2012 VOLVO S60 Problems

VIN Decoder

Premium Report

119

Complaints Reported

Complaints by Component

ENGINE

43 complaints

I experienced an engine issue that I believe is related to excessive oil consumption and the lack of an oil pressure light warning. The car was driven out of town when a noise was heard coming from the engine. A visual inspection of the engine revealed smoke coming from the engine department when the oil cap was removed. The dipstick was checked and showed no visible oil on the stick. Later in that evening, 3 additional quarts of oil were added to the engine but the addition of oil did not remedy the noise from the engine. The final result was that the car was towed to a Volvo dealership in Florida for repair. I checked the status of the recalls (oil comsumption and no oil pressure light) and the status is closed. From what I can tell, this issue appears to be directly related to previous recalls for the vehicle.

Apr 22, 2026

Engine has failed and is unrepairable. The car has been maintained well according to the manufacturer’s guidelines with regular oil changes. It has only 94,875 miles. The mechanic said that there is probably a piston gasket failure leading to oil leak into the engine. This appears to have been reported with this year/model vehicles. I would like Volvo to take ownership of poor manufacturing and fix the problem to my satisfaction.

Feb 22, 2025

Discovered that my engine is burning oil. There was no warning from my vehicle or from Volvo (during regular maintenance) that this was happening. It was just sudden that the check engine light went on and I checked the oil and found that it was basically empty. Volvo confirmed that the engine is burning oil and that this model and make was discovered to have this engine issue. Volvo did not offer a solution other than to buy a new vehicle to replace this one. In my research online, this problem is common for this model and make 2012 S60 T5, may other have reported the same issue and it seems that there is a recall for this problem but my vehicle (VIN) does not report this to be a problem for my car. I’m not sure what to do.

Jul 07, 2024

The contact owns a 2012 Volvo S60. The contact stated that upon starting the vehicle, an unknown belt fractured, and the vehicle failed to start. There were no warning lights illuminated. The contact called the local dealer, who informed the contact about diagnostic testing, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

May 21, 2024

Surpintine belt shredded due to faulty belt tensioner. Shreds of belt wedged between crankshaft timing sprocket on engine causing engine to jump timing while driving down highway and vehicle lost all power and very hard to steer due to all valves in motor bent because of poor design. Definitely a safety concern. Volvo is aware but does nothing. 11,000 dollars to replace engine.

Dec 19, 2023

+ 38 more complaints for this component

STEERING

6 complaints

I have experienced the steering in my car to become looser over time. I have found the culprit to be a plastic tension cap on the steering rack itself. The cap appears to have stripped and backed out completely and is now resting against the subframe. There is no warning of this happening and very hard to pinpoint the cause. The effect is that there is about 10 degrees of play in the steering wheel. It appears that it only affects the left wheel as that one is loose and the right wheel is tight. I will be taking it to the dealer to see if there is a replacement or an upgraded version of this cap but feel this should be addressed further as this could happen without warning.

Jun 12, 2023

The steering wheel trim peeled and created a razor sharp surface at the bottom which sliced through my finger and caused pain and bleeding. It is difficult to avoid touching the sharp part of the steering wheel especially at highway speeds. This startled me while driving and distracted me while I attempted to stop the bleeding. Volvo has agreed to replace the trim but will charge for labor if I choose to go into a dealer.

Sep 07, 2022

Injuries: 1

A METAL SILVER PIECE ON STEERING HAS A SHARP EDGE THAT RESULTED IN A CUT ON FINGER WHILE DRIVING. THE VEHICLE WAS IN MOTION AND TURNING.

Dec 30, 2017

Injuries: 1

AT THE BOTTOM OF THE STEERING WHEEL BEZEL, A SHARP EDGE IS EXPOSED. THIS EDGE IS RAZOR SHARP AND HAS CAUSED LACERATIONS. I SEE NHTSA ID NUMBER: 10503380 AND 10534272 APPEAR TO DESCRIBE THE SAME PROBLEM. (INCIDENT DATE IS APPROXIMATE). *TR

Apr 24, 2015

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT THE ALUMINUM ON THE STEERING WHEEL BECAME DETACHED. THE CONTACT SUSTAINED LACERATIONS TO THE HANDS AS A RESULT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 21,700.

Aug 08, 2013

Injuries: 1

+ 1 more complaint for this component

UNKNOWN OR OTHER

6 complaints

MY CAR HAS WATER IN THE LEFT BACK DOOR, AND I AM CERTAIN IT IS FROM THE RECALL OF THE LOCKS. I USE TO PARK IN MY GARAGE AND THE CAR IS NO LONGER GARAGE KEPT AND IT HAS RAINED A LOT. I CAN HEAR THE WATER SWISHING AROUND WHEN I STOP THE CAR. I WANT TO TAKE THE CAR BACK TO THE DEALERSHIP THAT DID THE RECALL LOCKS. WATER IS SATURATED IN THE BACK SEATING THE DRIVER'S SIDE.

Apr 03, 2021

DOOR LATCH AND LOCK FAILURE TO BOTH FRONT DOORS. PASSENGER DOOR LATCH/LOCK PASSENGER DOOR FAILED TO LOCK OR KEEP DOOR CLOSED WHILE IN MOTION. ONE WEEK LATER THE DRIVER'S DOOR LATCH/LOCK FAILED IN SAME WAY, WHICH ALLOWED DOORS TO FLY OPEN DURING A TURN WHILE VEHICLE IN GEAR AND IN MOTION. ELECTRIC DOOR LOCKS WOULD NOT ENGAGE. OPENING DOORS COULD BE STRUCK BY PASSING VEHICLES ENDANGERING LIVES OF OCCUPANTS. OCCUPANTS COULD BE THROWN OUT OF DOORS WHEN TURNING. UNABLE TO SECURE THE VEHICLE WHEN UNOCCUPIED. BOTH DOOR LATCHES ARE FORD PRODUCTS INSTALLED IN A VOLVO VEHICLE. SUBSTANDARD SAFETY DEVICE INSTALLED ON VEHICLE'S DOORS. NEARLY ENDLESS LIST OF SAFETY HAZARDS ASSOCIATED WITH THIS DEFECT. VOLVO IS AWARE OF THE PROBLEM AND FAILED TO DISCLOSE THE INFORMATION TO THE PUBLIC OR OWNERS OF THIS MAKE AND MODEL VOLVO, CAUSING THE OWNER OR OPERATOR TO BE UNAWARE OF THE POSSIBLE FATAL SAFETY HAZARD. VOLVO WAS CONTACTED BY THE CERTIFIED MECHANIC UPON REPLACING THE PART AND WAS ADVISED BY VOLVO THEY WERE AWARE OF THE DOOR LATCH/LOCK DEFECT.

Sep 16, 2019

VEHICLE HAD A NO START, NO CRANK CONDITION WHILE PARKED. WAS TOWED TO DEALERSHIP. DEALER DETERMINED NO START, NO CRANK CONDITION WAS CAUSED BY OUTDATED SOFTWARE. I DO NOT THINK VOLVO SHOULD DESIGN A CAR TO NOT START IF SOFTWARE IS OUTDATED. HAD I NEEDED TO USE THE CAR TO DRIVE TO HOSPITAL OR SOME OTHER EMERGENCY THIS WOULD HAVE BEEN AN ISSUE.

