2004 VOLKSWAGEN Touareg Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
231
Complaints Reported
Complaints by Component
POWER TRAIN
25 complaints
( STARTED NOTICING THIS PROBLEM ABOUT 1 TO 2 YEARS AGO)WHILE THE AUTOMATIC TRANSMISSION IS IN 5TH GEAR AND SPEEDS OF UNDER 50 MI./HR, WHEN STEPPING ON THE ACCELERATOR, THE AUTOMATIC DOWN SHIFT OCCURS WITH A VERY HARSH "KICK" TO A POINT THAT THE PASSENGERS FEEL THE JOLT. A FEW YEARS AGO, A SIMILAR PROBLEM REGARDING THE DOWN-SHIFT WAS SUBJECT OF RECALL WHICH THE DEALERS HAD TO INSTALL A "PATCH" ( UPDATED SOFTWARE) IN ORDER TO FIX THAT PROBLEM.
Jul 04, 2018
DRIVING ALONG IN A RESIDENTIAL NEIGHBORHOOD UNDER SLIGHT ACCELERATION AND A LOUD THUMPING NOISE BEGINS IN THE TRANSMISSION HUMP UNDER THE ARMREST - FELT LIKE SOMETHING HEAVY HAD BECOME WRAPPED AROUND THE DRIVESHAFT AND WAS CAUSING INTENSE VIBRATION ABOVE 30MPH. PARK THE CAR AND TOW TO REPAIR SHOP AND LEARN THE DRIVE SHAFT HAD BROKEN AND REQUIRED COMPLETE REPLACEMENT. THIS IS A VEHICLE THAT HAS NEVER BEEN OFFROAD AND VAST MAJORITY OF MILES ARE COMMUTING ON THE FREEWAY AND GENERAL AROUND-TOWN DRIVING. NO WAY SHOULD A WELL-MAINTAINED VEHICLE DOING LIGHT HIGHWAY DRIVING SUFFER A DRIVESHAFT FAILURE AT ONLY 105K MILES. CLEARLY A DEFECT THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR. REPAIR BILL WAS APPROXIMATELY $1600.
Jul 31, 2015
THE CENTER CARRIER BEARING ON THE DRIVE SHAFT WENT OUT. AT FIRST IT SOUNDED LIKE I HAD A FLAT TIRE BUT UPON FURTHER INSPECTION THAT WAS NOT THE CASE. THIS SEEMS TO BE A COMMON FAILURE. I WAS TOLD A DESIGN FLAW AND ALL OF THESE WOULD FAIL.. THE DEALERSHIP SAYS THAT THE ENTIRE DRIVE SHAFT HAS TO BE REPLACED. BUT IT WILL NOT BE COVERED SINCE IT IS OUT OF WARRANTY. SINCE THIS IS A COMMON FAILURE IT SHOULD BE FIXED BY VW AND NOT COSTING ALL THEIR CUSTOMERS OVER A GRAND TO FIX. *TR
Apr 22, 2013
REAR CENTER DRIVE SHAFT FROM GEARBOX TO DIFFERENTIAL, MIDDLE BEARING FAILS. VOLKSWAGEN ONLY SUPPLIES NEW SHAFTS FOR $1,400 NO BEARINGS OR EXCHANGE. THIS HAPPENS TO A LOT OF TOUAREGS ACCORDING THE CLUBTOUAREG FORUM. THIS IS A PREMATURE DESIGN FAILURE OF THIS CAR. *TR
Oct 15, 2012
AT 94,000 MILES TRANSMISSION PROBLEMS, TOLD TRANSMISSION NON-SERVICEABLE VW DOES NOT RECOMMEND ANY TRANSMISSION FLUID REPLACEMENT. COULD BE GEAR BOX COST $2400 OR ENTIRE TRANSMISSION COST $7,000. VWA WILL PAY $1,000 TO OUR CHOICE OF GEAR BOX OR TRANSMISSION REPLACEMENT BUT IF WE CHOOSE WRONG REPAIR WILL NOT PAY FOR ANYTHING FURTHER! VWA OBVIOUSLY IS AWARE OF PROBLEM AND DESIGNED THE TRANSMISSION IN SUCH A WAY THAT IT CAN'T BE SERVICED. WE HAVE HAD PRIOR ENGINE COIL RECALL REPLACED, UPDATED COMPUTER SOFTWARE AND REPLACED DRIVE-TRAIN AT COST OF $1900 AT 74,000 MILES. *TR
Sep 10, 2010
+ 20 more complaints for this component
FUEL/PROPULSION SYSTEM
19 complaints
I have contacted Volkswagen about my recall over a month ago the man claimed he ordered the parts and would be in contact but has never contacted me ever since and since then my vehicle has completely stopped working and the gas smell is at a very dangerous level
Nov 09, 2025
The flange for the fuel does not leak from that i can see couse if it was leaking it would be on the ground.
Sep 04, 2025
SUV IS NOT GETTING GAS TO ENGINE
Aug 09, 2020
THERE IS A STRONG SMELL OF GASOLINE OUTSIDE OF THE CAR AFTER THE CAR HAS BEEN DRIVEN (OR WHILE IT'S DRIVING, BUT IT'S NOT OFTEN I'M OUTSIDE OF THE CAR WHILE IT'S RUNNING). THIS IS DUE TO THE PLASTIC HOUSING ON THE FUEL PUMP THAT HAS DEVELOPED A CRACK, AND IS LEAKING GASOLINE. THIS IS SIMILAR TO ANOTHER RECALL, 17V583000, WHICH IS FOR THE FUEL FILTER FLANGE, BUT VW IS SAYING THEY WILL NOT COVER IT UNDER THAT BECAUSE THIS IS THE HOUSING, NOT THE FLANGE. BUT IT'S THE SAME RESULT...
Dec 04, 2019
FUEL FLANK WAS SEALED BY THE DEALERSHIP. HOWEVER, THERE IS FUEL LEAKING.
Jul 08, 2019
+ 14 more complaints for this component
AIR BAGS
17 complaints
The contact owns a 2004 Volkswagen Touareg. The contact stated while driving approximately 75 mph, the driver’s side curtain air bag deployed inadvertently. Due to the inadvertent air bag deployment, the vehicle failed to restart. The contact had not taken the vehicle to a dealer. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 90,000.
Jun 28, 2021
HIT A VERY MASSIVE POTHOLE AND IT CAUSED THE AIRBAG FAULTY STATEMENT TO APPEAR ON THE DASHBOARD. IT APPEARS THE AIRBAG ATTEMPTED TO DISCHARGE UPON HITTING A POTHOLE AND DID NOT DISCHARGE AND THUS THE AIRBAG MECHANISM WAS CONSIDERED FAULTY. A POTHOLE/RUMBLE STRIP SHOULD NOT CAUSE A AIRBAG FAULT TO APPEAR AS THIS COULD BE DANGEROUS.
Mar 10, 2019
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHILE DRIVING AT 50 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER SIDE SEAT AIR BAGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000.
Jan 14, 2016
BOTH RIGHT AND LEFT SIDE FRONT AIRBAG WIRING HARNESSES REQUIRED REPAIR WITHIN 600 MILES OF FIRST INCIDENT TO CORRECT PRIOR REPAIRS TO REPLACE HARNESS CONNECTORS WITH SPLICED WIRE UNDER VOLUNTARY SERVICE PACK "RECALL". BOTH REPAIRS WERE TRIGGERED BY AIRBAG FAULT LIGHT ON DASH. YOU HAD DONE AN INVESTIGATION IN 2006 ON THIS. VW WOULD NOT COVER THE REPAIRS BECAUSE I WAS "OUT OF WARRANTY". IT COST ME $600 TO FIX THE PROBLEM AND I HAVE NO ASSURANCE FROM THE DEALER IT WON'T OCCUR AGAIN OR THAT I WILL NEED NEW HARNESSES OR AIRBAG MODULES. *TR
Sep 09, 2014
2004 VW TOUREG FAULT WITH AIRBAGS. ELECTRICAL SYSTEM HAS FAILED WHICH HAS RESULTED IN ALL OF THE AIRBAGS TO BE DEACTIVATED. THE WIRING IS ROUTED AROUND THE HORN WHICH HAS RESULTED IN ONE SIDE OF THE HORN TO NOT WORK. UNSAFE AND NEEDS TO BE RECALLED. *TR
Jan 18, 2011
+ 12 more complaints for this component
ELECTRICAL SYSTEM
16 complaints
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHEN ATTEMPTING TO DRIVE. WHEN THE VEHICLE WAS STARTED, AN ELECTRICAL NOISE WAS HEARD FROM THE DASHBOARD. IN ADDITION, THE ELECTRICAL SYSTEM FAILED AFTER THREE DAYS. THE VEHICLE WAS TAKEN TO DAVID MAUS VOLKSWAGEN NORTH (1050 LEE RD, ORLANDO, FL 32810, PHONE: (407) 233-0529), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Dec 12, 2017
STRANDED WITH A DEAD BATTERY ON MULTIPLE OCCASIONS AS A RESULT OF A ELECTRICAL SYSTEM FAILURE WHICH VW ISSUED A TECHNICAL SERVICE BULLETIN ON AND FAILED TO NOTIFY THE CONSUMER THAT THERE WAS AN ISSUE WHILE UNDER WARRANTY. *TR UPDATED 01/25/10 *BF UPDATED 01/26/10.*JB
Jan 15, 2010
IF I DRIVE THE CAR FOR ONE HOUR AND TURN THE ENGINE OFF, WHEN TRYING TO RESTART THE ENGINE, THE STARTER WON'T CRANK. AFTER ANOTHER HOUR IT WILL RESET AND RESTART. IN AND OUT OF THE DEALER FOR 7 MONTHS AND SEVERAL REPAIR ATTEMPTS, THE STARTER STILL FAILS TO CRANK. *NM
Feb 09, 2007
I'VE BEEN HAVING VARIOUS PROBLEMS WITH THE ELECTRICAL SYSTEM ON MY 2004 VW TOUAREG FROM THE PURCHASE DATE OF 08/19/03. THE ALARM WOULD SOUND, WITHOUT CAUSE, THE DOORS WOULD NOT UNLOCK AND VARIOUS SWITCHES WOULD NOT WORK AT TIMES. ALL OF THE PROBLEMS WERE RANDOM. I BROUGHT THE CAR IN FOR REPAIR SEVERAL TIMES. BUT, THE PROBLEMS WERE NOT FIXED. IN APRIL 2006, MY CAR BATTERY WAS REPLACED BECAUSE IT WAS NO LONGER HANDLING A CHARGE. THE BATTERY CHANGE WAS A WARRANTY ITEM. AFTER THE BATTERY CHANGE, THE ELECTRICAL PROBLEMS BECAME MORE FREQUENT. MY TURN SIGNALS BEGAN TO ACT UP. WHEN I SIGNAL FOR A RIGHT TURN, THE BLINKER WILL CLICK TO THE LEFT ONE TO THREE TIMES, THEN TO THE RIGHT. I TOLD MURRIETA VW ABOUT THE PROBLEM AND BROUGHT THE CAR IN FOR WARRANTY SERVICE ON 06/30/06. THEY COULDN'T FIND A "FAULT CODE" AND COULDN'T MAKE THE CAR DUPLICATE THE PROBLEM. SO, THEY DIDN'T FIX THE CAR. I VIDEO TAPED THE PROBLEM FIVE TIMES, ON TWO DIFFERENT OCCASIONS AFTER THE 06/30/06. I ALSO HAVE TWO DIFFERENT WITNESSES WHO WITNESSED THE PROBLEM. I E MAILED THE VIDEOS TO MURRIETA VW AND SCHEDULED AN APPOINTMENT. I BROUGHT THE CAR BACK ON 07/08. MURRIETA VW WASN'T ABLE TO DIAGNOSE THE PROBLEM. I FEEL THAT THE CAR IS NOW DANGEROUS. IF I WERE TO SIGNAL A RIGHT TURN AT AN INTERSECTION, WITH AN ONCOMING CAR ASSUMING THAT I AM TURNING LEFT BECAUSE OF A DEFECTIVE TURN SIGNAL, I COULD END UP IN AN ACCIDENT. I'M NOT LOOKING FOR SPECIAL TREATMENT FROM VW. I JUST WANT MY CAR FIXED. 2004 VW TOUAREG SERIAL# W V G C M 67 L 04 D 002863. *JB
Jul 12, 2006
CURRENTLY, VW HAS PUBLISHED TECHNICAL SERVICE BULLETIN 27-05-01 AND 27-05-03 FOR THE TOUAREG RELATED TO BAD GROUND CONNECTIONS AT THE BATTERY AND A FAULTY BATCH OF GROUND/POSITIVE WIRES THAT RUN FROM THE GENERATOR TO THE BATTERY. HOWEVER, VW WILL ONLY REPAIR THE VEHICLE IF THE CAR GOES COMPLETELY DEAD, LEAVING THE DRIVER AND OCCUPANTS AT THE MERCY OF THE ENVIRONMENT THEY ARE STRANDED IN. AS THIS IS A SUV, THE ENVIRONMENT COULD BE ONE THAT POSES A THREAT TO THE WELL BEING OF THE OCCUPANTS. I HAVE OPENED CASE # 60111160 WITH VWOA AND EXPRESSED MY CONCERNS TO DWIGHT HARRISON VW IN SNELLVILLE, GA AND HAVE RECEIVED THE SAME RESPONSE......THE CAR HAS TO HAVE AN EXISTING NO-START CONDITION TO QUALIFY. *NM
Apr 01, 2006
+ 11 more complaints for this component
VEHICLE SPEED CONTROL
16 complaints
VEHICLE EXPERIENCED SUDDEN ACCELERATION WHILE ATTEMPTING TO MANEUVER INTO A PARKING SPACE, CRASHING INTO A WOODEN STRUCTURE. *TW
Feb 07, 2010
VEHICLE HAS AN INCONSISTENT LACK OF THROTTLE RESPONSE. WHEN PRESSING ACCLERATOR YOU MAY GET A RESPONSE, A DELAYED RESPONSE OR NOTHING. PULLING FROM STOP SIGN WITH A SAFE DISTANCE OF ONCOMOING TRAFFIC VEHICLE HESITATED ALMOST CAUSING COLLISION. HAVE BEEN ALMOST REAR ENDED WHEN VEHICLE DID NOT RESPOND TO THROTTLE AT STOP LIGHT.HAS BEEN TO DEALER 3 TIMES WITH NO RESOLUTION.*AK
Jan 26, 2006
DT: THE CONSUMER STATED THAT 2004, VOLKSWAGEN TOUREG EXPERIENCED LOSS OF ACCELERATION WHEN PULLING OUT. WHEN THE CAR IS STARTED IN THE MORNINGS IT IS FINE, BUT AFTER THE CAR SITS FOR A COUPLE OF HOURS IT STARTS HAVING A DELAY IN THE ACCELERATION WHEN PULLING OUT. THIS HAS BEEN HAPPENING FOR A COUPLE OF MONTHS. THE CAR HAS BEEN TO THE DEALERSHIP THREE OR FOUR TIMES, AND THEY COULD NOT FIX THE PROBLEM. THE DEALER SAID THEY WERE WAITING ON VOLKSWAGEN TO COME UP WITH A SOLUTION. THE CONSUMER CALLED VOLKSWAGEN, AND THEY SAID THAT THE CONSUMER SHOULD KEEP WORKING WITHIN THE TERMS OF THE WARRANTY UNTIL THE PROBLEM WAS SOLVED. THE PROBLEM AT THIS POINT SEEMED TO BE INTERMITTENT. AT THIS POINT NO ONE KNOWS WHAT IS WRONG WITH THE CAR. *AK
Sep 13, 2005
2004 VOLKSWAGEN TOUAREG THAT HESITATES UPON ACCELERATION FROM A COLD START APPROXIMATELY 20% OF THE TIME. THIS HESITATION PRESENTS A HAZARD TO BOTH PASSENGERS IN THE TOUAREG AND PASSENGERS IN VEHICLES OF ONCOMING TRAFFIC. VEHICLE BEGINS TO ACCELERATE THEN HESITATES. IT IS IMPOSSIBLE TO DETERMINE WHEN THIS MIGHT OCCUR. ALSO, THERE WAS A RECENT INCIDENT WHERE THE TOUAREG HESITATED AND THE VEHICLE BEHIND THE TOUAREG HAD TO RAPIDLY BRAKE TO AVOID REARENDING THE TOUAREG. IT HAS BEEN RETURNED TO THE DEALERSHIP ON 4 DIFFERENT OCCASIONS WITH THIS COMPLAINT HOWEVER THE DEALERSHIP INDICATES THEY CANNOT DUPLICATE THE COMPLAINT. VOLKSWAGEN OF AMERICA STATES NO PROBLEM FOUND. THE FOLLOWING QUESTIONS ON THIS FORM ARE NOT APPLICABLE AS NUMEROUS INCIDENTS HAVE OCCURRED ON NUMEROUS DATES AND WE ARE NOT ABLE TO INDICATE THE EXACT NUMBER OF INCIDENTS. THE ANSWERS GIVEN ARE ONLY TO ALLOW US TO PROCEED WITH THIS QUESTIONAIRE.*AK
Sep 02, 2005
MY VOLKSWAGEN TOUAREG HAS A "HESITATION" WHEN ACCELERATING AFFECTIONATELY KNOWN IN VW CIRCLES AS "DEATH LAG". MANY TIMES WHEN ATTEMPTING TO ACCELLERATE THE VEHICLE WILL JUST SIT THERE FOR 3-10 SECONDS EVEN IF THE ACCELLERATOR PEDAL IS DEPRESSED ALL THE WAY. THIS HAS NEARLY CAUSED NUMEROUS ACCIDENTS WITH SOME AVOIDED ONLY BY ONCOMING TRAFFIC SWERVING AND SKIDDING TO A STOP WHILE MY VEHICLE SITS STILL IN TRAFFIC.
