 2020 WITH THE SAME IGNITION PROBLEM.
Oct 22, 2020
THE CAR STARTS WHEN IT WANTS TO. IT COULD BE FINE THEN GO OUT TO START IT AND IT DOES NOT TURN OVER. BATTERY HAS BEEN REPLACED, STARTER REPLACED TWICE NOBODY CAN FIGURE OUT WHAT IS GOING ON. I SEE THIS IS VERY COMMON IN THE REVIEWS. HAS HAPPENED MULTIPLE TIMES
Feb 25, 2020
TAKARA RECALL I WAS DRIVING (THE VEHICLE WAS IN MOTION) ON A COTT STREET AND THE VAN STARTED SHAKING THEN THE ENGINE JUST SHUT OFF. THEN THE VAN WOULD TURN ON, BUT WOULD SHUT OFF IMMEDIATELY. I HAD TO CALL A TOW TRUCK TO GET THE VAN OFF THE ROAD. I COULD HAVE CRASHED AND NOW I DON'T WANT TO DRIVE MY KIDS IN THAT VEHICLE ANYMORE. I JUST DON'T FEEL SAFE. ALSO I JUST BOUGHT THIS VEHICLE 4 DAYS EARLIER FROM A USED CAR DEALER.
Feb 24, 2019
THE CAR STALLS/ TURNS OFF WHILE DRIVING ON CITY STREETS. HAPPENS RANDOMLY EVERY COUPLE OF WEEKS SINCE PURCHASE OF THE CAR IN 2016. HAVE TO PULL OVER AND RESTART CAR. HAVE HAD MECHANIC LOOK AT , NO CODES ARE COMING UP RELATED TO IT.
May 22, 2017
MY CAR HAS AN ISSUE OF NOT TURNING OVER RANDOMLY. FOR NO APPARENT REASON IT WILL NOT START. I'VE HAD THE CAR CHECKED SEVERAL TIMES AND THE ISSUE IS STILL THE SAME. MY MECHANIC FIND NOTHING WRONG WITH VEHICLE.
Feb 03, 2017
+ 2 more complaints for this component
STRUCTURE
6 complaints
AUTOMATIC SLIDING DOOR DID NOT LOCK IN OPEN POSITION. INSTEAD, IT OPENED ALMOST ALL THE WAY AND THEN IMMEDIATELY BEGAN CLOSING AGAIN. I WAS ALREADY REACHING INTO THE VAN AT THAT POINT AND HAD TO MOVE OUT OF THE WAY QUICKLY AFTER APPLYING PRESSURE TO THE DOOR TO KEEP IT FROM CLOSING ON ME DIDN'T WORK. THIS HAS HAPPENED ON 3 OTHER OCCASIONS. VEHICLE WAS SEEN BY A VW DEALERSHIP UNDER WARRANTY. THEY COULD NOT REPLICATE THE ISSUE BUT STATED IT WAS A KNOWN GLITCH. IT TOOK A LOT OF FORCE FROM ME AS AN ADULT TO TRY TO STOP THE DOOR FROM CLOSING. WE HAVE 3 CHILDREN THAT RIDE REGULARLY IN OUR VAN. "KNOWN GLITCH" IS NOT ACCEPTABLE. *TR
Aug 21, 2014
ON 1/7/13 WE WERE SIMPLY TRYING TO OPEN THE REAR POWER LIFT GATE USING THE REMOTE AND OVERHEAD BUTTON TO NO AVAIL. EXTREMELY DISAPPOINTED TO FIND OUT THAT THE REAR DECK LID LIFT GATE DRIVE UNIT CHAIN (PART#51528) BROKE THUS CAUSING THE POWER LIFT GATE OF OUR ROUTAN SE TO BE INOPERABLE. AFTER 3YRS AND BARELY 7 MONTHS OF NORMAL USE, WE ARE APPALLED THAT THIS CHAIN FOR THE POWER LIFT GATE WOULD SUDDENLY BREAK FOR NO LOGICAL REASON. WHAT IS MORE SHOCKING, THE PRICE FOR THIS PART IS $1,100 EXCLUDING LABOR. THIS IS THE QUOTE THAT WAS GIVEN TODAY BY KING VOLKSWAGEN SERVICE DEPARTMENT. *TR
Jan 14, 2014
WHILE MY 3 YEAR OLD WAS ENTERING THE VEHICLE THROUGH THE SIDE SLIDING DOOR, SHE PRESSED THE BUTTON TO CLOSE THE DOOR. WHILE THE DOOR WAS CLOSING, SHE SLIPPED GETTING HER ANKLE/FOOT TRAPPED BETWEEN THE DOOR JAM AND DOOR BUT OVER THE BRACKET ATTACHING THE FRONT OF THE DOOR. THE DOOR CONTINUED TO CLOSE UNTIL IT JAMMED, SHE FELL OUTSIDE THE VEHICLE WHILE STILL BEING TRAPPED. WE HAD TO PUSH ON THE DOOR TO TRY TO SLOWLY OPEN IT TO ATTEMPT TO FREE HER. AFTER PICKING HER UP AND REACHING UNDER THE DOOR TO MOVE HER FOOT WE WERE ABLE TO FREE HER. THE ENTIRE TIME WE WERE TRYING TO FREE MY DAUGHTER THE DOOR KEPT MAKING A CLICKING NOISE. *TR
Nov 22, 2013
WHEN CLOSING THE POWER SLIDING DOOR ON THE PASSENGER SIDE, MY DAUGHTER REACHED BACK IN AND THE DOOR CLOSED 4 FINGERS IN IT. THE DOOR IS SUPPOSED TO OPEN BACK UP WHEN IT SENSES THAT SOMETHING IS IN THE WAY OF IT CLOSING. IN THIS CASE, IT FULLY LATCHED AND STAYED CLOSED WITH HER FINGERS STUCK IN IT. *JB
Jun 26, 2012
WHEN THE VEHICLE IS PARKED ON A SLOPE THE DRIVER'S SIDE REAR PASSENGER DOOR OPENS THEN IMMEDIATELY CLOSES AND RISKS TRAPPING EXITING PASSENGERS. THE ISSUE DOES NOT APPEAR ON THE DOOR ON THE OPPOSITE SIDE. THE ISSUE HAS BEEN REPORTED TO VOLKSWAGEN SEVERAL TIMES BUT ACCORDING TO THEM "IT WORKS AS DESIGNED". IT HAS ALMOST TRAPPED OUR DAUGHTER AND ELDERLY RELATIVES. *TR
Feb 06, 2012
+ 1 more complaint for this component
SERVICE BRAKES
5 complaints
WHEN I BRAKE THE STREERING WHEEL SHAKES FROM OTHER CONSUMER COMPLAINTS IT IS A BRAKE ISSUE AS IT ONLY HAPPENS WHEN I BRAKE. THERE NEEDS TO BE A RECALL! THE CAR IS STILL UNDER WARRANTY WHEN IT STARTED HAPPENING! *JS
Jul 29, 2014
THE BRAKES STARTED VIBRATING AND SHUDDERING WHEN THE BRAKE PEDAL WAS PUSHED. TOOK TO DEALER AND WERE TOLD THAT THE ROTORS WERE WARPED AND THE DISK PADS WERE WORN OUT. STILL UNDER WARRANTY SO THEY REPLACED ROTORS AND BRAKE PADS. THIS HAS HAPPENED APPROXIMATELY EVERY 8 MONTHS WE HAVE HAD THE CAR. THE FIRST THREE WERE COVERED UNDER WARRANTY. I HAD TO FIGHT WITH THE DEALER FOR THE THIRD REPLACEMENT. THE FOURTH REPLACEMENT OF THE BRAKES THE DEALER REFUSED TO COVER THE COST. WE HAD TO PAY TO GET THE WORK DONE. WE ARE NOW ABOUT 10 MONTHS FROM THOSE BRAKE REPLACEMENTS AND ONCE AGAIN THE CAR IS SHUDDERING VIOLENTLY WHEN WE APPLY THE BRAKES. THIS SEEMS TO BE A CHRONIC ISSUE AND A SAFETY ISSUE. I UNDERSTAND THAT BRAKE PADS WEAR OUT BUT I CANNOT BELIEVE THAT YOU HAVE TO REPLACE THE ROTORS AND BRAKE PADS EVERY 8/10 MONTHS UNDER NORMAL DRIVING. THIS CAR IS PRIMARILY USED TO TAKE MY KIDS TO SCHOOL AND ACTIVITIES. UPDATED 5/1/2015 *JS
Jul 28, 2014
THE VEHICLE'S REAR BRAKES ARE PREMATURELY WEARING UNEVEN IN THE REAR OF THE VEHICLE, CAUSING SAFETY CONCERNS FOR MY FAMILY. WHEN I WENT TO LOOK UP BRAKE REPLACEMENT ONLINE ONE OF THE REVIEWS SAID THAT A CLIP WAS LEFT OFF DURING THE MANUFACTURING PROCESS DURING THE MERGING BETWEEN CHRYSLER AND VOLKSWAGEN. *TR
Jul 11, 2014
VOLKSWAGEN ROUTAN 2010: THE STEERING WHEEL SHAKES VIOLENTLY UPON BRAKING A REGULAR SPEEDS, ESPECIALLY GOING DOWNHILL. FRONT ROTORS WERE REPLACED AT 22,000, 35,000, AND NOW 54,000 MILES. *TR
Jun 25, 2014
2010 VOLKSWAGEN ROUTON WITH 17,000 MILES BEGAN SHAKING AND SHUDDERING EVERY TIME I BRAKE, EVEN AT SLOW SPEEDS. THIS CAR IS USED FOR MINIMAL DRIVING. I BROUGHT MY CAR IN AND WAS TOLD I NEED NEW ROTORS AND THAT MY ROTORS WERE WARPED. I AM STILL DRIVING THE CAR AND THE BRAKES STILL SHUDDER AND SHAKE.. I SPOKE TO A MECHANIC THAT DOESN'T WORK FOR VOLKSWAGEN BUT ON GERMAN CARS AND HE SAID HE OWNED A ROUTON AND IT IS A COMMON PROBLEM WITH THEIR ROTORS. I READ SEVERAL COMPLAINTS AND REVIEWS ONLINE WITH THE SAME ISSUE TOO. I DON'T THINK ITS SAFE TO HAVE CAR MANUFACTURERS MAKE BRAKE SYSTEMS SO POORLY AS I MAY BE ABLE TO AFFORD A REPAIR, MANY ELSE WONT AS THE REPAIR IS COSTLY AND NOT WHAT A PERSON WOULD EXPECT FROM A CAR WITH LITTLE MILEAGE. I JUST WANTED TO BRING IT TO YOUR ATTENTION IN CASE OTHERS HAVE REPORTED THE PROBLEM. *TR
Jun 03, 2014
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
4 complaints
The TIPM is not working and while driving the headlights turn off. This is very unsafe and impairs the driver
Mar 03, 2023
The contact owns a 2010 Volkswagen Routan. The contact stated that while his wife was driving at an undisclosed speed, the headlights failed to illuminate. The vehicle was taken to the dealer, where it was diagnosed that the totally integrated power module (TIPM) needed to be replaced; however, the replacement part was no longer manufactured. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 117,000.
Mar 03, 2023
DRIVING AT ANY GIVEN TIME THE HEADLIGHTS TURN OFF AND DO NOT COME ON. STOP AND RESTART CAR AND STILL DO NOT TURN ON. THE HIGH BEAMS OR THE LOW BEAMS. THEY WILL NOT SWITCH ON. THEY COME ON FOR A FEW SECONDS AND THEN TURN OFF. WILL TURN OFF AS WE ARE DRIVING AND WE ARE NO LONGER VISIBLE TO OTHER CARS.