May 11, 2018

<40K MILES 2ND OWNER BOUGHT CERTIFIED FROM DEALER 2015..2012 VOLVO S60..ENGINE LIGHT KEEPS COMING ON. TOOK TO DEALER IN DAVIE FLORIDA SAYS ENGINE COOLING SYSTEM PROBLEM..FAN OR AS SUCH..IM SEEING X6 RECALLS ON SIMILAR YEAR MAKE AND MODEL.MY VEHICLE VIN NOT SHOWING ON RECALL ROSTER..DEALER WANTS 1200.00 TO REPAIR..WHY WOULD I HAVE TO PAY IF ON RECALL ROSTER .BUT MY VIN NUMBER NOT REGISTERED FOR SAME ISSUE?

Feb 14, 2017

REAR DRIVER SIDE DOOR FLEW OPEN WHILE DAUGHTER WAS IN THE BACK SEAT. SHE FELL OUT THE CAR. PERSON WAS DRIVING THE VEHICLE AND THE DOOR JUST FLEW OPEN. PLEASE GET TO THE BOTTOM OF THIS IMMEDIATELY.

Dec 03, 2016

Injuries: 1

+ 1 more complaint for this component

ELECTRICAL SYSTEM

6 complaints

THE SENSUS/NAVIGATION SYSTEM IS PLAGUED WITH BUGS. FREQUENTLY MY BLUETOOTH FAILS TO CONNECT, AUDIO RANDOMLY STOPS WORKING FOR ALL SATNAV/RADIO FUNCTIONS, SOMETIMES THE SCREEN FAILS TO LOAD UP AT ALL. ALL SEEMS TO HAPPEN COMPLETELY RANDOMLY. SOME DAYS RADIO FUNCTIONS GREAT BUT SOME DAYS I CAN NOT LISTEN TO ANY AUDIO AT ALL. SOME DAYS MY PHONE CONNECTS TO BLUETOOTH WITHOUT ME EVEN TRYING TO CONNECT, AND SOME DAYS THE SATNAV RADIO DOES NOT CONNECT AT ALL. I HAVE EVEN GONE AS FAR AS TO RESET ALL NETWORK SETTINGS ON MY IPHONE AND REMOVE THE IPHONE FROM THE RECENT DEVICE LIST; STILL THE PHONE WILL NOT CONNECT TO THE CAR. THE ONLY THING I HAVE EVER SEEN 'FIX' THIS PROBLEM IS TO STOP THE CAR, GET OUT OF THE VEHICLE, WALK MORE THAN 20FT AWAY FROM THE CAR, LOCK THE CAR, AND WAIT A FEW MINUTES; UNLOCK, ENTER AND START VEHICLE; AND SUDDENLY IT WORKS AGAIN.

Nov 22, 2019

THE KEYLESS ENTRY FAILED ONE BY ONE. THE RIGHT FRONT FIRST, THEN THE LEFT FRONT DOOR. I WENT TO DEALER, ENDING UP PAYING MORE THAN 500 DOLLARS FOR FIXING IT. THEY SAID THAT IS CAUSED BY THE POOR DESIGN OF THE DOOR HANDLE WHICH ALLOWED THE WATER TO GET INSIDE AND TO DAMAGE THE SENSOR AND WIRES.

Dec 08, 2018

WHEN THE CAR IS OUTDOORS, IN TEMPERATURES APPROACHING 100 F, THE REAR (BACKUP) CAMERA FLICKERS OR FAILS ALTOGETHER.

Jun 29, 2016

HAVING ELECTRICAL PROBLEMS AND SOFTWARE PROBLEMS. IN THE MIDDLE OF DRIVING ALL ELECTRONICS WILL GO OFF. ALSO, CAR WONT ALWAYS SHUT DOWN OR START PROPERLY. LOOKED OVER MANY FORUMS AND FOUND THE EXACT COMPLAINTS. THERE HAVE BEEN OTHER RECALLS FOR ELECTRICAL AND SOFTWARE FOR THE S60, BUT APPARENTLY THEY DONT APPLY TO MY VIN, EVEN THOUGH I AM HAVING THE EXACT SAME ISSUE.

Mar 19, 2016

CAR STALLED (2 TIMES ) WHILE DRIVING IT. COULD NOT STEER OR OPERATE ANY PART OF THE CAR. ONCE I ALMOST GOT REAR ENDED MY A TRUCK ON A HIGHWAY. MY VOLVO DEALER'S SERVICE DEPARTMENT COULD NOT FIGURE OUT THE PROBLEM. (I RECENTLY READ ABOUT THE GM IGNITION PROBLEMS AND THAT SOUNDS EXACTLY LIKE WHAT WAS HAPPENING WITH THIS CAR). *TR

Feb 27, 2014

+ 1 more complaint for this component

SEAT BELTS

5 complaints

Our seat belts have been problematic because the passenger side is sticky and has to be moved around before it will disengage. When I took it to a dealer they said it was fine and just needed a little lubrication. Lubrication did not help the problem

Feb 11, 2023

The drivers seat belt to lock in place or unlock gets stuck ! Makes it very difficult to ge try out of my vehicle daily. This is a major concern if i am ever in an emergency and cannot get out of my seat

Jul 29, 2022

I have a 2012 S60R. I just received the recall notice for the front seat belts last week. In September of 2021, the warning light on the dash board intermittently comes on with a warning sound stating that my rear seat belt is not in use. This happens while starting the car and driving. There are no passengers riding in the rear seats of my car when this happens. I have tried to fasten the rear seat belts, but they do not fasten. I can not have passengers in the car due to the malfunction of the rear seat belts which is a safety issue. My vehicle is available for inspection upon request.

Feb 21, 2022

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V378000 (SEAT BELTS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. NAPLETON'S MID RIVERS CHRYSLER DODGE JEEP RAM (44951 VETERANS MEMORIAL PKWY, SAINT PETERS, MO 63376 (636) 242-1471) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Apr 06, 2021

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V378000 (SEAT BELTS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED TOM WOOD VOLVO (4620 E 96TH ST, INDIANAPOLIS, IN 46240; (317) 848-7447) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Nov 24, 2020

ELECTRICAL SYSTEM,ENGINE

4 complaints

On June 2, 2023 I went to start my car and the engine would not turn over. The dashboard displayed a number of warning lights and messages (DSTC Service Required, SRS Airbag Service Urgent, Transmission Service Required, Coolant System Service Required). When the tow truck driver arrived later that day, they tried to jumpstart my car but reported the battery was completely dead. I had the car taken to a local shop that specialized in Volvo cars. A few days later the shop called to tell me that not only was the battery dead, but my car key was no longer responding, and that the Engine Control Module "exploded." None of the mechanics at the shop had seen such a thing before. The shop also told me that they could not figure out what had been draining the battery. I was advised to reach out to the dealership. I did and happened to meet with the general manager and a lead technician who happened to be on site. I was told that while rare, the Engine Control Module can "explode." I was willing to drop the matter until I started seeing "Low Battery" warnings in early Sept. of 2023. I was finally able to get the car into the dealership on 1/2/24. After talking with the mechanic, he suggested that the satellite radio in my car was continuously draining my battery and to resolve the problem all they would need to do is download new software. A few hours later the mechanic confirmed that my car needed an RDAR upgrade to stop the battery drainage. I do not understand how the dealership could sell me the car without checking to make sure the software had been upgraded in the first place. RDAR failure is not something that pops up as a recall or major safety concern. If the car had lost power while in motion, there could have been serious consequences.