Jul 06, 2005
+ 11 more complaints for this component
TIRES
15 complaints
WE HAVE A 2004 VOLKSWAGEN TOUAREG WHICH HAS HAD A CONTINUING PROBLEM SINCE JUNE 2009. THE TIRE PRESSURE MONITORING SYSTEM CONTINUALLY COMES ON WITH LOUD AND SOMETIMES INTERMITTENT AND SOMETIMES CONTINUING BEEPING WARNING OF FLAT TIRES, OR THE SYSTEM IS "LEARNING". EACH WHEEL HAS A BATTERY OPERATED UNIT (WHEEL SENSOR) WHICH WILL NOT BE REPLACED UNDER WARRANTY UNTIL THE BATTERY IS COMPLETELY DEAD. THERE IS A $75- CHARGE EACH TIME TO INFORM YOU THAT THE BATTERY IS NOT YET DEAD. IN THE MEANTIME YOU DRIVE ALONG WITH THE WARNING SIGNAL GOING OFF. *TR
Aug 07, 2010
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS, THE FLAT TIRE CAUTION WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE CONTINUED TO TRAVEL THREE TO FOUR MILES WHEN THE EMERGENCY FLAT TIRE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD, BUT DID NOT NOTICE ANY FLAT TIRES. THE WARNING INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND THEY STATED THAT THE FAILURE WAS RELATED TO A FAULTY MANUFACTURER DESIGN. THERE WAS NO REPAIR AVAILABLE. THE TECHNICIAN WAS UNABLE TO DISENGAGE THE TIRE PRESSURE MODULE TO AVOID THE FALSE WARNINGS DISPLAYED ON THE INSTRUMENT PANEL. THE FAILURE MILEAGE WAS 38,200 AND CURRENT MILEAGE WAS 40,083. UPDATED 3/19/09 *CN UPDATED 03/23/09. *JB
Feb 06, 2009
THE TIRE PRESSURE MONITORING SYSTEM WILL PERIODICALLY DISPLAY VARIOUS WARNING MESSAGES INDICATING A FLAT TIRE. TIRE PRESSURE HAS ALWAYS BEEN NORMAL (UNCHANGED FROM PRIOR TARE), AND VISUAL INSPECTION OF THE TIRE INCLUDING SOAP TEST HAS ALWAYS BEEN NORMAL. DEALER HAS BEEN UNABLE TO FIX THE PROBLEM, CITING INABILITY TO REPLICATE IT. *TR
Dec 04, 2008
FOR MONTHS I LISTENED TO "DEFECTIVE TIRE" WARNINGS AND "CHECK TIRE PRESSURE" WARNINGS - ALL TO NO AVAIL - EVERYTHING WAS FINE. FINALLY, A LIGHT CAME ON - "TIRE PRESSURE MONITOR SYSTEM FAULT". I TOOK IT IN THE VACAVILLE VW, AND THEY DETERMINED IT WAS THE TPMS MODULE (NOT THE SENSOR). I HAVE AN EXTENDED WARRANTY AND WAS FIRST TOLD THAT THE MODULE WAS A COVERED COMPONENT, WHILE THE SENSOR WAS NOT. I LEFT IT THERE FOR THE APPROPRIATE REPAIRS ON A THURSDAY (11-6-08). ON FRIDAY, I WAS INFORMED THAT THE REPAIRS HAD BEEN MADE, BUT WHEN TEST DRIVING THE VEHICLE, THE "CHECK ENGINE" LIGHT CAME ON. AFTER CHECKING...THEY FIND THE COIL IS BAD. VACAVILLE VW REPLACES THE COIL AND IT IS READY FOR PICKUP ON TUESDAY, 11-11-08. I PICK THE VEHICLE UP ON WEDNESDAY AND TWO DAYS LATER, THE TIRE PRESSURE MONITOR SYSTEM FAULT LIGHT COMES ON AGAIN. IT IS NOW AT VACAVILLE VW AND I AM WAITING TO FIND OUT WHAT IS WRONG NOW. *TR
Nov 17, 2008
2004 TOUAREG-EXCESSIVE WEAR ON ALL 4 TIRES, LESS THAN 20K MILES. *JB
Jan 21, 2007
+ 10 more complaints for this component
ENGINE AND ENGINE COOLING
10 complaints
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THE OXYGEN SENSOR EMMISSIONS WARNING LIGHT REMAINED ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE FAST ENOUGH DUE TO AN RPM MALFUNCTION. THE VEHICLE WAS TAKEN TO BE DIAGNOSED, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 134,447.
Feb 29, 2016
I OWN A VOLKSWAGEN TOURAREG. THE CAR HESITATED BEFORE ACCELERATING INTO AN INTERSECTION. I AM ON RECORD WITH THE DEALER. THIS HAPPENED SEVERAL TIMES ,AND ONCE ALMOST CAUSED AN ACCIDENT. I AM AN ATTORNEY IN FLORIDA, AND BECAUSE OF VOLKSWAGEN'S INACTION IN THIS AREA I WAS CONSIDERING A LAWSUIT IN THE SOUTHERN DISTRICT OF FLORIDA FEDERAL COURT SYSTEM. IN PURSUING THE INTERNET I FOUND SEVERAL OWNERS OF THE 2004 TOUAREG WITH THE SAME PROBLEM. *AK
May 16, 2007
THE VEHICLE IS UNDRIVABLE / UNPREDICTABLE WHEN THE AMBIENT TEMPERATURE IS BELOW ZERO (F). THIS PROBLEM WAS OBSERVED FOR 4 DAYS IN FEB. 2004. THE CAR WILL START, BUT SURGES AND BALKS SO BADLY YOU CAN'T DRIVE IT. THIS CONDITION WILL CONTINUE FOR OVER 20 MINUTES. IT WILL RE-OCCUR THE NEXT TIME YOU TRY AND USE THE VEHICLE SO LONG AS THE TEMPERATURE IS BELOW ZERO. THE SAFETY HAZARD IS THAT IT LEAVES YOU STRANDED WHEREVER THIS HAPPENS. THERE'S NOTHING THE OPERATOR CAN DO. VW HAS TRIED 3 REPAIRS: (1) CHANGE THE ENGINE OIL TO SYNTHETIC, (2) & (3) REPROGRAM THE ENGINE COMPUTER TWICE TO SUPPOSEDLY FIX THIS PROBLEM. IT'S NOW 2 YEARS LATER, AND WE ARE EXPERIENCING BELOW ZERO WEATHER AGAIN, AND THE EXACT SAME PROBLEM PERSISTS. MY DEALER IS NOT ABLE TO FIND ANY INFORMATION ON THIS PROBLEM, AND CAN'T GET ASSISTANCE FROM VW. I WILL CONTACT VWOA DIRECTLY AND INITIATE A CASE. FINALLY, IN RESEARCHING THIS PROBLEM, I HAVE FOUND MANY OTHER OWNERS OF THE V6 ENGINE WHO REPORT THIS PROBLEM AND SAY IT'S NEVER BEEN CORRECTED. *JB
Feb 03, 2007
DT*: THE CONTACT STATED THAT THE VEHICLE STALLED COMPLETELY WHILE DRIVING AT 5 MPH, AND THE STARTER MOTOR WOULD NOT ENGAGE WHEN THE KEY WAS TURNED TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.
Jul 17, 2006
2004 TOUAREG V6 ENGINE HAS BEEN A TORMENT, WITH 40 DIFFERENT PROBLEMS! BUT TWO OF THE PROBLEMS COULD BE CONSIDERED SAFETY CONCERNS! ERADICATE BRAKING WITH LURCHING AND ACCELERATION HESITATION BOTH OF WHICH SET UP AN UNPREDICTABLE DRIVING STYLE! BOTH OF THESE PROBLEMS ARE MAGNIFIED WHEN ATTEMPTING A LEFT TURN. THE DRIVER CAN NOT DEPEND ON A ASSURED PERFORMANCE AT CRITICAL TIMES . A DRIVER MUST HAVE CONFIDENCE THAT HIS OR HER VEHICLE WILL PERFORM WITH ASSURANCE AT ALL TIMES !*JB
Aug 11, 2005
+ 5 more complaints for this component
SUSPENSION
8 complaints
AIR SHOCK EXTERIOR HOUSING AND COUPLING ON AIR HOSE ARE MADE OF TWO NON COMPATIBLE METALS CAUSING THE AIR SHOCK TO DETERIORATE. THIS CAUSES THE AIR SHOCK TO LOOSE AIR PRESSURE. *TR
Aug 14, 2013
DRIVING 2004 TOUAREG EQUIPPED WITH AIR SUSPENSION. SPEED 55 STARTING RIGHT HAND SWEEPING TURN THE RIGHT SIDE AIR SUSPENSION BLEW OUT DROPPING THE FRONT END TO BUMP STOPS CAUSING REAR OF TRUCK TO BOUNCE AND GO SIDEWAYS CAUSING LOSS OF CONTROL OF VEHICLE. APPARENTLY THERE IS A TSB TO CHANGE THE MATERIAL OF THE CONNECTOR THAT BLEW OUT, HOWEVER DEALERSHIP IS NOT WILLING TO PERFORM IT UNLESS I PAY FOR ANYTHING THEY MAY BREAK IN THE PROCESS OF THE REPAIR. CORROSION IS CAUSING FAILURES IN THE NORTHEAST. *TR
Jan 23, 2010
MESSAGE READS "FAULT-RUNNING GEAR-SUSPENSION-WORKSHOP" SUBSEQUENT CHECK AT DEALERSHIP REVEALED A LEAK IN THE RIGHT FRONT AIR SPRING THAT NEEDS TOTAL REPLACEMENT. WE WERE ADVISED OF"NO SERVICE BULLETINS OR RECALLS" AND THE REPAIR IS AT OUR EXPENSE ($2445.00) SINCE WE WERE NEARLY 3,000 MILES OUT OF WARRANTY. THE VEHICLE HAS NEVER BEEN OFF ROAD, ALL MILE'S ARE HIGHWAY INCURRED. *TR
Aug 26, 2007
MY 2004 VW TOUAREG HAS BEEN DIAGNOSED WITH PREMATURE FAILURE OF THE FRONT SUSPENSION BUSHINGS. THE VEHICLE HAS NEVER BEEN USED OFF-ROAD. THE VEHICLE HAS 55K MILES ON IT. I BELIEVE THAT THIS IS AN INHERENT DEFECT IN THE POLYMER USED FOR THE BUSHINGS AND IT SHOULD BE REPLACED AT VW'S EXPENSE. VW HAS NOT BEEN RESPONSIVE TO MY REQUEST. I HAVE HAD MANY CARS IN MY LIFE, AND THIS TYPE OF FAILURE HAS NEVER OCCURRED, EVEN WITH UP TO 105K MILES. THE REPAIR IS ESTIMATED TO COST $1700. THIS TYPE OF FAILURE COULD LEAD TO A SERIOUS ACCIDENT BY THE FAILURE OF THE SUSPENSION SYSTEM AND LOSS OF VEHICLE CONTROL. *TR
Aug 02, 2007
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHILE DRIVING AT 25 MPH THE CONTACT OBSERVED THAT THE VEHICLE WAS OUT OF ALIGNMENT. 3 TO 4 WHEEL ALIGNMENTS WERE PERFORMED TO CORRECT THE FAILURE AND THE REPAIRS WERE UNSUCCESSFUL. THE FAILURE ALMOST CAUSED THE CONTACT TO HAVE A COLLISION. THE WEATHER NOR SPEED WAS A FACTOR. THE CURRENT MILEAGE WAS 39,000. *AK
Feb 16, 2007
+ 3 more complaints for this component
EXTERIOR LIGHTING
6 complaints
Hello: this is the 2nd VW TOUAREG this year to repair so far, this one is a 2004 model that I have had to replace complete left & right xenon headlamp assembly Very pricy. Wiring insulation turns brittle, cracks & falls off inside the headlamp assembly, This allows the bare wires to touch & short causing fuses to blow shutting off headlamps while driving at night. This I think should be recalled, I have fixed 5 of these TOUAREGs in 4 years for this same problem. THANK YOU 10/24/24
Oct 24, 2024
THE HEADLIGHT ASSEMBLIES ON THIS VEHICLE FAIL DUE TO THE INTERNAL WIRING INSIDE OF THE HOUSING. THIS LEADS TO ZERO VISIBILITY DURING NIGHT TIME. THE HEADLIGHTS WHEN OPERATING CORRECTLY ALSO DO NOT PRODUCE ENOUGH LIGHT OUTPUT TO BE ABLE TO SEE DURING THE NIGHT EVEN WITH A BRAND NEW ASSEMBLY.
Nov 07, 2018
THE HEADLIGHTS CONTINUOUSLY SHORT OUT AND STOP WORKING. THE WIRES ON THE HEADLIGHTS HAVE NO INSULATION BECAUSE IT HAS FALLEN OFF. THIS PROBLEM HAS BEEN FIXED MULTIPLE TIMES AND STILL CONTINUES TO HAPPEN. I CONTACTED THE LOCAL VW DEALERSHIP AND WAS NOT HELPED. I CONTACTED VW CORPORATE OFFICE AND NO HELP. THERE WAS A CLASS ACTION SUIT AGAINST VW FOR THIS VERY ISSUE. MORE THAN ONCE IT HAS LEFT MY DAD STRANDED BECAUSE HE HAD NO HEADLIGHTS TO DRIVE HOME WITH.
May 09, 2018
DEFECTIVE HEADLIGHTS IN 2004 VW TOUAREG, LIGHTS GO OUT PERIODICALLY WHILE YOU ARE DRIVING. THIS WAS AN ISSUE COVERED BY A CLASS ACTION LAWSUIT. NOW VW WON'T EVEN TALK TO YOU ABOUT IT AND REFERS YOU TO AN 800 NUMBER THAT WAS DISCONNECTED YEARS AGO. THIS IS A MAJOR SAFETY ISSUE AND VW IS RUNNING AWAY FROM THEIR LIABILITY. TYPICAL BEHAVIOR FOR VW.
Feb 11, 2016
THIS IS A PROBLEM IMPACTING A LARGE PERCENTAGE OF 2005-2006 VW TOUAREGS WITH HID HEADLIGHTS. WIRE IN HEADLAMP ASSEMBLY IS TO SMALL FOR LOAD. THE INSULATION DECAYS DUE TO HEAT AND RESULTS IN A SHORT WHICH WILL BLOW THE FUSE FOR AFFECTED HEADLIGHT. USUALLY OCCURS WHEN SWITCHING ON HIGH BEAMS OR HITTING A LARGE BUMP. WHILE THERE IS AN INEXPENSIVE DIY FIX, OUTLINED IN BELOW LINK, VW IS TELLING OWNERS THEY NEED TO SPEND $950 PER HEADLAMP TO REPLACE THE ASSEMBLY. HTTP://WWW.CLUBTOUAREG.COM/FORUMS/F43/TOUAREG-DEAD-XENON-FIX-CODE-01344-A-103130.HTML. *TR
Apr 27, 2014
+ 1 more complaint for this component
FUEL SYSTEM, GASOLINE
4 complaints
The contact owns a 2004 Volkswagen Touareg. The vehicle had previously been serviced at the dealer under NHTSA Campaign Number: 17V583000 (Fuel System, Gasoline) however, the fuel pump failed after the recall repair was performed. The vehicle was taken to the dealer and diagnosed with fuel pump failure. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 130,000.