Aug 09, 2018
THE TOTALLY INTEGRATED POWER MODULE (TIPM) IS DEFECTIVE CAUSING THE VEHICLE TO STALE WHILE IN-MOTION RESULTING IN LOSS OF POWER STEERING AND BRAKING AND NEAR MISSES. THIS HAS OCCURRED WHILE VEHICLE WAS IN TRANSIT UP TO 45 MILES PER HOUR. THE VEHICLE'S DVD SYSTEM STOPPED WORKING. THE VEHICLE HAS FAILED TO START. ALSO, WHILE MAKING TURNS, FROM A STOPPED POSITION, THE VEHICLE HAS STALED RESULTING IN NEAR MISSES WITH ONCOMING TRAFFIC. WHILE STARTING THE VEHICLE, THE INTERIOR LIGHTS WOULD FLASH WHILE FAILING TO CRANK START. THE STALING WHILE IN MOTION OCCURS MULTIPLE TIMES DAILY. THE VEHICLE HAS BEEN TO THE MECHANIC AT LEAST 10 TIMES SINCE PURCHASING IT IN 2015. THE VEHICLE HAS ALWAYS HAD THIS PROBLEM SINCE PURCHASING. THE MOST RECENT VISIT TO THE MECHANIC CONCLUDED (2/2018) THE TIPM TO BE DEFECTIVE AND THAT THE DODGE/CHRYSLER PRODUCTS WITH THE SAME TIPM PART IS ALREADY RECALLED YET THE VW SISTER-PRODUCT IS NOT RECALLED. THE MECHANIC RECOMMEND REPLACING THE TIPM BECAUSE IT IS A SAFETY ISSUE AND WILL CONTINUE TO CAUSE STALING AT HIGH RATES OF SPEED, NEAR MISSES, IF THE PART IS NOT REPLACED. THE COST TO REPLACE WAS APPROX. $1,500.00. NHTSA NEEDS TO ISSUE A SAFETY RECALL FOR THE TIPM IN 2010 VW ROUTAN.
Mar 01, 2018
STEERING,ELECTRICAL SYSTEM,SERVICE BRAKES
4 complaints
I WAS DRIVING HOME FROM WORK APPROX. 30-35 MILES PER HOUR AND MY VAN DIED. I LOST POWER STEERING AND BRAKES. LUCKILY I WASN'T SERIOUSLY INJURED. THERE WAS NO WARNING. NO SERVICE ENGINE LIGHT. WITHIN A SPAN OF LESS THAN 2 YEARS IVE ALREADY REPLACED THE FUEL PUMP, THE BATTERY, AND THE ALTERNATOR IS STILL NEW AND UNDER WARRANTY. THE IGNITION/POWER WINDOWS FUSE CONSTANTLY NEEDS ADJUSTING SO I CAN ROLL MY WINDOW UP OR DOWN. ALL THE DASH LIGHTS COME ON RANDOMLY AS WELL. SOMETIMES THE WINDSHIELD WIPERS WOULD COME ON. NEVER HAD A VEHICLE DIE ON ME WHILE DRIVING DUE TO MANUFACTURERS ISSUES. AFTER READING OTHER CONSUMER COMPLAINTS ABOUT THE SAME ISSUES IM VERY CONFIDENT ITS THE TIPM. SOME COMPLAIN THAT THIS COSTS PEOPLE $1 000S ON A CHANCE THAT YOU CAN GET A COUPLE MORE YEARS OUT OF IT. THE VAN WANTS TO TURN OVER AND CONTINUES CRANKING WHEN KEY FOB IS IN IGNITION BUT DOESN'T TURN OVER. I CANNOT GET IT TO START AT ALL.
Sep 11, 2020
MY VAN SHUT DOWN WHILE DRIVING AGAIN. I WAS SLOWING DOWN TO MAKE A TURN AND THE ENGINE LOST POWER AND I LOST POWER STEERING AND BRAKES.
Dec 26, 2018
MY VAN SHUT DOWN WHILE DRIVING FOR THE FOURTH TIME. I WAS SLOWING DOWN TO A STOP AT A LIGHT AND THE ENGINE LOST POWER AND I LOST POWER STEERING AND BRAKES. THIS HAS BEEN HAPPENING MUCH MORE FREQUENTLY NOW THAN BEFORE (WITH 3 TIMES IN THE LAST MONTH). MY VAN IS NOT INCLUDED IN WIN MODULE RECALL AS THE VIN IS A COUPLE OF DIGITS OFF. THIS IS VERY FRUSTRATING AND SCARY.
Dec 26, 2018
MY VAN SHUT DOWN WHILE DRIVING AGAIN. I WAS SLOWING DOWN TO A STOP AT A LIGHT AND THE ENGINE LOST POWER AND I LOST POWER STEERING AND BRAKES.
Dec 26, 2018
STEERING,SERVICE BRAKES,ENGINE
4 complaints
REPORTED ISSUE TO VW RECALL GROUP VIA TELEPHONE 5/13/2019. THIS IS VERY SIMILAR TO A RECALL THAT TOOK PLACE FOR VW ROUTAN 2009-2010 THAT WERE CREATED BETWEEN THE DATES OF OCTOBER 2019 TO JUNE 2010. OUR VEHICLE WAS CREATED IN AUGUST OF 2010, AND I SUSPECT THE SAME PARTS WERE STILL USED. TWO ISSUES HAVE OCCURRED WITH 2010 VW ROUTAN SEL MINIVAN 4.0L ISSUES STARTED OCCURRING AFTER REPLACING A LOST KEY FOB. KEY FOB WAS ORDERED THROUGH LOCAL VW DEALER (BOB KING VW) AND REPLACED. FIRST ISSUE: CAR WOULD NOT START. PUT KEY INTO IGNITION SWITCH, TURN KEY, THE IGNITION SWITCH CLICKS BUT THE CAR WOULD NOT START. IN ORDER TO START CAR, WAIT AND REPEAT STEPS UNTIL CAR ACTUALLY STARTS. SECOND ISSUE: (HIGHLY DANGEROUS) INTERMITTENT SHUT OFF WHILE DRIVING CAUSING POWER STEERING TO TURN OFF AS WELL AS BRAKES. VERY DANGEROUS COMBINATION DUE TO THE FACT THAT TURNING BECOMES VERY DIFFICULT AS WELL AS BRAKING. IN ORDER TO BRAKE YOU HAVE TO APPLY GREAT FORCE TO BREAK SINCE THERE IS NO POWER TO THE CAR. THIS ISSUE HAS BEEN ENCOUNTERED OVER THE PAST TWO MONTHS AT LEAST FOUR (4) TIMES WHILE THE PRIMARY DRIVER HAS BEEN DRIVING THE VEHICLE. THE FIRST THREE TIMES THE VEHICLE WAS IN MOTION IN A RESIDENTIAL AREA. THE LAST TIME THIS ISSUE OCCURRED 5/13/2019 THE VEHICLE WAS IN MOTION ON A MAJOR ROAD WAY NEAR AN INTERSECTION. EVASIVE MANEUVERS WERE TAKEN TO GET VEHICLE OFF OF ROAD AND INTO A NEARBY PARKING LOT OFF THE STREET.
May 15, 2019
MY VAN HAS SHUT OFF TWICE NOW WHILE DRIVING. BOTH EVENTS HAVE OCCURRED WHILE TURNING RIGHT, AT A SLOW SPEED ON CITY STREETS (ONE TIME WITH MY CHILDREN IN THE VEHICLE). I LOSE POWER STEERING AND BRAKES AND THE ENGINE APPEARS TO SHUT DOWN (RADIO REMAINS ON). WHEN I FIRST TRIED TO RESTART IT, IT WOULDN'T AND THEN THE SECOND ATTEMPT SOUNDED UNUSUAL BUT IT DID START. THE TRACTION CONTROL LIGHT LIT UP ON THE DASHBOARD AS WELL. BOTH TIMES WERE IN GOOD DRIVING CONDITIONS. AFTER THE FIRST TIME, DUE TO MY RESEARCH ON THE ISSUE, I ONLY USE THE FOB WITH NOTHING ELSE HANGING FROM IT. IN ADDITION, I ALSO HAVE THE ISSUE OF THE VEHICLE RANDOMLY NOT STARTING. I USUALLY GET IT TO START BY FIDDLING WITH THE SHIFTER. OF COURSE, MY VAN IS NOT INCLUDED IN THE IGNITION MODULE RECALL, WHICH IS COMPLETELY ABSURD AS IT IS CLEARLY HAPPENING TO A LOT OF US. I LOVE EVERYTHING ABOUT THIS VAN EXCEPT FOR THESE TWO MAJOR ISSUES.
Oct 17, 2018
MY VEHICLE IS EXPERIENCING THE SAME PROBLEM AS OTHER VEHICLES OF THE SAME YEAR THAT RECEIVED A RECALL. THE CAR JUST SHUTS OFF, LOSES POWER AND ALL STEERING, BRAKING AND SO ON. IT MAKES THE VEHICLE VERY DANGEROUS. THE OTHER VEHICLES IN THIS YEAR ALL HAD BAD IGNITION SWITCHES BUT VW REFUSES TO INCLUDE MY VEHICLE AND OTHERS LIKE IT OF THE SAME MODEL YEAR THAT HAVE THE EXACT SAME PROBLEM. I BELIEVE THAT THEY NEED TO EXPAND THIS RECALL TO INCLUDE MORE VEHICLES OF THE 2010 MODEL. THE VEHICLE IS NOT SAFE TO DRIVE AND IS SCARY WHEN IT JUST CUTS OUT ON YOU WHEN YOU ARE DRIVING 30-40 MPH PLUS.
Jan 19, 2016
MY MINI-VAN SHUT OFF/ STALLED WHILE I WAS DRIVING ON THE ROAD. EVERY TIME IT STALLED I WAS DRIVING SLOWLY THROUGH CONSTRUCTION ZONE OR IN FRONT OF A LIGHT WHERE I HAD TO PRESSED THE BRAKE TO STOP THE CAR FOR OVER 30 SECONDS. I SEND IT TO VW SERVICE FOR REPAIR BUT NO PROBLEM WAS FOUND. I AM TOO SCARED TO DRIVE THE CAR BECAUSE I NEVER KNOW WHEN ITS THE NEXT TIME IT WILL STALL AGAIN WHILE I AM DRIVING ON THE ROAD.
Aug 05, 2015
ELECTRICAL SYSTEM,UNKNOWN OR OTHER
3 complaints
Car shuts off while driving, ignition key fob issue recall. Tipm system recall.
Aug 13, 2022
I purchased this vehicle in March of 2015 when my vehicle shut down and rebooted itself while driving. Since 2019-present, my vehicle shuts off while driving and will restart back up maybe 5 mins, an hour or so later. The ABS, check engine, airbag, and other lights on the dashboards come on and remain on, in which, my car begins to make a beeping sound. the headlights, wipers, and sometimes my horn goes on and off by itself. When my vehicle shuts off, so does my ability to steer the wheel, it locks up. when I turn the air on in the car, my car begins to shake as well. Also, I have replaced my car battery, alternator, and starter two times this year and my vehicle still have the same issue.
Jun 22, 2021
CONTACTED ORLANDO VOLKSWAGEN SOUTH 5474 S. ORANGE BLOSSOM TRAIL ORLANDO FL 32839 (866) 318-7865 (407) 581-0665 HTTPS://WWW.ORLANDOVWSOUTH.COM WAS TOLD THEY DO NOT DO THE RECALL. CONTACTED DEALER IN 2015 AND NOW WITH NO REMEDY. WHEN DRIVING THE CAR WILL TURN OFF AND LOSE ALL POWER. HAS HAPPENED 10 TO 20 TIMES AND IS VERY DANGEROUS.
Nov 13, 2020
WHEELS
3 complaints
OUR VAN WAS IN MOTION ON THE HIGHWAY AFTER AN ALMOST 2 HOUR DRIVE ON THE HIGHWAY. LOUD NOISE, SCREECHING, SHAKE/VIBRATION AND A LARGE BANG AND THE VAN DROPPED. UPON STOPPING AND INSPECTING WE FOUND THE RIGHT FRONT AND LEFT REAR BOLTS HAD COMPLETELY SHEERED COMPLETELY OFF BOTH WHEELS WHILE DRIVING ON THE HIGHWAY. WE WERE ABLE TO COAST TO SIDE OF ROAD AND AND THE WHEEL HUBS WERE RESTING ON THE INSIDE OF THE RIM. THE WHEEL HUBS HAVE DESTROYED THE INSIDE OF THE RIMS, THE HEAT CREATED FROM THE GRINDING HAS MELTED THE VW EMBLEM ON THE RIM. THE RIGHT FRONT TIRE HAD ALSO COME TO REST ON THE RIGHT FENDER. THE RIGHT REAR TIRE WAS OUT OF ALIGNMENT/PROPER POSITIONING HOWEVER OUR VISUAL INSPECTION AND LACK OF EXPERIENCE I CANNOT DETERMING IF THESE BOLTS ARE ALSO STARTING TO BREAKDOWN OR THE INCIDENT MAY HAVE CAUSED A DRIVE SHAFT/AXLE DAMAGE.