Jan 10, 2024

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT WHILE MAKING A LEFT OR RIGHT TURN, THE LOW OIL LEVEL WARNING LIGHT FLASHED ON THEIR INSTRUMENT PANEL AND DISAPPEARED. THE CONTACT ADDED A QUART OF OIL AND APPROXIMATELY THREE WEEKS LATER WHILE HIS WIFE WAS DRIVING, SHE BECAME AWARE OF A KNOCKING SOUND COMING FROM THE VEHICLE. THE CONTACT CHECKED THE VEHICLE AND CONFIRMED THE KNOCKING SOUND. THE CONTACT CHECKED THE DIPSTICK AND NOTICED THAT IT WAS DRY. THE CONTACT HAD NOT CONTACTED A DEALER OR A CERTIFIED MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT THE LOCAL DEALER FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

Nov 02, 2020

CAR DID NOT INDICATE LOW OIL PRESSURE AT ANY TIME. ENGINE SEIZED AND STALLED ON FREEWAY CREATING DRIVING HAZZARD. CAR WAS IN MOTION AT APPROX. 65 MPL, STARTED SHAKING AS IF A TIRE HAD BLOWN. CAR STARTED TO SMELL LIKE BUNED OIL, STALLED AND WOULD NOT RESTART. THE ONLY ALERT THAT CAME ON WAS THE LOW BATTERY ICON AFTER THE MOTOR SEIZED.

Apr 24, 2018

TL* THE CONTACT OWNS A 2012 VOLVO S60. WHILE DRIVING 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STARTER NEEDED TO BE REPLACED. THE STARTER WAS REPLACED, BUT THE FAILURE RECURRED WHILE STILL AT THE DEALER. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V592000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 49,740.

Nov 07, 2016

STRUCTURE

4 complaints

SIGNIFICANT ISSUES WITH EXTERIOR BODY PAINT, COMPLAINED TO VOLVO AND SHOWED IT TO DEALER AS PER THEIR ADVISE, DEALER AGREED THAT THIS SHOULD NOT BE THERE WITH LIMITED MILES AND MAINLY LOCAL DRIVING WITH THIS CAR. SCRATCHES ALL OVER THE BODY AND THIS WAS THERE WITH IN 4 YEARS OF CAR AND I HAVE TRIED DETAILING THE CAR MULTIPLE TIMES WITH NO HELP TO REMOVE SCRATCHES. WHILE AT DEALERSHIP, RAN IN TO DEALER EMPLOYEE AND ANOTHER CUSTOMER WITH SIMILAR ISSUE FOR 2012 VOLVO S60. VOLVO REFUSES TO ADDRESS THIS ISSUE SAYING IT'S OUTSIDE WARRANTY. DEALERSHIP TOOK PICTURES AND AGREED THAT THIS IS DUE TO SOME UNDERLYING PAINT ISSUES, THEY WOULDN'T PUT IT IN WRITING AND LET VOLVO MANAGE THE COMPLAINT. NEED SOME HELP TO ADDRESS THIS ISSUE AS IT IS MORE WIDESPREAD THAN VOLVO ADMITS. I JUST NEED PAINT REPLACEMENT AND NOT EXPECTING ANY FINANCIAL COMPENSATION. ATTACHING PICTURES AND CAN PROVIDE MORE IF NECESSARY (REFLECTION DUE TO LIGHT, PLEASE ZOOM IN AND YOU WILL SEE THE 2 INCHES LONG STREAKS AND WHITE SPECKLES ALL OVER). COMPLAINT NUMBER WITH VOLVO USA -ID#200417-000663

Oct 08, 2020

INTERIOR ADHESIVE CHROME TRIM DELAMINATING AND VERY SHARP CAUSING A CUT HAND ON THE STEERING WHEEL AND CENTER CONSOLE

Apr 17, 2020

Injuries: 1

DRIVERS SIDE REAR DOOR DISENGAGED WHILE TURNING ONTO THE HIGHWAY ACCESS RODE WITH PASSENGERS IN THE BACK, THE REAR PASSENGER NEARLY FELL OUT OF THE CAR. THE DOOR NO LONGER LATCHES WHICH CREATES A HUGE SAFETY CONCERN, MAKING ME UNABLE TO SAFELY OPERATE THE VEHICLE.

Jun 06, 2019

THE CAR WAS PURCHASED NEW FROM AN AUTHORIZED VOLVO DEALER. AFTER LITTLE OVER 12K MILES, THERE IS SEVER PAINT DAMAGE ON THE ENTIRE SURFACE OF THE CAR. THE PAINT APPEARS TO BE BUBBLING FROM UNDERNEATH. REQUIRES $8609.66 TO REPAIR. VOLVO ONLY WARRANTY THE PAINT FOR 12K MILES BUT ADVERTISES THE CAR HAVING 48 MONTH 50K MILES WARRANTY. VOLVO STATES THAT THE CAR MUST BE DRIED EVERY TIME IT GETS WET (INCLUDING WIPING THE CAR DRY AFTER IT RAINS). THEY HAVE GIVEN ME THE FOLLOWING EXCUSES FOR WHY THE PAINT IS DAMAGED: 1) WATER (E.G. RAIN) 2) SPRINKLER WATER 3) ACID RAIN 4) PESTICIDES I HAVE OTHER CARS MUCH OLDER THAN THIS CAR WHICH DO NOT HAVE SIMILAR PAINT DAMAGE. *TR

Jan 19, 2013

AIR BAGS

4 complaints

LIGHT ON THE INSTRUMENT PANEL INDICATES I NEED TO SERVICE MY AIRBAG IMMEDIATELY. THE AIRBAG HAS NEVER BEEN DEPLOYED. VOLVO SERVICE SAYS I NEED TO PAY TO REPLACE IT WHEN ITS NEVER BEEN USED.

Aug 07, 2019

CPSC: ON SEPTEMBER 8, 2018 AROUND 4:30PM ON A SATURDAY, I WAS RUNNING ERRANDS AND SUDDENLY MY CURTAIN AIRBAGS ON MY 2012 VOLVO DEPLOYED. THERE WAS A HIGH PITCH, LOUD SCREECHING NOISE, A LOUD POP AND ALL THIS DEBRIS SPRAYED ALL OVER ME AND THE INSIDE OF MY CAR AND THESE WHITE PLASTIC AIRBAGS (CURTAINS) BUSTED THROUGH THE ROOF OF MY CAR. *DT *JS

Nov 06, 2018

Injuries: 1

TL* THE CONTACT OWNED A 2012 VOLVO S60. WHILE DRIVING APPROXIMATELY 40 MPH, ANOTHER VEHICLE CUT IN FRONT OF THE CONTACT. AS A RESULT, THE CONTACT CRASHED INTO A POLE ON THE SIDE OF THE ROAD. THE AIR BAGS DID NOT DEPLOY. THE LOCAL POLICE AND THE FIRE DEPARTMENT WERE AT THE SCENE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. PRIOR TO THE CRASH, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V075000 (ELECTRICAL SYSTEM) AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE AIR BAG SENSOR MAY NOT HAVE BEEN IMPACTED, HENCE NO DEPLOYMENT. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 29,000.