Jun 14, 2022
2004 VOLKSWAGEN TOUAREG. CONSUMER WRITES IN REGARDS TO FUEL FILTER FLANGE SAFETY RECALL. *LD THE CONSUMER REQUESTED TO BE REIMBURED FOR THE REPAIRS COVERED IN THE RECALL. UPDATED 12/8/2017*JS
Dec 08, 2017
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR COMING FROM THE REAR DRIVER SIDE OF THE VEHICLE. THE CONTACT CALLED A LOCAL DEALER (PLATINUM VOLKSWAGEN, 45 NELSON AVE, HICKSVILLE, NY 11801) AND WAS INFORMED THAT THE PARTS WERE ON BACKORDER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND OPENED CASE NUMBER: [XXX]. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 220,638. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Nov 28, 2017
2004 TOURAG HAS A HESTIENCY IN STARTING CAUSING THE VEHCILE TO NOT MOVE IMMEDIATELY AND THEN SURGE FORWARD. WE ALSO OWN AN AUDI THAT HAD THE SAME PROBLEM AND THE REGIONAL AUDI MECHANICAL REP GOT IT STOPPED. VW MIGHT WANT TO CHECK WITH AUDI.
May 15, 2004
STRUCTURE
4 complaints
ALL OF THE EXTERIOR DOOR HANDLES ARE EXTREMELY LOOSE AND ONE OF THEM I HAVE TO MAKE SURE THAT THE HANDLE GOES IN ALL THE WAY BECAUSE MY KIDS SIT IN THE BACK SEAT AND I'M AFRAID THAT THE DOOR MIGHT SWING OPEN ONE DAY AND AN ACCIDENT MAY OCCUR. ALSO THE DOOR HANDLES SOMETIMES DON'T OPEN ON THE FIRST PULL WHETHER ITS FROM THE INSIDE OR OUTSIDE. *TR
Feb 03, 2014
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT WHENEVER IT RAINED, SHE WOULD FIND STANDING WATER INSIDE THE VEHICLE. ON ONE OCCASION WHILE ATTEMPTING TO START THE IGNITION, SPARKS EMITTED FROM THE IGNITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE SUNROOF DRAINS WERE THE CAUSE OF THE FAILURE. IN ADDITION, THE ABS CONTROLLER HAD BECOME RUSTED AND CAUSED THE VEHICLE TO ENGAGE IN FOUR BY FOUR MODE PERMANENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 90,000.
Aug 28, 2013
TWICE IN 18 MONTHS THE ENTIRE FRONT GRILL OF OUR 2004 VOLKSWAGEN TOURAEG HAS FLOWN OFF THE CAR, CRASHED INTO THE WINDSHIELD, AND THEN BOUNCED OFF THE TOP OF THE CAR INTO ONCOMING TRAFFIC. IN BOTH CASES THE MOTORIST, AND IN ONE CASE MOTORCYCLIST HAD TO SWERVE TO AVOID BEING HIT. THE FIRST TIME IT HAPPENED WAS IN SUMMER 2004. WE HAD IT REPAIRED AND VW ASSURED US IT WAS A FREAK INCIDENT, BUT IT OCCURRED AGAIN LAST SATURDAY. BOTH TIMES IT OCCURRED WHEN DRIVING AT HIGHWAY SPEED, BUT CERTAINLY NOT EXCESSIVELY. IT HAPPENED ONCE WHEN I WAS DRIVING, AND ONCE TO MY HUSBAND. THERE WAS NO WARNING AT ALL. THE GRILL DID NOT APPEAR TO BE LOOSE OR MAKING ANY RATTLING NOISES. WE FEEL VERY LUCKY THAT SERIOUS INJURY WAS AVOIDED, BUT ARE CONCERNED THAT THIS IS A RECURRING DEFECT THAT WILL SOONER OR LATER LEAD TO INJURY OR DEATH TO THE PEOPLE DRIVING BEHIND US IN PARTICULAR. *NM
Jan 31, 2006
WHILE TRAVELING WITH SUN ROOF OPEN VIBRATION INSIDE OF VEHICLE HURT CONSUMER'S EARS.*AK
Dec 17, 2003
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
3 complaints
My SUV was sitting for a few days at the airport and I when I got in the car, it started fine but the headlights, interior lights, power folding mirrors and the voltmeter were not working. I had to leave the car there since it was night time. The next day I drove it home in daylight and started checking fuses. I noticed two fuses (#2, #12) on the driver side fuse panel were failed. I replaced the #2, 5 amp, fuse and no changes were noticed. Then I replaced the #12, 25 amp, fuse and I heard a number of systems clicking and powering on; the lights flickered. Then I smelled burning and saw a puff of smoke come from under the dash. I immediately pulled the fuse . After troubleshooting, I found the body control module 7L6-937-049-K had caught fire internally and started to burn through the casing. Had I not pulled the fuse and disconnected the battery, this could have been catastrophic. Once I smelled the smoke, I realized it was like the acrid smell in the suv the night before. The fact the fuse blew the previous day saved the vehicle. It was parked on the fourth floor of parking garage at the airport so many vehicles could have been damaged and people endangered had it caught fire. Not to mention the disruption at an airport. There were no warning lamps. The only indication of a problem was the inoperable systems I mentioned. Also thinking back, the slight acrid smell was present the day I arrived at the airport, I had mistaken it for plane exhaust and car exhaust smells in the garage. The vehicle has not been inspected by any dealer, manufacturer or govermental agency. I have contacted the manufacturer for guidance and help with repairing. I am awaiting a response.
Apr 24, 2023
LIGHT WENT OUT ON DARK ROAD. NEARLY CRASHED. FOUND INSULATION ON WIRES FOR LIGHTS DETERIORATED. HARNESS WAS MELTED LOWER IN THE FENDER. ONLINE SEARCH FOUND SAME ISSUE IS COMMON AND INCLUDED FIRES.
Nov 17, 2020
ABOUT 2 WEEKS AGO, I STARTED BLOWING FUSES FOR THE DRIVERS SIDE TURN SIGNAL. I WOULD HAVE NO FRONT OR REAR TURN SIGNAL, AS WELL AS NO HAZARDS ON THE DRIVERS SIDE. I LOOKED INSIDE THE HEADLIGHT ASSEMBLY AND FOUND THAT ALL THE WIRING WAS EXPOSED DUE TO THE WIRING INSULATION ROTTING OFF, LEAVING EXPOSED WIRING. I AM A FIREFIGHTER, AND THIS IS A VEHICLE FIRE, WAITING TO HAPPEN. YOU CANT EVEN WRAP ELECTRICAL TAPE AROUND IT, DUE TO THE HEADLAMP UNIT NOT BEING ABLE TO BE TAKEN APART. I HAVE NO LEFT TURN SIGNALS, AND RISK BEING HIT, SIDESWIPED, OR GETTING A TICKET FROM THE POLICE FOR SOMETHING I CANNOT FIX. I HAVE REPLACED 4 DIFFERENT FUSES NOW TRYING TO FIX THIS.
Mar 11, 2017
POWER TRAIN,ELECTRICAL SYSTEM
3 complaints
THE ESP LIGHT CAME ON STEADY AND THE LIGHTS AROUND THE DIFFERENTIAL SWITCH CAME ON FLASHING. THEN THE VEHICLE LOST ELECTRICAL POWER AND WOULD NOT START. I HAD IT TOWED INTO THE DEALER AND THE SERVICE PEOPLE INDICATED THERE WERE NUMEROUS RECALLS ON THIS VEHICLE THAT CAUSED THIS PROBLEM. I WAS NEVER NOTIFIED OF THESE RECALLS. *TR
Oct 15, 2007
DT*: THE CONTACT STATED A WEEK AFTER HAVING THE TRANSMISSION REPLACED BY THE SERVICE DEALER, THE VEHICLE WAS DRIVEN 60 MPH ON THE HIGHWAY, AND THE ENGINE WARNING MESSAGE READ "TURN THE MOTOR OFF IMMEDIATELY", AS THE ELECTRICAL SYSTEM FAILED AND STALLED THE ENGINE. THE CONTACT WAS ABLE TO STEER AND COAST TO A STOP ON THE BREAK DOWN LANE. THE VEHICLE RESTARTED AND STALLED 7 TIMES BEFORE MAKING ONE MILE TO THE CONTACT'S DRIVEWAY. THE SERVICE DEALER PROVIDED A NUMBER TO A TOWING SERVICE. THE SERVICE DEALER DIAGNOSED THE PROBLEM AS AN ALTERNATOR AND ELECTRICAL FAILURE, DUE TO LEAKAGE FROM THE ENGINE WHEN THE ENGINE WAS REMOVED TO REPLACE THE TRANSMISSION. NO EVIDENCE WAS FOUND IN THE GARAGE OR DRIVEWAY, BEFORE OR AFTER THE PROBLEM OR WHILE PARKED IN THE DRIVEWAY WHILE WAITING FOR THE TOW TO THE SERVICE DEALER. THE MANUFACTURER WAS NOTIFIED. UPDATED 10/25/2006 - *NM
Sep 11, 2006
MY 2004 V6 VOLKSWAGEN TOUAREG FREQUENTLY STALLS AFTER THE ENGINE IS CRANKED. THIS HAS BEEN A PROBLEM SINCE WE PURCHASED THE VEHICLE IN OCT 2004. AFTER CRANKING YOU CAN PRESS ALL THE WAY DOWN ON THE GAS PEDAL BUT THE CAR WILL NOT MOVE AT ALL. AFTER A FEW SECONDS, IT WILL SPUTTER A LITTLE THEN MOVE THEN SPUTTER AGAIN THEN IT WILL DRIVE NORMALLY. THERE IS NO WAY TO TELL WHEN THIS WILL HAPPEN AND I AM CONCERNED THAT IT WILL CAUSE AN ACCIDENT IF I START THE VEHICLE THEN PULL OUT INTO ONCOMING TRAFFIC. *JB
Oct 06, 2005
VISIBILITY
3 complaints
2004 VW TOUAREG WINDSHIELD WIPER SYSTEM. WHEN WIPER IS SET TO WIPE CONTINUOUSLY, WIPER STOPS WHEN VEHICLE COMES TO A FULL STOP, AND WILL NOT BEGIN TO WIPE UNTIL VEHICLE EXCEEDS 5 MPH. DURING HEAVY RAINS, IT IS UNSAFE TO PROCEED TOO 5 MPH WHEN WINDSHIELD WIPER IS NOT WIPING. NO VISIBILITY IN HEAVY DOWNPOUR CONDITIONS, MUST PUT VEHICLE IN FORWARD MOTION TO WIPE AND SEE. ACCIDENT WAITING TO HAPPEN. MANUFACTURER INDICATES THIS IS A "FEATURE" NOT DEFECT! *NM
Oct 27, 2005
THIS HEADLIGHT WASHER(S) THAT POP UP FROM FRONT BUMPER CAME OFF DURING DRIVE FROM CA TO MD. DURING THE DRIVE BACK TEMPERATURE WENT INTO THE FREESING RANGE. WAS NOT AWARE THAT WHEN WASH THE WINDSHIELD THESE OTHER WASHERS POP UP TO WASHER THE HEADLIGHT. ANYWAYS, THEY DO AND DUE TO COLD IT GOT STUCK IN UP POSITION AND EVENTUALLY CAME OFF. DEALER INITIALLY SAID COVERED UNDER WARRANTY AND NOW SAYS THAT SINCE HAVE A SCRATCH ON SIDE BUMPER SOMEONE TEMPERED WITH THE WASHER. HOWEVER MORE IMPORTANTLY THEY SAID THAT IT HAS NEVER HAPPENED TO ANYONE BEFORE. I SAID MAYBE NOT YET OR IN DIFFERENT REGION SINCE THIS WAS WHEN DRIVING IN MUCH COLDER WEATHER. ALSO, THEY ALSO CONFIRMED THAT IT STUCKS IN THE DOWN POSITION WHEN THEY PUT IN A NEW ONE.
Mar 24, 2005
THE CONSUMER STATED THE DEFOGGER DID NOT DEFROST THE WINDSHIELD EFFICIENTLY. THIS CAUSED POOR VISIBILITY TO THE DRIVER. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION TWICE. THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. *JB *NM
Sep 14, 2004
STEERING,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)
2 complaints
THE EMERGENCY BRAKE ALARM WAS GOING OFF MORE FREQUENTLY AND TO SILENCE IT I WOULD PULL THE SPING ON THE BRAKE UP. THE BRAKE ALARM RANDOMLY WAS ANOYING BUT NOT A MAJOR CONCERN. I HADN'T HAD ANY MECHANICAL ISSUES WITH MY CAR UNTIL 01/23/16 I ATTEMPTED TO START MY CAR AND RECIEVED AN ERROR MESSAGE THE READ STEERING DEFECT AND IT WOULDN'T ALLOW YOU TO START THE CAR BEYOND THE ERROR MESSAGE. I HAD MY CAR TOWED TO VOLKSWAGON MENTOR OHIO AFTER HOLDING MY CAR FOR MORE THAN A WEEK I WAS FINALLY OFFERED A DIAGNOSIS THAT THE ACCESS MODULAR WAS NOT FUNCTIONING MEANING THE BRAIN OF THE VEHICLE WASN'T FUNCTIONING AND THE VW DEALERSHIP SERVICE DEPARTMENT DIDN'T HAVE ANSWER TO HOW THIS HAPPENED THEY HAD A $2500 SOLUTION TO THE PROBLEM AND THEY WERE MORE THAN HAPPY TO ASSIST IN REPLACEMENT OF THE ACCESS MODULAR WITH THERE HEARTY COST. THE BRAIN THE VOLKSWAGON ACCESS MODULAR STOPS FUNCTIONING AND VOLKSWAGEN AT NO FAULT OF MINE AND I'M CHARGED $2500 PLUS. MECHANICAL MAINTENANCE I UNDERSTAND BUT REPLACEMENT OF THE VEHICLES ACCESS MODULAR IS A REPAIR THAT I FEEL VOLKSWGON SHOULD COVER.