Apr 27, 2018
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE TIRE PRESSURE WARNING LIGHT ILLUMINATED AS THE FRONT PASSENGER'S SIDE TIRE DEFLATED. THE CONTACT HAD A ROADSIDE ASSISTANCE SERVICE CHANGE THE TIRE AND INSTALL THE SPARE. THE TIRE WAS TAKEN TO THE DEALER, WHO STATED THAT THE VALVE STEM ON THE TIRE WAS CORRODED. THE WHEEL WAS REPAIRED BUT THE FAILURE RECURRED ON THE REAR DRIVER'S SIDE WHEEL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000.
Aug 09, 2013
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE PERFORMING A ROUTINE INSPECTION, HE NOTICED THAT THE VALVE STEM WAS CORRODED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS ADVISED THAT THE STEM WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 33,000.
May 14, 2013
ELECTRICAL SYSTEM,VISIBILITY/WIPER
3 complaints
I DROPPED MY VAN OFF ON 1/21/15 AND TODAY IS 1/28/15 AND I CALLED THE DEALERSHIP THAT I BOUGHT THE VEHICLE FROM AND HE HAS BEEN HELPFUL BUT WHERE THEY DROPPED THE VAN TO, TO GET IT REPAIRED AT THE VOLKSWAGEN DEALERSHIP WHERE THEY CAN WORK ON IT SAY THEY CANNOT DUPLICATE THE MALFUNCTION. IT'S BEEN OVER A WEEK AND MY FIANCE HAD TO BE THE ONE TO CONTACT THE DEALERSHIP FOR AN UPDATE. NOW I HAVE A VIDEO THAT MY FIANCE HAS RECORDED AND I SENT IT TO THE DEALERSHIP WHERE I BOUGHT THE VAN AND HE HAS LOOKED AT IT. HE ALSO TRIED TO SEND IT VIA EMAIL TO THE VOLKSWAGEN DEALERSHIP WHERE MY VAN IS BEING REPAIRED AND THEIR EMAIL IS INCAPABLE OF RECEIVING THE FILE DUE TO THE FACT THAT IT IS TOO BIG BY THEIR STANDARDS. NOW MY FIANCE HAS CALLED THE VOLKSWAGEN DEALERSHIP DIRECTLY AND SAID TO THE SUPERVISING PERSON IN CHARGE OF WORKING ON MY VAN THAT WE ARE MORE THAN WILLING TO DRIVE OVER THERE AND SHOW HIM THE VIDEO, HIS REPLY WAS IT IS NOT NECESSARY. OK MY THOUGHT ON THAT IS IF YOU CANNOT DUPLICATE THE MALFUNCTION OF THE WINDSHIELD WIPERS NOT TURNING OFF, THE TURNING SIGNALS NOT WORKING AT ALL AND THE HEATED SEAT NOT WORKING AT ALL WOULDN'T YOU WANT TO SEE THE VIDEO. WE HAVE A RECORD OF IT AND I FEEL LIKE HE DOESN'T CARE. PLEASE INVESTIGATE THIS FAULTY VEHICLE. I AM FRUSTRATED AND NOW LOOKING INTO THE LEMON LAW. THIS VEHICLE IS A HAZARD AND MY KIDS SAFETY WHILE IN THIS VEHICLE IS MY PRIORITY. I DO NOT FEEL SAFE IN THIS VEHICLE. *TR
Jan 28, 2015
ONCE AGAIN MY FIANCE AND I ARE EXPERIENCING THE SAME PROBLEMS WITH THE WINDSHIELD WIPERS NOT TURNING OFF WHEN YOUR TURN OFF THE SWITCH. ALSO, THE TURNING SIGNALS ARE NOT WORKING, THE HEATED SEATS DON'T TURN ON AND THE CD PLAYER DOES NOT WORK. I CALLED THE DEALERSHIP WHERE I BOUGHT AND TOLD THEM IT IS HAPPENING AGAIN AND MY FIANCE EVEN DID A VIDEO OF THE PROBLEM AS IT WAS HAPPENING. THE WEAR PART OF THIS IS WHEN WE HIT A BUMP ON THE ROAD THE WINDSHIELD WIPERS STOPPED AND THE TURNING SIGNAL CAME ON. THAT DOES NOT SIT RIGHT WITH ME. THERE HAS TO BE A SHORT SOMEWHERE. WE HAVE TAKEN IT BACK THE DAY AFTER TO THE DEALERSHIP WHERE I BOUGHT IT. I AM NOT CONFIDENT IN THIS VEHICLE WITH OUR 3 KIDS. *TR
Jan 05, 2015
I JUST BOUGHT THIS VAN IN JULY OF THIS YEAR. MY FIANC DRIVES THE VAN MORE THAN ME AND HE TOLD ME THAT THE WINDSHIELD WIPERS WILL NOT SHUT OFF. I CALLED THE VOLKSWAGEN AT 1-800-822-8987 ON MONDAY AND GAVE HER MY VIN AND SHE SAID IT WAS NOT PART OF ANY RECALL BUT WHEN I LOOKED UP THE RECALL PAPERWORK ON THIS SITE, RCDNN-11V151-5396, IT SAID THE NUMBER OF VEHICLES AFFECTED BETWEEN 2V4RW-D-AR138555 - 2V4RW-D-AR348536 AND RCDNN-11V151-1295 (AMENDED), AND IT SAID THE NUMBER OF VEHICLES AFFECTED BETWEEN 2V4RW-D-AR138555 - 2V4RW-D-AR360513, IF I AM LOOKING AT IT CORRECTLY MY VIN FALLS BETWEEN THOSE NUMBERS. THIS IS THE FIRST WE EXPERIENCE ANY ISSUES AND TODAY MY FIANC TOLD ME THAT THE ODOMETER MILEAGE READS GATES INSTEAD OF THE NUMBERS. WE ARE DROPPING THE VAN OFF TOMORROW TO GET IT LOOKED AT BUT I AM BRINGING ALL THE PAPER OF THE RECALL AND THE SERVICE BULLETIN. I JUST BOUGHT THIS VAN AND WE ONLY USE IT LESS 6 MILES EVERY DAY, IT'S ONLY USED TO TRANSPORT MY KIDS TO AND FROM OUR DAYCARE, OR IF WE HAVE TO TAKE ALL 5 PEOPLE ANYWHERE OTHER THAN THAT WE DON'T USE IT, WE ALWAYS RENT CARS TO GET OUT OF THE AREA. PLEASE INVESTIGATE I HAVE 3 CHILDREN AND I DON'T WANT TO WORRY ABOUT EXPERIENCING A BAD ACCIDENT WITH MY KIDS IN THE CAR, LIKE SOME OF THE SUBMITTED COMPLAINANTS HAVE EXPERIENCED. *TR
Oct 29, 2014
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE
2 complaints
I bought this van just a few weeks ago. One day I was driving and all a sudden it lost power while in motion. This has happened 4xs so far. It could've resulted in the inability to stop my vehicle as the brakes are stiff after the power & engine stop working. It could've resulted in either I hit someone or someone could've hit me. My cousins husband had a town and country that did this & it was on a recall for the ignition switch failure. He's a mechanic. He has also stated what is going on is the ignition switch failure going into accessory mode while I'm driving. It's available to be inspected I just don't have the money to have it inspected at this point by a dealership.
Nov 12, 2024
2010 VW Routan VIN:[XXX] We purchased the vehicle used in November of 2018. From November 2018 through early 2020, I experienced the car turning off while driving it about once every 4-6 months. When researching this issue we found that extra weight from other keys or keychains could be affecting it so we separated the car key from my house keys. This showed no improvement. From early 2020 through early 2021, the issue increased in frequency. Instead of once every 4-6 months it became once a month. And, unfortunately in the past 3 months, it has started occurring several times a week (sometimes multiple times a day). This has been a safety concern for our family and we are very nervous that this could cause a serious accident. Luckily the other vehicles around us when this occurs have been alert drivers that were able to give us the extra time to restart our vehicle. We realize that this won’t always be the case and need to get it fixed. The issues we are experiencing as outlined above are in line with the issues listed in NHTSA Campaign ID: 11V151000 for other 2010 VW Routans. However, for whatever reason, our VIN number is not included in the recall. I would like to make a formal appeal with nhtsa that our vehicle be included in this recall and that it be repaired by VW as it is quite clear that what we are experiencing is from the issue in this NHTSA Recall Campaign. We are disappointed to be in a position to fight for something to get fixed that is quite clearly caused by a defaulted part, but remain hopeful that this will be resolved in a timely manner. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Jul 21, 2021
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKES
2 complaints
Battery failure due to parasitic draw from Ignition IOD fuse ( J13fuse) reads 0.9 draw and M11 fuse ( hvac system) reads 0.6 draw. First occurrence 2/10/24 and second occurrence 2/11/24. Informed auto repair shop on 2/12/24 and goes in for diagnostic 2/15/24. Abs control module failure( intermittent ) Egr valve replacement (8/9/24 due to overheating but no warning lights due to overheating was displayed which is strange) Speed control sensor was replaced as well 8/9/24 but still has problems getting stuck or not reading the right speed . Consumes fuel faster than normal as well . Getting about 9 miles to the gallon.
Feb 12, 2024
CAR FLASHES ABS ESP SKID CONTROL MONITOR, SHUTS CAR OFF WHILE DRIVING. GOES BACK OFF, DOES IT AGAIN.LOCKS THE CAR, WON'T START, THEN STARTS A BIT LATER. COOLING SYSTEM , HEATER HOSE ISSUES, BRAKE ISSUES, CRUISE CONTROL SHUTS OFF RANDOMLY. COULD KILL SOMEONE. INTERNET SEARCH ESP VOLKSWAGENDDEFECT.COMVOLKSWAGEN_ROUTAN_PROBLEMS.HTM ALL EXACTLY WHAT I HAVE EXPERIENCED SINCE PURCHASING THIS VEHICLE A YEAR AGO. AFRAID TO DRIVE IT. UPDATED 04/05/2017 *JS
Jul 06, 2016
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER
2 complaints
All electrical gauges randomly go on and off, there is a continuous beeping to go along with it, the windshield wipers will go on and off. It seems to happen more in the summer or if it’s raining. It will occasionally stall while doing this, especially in a stationary position (like at a drive through).
Oct 07, 2023
I WOULD LIKE TO INFORM YOU THAT THE TIPM IS NOT JUST RELATED TO CHRYSLER. THE ROUTAN IS A JOINT VENTURE BETWEEN CHRYSLER AND VW. IT HAS THE BODY OF A VW BODY BUT THE ENGINE IS A CHRYSLER. MY ROUTAN HAS HAD THE TIPM FAIL ON 2/6/2016 AND CONFIRMED BY VW DEALERSHIP. THE VAN HAS THE SAME SIGNS THAT EVERY ONE ELSE WAS REPORTING EXCEPT THAT THE ENGINE NEVER SHUT OFF WHILE. IT HAS THE SIGNS OF THE ENGINE NOT WANTING TO TURN OVER, DASH LIGHTS NOT WANTING TO WORK PROPERLY AND NOW THE HEADLIGHTS NOT WORKING ON LOW OR HIGH BEAMS. THE HEAD LIGHTS HAPPENED WHEN I WAS DRIVING ON THE CITY STREETS. THE ENGINE NOT WORKING HAPPENS WHEN WE COME OUT OF THE STORES FROM SHOPPING, FIRST THING IN THE MORNING AND SAME WITH THE WINDOWS AND DOORS OPENING WHEN NOT IS USE. I RESEARCHED ONLINE ABOUT OTHER ROUTANS AND THEY HAVE CHRYSLER TIPM IN THEM. I DO NOT UNDERSTAND WHY ROUTAN'S HAVE NOT BEEN INCLUDED BECAUSE IT IS A CHRYSLER PRODUCT BUT IT HAS A VW NAME ON IT. IT WAS MADE IN THE CHRYSLER WINDSOR PLANT IN CANADA. THIS ALL STARTED IN LATE DECEMBER OF 2014 AND IT WAS OFF AND ON SINCE THEN. THE HEADLIGHTS PROBLEM IS NEW BUT THE ENGINE, DOORS AND WINDOWS ARE OFF/ON ISSUE TOO.