Nov 06, 2015

Crash: 1

Injuries: 1

ON JUNE 1ST ANOTHER CAR FAILED TO YIELD THE RIGHT OF WAY AND PULLED INTO THE PATH OF MY CAR WHILE I WAS GOING APPROX. 45MPH. I HIT THE BRAKES HARD AND TURNED TO THE LEFT TO TRY AND AVOID THE CAR AND COLLIDED WITH THE OTHER CAR. I ESTIMATE THE SPEED OF AT LEAST 35MPH AT IMPACT. THE RIGHT FRONT OF THE CAR TOOK MOST OF THE IMPACT. THE DRIVER'S SIDE AIRBAG DEPLOYED AND BURNED MY ARM. HOWEVER, DESPITE THE PASSENGER SIDE OF THE CAR TAKING THE BRUNT OF THE IMPACT, THE PASSENGER AIRBAG DID NOT DEPLOY. THE PASSENGER (MY FIANC) WAS DIAGNOSED WITH A CONCUSSION DUE TO THIS ACCIDENT. I BELIEVE THE CONCUSSION MAY HAVE BEEN AVOIDED HAD HER AIRBAG DEPLOYED. VOLVO INSPECTED THE VEHICLE AND CLAIMS FOR SOME REASON THE AIRBAG SHOULD NOT HAVE DEPLOYED IN THIS ACCIDENT. I SUSPECT THEY ARE COVERING UP A PRODUCT FAILURE. I HAVE PICTURES OF THE ACCIDENT AVAILABLE FOR YOUR REVIEW. *TR

Jun 20, 2014

Crash: 1

Injuries: 2

UNKNOWN OR OTHER,ENGINE

3 complaints

I bought used s60 and sent car to auto shop due to engine seize . I was told The engine needed to be replaced. I has replacement done. Car ran good and I was pleased. Months later, the vehicle made a clicking noise when I arrived home. When I checked the oil the following morning, there was no oil in car. I was never given a low oil level indication or warning. Now car is making crazy tapping sounds. i

Oct 06, 2023

I was driving on my way back home. When my car started to knock. As I was slowing down to pull over. My oil pressure light came on. Granted, the reason was unknown. I had just recently checked the oil level. I got out to check the dipstick to find smoke coming out where the dipstick was. Curious as I was, I had no oil which left me puzzled. After some research, I found that my car had a recall on it for oil consumption. I called and asked a rep if they could verify if my vehicle was serviced for the issue. But without a doubt, he said it was. I just want to know if the problem was fixed. I currently can't crank my vehicle. I even dug into it myself and found that I had a bad starter nd battery. After replacing the two. I still can't get my vehicle to turn over. Any help would be much appreciated. Thank you, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Jul 13, 2021

CAR NEVER WARNED OF LOW PRESSURE OR OIL LOW. CAR STARTED TO SHIMMY AND BLOW WHITE SMOKE. IT CAN NO LONGER BE DRIVEN. PISTON HEADS BLEW DUE TO LACK OF LUBRICATION.WILL COST APPROX 7 TO 8 THOUSAND TO FIX.

Jan 11, 2021

VISIBILITY

2 complaints

While driving or parked water is dripping down my window shield. This obstructs my view and distracts me from driving. It further distracts my driving if I have to wipe away the water which usually leads to smearing which causes further obstruction to my field of vision.

Feb 28, 2024

original windshield never replaced unglueing to the point where you can push the glass and have it move and minor seepage of water

Feb 21, 2024

EXTERIOR LIGHTING

2 complaints

These headlight assemblies commonly develop significant water ingress problems as they age. Owners report issues in wet climates even when these cars were relatively new, resulting in bulb ignition problems as water finds it way into the ballasts, resulting in high-voltage shorting. The water in the headlight housings also "fogs" up the forward lens, resulting in a poor distribution of light out the front, both poor for the driver and dazzling for oncoming traffic. The headlights can work fine for weeks or months, and then a wet week comes along and 1 or both headlights fail to operate or work but poorly and blind oncoming traffic. If caught after dark in the rain the headlights often fail to function. If this could be solved with new headlight assemblies for a reasonable price, I would not consider this a major safety issue, unfortunately, they are difficult to source, astronomically priced (~$1100 per assembly), and replacing them doesn't seem to fix this problem for many owners of these cars. The way these assemblies are vented from the factory seems to be problematic for water ingress and the position of the ballasts ensures that any significant water ingress causes the ballast to short internally. I believe that the atmospheric vent on these must be positioned in such a way that they suck water in as they cool if its raining. The all-halogen assemblies for these cars work better, likely because there's no ballast for the water to leak into and more heat from the bulb to quickly evaporate the water out of the same assembly design. The poorly designed housing is "saved" by the simpler electronics and thermal output of the bulbs. Unfortunately, different factory programming is required to run the all-halogen assemblies. A recall should be issued to replace all of these gimmicky (and distracting) "steerable" xenon headlights with the halogen versions, with the reprogramming effort included in the recall.

Sep 11, 2023

When I purchased the 2012 volvo S60 back in June we started to drive and it said low beam out and later found out that it was the drivers side low beam took it back and they tried a new headlight but didn't work but we found the problem it was the ballast to the hid bulb was bad changed it bam fixed 2 days later the light came back on and said low beam out but this time it was the passenger side took it back and they checked and said that it was the samething the low beam hid ballast so got that they changed it and bam fixed well left there and less than a week later the light comes back in saying low beam out and only its the same side again this time the passenger side, so my question and concern is I can't ve the only one having this issue with my headlights causing me to drive with high beams on which isn't safe so please get back to me with an answer I believe there is something faulty with these S60 r-design hid low beam headlights please help

Dec 08, 2021

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

2 complaints

My wife and I were driving to BWI airport for a 10:30am flight from Virginia Beach in the Express Lane on I-95N going 75mph when all of a sudden at 8:30am the engine seized and I got a message telling me I would experience "Reduced Engine Performance" as my car puttered to a stop with white smoke pouring out of the exhaust. Prior to this message I had no warnings or messages on my dashboard. I got out of my car to check my oil and it was completely evaporated, so I called AAA. While we are 1 hour into waiting (it is now 9:30am) on the narrow shoulder of two Express Lanes for a tow truck to take our car to a shop at 11:40am and for a Lyft driver to figure out how to get to us, two VDOT employees told us we had to move our car by 11am otherwise the state police will tow us. I managed to call a local tow company who finally arrived by 10:55am, so we had been stranded in an Express Lane watching cars fly by at 85mph for almost 2 and a half hours before we were able to move. After the first shop took a look and told me the engine was damaged and that they couldn't replace it, I had it towed to a Volvo dealership. 5 days and a $375 diagnostic later, they find that the turbocharger has an internal oil leak and that this and the catalytic converter would have to be replaced for $6k. Aside from now being carless 4 hours from the dealership and missing my wife's birthday celebration without refund, I now have a $6,375 bill that I had no way of preventing due to a manufacturing design flaw in 2012 Volvo S60 T5. I SHOULD have been warned of a low oil situation so I could have at least pulled over and properly tended to it. I SHOULD NOT have to be liable for a Volvo design flaw that may involve faulty piston rings that has apparently affected countless others. This incident put both my wife and I in danger on an Express Lane on a very busy highway. Volvo needs to be accountable for this design flaw.

