How many problems does the 2004 VOLVO S60 have?

The 2004 VOLVO S60 currently has 198 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2004 VOLVO S60?

The most common problems reported for the 2004 VOLVO S60 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2004 VOLVO S60 problem data come from?

All problem and complaint data for the 2004 VOLVO S60 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2004 VOLVO S60 Problems

ENGINE AND ENGINE COOLING

46 complaints

2004 VOLVO S60R, EXPERIENCE TOTAL ENGINE SHUTDOWN AT APPROXIMATELY 30 MPH THE VEHICLE JUST QUIT RUNNING. CW A DIAGNOSTIC INVESTIGATION BY THE DEALER, CONFIRMED THE FUEL PRESSURE SENSOR WAS AT FAULT. THE SENSOR WAS REPLACED AT A COST OF $ 420.69. THE CONSUMER INQUIRED ABOUT A RECALL. HOWEVER, HE WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN RECALL # 07V226000. *JB

Jan 29, 2015

TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED AND THE ENGINE SEIZED. THE FAILURE HAD RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS EXHIBITING THE SAME FAILURES AS LISTED IN RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 187,000.

Jan 27, 2015

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH ATTEMPTING TO COME TO A COMPLETE STOP, THE VEHICLE STALLED WITHOUT NOTICE. THE CONTACT MENTIONED ALL LIGHTS ON THE CONTROL PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO MADE THE CONTACT AWARE OF RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Jul 10, 2014

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THE DRIVERS SPEED WAS 25 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CHECK ENGINE LIGHT ILLUMINATED PRIOR TO THE FAILURE; YET, THE VEHICLE RESTARTED AFTER THE FAILURE OCCURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 80,250.

Apr 02, 2012

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE DECELERATED WITHOUT WARNING AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE DEALER WAS CONTACTED AND ADVISED THE CONTACT THAT THAT THEY WOULD REPAIR THE VEHICLE BY REPLACING THE FUEL PRESSURE SENSOR. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED TWICE. THE FAILURE MILEAGE WAS 94,000 AND THE CURRENT MILEAGE WAS 95,412.

Mar 05, 2012

+ 41 more complaints for this component

FUEL SYSTEM, GASOLINE

20 complaints

MY CAR WAS DYING ON THE HIGHWAY OR ON A REGULAR STREET ROAD. ENDED UP BEING THE FUEL PRESSURE SENSOR WHICH IS ON THE RECALL LIST BUT DIDN'T COME UP FOR MY VIN. I WAS DEALING WITH THIS FOR 6 MONTHS OR SO AND IT WAS VERY DANGEROUS. I DON'T UNDERSTAND WHY MY CAR ISN'T ON THE RECALL LIST. ANY HELP IS APPRECIATED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Nov 10, 2014

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE WOULD LOSE POWER AND EXHIBIT A SUDDEN INCREASE IN ENGINE RPMS BEFORE THE VEHICLE ACCELERATED. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE DEALER DIAGNOSED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

Oct 31, 2014

I HAD MY CAR IN FOR SERVICE AT MY LOCAL VOLVO REPAIR SHOP AND ONE OF THE ITEMS I HAD THEM INVESTIGATE WAS A FUEL SMELL. THEY TOLD ME THEY FOUND A CRACK AT FUEL PUMP SENDER RH SIDE. THEY MENTIONED THAT THEY THOUGHT THERE WAS A RECALL FOR THIS SINCE THEY HAVE SEEN IT SEVERAL TIMES BEFORE AND THAT I SHOULD CONTACT MY VOLVO DEALER. I JUST LOOKED ONLINE AND FOUND WHAT THEY WERE TALKING ABOUT BUT IT DOES NOT LIST THE STATE WHERE I PURCHASED THE VEHICLE AND RESIDE? I AM THE ORIGINAL OWNER. THE REPAIR SHOP DID CONTACT A LOCAL DEALER FOR ME AND THE DEALER TOLD THEM THAT THERE WAS NOT A RECALL? I GUESS I WILL CONTACT SOME OTHER LOCAL DEALERS THIS WEEK AND SEE WHAT THEY SAY? SEEMS LIKE COLORADO SHOULD HAVE BEEN ADDED TO THIS RECALL EVERY STATE NEAR US IS PART OF IT. IF I CANT GET THIS REPAIRED UNDER THE RECALL WHAT SHOULD I DO TO MAKE IT HAPPEN? *TR

Mar 23, 2014

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WOULD FAIL TO ACCELERATE WHEN DRIVING AT VARIOUS SPEEDS. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD INTERMITTENTLY STALL DURING THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND AN INDEPENDENT REPAIR SHOP TO HAVE THE FAILURE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO THE FUEL PRESSURE SYSTEM. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V483000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE FAILURE MILEAGE WAS 67,000.

Oct 26, 2011

I OWN A 2004 VOLVO S60. I RECENTLY FOUND OUT THAT THERE IS A RECALL ON MY VEHICLE AFTER MY MECHANIC TOLD ME MY CHECK ENGINE LIGHT WAS DUE TO THIS RECALL. VOLVO SAYS THERE IS NO SUCH RECALL AT FIRST, BUT UPON CALLING THE CUSTOMER SERVICE NUMBER I FOUND OUT THAT THERE IS. HOWEVER, THEY SAY IT IS VIN SPECIFIC AND THAT MINE IS NOT COVERED. MY MECHANIC SAYS THAT THIS NEEDS TO BE TAKEN CARE OF, FOR THIS PROBLEM CAN CAUSE MY ENGINE TO STALL OUT AT ANYTIME AND CAUSE MY STEERING WHEEL TO JERK AROUND ON THE HIGHWAY. TO ME, THIS IS A HUGE PROBLEM, SOUNDS LIKE THAT IT COULD POTENTIALLY KILL ME ON THE ROAD. HOW CAN SOMETHING THAT CAN BE THIS POTENTIALLY DANGEROUS NOT BE VOLVOS RESPONSIBILITY TO FIX? JUST BECAUSE MY VIN NUMBER IS DIFFERENT DOES NOT MEAN THE PROBLEM IS ANY LESS SERIOUS, THOUGH VOLVO SEEMS TO THINK IT IS. *TR

Oct 04, 2011

+ 15 more complaints for this component

FUEL/PROPULSION SYSTEM

12 complaints

Starting Sunday November 27 my car started dripping gasoline on the floor, on the driver side near the rear wheel. Immediately I took it to Volvo dealer Wynne in Hampton, VA. The service specialist told me there was not any existing recall for that issue and let me go. That night I put under the leak a flat pan. That night I collected one gallon in about 8 hours. I called Volvo cars USA [XXX] explained me the car have been fixed for the campaign #09V483000 in September 14, 2010. I own the car since 2015. I asked her if the recall should be possible to do it again at no cost for me, because it falls under Safety due to the fact the car may get in fire due to the leak of gas. She asked me to go back again to Wynne Volvo dealer and tell to the service specialist that I talked to them and if they wouldn't repair my car I could open a case with Volvo Cars USA. The service specialist told me I could leave the car for inspection, but I would be responsible for at least $180 to get and estimate, but never said that they would fix it under the safety recall number 09V483000 for vehicles sold or registered in the states with hot climate like Virginia. The recall started in January 15, 2010. It covers the fuel pump that can develop cracks in the fuel pump flange. The technician said the repair they did under the recall was replacing an O-Ring gasket only not the fuel pump. The person I talked to in Service is [XXX] with Title Service Advisor. Phone number [XXX]. I called again today Wednesday November 30, 2022 to Volvo Cars USA they said they can not promise to wave the repair because they need first that I pay $180 for a car diagnostic of the issue. They would probably accept to pay part of the total charge but they would be doing it at good will. I don't have $180 to pay upfront for a safety recall that it didn't last but only 12 years. The Safety recall is valid as long as the car is in service, it doesn't matter if I am or not the first owner. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Nov 30, 2022

ENGINE STALLS....MULTIPLE TIMES

Sep 16, 2017

GASOLINE FILL OVERFLOWS FREQUENTLY WHEN PUTTING IN FUEL, REGARDLESS OF AMOUNT OF FUEL ALREADY IN THE TANK.

Oct 11, 2016

FUEL PUMP LEAKED. SMELL GAS. SCARED IT MAY CATCH FIRE. EXPENSIVE REPAIR. VOLVO IS REFUSING TO HONOR RECALL BECAUSE (1) VEHICLE PURCHASED IN NJ (THOUGH HAS SPENT LIFE IN VA) AND (2) WORK DONE AT NON-VOLVO MECHANIC. DUE TO THE SEVERITY OF THE ISSUE, I TOOK IT TO THE NEAREST MECHANIC RATHER THAN RISK DRIVING IT TO DEALER AND HAVING IT CATCH FIRE.

Jan 07, 2016

TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING 65 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO BE DIAGNOSED AT THE DEALER. THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Dec 01, 2015

+ 7 more complaints for this component

ENGINE

11 complaints

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE STATIONARY, THE ENGINE CAUGHT FIRE. THE CONTACT STATED THAT SMOKE ENTERED INTO THE CABIN OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND OPENED THE HOOD, AND THE ENGINE WAS SURROUNDED BY FLAMES. A POLICE OR FIRE DEPARTMENT REPORT WAS NOT FILED. AN INDEPENDENT MECHANIC EXTINGUISHED THE FIRE. THERE WERE NO INJURIES SUSTAINED. A DEALER WAS NOT MADE AWARE OF THE FIRE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FIRE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.

Nov 01, 2018

Fire: 1

CAR IS VOLVO S60 2004 TRIM 2.4 4 DOOR SEDAN FWD HAS 90317 MILES ON IT. FROM LAST FEW WEEKS WHEN I AM DRIVING VEHICLE IT STARTS LOSING POWER AND A WARNING COME TRY SLOW DOWN OR SHIFT UP AND MY CHECK ENGINE LIGHT STARTED BLINKING. THIS HAPPENED 4 TIMES IN LAST 1 WEEK AS THE RESULT I NEED TO PULL MY CAR TO SAFE PLACE AND RESTART THAT AND THEN IT RUNS BETTER. THIS HAS REALLY PUT ME IN DANGER TO MYSELF AND OTHER PEOPLE ON ROAD. I AM SCARE OF DRIVING THE CAR IN MULTIPLE LANE ROADS IN OTHER LANES. I AM NOW DRIVING IT ON RIGHT LANE ONLY SO THAT KEEP MYSELF AND OTHER PEOPLE SAFE FOR QUICK PULL OVER IF NEEDED. CHECK ENGINE GIVES ME CODE P0171 AND P0300. I WENT ON LINE AND FOLLOWED ADVICE AND CHANGED SPARK PLUGS, IGNITION COILS AND ALSO OXYGEN SENSOR BUT NO DIFFERENCE. STILL CAR DID SAME THING WHEN I WAS DRIVING WITH MY FAMILY. I WENT ON LINE AND SAW THAT MANY PEOPLE HAVE THAT ISSUE WITH VOLVO S60 OF THIS YEAR AND MODEL AND STRUGGLING. I THINK THIS IS SOME VOLVO S 60 2004 MODEL RECALL ISSUE AS IT IS CREATING ACCIDENTAL HAZARD TO THE OWNER OF THE CAR AND THE OTHER TRAFFIC. DR TAKYAR

Nov 03, 2017

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE ENGINE STARTED TO HESITATE AND STALLED. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND WAITED FOR APPROXIMATELY THREE MINUTES AND RESTARTED THE VEHICLE. THE CONTACT DROVE THE VEHICLE TO M.P.L. AUTOMOTIVE LACONIA NEW HAMPSHIRE (INDEPENDENT MECHANIC). THE VEHICLE WAS DIAGNOSED WITH A FUEL RAIL PRESSURE SENSOR NEEDING REPLACEMENT AND ALSO ADVISED THE CONTACT OF NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLANT). THE CONTACT CALLED LOVERING VOLVO MEREDITH NEW HAMPSHIRE WAS ADVISED THAT THE VIN WAS PART OF THE RECALL. THE VEHICLE WAS NOT REPAIRED AS OF YET. THE APPROXIMATE FAILURE MILEAGE WAS 158,000.

Jun 28, 2017

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE STALLED ON MULTIPLE OCCASIONS WHILE DRIVING. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

Aug 12, 2015

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE STALLED.THE PROBLEM RECURRED NUMEROUS OF TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER NOR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Dec 02, 2014

+ 6 more complaints for this component

SEATS

10 complaints

DRIVING HOME FROM CHURCH,, SMOKE STARTED COMING FROM THE DRIVERS SEAT,FROM THE HEATED SEAT. BURNED A HOLE THRU THE LEATHER . WAS ABLE TO TURN OFF THE SWITCH AND PUT SOME SNOW INTO THE GOLF SIZE HOLE AND PULLED THE FUSE TO THE ELECT HEAT SWITCH. NO FURTHER DAMAGE WAS NOTICED .CITY STREET. THE HOLE IS ABOUT 11/2 IN BELOW LEFT SIDE BEADING AND CLOSER TO FRONT OF SEAT. LEATHER SEAT IN VERY GOOD CODITION AND NON SMOKER. GARAGE KEEP.

Apr 05, 2021

Fire: 1

HEATED SEAT SHORTED WHEN TURNED ON ON DRIVERS SIDE AND BURNED ME WHILE DRIVING.