Apr 05, 2016
I RECENTLY PURCHASED A 2004 VW TUAREG IN JULY 1ST OF 2014. IMMEDIATELY UPON PURCHASING THE VEHICLE I BEGAN RECEIVING A PARKING BRAKE ALARM WHEN I TURNED ON THE VEHICLE. THE ALARM WOULD PERSIST UNTIL I PUSHED DOWN ON THE PARKING BRAKE. I WOULD ALSO RECEIVE AN OCCASIONAL ALARM FOR THE TIRE PRESSURE MONITORING SYSTEM. THEN, ON DECEMBER 15, 2014 THE VEHICLE REFUSED TO TURN ON AT ALL. THE DASHBOARD DISPLAY HAD A FLASHING STEERING WHEEL. I HAD THE VEHICLE TOWED TO A VOLKSWAGEN DEALERSHIP WHERE THE TECHNICIANS LOOKED IT OVER AND TOLD ME THAT THE CAUSE OF THE PROBLEM IS THAT TWO CABLES TOUCHED AND SHORTED OUT THE SYSTEM. AFTER 3 WEEKS OF HOLDING THE VEHICLE, THE COST OF REPAIR WAS QUOTED AT AROUND $3,500 TO REPLACE SOME MODULES. I WAS ALSO INFORMED THAT THIS MIGHT BE A RECALL ISSUE AS MANY OTHER 2004 VW TUAREGS HAVE HAD SIMILAR PROBLEMS. *TR
Jan 26, 2015
STEERING,ELECTRICAL SYSTEM
2 complaints
CAME OUT TO 2004 V8 TOUAREG,AND IT WOULD NOT START. MRI READS STEERING DEFECTIVE WORKSHOP. AFTER SOME RESEARCH I DISCOVERED THAT THIS IS A COMMON DEFECT IN TOUAREGS AND ONE WHICH VW REFUSES TO TAKE RESPONSIBILITY OF.IT RENDERS THE VEHICLE PARALYZED AND DUE TO IT BEING ALL WHEEL DRIVE, REQUIRES SPECIAL EQUIPMENT TO EVEN TOW IT. I AM FURIOUS. THIS IS A KNOWN, DANGEROUS ISSUE AND NO RECALL FOR IT - SHAME ON YOU VW. WHAT IF I WAS WITH MY YOUNG CHILDREN? THERE IS NO WARNING FOR THIS FAILURE. ALL IS FINE AND THEN WHAM, IT WILL NOT START, TURN OVER, SHIFT INTO NEUTRAL, ETC. YOU ARE 100% PARALYZED WHERE YOU ARE - BE IT AT A GAS PUMP OR A REMOTE DIRT ROAD. *TR
Dec 21, 2014
I WENT TO START THE CAR IN MY DRIVEWAY AND A RED WARNING ICON APPEARED ON THE INSTRUMENT PANEL. I LOOKED IT UP IN THE OWNERS MANUAL WHICH STATED THE ICON INDICATED A STEERING SYSTEM FAILURE. FURTHER, THE IGNITION KEY THEN STUCK IN THE IGNITION SWITCH/LOCK AND COULD NOT BE REMOVED. AS A RESULT THE TRUCK'S TRANSMISSION GEAR SELECTOR COULD NOT BE TAKEN OUT OF THE "PARK" DETENT. THIS RESULTED IN MY NOT BEING ABLE TO GET THE TRUCK TO A POSITION WHERE A TOW TRUCK COULD ACCESS THE CAR UNTIL THE SNOW MELTED TWO MONTHS LATER. THE VW AUTHORIZED REPAIR CENTER DIAGNOSED THE PROBLEM AS A FAILURE IN THE STEERING COLUMN. FURTHER, THEY STATED THAT THIS IS A COMMON FAILURE MODE FOR THIS MODEL AND THEY BELIEVED A RECALL OR CAMPAIGN WAS IMMINENT. THIS IS A SERIOUS DESIGN FLAW. IF IT HAD FAILED WHILE BEING DRIVEN THE RESULTS COULD HAVE BEEN CATASTROPHIC. ALSO VW MARKETS THIS TRUCK AS SUITABLE FOR OFF ROAD TRAVEL IN REMOTE PLACES, IF IT FAILED WHILE I WAS IN A REMOTE AREA, I COULD HAVE BEEN STRANDED AND PLACED IN GRAVE PERIL SINCE I WOULD NOT BEEN ABLE TO ROLL THE TRUCK TO AN AREA SUITABLE FOR RECOVERY OR FLAT TOW IT IF NECESSARY. *TR
Jul 05, 2012
SEAT BELTS
2 complaints
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THE REAR MIDDLE SEAT BELT SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT SEAT BELT SHOULD BE REPLACED BUT THE MANUFACTURER DID NOT KNOW HOW TO PROPERLY CORRECT THE PROBLEM. THE FAILURE AND CURRENT MILEAGES WERE 82,000. *TR
Jun 20, 2013
REAR MIDDLE SEAT BELT WAS JAMMED AFTER FOLDING DOWN THE REAR SEAT. *TR
Mar 17, 2013
POWER TRAIN,TIRES
2 complaints
I HAVE A 2004 TOUAREG AND HAVE BEEN HAVING TRANSMISSION ISSUES HARD SHIFTS, BUCKING AND HARD DOWNSHIFTS. I HAVE TAKEN THIS TO THE VW DEALER AND THEY SAY THERE IS NOTHING WRONG WITH THE TRANSMISSION. IT IS VERY VERY DANGEROUS WHEN ACCESS THE HIGHWAY AND IN SEVERAL CASES IT SHIFTS SO HARD THAT IT KNOCKS IT'S SELF OUT AND YOU HAVE TO PULL OFF THE HIGHWAY UNTIL RESETS TO 4TH GEAR FROM 6TH. I NOW HAVE TO SHIFT MANUALLY. I HAVE THIS ISSU E DAILY AND I KNOW THIS IS A WIDE SPREAD ISSUE. *TR
May 28, 2010
CONSUMERS VEHICLE IS EXPERIENCING ERRATIC SHIFTING. WHEN ACCELERATING FROM A STOP CAR WILL HESITATE AND JERK. *TS THIS PROBLEM SEEMS TO ONLY OCCURE WHIL THE TRANSMISSION IS IN LOWER GEARS. THE VEHICLE HAS BEEN TAKEN TO THE DELER AT LEAST THREE TIMES BUT THEY HAVE NOT BEEN ABLE TO LOCATE OR FIX THE PROBLEM. THE CONSUEMR HAS ALSO CONTACTED TEHE MANUFCATURE BUT THEY PROVIDED NO ASSISTANCE. THE TIRE HAVE EXCESSIVE WEAR AT ONLY 16000 MILES. *NM
Sep 28, 2005
LATCHES/LOCKS/LINKAGES
2 complaints
SENSORS ON THE DOOR HANDLE FOR THE 2004 VW TOUAREG FAILING TO WORK. I PUT MY CHILD IN THE BACK SEAT AND SHUT THE DOOR AND THE LOCKS ENGAGED WITH THE KEYS INSIDE. 2 YR OLD CHILD WAS LOCKED IN THE CAR UNTIL I COULD BREAK INTO THE HOUSE AND GET A SPARE SET OF KEYS. *TR
May 26, 2010
DOOR HANDELS STICK IN THE OPEN POSITION SO DOORS DO NOT CLOSE. TAKEN TO DEALER, DEALER DID NOT FIX ISSUE. MY DAUGHTER'S HAND THEN WAS HURT AFTER DOOR SLAMMED INTO HER AS IT WAS DID NOT LATCH DUE TO STICKING DOOR HANDELS. CALLED VOLKSWAGEN, THEN BOOKED THE CAR FOR REPAIR. AFTER COLLECTING CAR FROM DEALER'S SECOND REPAIR, THE PROBLEM STILL OCCURS, BUT AT NOT AS OFTEN. CAR STILL DEFECTIVE.
May 05, 2005
SUSPENSION,SERVICE BRAKES, HYDRAULIC
2 complaints
SCREECHING BRAKES. THE BRAKES WERE SCREECHING FOR THE PAST THREE MONTHS AND THE VW DEALERSHIP REPLACED THE PADS AND DISC. AFTER THREE ATTEMPTS, I WAS TOLD THAT THE SCREECHING IS NORMAL. ALSO, SINCE I BOUGHT THE SUV IN SETPTMBER 2004, I HAVE BEEN HAVING AN ALIGNMENT PROBLEM WHICH RESULTED IN EXCESSIVE TIRE WEAR. THE DEALER DID NUMEROUS ALIGNMENTS AND I CHANGED ALL FOUR TIRES( 3 TIMES), BUT THE PROBLEM STILL EXISTS. THE VEHICLE ONLY HAS ABOUT 28,000 MILES. *TR
Aug 27, 2008
VOLKSWAGEN TOUAREG 2004 DOES NOT STOP IN INCLEMENT WEATHER. *BF ALL FOUR TIRES WERE PRACTICALLY BALD AND THE VEHICLE NEEDED AN ALIGNMENT. THE FRONT TIRES WERE SLIGHTLY MORE WORN THAN THE REAR. ALSO, THE CLOCK WAS INOPERATIVE AND THE BRAKES WOULD LOCK UP ON SNOWY CONDITIONS. *SC
Feb 24, 2005
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE
2 complaints
I BOUGHT A 2004 VOLKSWAGEN TOUAREG NEW AND TREATED IT LIKE A BABY. DEALER SERVICE, NEVER OFF-ROAD. AT 80,000 MILES (I COMMUTE 200 MILES PER DAY ON THE FREEWAY) THE ENGINE BLEW. DEALER SAID THAT AFTER THE VEHICLE HAD BEEN PARKED AND TURNED OFF THE FUEL INJECTOR PARTIALLY FILLED A CYLINDER WITH LIQUID GASOLINE. LATER WHEN THE VEHICLE WAS STARTED THE PISTON SLAMMED INTO THE LIQUID AND BLEW THE ENGINE. PARTS ALONE TO REPAIR ARE $15,000. SINCE THE COST OF REPAIRS EXCEEDS THE VALUE OF THE VEHICLE I WON'T BE REPAIRING IT -- IT IS A TOTAL LOSS. *JB
Jan 20, 2007
WHEN MAKING RIGHT OR LEFT TURNS THE VEHICLE'S ENGINE HESITATED. THE CONSUMER WAS CONCERNED THAT THE FAILURE WOULD RESULT IN AN ACCIDENT. *AK *NM
Oct 15, 2004
POWER TRAIN,VEHICLE SPEED CONTROL
2 complaints
TL*- THE CONTACT STATED THAT SINCE SHE PURCHASED THE VEHICLE ACCELERATION HAS BEEN SLUGGISH. THE DEALER STATED THAT IT WAS THE NATURE OF THE BEAST, AND THERE WAS NOTHING THAT THEY COULD DO ABOUT IT. THE ENGINE WAS NOT POWERFUL ENOUGH TO SUSTAIN THE WEIGHT OF THE VEHICLE. THE CONTACT OFTEN TOOK THE VEHICLE FOR REPAIRS. NEITHER ROAD NOR WEATHER CONDITIONS HAVE BEEN FACTORS IN THE FAILURE.*AK WHEN ACCELERATING FROM A DEAD STOP, ACCELERATION IS SLOW BUT STEADY, WHEN ACCELERATING WHILE MOVING BETWEEN 40 MPH ACCELERATION IS NON-EXISTENT FOR APPROXIMATELY 3 SECONDS AND THEN TAKES OFF FAST. UPDATED 03/30/07. *JB
Jan 04, 2007
WHEN ACCELERATING FROM A VERY SLOW SPEED OR A "ROLLING" STOP, THE CAR HESITATES OR STALLS BEFORE ACCELERATING, THEN LURCHES FORWARD. THIS PROBLEM OCCURS RANDOMLY, BUT CONSISTENTLY. WHEN DRIVING UP A HILL TO A STOP, THE VEHICLE REGULARLY JUMPS FORWARD AT THE LAST DOWNSHIFT IN THE STOPPING PROCESS. THIS IS DANGEROUS AND THREATENS MY SAFETY, THOSE AROUND ME IN TRAFFIC, MY PASSENGERS, AND OTHER POTENTIAL DRIVERS OF MY VEHICLE. I'VE BEEN TOLD BY VOLKSWAGEN OF AMERICA & MY DEALER THAT THIS IS THE WAY THIS SUV IS DESIGNED TO PERFORM. THE FACT THAT THE "HESITATIONS/STALLS" OCCUR AT RANDOM ONLY FURTHERS MY POINT THAT THIS IS CLEARLY A DEFECT AND NOT "JUST THE WAY THIS MODEL DRIVES" AND "YOU JUST HAVE TO GET USED TO IT" AS I WAS TOLD BY THE SERVICE MANAGER AT MARTENS VW.*AK
May 21, 2004
SERVICE BRAKES, HYDRAULIC
2 complaints
6/04 & 9/04 - TOOK VEHICLE IN TO DEALERSHIP TO CHECK BRAKE EFFICIENCY & SQUEALING NOISE. BOTH TIMES DEALERSHIP REPORTED NO PROBLEM AND BRAKE NOISE WAS CREATED BY BRAKE DUST & WAS NORMAL. 2/05 - BRAKES FAILED AND CAUSED CAR ACCIDENT. *JB
Feb 13, 2005
WHILE PULLING INTO THE APT. PARKING LOT THE BRAKES FAILED AND THE STEERING WHEEL LOCKED, THERE WAS AN ALERT ON THE CONTROL SCREEN BUT I AM NOT SURE WHAT IT SAID. AS A RESULT THE CAR DROVE OVER A FIRE HYDRANT AND HIT THE TRUNK OF A CAR PARKED NEXT TO THE HYDRANT. BOTH FRONT WHEELS WERE DAMAGED AND THE DRIVERS SIDE WHEEL CAME COMPLETELY OFF. THERE WERE NO PHYSICAL INJURIES AND ONLY ONE PERSON (TOM) WAS INVOLVED IN THE ACCIDENT. THE POLICE WERE CALLED AND THE OFFICER STATED THAT THE BRAKES FELT "MUSHY." NO TICKETS WERE ISSUED. STILL WAITING FOR A ADJUSTER TO VIEW THE CARS INVOLVED. THE CAR WAS PURCHASED NEW IN AUG. AND WAS TAKEN BACK TO THE SERVICE CENTER TWICE WITHIN A MONTH. FIRST FOR AN AIR BAG PROBLEM, 2 FOR A BRAKE WARNING LIGHT. THEY DID NOT DO A DIAGNOSTIC FR THE BRAKES THEY ONLY CHANGED A LIGHT BULB. THE WARNING LIGHT CAME A WENT SPORADICALLY BEFORE THIS SERVICE. *NM
Jan 15, 2005
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ENGINE
1 complaint
Leaking gas caught on fire put it out but now I have no head lights no high beams replaced everything still nothing. All lights on dash go crazy kills battery all the time and had to replace something in the rear end. Overall it has cost me $2500 and I still have no headlights at all and leaking gas. It’s my only vehicle I hope next time it doesn’t catch back on fire could have been worse and still could be. Somebody could get hurt and I have kids.
Nov 25, 2021
ELECTRICAL SYSTEM,SERVICE BRAKES
1 complaint
LIGHTS ON THE DASH COME ON HILL ASSIST SHUTS ON AND OFF BY ITSELF BRAKE LIGHT COMES ON AND OFF SUNROOF HAS OPEN BY ITSELF AC HAS STOPPED WORKING AND THE NEXT DAY WORKS AGAIN HEATED STEERING WHEEL WORKS WHEN IT WANTS THIS HAPPENED WHILE YOU'RE DRIVING OR SITTING STILL EVERYTHING I HAVE READ ON THE INTERNET HAS POINTED TO AN ELECTRICAL ISSUE THIS IS AN EVERYDAY THING
Aug 20, 2019
ELECTRONIC STABILITY CONTROL (ESC),ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
I WAS DRIVING ON THE HIGHWAY @ 70MPR WHEN ALL OF A SUDDEN WITHOUT WARNING THE CAR STARTS ACTING SLUGGISH FOR A MIN THEN BACK TO NORMAL, AND RANDOMLY FOR THE NEXT HOUR OR SO DOES(I HAD A WAYS TO GO) THIS A FEW MORE TIMES. I GOT TO MY DESTINATION AND LET HER REST FOR THE NIGHT. THE NEXT MORNING IT WAS DOING FINE EXCEPT NOW THE EMISSION CONTROL LIGHT CAME ON AND STAYED ON. BY THIS TIME IT WAS TIME FOR THE 100,000 MILE MAINTENANCE TO BE DONE AND IT DID GREAT UNTIL ABOUT 6 MONTHS LATER I WAS DRIVING @ 35MPR WHEN IT STARTED LOOSING POWER, THO I ONLY LOST A LITTLE BIT OF POWER STEERING WAS FORCED TO COME TO A STOP, WHICH JUST HAPPEN TO BE A ONE WAY BRIDGE, BABY IN THE CAR AND HAD TO PUSH MYSELF THE REST OF THE WAY ACROSS IT. ONCE OFF THE BRIDGE I TURNED THE CAR OFF (IT STAYED ON TIL I DID THIS) LET IT REST A MINUTE AND IT STARTED UP FINE AND LET ME GO A FEW BLOCKS STILL SLUGGISH AND THEN LOST POWER AGAIN. I REPEATED THIS PROCESS FOR ABOUT 5 MILES OR SO WHEN I WAS FORCED TO PARK IT CUZ I DIDN'T WANT TO RISK CROSSING THE HIGHWAY AGAIN. HAD IT TOWED TO DEALERSHIP WHERE THEY DID THE FLANGE RECALL, THAT DIDNT' FIX THE PROBLEM SO HAD TO REPLACE BOTH FUEL PUMPS AND THAT WAS ROUGHLY @ 103,000. 8 MONTHS LATER IT HAPPENS AGAIN THIS TIME AROUND 107,000. DEALERSHIP TOOK 4 HOURS TO DIAGNOSE ONLY TO TELL ME I NEED THE FUEL TANK REPLACED BECAUSE SOMEHOW ALL THE WIRES, CONNECTORS, AND CAPS THAT HAVE TO DO WITH THE FUEL LINES/TANK/PUMPS ARE EITHER MISSING, CRACKED, OR DAMAGED SO I NEED A WIRING HARNESS AS WELL. THEY ARE QUOTING A ME $5000 FIX!!!
Jul 08, 2019
STEERING,SUSPENSION,WHEELS
1 complaint
TAKATA I WAS DRIVING PERFECTLY FINE AND I CAME UPON A TURNING TO MAKE THE LEFT AND OUT OF NO WHERE MY CAR START SLIDING OUT OF CONTROL I TRIED TO CONTROL IT BECAUSE THERE WAS A DITCH CLOSE BY WHERE I WAS IT WAS SLIDING TO THE RIGHT TRIED TO SPIN THE STEERING TO THE LEFT BUT THE CAR WAS JUST DOING WHAT IT FELT LIKE I ENDED UP HITTING IN THE RAIL WHERE THE DITCH WAS AND PUSHING THE CAR BACK INTO THE MIDDLE OF THE ROAD BEAR IN MIND I HAD MY CHILDREN IN MY CAR NO ONE CAN GIVE ME AN EXPLANATION TO MY MY CAR JUST SPIRAL OUT OF CONTROL AND I KNOW I WAS NOT DRIVING FAST I AM NOT A FAST DRIVER ONE THING IS TO BE DONE AND CHECK OUT WITH THIS VEHICLE BEFORE IT CLAIM THE LIFE OF ANYONE THAT GOD MY LOVE AND MY KIDS WAS SPARED THE BRAKES SPEED CONTROL AND BODY OF THE CAR WAS AFFECTED AS WELL BUT IT IS NOT ALLOWING ME TO SELECT ALL OF THE OPTIONS ABOVE
Mar 29, 2019
UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
THE TOUAREG MADE SOME RATTLING NOISE WHILE I WAS DRIVING AT 35 MPH. AS SOON I STOPPED AND MADE IT MY DESTINATION AND TURNED OFF THE CAR THE CAR WOULDN'T START UP. I TOOK IT TO THE DEALERSHIP AND THE DEALERSHIP COULDN'T FIGURE OUT WHY THE CAR WOULDN'T START. FINALLY, AFTER A WELL OVER A WEEK, THEY DETERMINED THAT I NEEDED TO REPLACE ALL SIX FUEL INJECTORS. THE FUEL INJECTORS GOT REPLACED NOW THE CAR TURNS ON BUT AS SOON AS YOU STEP ON THE GAS THE CAR DIES.