Feb 17, 2022

MY 2012 VOLVO S60 HAD SERIOUS ENGINE NOISE BROUGHT TO THE SHOP THEY THOUGHT IT MIGHT OF BEEN THE FACT THAT I HAD LOW OIL, BUT I HAD JUST GOTTEN MY OIL CHANGED 12/17/14 AND IT WAS 5/27/15 NOW AND I HAD NOT DRIVEN ANYWHERE CLOSE TO 6 THOUSAND MILES TO DEPLETE ALL THE OIL. THE SHOP TOLD ME TO REALLY FIGURE OUT WHAT WAS GOING ON THEY WOULD HAVE TO TAKE OUT THE ENGINE TO TAKE A LOOK AT WHAT WAS MAKING THE NOISE. THAT EVENING I GOT A CALL FROM THE SHOP AGAIN TELLING ME THAT THERE WAS A SERIOUS PROBLEM. THEY TOLD ME BECAUSE MY CAR WAS DANGEROUSLY LOW ON OIL IN FACT 3 QUARTS LOW THAT THE ENGINE FOR THAT FACT HAD NOT GOTTEN ANY OIL, THIS IN TURN CASED THE BARRING AND THE CRANK SHAFT THE BE DAMAGED SO BAD THAT THEY SHOP TO ME THAT IF BASICALLY BEYOND REPAIR AND I WOULD NEED TO GET A NEW ENGINE. UPON RESEARCHING THE INTERNET I CAME ACROSS A STRING OF RECALLS FOR MY CAR, IT STATED THAT THE VOLVO'S SOFTWARE HAD A PROBLEM WHICH PREVENTED THE LOW ENGINE OIL LIGHT FROM COMING OUT AND IN DECEMBER 2013 THEY STARTED A RECALL. I CHECK THE WEBSITE AND GOT THE NUMBER TO VOLVO OF NORTH AMERICA AND CALLED AND WAS TOLD THAT MY CAR WAS ONE OF THE VEHICLES THAT WAS RECALLED. I WAS ALSO TOLD THAT THEY PROBLEM WAS FIXED BY A SIMPLE SOFTWARE UPDATE. I WAS ALSO TOLD THAT IN THEIR RECORDS MY CAR WAS TAKEN INTO VOLVO AND THE UPDATE WAS APPLIED TO MY CAR FIXING THE PROBLEM. I TOLD THE REPRESENTATIVE ON THE PHONE THAT IF THIS WAS THE CASE THEN IT MUST OF NOT WORKED BECAUSE MY CAR WAS IN THE SHOP WITH THE EXACT SAME PROBLEM THAT VOLVO'S WEBSITE DESCRIBED AND ALSO NO "LOW ENGINE OIL" LIGHT EVER CAME ON.

May 28, 2015

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

2 complaints

SIRIUS RADIO MODULE FAILURE CAUSE CONTROL AND DISPLAY OF BACK UP CAMERA, NAVIGATION, HANDS FREE PHONE, AND RADIO TO STOP WORKING.

Mar 04, 2021

MY CAR DOESN'T NOTIFY ME THAT THE ENGINE OIL IS LOW. LAST YEAR, I DROVE ALL THE WAY TO MISSISSIPPI WITHOUT IT WARNING THAT THE OIL WAS LO WITH BARELY ANY OIL ON THE DIP STICK. WE STOPPED TO CHECK IT WHEN WE GOT GAS AND THAT IS HOW WE KNEW. IT HAS BEEN LOW SEVERAL TIMES THIS YEAR WITHOUT NOTIFYING ME. I HAVE TO CONSTANTLY CHECK THE OIL TO ENSURE THERE IS ENOUGH IN THERE. IT DOES NOT HAVE AN OIL LEAK AS THERE IS NO OIL ON THE CONCRETE. I HAVE CHECKED WITH THE VOLVO DEALERSHIP AND WAS TOLD THERE WAS NO RECALL FOR MY CAR IN REFERENCE TO LOW OIL BUT THERE SHOULD BE. I COULD HAVE BLOWN MY ENGINE

Oct 29, 2020

LATCHES/LOCKS/LINKAGES

2 complaints

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER:19V849000 (LATCHES/LOCKS/LINKAGES) HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. (CAPITAL VOLVO OF ALBANY 347 NEW KARNER RD, ALBANY, NY 12205 (518) 389-6500) WAS CONTACTED AND CONFIRMED THE REMEDY PART WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND CONFIRMED PARTS NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Feb 13, 2020

2012 VOLVO S60. VIN: [XXX] . ON OR ABOUT 09/09/2019, THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC TO REPAIRER/REPLACE THE PASSENGER DOOR LATCH/LOCK, WHICH HAD FAILED. THIS FAILURE PREVENTED ALL LOCKING AND LATCHING SAFETY FEATURES TO OPERATE. THIS CAUSED THE DOOR TO NOT LATCH OR LOCK ALLOWING THE DOOR TO OPEN DURING ANY TURN. UPON ARRIVAL AT THE MECHANIC'S SHOP THE DRIVER'S DOOR LOCK/LATCH FAILED IN THE SAME WAY. UPON REMOVAL OF THE PART IT WAS FOUND TO BE A FORD PART, NOT A VOLVO PART. THE MECHANIC CONTACTED VOLVO AND WAS ADVISED THAT VOLVO WAS AWARE OF THE FAILURES BUT IT HAD NOT BEEN MADE PUBLIC AND NO RECALL WAS IN AFFECT. A COMPLAINT WAS MADE BY ME TO VOLVO CORPORATE AND WAS TOLD TO TAKE THE VEHICLE TO A VOLVO DEALERSHIP. ALL INSTRUCTIONS WERE FOLLOWED. A VIDEO WAS MADE BY ME WITH MY 15 YEAR OLD DAUGHTER USING THE CAMERA IN A PARKING LOT. THIS VIDEO ILLUSTRATES THE UNSAFE DOOR LOCK/LATCH AND IT'S EXTREME DANGER TO THE PUBLIC AT LARGE, INCLUDING ANY PERSON THAT OWNS THIS MAKE AND MODEL OF VEHICLE. UPON THE LATCH/LOCK FAILURE, THE DOOR(S) ARE ALLOWED TO OPEN FREELY WHILE THE VEHICLE IS IN MOTION AND THE AUTO AND MANUAL ELECTRIC LOCKS WILL NOT ENGAGE. THIS COULD CAUSE AN EJECTION OF THE VEHICLE'S DRIVER OR OCCUPANTS DURING EVEN A SLIGHT TURN. IN THE EVENT OF A COLLISION THIS WOULD MOST LIKELY CAUSE THE EJECTION OF THE VEHICLE'S DRIVER AND OR OCCUPANTS. IF THE DOOR OPENS WHILE IN MOTION THE DOOR COULD STRIKE ANOTHER VEHICLE OR PEDESTRIAN CAUSING SERIOUS INJURY OR DEATH. THIS DOOR LATCH/LOCK SHOULD BE RECALLED ON ALL VOLVO'S OF THIS YEAR AND MODEL FOR THE SAFETY OF THE GENERAL PUBLIC AND REPLACED WITH AN AUTHORIZED VOLVO PART THAT IS CERTIFIED AS SAFE. THE REAR DRIVER'S SIDE AND PASSENGER DOOR LATCHES/LOCKS HAVE NOT BEEN EVALUATED AT THIS TIME. *JS PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Sep 18, 2019

BACK OVER PREVENTION

1 complaint

At temperatures around 90* and higher the rear camera flickers and is unusable. This happens without any warning and when vehicle attempting to reverse.