Jan 25, 2018

Fire: 1

Injuries: 1

TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE THE HEATED DRIVER SIDE SEAT WAS IN THE ON POSITION, A BURNING ODOR STARTED TO EMIT INSIDE THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACTED DISCOVERED A FLAME COMING FROM THE SIDE OF THE DRIVER SEAT. THE CONTACT INDICATED THAT THE FLAME SELF EXTINGUISHED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 107,000. UPDATED 4/7/15*CN

Mar 03, 2015

Fire: 1

THE DRIVER SEAT OVERHEATED, APPARENTLY FROM A MALFUNCTIONING SEAT WARMER, CAUSING COMBUSTION. THE FIRE BURNED THROUGH THE SEAT PADDING, OUTER LEATHER COVERING, AND THE DRIVER'S CLOTHING. IT BURNED INTO A WALLET IN THE DRIVER'S BACK POCKET, WHICH PROTECTED THE DRIVER FROM A BURN. THE BURN HOLE IN THE SEAT IS ABOUT THE SIZE OF A NICKEL. *TR

Mar 01, 2013

Fire: 1

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT HE ACTIVATED THE HEATED SEATS AND AFTER A MATTER OF MINUTES, SMOKE BELLOWED FROM THE SIDE OF THE DRIVER'S SEAT. THE SEAT WARMER WAS DEACTIVATED AND THE CONTACT NOTICED THAT A ONE INCH HOLE HAD BEEN BURNED INTO THE SEAT. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A MECHANIC. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 300,000. UPDATED 2/12/13 *CN

Jan 30, 2013

+ 5 more complaints for this component

ELECTRICAL SYSTEM

9 complaints

The contact owns a 2004 Volvo S60. The contact stated that while operating the vehicle, the instrument panel would not illuminate or operate. During the failure, the fuel gauge, speedometer, odometer, and other information was unavailable to the driver. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 157,000.

Nov 22, 2021

TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED AND WAS PULLED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS RESTARTED AND THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.

Jul 21, 2017

CAR WAS IN PARK AND RUNNING WHEN ELECTRICAL WIRES TO THE WINDSHIELD WIPERS CAUGHT FIRE. THE BUNDLE OF WIRES ARE HOUSED IN A RUBBER TUBE. MY UNDERSTANDING IS RUBBER IS QUITE FIRE-RESISTANT. THERE HAVE BEEN 5 RECALLS ON THIS MODEL, TWO WHICH WERE RELATED TO ELECTRICAL FIRES. NEITHER APPLIED TO THIS PARTICULAR CAR FIRE. LOCAL VOLVO DEALERSHIP WANTS NOTHING TO DO WITH THE SITUATION; THEY SEND US TO CORPORATE CUSTOMER SERVICE AND THEY, IN TURN SEND US BACK TO THE LOCAL DEALERSHIP . SERVICE MANAGER SAID HE WAS NOT A KNOWLEDGEABLE FIRE INSPECTOR AND SUGGESTED THAT WE HIRE AN EXPERT IN THAT FIELD. *TR

Jun 05, 2014

Fire: 1

PURCHASED THIS CAR IN 2010 WITH 51,000 MILES. SHORTLY AFTER PURCHASE CHECK ENGINE LIGHT CAME ON WITH SERVICE ENGINE SOON MESSAGE. CAR WORKED FINE. THEN BRAKE FAILURE MESSAGE CAME ON, BRAKES WORKED FINE. TOOK VEHICLE TO VOLVO DEALERSHIP AND THEY FOUND A WAY TO "RESET" SYSTEM. GO IN TRUNK, REMOVE BLACK BATTERY CABLE, TOUCH IT TO RED BATTERY CABLE FOR APPROX 10 SECONDS AND THE SYSTEM WILL. WE'VE RESET THE SYSTEM COUNTLESS TIMES AND IT CONTINUES TO BE A PROBLEM. ABOUT 3 MONTHS AGO ALL GAUGES WOULD QUIT WORKING AND CAR WOULD RANDOMLY BRAKE AT ABOUT 45 MPH. PLUS AFTER COMING TO STOP, CAR WOULD BARELY MOVE BUT AFTER IT GOT GOING IT WOULD BE FINE. RESET SYSTEM AND IT WORKED FOR ABOUT 3 MILES AND HAPPEN AGAIN. VOLVO MECHANIC FOUND AWD (DEM) CONTROL MODULE FAILURE. REPLACED THIS AT $1500 FOR THE PART AND AFTER 50 MILES, GAUGES STILL WORK, NO RANDOM BRAKING AND ACCELERATION IS NORMAL. BUT....SERVICE ENGINE MESSAGE AND CHECK ENGINE LIGHT BACK ON. WAS TOLD THAT ALL MODULES RELATE TO EACH AND IF ONE IS OUT IT CAN AFFECT THE OTHERS. AT ABOUT $1500 PER MODULE, IT IS COST PROHIBITIVE TO REPLACE ALL THESE, 6 TO BE EXACT. VOLVO NEEDS TO RECALL THESE VEHICLES AND REPLACE THESE MODULES. *TR

Feb 07, 2013

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING SEVERAL ELECTRICAL FAILURES. THE REAR DOOR INDICATOR WAS ILLUMINATED, THE VEHICLE WAS EXHIBITING HESITATION, THE STEERING WAS HARD TO TURN AND THE INTERIOR LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE BRAKE, SPARK PLUGS AND AIR FILTER WAS REPLACED HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO EXPERIENCE THE ELECTRICAL FAILURES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000 AND THE CURRENT MILEAGE WAS 120,000.

Jun 29, 2012

+ 4 more complaints for this component

POWER TRAIN

9 complaints

WHILE DRIVING 45 MILES PER HOUR AND ABOUT TO GET ON THE ON RAMP ON TO I-10. CAR LOST ALL ACCELERATION AND CAME TO A COMPLETE STOP. *TR

Aug 05, 2013

I WAS DRIVING MY 2004 VOLVO S60. THERE WERE NO ADVERSE DRIVING CONDITIONS, AND I WAS DRIVING NORMALLY. I WENT TO PUT MY S60 IN PARK, AND IT WOULD NOT GO PAST NEUTRAL INTO EITHER REVERSE OR PARK. MY S60 HAS A GEARTRONIC TRANSMISSION (GEARTRONIC IS ESSENTIALLY THE BRAND NAME OF THE VOLVO MANUMATIC TRANSMISSION. SOURCE: HTTP://WWW.EHOW.COM/INFO_7784643_GEARTRONIC-TRANSMISSION.HTML#IXZZ1K1HJ4JPR) THIS IS A SAFETY ISSUE BECAUSE OF THE FACT THAT IF I NEEDED TO GO INTO REVERSE I COULDN'T, AND BECAUSE I COULD NOT SHIFT INTO PARK AND THEREFORE COULD NOT REMOVE MY KEY FROM THE IGNITION. THERE WERE NO NOTICEABLE EVENTS LEADING UP TO THIS FAILURE OF THE GEARTRONIC TRANSMISSION SHIFT KNOB, BUT IT IS A VALID SAFETY ISSUE, AND MAY RESULT IN A RECALL IF THIS FAILURE OCCURS IN MORE VOLVOS WITH THE GEARTRONIC TRANSMISSION. ANY INFORMATION YOU CAN GATHER FROM VOLVO DEALERS AND OTHER REPUTABLE VOLVO SERVICE BUSINESSES CAN POTENTIALLY GATHER ENOUGH ISSUES WITH THE GEARTRONIC TRANSMISSION SHIFT KNOB TO ISSUE A RECALL. THIS ISSUE, IF IT HAS OCCURRED OR DOES OCCUR IN OTHER VOLVOS WITH THE GEARTRONIC TRANSMISSION AND GEAR SHIFT KNOB, MAY CAUSE THE DRIVER TO NOT BE ABLE TO SHIFT INTO OR OUT OF CERTAIN GEARS, AND MAY RESULT IN THE CARS NOT BEING ABLE TO BE PUT INTO PARK. THIS COULD RESULT IN SAID VEHICLES ROLLING AFTER TURNED OFF. ALSO, THE KEY WILL NOT COME OUT OF SAID VEHICLES IF THEY ARE NOT ABLE TO BE SHIFTED INTO PARK. *TR

Apr 19, 2011

ANGLE GEAR FAILURE IN VOLVO S60R AWD. *TR

Oct 24, 2008

WHEN ACCELERATING FROM A STOP, THE TRANSMISSION SEEMS TO SKIP A GEAR. THIS RESULTS IN UNEVEN ACCELERATION, MAKING MERGING INTO TRAFFIC HAZARDOUS. IT ONLY HAPPENS SPORADICALLY. *TR

Jan 10, 2008

THE GEAR SHIFT HEAD DISINTEGRATED IN MY HAND AS I SHIFTED FROM PARK INTO DRIVE CAUSING THE VEHICLE UNABLE TO BE SHIFTED INTO ANY GEAR BUT "DRIVE". COULD NOT TURN OFF THE VEHICLE, BUT WAS ABLE TO DRIVE INTO THE NEAREST VOLVO DEALER. CONSEQUENCES COULD HAVE BEEN DIRE IF I HAD TO STOP FOR A ROAD/POLICE EMERGENCY. *NM

Dec 07, 2006

+ 4 more complaints for this component

TIRES

8 complaints

DELAMINATION OF BRIDGESTONE BLIZZAK 15 INCH SNOW TIRE AT HIGHWAY SPEED, REAR LEFT TIRE. NO INJURY OR DAMAGE BUT TIRE TREAD COMPLETELY SEPARATED FROM SIDEWALL AS ONE UNIT LIKE A DONUT. 1 YEAR OLD TIRES WITH LESS THAN 10,000 MILES. *TR

Jan 17, 2010

FAILURE OCCURRED WITH PIRELLI P-ZERO ROSSO 235/40-18 TIRES. FAILURE OCCURRED IN CONSTRUCTION ZONE WITH VEHICLE TRAVELING 5 MI OVER POSTED SPEED LIMIT. ROAD WAS BEING REFINISHED. LEFT FRONT TIRE IMPACTED WITH RAISED MANHOLE. IMPACT CAUSED BULGE IN TIRE SIDEWALL. SIMILAR EVENT ALSO HAPPENED IN APRIL 2006 WHEN DRIVING SAME CAR IN ANOTHER CONSTRUCTION ZONE. DROVE OVER STEEL PLATE IN ROAD AT SLIGHTLY ABOVE POSTED SPEED LIMIT. LEFT FRONT TIRE IMPACTED PLATE AND BULGE APPEARED. IN BOTH INCIDENTS, TWO NEW TIRES HAD TO BE PURCHASED (4 TOTAL). *TR

Aug 17, 2008

FRONT TIRES ARE RUBBING THE BODY ON THE INSIDE OF THE TIRE. VEHICLE HAS ORIGINAL WHEELS AND TIRES. CHRONIC PROBLEM WITH VOLVO. *TR

Feb 27, 2008

I OWN A VOLVO S60 AND HAVE UNDER 30,000 MILES ON THE VEHICLE. YESTERDAY I SUFFEREDTHE SECOND BLOW OUT ON THE CONTINENTAL CONTITOURING CONTACT TIRES, 215/55R16 93H CH95. I AM CONCERNED FOR MY SAFETY AND THE SAFETY OF OTHERS AS THESE TIRES APPEAR TO BE DEFECTIVE WITH TWO BLOW OUTS IN UNDER 30,000 MILES. THE TIRES ARE RATED TO 60,000 MILES. *AK

Jul 12, 2007

2004 VOLVO S60 R WITH 18" TIRES. INSIDE DRIVER TIRE CONTACTS INSIDE DRIVER TIRE WALL. WEAR WILL CAUSE PREMATURE TIRE FAILURE. DEALER HAS ALWAYS MAINTAINED THAT THIS "RUBBING" IS NOT A PROBLEM. I HAVE COMPLAINED MULTIPLE TIMES. I HAVE PHOTOS OF THE TIRE DAMAGE. THE SIDE WALL AND CORNER TREAD IS WORN THROUGH TO THE STEEL BELT AND CORD. I HAVE BEEN TOLD THAT THIS IS NOT DUE TO ALIGNMENT, BUT MATCHES UP WITH THE RUBBING OF THE TIRE WELL WALL. *JB

Feb 18, 2007

+ 3 more complaints for this component

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

6 complaints

THE ENGINE LIGHT CAME ON IN MY 2004 VOLVO S60R. THE CAR WOULD LOOSE ACCELERATION AND ALSO STALLED. VOLVO SAID IT WAS THE FUEL PRESSURE SENSOR AND THAT IT HAD BEEN RECALLED BY VOLVO- RECALL # 07V226000. BUT THE VIN # OF MY CAR WAS NOT INCLUDED IN THE RECALL. IT WAS THE SAME PART THAT WAS RECALLED ON OTHER 2004 S60S. WHY NOT ON THE R AS WELL? *TR

Jan 13, 2011

TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 30 MPH THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE RESTARTED WITHIN A FEW MINUTES. THE VEHICLE WAS THEN INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT THE FUEL PUMP AND THE ENGINE COOLING SYSTEM HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.