Feb 08, 2016
ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE
2 complaints
This has happened multiple times. The ignition will cut off which make the car engine quit running. Loss of braking, steering, power has left me in the middle of intersections being nearly avoided being ran into. When this happens all the warning lights come on and the engine turns off. The exact problem VW recall number 28H1 is affecting my vehicle.
Mar 04, 2022
I AM WRITING TO ADDRESS A SAFETY ISSUE I HAVE WITH MY VEHICLE, A 2010 VOLKSWAGEN ROUTAN. MY HUSBAND AND I PURCHASED THIS CAR LAST YEAR AND SHORTLY AFTER ITS PURCHASE STARTED TO EXPERIENCE ELECTRICAL ISSUES WITH THE VEHICLE. THESE ISSUES INCLUDED WARNING LIGHTS ON THE DASH ILLUMINATING, POWER FAILURES OF THE DASH BOARD GAUGES (SPECIFICALLY THE SPEED GAUGE) AND RADIO, AND MOST ALARMINGLY THE CAR WOULD COMPLETELY STALL AND LOSE POWER. THIS ISSUE OF LOSING POWER TO THE ENTIRE CAR HAS HAPPENED BOTH WHILE THE CAR IS IN MOTION AND WHILE IT HAS BEEN STOPPED AT TRAFFIC LIGHTS, AS WELL AS AT HIGH AND LOW SPEEDS. WE TOOK THE CAR TO A LOCAL VW DEALERSHIP HOPING THEY MIGHT BE ABLE TO DIAGNOSE THE ISSUE AND FIX IT. AFTER NEARLY 3 WEEKS OF HAVING DIFFERENT PARTS REPLACED, BEING TOLD THE ISSUE WAS SOLVED IT WAS NOT. WHEN DRIVING THE VEHICLE WITH ONLY THE KEY IN THE IGNITION IT PERFORMS BETTER, ALTHOUGH STILL DIES OCCASIONALLY, BUT WITH ANYTHING ON THE KEYRING IT WILL DIE ALMOST INSTANTLY. IT WASN'T UNTIL AFTER REMOVING OUR CAR FROM THIS DEALERSHIP THAT WE LEARNED ABOUT A RECALL ON THE VW ROUTANS THAT SEEMED VERY SIMILAR TO THE ISSUES WE WERE EXPERIENCING. UPON RESEARCH WE DISCOVERED THAT OUR VEHICLE WAS PRODUCED WITHIN THE SAME MONTH OF THE RECALLED VEHICLES BUT APPARENTLY NOT BEFORE THE ENDING DATE OF THAT RECALL. SO OTHER VW DEALERSHIPS WOULD BE HAPPY TO REPLACE THE MALFUNCTIONING PART BUT AT AN OUT OF POCKET COST FOR US, WHICH WE SIMPLY CANNOT AFFORD, ESPECIALLY AFTER THE BILL WE ARE STILL WORKING TO PAY FOR OTHER UNNECESSARY WORK. AS A CONSUMER IT IS VERY FRUSTRATING TO HAVE A VEHICLE THAT IS CLEARLY DEMONSTRATING THE SAME ISSUES AS PREVIOUSLY RECALLED VEHICLES BUT DOES NOT FALL UNDER THAT RECALL. WE HAVE REDUCED TO ONLY DRIVING THIS VEHICLE AS NECESSARY AND NO LONGER USE IT TO TRANSPORT OUR TWO YOUNG CHILDREN AS WE FEAR GREATLY FOR THEIR SAFETY.
Aug 29, 2016
STEERING,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
2 complaints
THE ENGINE STALLS AS THE VEHICLE IS DRIVEN AND IT LOCKS THE STEERING WHEEL. THIS HAPPENED ABOUT 8 TIMES WITHIN THE PAST 24 MONTHS. WE DISCOVERED THAT 12,000 AND MORE ROUTAN 2009 AND 2010 HAVE BEEN RECALLED FOR THE SAME PROBLEMS WITH SOME FATALITIES REPORTED DUE TO THIS DEFECT: IGNITION MODULS AND ELECTRONIC MODULS. VW AND GM-CHRYSLER ARE NOT SUPPORTING THE VW. DEALER REPAIR/REPLACEMENT AS MY VW ROUTAN SEEMS NOT HAVING BEEN TRACKED DOWN DURING INITIAL RECALLS.
Aug 19, 2019
2010 VOLKSWAGON ROUTAN HAS STOPPED IN MID TRAFFIC GOING 30-40 MPH ON A BUSY ROAD. LIGHTS AND AUDIO HAVE FLICKERED, THEN TURN OFF. CAR SPONTANEOUSLY STARTS AND STOPS ANY GIVEN TIME IN MOTION AND STANDING STILL, AND CANNOT BE JUMPED TO REVIVE. HAVE BEEN IN THE CAR WITH MY CHILDREN AND HAVE HAD IT STOP IN THE MIDDLE OF THE ROAD. WE HAVE HAD IT LESS THAN A YEAR, COMPLETELY UNSAFE. TOLD THE EXACT RECALL DOESN'T APPLY TO MY VIN#.
Mar 07, 2018
STEERING,ELECTRICAL SYSTEM
2 complaints
I BELIEVE THE IGNITION SWITCH IS FAULTY BUT MY VIN DOES NOT COME UP UNDER THE IGNITION SWITCH RECALLS (15V194000 OR 11V151000). ONE TIME WHEN ACCELERATING UP A BUMPY HILL GOING ABOUT 40 MPH ON A HIGHWAY, THE VEHICLE SHUT OFF AND POWER STEERING WAS NOT AVAILABLE. I WAS ABLE TO MANEUVER TO THE SIDE OF THE ROAD AND TURN IT OFF, PUT IT IN PARK, AND TURN IT BACK ON. ANOTHER TIME ON A FLAT BUMPY ROAD, ACCELERATING AT ABOUT 35 MPH, THE VEHICLE SHUT OFF AGAIN WITH NO POWER STEERING AVAILABLE. I AGAIN PULLED OVER, PUT IT IN PARK, TURNED IT OFF AND THEN RESTARTED IT.
May 03, 2019
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL SEIZED WITHOUT WARNING AND THE ELECTRICAL SYSTEMS FAILED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
Mar 04, 2016
STEERING,VEHICLE SPEED CONTROL,SERVICE BRAKES
2 complaints
VAN CUTS OFF WHILE DRIVING. INABILITY TO STEER, LIMITED BRAKING. CAR GOES COMPLETELY DEAD BUT STILL START BACK ONCE I HAVE COMPLETELY STOPPED. THIS IS VERY HAZARDOUS ESPECIALLY WHEN YOUR DRIVING OVER 45 WITH A LOT OF TRAFFIC FOLLOWING BEHIND YOU.
Mar 30, 2019
WHEN DRIVING DOWN THE ROAD GOING ABOUT 30MPH MY CAR SUDDENLY SHUT OFF. NO INDICATOR LIGHTS CAME ON AND MY POWER STEERING WAS GONE AS WELL AS MY ABILITY TO BRAKE WELL. LOOKING ONLINE THEIR WAS A RECALL ON MY MODEL YEAR AND MAKE OF VAN FOR THE SAME PROBLEMS WITH THE IGNITION SWITCH BUT MY VIN NUMBER DID NOT PULL UP A RECALL. I CONTACTED VW AND THEY ALSO STATED MY CAR WAS NOT PART OF THAT RECALL. THANKFULLY I WAS ABLE TO PULL TO SIDE OF THE ROAD SAFELY.
Nov 08, 2018
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
2 complaints
TL* THE CONTACTS OWNS A 2010 VOLKSWAGEN ROUTAN. WHEN THE CONTACT OPENED THE DRIVER'S DOOR, SNOW FELL ONTO THE POWER WINDOW SWITCH. AFTER THE CONTACT CLEANED THE SNOW OFF THE SWITCH, SHE LATER SMELLED A BURNING ODER COMING FROM THE DOOR. THE CONTACT ATTEMPTED TO USE THE WINDOW LATER IN THE DAY, BUT THE WINDOW FAILED TO GO DOWN. THE CONTACT CHECKED THE FUSES AND OTHER COMPONENTS ON THE VEHICLE, BUT COULD NOT FIND THE CAUSE OF THE FAILURE. THE CONTACT FELT THAT WATER FROM THE MELTED SNOW CAUSED THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 148,845.
Feb 08, 2018
VAN WARNING LIGHTS COME ON WITHOUT NOTICE; WHEN DRIVEN INSTRUMENT PANEL LIGHTS FLICKER AND DIM, AUDIO SYSTEM CUTS OFF AND ON WHILE DRIVING. WAS TAKEN TO DEALER AND HAD TIPM WAS REPLACED AND ISSUE STILL PERSISTS.
Oct 14, 2017
STEERING
2 complaints
THE STEERING WHEEL MAKES A CRANKING SOUND WHEN RIGHT TURNS AND LEFT TURN IS MADE. APPARENT THAT AN ACCIDENT CAN EASILY OCCUR IF THIS PERSISTS. THE DEALERSHIP IN GREATNECK NY WAS NOT ABLE CORRECT THIS PROBLEM DESPITE NUMEROUS COMPLAINTS. THIS PROBLEM HAPPEN WHEN THE VEHICLE IS IN MOTION AND TURNS ARE MADE BY THE DRIVER. THIS PROBLEM HAS PERSISTED OVER THE YEARS - SOMETIME IN AUGUST 2012, I BROUGHT VEHICLE INTO THE DEALERSHIP TO HAVE IT CHECKED FOR A PROBLEM RELATED TO THE STEERING WHEEL. I STILL HAVE A RELATED PROBLEM WITH THE VEHICLE. THIS VEHICLE IS UNSAFE TO DRIVE MY 5 CHILDREN. BECUASE THE DEALER COULD NOT RESOLVE THIS PROBLEM AND IT HAS NOW AROSE AGAIN. THIS COMPLAINT IS NOW SUBMITTED. I DO HAVE AN INVOICE WHICH STATES MY COMPLAINT BACK IN 2012.
Nov 04, 2016
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH, THE VEHICLE BEGAN PULLING INTO THE RIGHT DIRECTION INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FIVE TIMES FOR THE IDENTICAL FAILURE. A FRONT END ALIGNMENT WAS PERFORMED TWICE AND THE REAR AXLE WAS ALSO REPLACED. THE FAILURE PERSISTED FOLLOWING REPAIRS. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE BACK TO THE DEALER. THE FAILURE MILEAGE WAS 4.