Aug 14, 2024

ENGINE AND ENGINE COOLING

1 complaint

The contact owns a 2012 Volvo S60. The contact stated that while driving at an undisclosed speed, she smelled a burning odor in the interior of the vehicle, after which the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. After a visual inspection of the engine compartment, the contact became aware that the engine was without oil; however, the low oil warning light was not illuminated. The check engine warning light was illuminated. The vehicle was not taken to the dealer nor an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 13V592000 (Engine and Engine Cooling) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 137,000.

Feb 07, 2024

SEAT BELTS,LATCHES/LOCKS/LINKAGES

1 complaint

The contact owns a 2012 Volvo S60. The contact stated that while driving approximately 10 MPH, the driver’s side rear door opened unintendedly without the driver touching the door handle. The contact pulled over to the side of the road and inspected the vehicle. Additionally, the contact stated that on several occasions when the seat belt tongue was inserted inside the buckle, the seat belt failed to latch properly. The contact stated that the latch plate latched securely after several attempts. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 150,000.

Aug 09, 2023

VISIBILITY/WIPER

1 complaint

The front windshield has a faulty gasket, I put sealant from Autozone but didn’t help. Water falls down the windshield causing skewed vision. I’m also afraid that there may be some type of short, which can cause damage either parked or driving.

Jun 30, 2022

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER

1 complaint

When I first bought this Volvo there was condensation in both of the headlights then took it for a test drive and I really liked it and when I got back the dealer said if I was to buy it he would take care of both headlights so I assumed that he did but I bought it and left and was driving and then a code came on in the car saying low beam out I was like oh [XXX] so took it back to them they had me go buy $120 light bulb and that wasn't the problem they did some working and testing and said that it was the low beam ballast so I bought 1 for the drivers side and that fixed that problem but then not even a week later the same light came on saying low beam out, took it back and they said that it was the same thing on opposite side on passenger side so they said order the part and we'll fix it I did that took it back to them and they said it was fixed not even a day later and the light was back on swing low beam out I'm thinking that there is an issue that has to deal with some kind of recall with these lights cause there is no way that they should break that easy or quick so please get back to me and let me know thank you INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Jan 21, 2022

VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

1 complaint

Volvo arrived at the hiking trailhead parking lot at approximately 10 miles an hour, slowed down more to select parking space then turn right into space in front of a cement outhouse. Space had a cement parking block. As the car was about to come to a complete stop in the space, it suddenly accelerated on its own as if the accelerator was press all the way overcoming the cement block and crashing into the outhouse. Both driver and passenger airbags were deployed. The driver never took the foot off the brake when the car accelerated. The automated braking system never deployed. Prior to the accident, the low battery warning light was on but the battery was checked out by a professional to be fully charged. We walk away from the accident bruised with back and chest pains from the seat belt but considered ourselves lucky. Had we not parked with a cement outhouse five feet in front of us two spaces over, we would have accelerated into an open field and into a forest of trees.

Jun 30, 2021

Crash: 1

SEAT BELTS,ENGINE

1 complaint

I was on my was home from work and I Engine Started to malfunction In the middle of the street I got help to push out of the street waited a few minutes and it started back up thank God it got me home but now I’m still having problems

Jun 04, 2021

Crash: 1

VISIBILITY/WIPER,FORWARD COLLISION AVOIDANCE

1 complaint

WINDSHIELD SEPARATING FROM THE CAR AT THE TOP. POTENTIALLY HAZARDOUS FROM WATER RUNNING DOWN THE INSIDE OF THE WINDSHIELD THAT CAN NOT BE CLEARED EXCEPT BY HAND WHILE DRIVING. ALSO LIKELY TO CAUSE WATER DAMAGE TO THE INTERIOR OF THE CAR!

Apr 09, 2021

SEAT BELTS,STRUCTURE

1 complaint

RECALL NOTICE ON 11/2019 TO REPLACE ALL DOORS DUE TO A SAFETY ISSUE (RECALL #: R89978: DOOR LATCHES). RECENTLY ON 12/1/2019, 12/23/2019 AND 1/5/2020 I NOTICED THAT MY REAR RIGHT DOOR SLIGHTLY OPENED WHILE CITY DRIVING IN SUBURBAN NEIGHBORHOOD (LOTS OF STOPS) AND THE DOOR SIGNAL DID NOT INDICATE. THEY DID NOT FULLY OPEN BUT THE LATCH SEEMS TO HAVE AN ISSUE. HAVE BEEN REACHING OUT TO SERVICE AND VOLVO DOES NOT HAVE THE PARTS NEEDED.

Jan 06, 2021

UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE

1 complaint

AS I APPROACHED A RED LIGHT I BEGAN TO SLOW DOWN AND MY CAR STARTED TO SHAKE AND THEN IT TURNED OFF I WAS UNABLE TO TURN ON MY HAZARDS TO WARN OTHER DRIVERS OR PULL OVER TO THE SIDE, AFTER A COUPLE SECONDS THE LIGHTS CAME BACK ON AND I PUT THE CAR IN P AND STARTED IT AGAIN. IT HAPPENED AGAIN LATER ON THE SAME DAY.

Dec 16, 2020

FUEL SYSTEM, GASOLINE,ENGINE

1 complaint

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND OPERATED AS DESIGNED. THE VEHICLE WAS TAKEN TO THE VOLVO STORE LOCATED AT 1051 WEST WEBSTER AVE, WINTER PARK, FL 32789, BUT WAS NOT DIAGNOSED NOR REPAIRED. THE NHTSA CAMPAIGN NUMBER: 11V303000 (FUEL SYSTEM, GASOLINE) WAS REFERENCED HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 79,000.

Jul 20, 2020

FUEL/PROPULSION SYSTEM

1 complaint

THERE WAS ONE INCIDENT THAT MY CAR WAS NOT ACCELERATING ON THE HIGHWAY. THE CAR WOULD STALL FOR A BIT AND WHEN I TRIED TO MAINTAIN THE SAME SPEED I WAS GOING AT, I WOULD PRESS THE GAS PEDAL AND THE SPEED WOULD NOT CHANGE, IT CONTINUED TO SLOW DOWN. FORTUNATELY, I WAS ABLE TO PULL OVER TO THE SIDE OF THE HIGHWAY AND PUT MY CAR ON PARK. THIS WHEN I PUT THE CAR IN NEUTRAL TO CHECK THE RPM, TO SEE IF THE GAS WAS WORKING. THE RPM WOULD GO UP EVERY TIME I PRESSED ON THE GAS PEDAL. FROM THERE, I TURNED MY CAR OFF AND ON, AND TRIED TO SEE IF THE CAR WAS ABLE TO ACCELERATE. ONCE I TURNED THE CAR BACK ON, THE CHECK ENGINE LIGHT HAD TURNED ON. I MANAGED TO GET HOME FROM WORK DRIVING ON THE LEFT LANE AND AT A SLOW SPEED. THAT IS WHEN I SCHEDULED AN APPOINTMENT WITH MY MECHANIC. THE FOLLOWING DAY, THE MECHANIC HAD FOUND OUT THAT THERE WAS AN ISSUE WITH MY FUEL PUMP, THERE WAS NOT ENOUGH PRESSURE. UPON DOING SOME RESEARCH ON THE ISSUE, I HAD FOUND OUT THAT THE NHTSA HAD REPORTED A RECALL WITH THE SAME ISSUE FOR THE SAME MODEL AND YEAR OF MY CAR (HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2011/RCDNN-11V303-8835.PDF). I SEARCHED MY VIN NUMBER TO SEE IF MY CAR FELL UNDER THE RECALL PERIOD LISTED ON THE WEBSITE, AND IT HAD REPORTED ONLY A DOOR LATCH ISSUE AND NOT THE FUEL PUMP. I WOULD LIKE THE NHTSA TO INVESTIGATE FURTHER INTO THE ISSUE WITH THE FUEL PUMP, MORE SPECIFICALLY, DETERMINE WHETHER OR NOT THE TIME PERIOD FOR ISSUE STATED UNDER THE RECALL NEEDS TO BE EXTENDED EVEN FURTHER. *TR