Nov 19, 2010

1. VEHICLE STALLED 2 TIMES, LAST YEAR AND ON 08/09/2010 WHILE DRIVING ON HIGHWAY. I WAS ABLE TO RESTART BOTH TIME. THE SECOND TIME I WAS ABLE TO RESTART AFTER 5 MINUTES AND DRIVE TO THE NEARBY THE VOLVO STORE DEALERSHIP. 2. THE DEALERSHIP DIAGNOSED THE PROBLEM AND DETERMINED THE BATTERY WAS THE ISSUE. HOWEVER I SEE 2 RECALL CAMPAIGN ID NUMBERS: 09V483000 AND 07V226000 WHICH MAY BE THE ROOT CAUSE OF THE PROBLEM. I TALKED TO THE SERVICE MANAGER AT THE VOLVO STORE DEALERSHIP (1051 W. WEBSTER AVE, WINTER PARK, FL 32789 - 407-628-0550) BUT THE DEALERSHIP WON'T LOOK AT IT BECAUSE THEY SAID MY CAR IS NOT SHOWN UP FOR RECALL IN THEIR VOLVO DATABASE. 3. REPLACE THE BATTERY. *TR

Aug 12, 2010

CERTIFIED PREVIOUSLY OWNED VEHICLE STALLED DUE TO BUTTERFLY VALVE WITHIN THROTTLE BODY NOT OPENING FAST ENOUGH WHEN GOING AROUND A CORNER AND TOO MUCH LOAD ON THE ENGINE. EXAMPLE: EXITED FREEWAY AND WAS TURNING LEFT WHILE BRAKING DUE TO UPCOMING RED LIGHT. THE ENGINE STALLED IN THE MIDDLE OF AN INTERSECTION WHILE THE VEHICLE WAS IN MOTION AT APPROXIMATELY 10 MPH. LOST STEERING AND BRAKING POWER. THE PROBLEM WAS FIRST NOTICED WHEN MAKING RIGHT TURNS AND HAVING TO SUDDENLY BRAKE FOR A PEDESTRIAN, BICYCLIST, OR OTHER TRAFFIC HAZARD AND THE ENGINE STALLING OR FLUTTERING AT MUCH LOWER SPEEDS. AS IT WORSENED OVER THE COURSE OF A WEEK IT WAS ULTIMATELY THE WORST WITH THE MID-INTERSECTION STALL. AT THIS POINT WE WERE AFRAID TO DRIVE THE VEHICLE FOR FEAR OF CRASHING. VEHICLE WAS PURCHASED FROM A DEALER AS CERTIFIED PRE-OWNED 68,735 MILES ON 05/02/2008 AND WAS TAKEN TO DEALER FOR STALLING AT 76,678 MILES ON 08/15/2009. DEALER REPORTED THIS AS A MAINTENANCE ISSUE NOT COVERED UNDER WARRANTY. REPAIRS FOR CLEANING THE THROTTLE BODY, RESETTING VALVE, AND INSTALLING NEW GASKETS WAS $402.93. VEHICLE ORIGINALLY PURCHASED IN SOUTHERN CALIFORNIA. VEHICLE MOVED TO WASHINGTON IN FEBRUARY OF 2009. *TR

Feb 15, 2010

TL*THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS NO RESPONSE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. SUDDENLY,THE ENGINE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. ROADSIDE ASSISTANCE WAS CALLED TO THE SCENE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE TECHNICIAN STARTED THE ENGINE, BUT WAS UNABLE TO DUPLICATE THE FAILURES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON A SEPARATE OCCASION FOR IDENTICAL FAILURES AND THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE SENSOR FAILED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE FAILURE AND CURRENT MILEAGES WERE 77,000.

Jul 13, 2009

+ 1 more complaint for this component

VEHICLE SPEED CONTROL

5 complaints

TL*THE CONTACT OWNS A 2004 VOLVO S60 . THE CONTACT STATED WHILE DRIVING ON THE HIGHWAY APPROXIMATELY 65 MPH, THE VEHICLE STALLED. HE MENTIONED THAT THE FAILURE OCCURRED SEVERAL TIMES PRIOR. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THE THROTTLE BODY NEEDED TO BE REPLACED. THE FUEL PRESSURE SENSOR ALSO HAD TO BE REPLACED UNDER NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING ). THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 55,000.

Apr 08, 2011

TL*THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING AT ANY SPEED, THE CONTACT STATED THAT THE VEHICLE WOULD MOVE INTO LIMP MODE, CAUSING THE VEHICLE TO STALL. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT DID NOT INFORM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 96,000.

Dec 21, 2010

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WOULD ILLUMINATE SPORADICALLY FOLLOWED BY THE VEHICLE STALLING. THE FAILURE WOULD OCCUR MOST OFTEN WHEN DRIVING AT LOW SPEEDS. THE VEHICLE WAS TAKEN TO A LOCAL INDEPENDENT MECHANIC WHO ADVISED THE CONTACT THAT THE FUEL SENSOR WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED BUT WOULD PROVIDE NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGE WAS 52,000. UPDATED 12/03/10. *LJ

Sep 14, 2010

ON 1/6/07 I WAS TRAVELING VIA INTERSTATE WHEN THE 2004 VOLVO S60T EXPERIENCED WHAT WAS DISPLAYED ON THE SCREEN AS REDUCED ENGINE PERFORMANCE, AND QUICKLY SLOWED TO ABOUT 40 MPH. I WAS VERY NEARLY REAR-ENDED AS I WAS IN THE FAST LANE IN THE PROCESS OF PASSING A SLOWER VEHICLE. I PROCEEDED TO THE NEAREST EXIT AND COASTED INTO A GAS STATION. I TURNED OFF THE CAR AND TRIED TO RESTARTED IT. HOWEVER, IT MADE A LOUD NOISE, SHOOK, AND THEN FAILED TO CRANK. IT WAS TOWED TO THE NEAREST VOLVO DEALERSHIP, WHERE THEY INFORMED ME IT WAS A FAULTY THROTTLE BODY (ETM). THE CAR ONLY HAD 58,000 MILES , 8,000 OUT OF WARRANTY. THE REPAIRS INCLUDED REMOVING AND CLEANING THE ETM, REPLACING THE THROTTLE BODY, AND ETM SOFTWARE RELOADED FOR A TOTAL OF $14,000. 3 MONTHS LATER, WHILE I WAS IN THE HOSPITAL GIVING BIRTH, MY HUSBAND EXPERIENCED THE SAME MALFUNCTION ON THE WAY TO THE HOSPITAL, LOST POWER, AND HAD TO GET ALTERNATE TRANSPORTATION. WE TRADED THE CAR IMMEDIATELY WITHOUT REPAIR. *AK

Jun 19, 2007

TL*- WHILE PARKING THE 2004 VOLVO S60 IN THE DRIVEWAY THE VEHICLE SUDDENLY LURCHED FORWARD, CAUSING THE FRONT WHEELS TO GO OVER A CEMENT BLOCK, HITTING THE HOUSE LIGHTLY. SMOKE STARTED COMING FROM THE ENGINE, AND THE SERVICE ENGINE LIGHT ILLUMINATED ON THE DASHBOARD. THE CONTACT HAD THE VEHICLE TOWED TO A BODY SHOP SINCE THERE WAS SOME SLIGHT DAMAGE IN THE FRONT OF THE VEHICLE. CONTACT COULD PROVIDE PICTURES IF NEEDED. THE CURRENT AND FAILURE MILEAGE WERE BOTH 26800.*AK

Feb 28, 2007

Crash: 1

FUEL SYSTEM, OTHER

4 complaints

VOLVO S60, 2004 RECALL LETTER DATED JANUARY 15, 2010. *TR

Feb 15, 2010

2004 VOLVO S60 FUEL PRESSURE SENSOR. VOLVO ISSUED A RECALL FOR THIS FOR 2003-2004 MODELS. MY CAR HAD THIS PROBLEM AND ITS SYMPTOMS (CAR STALLING). VOLVO DEALERSHIP SAID MY CAR DID NOT FALL INTO RECALL DUE TO VIN # BREAK. VOLVO CORPORATION NEVER BOTHERED TO RETURN MY CALLS. I FEEL THAT I SHOULD BE REIMBURSED FOR THIS REPAIR AS IT CLEARLY MEETS THE RECALL DESCRIPTION. *TR

Mar 19, 2009

WHILE FUELING THE VEHICLE, GASOLINE BUBBLES UP AND OUT THROUGH THE FILLER NECK, LEAVING A LARGE PUDDLE OF GASOLINE ON THE GROUND. THIS GENERALLY HAPPENS WHEN THE TANK IS LESS THAN HALF FULL. *TR

Apr 21, 2008

I HAVE HAD THE SAME PROBLEM OF THE CAR STALLING AROUND TURNS AND ON ABRUPT STOPS. IT SEEMED TO FIRST BE RESOLVED BY THE RECALL OF THE PRESSURE SENSOR. RECENTLY THOUGH THE CAR HAS BEEN STALLING SOMETIMES 5 TIMES PER DAY WHEN DOING THE SAME. THE DEALER CLAIMS IT IS A PVC PROBLEM THAT NEEDS TO BE CLEANED AND WANTS TO CHARGE $1000 DOLLARS TO DO IT. *TR

Feb 17, 2008

ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

CAR STALLED WHILST BREAKING

Jun 18, 2016

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL RAIL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

Dec 07, 2015

STEERING

2 complaints

I AM WRITING ABOUT WHAT MAY BE DESIGN FLAW WITH THE VOLVO S60R THAT HAS ME VERY CONCERNED. MY FRONT TIRES RUB ON THE BODY IN THE WHEEL WELL WHEN I TURN SHARPLY INTO A PARKING SPACE. I DON'T THINK IT SHOULD DO THAT BUT I'VE BEEN TOLD IT'S "NORMAL" AND THE CAR "SETTLES" AS IT GETS OLDER. SEVERAL OTHER VOLVO S60 OWNERS HAVE THIS SAME PROBLEM WHERE THE TIRES RUB ON THE BODY. PLEASE LOOK INTO THIS. I BELIEVE IT WILL CAUSE SERIOUS CONSEQUENCES IN AN EMERGENCY SITUATION AND IT'S WEARING DOWN THE EDGE OF THE TIRES PREMATURELY, WHICH MAY ALSO BE DANGEROUS.

Jan 07, 2015

TL* THE CONTACT OWNS A 2004 VOLVO S60R. THE CONTACT WAS TRAVELING 12 MPH WHEN THE FRONT PASSENGER LOWER CONTROL ARM DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VIN FAILED TO QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER:04V029000 (STEERING:LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 135,000.

Jul 24, 2012

ELECTRICAL SYSTEM,SEATS

2 complaints

DRIVER'S SIDE SEAT STARTED SMOKING WITHIN A FEW SECONDS OF STARTING THE VEHICLE WHILE BACKING OUT OF PARKING PLACE. SEAT HEATER WAS ON. IMMEDIATELY STOPPED AND TURNED OFF SEAT HEATER AND SMOKING STOPPED. QUARTER SIZE HOLE WAS BURNED INTO THE LEATHER SEAT BOTTOM ON THE DRIVER'S SIDE OUTSIDE PANEL. TOOK IT TO DARRELL WALTRIP VOLVO/SUBARU IN FRANKLIN, TN, AND THEY SAID IT WAS THE SEAT HEATER AND TOOK THE FUSE OUT. SAID IT WASN'T COVERED UNDER WARRANTY AND NO RECALL OUT. HOPE NO ONE HAS THIS PROBLEM DRIVING DOWN THE INTERSTATE. BEST REGARDS AND THANKS FOR ALL YOUR HARD WORK, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Dec 29, 2014

Fire: 1

LIKE MANY OTHERS WHO ARE ON VOLVO WEBSITES HAVE REPORTED I TOO HAD A FIRE ON THE DRIVERS SEAT LEFT SIDE DUE TO MY SEAT HEATER. I NOW HAVE A HALF DOLLAR SIZED HOLE IN THE SIDE OF MY SEAT. THE FIRST SIGN OF THIS WAS A SMELL AND THEN A LOT OF SMOKE. LUCKILY I WAS ABLE TO PULL OVER QUICKLY AND HAD A TOWEL HANDY TO SNUFF IT OUT, OTHERWISE I WOULD HAVE BURNED HANDS OR OTHER PARTS. I'VE BEEN A LIFELONG VOLVO OWNER, I HAVE TO SAY I'M SURPRISED VOLVO HASN'T AT LEAST WARNED THEIR DEALERS ABOUT THIS PROBLEM. I DID SEE ANOTHER DRIVERS SEAT TOTALLY BLACKENED AND BURNT OUT LAST TIME I TOOK MY CAR IN, WAS AMAZED THAT IT COULD EVEN HAPPEN LET ALONE BE A COMMON OCCURRENCE. NOW AFTER SEARCHING ONLINE THIS IS A PREVALENT PROBLEM. *TR

Feb 09, 2012

Fire: 1

FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

2 complaints

LOSS ACCELERATION IN THE VEHICLE ON THE HIGHWAY AT 60 MPH. THE CAR WOULD NOT SPEED UP AND CONTINUE TO SLOW DOWN BUT NEVER CAME TO A FULL STOP. I WAS NOT ABLE TO GO PASS 40 MPH IN THE CAR AND ACCELERATION WAS SLOW. FIRST TIME IT HAPPEN, THE DEALER SAID THROTTLE BODY AND OIL COLLECTION SYSTEM NEEDED TO BE REPLACED. I REPLACED BOTH. IT HAPPENS AGAIN, TOOK IT TO A DIFFERENT PERSON, THE MECHANIC SAID FUEL CONTROL NEEDED TO BE REPLACED. I REPLACED THAT. IT HAPPEN THE THIRD TIME AND TOOK IT TO DEALER AND HE INFORMED ME THE SPARK PLUGS. I REPLACED THAT. NOW, THE PROBLEM IS STILL HAPPENING. *TR