Oct 04, 2010
TIRES,WHEELS
2 complaints
WHILE DRIVING AT A SPEED OF 50 MPH ON A RURAL ROAD, THE FRONT DRIVER-SIDE TIRE INSTANTLY DEFLATED. FORTUNATELY, THE VEHICLE WAS SAFELY PULLED OVER AWAY FROM TRAFFIC. UPON EXAMINATION IT WAS FOUND THAT THE VALVE STEM HAD BROKEN OFF, AND THE TIRE HAD DEFLATED AS A RESULT. THE REST OF THE TIRE WAS IN GOOD CONDITION. IN THIS TYPE OF VEHICLE, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) IS PART OF THE VALVE STEM, AND THAT IS WHAT HAD BROKEN OFF. A SECOND SIMILAR INCIDENT HAPPENED APPROXIMATELY 6 MONTHS LATER WITH THE REAR DRIVER-SIDE TIRE OF THE VEHICLE, WHILE TRAVELING AT 55 MPH. *TR
Apr 15, 2015
FRONT DRIVER SIDE TIRE RAPIDLY DEFLATED CAUSING THE VEHICLE TO PULL RIGHT INTO ON COMING TRAFFIC. THE NEAR MISS COULD HAVE BEEN FATAL. UPON INVESTIGATION IT WAS DETERMINED THAT THE CAUSE WAS CORROSION OF THE TPMS VALVE. I DID A QUICK INTERNET INVESTIGATION AND LEARNED THAT THE CORROSION AND RESULTING TIRE FAILURE ARE COMMON INCIDENTS. WHY HAVEN'T THESE FAULTY TPMS VALVES BEEN RECALLED? THIS ISSUE WILL SURELY RESULT IN DEATHS WHICH I BELIEVE IS THE OPPOSITE OF WHAT THESE TPMS SENSORS ARE FOR. *TR
Dec 26, 2013
TIRES
2 complaints
THREE WEEKS PRIOR, I'D INSTALLED 4 NEW TIRES. RETURNING HOME FROM DR'S. OFFICE THIS DAY, I HEARD A SMALL 'POP', THEN BEGAN HEARING RUMBLING, THEN REALIZED CAR BEING PULLED TO EDGE OF ROAD. FLAT TIRE? ON A 3 WK OLD TIRE? SURE ENOUGH THE RIGHT FRONT TIRE WAS FLAT. VERY FORTUNATE FOR LOCATION OF OCCURRENCE, SPEED ZONE, AND DISTANCE TO THE VERY PLACE I'D PURCHASED THE TIRES. THIS VEHICLE IS EQUIPPED WITH TPMS. THE SENSOR STEM IS HELD TIGHT TO THE EXTERIOR OF THE RIM WITH A METAL NUT. THE NUT HAD POPPED OFF WHILE DRIVING, THUS THE STEM RETRACTED TOWARDS THE INSIDE THE RIM / WHEEL AND RELEASED ALL THE AIR IN THE TIRE. THE THREADS ON THE STEM WERE CORRODED AWAY AND COULD NO LONGER HOLD THE NUT IN PLACE. I HAD TO PURCHASE A NEW TIRE. I DECIDED TO HAVE THE TIRE STORE LOOK AT THE OTHER 3 STEMS / NUTS ON THE OUTSIDE. ONLY ONE OF THE THREE REMAINING NUTS COULD BE LOOSENED. THE OTHER TWO WERE FUSED IN PLACED DUE TO CORROSION. I DECIDED TO HAVE REMOVE THE OTHER 3 STEMS REMOVED AS I DID NOT TRUST THEM ENOUGH TO PUT MY WIFE OR GRANDSONS, OR ANY PASSENGER IN THE VEHICLE WITH ME AFTER SEEING WHAT HAPPENED. HAD I BEEN SEEING ONE OF MY OTHER DOCTORS, TAKING ROUTE 531 AT THE 65MPH LIMIT, AND THIS HAD HAPPENED ON ONE OF THE SEVERAL SEVERE CURVES, I SHUDDER TO THINK WHAT MAY HAVE HAPPENED. THE SENSORS ACTUALLY ARE LABELED AS 'CHRYSLER' PRODUCT. I HAVE CALLED BOTH VWCARES AND CHRYSLER AND BROUGHT THIS TO THEIR ATTENTION. I HAVE WARNED AS MANY FAMILY AND FRIENDS AS POSSIBLE ABOUT THESE TPMS SENSORS AND STEMS, AND ADVISED THEM ALL TO INSPECT THEIRS REGULARLY. OUR SON IS A GM TECHNICIAN AND ADVISED US THAT GM ACTUALLY RECOGNIZED THEY NEEDED TO UPGRADE THEIR VALVE STEMS A FEW YEARS AGO TO PROTECT SUCH AN OCCURRENCE. *TR
Aug 22, 2014
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED WHILE DRIVING 25 MPH THE LEFT REAR TIRE SENSOR THAT WAS LOCATED INSIDE THE TIRE CAME LOOSE CAUSING THE TIRE TO BECOME FLAT. THE VEHICLE WAS TAKEN TO A TIRE SHOP WHERE THEY INSTALLED THE SPARE TIRE AND INFORMED HIM OF THE LOOSE SENSOR WITHIN THE TIRE. THE DEALER NOR MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 3,300.
Jul 11, 2011
STEERING,SUSPENSION
2 complaints
VEHICLE PULLS TO THE RIGHT. VEHICLE WAS TAKEN TO DEALER THREE TIMES FOR REPAIR AND TO AN INDEPENDENT DEALER. ALIGNMENT PERFORMED EACH TIME, BUT VEHICLE CONTINUES TO PULL TO RIGHT. DEALER AND VWOA STATE THAT BECAUSE ALIGNMENT IS WITHIN SPEC THERE IS NOTHING THAT CAN BE DONE. I INDICATED THAT PROBLEM IS LIKELY WITH STEERING RACK, SUSPENSION OR SUB FRAME, BUT DEALER AND VWOA INSISTED THAT BECAUSE ALIGNMENT IS WITHIN SPEC THERE IS NOTHING ELSE THEY WILL DO. VEHICLE CONTINUES TO PULL TO THE RIGHT AND DRIVING VEHICLE REQUIRES CONSTANT PRESSURE ON WHEEL TO KEEP THE VEHICLE STRAIGHT. *TR
May 03, 2012
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE BEGAN ABNORMALLY PULLING TO THE RIGHT, CAUSING DIFFICULTY IN STEERING. THE CONTACT TOOK THE VEHICLE TO A LOCAL DEALER TO HAVE A WHEEL ALIGNMENT PERFORMED AND TO HAVE THE TIRES ROTATED YET THE FAILURE PERSISTED. THE CONTACT STATED THERE WERE MANY COMPLAINTS ONLINE REGARDING THE SAME YEAR, MAKE AND MODEL AS HIS WITH COMPLAINTS OF THE VEHICLE PULLING TO THE RIGHT INDEPENDENTLY. THE CONTACT WAS CONCERNED OF A POTENTIAL CRASH INVOLVED WITH THE FAILURE OCCURRING. THE FAILURE MILEAGE WAS 200. UPDATED 01/26/11*LJ UPDATED 04/18/11
Oct 04, 2010
ENGINE AND ENGINE COOLING
2 complaints
TL*THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED WITHOUT ANY WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER PLACING IT IN THE PARK POSITION. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HER THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS ALSO CONTACTED AND ADVISED HER THAT SHE WAS NOT INCLUDED IN ANY RECALLS. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.
May 10, 2011
WHILE DRIVING ON A HIGHWAY AT 65 MPH MY CAR SUDDENLY SHUT OFF AND THE STEERING WHEEL TIGHTEN UP. I WAS IN THE LEFT LANE AND WAS ABLE TO GET OVER TO THE SHOULDER. I TURNED THE VEHICLE OFF AND IT TURNED BACK ON WITH NO PROBLEM. A SECOND INCIDENT OCCURRED 03/09/11 AS I WAS ATTEMPTING TO TURN RIGHT AT AN INTERSECTION. MY STEERING WHEEL WAS SO TIGHT THAT I COULD NOT MAKE THE TURN AND HAD TO DRIFT TO THE OTHER SIDE OF THE INTERSECTION BECAUSE I HAD ALREADY SLOWED DOWN TO MAKE THE TURN. AGAIN THE CAR TURNED BACK ON. MY CAR ALSO FREQUENTLY STALLS IMMEDIATELY UPON TURNING IT ON BUT I THOUGHT NOTHING OF IT UNTIL IT STARTED STALLING WHILE DRIVING. I TOOK IT IN FOR SERVICE AND WAS TOLD THAT THEY COULD NOT REPLICATE THE PROBLEM AND THAT THE COMPUTER WAS NOT INDICATING A PROBLEM. THEREFORE THE CAR WAS FINE AND I SHOULD COME AND PICK IT UP. I INFORMED THEM WHEN I DROPPED THE CAR OFF THAT I READ ONLINE THAT THERE WAS A PENDING RECALL FOR THE IGNITION SWITCH THAT WAS RELEASED ON 03/10/11; HOWEVER, THE DEALERSHIP INFORMED ME THAT THEY COULD NOT REPLACE THE IGNITION SWITCH UNTIL THE RECALL WAS OFFICIAL SOMETIME IN APRIL BECAUSE THEY WOULD NOT BE REIMBURSED. I HAVE FILED A COMPLIANT WITH VW AND AM WAITING FOR A RESPONSE FROM THE REGIONAL MANAGER.
Mar 11, 2011
AIR BAGS
1 complaint
The contacts husband owns a 2010 Volkswagen Routan. The contact stated that the air bag safety light illuminated. The vehicle was taken to an independent mechanic who diagnosed with the air bag and air bag clock spring needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 98,153.
Mar 22, 2023
STEERING,ELECTRICAL SYSTEM,ENGINE
1 complaint
The vehicle turned off in the drive gear. I lost steering,breaking and control of vehicle.
Aug 23, 2021
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM
1 complaint
Hi - I have a 2010 VW Volkswagen that has an issue with headlights intermittently working, which is very hazardous and also the windshield wipers randomly turn on and the car was intermittently starting (now won’t start at all since 7/18/2021) among other things. Car appears to not be starting due to fuel relay with TIPM. The intermittent headlights is very dangerous but corrects itself in a few days so mechanics haven’t been able to figure it out. This car is related to the several Chrysler models from 2010-2014 (it states Chrysler on various parts of my VW Routan) that had a recall for issues with the TIPM box, which appears to be the issue with my vehicle. As far as I can tell the same recall was not issued for the Routan. Why? I’ve found many similar descriptions of Routan owners that have had the same issues I have and these go back to the TIPM. Will there be a recall? There is one of many links detailing people with the same issues/concerns. https://www.change.org/p/matthias-mueller-volkswagen-of-america-volkswagen-of-america-recall-the-routan-due-to-a-major-safety-issue my Vin is [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Jul 21, 2021
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,AIR BAGS
1 complaint
The TIPM is failing which is a common issue with the vehicle make/model. My particular vehicle was not covered under any recalls, however, I have the same tell tale TIPM failure issues as all of the cars that were part of the recall. My lights intermittently work which causes a safety hazard. They will either not turn at all, will turn on and start flashing, or will appear to be working as normal until I'm driving and then they will flash off intermittently. This puts anyone in my car as well as oncoming traffic at risk when my lights malfunction at night. The airbag warning indicator light also flashes off and on as well making me think that it may be failing whenever the TIPM is not functioning properly. The door locks and windows have also locked/unlocked and opened/closed at random (even when the vehicle is off and has been parked with the power off for hours). I spoke with the mechanic about all of these issues and he verified that it was likely a failing TIPM and that it is a well-known issue with the Routan. My vehicle is available for inspection any time. Volkswagen and Chrysler know that this is a common issue and yet they have put their customers in danger by not recalling all of the affected vehicles. I am not sure what date to put as the date of incident as this has been ongoing since I have owned the vehicle. I put the current date (as it happened just today) and mileage, however, please understand that this has been an ongoing issue for years and Volkswagen has failed to include my vehicle in any recalls even though this is a well-known issue.
May 20, 2021
ELECTRICAL SYSTEM,SEATS,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
THE WHOLE ELECTRICAL SYSTEM HAS GONE OUT WHILE DRIVING IN LIMESTONE COUNTY ALABAMA. KEYS DON'T START IT NONE OF AUTOMATIC DOORS WILL OPEN.
Oct 12, 2020
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
WHEN CAR IS RUNNING, EITHER IN PARK OR DRIVE, THE ENGINE CUTS OUT. WE MUST WAIT 30 SEC TO RESTART. IT WILL THEN RESTART. THIS ACTION HAPPEND BOTH WHEN THE CAR IS IN PARK AND DRIVE. THE ACTION HAPPENED ONCE IN OUR DRIVEWAY AND ONCE COMING OUT OF A CARRY OUT DRIVEWAY.
Aug 02, 2020
ELECTRICAL SYSTEM,STRUCTURE
1 complaint
DRIVERS SIDE SLIDING DOOR WILL NOT OPEN. I'VE TRIED ALL KINDS OF WAYS TO OPEN IT AND IT WILL NOT BUDGE. ALSO, WHEN DRIVING, CAR SHUT OFF WITH NO WARNING.