Jul 28, 2018
WHEELS
1 complaint
FROM THE DATE OF PURCHASE( IN DECEMBER OF 2003), TPMS HAS BEEN "ON" IN YELLOW/ORANGE COLOR INDICATING THAT THE TIRE PRESSURE IN ALL/VARIOUS LOCATIONS NEED ADJUSTMENT. AFTER INSPECTION BY MYSELF, GAS STATION ATTENDANTS, TIRE SHOP COMPANIES, AND VW DEALERSHIPS, I FINALLY GAVE UP. IN THE BEGINNING, THE DEALERSHIP ( WHERE I PURCHASED THE CAR) WOULD NOT OFFICIALLY ADMIT TO THE PROBLEM, BUT AFTER A COUPLE OF YEARS, IN A VERY INFORMAL WAY, THEY CLAIMED THE THIS TECHNOLOGY WAS BRAND NEW AND THAT IT HAS ITS FLAWS! THAT I SHOULD NOT TAKE THOSE WARNINGS TOO SERIOUSLY. UNAWARE OF ANY RECALLS, I GAVE UP ON THIS TOPIC. NOW, I JUST WANT TO BE ON THE RECORD!
Jul 04, 2018
AIR BAGS,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
DRIVE IT SHORT DISTANCE AND IT WON'T START AGAIN FOR HOURS! HAVE TAKEN IT TO VW TO PUT ON BRAKES AND ASKED THEM TO CHECK IT OUT, FOUND NOTHING! THEY HAVE KNOWN ABOUT THIS RECALL SINCE APRIL 2017 SHOWS AIR BAG LIGHT ON ALL THE TIME !
Dec 26, 2017
UNKNOWN OR OTHER
1 complaint
I WOULD LIKE TO KNOW IF MY CAR IS PART OF THE RECALL CARS
Oct 24, 2017
UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM
1 complaint
SOME WEEKS AGO, THE TV NEWS REPORTED A RECALL FOR MY VEHICLE. I HAVE HAD NO OTHER NOTIFICATION. I HAVE LIVED HERE FOR 51 YEARS AND HAVEN'T CHANGED MY PHONE NUMBER. WHAT IS MOST DISTURBING IS THAT YOUR WEBSITE KNOWS NOTHING ABOUT THIS!!! BESIDES CASHING YOUR PAYCHECK, WHAT ELSE DO YOU DO TO JUSTIFY BREATHING???
Oct 06, 2017
POWER TRAIN,UNKNOWN OR OTHER
1 complaint
TRANSMISSION JUMPS, LUNGES, HAS DONE THIS SINCE 2009. THE DEALER STATES IT NEEDS REPLACING. SHOULD BE REPLACED BY VOLKSWAGEN.
Jun 19, 2016
AIR BAGS,ENGINE
1 complaint
AIRBAG WARNING LIGHT COMES ON AFTER CHANGING BATTERY. LOCAL MECHANICS CAN'T TURN IT OFF. DEALER WANTS LARGE AMOUNT TO "DIAGNOSE" THE PROBLEM. SEVERAL OTHER OWNERS HAVE THE SAME ISSUE WITH THE SEATBAG WARNING SYSTEM COMING ON RANDOMLY...VERY DANGEROUS...AND VW KNOWS ABOUT THE PROBLEM. HAS BEEN HAPPENING FOR YEARS. THE OTHER ISSUE IS WITH THE ENGINE...THE 2004 TOUAREG ENGINE BLEW AT LESS THAN 50K...DEALER SAID WE MUST HAVE DRIVEN THE CAR WHEN IT WAS HOT. JUST NONSENSE. SEVERAL OTHERS HAVE HAD MAJOR PROBLEMS WITH THE TOUAREGS.. ENGINE PROBLEMS AND THE TRANSMISSIONS/ENGINES SURGE ON SLOWING DOWN OR EVEN SPEEDING UP. TONS OF PROBLEMS WITH THE VEHICLE LINE AND VW AMERICA AND GERMANY WILL NOT DO ANYTHING ABOUT. THE ENGINE BLEW WHEN IT WAS ABOUT 100 DEGREES OUTSIDE.. WE ALWAYS SERVICE OUR VEHICLES REGULARLY.
Jun 10, 2016
STEERING,VEHICLE SPEED CONTROL
1 complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE VEHICLE HESITATED AND WOULD NOT INCREASE IN SPEED WHILE THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT ALSO STATED THAT WHILE MAKING A TURN, THERE WAS A LOUD CLICKING NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.
Nov 24, 2015
SERVICE BRAKES,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHILE DRIVING AT 45 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE AND THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DIFFICULT TO DEPRESS. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. ALL WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT CLUSTER. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE CONTACT WAS UNSURE ABOUT WHAT REPAIRS WERE PERFORMED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 31,000. THE VIN WAS UNAVAILABLE.
Oct 28, 2015
POWER TRAIN,AIR BAGS,VISIBILITY/WIPER
1 complaint
AIRBAG MODULE DEFECTIVE WITH ONLY 54,496 MILES AND A $1200 COST TO FIX. THIS IS A SAFETY ISSUE! DASH LIGHTING HAS WENT ON AND OFF FOR AIRBAG. A WASHER PUMP DEFECTIVE, POWER TRAIN TRANSMISSION JUMPS AND HAS BEEN AN ONGOING PROBLEM AND KNOWN PROBLEM BY VOLKSWAGEN BUT NOBODY WANTS TO ADMIT THE DEFECT PROBLEM. *TR
Feb 04, 2015
POWER TRAIN,ENGINE
1 complaint
CAR STALLS, SKIPS GEARS, JERKS, WHEN COMING FROM A FULL STOP TO ACCELERATING JERKS AND PULL REALLY HARD GOING INTO 1ST AND 2ND GEAR,, TOOK IT TO THE DEALER AFTER PAYING 800 DOLLAR THEY COULD FIND ANYTHING WRONG,, AND THAT WAS VW DEALER.... I'VE BEEN SEEIN ALOT OF THE SAME COMPLAINTS FOR THIS SPECIFIC MODEL AND YEAR, CAN SOME PLEASE LET ME KNOW IF VOLKSWAGEN IS NOT GOING TO TAKE RESPONSIBILITY FOR THIS ISSUE ATLEAST TELL ME WHAT COULD BE WRONG, SO I CAN FIX IT AND GET RID OF THIS STUPID CAR. IM BETTER OFF WITH AN AMERICAN CAR... *TR
Oct 27, 2014
VISIBILITY/WIPER
1 complaint
I WAS DRIVING ON 101 SOUTH FROM SANTA ROSA TOWARDS SAN FRANCISCO AND WHEN IN THE NOVATO AREA THE REARVIEW MIRROR CAME OFF DANGLING FROM THE HEADLINER BY THE WIRING HARNESS RIGHT ON MY FACE. THE DANGLING REARVIEW MIRROR BLOCKED MY VIEW OF THE ROAD AND THIS BIG DISTRACTION NEARLY CAUSED AN ACCIDENT. THIS IS CLEARLY A SAFETY ISSUE, REARVIEW MIRRORS SHOULD NOT JUST RANDOMLY FALL OFF. I STRONGLY BELIEVE THAT VOLKSWAGEN OUGHT TO HAVE A RECALL FOR THIS DEFECTIVE MIRROR AND PERFORM A REPAIR AT VW'S EXPENSE. MY AAA CERTIFIED MECHANIC QUOTED ME IN EXCESS OF $700.00 TO RE-GLUE THE REARVIEW MIRROR TO THE WINDSHIELD. *TR
Aug 28, 2014
STEERING,ELECTRONIC STABILITY CONTROL (ESC)
1 complaint
WOULDN'T START SO HAD IT TOWED TO NORTHLAND VOLKSWAGEN. THERE THEY TESTED AND SAID I NEEDED STEERING COLUMN REPLACED AND WIRING DONE . NOT SURE BUT HAVE NEVER HAD PROBLEMS WITH COLUMN NOT PERFORMING CORRECTLY BUT I DON'T HAVE A CLUE ABOUT WIRING INSIDE ONE. THE REPAIRS ARE 2538.08 AND 1567.77 IS FOR THE COLUMN. *TR
Jul 30, 2014
STEERING,SERVICE BRAKES
1 complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO THE DEALER FOR REGULAR SERVICE WHEN HE WAS ADVISED THAT THE BRAKES NEEDED REPLACING. THE CONTACT WAS ALSO ADVISED THAT THE BOLTS TO THE CALIPERS WERE FRACTURED ALONG WITH THE STEERING LINKS, WHICH WOULD ALSO NEED REPLACING. THE DEALER REPAIRED THE BRAKE DISK, CALIPERS, BRAKE LINING, BOLTS AND THE STEERING KNUCKLES. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WAS NO LONGER COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 114,940. THE CURRENT MILEAGE WAS APPROXIMATELY 115,000. UPDATED 11/12/12 *CN THE CONSUMER STATED THE HOLDING CALIPERS NOT FRACTURED, THREADS WERE BADLY RUSTED INTO STEERING KNUCKLE REQUIRING REPLACEMENT OF DRIVER SIDE STEERING KNUCKLE. THE FAILURES ARE NOT DUPLICATED ON THE RIGHT FRONT BRAKE ASSEMBLY. THE CONSUMER HAS THE DEFECTIVE PARTS. THE VEHICLE HAS NEVER BEEN OPERATED IN OFF ROAD CONDITION OR EXPOSED TO SALT WATER. UPDATED 12/11/2012 *JS
Oct 15, 2012
ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
WHILE ACCELERATING ONTO THE HIGHWAY, A LOUD, REPETITIOUS BANG/CLUNK FROM THE MIDDLE UNDERSIDE OF THE VEHICLE STARTED, SOUNDING SIMILAR TO A BLOWN TIRE. NO ABNORMAL OPERATIONS NOTED PRIOR TO THIS. LIMPED THE CAR BACK TO THE SHOP AT 15 MPH AND FOUND THE CENTER DRIVESHAFT CARRIER BEARING FAILED. THE SERVICE TECH ACTED AS IF THIS WAS COMMON AND WAS NOT SURPRISED. I HAVE A 1981 MERCURY WITH OVER 305000 MILES AND NEVER LOST A BEARING IN MY DRIVESHAFT. MECHANICAL PARTS FAIL. THE WORST PART OF THIS EVENT IS VOA'S REACTION THAT SOMEHOW THEY ARE NOT RESPONSIBLE FOR A POOR/WEAK DESIGN. LIST OF OTHER MAJOR COMPONENT FAILURES WITH NO RECALL THAT ARE COMMON TO ALL TOUAREGS OF THIS GENERATION ACCORDING TO THE COMPANY'S OWN SERVICE TECH'S: CENTER DIFFERENTIAL LOCK MOTOR FAIL REAR DIFF. LOCK MOTOR FAIL COOLING FANS DO NOT SHUT OFF, DRAIN BATTERY THERMOSTAT HOUSING LEAK RADIO FAILURE. *TR
Jul 09, 2012
ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER
1 complaint
I WAS DRIVING A SHORT DISTANCE FROM MY HOUSE (2 MILES) WHEN I NOTICED MY CAR NOT DRIVING NORMALLY. I HAD DRIVEN IT THE 3 PREVIOUS DAYS WITH NO PROBLEM. I FINISHED MY ERRAND, THEN PROCEEDED TO HEAD HOME. IT WAS NOTICEABLY GETTING WORSE. I SMELLED SOMETHING AT A STOPLIGHT, NOT SURE IF IT WAS MY CAR, OR CAR ALONGSIDE OF ME. I SAW A LIGHT HAD COME ON, ON MY DASHBOARD (CK. ENGINE?) AND LOOKED AT THE GAUGES, EVERYTHING WAS NORMAL. I DECIDED TO HEAD HOME FIRST TO HAVE MY NEIGHBOR FOLLOW ME UP TO REPAIR SHOP. PARKED IN DRIVEWAY, WENT INSIDE MY HOME TO CALL HER, LOOKED OUT MY OPEN FRONT DOOR ABOUT 5 MINUTES LATER WHERE I SAW SMOKE AND SMELLED IT. RAN OUT, MY AUTO WAS SERIOUSLY SMOKING HEAVY BROWN SMOKE, RAN NEXT DOOR TO CALL 911, AND AUTO BURST INTO FLAMES AND CAUGHT HOUSE ON FIRE ALSO. I AM NOW IN A HOTEL BECAUSE OF MAJOR FIRE AND SMOKE DAMAGE. *KB
Jul 20, 2011
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM
1 complaint
CONSTANT REPAIR OF 2004 VW TOUAREG: THIS VEHICLE HAS BEEN CERTIFIED IN ALL STATES OF THE UNION AS BEING A CERTIFIED LEMON. WHEN I PURCHASED THE VEHICLE I HAD NO IDEA OF THIS. I HAVE HAD TO REPLACE A FAN SENSOR WHICH IS A CERTIFIED VW DEFECT, BUT I HAD TO PAY FOR THE COST, REPAIR AND LABOR IN THE AMOUNT OF $550 AND FURTHER, THE VEHICLE LEFT ME STRANDED BECAUSE THE FAULTY SENSOR ALLOWED A FAN TO KEEP BLOWING THEREBY DRAINING MY BATTERY COMPLETELY. REAR WINDSHIELD WIPER DISINTEGRATED DURING HEAVY RAIN AND COST 65 TO REPAIR ALTHOUGH THE PIECE LOOKS LIKE SOMETHING A CHILD PUT TOGETHER. FRONT WINDSHIELD WIPER FLEW OFF OF CAR WHILE RAINING, CAUSING ME TO PULL OVER AND BE STRANDED ONCE AGAIN. I GOT STRANDED AGAIN BECAUSE THE VW ENGINE COILS BURNT OUT WITHOUT NOTICE LEAVING ME STRANDED IN BLIZZARD CONDITIONS IN CHICAGO. I HAD TO GET A NEW BATTERY BUT WAS CHARGED $250 FOR THE BATTERY AND INSTALLATION BECAUSE VW CHOSE TO PUT THE BATTERY UNDER THE FRONT DRIVER'S SEAT. NOT THREE WEEKS HAVE PASSED AND I HAVEN'T EVEN DRIVEN THE VEHICLE BUT BOTH FUEL PUMPS AND THE FLANGE MODULE HAVE GONE OUT. I HAD TO PAY $1500 FOR LABOR, PARTS, SHOP AND REPAIRS. VEHICLE HAS 91,000 AND BRAKES AND ROTORS HAVE GONE OUT AGAIN FOR THE 3RD TIME. RIGHT DOOR OPENS WHEN DRIVING ALTHOUGH THE VEHICLE IS LOCKED, WHICH IS ANOTHER CERTIFIED DEFECT. VEHICLE LUNGES FORWARD FROM A STOPPED POSITION AND THEN HESITATES WHEN TRYING TO SPEED UP ON THE HIGHWAY. *TR
Feb 21, 2011
PARKING BRAKE
1 complaint
EVERY TIME THE CAR IS STARTED THE WARNING LIGHT SHOWS THAT THE PARKING BRAKE IS ENGAGED. I NEVER USE THE PARKING BRAKE. I HAVE TALKED TO THE DEALER AND THEY SAY THAT THE PARKING BRAKE PEDAL NEEDS TO BE "HAND LIFTED" TO CLEAR THE WARNING LIGHT. WHEN I TRIED THIS IT DID CLEAR THE WARNING LIGHT FROM THE DASH. MY QUESTION IS WHY WOULD MY PARKING BRAKE BE ENGAGED IF I NEVER HAVE USED THE PARKING BRAKE? IT MAY JUST BE SOME MALFUNCTION WITH THEIR WARNING LIGHTS OR SENSORS, BUT HOW I AM I TO KNOW IF THIS IS A REAL PARKING BRAKE WARNING? *TR
Dec 17, 2010
POWER TRAIN,ELECTRICAL SYSTEM,STRUCTURE,TIRES
1 complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THE GEAR SHIFT SELECTOR WOULD NOT MOVE OUT OF PARK AND HE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. WHILE THE VEHICLE WAS BEING TOWED, THE ENTIRE CONSOLE AND WARNING LIGHTS ILLUMINATED. IN ADDITION, THE CONTACT STATED WATER WAS ENTERING THE VEHICLE AND SETTLING IN THE TRUNK NEAR THE SPARE TIRE. THE DEALER REMOVED THE SHIFTER CABLE AND REPLACED THE HARNESS, A WIRE AND THE SHIFTER COLUMN. THE FAILURE MILEAGE WAS 75,285 AND THE CURRENT MILEAGE WAS 76,065. UPDATED 11/02/10. *LJ THE CONSUMER STATED THE TRUNK WOULD NOT OPEN PROPERLY. THE TIRE SENSORS WOULD COME ON. THE IGNITION SWITCH WAS DEFECTIVE AND HAD TO BE REPLACED. UPDATED 11/04/10