Jul 16, 2014

WHILE DRIVING 70 MPH, CAR LOST ACCELERATION AND STALLED WITHOUT WARNING. IF I WOULD HAVE BEEN REAR ENDED GOING AT THIS SPEED I COULD HAVE LOST MY LIFE. CHECK ENGINE LIGHT CAME ON AND ALL CODES ARE ASSOCIATED WITH THE 181 RECALL. CALLED VOLVO AND VOLVO STATED THAT THIS VIN NUMBER WAS NOT PART OF THE RECALL YET I AM EXPERIENCING THE SAME EXACT PROBLEM AND HAVE THE SAME EXACT ENGINE CODES WHEN RUNNING A DIAGNOSTICS TEST ASSOCIATED WITH THIS RECALL. *TR

Jun 17, 2013

SUSPENSION

2 complaints

WHEN I DRIVE MY MANUAL TRANSMISSION S60R VOLVO, AND I SHIFT I HEAR A LOUD THUD IN THE BACK OF THE CAR, I CHECKED EVERYTHING THAT COULD POSSIBLY BE MAKING THE NOISE AND SECURED IT, IT BOTHERED ME SO MUCH I TOOK IT TO THE VOLVO DEALER AND THEY TOLD ME THAT IT WAS ACTUALLY BECAUSE OF THE SUSPENSION SOFTWARE AND THAT THERE WAS A RECALL FOR THIS, HOWEVER IT WAS NOT APPLICABLE FOR MY VIN. HE SAID THIS WAS THE BEST GUESS HE COULD MAKE, I INFORMED HIM THAT IT ONLY MAKES THE NOISE IF YOU MAKE A PRETTY GENTAL SHIFT, BUT IT CAN HAPPEN AT ANY TIME. *TR

Feb 05, 2011

LOUD NOISE FROM REAR WHEELS. FIRST THOUGHT TO BE WORN TIRES. TURNED OUT TO BE THE BEARINGS FAILED. CAUSED DAMAGE TO SPEED SENSOR, ROTOR, REAR AXLE DRIVE SHAFT. CAR SHOOK VIOLENTLY AS SPEEDS WHERE REDUCED. DEALER WILL NOT FIX PROBLEM. ALL PARTS TO BE REPLACED AT OWNERS EXPENSE. *NM

Feb 14, 2006

EQUIPMENT

2 complaints

2004 S60 VOLVO ALARM SYSTEM SERVICE REQUIRED. I'VE OWNED MORE THAN 8 DIFFERENT CARS OLDER THAN THIS CAR, AND THEY NEVER HAD ANY ISSUE WITH THE ALARM. IT SEEMS TO BE VERY COMMON TO REPLACE THE ALARM MODULE IN THIS VOLVO MODEL BECAUSE OF THE ACID LEAK FROM THE BATTERY THAT CAUSES A SHORT IN THE CIRCUIT. AND YES IT WILL HAPPEN AGAIN AFTER THE REPLACEMENT. WHAT A RIPOFF. *LN

Jan 16, 2011

I HAVE 2004 VOLVO S60VOLVO . I WAS TRYING TO RAISE MY VEHICLE ON THE OEM JACK CAME WITH MY CAR TO CHANGE THE WHEEL. AFTER FEW SECOND I REMOVED MY TIRE , THE JACK COLLAPSED - AND MY CAR CAME CRASHING DOWN. I WAS LUCKY AS I HAD STUCK MY HEAD INTO THE WHEEL WELL MOMENTS BEFORE TO CHECK MY BRAKE PADS AND ROTORS, AND HAD MY FINGERS AROUND THE SUSPENSION LINKAGES. *TR

May 03, 2010

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

2 complaints

I OWN A 2004 VOLVO S60R THAT HAS TURN SIGNAL ISSUES. THERE WAS NO EVENT LEADING UP TO THE FAILURE. SIMPLY ONE DAY IT NO LONGER WORKED 100% OF THE TIME. WHEN USING THE TURN INDICATOR STOCK TO SIGNAL A LEFT TURN IT WILL NOT DO SO IF I FULLY DEPRESS IT INTO THE LOCK POSITION. IF I HOLD IT ONLY PART OF THE WAY BEFORE IT LOCKS INTO THE POSITION IT SOMETIMES WORKS. IF I DO PUT IT INTO THE FULLY LOCKED POSITION AND TURN THE STEERING WHEEL SOMETIMES IT MAY WORK AND SOMETIMES IT MAY NOT. THIS ONLY EFFECTS THE LEFT TURN SIGNAL AND NOT THE RIGHT. I SAW THE FOLLOWING ARTICLE (HTTP://WWW.BUSINESSWEEK.COM/NEWS/2010-07-26/VOLVO-SUVS-EXAMINED-FOR-ELECTRONICS-FLAWS-U-S-SAYS.HTML) ABOUT THE 2004 - 2005 XC90 EXHIBITING THE SAME BEHAVIOR WITH THE TURN SIGNAL STALK INTERMITTENTLY WORKING. OBVIOUSLY THE CONSEQUENCES WOULD BE DISASTROUS IF I CANNOT SIGNAL MY INTENTIONS ON LANE CHANGING AND OTHERS WOULD THEN COLLIDE INTO ME CAUSING INJURY AND POSSIBLY DEATH TO EITHER ONE OR ALL PARTIES INVOLVED. NO PARTS HAVE BEEN REPLACED AND THE DEFECTIVE PART IS STILL INSTALLED ON MY VEHICLE. *TR

Jul 28, 2010

BULBS CONTINUOUSLY BURNS OUT CAUSING ERRORS THAT CANNOT BE READILY FIX BY THE OWNER. BULBS SUCH AS FOR HEADLIGHTS, TURN SIGNALS AND REAR LIGHTS BURN OUT CONSTANTLY. WE ARE AVERAGING A BULB REPLACEMENT EVERY 2 MONTHS. *TR

Sep 26, 2008

ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER

2 complaints

THE ENGINE LIGHT CAME ON IN MY 2004 VOLVO S60. THE CAR WOULD LOOSE ACCELERATION. TOOK IT TO OUR MECHANIC AND HE SAID IT WAS THE FUEL PRESSURE SENSOR AND THAT IT HAD BEEN RECALLED BY VOLVO- RECALL # 07V226000. TOOK IT TO THE DEALER AND THEY SAID THAT THE VIN # OF MY CAR WAS NOT INCLUDED IN THE RECALL. IT WAS THE SAME PART THAT WAS RECALLED ON OTHER 2004 S60S. THE COST WAS $450 TO REPAIR. *TR

Jul 09, 2010

FUEL PRESSURE SENSOR FUNCTIONING OUTSIDE OF ITS NORMAL PARAMETERS ECM CODE 2600. THERE IS RECALL ON THE PROBLEM BUT DEALER WILL NOT REPLACE THE SENSOR FREE OF CHARGE. RECALL #07V226000

Apr 01, 2010

EXTERIOR LIGHTING

2 complaints

ABOUT EVERY 2-3 MONTH WHEN I GO TO START MY VOLVO S60 THE FRONT LEFT LIGHT BLOWS OUT. I HAVE HAD MY CAR FOR A LITTLE OVER A YEAR AND HAVE HAD TO REPLACE THE HEADLAMPS 5 TIMES. THE FIRST TIME I CHANGED THE LIGHTS I DID NOT WEAR GLOVES SO IT COULD HAVE POSSIBLE BEEN MY FAULT. EVERYTIME AFTER I HAVE WORN GLOVES TO CHANGE THE LIGHTS AND STILL HAVE THE SAME PROBLEM. *TR

Sep 04, 2008

CONSUMER NOTICED THAT THE RIGHT FRONT HEADLIGHT LAMP WAS INOPERATIVE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE HEAD LAMP BLEW OUT AND NEEDED TO BE REPLACED. IT WOULD COST THE CONSUMER $1,200.00 TO GET IT REPLACED. PLEASE PROVIDE FURTHER DETAILS. *NM A PEBBLE FROM THE STREET MADE A SMALL HOLE IN THE GLASS IN FRONT OF THE HEADLAMP. MOISTURE INTRUDED INTO THE LAMP CASING. DUE TOTHE HEAT INTENSITY OF THE LAMP, IT SHORT-CIRCUITED. THE DESIGN OF THE HEAD LAMP SYSTEM DOES NOT ALLOW FOR THE SWIPE REPLACEMENT OF THE LAMP. THE HOLE IN THE GLASS CAUSES NEED FOR THE ENTIRE $1200 SYSTEM TO BE REPLACED. *BF

Apr 25, 2005

AIR BAGS

2 complaints

TL*THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING BETWEEN 25-30 MPH, THE CONTACT STRUCK A DEER AND THE VEHICLE FLIPPED OVER. NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE CONTACT SUSTAINED BACK AND NECK INJURIES. THE CONTACT HAS PICTURES. THE CURRENT AND FAILURE MILEAGES WERE 41,000.

Aug 29, 2008

Crash: 1

Injuries: 1

ON MARCH 12 MY VOLVO S-60R WAS T-BONED"BY A LARGE SUV ORD EXPLORER THAT IMPACTED A POINT NEAR MY FRONT DRIVER'S-SIDE WHEEL. THE SUV IMPACT CAUSED MAJOR DAMAGE TO THE FRONT END BY TOTALLY REMOVING THE VOLVO'S BUMPER AND MANGLING THE FRONT DRIVER QUARTER PANEL DOWN TO THE CHASSIS. ALTHOUGH MY CAR WAS SENT SPINNING BY THE FORCE OF THE COLLISION. NONE OF THE AIRBAGS DEPLOYED AT THIS INITIAL IMPACT. AS MY VOLVO PROCEEDED TO SPIN CLOCKWISE ACROSS THE PAVEMENT IT IMPACTED THE OVER PASS GUARD-RAIL SUCH THAT THE DRIVER'S SIDE SLAMMED INTO THE GUARD-RAIL, PINNING ME IN THE VEHICLE. ONLY THE PASSENGER FRONT AIRBAG DEPLOYED ON HITTING THE GUARD RAIL AND RELEASING MUCH SMOKE INTO THE CABIN. EVEN THOUGH THIS WAS AN ABRUPT, VIOLENT IMPACT , BOTH WHEN THE SUV HIT ME, AND WHEN MY CAR SLAMMED INTO THE GUARD RAIL THE ONLY COMPONENT OF THE AIRBAG/COLLISION CURTAIN SYSTEM TO FUNCTION WAS THE DASHBOARD INSTALLED PASSENGER AIR BAG. IT IS IMPORTANT TO NOTE THAT THERE WAS NO OTHER PERSON TRAVELING IN THE VOLVO BUT ME. THE FRONT PASSENGER SEAT AND THE REAR SEATS- WERE EMPTY. WITHIN ABOUT 12 HOURS OF THE ACCIDENT I WROTE VOLVO AMERICA TO EXPRESS MY EXTREME DISSATISFACTION WITH THE FAILURE OF THE CAR'S SAFETY SYSTEM.*AK

Mar 20, 2007

Crash: 1

Injuries: 1

ELECTRICAL SYSTEM,AIR BAGS,ENGINE

1 complaint

2004 VOLVO S60 PURCHASED THE CAR USED IN SEPT 04. On 7/8/24 STRANDED AT 7-11 CAR WOULDN'T START. ACTING AS IF THERE WAS POWER LOSS, AC WENT OFF, BRAKE FAILURE LIGHT ON PANEL, POWER WINDOWS AND LOCKS DID NOT WORK, TEMP 105 OUTSIDE , THEN DRIVER PANEL WENT BLACK., I WAS SCARED. ENGINE WOULDN'T START. FINALLY, AFTER WAITING 10 MINUTES...IT STARTED RUNNING BUT WAS SLUGGISH. RADIO WAS ON, POWER DOOR, LOCKS, AND WINDOWS, DID NOT WORK. CUT THE CAR OFF AND BACK ON, ALL POWER RETURNED, NOW CHECK ENGINE AND AIR BAG TROUBLE ON PANEL. CALLED VOLVO DEALER NEXT DAY NEAR MY HOME, THEY CAN NOT SEE MY CAR TIL NEXT WEEK TUESDAY. CAN NOT ACCESS ENGINE BOX, MUST GO TO DEALER.

Jul 08, 2024

AIR BAGS,FUEL/PROPULSION SYSTEM

1 complaint

RECALL AIRBAGS- FUEL GAUGE GOES UP AND DOWN NEVER REGISTERS CORRECTLY

Oct 21, 2021

SEAT BELTS

1 complaint

YES MY PASSENGER SIDE SEAT BELT JUST RANDOMLY LOCKED UP. MY CAR HAS NEVER BEEN IN ANY CRASHES I DIDN'T STOP SHORT FOR IT TO LOCK UP. I WENT TO PUT IT ON AND IT WOULD ONLY PULL HALF WAY OUT AND THEN WHEN IT WENT BACK IT IT STUCK. IT WON'T COME OUT AT ALL AT ALL NOW. I CAN'T PASS INSPECTION WITHOUT IT WORKING.