May 04, 2020
ELECTRICAL SYSTEM,AIR BAGS,UNKNOWN OR OTHER
1 complaint
IT TURNS ON ALL THE LIGHTS ON THE DASHBOARD SAYING IT NEEDS AUTO ASSIST SERVICE THERE IS NO PROBLEM WITH IT THE DEALER CANNOT TAKE CARE OF IT BECAUSE THEY DON'T TAKE CARE OF VOLKSWAGEN ROUTAN NO MORE
Dec 15, 2019
UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC),ENGINE
1 complaint
WHILE DRIVING (CAR IN MOTION)THE CAR TO PICK UP MY CHILDREN FROM SCHOOL, IT SOUNDED LIKE IT WAS DRAINING. THE ALERT LIGHT BEEPED SO I LOOKED AT DASH THE LIGHTS/INFO ON CAR STARTED BLINKING THEN THE CAR STOPPED COMPLETELY IN MIDDLE OF THE ROAD. NO POWER WOULD WORK I COULDN'T ROLL DOWN THE WINDOWS OR TURN ON HAZARD LIGHTS, I HAD TO PUT CAR IN PARK. THE KEY WAS STUCK IN THE IGNITION AND WOULD NOT START FROM A JUMP. THE CAR HAD NO WARNING SIGNS AND WAS RECENTLY INSPECTED AND CHECKED ON COMPUTER AND THEY WERE UNABLE TO GET ANY CODES OR SEE ANY ENGINE PROBLEMS. CAR WOULD NOT EVEN GO INTO NEUTRAL TO MOVE OFF THE ROAD. CAR WAS TOWED TO MY HOME AND STILL NOT ABLE TO JUMP BATTERY AND CAR WON'T START. ALL POWER REMAINS OFF AND CAN'T LOCK CAR WITH KEY EITHER.
Sep 06, 2019
FUEL SYSTEM, GASOLINE,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT CALLED HATFIELD VOLKSWAGEN (1495 AUTO MALL DR, COLUMBUS, OH 43228, (855) 627-5215) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE CONTACT STATED THAT THE FAILURE WAS SIMILAR TO A FUEL PUMP RELAY FAILURE. THE FAILURE MILEAGE WAS 80,000.*DT
Jun 18, 2019
POWER TRAIN,STRUCTURE,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 40 MPH. THE CONTACT ALSO MENTIONED THAT THE REAR PASSENGER DOOR MADE AN ABNORMAL NOISE WHEN BEING OPENED. THE VEHICLE WAS TAKEN TO HILEY VOLKSWAGEN OF ARLINGTON (1461 E INTERSTATE 20, ARLINGTON, TX 76018, (817) 575-6000) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE DEALER STATED THAT THE DOOR WAS NOT UNDER WARRANTY; HOWEVER, THE TRANSMISSION WAS REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED AFTER THE VEHICLE WAS REPAIRED. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 112,000.
Sep 28, 2018
ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
ESP ABS LIGHT ILLUMINATES WHILE CAR IS IN MOTION AND THE CAR WILL NOT SHIFT OUT OF GEAR WHEN STOPPED AS IF THE BREAK IS NOT DETECTED. HAVE TO SHUT CAR OFF IN THE MIDDLE OF TRAFFIC OR DROP OF LINES AND TURN BACK ON SEVERAL TIMES TO CLEAR ERROR AND GET SHIFTER TO SHIFT TO DRIVE GEAR. USED SNAP ON READER TO CHECK CODES AND DOES NOT RECOGNIZE CAR AS VW, INSTEAD IT PULLS UP CHRYSLER TOWN AND COUNTRY. TRIED TO REPLACE A BREAK LIGHT MODULE, THE PART WAS ACTUALLY FOR A DODGE NEON. (I AM ONLY OWNER, BOUGHT VAN BRAND NEW). SYMPTOM CAME BACK AFTER TWO DAYS. CODE READER CANNOT FIND ANYTHING CAUSING CODE TRIGGER. ALSO KEY DOESN'T ALWAYS WORK IN IGNITION SWITCH, MUST SOMETIMES TRY TO TURN ON 3 TIMES. THIS HAS OCCURRED SINCE PURCHASE. AMAZED AT ALL THESE SAFETY ISSUES AND YET VW DOES NOTHING. $34,000 CAR AND I AM GOING TO HAVE TO REPLACE IT ALREADY. ONLY 66,000 MILES ON THE CAR. TRANSMISSION REBUILT BY VW AT 12,000 MILES, ROTORS CHANGED AT 9,000 MILES, MOTOR PARTS REBUILT AT 35,000 MILES. CAR BURNS 6 QUARTS OF OIL EVERY 4,000 MILES. VAN DOORS WILL SHUT ON KIDS EVEN THOUGH THEY ARE SUPPOSED TO STOP WHEN SOMETHING IS IN THE WAY. WORST CAR I HAVE EVER BOUGHT, AND VW DOESN'T CARE TO RESOLVE ALL THESE ISSUES CUSTOMERS HAVE.
Oct 25, 2017
POWER TRAIN,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
VOLKSWAGEN ROUTAN 2010 WILL TURN OFF WHILE IN MOTION, ON HIGHWAY, STREET, OR WHEN STATIONARY. CAR IS AN AUTOMATIC AND WILL NOT ADJUST TO THE PROPER GEAR WHEN DRIVING. WHEN IN DRIVE THE CAR WILL ACT AS IF IT IS IN NEUTRAL AND ROLL BACKWARDS AND WILL NOT KICK INTO FIRST GEAR. THE ELECTRONIC SYSTEM NEVER WORKS PROPERLY AND IS CONSTANTLY NEEDING NEW BATTERIES VERY FEW MONTHS. THIS CAR IS UNSTABLE, UNSAFE, AND UNRELIABLE! THE VOLKSWAGEN ROUTAN 2010 NEEDS TO BE RECALLED IMMEDIATELY!
Sep 12, 2017
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
1 complaint
WHILE OPERATING THE VEHICLE THE CAR STALLED AN SIMPLY STOPPED IN THE MIDDLE OF DRIVING. COMPLETELY RIDICULOUS, VERY DANGEROUS! YOUR WEBSITE STATES THAT VEHICLES SAME YEAR, MAKE AND MODEL AND MANFU DATE THEVSAME HAVE RECALLS FOR EXACT SAME ISSUE. THIS IS URGENT. THIS COULD CAUSE THE DEATH OF ME OR MY FAMILY. IT MUST BE FIXED BY VW, ESPECIALLY WHEN RECALLS ARE THERE FOR SOME.
Apr 27, 2017
VISIBILITY
1 complaint
CPSC: 2010 VOLKSWAGEN ROUTAN THESE CARS SEEM TO HAVE AN INHERENT ISSUE WITH THE DRIVER SIDE WINDOW REGULATORS . *BF THE CONSUMER STATED WHEN THE WINDOW REGULATOR FAILED IT SOUNDED AS IF A BOMB WENT OFF AND HIT THE WINDOW. THE CONSUMER HAS 2 VOLKSWAGEN ROUTANS WITH THE SAME ISSUE. THE CONSUMER WOULD LIKE TO BE REIMBURSED FOR THE COST OF REPAIRS. *JS
Apr 04, 2017
ELECTRICAL SYSTEM,AIR BAGS
1 complaint
THE KEY SLIPS OUT OF THE ON POSITION AND THE ELECTRONIC SYSTEM DOES NOT ENGAGE. I THOUGHT MY VEHICLE WAS PART OF THE RECALL ISSUED BY VW IN 2015 (PART 573 SAFETY RECALL), BUT WHEN I TOOK IT TO THE DEALER TO BE DIAGNOSED AND REPAIRED, I WAS INFORMED THAT THIS RECALL IS VIN SPECIFIC AND MY VIN WAS NOT A PART OF THE RECALL AND THEREFORE THE REPAIR WOULD NOT BE COVERED BY VW. I CALLED VW AND THEY TOLD ME THE SAME THING, EVEN THOUGH IT IS THE EXACT SAME PROBLEM THAT IS LISTED IN THE RECALL AND THE PART THAT NEEDS TO BE REPLACED IS THE WIN MODULE. I NEED HELP! *TR
Dec 19, 2016
LATCHES/LOCKS/LINKAGES
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHEN THE CONTACT OPENED THE REAR SLIDING DOOR ON THE DRIVER SIDE, THE CHILD SAFETY LATCH FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE PART WAS BEING ORDERED FOR THE REPAIR. THE LATCH WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 06/14/16*LJ
Feb 10, 2016
ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. WHILE DRIVING APPROXIMATELY 20 MPH, THE ESP WARNING INDICATOR ILLUMINATED AND THE ENGINE SEIZED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 64,000.
Jan 06, 2016
STEERING,FUEL/PROPULSION SYSTEM
1 complaint
IN APRIL 2015 THE CHECK ENGINE LIGHT CAME ON IN MY 2010 VW ROUTAN, MAYBE A WEEK OR SO LATER IT STARTED TO STALL WHILE I WAS DRIVING IT. I TOOK IT TO AN IMPORT DEALER LOCALLY TO HAVE IT LOOKED AT AND WAS TOLD THAT THE EGR VALVE WAS BAD. THEY REPLACED IT, WHICH COST ME $400, AND PUT A NEW GAS CAP ON IT. IN JULY THE ENGINE LIGHT CAME ON AGAIN, HAD THE CODES RUN AT A PARTS STORE AND IT WAS THE EGR VALVE AGAIN. TOOK IT BACK TO THE SHOP THAT DID THE FIRST REPAIR BECAUSE IT STILL HAD A PARTS AND LABOR WARRANTEE WITH THEM. THEY REPLACED IT AGAIN. NOW, IN SEPTEMBER, MY ENGINE LIGHT IS ON AGAIN AND AGAIN IT SAYS IT'S THE EGR VALVE. I HAVE CALLED THE SHOP TO GET IT IN TO BE REPAIRED AGAIN, WAITING ON A CALL BACK. THIS ISSUE IS QUITE SCARY BECAUSE IT HAS AND PROBABLY WILL AGAIN STALL OUT ON THE HIGHWAY CAUSING ME TO HAVE TO TRY TO PULL OVER AND PUT IT IN NEUTRAL TO RESTART IT. I CALLED VW CUSTOMER CARE AND WAS TOLD THAT I WOULD NEED TO TAKE IT TO A VW DEALERSHIP AT MY OWN COST TO HAVE IT DIAGNOSED, AND BASICALLY TELL ME WHAT I ALREADY KNOW, I AM NOT SPENDING ANOTHER $400 TO REPLACE THIS VALVE WHEN I HAVE ALREADY DONE THAT ONCE THIS YEAR. BECAUSE I REFUSE TO PAY FOR REPAIRS THAT ARE COVERED UNDER THE ORIGINAL SHOP WARRANTEE VW REFUSES TO DO ANYTHING OR EVEN ACKNOWLEDGE THAT THIS IS AN ISSUE.
Sep 14, 2015
ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER
1 complaint
THIS WILL BE THE THIRD TIME THAT MY FIANCE AND I ARE EXPERIENCING THIS PROBLEM. I HAVE TAKEN MY VAN BACK TO THE DEALERSHIP THE FIRST WEEK OF JANUARY 2015, IT HASN'T BEEN 2 WEEKS AND THE PROBLEM HAS COME BACK. THE VAN IS GOING BACK TO THE DEALERSHIP TO GET FIXED. THIS MORNING THE WINDSHIELD WIPERS TURNED ON AND WON'T TURN OFF OR STOP WHEN WE TURN THE SWITCH TO TURN OFF, THE TURNING SIGNAL BLINKERS, AND THE HEATED SEATS WON'T TURN ON AT ALL. WE CALLED THE DEALERSHIP AND THEY SAID THE MANUFACTURE FIXED IT BUT THEY DON'T UNDERSTAND WHY IT'S HAPPENING. TO COVER OURSELVES WE HAVE A VIDEO OF THE PROBLEM AS IT HAPPENED THIS MORNING. WE DEPEND ON THIS VAN WHEN WE TO TRANSPORT MY 3 KIDS I DON'T WANT TO KEEP THINKING SOMETHING WILL HAPPENED ON THE ROAD WHILE IN USE OR CAUSE OR BE IN AN ACCIDENT ESPECIALLY THAT THE TURNING SIGNALS WON'T TURN ON. PLEASE INVESTIGATE. *TR
Jan 21, 2015
POWER TRAIN,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE STARTED VIBRATING AND THE SPEED FLUCTUATED INDEPENDENTLY. ALSO, THE VEHICLE STARTED TO JERK AND THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED WITH A FAULTY SENSOR. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Jan 06, 2015
POWER TRAIN,STRUCTURE,SERVICE BRAKES,ENGINE
1 complaint
BOUGHT THE VAN IN FEBRUARY 2012 SINCE THEN IT HAS BEEN IN THE SHOP 11 TIMES FOR TRANSMISSION,ROTORS,AND MY PASSENGER SLIDING DOORS THEY OPEN AUTOMATICALLY. NOW ITS LEAKING ANTIFREEZE AND WE BOUGHT EXTENDED WARRANTY AND THIS PART THE PLASTIC Y PART THAT CONTEXTS TWO HOSES THEY SAY ISN'T COVERED AND WANTS US TO PAY 450$ TO DO IT..THE VAN HAS 38,035 MILES WE BOUGHT IT WITH 18,563 MILES HOW CAN THIS VEHICLE HAVE THIS MANY PROBLEMS? MY POWER DOORS I BELIEVE IF THEY OPEN WHEN YOUR PUMPING GAS ISN'T RIGHT. *TR
Dec 03, 2013
VISIBILITY/WIPER
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE ENTERING A RESIDENTIAL GARAGE, THE REAR LIFTGATE GLASS EXPLODED AS THE REAR LIFT GATE HAPHAZARDLY OPENED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 17,000.