Aug 05, 2010
POWER TRAIN,ELECTRICAL SYSTEM,AIR BAGS,STRUCTURE,LATCHES/LOCKS/LINKAGES,TIRES
1 complaint
2004 VW TOUAREG V-8 MANY PROBLEMS BUT 3 WORTH REPORTING: FOR NO APPARENT REASON PASSENGER DOOR COULD NOT BE OPENED OR UNLATCHED BY USING ANY KNOWN MEANS INCLUDING THE INSIDE DOOR HANDLE OR OUTSIDE DOOR HANDLE, ELECTRIC LOCK ACTUATOR CLICKS AS IF THE DOOR IS UNLOCKED BUT THE DOOR CAN NOT BE OPENED OR UNLATCHED. VEHICLE HAD TO BE BROUGHT TO VW DEALERSHIP AND WORKED ON BY DESTROYING THE DOOR HANDLE TO OPEN THE DOOR AND PERHAPS CUTTING A WHOLE IN THE BODY PANNEL AT THE COST OF 2 HOURS OF DIAGNOSTICS, 8 HOURS OF LABOR TO OPEN DOOR AND PROBABLY 2 OR 3 ADDITIONAL HOURS OF REPLACING DOOR HANDLE IF BODY OF DOOR IS NOT BENT, PLUS PARTS VEHICLE HAS MANY ELECTRICAL GLITCHES INCLUDING BUT NOT LIMITED TO INTERMITTENT MALFUNCTION OF AIR BAG IGNITERS....ONCE AGAIN HAVING THE POTENTIAL TO CAUSE SERIOUS HARM OCCUPANTS GIVEN THE RIGHT CIRCUMSTANCES THIS IS A POTENTIAL DANGEROUS SITUATION AND HAS MADE ME LOSE ALL FAIH IN THIS MANUFACTURER. VEHICLE LUNGES FORWARD WHEN STOPPED AT TRAFIC LIGHTS AND BEGINNING TO PROCCEED ON A GREEN. *TR
Jun 04, 2010
STEERING,ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES
1 complaint
UNEXPECTED AND SUDDEN ELECTRICAL MALFUNCTION OF THE STEERING COLUMN LOCK CAUSING THE VEHICLE TO SHUT DOWN, UNABLE TO START OR MOVE SHIFTER LEVER OUT OF GEAR. *TR
Feb 05, 2010
POWER TRAIN,AIR BAGS
1 complaint
I HAVE A 2004 VW TOUAREG V8, I HAVE A AIRBAG LIGHT THAT COME ON (AIRBAG FAULT), NOW THE TRAN LIGHT IS COMING ON WHEN I START THE SUV. *TR
Nov 12, 2009
FUEL SYSTEM, GASOLINE,POWER TRAIN
1 complaint
I WAS PARKING THE VEHICLE IN A TIGHT PARKING LOT AND MANEUVERING AROUND A TREE IN ORDER TO PULL FURTHER UP INTO THE SPACE. AS I GENTLY PUSHED DOWN ON THE ACCELERATOR TO INCH INTO THE SPOT, THE CAR LURCHED FORWARD AT A VERY HIGH RATE OF SPEED CRASHING INTO A WOODEN GARBAGE BOX. I JAMMED ON THE BRAKES BEFORE GOING THROUGH THE FENCE. I WAS INCREDIBLY LUCKY THAT I WAS NO LONGER AIMING AT THE TREE. IT WAS AS THOUGH THE CAR SUDDENLY WANTED TO PEAL OUT IN A MANNER THAT WAS TOTALLY OUT OF SYNC WITH THE AMOUNT OF PRESSURE ON THE GAS PEDAL. IT JUST STARTED SPEEDING TOWARD THE FENCE/BOX. LOOKING BACK ON IT, I BELIEVE THAT THIS HAPPENED A COUPLE OF DAYS BEFORE AS I STARTED TO ACCELERATE AFTER STOPPING AT A STOP SIGN. THOUGH THE REACTION OF THE CAR WAS SIMILAR, IT WAS NOT NEARLY SO PRONOUNCED. IT FELT AS THOUGH THE CAR WAS TRIPPING OVER ITSELF. I HAD THE INSURANCE TOW THE CAR TO THE MECHANIC BUT SO FAR HE HAS NOT BEEN ABLE TO REPLICATE THE PROBLEM. I SPOKE WITH BOTH THE LOCAL VW SERVICEMAN AND VW NORTH AMERICA BUT THEY DENIED EVER HEARING ABOUT SUCH A PROBLEM. I HAVE HAD THIS CAR FOR OVER 6 YEARS AND HAVE NEVER HAD THIS HAPPEN BEFORE THE OTHER DAY. *TR
Oct 16, 2009
SUSPENSION,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,TIRES
1 complaint
I HAVE HAD MY 2004 VW TOUAREG SINCE JUNE 2006 AND HAVE HAD PROBLEM AFTER PROBLEM WITH THE VEHICLE. THE CATALYTIC CONVERTER WENT OUT WITHIN 6 WEEKS OF BUYING THE CAR, THE DRIVE SHAFT HAD TO BE REPLACED, THE AIR CONDITIONING COMPRESSOR HAD TO BE REPLACED, THE BRAKES HAVE HAD TO BE REPLACED AND I AM GETTING ANOTHER "CHECK BRAKE PADS" ERROR AGAIN, THE TIRE MONITORING SYSTEM CONTINUALLY TELLS ME I HAVE A FLAT, THE RADIO AMPLIFIER WAS MAKING A LOUD CRACKING SO THE DEALERSHIP REPLACED A FUSE AND BLEW THE 2 BACK SPEAKERS (WHICH THEY WOULD NOT FIX, HEWLETT VW IN GEORGETOWN, TEXAS), THE AUTO DIFFERENTIAL IS GOING OUT. THERE SEEMS TO BE NO END IN SIGHT FOR REPAIRS. *TR
Dec 22, 2008
ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,TIRES
1 complaint
MULTIPLE ENGINE LIGHT FAILURES FOR OVER 4 YEARS. ENGINE LIGHT CAME ON AND ENGINE SHUT DOWN IMMEDIATELY WHILE WIFE WAS ON THE FREEWAY. VERY DANGEROUS...ESSENTIALLY NO WARNING. HAVE REPLACED WIRING HARNESS IN THE VEHICLE AND HAVE HAD IT IN THE SHOP FOR ELECTRICAL ISSUES MANY TIMES. UNSAFE HANDLING AND ACCELERATION...CAR JUMPS FORWARD AT STOPS WHILE IT IS DOWNSHIFTING. THINK THE TRANSMISSION, TIRES AND BRAKES SHOULD BE TESTED. THINK YOU WILL FIND THEY ARE DEFECTIVE. ENGINE BLEW UP AT 44,000 MILES. VERY DANGEROUS CAR..AND YOU WILL FIND OTHER TOUAREGS WITH SIMILAR ISSUES. SHOULD BE RECALLED. *TR
Aug 15, 2008
SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE,POWER TRAIN,TIRES,EQUIPMENT
1 complaint
2004 VW TOUAREG WITH TIRE FAILURE AND KEY PROGRAMMING. CONSUMER STATES HE HAD TO REPLACE THE TIRES DUE TO A PUNCTURE IN ONE OF THE SIDEWALL TIRES. THE SECOND KEY RECEIVED NEEDED TO BE PROGRAMMED AND DEALER CHARGED HIM FOR PROGRAMMING. *KB THE CONSUMER STATED HE GETS LOW GAS MILEAGE. WHEN THE VEHICLE WAS RETURNED TO THE CONSUMER, THE TIRE MONITORING SYSTEM WOULD COME ON AND GO OFF REPEATEDLY. THE DRIVE SHAFT WAS REPLACED DUE TO A VIBRATION WHEN MAKING TURNS. THE FRONT BRAKES NEEDED TO BE REPLACED.*JB
Nov 26, 2007
SUSPENSION,SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,TIRES
1 complaint
TL*THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE WARNING TONE OF THE TIRE PRESSURE MONITORING SYSTEM SOUNDS INTERMITTENTLY. IN ADDITION, THE HEADLIGHTS FAILED, AND THE VEHICLE PULLED TO THE RIGHT SPORADICALLY AND WITHOUT WARNING. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. THE CONTACT POSSESSED THE REPAIR INVOICES. THE FAILURE MILEAGE BEGAN AT 100. *AK THE CONSUMER STATED THE FAILURES CONTINUE, SHE HAS HAD MULTIPLE PROBLEMS WITH THIS VEHICLE BRAKE ROTORS REPLACE AT 15,000 MILES, BRAKE PADS HAD TO BE REPLACED AT 18,000 MILES, TWO TIRES REPLACE AT 16,000 MILES, TPS LIGHTS CONTINUE TO GO ON AND OFF BEEN FIXED, FOUR NEW TIRES AT 30,000 MILES. THE CONSUMER STATES THAT THERE HAVE BEEN 9 RECALLS AND TPS LIGHTS STILL IN FAILURE. UPDATE 05/04/07*TR
Mar 30, 2007
SERVICE BRAKES, HYDRAULIC,TIRES,ELECTRICAL SYSTEM
1 complaint
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2004 VOLKSWAGEN TORGUE WITH 31000 FAILURE MILEAGE AT ANY RATE OF SPEED THE TPS MONITORING SYSTEM LIGHT TURNED ON, AND STAYSED ON UNTIL THE VEHICLE WAS RESTARTED A COUPLE OF TIMES. ALSO, THE VEHICLE PULLED TO THE FRONT PASSENGER SIDE AND WAS WEARING OUT THE TIRES AND BRAKES ON THAT SIDE. *AK
Feb 21, 2007
EXTERIOR LIGHTING,TIRES
1 complaint
DT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE THE PASSENGER SIDE OR DRIVER'S SIDE HEADLIGHT DARKENED. THERE WERE NO WARNING INDICATORS OR DASHBOARD LIGHTS ILLUMINATED TO INDICATE THERE WAS A FAILURE WITH THE HEADLIGHT(S). EVENTUALLY, THE OTHER HEADLIGHT DARKENED. THE ONLY WAY THE LIGHTS WOULD ILLUMINATE AGAIN IS BY RESTARTED THE IGNITION. THE DEALERSHIP REPLACED A COMPUTER CHIP, CHANGED THE BULBS AND OTHER UNKNOWN REPAIRS WERE MADE, HOWEVER THE PROBLEM STILL PERSISTS. UPDATED 8/14/2006 - THE TIRE WARNING LIGHT ILLUMINATED. THE DEALER REPLACED THE CONTROL UNIT. *NM
Jul 20, 2006
SUSPENSION,SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,VISIBILITY,TIRES
1 complaint
VOLKSWAGEN 2004 TOUAREG SPORT UTILITY 4D HAS SERIOUS ALIGNMENT PROBLEMS RESULTING IN PREMATURE TIRE WEAR ON ALL 4 TIRES! FRONT 2 TIRES ARE DOWN TO METAL SHOWING WITH ONLY 19,880 MILES. CAR HAS BEEN IN FOR ALL SCHEDULED SERVICES AND ROTATIONS. ALMOST LOST CONTROL OF CAR WHILE DRIVING! ALSO, PRE-MATURE WEAR OF FRONT & BACK BRAKES & PADS DUE TO THE ALIGNMENT/TIRE PROBLEMS! CONDENSATION ON FRONT WINDSHIELD THAT DEFOGGER DOES NOT REMOVE. FUEL INJECTION RECALL THAT ON SERVICE BULLETIN STATED IT COULD RESULT IN A FIRE IF NOT FIXED! TIRE PRESSURE MONITORING SYSTEM FAILURE, ESP FAILURE, COMPUTER SOFTWARE FAILURE! *NM
Jun 05, 2006
ENGINE AND ENGINE COOLING,EQUIPMENT
1 complaint
VW TOUAREG ENGINE PROBLEMS IN THE WINTER. I WILL SEND THE INFO AS VW DEALER REPAIR INFO AND ENGINE PROBLEMS WAS RECORDED ON TAPE/DVD. *JB
May 25, 2006
SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,POWER TRAIN,VISIBILITY
1 complaint
I BROUGHT A VOLKSWAGEN TOUAREG. THIS VEHICLE HAS A LOT PROBLEMS WITH THE BRAKE AND ENGINE. SO I FILED A LEMON REQUEST. LAST MONTH, VW ASKED ME TO DROP THIS VEHICLE TO VW DEALER TO INVESTIGATE THE BRAKE PROBLEM. ON MARCH 23, THE VW EXPERT TEST DROVE MY TOUAREG AND HAD AN ACCIDENT BECAUSE THE BRAKES FAILED. THERE IS A POLICE REPORT. *NM THE REAR WIPER MADE A CLICKING NOISE. UPDATED 05/04/06. *JB THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALER REPLACED THE ENGINE CONTROL MODULE. THE TRANSMISSION CONTROL MODULE WAS UPDATED. UPDATED 06/01/06. *JB
Apr 09, 2006
SERVICE BRAKES, HYDRAULIC,PARKING BRAKE,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE,TIRES,EQUIPMENT
1 complaint
I TOOK DELIVERY OF MY 2004 VW TOUAREG ON 7-11-04. BY 9-9-04 IT WAS HAVING PROBLEMS. IT HAS BEEN IN 6 TIMES FOR ELECTRICAL PROBLEMS, 3 TIMES FOR THE AC, 3 TIMES FOR THE BATTERY, AND 1-2 TIMES FOR OTHER THINGS. TOMORROW, I WILL BE TAKING IT IN AGAIN FOR FURTHER A/C PROBLEMS, BRAKES THAT CATCH ON THEIR OWN WHILE IN DRIVE, INTERMITTENT FAULTY TRIGGERING OF TIRE PRESSURE MONITORING SYSTEM, AND A HOLE THAT I DISCOVERED ONLY DAY IN THE FIRE BLANKET UNDER THE HOOD. APPARENTLY THE ENGINE HEAT HAS BEEN BURNING A HOLE IN IT AND HAS BURNED AWAY A HOLE RIGHT THROUGH THE BLANKET TO THE HOOD ITSELF, BUT NOT THROUGH THE HOOD YET. THIS CAR HAS MEANT TIME LOST FROM WORK AND AN INORDINATE AMOUNT OF TIME SPENT IN THE SHOP AND PAYING FOR RENTAL CARS. THIS CAR IS A FIRE AND SAFETY HAZARD. FAIRFAX COUNTY CONSUMER PROTECTION (ROY SEGER) HAD CONTACTED VW AS THIS CAR FALLS UNDER THE LEMON LAW. VW RESPONDED THAT THEY WOULD NOT COMPLY, STATING THAT THEY HAD FIXED THE BATTERY. THEIR RESPONSE FAILED TO ACCOUNT FOR THE MULTITUDE OF OTHER PROBLEMS...AND NOW THIS. I HAVE NEVER FELT SO POWERLESS. IS THERE ANYTHING YOU CAN DO TO HELP?? *NM
Mar 12, 2006
SUSPENSION,POWER TRAIN,TIRES
1 complaint
ALIGNMENT: SINCE ITS PURCHASE THE CAR WAS NOT PROPERLY ALIGNED. I TOOK IT TO THE DEALER SEVERAL TIMES, AT THE 5,000 MILES, 10,000 MILES, AND 20,000 MILES SERVICES. IT WAS NOT FIXED AT ALL. THE REPAIR SHEET STATED THAT CAR WAS FIXED TO THE MANUFACTURER'S STANDARDS. AT THE 20,000 MILES SERVICE I REQUESTED THE CAR TO REPAIRED BEFORE I TAKE IT BACK. THE DEALER TOLD ME THAT DUE TO THE UNEVEN TIRES THERE WAS NO WAY FOR THEM TO REPAIR THE ALIGNMENT, AND THAT THE ONLY WAY TO FIX IT PROPERLY WAS TO REPLACE THE TIRES FIRST. I REPLACED THE TIRES AND BROUGHT THE CAR BACK. THE DEALER HAD THE CAR IN THE SHOP FOR THREE DAYS THE FIRST TIME. WHEN I TESTED THE CAR AFTER THE FIRST TIME IT WAS NOT FIXED. I TOOK IT BACK AND HAD A DISPUTE WITH THE TECHNICIAN. WHEN OTHER TECHNICIANS TESTED THE CAR THE DEALER DECIDED TO KEEP FOR REPAIR. THE CAR WAS AT THE SHOP FOR TWO DAYS. WHEN IT WAS FINALLY DONE, THE CAR HAD THE SAME PROBLEM. COMPUTER SYSTEM: LIGHTS AND SIGNALS PERIODICALLY STOP WORKING. GAS SENSOR PERIODICALLY STOPS WORKING FOR DAYS. CD PLAYER. PERIODICALLY SKIPS AND DOES NOT WORK. TRANSMISSION: PERIODIC JERKING WHEN SHIFTING TO LOWER SPEEDS. SCREECHING SOUND COMES FROM THE FRONT RIGHT SIDE AFTER 20 -30 MINUTES OF DRIVING. TIRES WERE WORN OUT AFTER 10,000 MILES.*AK