Mar 10, 2021

AIR BAGS,STRUCTURE

1 complaint

MY SON WAS IN A SIDE IMPACT COLLISION ON THE PASSENGER SIDE OF HIS 2004 VOLVO S60. HE WAS IN A RURAL AREA AND EITHER DIDN'T SEE THE ONCOMING CAR OR MISSED HIS STOP SIGN AND THE ONCOMING DRIVER WAS UNABLE TO STOP. THE OTHER DRIVER IS UNINJURED BUT MY SON IN SEVERELY INJURED WITH A GRADE 3 DAI HEAD INJURY. HE WAS WEARING HIS SEAT BELT. THE SIDE AIRBAGS DEPLOYED BUT NOT THE ONE IN THE STEERING WHEEL. IN AN EMAIL VOLVO TOLD ME THIS IS HOW THE AIRBAGS ARE DESIGNED AND THAT THE DRIVER AIRBAGS WILL NOT DEPLOY ON SIDE IMPACT. IF THAT IS CORRECT INFORMATION, THIS NEEDS TO CHANGE. THE ONLY SIGNIFICANT INJURY MY SON HAS IS WHERE HIS HEAD HIT THE STEERING WHEEL, IF THAT AIRBAG HAD DEPLOYED HIS INJURIES WOULD HAVE POTENTIALLY BEEN MUCH LESS. THE AIRBAGS ARE ALREADY THERE, I DON'T UNDERSTAND WHY THEY CAN'T JUST DEPLOY ON ANY SIGNIFICANT IMPACT. I WILL INCLUDE PICTURES.

Oct 13, 2020

Crash: 1

Injuries: 1

SERVICE BRAKES, AIR,AIR BAGS

1 complaint

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED WHILE ATTEMPTING TO MAKE A LEFT TURN, ANOTHER VEHICLE INTERSECTED HER LINE CAUSING IMPACT TO THE FRONT DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT STATED THAT THE ABS WARNING LIGHT WAS ILLUMINATED PRIOR TO THE ACCIDENT. THE CONTACT STATED NO ONE SUSTAINED INJURIES OR SOUGHT MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE VEHICLE FAILURE HAD NOT BEEN DIAGNOSED OR REPAIRED BY A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 162,000. *LN*JB

Mar 09, 2020

Crash: 1

STEERING,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

IN STOP AND GO TRAFFIC, MY FOOT WAS ON THE BRAKE TO SLOW DOWN. I TOOK MY FOOT OFF THE BRAKE AND STEPPED ON THE ACCELERATOR AS TRAFFIC MOVED AGAIN, THERE WAS NO RESPONSE TO MY FOOT ON THE GAS PEDAL. THE FUEL TANK, WHICH I HAD JUST FILLED 10 MILES BEFORE, SHOWED AS EMPTY ON THE FUEL GAGE. I WAS VERY, VERY SLOWLY ROLLING FORWARD WITH RESIDUAL MOMENTUM AND MY STEERING WASN'T WORKING. THERE WAS JUST ENOUGH PLAY IN THE WHEEL AND FORWARD MOMENTUM TO AIM AND ARRIVE AT THE SHOULDER OF THE HIGHWAY. THIS WAS ON RTE 156 IN MONTEREY COUNTY, CALIFORNIA, WHERE VERY DANGEROUS ACCIDENTS HAPPEN ALL THE TIME. CAR HAD TO BE TOWED AND THE DEALERSHIP HAS BEEN UNABLE TO REPLICATE FAILURE. IT WAS OUTRAGEOUSLY DANGEROUS AND I WAS ALONE WITH MY 11-YEAR-OLD CHILD. SO FRIGHTENING!!!

Oct 17, 2017

STEERING,FUEL/PROPULSION SYSTEM

1 complaint

I JUST RECENTLY WENT TO A DEALER FOR A GAS FUEL LEAK. THEY NOTICED A CRACK IN THE HOLDER. THE MECHANIC ALSO ASKED ME TO CHECK FOR A RECALL BEFORE FIXING DUE TO THIS BEING A COMMON PROBLEM WITH SOME VOLVOS. I AM ALSO NOTICING THERE IS A POWERSTEERING LEAKAGE SOMEWHERE BECAUSE IM CONSTANTLY PUTTING IN POWERSTEERING. PLEASE TAKE MY COMPLAINT IN CONSIDERATION DUE TO IT BEING LIFE THREATING AND I HAVE CHILDREN WHO I HAVE TO CARRY AROUND IN THAT VEHICLE. IF ITS A DEFECTIVE EQUITMENT ON VOLVO IM ASKING FOR IMMEDIATE REPLACEMENT. FOR SAFETY

Jul 12, 2017

ELECTRICAL SYSTEM,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, RESTARTED THE VEHICLE, AND RESUMED DRIVING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

Jul 05, 2016

STEERING,SERVICE BRAKES,ENGINE

1 complaint

THE 2.4L 2004 VOLVO S60 EXPERIENCES ERRATIC BEHAVIOR AND ENGINE FAILURE WHEN OPERATING MULTIPLE CONCURRENT ELECTRICAL SYSTEMS. WHEN THESE SYSTEMS (OPERATED WITHIN SPECIFIED GUIDELINES) ARE USED CONCURRENTLY THEY CAUSE THE FOLLOWING CONDITIONS: ENGINE FAILURE, LOSS OF POWER STEERING, LOSS OF BRAKES. THE FOLLOWING IS A LIST OF ELECTRICAL CHANNELS THAT HAVE BEEN USED TO TRIGGER THE ENGINE FAILURE: BRAKES, INDICATOR LIGHTS (RIGHT OR LEFT) HEATED SEATS (X2) FRONT WINDSHIELD DEFROST MULTIPLE S60 MODEL OWNERS HAVE REPORTED HAVING EXPERIENCED THIS SAME ENGINE FAILURE WHICH CANNOT BE DETECTED BY THE MANUFACTURES DIAGNOSTICS TEST. WHEN TESTED THE BATTERY, ALTERNATOR AND COMPUTER ALL PRESENT POSITIVE READ-OUTS. HTTP://REPAIRPAL.COM/REPLACED-MAP-SENOR-AND-MAF-AIRFLOW-ENGINE-LIGHT-BACK-ON-HESITATE-STILL-CUT-OFF-321 HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2290017/VOLVO-S60-ENGINE-CUTS-OFF-WHILE-TURNING HTTPS://ANSWERS.YAHOO.COM/QUESTION/INDEX?QID=20110502120739AA0TJSR THIS IS A SERIOUS CONDITION THAT COULD RESULT IN A COLLISION OR EVEN DEATH. A RECALL ON THIS MODEL IS BEING IMMEDIATELY REQUESTED. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Jan 21, 2015

POWER TRAIN,ELECTRICAL SYSTEM

1 complaint

WHILE DRIVING, THE CAR JERKS VIOLENTLY - THE SAME THING HAPPENS WHEN THE CAR IS IDLING (NO JERK, ONLY AN "CLICK" SOUND). IT HAPPENS ANYTIME BUT SEEMS WORSE IN THE SUMMER BUT I THINK IT'S HOT-HEAT RELATED. THE OTHER ISSUES ARE RELATED: -THE INTERIOR LIGHTS USUALLY COME ON -THE INSTRUMENT PANEL GOES COMPLETELY BLANK/LIGHTS GO OFF/NO AVAILABLE EMERGENCY LIGHTS -THE WINDSHIELD WIPERS MAKE ONE WIPE SOMETIMES -THE "REAR PASSENGER DOOR OPEN" WARNING COMES ON -THE "BRAKE FAILURE STOP SAFELY" WARNING COMES ON AND SOMETIMES "CHECK ENGINE" LIGHT COMES ON. NOT ALL OF THESE SYMPTOMS OCCUR EACH TIME. THERE ARE MORE SEVERE AND LESS SEVERE INCIDENTS. *TR

Oct 31, 2014

VEHICLE SPEED CONTROL,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THERE WAS A SUDDEN LOSS OF ENGINE POWER WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY AND BODY GASKET NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 145,000.

Feb 05, 2014

AIR BAGS,STRUCTURE,SERVICE BRAKES

1 complaint

I WAS DRIVING 35-40 MPH WHEN A VEHICLE 2 CARS AHEAD OF ME HAD TO MAKE A QUICK STOP. I DID NOT SEE THIS HAPPEN IN TIME, SLAMMED ON MY BRAKES AND CONSEQUENTLY SMASHED INTO THE BACK OF THE CAR IN FRONT OF ME, WHO THEN HIT THE CAR IN FRONT OF HIM. I TOTALED MY CAR. THE PASSENGER AIR BAG DEPLOYED AND FILLED MY CAR WITH SMOKE (OR WHATEVER THAT IS) HOWEVER, THE DRIVER AIR BAG DID NOT DEPLOY. I WAS RUSHED TO A TRAUMA CENTER AND MY INJURIES INCLUDE MY BACK, NECK AND I LOST A TOOTH FROM MY FACE HITTING THE STEERING WHEEL. MY CHEST AND LEGS ARE COVERED IN BRUISES FROM THE SEAT BELT. I AM VERY LUCKY, HOWEVER, I DO NOT LIKE TO THINK OF WHAT COULD HAVE OCCURRED IF I WAS AT A HIGH SPEED AND ON THE FWY. AND THE AIR BAG DID NOT DEPLOY BECAUSE IT WAS DEFECTIVE, AND PERHAPS IT WAS NOT DESIGNED TO GO OFF IN THIS PARTICULAR INCIDENT? I HIT HEAD ON, NO LOGICAL REASON TO THINK THE PASSENGER AIRBAG GOING OFF AS IT DID, BUT NOT MINE OR DRIVER SIDE. *JB

Sep 18, 2013

Crash: 1

Injuries: 1

VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

CHECK ENGINE LIGHT CAME ON AND CAR LOST POWER WHILE DRIVING AT HIGHWAY SPEEDS. IT WOULD NOT ACCELERATE AND DISPLAYED THE MESSAGE "REDUCED ENGINE PERFORMANCE". DEALER INDICATED IT WAS A CRACKED INTERCOOLER HOSE AND THAT CAUSED THE ISSUE. IT WAS REPLACE AND AFTER ABOUT TWO MONTHS THE SAME SYMPTOMS HAPPENED. IT WAS THEN DIAGNOSED AS A BAD ELECTRONIC THROTTLE BODY. THAT WAS REPLACED AND THE SAME SYMPTOMS HAPPENED WITHIN TWO MONTHS AGAIN. THE CAR NOW DOES NOT ACCELERATE MORE THAN 10 MPH. THE NEXT DIAGNOSIS WAS TO REPLACE THE COMPLETE ENGINE WIRING HARNESS. THE CAR IS UNSAFE TO DRIVE BECAUSE IT STALL OR DECELERATE FROM HIGHWAY SPEEDS WITH NO NOTICE. IT IS VERY SIMILAR TO A RECALL FOR MODEL YEARS UP TO 2002. *TR

Aug 22, 2013

FUEL SYSTEM, GASOLINE,ENGINE

1 complaint

DRIVING HOME AFTER PURCHASING THE CAR (YEAH), I WAS TURNING INTO A PARKING LOT, SO MY SPEED WAS DESCENDING AND THE CAR STALLED. I WROTE IT OFF AS MY FAULT BECAUSE IT DID NOT HAPPEN AGAIN UNTIL 3 MONTHS LATER. WITHIN THE PAST 3 WEEKS THE CAR HAS STALLED WHILE IN MOTION APPROX. 6 TIMES. VOLVO STATED THE RECALLED PART FOR THIS ISSUE WAS REPLACED IN 2009. I NOTIFIED THE DEALER AND HAVE A APPOINTMENT FOR REPAIR, AT MY EXPENSE BECAUSE IT WAS ALREADY REPLACED. MEANWHILE I WILL NOT DRIVE THE CAR DUE TO THE LACK OF SAFETY. WISH I WOULD HAVE RESEARCHED THE CAR MODEL BEFORE PURCHASE. *TR

Jul 24, 2013

POWER TRAIN,ENGINE

1 complaint

APPROXIMATE A MONTH LATER AFTER I BROUGHT 2004 VOLVO S60 AT DEC 2011, WHEN I WAS DRIVING IN FREEWAY TO POST OFFICE, WHAT A SUDDEN, THE ENGINE STALLED WITHOUT WARNING, I PRESS THE ACCELERATE PEDAL, BUT IT WAS NOT RESPONSE, BUT THE CAR STILL HV A LITTLE MOMENTUM, THEN IT TURN IT TO THE CORNER AND THE CAR WAS STOPPED. I TURN OFF THE KEY AND RESTART THE CAR AGAIN, IT WORKED.AFTER A YEAR, THE PROBLEM COME BACK AGAIN AND THE FREQUENCY BECOME MORE, UP TIL DEC, 2012, 3 MORE TIMES SAME PROBLEM INCURRED. IT WAS SCARY. *TR

Dec 10, 2012

PARKING BRAKE,SERVICE BRAKES

1 complaint

GOOD AFTERNOON, WE HAVE EXPERIENCED A CATASTROPHIC FAILURE OF THE EMERGENCY BRAKE, WHEREBY THE BRAKE LINING OF THE E-BRAKE IS OF AN "ORGANIC" COMPOUND AND ACCORDING TO THE VOLVO TECHNICIAN "SWELLS" WHEN IT GETS WET, CAUSING THE E-BRAKE TO LOCK-UP. MY BRIDE WAS IN OUR NEIGHBORHOOD WHEN THIS OCCURRED, CAUSING THE ENTIRE BRAKING ASSEMBLY AND ASSOCIATED PARTS TO BE RIPPED AND BUSTED LOOSE. VOLVO CHARGED US $2100 IN PARTS AND LABOR TO "FIX" THIS. VOLVO TECHS DID SAY THAT THIS HAPPENS ALOT, BUT ALOT AT SPEED (FASTER THAN 25MPH). CAN YOU IMAGINE THIS E-BRAKE LOCK-UP AT HIGHWAY SPEEDS. HOW FREQUENTLY HAS THIS HAPPENED? I HAVE PICTURES OF THE AFFECTED PARTS. THIS IS TOTALLY UNSAFE AND VOLVO KNOWS ABOUT IT. *TR