Oct 11, 2013
LATCHES/LOCKS/LINKAGES,VEHICLE SPEED CONTROL
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE BEGAN TO DECELERATE WITHOUT WARNING. IN ADDITION, THE KEY FOB FAILED TO UNLOCK THE FRONT DRIVER'S SIDE DOOR UPON ACTIVATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. AN UNKNOWN REPAIR WAS PERFORMED ON THE DOOR LOCK. THE TECHNICIAN WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE RELATED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 29,000. THE VIN WAS NOT AVAILABLE.
Aug 15, 2013
STEERING,WHEELS,SERVICE BRAKES
1 complaint
2010 ROUTAN WITH 26K MILES PULLS TO THE RIGHT AND MOST LIKELY HAS DONE SO SINCE I BOUGHT IT SINCE THE TIRES NEED REPLACING. THE BRAKES HAVE BEEN REPLACED AT 18K AND NOW NEED TO BE DONE AGAIN. VW DENIES THERE IS AN ISSUE WITH VEHICLES PULLING TO THE RIGHT. OPENED CASE 130240300 WITH VW. THEY REFUSE TO COVER THE COST TO DIAGNOSE THE CAUSE OF THE PULLING AND TIRE WEAR. RECALL NEEDS TO BE ISSUED I HAVE SEEN NUMEROUS POSTINGS WITH THE SAME ISSUE ONLINE. *TR
Apr 11, 2013
POWER TRAIN,EXTERIOR LIGHTING,STRUCTURE,SERVICE BRAKES
1 complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED NUMEROUS FAILURES. THE REAR ROTORS BECAME WARPED NUMEROUS TIMES AND THE DEALER REPLACED THE ROTORS FOUR TIMES. THE TRANSMISSION WOULD CAUSE THE VEHICLE TO LUNGE ABRUPTLY WHEN THE GEAR WAS SHIFTED FROM REVERSE TO DRIVE. ADDITIONALLY, THE FOG LIGHT ASSEMBLY BECAME OVERHEATED AND BURNED SEVERAL TIMES. THE PLASTIC ON THE FRONT PASSENGER SIDE DOOR BECAME FRACTURED AND CAUSED THE CONTACT TO SUSTAIN LACERATIONS TO THE RIGHT HAND AND FINGERS. THE VEHICLE WAS TAKEN THE TO THE DEALER WHERE ALL DEFECTIVE PARTS WERE REPLACED HOWEVER, THE CONTACT WAS CONCERNED THAT THE FAILURES WOULD LIKELY RECUR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 11,418 AND THE CURRENT MILEAGE WAS 14,470.
Nov 05, 2012
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
1 complaint
PURCHASED THE VEHICLE FROM THE DEALERSHIP IN APRIL 2011. WE TOOK A FAMILY VACATION IN JUNE AND NOTICED THAT THE VEHICLE SHUT ITSELF OFF A FEW TIMES WHILE IN MOTION; CAUSING THE VEHICLE TO LOSE POWER AND ALL STEERING. ON THE SAME TRIP, WHEN USING THE KEY FOB, THE ENTIRE ELECTRICAL SYSTEM WOULD FREEZE AND SHUT ITSELF OFF. IT EVENTUALLY TURNS BACK ON AFTER 5 OR SO MINUTES. THE WYNN MODULE WAS REPLACED. BEFORE DEPARTING FOR THE VACATION, WE HAD BRAKE ISSUES WITH THEM MAKING A GRINDING NOISE AND , SOMETIMES NO STOPPING POWER. DEALER REPLACED ROTORS. THE PASSENGER SLIDER DOORS HAVE ISSUES. WHEN CLOSING, THE DOOR'S SAFETY MECHANISM WOULD NOT BACK TRACK THE DOORS WHEN IT HIT SOMETHING COMING OR GOING INTO/OUT OF THE VEHICLE. THE DOOR SHUT ON MY SON! THE VEHICLE HAS BEEN TO THE DEALERSHIP MORE TIMES THAN A NEW VEHICLE SHOULD.... DID I MENTION THAT WE STILL HAVE BRAKE ISSUES AND ELECTRICAL ISSUES. IT SEEMS THAT ALL THE DEALERSHIP CAN SAY IS THAT WE CANNOT DUPLICATE THE SITUATION. EACH TIME THAT THE VEHICLE GOES TO THE DEALER, THEY HAVE IT FOR A WEEK OR MORE! I HAVE OWNED CHRYSLER/DODGE PRODUCTS BEFORE THIS AND THIS IS WHY I WENT TO A VW. NEEDLESS TO SAY, I DIDN'T DO MY HOMEWORK BEFORE PURCHASING. IT SEEMS THAT THIS VW IS A "CHRYSLER". AS OF TODAY, 15 JANUARY, I AM LOOKING INTO THE "LEMON LAW" AND POSSIBLY SEEKING LEGAL ACTION. SOMETHING NEEDS TO BE DONE. WHY DO WE HAVE TO WAIT UNTIL THIS VW VEHICLE CAUSES SERIOUS DAMAGE TO PROPERTY, PERSON AND MAYBE EVEN DEATH BEFORE THE NHTSA LOOKS INTO THE VW SITUATIONS?
Jan 15, 2012
POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
AUGUST 11, 2010 THE CHECK ENGINE LIGHT WAS ONE. CODES P0038 AND P0032 FOR 02 SENSOR FAULTS POPULATED. THE CODES WERE CLEARED. WE WERE WITHOUT THE USE OF OUR VEHICLE FOR APPROXIMATELY DAY. SEPTEMBER 13, 2010 THE CHECK ENGINE LIGHT CONTINUED TO COME ON. THE GROUNDS WERE TIGHTENED AND THE VEHICLE WAS TEST DRIVEN. A LOANER/RENTAL VEHICLE WAS ISSUED FOR APPROXIMATELY 2 DAYS. DECEMBER 3, 2010 THE CHECK ENGINE LIGHT WAS STILL COMING ON AND OFF. CHECK AND FOUND FAULT CODES STORED FOR REAR 02 SENSOR. THE FAULTY REAR 02 SENSOR WAS REPLACED. A LOANER/RENTAL VEHICLE WAS ISSUED FOR APPROXIMATELY 4 DAYS. FEBRUARY 18, 2011 THE CHECK ENGINE LIGHT WAS STILL COMING ON. IT WAS DETERMINED THAT THE ECM NEEDED TO BE RESET. THE ECM WAS RESET AND RECHECKED FOR CODES. A LOANER/RENTAL VEHICLE WAS ISSUED FOR APPROXIMATELY 1 DAY. MAY 13, 2011 THE CHECK ENGINE LIGHT WAS STILL COMING ON. THE ROUTAN STALLED OUT TWICE IN ONE DAY WHILE DRIVING. THE WIN MODULE WAS REPLACED AND TWO NEW KEYS WERE PROGRAMMED FOR THE VEHICLE. A LOANER/RENTAL VEHICLE WAS ISSUED FOR APPROXIMATELY 10 DAYS. OCTOBER 31, 2011 THE VEHICLE WAS HUMMING DURING ACCELERATION AND PULLING WITHOUT PROPERLY SWITCHING GEARS. METAL WAS FOUND IN THE PAN BELL, HOUSING AND COMPOUNDS. THE TRANSMISSION WAS REPLACED. A LOANER/RENTAL VEHICLE WAS ISSUED FOR APPROXIMATELY 13 DAYS. DECEMBER 7, 2011 THE ROUTAN STALLED OUT TWICE WHEN GOING FROM REVERSE TO DRIVE. A LOANER VEHICLE WAS ISSUED AND WE WERE WITHOUT THE USE OF OUR VEHICLE FOR APPROXIMATELY ONE DAY. DECEMBER 16, 2011 THE VEHICLE STALLED WHILE IN MOTION TWICE, ONCE WHILE STOPPING AT A TRAFFIC SIGNAL AND AGAIN WHILE PARKING AND PLACING THE VEHICLE IN REVERSE. WE TOOK THE VEHICLE TO YOUR DEALERSHIP TO BE TESTED AND REPAIRED. WE WERE ISSUED A LOANER VEHICLE. AS OF TODAY, DECEMBER 16, 2011, WE ARE STILL WITHOUT THE USE OF OUR VEHICLE. *TR
Dec 16, 2011
SERVICE BRAKES, HYDRAULIC
1 complaint
THE REAR ROTORS ARE FOUND TO BE OUT OF SPECIFICATION FROM THE FACTORY. THE VEHICLE VIBRATES SEVERELY WHEN BRAKING FROM SPEEDS IN EXCESS OF 50 MPH. I FIRST COMPLAINED ABOUT THE PROBLEM TO THE DEALERSHIP THE VEHICLE WAS AT APPROXIMATELY 3,500 MILES AND WAS TOLD THAT IT WAS A TIRE PRESSURE PROBLEM AND THAT THE ROTORS WERE FINE. I COMPLAINED AGAIN AT APPROXIMATELY 9,000 MILES AND WAS TOLD THE SAME THING. FINALLY AT 12,606 MILES I RETURNED TO THE DEALERSHIP AND REQUESTED THAT THEY TEST THE VEHICLE AT 50 MPH, AS ON PREVIOUS OCCASIONS THEY HAD DRIVEN IT IN THE PARKING LOT AND THE PROBLEM DOES NOT MANIFEST AT SPEEDS BELOW 40 MPH. THE DEALERSHIP FINALLY ADMITTED THAT THERE WAS A PROBLEM WITH THE REAR ROTORS IN THAT THE WERE OUT OF SPECIFICATION, I.E. THE WRONG ONES HAD BEEN INSTALLED AT THE FACTORY. MY CONCERN IS THAT AN ACCIDENT COULD HAVE OCCURRED DUE TO THE INCORRECT ROTORS AND I NOW WONDER HOW MANY OTHER ROUTAN VANS LEFT THE FACTORY WITH THE SAME PROBLEM. IF THE DEALERSHIP AND DONE A PROPER JOB WHEN I FIRST COMPLAINED ABOUT THE PROBLEM I WOULD NOT BE CONCERNED AT THE MOMENT. VW COULD HAVE FACED A SEVERE LIABILITY LAWSUIT IF I HAD BEEN INVOLVED IN A CRASH BECAUSE OF THE OUT OF SPECIFICATION ROTORS. *TR
Nov 03, 2011
ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
WAS DRIVING ON A FREEWAY WITH A BABY WHEN THE CAR WILL NOT MOVE FORWARD WHILE RUNNING AT 60MPH. VERY DANGEROUS ESPECIALLY WITH A BABY. THE CAR WAS ALSO BACKING UP IF WE DO NOT STEP ON THE HANDBRAKE. THE PREVIOUS DAY BROUGHT THE CAR TO THE DEALER BECAUSE I TOLD THEM THAT THE CAR WILL NOT MOVE EVEN IF I STEP ON THE GAS AND THE ENGINE LIGHT IS ON. ALSO TOLD THEM TO CHECK THOROUGHLY BECAUSE I AM GOING ON A ROADTRIP. THEY CALLED AND SAID THE CAR DOES NOT HAVE A PROBLEM. I FOUND OUT THAT VOLKSWAGEN HAS AN ISSUE WITH TRANSMISSION. SERVICE CENTER SHOULD HAVE LOOK INTO THIS BEING THAT IT IS COMMON PROBLEM WITH VOLKSWAGEN BEFORE RELEASING THE CAR. ALSO WHEN I CALLED THEIR ROADSIDE ASSISTANCE THEY SAID THAT THE NEAREST DEALER WILL NOT TAKE OUR CAR BECAUSE WE NEED AN APPOINTMENT. ( FOR AN EMERGENCY) WHAT DO WE DO, I EVEN TOLD THEM WE HAVE A BABY WITH US AND WE ARE IN A BUSY FREEWAY. WE HAD TO CALL AGAIN AND TELL THEM THE SITUATION. THEN THE DEALER HELPED US. CALLED VOLKSWAGEN CUSTOMER SERVICE ON 9/06 TOLD A GUY NAMED[XXX]. ABOUT THEIR WARRANTY AND SAID TALK IT OUT WITH THE DEALER, DEALERS ARE A PRIVATE OWNED COMPANY. WHO DO WE THEN BRING THE CAR FOR REPAIR FOR CARS UNDER WARRANTY? WHEN I CALLED THEIR CUSTOMER SERVICE SEEMS LIKE TRANSMISSION ISSUE IS NOT SOMETHING IMPORTANT BUT NOT FOR SOMEBODY LIKE ME WHO DRIVES WITH A BABY IT IS VERY IMPORTANT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