Jan 29, 2006
ENGINE AND ENGINE COOLING,VISIBILITY,TIRES
1 complaint
2004 VOLKSWAGEN TOUAREG LOSS POWER OWN 3 OCCASIONS AT 780 MILES. WINDSHIELD WIPERS DID NOT WORK IN THE INTERMITTENT MODE, TIRE PRESSURING MONITORING SYSTEM MALFUNCTIONED. *TS ***NO ANSWER REQUIRED*** THE TIRE PRESSURING MONITORING SYSTEM WAS GIVING A FALSE READING AS IF THERE WAS A PROBLEM WITH THE TIRES. *JB
Jan 09, 2006
STEERING,SUSPENSION
1 complaint
ALIGNMENT ON 2004 VW TOUAREG IS HORRIBLE. TAKEN BACK AT LEAST 3 TIMES AND IT HAS NEVER BEEN FIXED. TIRES ARE NOW SHOT BECAUSE OF THE ALIGNMENT PROBLEMS. COMPUTER KEEPS BEEPING THAT THERE IS A FLAT TIRE WHEN THE AIR PRESSURE IS FINE WHEN CHECKED. TAKEN IN AT LEAST 3 TIMES AND IT STILL HAS NOT BEEN FIXED. SPEAKERS RATTLE AS IF THEY ARE BLOWN....ALSO....NEVER BEEN FIXED. *JB
Dec 10, 2005
SUSPENSION,LATCHES/LOCKS/LINKAGES,TIRES
1 complaint
DOOR HANDLES STICK ON ALL FOUR DOORS. LAST YEAR, MY HUSBAND WAS IN THE PASSENGER SEAT AS I WENT AROUND A CORNER, THE PASSENGER DOOR FLUNG OPEN AND MY HUSBAND ALMOST FELL OUT. LUCKILY HE WAS WEARING HIS SEAT BELT. THE DOOR HANDLES WERE REPLACED BY THE DEALERSHIP. HOWEVER, THE DOOR HANDLES HAVE STARTED STICKING AGAIN. I HAVE TO PULL THE HANDLE AND LET IT GO QUICKLY TO LOOSEN THE HANDLE SO IT CLOSES FULLY. I NOTICED WITH 1000 MILES ON MY VEHICLE THAT THERE WAS A PULL IN THE FRONT END. I TOOK IT TO THE DEALER AND THEY SAID IT NEEDED TO BE ALIGNED. THEY REFUSED TO PAY FOR THE ALIGNMENT, MY TIRES WERE COMPLETELY WORN TO THE TREAD BARS WITH 15,000 MILES ON ALL FOUR, THEY WERE CUPPED. THE MANUFACTURER REPLACED 2 TIRES AND I PAID FOR 2 TIRES AND A 4 WHEEL ALIGNMENTS. *NM *AK
Nov 07, 2005
ENGINE AND ENGINE COOLING,POWER TRAIN,SEAT BELTS,STRUCTURE,LATCHES/LOCKS/LINKAGES,TIRES
1 complaint
OUR 2004 VW TOUAREG V-8 HAS THE FOLLOWING PROBLEMS DESPITE FIVE TRIPS TO THE DEALER: I) HESITATION DURING ACCELERATION; II) PULLS HARD TO THE RIGHT; AND III) SHIFTS ROUGHLY AT LOW SPEEDS. PAST PROBLEMS INCLUDE: IV) THE LATCH ON THE REAR DOOR BROKE, SUCH THAT IT CAME CRASHING DOWN ON MY WIFE'S HEAD; V) THE REAR SEAT BELT LATCH WOULDN'T WORK; VI) THE CAR SHUDDERED BADLY WHEN YOU TRIED TO MAKE A TURN AT LOW SPEEDS (E.G., WHILE PARKING) AND VII) THE FLAT TIRE INDICATOR WENT ON EVEN THOUGH THE TIRE WAS NEITHER FLAT NOR LOW. WE HAVE AN ARBITRATION SCHEDULED FOR 11/9/05 UNDER CALIFORNIA'S LEMON LAW. *NM
Oct 26, 2005
SUSPENSION,ELECTRICAL SYSTEM
1 complaint
MY 2004 V8 TOUAREG IS ABSOLUTELY THE BIGGEST LEMON EVER BUILT. IT HAS BEEN IN THE DEALERSHIP FOR 11 FULL WEEKS THIS YEAR WITH A VARIETY OF ISSUES. THE TWO MOST SIGNIFICANT WHICH HAVE TAKEN VW 5 WEEKS EACH TO IDENTIFY AND RESOLVE ARE THE ELECTRICAL SYSTEM WAS COMPLETELY MALFUNCTIONING AND THE PUMP TO CHANGE THE SUSPENSION HAS A LEAK. VW HAS BEEN COMPLETELY IN THE DARK ON THESE MAJOR PROBLEMS AND ONLY AFTER REPEATED TRIPS TO THE DEALER AND MANY DENIALS FROM VW DID THE ADMIT THAT THIS CAR IS AN OVER ENGINEERED AND POORLY BUILT CAR. *JB
Oct 10, 2005
ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL
1 complaint
DT: THE VEHICLE HESITATES ON ACCELERATION, AND THIS HAPPENS INTERMITTENTLY. WHILE STEPPING ON THE GAS PEDAL AND THE VEHICLE HESITATES. THE CONSUMER TOOK THE VEHICLE TO DEALER, AND THEY SAID THIS WAS NORMAL, BUT THEY DID SAY VOLKSWAGEN PROGRAMMED A DELAY IN THE COMPUTER CHIP. THERE IS NO FOREWARNING, NO LIGHTS COME ON, AND THERE IS NO NOISE. THIS FIRST HAPPENED ON MARCH 1, 2005. *AK
Sep 26, 2005
SUSPENSION,ELECTRICAL SYSTEM,TIRES,EQUIPMENT
1 complaint
I AM HAVING TROUBLE WITH MY VW TOUAREG V6. SINCE THEN I HAVE HAD NUMEROUS VISITS TO THE DEALER FOR FAILURES IN DESIGN. FOOTLIGHT WOULD NOT SHUT OFF WHEN THE CAR WAS OFF DUE TO TRUNK DOOR LATCH BEING BROKEN AT TIME OF PURCHASE. TIRES WERE WEARING FASTER THAN NORMAL AND THE ALIGNMENT WAS BAD. I WAS GIVEN NEW TIRES, HOWEVER, WHEN I ASKED IF THIS COULD HAPPEN AGAIN, I WAS TOLD YES AND THEY WERE UNSURE WHAT VW WOULD DO IN THE FUTURE. TIRE PRESSURE LIGHT GOES ON AND OFF AT ANY TIME. I WAS TOLD THIS WAS A MALFUNCTION THAT HAPPENS WHEN YOU HAVE NUMEROUS COMPUTER OPTIONS. IT CAME ON AFTER A TIRE ROTATION AND OIL CHANGE AND THE DEALER SAID "DON'T WORRY, IT WILL RESET ITSELF AND GO OFF".RADIO HAS MYSTERIOUSLY STOPPED WORKING FOR 24 HOURS AT A TIME. CAR HAS ACTUALLY BEEN DEAD ON TWO OCCASIONS AND HAS LEFT ME STRANDED. I WAS TOLD BY THE DEALER THAT THE BATTERY IN THE TOUAREG CAN'T SUPPORT THE CAR AND THE COMPUTER MODULES. I WAS TOLD THERE WAS NOTHING THAT COULD BE DONE ABOUT THIS AS THE BATTERY WAS FULLY CHARGED. I WAS TOLD THIS WAS A MISTAKE BY VW AND I WOULD HAVE TO LIVE WITH IT. I WAS ALSO TOLD TO NOT DRIVE IN THE CITY AS THIS MAKES THE PROBLEM MUCH WORSE. I WAS TOLD THAT THEY AREN'T SURE HOW THAT HAPPENED, BUT SIMPLY RESETTING THE CAR MADE IT RETURN. CD PLAYER WOULD NOT WORK,CAR WAS "RESET". I FIND THIS CAR TO BE THE BIGGEST JOKE EVER MADE. I UNFORTUNATELY AM OVER THE MILEAGE FOR THE LEMON LAW IN MAINE (I HAVE 27,000MILES ON THE CAR). I REALLY THINK THINGS ARE GETTING WORSE IN MY CAR THE LONGER I HAVE THE THING. MY BIGGEST CONCERN WITH THE CAR IS THAT THERE IS A POSSIBILITY IT COULD STOP WORKING AT ANY MOMENT. I FEEL I SHOULD NOT HAVE TO CARRY A SELF JUMPING SYSTEM IN A PRACTICALLY BRAND NEW $34,000 CAR. I WAS ALSO TOLD BY MY DEALERSHIP WHEN I STATED I WAS THINKING OF SELLING THE CAR, THAT THEY DIDN'T BLAME ME AS THEY HAD HEARD A LOT OF PEOPLE SAY THAT ABOUT THE TOUAREG. YEAH, I FEEL REALLY SAFE WITH THIS CAR. I THINK IT IS TIME SOMEONE DO SOMETHING ABOUT THIS CAR AND VW. *NM
Sep 18, 2005
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES
1 complaint
PASSENGER DOOR OPENED GOING DOWN THE ROAD, HANDLE DOES NOT RETRACT SOMETIMES. A LITANY OF ELECTRIC QUIRKS AND EXCESSIVE TIRE WEAR, ALSO JERKY ACCELERATION. *JB
Aug 29, 2005
POWER TRAIN,VISIBILITY
1 complaint
DT: THE CONSUMER STATES HIS 2004 VOLKSWAGEN TOUAREG WAS HAVING A THROTTLE DELAY PROBLEM. THIS IS ESPECIALLY BAD WHEN PULLING OUT FROM AN INTERSECTION. THIS LASTED FOR ABOUT 2-4 SECONDS AND IT IS INTERMITTENT. AFTER THE VEHICLE HAS A DELAY THE RPMS GO UP T 3,000 TO 4,000. THIS HAS BEEN HAPPENING FOR ABOUT A YEAR. THE VEHICLE HAS BEEN AT THE DEALERSHIP FOR THIS PROBLEM 4 TIMES. A REGIONAL TECHNICAL REPRESENTATIVE CAME AND EXAMINED THE VEHICLE. HE TRIED TO FLASH THE VEHICLE AND UPGRADED THE COMPUTER SYSTEM. THIS STILL HAS NOT WORKED. THE VEHICLE HAS CONSISTENTLY BECAME WORSE. THE OWNER HAS AN APPOINTMENT WITH VOLKSWAGEN NEXT WEEK TO ASSESS THE PROBLEM AGAIN. ALSO, THE DEALER HAS BEEN CONTACTED BY THE MANUFACTURER, WHO WANTED MORE DIAGNOSTIC WORK DONE. SPEED WAS NOT A FACTOR. IT IS COMING FROM A STOP TO PULLING OUT THAT THE THROTTLE IS HAVING THE DELAY. THE CONSUMER IS PROVIDING ALL THE INFORMATION THAT HE HAS AVAILABLE AT THIS TIME. *AK THE DRIVER WINDOW WAS INOPERATIVE AND THE HEATER BLOWER FAN WAS NOISY. *SC *JB
Aug 24, 2005
SUSPENSION,TIRES
1 complaint
TIRE PRESSURE MONITORING SYSTEM FAILURE (TPMS) NO EVENTS LED TO FAILURE, SYSTEM JUST DISAPPEARED FROM CAR...TELLS ME I HAVE A FLAT TIRE WHEN I DON'T....TIRES LOSING PRESSURE NOW AND ALIGNMENT IS OFF FOR A SECOND TIME AFTER BEING SERVICED, TIRES WEARING INCORRECTLY AND AT A FAST RATE...THERE IS A SERIOUS PROBLEM HERE THAT NEED TO BE INVESTIGATED WITH VW BEFORE ANOTHER FORD/TIRE SITUATION/DEATH HAPPENS TO ALL OF US NOW VW TOUAREG OWNERS. (2004 VW TOUAREG V6 OWNER: BRAND NEW!)*JB
Aug 13, 2005
AIR BAGS,EQUIPMENT
1 complaint
2004 VOLKSWAGEN TOUAREG HAS A BURNING ODOR COMING FROM THE VENTS. *MR THE CONSUMER ATTEMPTED TO TURN ON THE A/C WHEN THE BURNING ODOR OCCURRED. THE ODOR WAS SO STRONG THAT THE CONSUMERS DAUGHTER HAD BECOME SICK AND VOMITED IN THE VEHICLE. ALSO, THE AIR BAGS DID NOT WORK. *SC *JB
Jul 22, 2005
AIR BAGS,TIRES
1 complaint
DT: VW TOUAREG 2004. THE CONTACT STATES THAT THE AIR BAG SENSOR IS ON; THIS MEANS THE AIR BAGS ARE DISABLED. THE AIR BAGS HAVE BEEN REPAIRED ONCE, BUT IT HAPPENED AGAIN. THE VEHICLE WILL BE TAKEN IN TO A SERVICE DEALER TODAY. ALSO, AT 9,000 MILES ALL FOUR TIRES HAD TO BE REPLACED. THE SERVICE DEALER STATED THAT IT WAS UNUSUAL WEAR FROM THE VEHICLE, AND TO CONTACT THE TIRE MANUFACTURER. *AK *SC
Jul 08, 2005
SERVICE BRAKES, HYDRAULIC,SEATS
1 complaint
DT: THE PROBLEM BEGAN ON 4-04. PROBLEMS WITH BRAKES. HYDRAULIC BRAKES ARE PULLING, CAUSING EXCESSIVE SCREECHING NOISE AND BRAKE DUST. BRAKES ARE NOW GRINDING. BRAKES HAVE BEEN SERVICED 3 TIMES IN THE LAST YEAR. VOLKSWAGEN WILL NOT OFFER ANY FURTHER ASSISTANCE. DEALER REPORTS THAT VOLKSWAGEN IS WORKING ON PROBLEM IN GENERAL. OCCURS IN ALL WEATHER AND DRIVING CONDITIONS. PROBLEM IS GRADUAL AND WORSENING. ON LAST SERVICING, VEHICLE WAS REPORTED TO HAVE HAD A BRAKE RESURFACING. BRAKES ARE ALL WHEEL. ALSO, DRIVER'S SEAT IS NOT GOING UP AND IS BROKEN. *AK
May 31, 2005
ELECTRICAL SYSTEM,SEAT BELTS,SEATS,EQUIPMENT
1 complaint
1.THE CLOCK ON THE DASHBOARD: THE TIME IS RUNNING ALMOST 1 MINUTE FASTER PER DAY. IF YOU DONT FIX IT FOR 10 DAYS, IT WOULD RUN 10 MINUTES AHEAD. 2.THE DRIVERS SEAT: WHEN I PURCHASED THIS CAR, I ASKED FOR POWER SEATS BUT THE DEALER DIDNT HAVE IT. I WAS A LITTLE UNCOMFORTABLE WITH THE MANUAL SEAT, BUT THE SALES PERSON CONVINCED ME, SO I DECIDED TO TAKE THE ONE WITH MANUAL. SINCE THEN, IVE FELT THAT THE DRIVERS SEAT IS ALWAYS SINKING DOWN SO I CONSISTENTLY HAVE TO PULL UP THE STICK TO PUSH UP THE SEAT QUITE OFTEN WHILE IM DRIVING. 3.REAR SEAT: I HAD TO FOLD THE REAR SEAT ONCE TO LOAD SOMETHING IN THE BACK. AFTER, I TRIED TO UNFOLD THE SEAT BUT IT DIDNT GO BACK. I BROUGHT THIS CAR TO THE DEALERS SERVICE ON NOV. 15TH, 2004. WHILE ONE OF THE SERVICE PERSONS WAS TRYING TO UNFOLD THE REAR SEAT, HE HAD TO CUT THE SEAT BELT AND HAS SCRATCHED THE SEAT AND BROKEN SOME PIECE ON THE SEAT. HE SAID HES GOING TO ORDER SOME PARTS AND IT WOULD TAKE A FEW DAYS. EVER SINCE THEN, NOBODY KNOWS THE STATUS OF THIS ORDER. BOTH THE SERVICE DEPT AND THE CUSTOMER CARE DEPT, IN HEADQUARTERS HAVE ALWAYS BEEN TELLING ME ITS ON BACKORDER WITH NO FURTHER INFORMATION, AND THEY DONT KNOW WHEN FOR LAST SIX MONTHS. I ASKED THEM IF YOU DONT HAVE THE PART, EVEN IN GERMANY, HOW LONG WILL IT TAKE FOR THE MANUFACTURER TO MAKE THE PART? AND THEY KEEP SAYING IS DONT KNOW AND WE ARE STILL CHECKING THE STATUS OF THE PART EVERYDAY. IN A COMMON SENSE, THE PERIOD OF FOUR MONTHS SHOULD BE ENOUGH TIME TO MAKE THE PART AND SHIP IT TO THE DEALER. I ALSO SENT A COMPLAINT LETTER TO THE CEO OF THE DEALER/MCKENNA & VW NORTH AMERICA HEADQUATER A COUPLE OF MONTHS AGO. BUT STILL THEY DON'T KNOW ABOUT THE PART.