May 20, 2020

ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

THE OIL WAS CHANGED AT 85,000 MILES. AT APPROXIMATELY 90,000 MILES, THE LOW OIL PRESSURE LIGHT FLASHED ON AND IMMEDIATELY DISAPPEARED WHEN MAKING TURNS. THE SENSOR LIGHT DID NOT REMAIN ON THE DASHBOARD. THERE WAS NO EVIDENCE OF OIL LEAKING. AFTER A COUPLE OF DAYS, THE ENGINE BEGAN KNOCKING. THE OIL LEVEL WAS CHECKED AND WAS LOW. OIL WAS ADDED TO THE CAR. THE CAR WAS TAKEN TO THE VOLVO DEALER FOR A DIAGNOSTIC CHECK. THE DEALER REPRESENTATIVE STATED THAT NO WARNING LIGHT INDICATORS SHOWED DURING THE DIAGNOSTIC CHECK. THE ENGINE WAS STARVED OF OIL AND NEEDED TO BE REPLACED. HE MENTIONED THAT FOR THIS MODEL AND YEAR, NEW VEHICLE OWNERS THAT STILL HAD A WARRANTY WERE ASKED TO COME IN AND HAVE PISTON O-RINGS REPLACED BECAUSE OF EXCESSIVE OIL CONSUMPTION. WE WERE NOT MADE AWARE OF THIS ISSUE.

Jun 26, 2019

ELECTRONIC STABILITY CONTROL (ESC),ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

IN OCTOBER 2018. WHILE DRIVING MY 2012 VOLVO ( 88,000 MILES)THE CAR STARTED TO HESITATE IN TRAFFIC THEN IT STOP. I HAD JUST EXIT THE EXPRESS HIGHWAY ON TO A CITY STREET. THERE WAS NO SENSOR LIGHTS OR ENGINE CHECK LIGHT THAT CAME ON AT ALL. TRIED TO CRANK THE CAR BACK UP. THE CAR WOULD NOT START. SUDDENLY THE OIL LIGHT AND THE AIR BAG LIGHT CAME ON. A SEARS TECHNICAL CAME OUT TO JUMP START THE CAR THINKING IT WAS MY BATTERY TO TAKE CAR TO THERE SHOP. HE CHECK THE OIL BECAUSE THE LIGHT WAS ON. THE OIL WAS FINE NOT LOW. I HAD JUST HAD A OIL CHANGE SEPT 2018. THE CAR STILL WOULD NOT START. I HAD TO GET A TOW TO A SHOP FOR FOREIGN CARS. MY DIAGNOSIS ENGINE LOCKED UP. THE INJECTORS 5 AND 6 WAS WIDE OPEN (HYDRO LOCKING ) FUEL HAD BEEN LEAKING EVERYWHERE EVEN IN MY OIL. THE PRICE WAS $1400.00 TO REPAIR.

Oct 27, 2018

POWER TRAIN,STRUCTURE,FUEL/PROPULSION SYSTEM

1 complaint

MY VEHICLE WAS PARKED IN A GROCERY STORE LOT. I ENTERED THE VEHICLE TO BACK IT OUT OF ITS PARKING SPOT. IT WAS NEXT TO A FULL SIZED VAN WHICH HAD CARPET CLEANING EQUIPMENT MOUNTED INSIDE. I STARTED THE CAR AND PLACED IT IN REVERSE AS IT BEGAN TO ACCELERATE ON ITS OWN. I TRIED TO SLOW THE VEHICLE WITH THE BRAKE WHICH FAILED. I COLLIDED WITH A BLOCK WALL IN THE REAR OF THE CAR AND ATTEMPTED TO GET IT OUT OF GEAR, WITH THE SOLID JARRING FROM THE REAR THE CAR WENT INTO DRIVE AND CONTINUED TO ACCELERATE TO FULL SPEED, WHILE I WAS ATTEMPTING TO BRAKE. THE VOLVO HIT THE VAN WHICH IT HAD BEEN PARKED NEXT TO IN THE REAR LEFT BUMPER AND DROVE IT APPROXIMATELY 20 FEET THROUGH A PLANTER AND INTO A PARKING SPOT ON THE OTHER SIDE OF THE PLANTER. THIS CAR (VOLVO) IS EQUIPPED WITH A COLLISION WARNING SYSTEM THAT WAS SUPPOSED TO HAVE AUTO BRAKED AND DID NOT. ADDITIONALLY THE AIR BAGS DID NOT DEPLOY. I TOOK THE CAR TO VOLVO AND HAD THEM ATTEMPT TO PULL CODES FROM THE VEHICLES INFORMATION SYSTEM. THEY REPORTED THAT NO CODES WERE PRESENT AND ATTEMPTED TO EXPLAIN AWAY THE INCIDENT AS DRIVER ERROR. THE CAR WAS TOTALED IN THE PROCESS. I AM CERTAIN THAT THERE WAS NO DRIVER ERROR AND THAT WHAT HAPPENED WAS A SUDDEN UNEXPLAINED ACCELERATION. OTHER SOMEWHAT SIMILAR INCIDENTS ARE REPORTED ON THE INTERNET. THE CAR HAS BEEN RETAINED IN MY POSSESSION UNTIL MAR 9TH 2017. IN THE EVENT IT SHOULD BE EVALUATED I HAVE IT AVAILABLE.

Feb 03, 2017

Crash: 1

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

ON APRIL 12, 2016 I TOOK MY VOLVO S-60 LEASED BRAND NEW FROM VOLVO AND THE PURCHASED AT THE END OF THE LEASE AS A CERTIFIED PRE-OWNED CAR IN FOR AN OIL CHANGE AND A CHECK OIL LIGHT. VOLVO HAD A RECALL ON OIL PRESSURE CENSORS (THIS HAD CAUSED OTHER CAR ENGINES TO SEIZE SOMETHING THAT THE NTSB HAS REPORTED ON). THE VOLVO AUTHORIZED DEALER, HERB GORDON, CLAIMED TO HAVE MADE THIS REPAIR. HOWEVER ON JUNE 21, 2016, THE ENGINE SEIZED IN THE MIDDLE OF A BUSY ROAD. THE VOLVO AUTHORIZED DEALER DETERMINED IT NEEDED A NEW ENGINE, AT THE TIME, I ASKED ABOUT SIMPLY APPLYING THE COST TO REPLACE THE ENGINE (ABOUT $12,000) TO GETTING ME INTO A NEW CAR. VOLVO REFUSED AND WENT AHEAD WITH AN ENGINE REPLACEMENT (THEY HAD MY CAR FROM JUNE 21, 2016 TO AUGUST 1, 2016. THE CAR BROKE DOWN AGAIN ON AUGUST 15, 2016 WHILE MY FAMILY AND I WERE ON THE ROAD FOR A VACATION. WHEN WE RETURNED FROM VACATION THE CAR WAS GIVEN BACK TO US BUT THE PROBLEM NOW IS THAT THE CAR'S VALUE HAS SIGNIFICANTLY DIMINISHED BECAUSE OF THE ENGINE REPLACEMENT, THE BLUEBOOK VALUE OF THE CAR IS ON AVERAGE $13,789 BUT THE HIGHEST WE CAN GET FOR IT IS $8,000 BECAUSE OF THE DAMAGE DONE TO IT BY VOLVO. WE HAVE TRIED TO GET VOLVO TO WORK WITH US BY MAKING UP THAT DIFFERENCE AS A TRADE IN ON A CAR THEY HAVE IN STOCK. WE HAVE BEEN MET WITH NOTHING BUT HOSTILITY AND ABUSE. IN FACT EARLIER TODAY WE WERE TOLD BY A CUSTOMER SERVICE REPRESENTATIVE AT VOLVO TO SHUT UP AND THEN HE HUNG UP ON US,