Sep 06, 2011
STRUCTURE,LATCHES/LOCKS/LINKAGES
1 complaint
POWER REAR SLIDING DOORS OPEN AND THEN CLOSE WHEN YOU OPEN THEM WITH THE KEY FOB, HANDLE, OR INSIDE SWTICH. WHEN THIS HAPPENS THE SAFETY FEATURE DOES NOT WORK. *TR
Jun 09, 2011
VEHICLE SPEED CONTROL
1 complaint
I HAD THE FOLLOWING PROBLEM OCCUR WITHIN THE FIRST FEW MONTHS OF OWNING A 2010 ROUTAN. (THE DEALERSHIP TOLD ME THAT IT WAS NOT A PROBLEM, RATHER THAT I WAS NOT FAMILIAR WITH THE WAY THE NEW TRANSMISSIONS WORK.) WHEN THE CRUISE CONTROL IS SET NEAR 50 MPH AND THE VEHICLE GOES DOWNHILL IT WILL DOWNSHIFT AUTOMATICALLY AND THE ENGINE WILL INCREASE ITS RPMS, ESSENTIALLY CREATING A MOTOR-BRAKE THAT KEEPS THE SPEED LESS THAN ABOUT 55 MPH. I ACCEPTED THEIR EXPLANATION AND THEIR ASSURANCE THAT IT WAS SAFE AND WOULD NOT DAMAGE THE VEHICLE. I HAVE ONLY OBSERVED THIS HAPPENING AT SPEEDS NEAR 50MPH. HOWEVER, THIS SUNDAY WHEN IT HAPPENED ON A PARTICULARLY LONG, WINDING HILL, I DECIDED THAT I WOULD PREFER TO MANUALLY USE THE BRAKE, SO AFTER IT BEGAN DOWNSHIFTING I PRESSED THE CRUISE CONTROL BUTTON TO TURN IT OFF. IT DID NOT TURN OFF. I PRESSED THE BUTTON SEVERAL MORE TIMES, BUT IT HAD NO EFFECT. I PRESSED MY FOOT ON THE BRAKE, BUT THE VEHICLE STAYED IN THE LOWER GEAR WITH THE ENGINE REVVING AND IT APPEARED TO ME THAT THE BRAKE AND THE ENGINE WERE WORKING AGAINST ONE ANOTHER. I DECIDED TO LET THE VEHICLE CONTROL ITSELF UNTIL WE RETURNED TO LEVEL GROUND. ONCE WE REACHED LEVEL GROUND AND I COULD HEAR THE ENGINE BEGIN TO REDUCE ITS RPMS, I PRESSED ON THE BRAKE AND THE CRUISE CONTROL DISENGAGED. THIS WAS SCARY BUT CONTROLLABLE BECAUSE THE ROAD WAS DRY AND THE ROAD, THOUGH STEEP, WAS WIDE AND EASY TO NAVIGATE. HOWEVER, ON A SNOWY OR WET ROAD, THIS WOULD HAVE BEEN A VERY DANGEROUS PROBLEM AND IF IT HAPPENS TO ANYONE ELSE THEY MAY PANIC AND DO SOMETHING EVEN MORE DANGEROUS. THEN, AN ACCIDENT INVESTIGATOR WILL NOT REALIZE THE CAUSE OF THE ACCIDENT BECAUSE, AS IN MY CASE, THE CRUISE CONTROL WILL BE TURNED OFF. BUT THE DRIVER WILL NOT HAVE BEEN IN CONTROL OF THE VEHICLE. THIS, I BELIEVE IS A VERY UNSAFE SITUATION. I HAVE NOT REPORTED THIS SUNDAY'S INCIDENT TO THE DEALER OR TO VW.
May 25, 2011
FUEL SYSTEM, OTHER,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
I PURCHASED A 2010 VW ROUTAN IN MAY 2010. I HAVE HAD MULTIPLE ISSUES WITH THE VEHICLE SINCE THAT TIME - ELECTRICAL ISSUES WITH THE SLIDING DOORS, TRANSMISSION NOT SHIFTING CORRECTLY, THE VEHICLE'S STRAINED ABILITY TO BACK UP WHEN STOPPED/PARKED ON A DECLINE. THE ONLY ISSUE WHICH HAS BEEN SATISFACTORILY ADDRESSED TO DATE IS THE SLIDING DOOR ELECTRICAL ISSUE. MY MOST PRESSING CONCERN, HOWEVER, INVOLVES A STALLING ISSUE WHICH OCCURS WITHOUT WARNING AND WITHOUT ANY PARTICULAR PATTERN. ON SEPTEMBER 2, 2010, WHILE TRAVELING ON THE INTERSTATE AT APPX 60 MPH THE VEHICLE STALLED OUT. FORTUNATELY, MY HUSBAND WAS DRIVING AND WAS ABLE TO PULL THE VEHICLE TO THE SIDE OF THE ROAD. ONCE STOPPED, THE VEHICLE RESTARTED WITHOUT TROUBLE AND WE WERE ABLE TO REACH A SAFE LOCATION TO CALL THE DEALERSHIP. THE DEALERSHIP HAS BEEN UNABLE TO IDENTIFY ANY PROBLEMS WITH THE VEHICLE AS THEY SAY THE "DIAGNOSTIC TESTS" SHOW NOTHING IS WRONG AND THAT IT IS OPERATING ACCORDING TO THE MANUFACTURER DESIGN. I PURCHASED THIS VEHICLE IN LARGE PART TO THE VW HIGH SAFETY RATING, YET, I AM NOT CONVINCED THIS VEHICLE LIVES UP TO THAT STANDARD. I PREVIOUSLY OWNED A VW PASSAT PRIOR TO THE PURCHASE OF THE ROUTAN AND WAS VERY PLEASED. HOWEVER, I CANNOT SAY THE SAME ABOUT MY EXPERIENCE WITH THE ROUTAN. A VEHICLE THAT STALLS WITHOUT EXPLANATION IS A SAFETY CONCERN WHICH I WOULD HOPE WOULD BE INVESTIGATED AND ADDRESSED IMMEDIATELY. *TR
Mar 09, 2011
STEERING,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING
1 complaint
2010 ROUTAN WITH LESS THAN 10K MILES ON IT. WHILE DRIVING ON A CITY STREET THE VEHICLE SHUT OFF LEAVING US WITH NO POWER BRAKES, NO POWER STEERING AND VERY LITTLE CONTROL OF THE CAR. MY HUSBAND WAS ABLE TO PULL OVER AND WAIT FOR THE CAR TO STOP. HE THEN PUT IT IN PARK AND RESTARTED IT. WE TOOK IT STRAIGHT TO THE DEALERSHIP SERVICE. THE SAME THING HAD HAPPENED TO ME THE DAY BEFORE AND AT LEAST A DOZEN TIMES BEFORE THAT. I THOUGHT IT WAS SOMETHING I WAS DOING. VW SERVICE CAN FIND NOTHING WRONG WITH THE VEHICLE AND WE HAVE MADE IT CLEAR THAT THEY CAN KEEP IT UNTIL THEY DO. WE DO NOT FEEL SAFE AND WILL NOT TRUST OUR LIVES OR THE LIVES OF OUR CHILD AND FRIENDS IN THIS CAR. I HAVE HEARD MANY OTHER PEOPLE WITH THIS SAME PROBLEM. SOMETHING NEEDS TO BE ADDRESSED ASAP. I HAVE CONTACTED VW AND NOTIFIED THEM OF THE PROBLEM AND WAITING FOR A CALL BACK. ALSO WAITING FOR NEWS ON OUR VEHICLE..DAY 2 AT THE SHOP. *TR
Feb 24, 2011
SERVICE BRAKES, HYDRAULIC,EQUIPMENT
1 complaint
ROUTAN SEEMED TO JOLT/SKID WHEN BRAKE WAS PRESSED. THIS WOULD HAPPEN APPROXIMATELY EVERY 3RD DAY. TOOK IT TO THE DEALERSHIP AND THEY FOUND THE ROTORS WERE WORN. THIS I CANNOT UNDERSTAND WHEN IT IS A NEW 2010 WHICH I PURCHASED IN AUGUST OF 2010. I DO NOT COMPREHEND AND UNDERSTAND THEIR EXPLANATION. THE DESCRIBED HOW THE ROTOR WORKS ALONG WITH THE BRAKE. BOTTOM LINE IS A MORE SENSIBLE MATERIAL IS BEING USED. THEY WERE NOT REPLACED ONLY TOUCHED UP. MAKES NO COMPLETE SENSE AND TO ME IS ALREADY A SAFETY HAZARD. ALSO THERE IS A TICKING SOUND COMING FROM THE ENGINE BUT THEY COULD NOT DETECT/FIND IT. I'M TO GO BACK AND DO A TEST DRIVE WITH THEIR TECHNICIAN SO THAT I CAN POINT OUT TO THEM THE SOUND. WELL TODAY WHEN I STARTED THE ROUTAN IT HAS MORE OF A CLICKING SOUND WHICH WAS NOT THERE BEFORE. I WOULD HEAR THE SOUND ONLY WHEN THE GAS PEDAL WAS BEING USED. WHEN GAS PEDAL WOULD BE RELEASED IT WOULD GO AWAY BUT NOW IT IS A CONSTANT SOUND. *TR
Jan 19, 2011
STEERING,POWER TRAIN
1 complaint
TL* THE CONTACT OWNS 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE TRANSMISSION AND STEERING GOES OUT ON THE VEHICLE. THE VEHICLE WILL STOP WHILE DRIVING AT ANY SPEED AND THE STEERING WILL FAIL. IF THE VEHICLE IS TURNED OFF AND RE-STARTED THE TRANSMISSION WILL WORK, BUT THE VEHICLE WILL CONTINUE TO SHIFT VERY HARD AND THERE IS A LOUD BANGING SOUND AND IT FEELS LIKE SOMEONE HIT THE VEHICLE. THE VEHICLE GIVES NO WARNING BEFORE THE FAILURES OCCUR. THE DEALER HAS INSPECTED THE VEHICLE AND STATED THAT THEY CANNOT FIND ANY PROBLEMS WITH THE TRANSMISSION. THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 659.
Sep 22, 2010
Frequently Asked Questions
How many problems does the 2010 VOLKSWAGEN Routan have?
The 2010 VOLKSWAGEN Routan currently has 239 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2010 VOLKSWAGEN Routan?
The most common problems reported for the 2010 VOLKSWAGEN Routan are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2010 VOLKSWAGEN Routan problem data come from?
All problem and complaint data for the 2010 VOLKSWAGEN Routan comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - VOLKSWAGEN Routan
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2004 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
Other VOLKSWAGEN Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models