Oct 21, 2012

STEERING,ELECTRICAL SYSTEM,ENGINE

1 complaint

WHEN TURNING A CORNER. I NOTICED THE CHECK ENGINE LIGHT WAS ON. THE THIS HAPPENED A SECOND TIME A WEEK LATER, AND THEN SEVERAL ADDITIONAL TIMES. I TOOK THE CAR TO INDEPENDENT MECHANIC AND HE CHECKED IT OUT BUT COULDN'T DIAGNOSE THE PROBLEM. HE ONLY SPECULATED THAT IT COULD BE THE PVC BOX, BUT THAT THEY WERE NOT SURE IT WOULD FIX THE PROBLEM. THE CAR HAD APPROXIMATELY 100K AFTER THIS HAPPENED ABOUT EIGHT TIMES IN THE NEXT 3 MONTHS, I TOOK THE CAR TO VOLVO DEALER. THEY CHECKED IT OUT, AND TOLD ME IT MAY BE THE PVC BOX, BUT THEY WERE NOT SURE THIS WOULD FIX THE PROBLEM. I TOOK IT TO ANOTHER MECHANIC AND WHO SAID IT WAS THE CATALYTYIC CONVERTER. THIS PROBLEM HAS BEEN ONGOING FOR A YEAR. I TOOK THE CAR TO ANOTHER MECHANIC AND HE CHANGED THE SPARK PLUGS AND CABIN FILTER. HE TOLD ME TO TAKE THE CAR TO THE VOLVO DEALERSHIP/SERVICE TO HAVE THE COMPUTER RESET. HE SAID, BECAUSE THE CAR LOOSES PRESSURE AND STALLS WHEN YOU MAKE A QUICK TURN. I CALLED VOLVO THEY SAID THIS WOULD FIX THE PROBLEM. I TOOK THE CAR TO VOLVO TO GET AN OIL CHANGE. THEY TOLD ME THE CAR STALLED OUT ON THE MECHANIC 3 TIMES AND THE CHECK ENGIINE LIGHT WAS ON. THEY CHECKED THE CAR ON THE COMPUTER AND TOLD ME THE ENGINE COILS NEEDED REPLACING. THAT WAS THE PROBLEM. I PAID FOR THE ENGINE COILS TO BE REPLACED AND SOME OTHER WORK WHICH TOTALED $1350.00. I PICKED THE CAR UP ON FRIDAY, ON MONDAY, WHILE TURNING A CORNER THE CAR STALLED OUT, NO POWER, NO STEERING, JUST ONBOARD LIGHTS. IT HAPPENED AGAIN ON TUESDAY MORNING. I EXPERIENCED THIS PROBLEM WHEN THE CAR WAS UNDER RECALL. THE DEALERSHIP FIXED IT, BUT IT SEEMS AS THOUGH THIS PROBLEM IS OCCURING AGAIN. THIS IS DANGEROUS AND VOLVO SHOULD BE RESPONSIBLE AND FIX THESE CARS. THERE ARE SOME SERIOUS MECHANICAL/ENGINE PROBLEMS WITH THIS VEHICLE. *TT

May 22, 2012

SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL

1 complaint

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT WAS DRIVING 25 MPH WITH CRUISE CONTROL ACTIVATED WHEN THE BRAKES WERE DEPRESSED BUT THE VEHICLE FAILED TO STOP. THE CONTACT CRASHED INTO FIVE VEHICLES. THE CONTACT'S VEHICLE WAS DESTROYED. THE POLICE WERE CONTACTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC AND THE MANUFACTURER WAS CONTACTED. UPDATED 04/16/12 *BF THE CONSUMER STATED THE CRUISE CONTROL WAS NOT FUNCTIONING PROPERLY. THE THROTTLE REMAINED OPEN. UPDATED 04/25/12

Mar 13, 2012

Crash: 1

STEERING,ELECTRICAL SYSTEM

1 complaint

1/22/08 INSERTED KEY AND IT WOULD ONLY MOVE INTO THE FIRST POSITION ACTIVATING THE RADIO, LIGHTS, ETC. UNABLE TO CONTINUE TO TURN KEY AND TURN ON AUTOMOBILE. STEERING COLUMN LOCK ASSEMBLY FAILED, ALTHOUGH IT IS EXPECTED TO LAST THE LIFE OF THE CAR, LEAVING ME STRANDED AND WITHOUT A CAR FOR OVER A WEEK SINCE PART COMES FROM GERMANY. 4/17/12 SAME SYMPTOMS AND ONCE AGAIN I AM STRANDED UNEXPECTEDLY. VOLVO DEALER REPORTS THIS HAPPENS OFTEN AND NEW DOUBLE PRICED PART MIGHT LAST LONGER. THIS IS A DANGER DUE TO ITS SUDDEN COMPLETELY UNPREDICTABLE ONSET, INABILITY TO BE DRIVEN, AND LENGTH OF TIME THAT THE CAR IS UNABLE TO BE IN USE. *TR

Feb 17, 2012

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1 complaint

WHEN TURNING A CORNER, THE ENGINE STOPPED, STEERING STOPPED WORKING AND LIGHTS ON DASHBOARD COME ON. THIS HAPPENED A SECOND TIME TWO DAYS LATER. TOOK TO INDEPENDENT MECHANIC AND HE CHECKED ALL WORK HE HAD DONE IN THE PAST PLUS CHECKED THE WHOLE CAR OUT AND HE COULD NOT FIND WHY THE CAR STOPPED. TWO DAYS LATER THE CAR AGAIN STALLED OUT WHEN IN TRAFFIC - ENGINE STOPPED, STEERING STOPPED WORKING AND LIGHTS ON DASHBOARD CAME ON. LAST TWO TIMES THIS HAPPENED I WAS DRIVING ON A STRAIGHT ROAD. THIS HAS HAPPENED 5 TIMES NOW IN THE LAST WEEK. ALL TIMES ENGINE STOPPED WORKING, I WAS DRIVING BETWEEN 10 AND 40 MILES PER HOUR. AFTER RESEARCHING THIS PROBLEM, I FOUND OUT THAT MY VEHICLE HAD BEEN RECALLED AND AT 53,333 MILES THE FUEL PRESSURE SENSOR WAS REPLACED BY THE DEALER. NOW 42,000 MILES LATER IT APPEARS THAT IT IS ONCE AGAIN THE FUEL PRESSURE SENSOR. THIS IS VERY DANGEROUS ESPECIALLY SINCE I DO A LOT OF HIGHWAY DRIVING AND ALSO LIVE IN AN AREA WHERE CHILDREN HAVE BEEN KNOW TO RUN OUT INTO THE STREET. NOT ONLY IS THERE A POSSIBILITY OF A CAR ACCIDENT, BUT ALSO THE POSSIBILITY OF A CHILD BEING HIT IF I CANNOT TURN THE CAR QUICKLY TO AVOID THE CHILD. AT THIS POINT I AM AFRAID TO DRIVE THE CAR AND FELL VERY UNSAFE EVEN THOUGH VOLVOS ARE KNOW FOR THEIR SAFETY. AFTER READING NUMEROUS REPORTS OF MANY PEOPLE HAVING THIS PROBLEM WITH THEIR 2004 S60 VOLVOS IT MAKES ME WONDER WHY VOLVO IS NOT CORRECTING THIS PROBLEM ON ALL 2004 VOLVO S60S THAT ARE HAVING THIS SAME PROBLEM. MY MECHANIC IS CHECKING ON THIS PROBLEM AND WILL REPLACE NEXT WEEK IF THIS IS THE REAL ISSUE. SOMETIMES DOORS LOCK FOR NO REASON AT ALL. ALSO I HAVE HAD TO REPLACE THE REAR LIGHTS ON THIS VEHICLE SEVERAL TIMES. SEEMS MUCH MORE THAN NORMAL. *TT

Jan 20, 2012

ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

1 complaint

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN THE VEHICLE ABNORMALLY ACCELERATED UNTIL CRASHING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER BUT THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS REPAIRED FOR THE BODY DAMAGES. THE FAILURE AND CURRENT MILEAGE WAS 92,058. UPDATED 05/26/11 *BF THE CONSUMER STATED AS SHE MADE A TURN, THE VEHICLE TOOK OFF AT A VERY HIGH SPEED. THE VEHICLE WENT FORM SIDE TO SIDE AS SHE TRIED VERY HARD TO BRAKE AND STEER AWAY FROM THE INCLINE ON THE RIGHT. THIS ACTION CONTINUED FOR ABOUT 0.3 MILES, BEFORE THE VEHICLE AIR LIFTED AND THE RIGHT PASSENGER SIDE BETWEEN THE REAR DOOR AND REAR QUARTER PANEL HIT THE GUARDRAIL. THE VEHICLE THEN BOUNCED OFF THE GUARDRAIL, CROSSED THE STREET, JUMPED THE GUTTER AND LANDED ON ITS WHEELS IN A NEARBY FIELD, WHERE IT CAME TO A STOP. WHEN SHE TRIED TO START THE VEHICLE, SHE KEPT IN THE LOWEST GEAR, WITH HER FOOT ON THE BRAKE AND A MESSAGE LIGHT ILLUMINATED STATING DO NOT DRIVE, COOLANT IS LOW. UPDATED 08/24/11

Apr 29, 2011

Crash: 1

ENGINE AND ENGINE COOLING,EQUIPMENT

1 complaint

2004 VOLVO S60 STALLED SUDDENLY WHEN TURNING. IT HAS STALLED WHEN PULLING FROM A STOP SIGN. BOTH INCIDENTS OCCURRED AROUND WITH 100,000 MILES ON THE CAR. COMPLETE LOSS OF POWER, STEERING, AND BRAKING. VEHICLE TAKEN TO DEALER AND WAS TOLD THERE WAS A PROBLEM WITH THE FUEL PRESSURE SENSOR. THERE IS A RECALL FPS FOR THE SAME YEAR, MAKE AND MODEL AS MY CAR, HOWEVER, I WAS TOLD THAT MY VIN# IS NOT INCLUDED IN THE RECALL. PROBLEM HAS YET TO BE FIXED. *TR

Apr 24, 2011

FUEL SYSTEM, GASOLINE,EXTERIOR LIGHTING

1 complaint

PURCHASED AUTO NEW. IT WOULD SEEM THAT I HAVE HAD SOME OF THE SAME PROBLEMS MENTIONED BY OTHERS. CAR STALLING ON HIGHWAY AT 65 MILES PER HOUR, TWICE, VERY SCARY. PULLED OFF AND RESTARTED. (FUEL PRESSURE SENSOR MALFUNCTION) SEEMS THERE IS A RECALL HOWEVER WHEN I INQUIRED MY VIN # WAS NOT INCLUDED. COSTLY REPAIR AS MUST PURCHASE PART FROM DEALER. DRIVER SIDE HEAD LAMP, LOW BEAM, HAS BEEN REPLACED SO OFTEN LOST TRACK, OVER HALF A DOZEN TIMES, IS OUT NOW! HAVE NEVER REPLACED PASSENGER SIDE LAMP! I POINT OUT THE OTHER S60'S I SEE ON THE ROAD WITH A HEADLAMP LIGHT OUT TO MY KIDS AS A GAME NOW. *TR

Nov 15, 2010

STRUCTURE,LATCHES/LOCKS/LINKAGES

1 complaint

I HAVE A 2006 VOLVO S-60 AND THE INTERIOR DOOR PANEL ON PASSENGER SIDE FAILED WHICH LEADS TO THE PASSENGER NOT BEING ABLE TO EXIT THE VEHICLE. *TR

Sep 21, 2010

POWER TRAIN,AIR BAGS

1 complaint

WHEN PULLING INTO A PARKING SPACE AT MY DAUGHTER'S SCHOOL, VEHICLE SUDDENLY ACCELERATED OVER THE SIDEWALK AND STRUCK THE BUILDING. TRANSMISSION POPPED IN REVERSE AND VEHICLE ACCELERATED BACKWARDS. EVEN WITH THE BRAKE PEDAL ALL THE WAY TO THE FLOOR, VEHICLE WOULD NOT STOP. I FORCED THE TRANSMISSION INTO PARK AND TURNED OFF THE VEHICLE TO GET IT TO STOP AFTER GOING IN REVERSE FOR APPROXIMATELY 50 FEET. THERE WAS SIGNIFICANT DAMAGE TO THE CAR AND BUILDING (PICTURES AVAILABLE). NONE OF THE AIRBAGS DEPLOYED. *TR

Aug 10, 2010

Crash: 1

Injuries: 1

ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

1 complaint

2004 VOLVO S60 IGNITION KEY FAILURE: KEY REFUSED TO TURN CAR WILL NOT START. CAR WILL NOT GO IN TO NEUTRAL. CAR MUST BE ABANDONED OCCUPANTS MUST SEEK TRANSPORTATION. FIRST OCCURRENCE APRIL 17TH 2008. SECOND OCCURRENCE JULY 5TH. 2010. CAR TOWED TO DEALER AND IGNITION LOCK REPLACED BOTH TIMES. TOTAL COST $1662.48. *TR