May 18, 2005
STEERING,SERVICE BRAKES, HYDRAULIC
1 complaint
SINCE I PURCHASED A 2004 VW TOUAREG ON 2/28/04 I HAVE HAD VARIOUS PROBLEMS WITH IT. THE MOST SEVERE IS THE FRONT END ALLIGNMENT AND BRAKES. I HAVE HAD A TOTAL OF 6 FRONT END ALLIGNMENTS SINCE I PURCHASED THE VEHICULE. IT IS IN THE SHOP RIGHT NOW AND THEY CAN NOT CORRECT IT. THIS IS A AN EXTREME HAZARD AT HIGHER SPEEDS SINCE THE SUV PULLS HARD TO THE RIGHT. I WAS TOLD BY THE MECHANIC THAT WORKED ON MY VEHICULE THAT HE SET THE ALLIGNMENT TO FACTOR SPECS AND IT STILL PULLS TO THE RIGHT. I TOOK IT TO TIRE KINGDOM TWICE AND THEY DID THE SAME AND DID A HIGH SPEED BALANCE ON THE TIRES AS WELL AND IT STILL PULLS TO THE RIGHT. ALSO VOLKWAGON OF AMERICA PUT OUT CIRCULAR VWA-04-12 STATING THAT THERE IS A FACTORY PROBLEM WITH FRONT END ALLIGNMENTS ON CERTIN VIN NUMBERS ON THE TOUAREG. VW WILL NOT ACKNOWLEDGE THAT THERE IS A PROBLEM. I ALSO HAVE TROUBLE WITH THE BREAKS MAKING LOUD NOISE AND WEARING OUT FAST. NOW THEY ARE TELLING ME THAT THE ROTORS ARE BAD. I HAVE COMPLAINED ABOUT THE BRAKES AND NOTHING WAS DONE. ALSO THERE IS CONDENSATION ON THE WINDSHIELD FROM THE AIR CONDITIONING AND THEY DID HAVE A RECALL ON THIS, BUT THE TROUBLE STILL EXSISTS.
May 16, 2005
SERVICE BRAKES, HYDRAULIC,WHEELS
1 complaint
DRIVER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR AND THE STEERING WHEEL FAILED TO TURN. DRIVER LOST CONTROL OF THE VEHICLE AND HIT A FIRE HYDRANT. LEFT SIDE (DRIVER'S SIDE) WHEEL SHEARED OFF. DRIVER WAS NOT INJURED. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC STATED THAT A CAUSE COULD NOT BE DETERMINED AT THIS TIME. *AK *BF *NM
Apr 27, 2005
SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM,AIR BAGS,LATCHES/LOCKS/LINKAGES,TIRES
1 complaint
MY 2004 TOUAREG WITH LESS THAN 5000 MILES HAS BEEN IN FOR SERVICING 7 TIMES. THE BRAKES HAVE BEEN WORKED ON AND LOOKED AT THREE TIMES. THEY STILL SQUEAL BUT THE PROBLEM HAS LESSENED. OF MORE CONCERN ARE THE SAFETY ISSUES THAT HAVE AFFECTED ME. I HAVE BEEN LOCKED OUT OF MY VEHICLE TWICE, EACH TIME WITH A DIFFERENT RESOLUTION. UPDATED SOFTWARE WAS THE LATEST FIX. MY AIRBAG FAULT LIGHT IS NOW ON. ANOTHER SOFTWARE RESOLUTION IS ON THE WAY. I HAVE NO CONFIDENCE IN THE QUALITY OR SAFETY OF THIS VEHICLE OR WHEN THE NEXT ISSUE WILL ARISE. VOLKSWAGEN TOLD ME MY CAR WAS NOT PROBLEMATIC AND I HAD "BUYERS REMORSE". I AM IN AWE OF THEIR LACK OF CONCERN ESPECIALLY WHEN I KNOW I AM NOT THE ONLY TOUAREG OWNER OUT THERE WITH PROBLEMS.*AK
Apr 11, 2005
VISIBILITY,TRAILER HITCHES,EQUIPMENT
1 complaint
THE TOUAREG HAS TWO DEFCTS THAT WILL EVENTUALLY LEAD TO IF THEY HAVE NOT CAUSED DAMGE. FOR MONTHS I HAVE TRIED TO GET VW TO FIX THE DEFECTIVE TAIL LIGHT FAULTS AND WARNINGS DUE TO THE INSTALLATION OF THE TOW HITCH. VW CLAIMS THESE ISSUES ARE RELATED TO ALL TRAILERS. ADDITIONALLY, THIS VEHICLE HAS A DEFECTIVE DRIVERS WINDSGHIELD WIPER THAT CAUSES OBSCURED VISABILITY. BOTH ARE DANGEROUS AND VW CLAIMS NORAML OPERATION. I AM FRUSTERATED AND IN DISBELIEF THAT VW WILL NOT CORRECT THE VEHICLES ISSUES. I AM WRITTING IN AN ATTEMPT TO REPRESENT THE PEOPLE AGAINST THIS VEHICLE MANUFACTURE
Feb 15, 2005
POWER TRAIN,ELECTRICAL SYSTEM,VISIBILITY,VEHICLE SPEED CONTROL
1 complaint
VEHICLE WOULD JUMP FORWARD WHEN MAKING TURNS, MAKING IT DIFFICULT TO CONTROL VEHICLE. OWNER TOOK VEHICLE TO DEALER FOR REPAIR OF THE TRANSFER CASE 3 TIMES. THE ACCELERATOR PEDAL WOULD GET STUCK, WHICH WAS NOT ENABLING THE VEHICLE TO ACCELERATE AND TO CHANGE GEARS. ALSO, WINDSHIELD WIPERS WOULD WORK INTERMITTENTLY, CAUSING VISIBILITY PROBLEMS ON THE ROAD DURING INCLEMENT WEATHER. IN ADDITION, THE BATTERY WOULD DRAIN AND CAUSE THE VEHICLE NOT TO TURN ON. MANUFACTURER WAS CONTACTED BY OWNER NUMEROUS TIMES.*AK
Feb 07, 2005
SERVICE BRAKES, HYDRAULIC,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
ON TWO OCCASIONS MY 2004 VOLKSWAGEN TOUAREG V-8 EXPERIENCED COMPLETE ELECTRICAL SYSTEM FAILURES. THE VEHICLE WOULD NOT START ON THESE TWO OCCASIONS. THERE WAS NO ELECTRICAL POWER AS IF THE BATTERY WERE COMPLETELY DEPLETED. I DID NOT CAUSE ANY ELECTRICAL/BATTERY DRAIN, I.E. LEAVING ON LIGHTS OR LEAVING ANY ELECTRICAL EQUIPMENT ON. LOCAL VW DEALERSHIP SERVICE CONDUCTED AN ANALYSIS AND FOUND SEVERAL FAULTS STORED. BUT THE SERVICE ADVISER SAID NONE OF THE STORED FAULTS INDICATED WHAT CAUSED THE COMPLETE ELECTRICAL FAILURE. FIRST INCIDENT WAS APRIL, 2004 AND MOST RECENT DEC. 28, 2004. I ALSO EXPERIENCED NUMEROUS OTHER ELECTRICAL AND/OR COMPUTER MALFUNCTIONS. THESE MALFUNCTIONS WERE RELATED TO: ALL-WHEEL DRIVE SYSTEM, DRIVE LINE SYSTEM, STABILITY CONTROL SYSTEM, ANTI-LOCK BRAKES, STEERING INPUT, DOOR LOCKS, INTERIOR LIGHTING FEATURES, TIRE PRESSURE MONITORING, AND KEYLESS REMOTE. ALL-WHEEL DRIVE SYSTEM, DRIVE LINE SYSTEM, ANTI-LOCK BRAKES, AND STEERING INPUT MALFUNCTIONS OCCURRED FOUR TOTAL TIMES. DEALER/SERVICE COULD NOT "DUPLICATE" THE PROBLEM AND NO REPAIRS WERE MADE. THE DOOR LOCKS AND INTERIOR LIGHTING PROBLEMS WERE CONSTANT BUT DEALER/SERVICE COULD NOT "" THE PROBLEM. THE TIRE PRESSURE MONITORING WAS REPAIRED AND HAS BEEN PROBLEM FREE SINCE MARCH 2004. THE KEYLESS REMOTE DOOR LOCK/UNLOCK WAS REPAIRED AND WORKS BETTER BUT HAS NOT BEEN PROBLEM FREE. *NM
Jan 16, 2005
ENGINE AND ENGINE COOLING,POWER TRAIN,AIR BAGS
1 complaint
WHILE DRIVING VEHICLE HESITATED. CONSUMER PRESSED DOWN ON THE ACCELERATOR PEDAL AND VEHICLE MOVED INTERMITTENTLY ON ITS OWN. SRS LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC PLACED THE VEHICLE ON A DIAGNOSTIC MACHINE. THE MECHANIC DETERMINED THAT THE SENSOR SHAFT FOR TRANSMISSION AND ENGINE NEEDED TO BE REPLACED. THIS PROBLEM WAS A DESIGN FLAW DEFECT. CONSUMER INFORMED THE MECHANIC THIS PROBLEM WAS NOT ACCEPTABLE AND HAD NOT BEEN RESOLVED. *AK
Oct 07, 2004
AIR BAGS,ELECTRICAL SYSTEM
1 complaint
WHILE DRIVING SRS AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER PRESSED DOWN ON THE HORN AN IT FAILED. CONSUMER DROVE THE VEHICLE TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE CLOCK SPRING NEEDED TO BE REPLACED. *AK
Jun 21, 2004
SEATS
1 complaint
PASSENGER SITTING BEHIND DRIVER IN 2004 VOLKSWAGEN TOUREG WAS INJURED WHEN DRIVER LEFT THE CAR. ELECTRIC SEAT RETRACTED BACK AND DOWN ONTO THE PASSENGER' S FEET THAT WERE UNDER THE DRIVERS SEAT. SEAT ACTION OCCURS AUTOMATICALLY TO MAKE IT EASIER FOR THE DRIVER TO EXIT THE VEHICLE.*AK
May 21, 2004
STEERING
1 complaint
I HAVE RECENTLY PURCHASED A 2004 VOLKSWAGEN TUAREG WITHOUT DRIVING THE VEHICLE OFF THE PARKING LOT I TOOK IT STRAIGHT TO THE SERVICE MANAGER BECAUSE THE VEHICLE FELT LIKE IT WAS PULLING HARD TO THE RIGHT. I WAS INFORMED THAT IT WAS NECESSARY TO PUT 800 PLUS MILES ON THE VEHICLE BEFORE THEY WOULD ALIGN THE FRONT END. AFTER PUTTING THE REQUIRED MILES ON THE VEHICLE IT WAS TAKEN BACK TO THE DEALERSHIP WITH THE EXPECTATION OF AN ALIGNMENT. I PICKED THE CAR UP THAT AFTERNOON AND I WAS TOLD BY THE SERVICE MANAGER THAT THIS CAR WAS PROPERLY ALIGNED AND THAT IT WAS VERIFIED BY TWO INDIVIDUALS WHO DROVE TO CAR. THIS VEHICLE HAS A PROPENSITY TO RAPIDLY PULL OFF THE ROAD WITH ALMOST ANY KIND OF CROWN. THE STEEPER THE CROWN THE MORE RADICAL IT WANTS TO PULL. THIS IS EITHER A BOGUS SERVICE MANAGER OR THE VOLKSWAGEN TOUAREG HAS SERIOUS PROBLEMS THAT PREVENT IT FROM TRACKING DOWN THE ROAD IN A STRAIGHT LINE. I HAVE HAD BMWS, PORSCHES, GMC YUKONS AND PICKUP TRUCKS THAT STAY ON THE ROAD 100 PERCENT BETTER THAN THIS VEHICLE. I WOULD GREATLY APPRECIATE SOME FEEDBACK FROM OTHER OWNERS WHO MAY BE EXPERIENCING THE SAME PROBLEM. IT WILL ONLY BE A MATTER OF TIME BEFORE THIS VEHICLE VEERS OFF A ROAD AND TAKES OUT A TELEPHONE POLE. THIS IS EITHER AN ALIGNMENT PROBLEM OR A DESIGNED FLAW. SINCERELY, HENRY MOSELEY
Apr 10, 2004
ELECTRICAL SYSTEM,TIRES
1 complaint
2004 TOUAREG THAT HAS EXPERIENCED MULTIPLE BATTERY FAILURES DUE TO EXCESSIVE DRAW. THE VEHICLE CANNOT BE LEFT UNATTENDED FOR MORE THAN 3-4 DAYS W/OUT EXPERIENCING BATTERY FAILURE. HAS BEEN TO VW SERVICE ON 3 OCCASSIONS FOR A TOTAL OF 40 BUSINESS DAYS. THE CAR HAS ALSO EXPERIENCED MULTIPLE TIRE PRESSURE MONITORING SYSTEM FAILURES WHICH COULD PROVIDE ERRONEOUS INFORMATION DIRECTLY RELATED TO THE TIRE CONDITION. ACCORDINGLY, THE VEHICLE ISS UNRELIABLE, PRONE TO ELECTRICAL SYSTEM MALFUNCTIONS WHICH COULD IMPACT OPERATOR, PASSENGER AND OTHER MOTORIST SAFETY.
Mar 09, 2004
ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL
1 complaint
2004 VW TOUAREG V8. THESE VEHICLES EXHIBITS FREQUENT BUT INCONSISTENT DELAY IN THROTTLE RESPONSE. THIS ISSUE ARISES MOST OFTEN IN HEAVY TRAFFIC WHEN THE DRIVER COMES TO A ROLLING STOP. WHEN SHIFTING INPUTS FROM THE BRAKE TO THE THROTTLE THE VEHICLE WILL FREQUENTLY EXHIBIT A 1-2 SECOND DELAY BEFORE THERE IS ANY RESPONSE FROM THE ENGINE. THIS HAS TWO DANGEROUS CONSEQUENCES. FIRST, THE DRIVER MAY INCREASE THE THROTTLE PRESSURE WAITING FOR A RESPONSE, THEN GETTING MORE THEN EXPECTED ACCELERATION WHEN THE ENGINE FINALLY RESPONDS. SECOND, THE DRIVER COULD BE LEFT SITTING IN AN ONCOMING LANE WAITING FOR THE ENGINE TO RESPOND AND TAKE THE VEHICLE SAFELY ACROSS THE INTERSECTION. I HAVE REPORTED THIS TO TWO DIFFERENT VW DEALERS, ONE OF WHICH TURNED THE COMPLAINT TO VW. THERE HAS BEEN NO ACTION TAKEN, OR FURTHER RESPONSE FROM VW. *JB
Jan 27, 2004
Frequently Asked Questions
How many problems does the 2004 VOLKSWAGEN Touareg have?
The 2004 VOLKSWAGEN Touareg currently has 231 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2004 VOLKSWAGEN Touareg?
The most common problems reported for the 2004 VOLKSWAGEN Touareg are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2004 VOLKSWAGEN Touareg problem data come from?
All problem and complaint data for the 2004 VOLKSWAGEN Touareg comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - VOLKSWAGEN Touareg
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
Other VOLKSWAGEN Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models