Jul 15, 2010

ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER,EXTERIOR LIGHTING

1 complaint

2004 VOLVO S60 REGULARLY SERVICED BY VOLVO. BOUGHT NEW, WELL MAINTAINED, EXC COND, & OIL CHANGED EVER 3000 MILES. ONLY 68K MILES PRESENTLY BUT MANY PROBLEMS SINCE BOUGHT NEW. #1) REPLACING BURNED OUT REAR/FRONT HEADLIGHT BULBS CONSTANTLY. #2) CHECK ENGINE LIGHT CAME ON BEFORE 40K MILES. WASN'T TOO CONCERNED AT FIRST BECAUSE ONLY ISSUE I SEEMED TO HAVE WAS HESITATION SOMEWHAT WHEN ACCELERATING AFTER BEING PARKED. UNTIL ONE DAY VEH WOULDN'T ACCELERATE BEYOND A ROLL AFTER BEING STOPPED FOR RED LIGHT. A FEW DAYS LATER DRIVING APPROX 50 MPH UPHILL CAR STOPPED ACCELERATING AND STALLED. BOTH TIMES I WAS ABLE TO ROLL TO SIDE OF ROAD, RESTART & MAKE IT HOME. SCARED ME ENOUGH THOUGH TO TAKE TO VOLVO NEXT DAY. FUEL SENSOR GAUGE NEEDED TO BE REPLACED. WHEN I CHECKED IF COVERED UNDER RECALL - FOUND MY CAR WASN'T BASED ON VIN, ANOTHER FAIRLY COSTLY REPAIR. #3 - AC FAN WOULDN'T GO OFF ONE DAY - FAN RUNNING FULL BLAST & CONTROL SWITCH WOULDN'T REGULATE OR WORK. FAN CONTINUED TO RUN EVEN WHEN I TURNED OFF IGNITION. DEAD BATTERY NEXT MORNING NEEDED JUMP START. AC FAN MODULAR BAD - MODULAR REPAIR DONE & THEN FAN SOMEHOW BURNED OUT DUE TO NEW MODULAR WHEN MECHANIC TESTING REPAIR - NOW FAN NEEDED TO BE REPLACED. VERY COSTLY REPAIR ONCE AGAIN. #3 - CHECK ENGINE LIGHT CAME ON. AFTER MONTHS TO SEVERAL MECHANICS, CHECKING OIL, ETC. TOLD LIGHT PROBABLY JUST FAULTY. THEN CHECK OIL LIGHT BLINKS - CAR HAD LESS THAN 1/2 QT OIL & I HAD MAJOR ENGINE DAMAGE. HAD COMPLETE ENGINE REBUILT & VERY EXPENSIVE. ENGINE RUNNING GREAT. NOW 2 MOS LATER & I HEAR A METAL TO METAL NOISE/SOUND WHEN MAKING TURNS - PREFERABLY RIGHT HAND - & COMING FROM RGHT FRONT SIDE OF CAR. MECHANIC CAN'T SEE SAFETY ISSUES WHEN UP ON RACK. HAS NO CLUE. NOISE ANNOYING AND CONCERNING. IT SOUNDS LIKE WHEEL IS GOING TO FALL OFF CAR. I AM SURE IT WILL COST ANOTHER FORTUNE . HOWEVER ONCE REPAIRED - TRADING IN. I LOVED MY CAR...HOWEVER NO LONGER FEEL VEH IS SAFE OR DEPEN. *TR

Nov 09, 2009

PARKING BRAKE

1 complaint

PARKING BRAKE PAD DELAMINATED FROM SHOE: DISLODGED AFTER DRIVING OVER A BUMP IN THE ROAD AND BECAME WEDGED INTO REAR SPINDLE CAUSING WHEEL TO LOCK UP AND RESULTED IN MAJOR DAMAGE TO BRAKE AND WHEEL COMPONENTS. 1 OCCURRENCE, REQUIRED REPLACEMENT OF LEFT REAR ROTOR, BACKING PLATE, SPINDLE, PARKING BRAKE SHOES (BOTH SIDES) AND PARKING BRAKE CABLE. *TR

Jan 15, 2009

ENGINE AND ENGINE COOLING,VISIBILITY,AIR BAGS,SERVICE BRAKES, ELECTRIC

1 complaint

2004 VOLVO S60 2.5 TURBO: NO WARNING TO THE EVENTS. ON NUMEROUS OCCASIONS, THE CAR FEELS AS IF IT HAS HIT A LARGE OBJECT, TEMPORARILY LURCHES AND APPEARS TO MOMENTARILY STALL CREATING A TEMPORARY LOSS OF VEHICLE CONTROL. THIS IS FOLLOWED BY AN IMMEDIATE LOSS OF ALL INSTRUMENT GAUGES, AIR CONDITIONER, WINDOW CONTROLS AND DOOR LOCKS. THE FAN DID CONTINUE TO WORK. THE ABS WARNING LIGHT ALSO INDICATED AS WELL AS A WARNING THAT NO BRAKES FUNCTION EXISTED. THE SRS SERVICE AIR BAG URGENT INDICATION IS ILLUMINATED. ON TURNING THE CAR OFF AND RESTARTING, THE FUNCTIONS OF THE CAR RETURN WITH EXCEPTION THAT THE SRS SERVICE AIR BAG URGENT INDICATION REMAINS. THIS PROBLEM CAN TAKE MONTHS TO REPEAT OR ONLY A MATTER OF MINUTES. IT SEEMS TO BE MORE PREVALENT IN HOT WEATHER. THE VEHICLE WAS TAKEN TO THE SERVICE SHOP AT THE VOLVO DEALER AND THEY COULD ONLY CLEAR ALARMS AS THEY SAID THE EVENT CREATED TOO MANY ALARMS/FAULT CODES TO TROUBLESHOOT. THEY DOWNLOADED NEW SOFTWARE REVISIONS TO EACH CONTROL MODULE IN THE CAR. AFTER A PERIOD OF APPROXIMATELY A MONTH, THE EVENTS BEGAN OCCURRING AGAIN. THE VEHICLE HAS BEEN TAKEN TO NON OEM MECHANICS AS WELL AND THEY ARE NOT ABLE TO TROUBLESHOOT THE FAULT. THE VEHICLE IS SCHEDULED TO BE TAKEN TO THE DEALERS SERVICE SHOP AGAIN. SEARCHING THE INTERNET CHAT ROOMS AND BLOGS, AS WELL AS THIS SITE, THERE APPEARS TO BE NUMEROUS OTHER VEHICLES WITH THIS SAME SAFETY FAULT THAT STALLS VEHICLES IN TRAFFIC AND CREATES VERY SUDDEN AND SEVERE LURCHES IN POWER ULTIMATELY LEADING TO A MOMENTARY STALL OUT WITH LOSS OF ALL INSTRUMENT INDICATIONS TO INCLUDE SPEED, RPM, TURN INDICATOR, ETC. *TR

Jul 28, 2008

TIRES,EQUIPMENT

1 complaint

LATE LAST SUMMER, UPON STARTING UP MY CAR, I NOTICED A HISSING NOISE COMING FROM THE CENTER PANEL ON THE DASHBOARD. DIDN'T REALLY THINK ANYTHING OF IT UNTIL I TRIED TO TURN ON THE AIR CONDITIONER AND THE CAR MADE THE SAME HISSING NOISE. NOISE LASTS ONLY 5-10 SECONDS UPON STARTUP OF THE CAR OR THE AC, BUT NOW THE AC ONLY BLOWS HOT AIR. TOOK CAR TO VOLVO DEALERSHIP HERE IN SOUTHERN CALIFORNIA WHERE I PURCHASED THE CAR AND THEY SAID THAT THEY WERE GOING TO HAVE TO RIP OPEN THE ENTIRE FRONT PANEL TO INVESTIGATE THE PROBLEM. AS I HAVE BEEN TOLD TWICE PREVIOUSLY BY THIS DEALERSHIP THAT I NEED SERVICE THAT I DID NOT REALLY NEED (THIS WAS NOW THE THIRD TIME), I CHOSE TO HOLD OFF ON LETTING THEM PERFORM SUCH A TASK. INSTEAD, I TOOK THE CAR TO ANOTHER MECHANIC AND DESCRIBED THE PROBLEM TO HIM. HE LET ME KNOW THAT WHEN THERE WAS NO FREON LEFT IN THE AC UNIT. THEY REPLACED IT AND WITHIN ONE DAY, IT HAD COMPLETELY LEAKED. THEY THEN PERFORMED AN INSPECTION ON THE AC AND EITHER THE COMPRESSOR OR THE HOSES HAS A MAJOR LEAK IN IT. I HAVE NO ACCIDENTS AND THE CAR HAS LESS THAN 60,000 MILES ON IT CURRENTLY. THE PROBLEM WAS FIRST DETECTED AT LESS THAN 45,000 MILES ON IT. ESTIMATE ON REPAIR WAS $1500+. AT 22,500 MILE CHECKUP, VOLVO REPLACED RADIATOR ON CAR. MECHANIC SAID THAT IT WAS POSSIBLE THAT VOLVO DEALERSHIP MAY HAVE DAMAGED THE AC UNIT AT THAT TIME SINCE THEY ARE IN CLOSE PROXIMITY. IN ADDITION, AS I NOTICED ON ANOTHER PERSON'S COMPLAINT FORM, I ALSO HAVE THE RUBBING OF THE FRONT TIRES WHEN TURNING. QUITE ANNOYING AND I DO MY BEST TO AVOID THE FRICTION AT ALL COSTS. DOESN'T OCCUR ON NORMAL TURNS, JUST WHEN MANEUVERING FOR PARKING SPACES OR GETTING OUT OF MY PARKING GARAGE. *TR

Jul 21, 2008

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

I HAVE A 2004 VOLVO S60 WITH 57,700 MILES. ALL WORK ON THE VEHICLE HAS BEEN DONE BY VOLVO. RECENTLY, WHEN THE AC IS ON, THE FAN SPEED HAS STOPPED RESPONDING TO ADJUSTMENTS. NOTHING HAPPENS WHEN I TRY TO ADJUST THE SPEED AND THEN, ON ITS OWN, THE SPEED WILL CHANGE A FEW MINUTES LATER. WHEN I TURN THE CAR OFF, THE FAN CONTINUES TO RUN FOR AT LEAST FIVE MINUTES. I'M AFRAID THAT ONE DAY IT WON'T TURN OFF AND WILL DRAIN THE BATTERY. THE VOLVO REP AND AN INDEPENDENT MECHANIC FEEL THAT THE REPAIR MAY BE COSTLY AND JUST TO DO THE DIAGNOSTIC IS EXPENSIVE, SO I HAVEN'T HAD IT DONE WHILE I DECIDE WHETHER TO JUST TRADE IN THE VEHICLE. *TR

Jun 30, 2008

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,VISIBILITY,EQUIPMENT

1 complaint

2004 VOLVO S60 2.5T. PURCHASED THE CAR USED IN SEPT 07. 6-5-08 PANEL DISPLAYED OPEN REAR DOOR WHILE DRIVING 65MPH ON HIGHWAY, MY DOOR WAS NOT OPENED. CAR JERKED AS IF THERE WAS POWER LOSS, AC WENT OFF, BRAKE FAILURE LIGHT ON PANEL, POWER WINDOWS AND LOCKS DID NOT WORK, TEMP 105 , THEN DRIVER PANEL WENT BLACK. CAR JERKED 3 TIMES IN MID TRAFFIC, I WAS SCARED TO DEATH FOR MY LIFE. ARRIVED AT MY EXIT, PULLED OVER TO A GAS STATION, ENGINE STILL RUNNING BUT SLUGGISH, RADIO WAS STILL ON, POWER DOOR LOCKS AND WINDOWS DID NOT WORK, AC OFF. ENGINE STILL RUNNING SO I MADE IT A COUPLE OF MILES UP THE STREET TO MY HOME. CUT THE CAR OFF AND BACK ON, ALL POWER RETURNED, NOW CHECK ENGINE AND AIR BAG TROUBLE ON PANEL. WENT TO VOLVO DEALER NEXT DAY 6-6-08 NEAR MY HOME, THEY CAN NOT SEE MY CAR TIL NEXT WEEK TUESDAY. WENT TO PEPBOYS, BATTERY AND ALTERNATOR ARE OK, CAN NOT ACCESS ENGINE BOX, MUST GO TO DEALER. CALLED VOLVO FOR TUESDAY 6-10-08 APPOINTMENT. CAR DUPLICATED SAME PROBLEM MONDAY 6-9-08 ON DRIVE HOME FROM WORK ON THE HIGHWAY TEMP 105 ETC. SEARCHED FOR COMPLAINTS AND RECALLS, MY RECALLS WERE REPORTED COMPLETED WHEN I PURCHASED THE CAR, FOUND ALL OF THIS VALUABLE INFO ONLINE, WILL SEE DEALER TOMORROW AND TAKE THESE RELATED COPIES OF COMPLAINTS WITH ME. *TR

Jun 09, 2008

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING

1 complaint

I WAS LEAVING UCLA PARKING GARAGE (I'M AN RN THERE) WHEN I PUT MY VOLVO 2004 S60 INTO GEAR AND IT TOOK OFF BACKWARDS LIKE A ROCKET, CAR WAS THROWN INTO A CONCRETE POST FAR AWAY FROM WHERE I BEGAN. I IMMEDIATELY PUT CAR IN PARK SINCE I THOUGHT I'D GET OUT AND SEE WHAT ON EARTH HAPPENED, BUT IT THEN LUNGED FORWARD BY ITSELF AND TOOK OFF WITHOUT STOPPING!!! THANK GOD IT WAS 6PM AND NOT AN HOUR EARLIER WHEN MANY STAFF WOULD HAVE BEEN IN GARAGE, I'D HAVE RUN THEM OVER! I ALSO TURNED OFF IGNITION WITH KEY, NOTHING HELPED!! IT KEPT GOING ALONG WITH A MIND OF ITS OWN AT APPROX 15 MPH MAKING A GROWLING WHIRRING SOUND. I WAS ABLE TO STEER CAR AND AVOID OTHER VEHICLES BUT EVENTUALLY HAD TO MAKE SERIOUS DECISION TO PURPOSELY CRASH INTO ANOTHER CONCRETE MASSIVE POST WHICH I DID AND THE "POSSESSED BEAST". FINALLY CAME TO A HALT WITH FLUID POURING OUT ALL OVER,. MY BRAKES DID NOT WORK DURING THIS EVENT, NOT AT ALL, THAT'S WHY I COULDN'T STOP THE CAR (ALONG WITH FOOT ON BRAKE, TRIED PUTTING CAR IN PARK GEAR AND TURNED OFF IGNITION KEY LAST AUGUST WHEN I HAD ONLY 22, 000 MILES ON CAR IT TOOK IT TO VOLVO DEALER TWICE, SINCE CAR WAS OFTEN STALLING AND STOPPING ON THE STREET WHILE I WAS DRIVING. I WAS TOLD THEY COULDN'T FIND IT STALLING WHEN THEY TEST DROVE IT BUT THEY MENTIONED THEY CLEANED THE THROTTLE AND SAID THAT COULD HELP (WHICH IT DID UNTIL 2, 500 MILES LATER WHEN THIS HAPPENED. I HAVE DEALER PAPERWORK INDICATING CAR STALLING AND THAT THEY CLEANED THROTTLE BOX ALSO, THEY SAID I SHOULD BE TAKING CAR ON THE FREEWAY MORE AT HIGH ENOUGH SPEED TO "BLOW OFF THE CARBON" I SPENT FRIDAY NIGHT IN ER WITH NECK/SHOULDER INJURIES, BUT THIS COULD HAVE BEEN A DISASTER. FORGOT TO MENTION THAT WHEN I TOOK CAR IN FOR SERVICE JULY 2007 DEALER REPLACED FUEL PRESSURE SENSOR AS PER RECALL. DON'T KNOW IF THIS IS SIGNIFICANT. ALSO WROTE ON FORM "DURING INSPECTION FOUND UPPER ENGINE MOUNT COLLAPSED, CAUSE........ ENGINE REPAIR". UPDATED 03-25-08 *BF THE DEALER STATED REAR BRAKE PADS HAD TO BE REPLACED. UPDATED 03/25/08 *TR

Feb 27, 2008

Crash: 1

Injuries: 1

STEERING,ENGINE AND ENGINE COOLING

1 complaint

LTR RE 2004 VOLVO S60 2.5 T STEERING DEFECT; SEEKING STEERING OF MY VEHICLE BE CORRECTED, RE-ENGINEERED TO THAT OF ANY CURRENT VOLVO SEDAN; PLEASE CONTACT HER BY MAIL OR PHONE WITHIN 14 DAYS OF THIS LETTER. *KB THE CONSUMER STATED THE TIRES WERE RUBBING AGAINST THE STEERING WELL WHEN MAKING TURNS. THE DEALER PERFORMED A TEMPORARY FIX BY INSTALLING A STEERING RACK LIMITER TO PREVENT THE TIRE RUBBING. THE CONSUMER CALLED THE DEALER BACK ONCE THE PROBLEM RETURNED AND WAS THEN INFORMED THAT THERE WAS A STEERING ENGINEERING DEFECT WITH THE VEHICLE AND THE MANUFACTURER WAS OFFERING A STEERING REPLACEMENT KIT THAT COULD BE INSTALLED AT NO COST. ONCE THE REPLACEMENT KIT WAS INSTALLED, THE CONSUMER SOON DISCOVERED THE STEERING RADIUS WAS INCREDIBLY DIMINISHED AND THAT SHE COULD NO LONGER MAKE U-TURNS AT AN INTERSECTION. THE DEALER TOLD THE CONSUMER THE STEERING KIT WAS THE ONLY SOLUTION THAT VOLVO OFFERED. THE CONSUMER STATED THE COOLANT LIGHT WAS ON. THE DEALER STATED THE RADIATOR WAS LEAKING. *JB

Sep 27, 2007

SEAT BELTS,CHILD SEAT

1 complaint

IN REGARD TO A 2004 S60 VOLVO 2.5 AWD-T WE NOTICED A SEAT BELT PROBLEM WITH THE BACK SEAT CENTER SEAT BELT. WE SECURED OUR INFANT CAR SEAT BASE WITH THE CENTER SEAT BELT, AND HAVE BEEN DOING SO SINCE SHE WAS BORN. THE LOCAL POLICE STATION HAD A SERVICE THAT DEMONSTRATED PROPER INSTALLATION AND INSURED WE WERE ABLE TO DO IT OURSELVES. THE OFFICER THEN INSTALLED IT FOR US WITH NO PROBLEM. TODAY WE NOTICED THE BASE WAS REALLY LOOSE! I TRIED TO REINSTALL THE SEAT BY ATTACHING IT TO THE SEAT BELT IN THE USUAL FASHION. HOWEVER, I DISCOVERED THAT THE SEAT BELT DID NOT HOLD THE BASE TIGHTLY AS IT DID BEFORE!!! IN SUMMARY- NORMAL USE LED UP TO THE FAILURE OF THE THREE POINT SAFETY BELT IN THE REAR CENTER SEAT POSITION TO PROPERLY HOLD THE BASE OF AN INFANT CAR SEAT SAFELY. WE ARE GOING TO CALL THE DEALER FIRST THING IN THE MORNING AND HAVE IT FIXED. *JB

Jan 07, 2007

STRUCTURE

1 complaint

I WAS DRIVING MY 2004 VOLVO S60 ON THE NJ TURNPIKE. WINDS REPORTED THAT DAY TO BE UP TO 50 MPH AND I AM DRIVING AT AROUND 50 TO 60 MPH WHEN I HEARD A LOUD SOUND FROM THE REAR OF MY CAR. I STARTED TO SLOW DOWN TO ENTER ONTO THE BREAKDOWN LANE ON THE TURNPIKE DRAGGING THE BUMPER AS I PULLED OVER. WHEN I GOT OUT TO INSPECT I FOUND THAT MY BUMPER COVER HAVE BLEW OFF OF THE CAR AND WAS HANGING ON DUE TO A WIRE THAT WAS CONNECTED TO IT ON THE RIGHT SIDE. I CALLED MY VOLVO DEALER AND WAS OFFERED AN APPT TO BRING IT IN. THE SERVICE MANAGER ALONG WITH HIS REGIONAL REP IS DISPUTING THAT THIS COULD HAVE HAPPENED. THEY ARE SAYING THAT THEY HAVE NEVER HEARD OF THIS BEFORE AND THAT IT COULD NOT HAVE HAPPENED BECAUSE IT HAS NEVER HAPPENED AND WILL NOT TAKE RESPONSIBILITY FOR THE REPLACEMENT UNLESS IT IS PAID FOR BY ME. NEITHER THE DEALER OR THE REP IS CONCERNED ABOUT THE SAFETY OF THIS INCIDENT AND WHY THIS ACTUALLY HAPPENED. IT IS BY THE GRACE OF GOD THAT THIS BUMPER COVER DID NOT COMPLETELY DISLODGE CAUSING FATALITIES TO OCCUR HAD THE WIND BLEW IT IN THE PATH OF OTHER CARS ON THE ROADS. NOT ONLY AM I NOT GETTING GOOD SERVICE VOLVO IS NOT CONCERNED ABOUT SAFETY WHICH IS THE CORE OF THEIR COMMITMENT TO THE CONSUMERS. MY CHARACTER AND MY INTEGRITY AND CREDIBILITY IS BEING CHALLENGED BY THE SERVICE MANAGER AND HIS REGIONAL REP RATHER THE REASON FOR THE BUMPER COMING OFF IN THIS WAY. MY CONFIDENT IN THE SAFETY OF THE CAR AND VOLVO CUSTOMER SERVICE HAS BEEN DESTROYED. VOVLO IS SAYING THAT THIS IS THE FIRST TIME THEY HAVE HEARD OF A BUMPER BLOWING OFF. THERE IS ALWAYS A FIRST AND BEING THE FIRST DOES NOT INDICATED THAT IT'S IMPOSSIBLE TO HAVE HAPPENED. *JB

Nov 07, 2006

STEERING,SUSPENSION

1 complaint

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS AND TURNING LEFT OR RIGHT THE TIRES TOUCHES THE FRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION ON FOUR OCCASIONS. THE FIRST TIME THE DEALER PLACED STEERING BLOCKS ON THE VEHICLE. THE SECOND, THIRD AND FOURTH TIMES THE DEALER ADJUSTED THE CONTROL ARMS. HOWEVER NONE OF THESE EFFORTS REMEDIED THE PROBLEM. THE PROBLEM CONTINUES AND THE VEHICLE HAS NOT BEEN RETURNED TO THE DEALER FOR FURTHER DIAGNOSTIC TESTING. UPDATED 2/24/2006 - POWER STEERING RESERVOIR LEAKED FLUID FROM THE BOTTOM HOSE NEAR THE CLAMP. THE CONSUMER HEARD A METAL ON METAL SOUND WHILE TURNING THE WHEEL. THE DEALER MODIFIED THE STEERING STOPS. AL FOUR TAILLIGHT AND BOTH LOW BEAM BULB WENT OUT. *NM

Jan 31, 2006

ELECTRONIC STABILITY CONTROL

1 complaint

I RECENTLY PURCHASED A VOLVO S60R AUTOMOBILE FOR EAGLE VOLVO OF RIVERHEAD NY. I RECEIVED THE S60 R IN EARLY DECEMBER AND AS OF TODAY (2-04-04) I HAVE APPROX 1750 MILES ON IT. .*AK SO WHY ALL THE DETAIL, WELL SINCE I HAVE OWNED THIS CAR IT HAS BEEN IN THE SHOP THREE (3) TIMES FOR A PROBLEM WITH THE 4C SUSPENSION SYSTEMS. THE FIRST TIME IT SPENT APPROX A WEEK AT THE SHOP AND WAS TO BE RESOLVED WITH A SENSOR REPLACEMENT. THE SECOND TIME WAS BECAUSE A SOFTWARE UPDATE WAS REQUIRED FOR THE SYSTEM, AND THE THIRD TIME THEY HAVE SPENT TWO DAYS ON IT AND ARE STILL NOT SURE WHAT THE ISSUE IS. I HAVE BEEN VERY PATIENT OVER THIS PROBLEM. I UNDERSTAND THESE THINGS HAPPEN, AND IF IT WHERE NOT FOR MY SALES PERSON WAYNE LAKE COMMITMENT TO ME I WOULD BE PROBABLY LOOKING FOR ANOTHER CAR. THAT BEING SAID I AM VERY CONCERNED ABOUT THE LEVEL OF SERVICE I AM GETTING FROM VOLVO ITSELF. EVEN AFTER I CALLED VOLVO CUSTOMER SERVICE TO ASK FOR SUPPORT IN THIS MATTER , I RECEIVED INFORMATION THAT A FIELD TECHNICIAN WOULD NOT BE ABLE TO COME OUT AND HELP IN THE RESOLUTION OF MY PROBLEM FOR TWO WEEK ( NEXT WEEK THEY ARE ALL GOING TO TRAINING) .. TO HEAR THIS IS AN OUTRAGE. I HAVE BEEN WITHOUT MY CAR FOR NEARLY 10 DAYS IN TOTAL; I HAVE LESS THE 2500 MILES, AND HAVE BROUGHT IT BACK TO THE SHOP THREE TIMES FOR THE SAME ISSUE AND EVEN AFTER ALL OF THIS VOLVO DOES NOT FEEL THAT THIS ISSUES WARRANTS A CHANGE IN SOMEONES SCHEDULE OR THE NEED TO MAKE SOME ARRANGEMENTS TO GET MY CAR REPAIRED IN A TIMELY MANNER. WORST YET , YOU WOULD THINK AFTER CALLING VOLVO CUSTOMER SERVICE AND OPENING UP A SO CALLED FOLDER THAT I WOULD RECEIVE A CALL EXPLAINING THE SITUATION OR WHAT WAS BEING DONE TO CORRECT THIS PROBLEM. OR AT LEAST OFFERING MY SOME COMPENSATION FOR MY TROUBLES, LIKE A LONG TERM LOANER CAR TO REPLACE THE CAR I DO NOT HAVE DUE TO THIS ISSUE, OR MAYBE EVEN AN OFFER OF EXTENDING THE WARRANTY TO ADDRESS MY CONCERNS OVER THE RELIABILITY OF THE 4 C SUSPENSION.

Feb 04, 2004

2004 VOLVO S60 Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2004 VOLVO S60 have?

What are the most common problems with 2004 VOLVO S60?

Where does this 2004 VOLVO S60 problem data come from?

Other Years - VOLVO S60

Other VOLVO Models

Similar Brands