Jan 09, 2017

POWER TRAIN,ENGINE

1 complaint

MY 2012 S60 HAS LESS THAN 63K MILES AND IT IS BURNING OIL. I'VE NOT SEEN ANY LEAKS OR EXHAUST SMOKE, SO I ASSUMED ALL WAS WELL. DEALER SHIP ADVISED IT'S NORMAL FOR A VOLVO TO LOSS 1-2 QUARTS OF OIL BETWEEN OIL CHANGES. RECENTLY THE ENGINE FAILED WITH NO WARNING, AND WARRANTY IS OUT. CAN'T BELIEVE A 2012 VEH. WOULD HAVE SUCH ENGINE PROBLEMS AND VOLVO CUSTOMER SERVICE DOES NOT ACKNOWLEDGE THE PROBLEM.

Sep 22, 2016

POWER TRAIN

1 complaint

WHEN AT A FULL STOP, WITH FOOT ON THE BRAKE, ON A HILL AND IN GEAR (DRIVE) THE CAR ROLLS BACKWARDS WHEN REMOVING MY FOOT FROM THE BREAK PEDAL. THE TRANSMISSION DOES NOT ENGAGE UNLESS THE GAS PEDAL IS DEPRESSED. THE VOLVO OF SAN DIEGO "TECHNICIAN" CHECKED A 2013 VEHICLE WITH THE SAME TRANSMISSION AND FOUND THE SAME PROBLEM. UNFORTUNATELY, HE USED THIS TEST TO PROVE THAT THIS WAS NORMAL BEHAVIOR FOR THIS VEHICLE, AND THUS, THE TRANSMISSION WAS IN FINE CONDITION. .I DON'T SEE HOW A CAR ROLLING BACKWARDS WHILE IN A FORWARD GEAR COULD EVER BE CONSIDERED NORMAL BEHAVIOR. IT IS AT BEST, A DEFECT, AT WORST, A SAFETY ISSUE. VOLVO OF SAN DIEGO REFUSES TO FIX THE PROBLEM. IT SHOULD BE NOTED THAT THIS CAR HAS ONLY 46,000 MILES, AND IS STILL UNDER FULL WARRANTY. THERE ARE OTHER ISSUES WITH THIS TRANSMISSION, BUT THEY ARE DIFFICULT TO DESCRIBE IN THIS FORMAT, BUT THE PROBLEMS WERE VERIFIED BY THE VOLVO OF SAN DIEGO PERSON WHO WENT ON THE TEST DRIVE WITH ME, ON JUNE 15TH, 2016. THIS IS AN ONGOING ISSUE WHICH I HAVE BEEN DESCRIBING TO VOLVO OF SAN DIEGO SINCE DECEMBER 2015. TO DATE, THEY HAVE REFUSED TO EVEN ACKNOWLEDGE THAT THERE IS A PROBLEM.

Jul 16, 2016

STEERING,ENGINE

1 complaint

1) POWER STEERING FLUID LEAKING CONSTANTLY SINCE PURCHASING CAR AT 52K MILES; DIAGNOSED AS RACK AND PINION FAILURE 2) ENGINE LIGHT CAME ON AND ENGINE MADE WHISTLING NOISE AT 60K MILES WHILE DRIVING; DIAGNOSED AS PCV FAILURE

Jan 01, 2016

EQUIPMENT

1 complaint

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT THE AIR CONDITIONER UNIT EMITTED AN ABNORMAL CHEMICAL SMELL THAT CAME THROUGH THE VENTS. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED DAILY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS STATED THAT MOLD WAS BUILT UP ON THE EVAPORATOR THAT WAS CONNECTED TO THE AIR CONDITIONER. THE SOFTWARE WAS UPGRADED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 41,000. UPDATED 08/19/14*LJ

Jul 15, 2014

VEHICLE SPEED CONTROL,ENGINE

1 complaint

ON THE APRIL 23, 2014, MY HUSBAND WAS DRIVING AND THE CAR SHOT OUT AT HIGH SPEED HE DIDN'T REALIZE WHAT HAPPENED. ON APRIL 24, 2014, I WAS IN MY DRIVEWAY IN PARK AS I PUT THE CAR IN DRIVE TO SLOWLY ENTER MY GARAGE THE CAR TOOK OFF AT HIGH SPEED TIRES SPUN LEFT TIRE MARKS ON MY PAVEMENT AND I HIT THE BRAKES IN GARAGE NOT TO HIT THE WALL AND LEFT MARKS THERE AS WELL. MY NEIGHBORS WERE RIGHT THERE WITNESSING THIS SCARY EXPERIENCE. I CALLED CORPORATE IMMEDIATELY THEY TOLD ME TO GET IT TO THE DEALER. I CALLED A TOW TRUCK AND THE TOW TRUCK DRIVER TOOK THE KEYS TO SLOWLY DRIVE IT ONTO THE FLATBED AND THE CAR AGAIN TOOK OFF AT HIGH SPEED AND ALMOST FLEW OFF THE TOW TRUCK! ALSO, THE PUSH BUTTON START BUTTON WAS A PROBLEM, EVER SINCE THE VEHICLE WAS LEASED. UPDATED 07/28/14 UPDATED 10/27/2014 *JS

Apr 29, 2014

AIR BAGS,SEAT BELTS,STRUCTURE

1 complaint

ON AUGUST 24, 2013, I WAS INVOLVED IN A CAR ACCIDENT. A CAR STOPPED SHORT ON THE HIGHWAY. THE CAR IN FRONT OF ME HIT THAT CAR. I THEN HIT THE CAR IN FRONT OF ME. I HAD ONLY A FEW SECONDS TO REACT. ANOTHER CAR THEN RE-ENDED ME. MY AIRBAG NOR SEATBELT PRETENTIONERS DEPLOYED. I HAD DIFFICULTY TURNING THE CAR OFF. THE CAR WAS TOTALED. WITHIN A FEW WEEKS OF THE INCIDENT, I REPORTED THE MATTER TO VOLVO. THEY SENT AN INVESTIGATOR OUT. VOLVO CLAIMS THAT SENSORS WERE NOT ACTIVATED SINCE THE DAMAGE WAS ABOVE THEM, AND THERE WAS NOT ANY PROBLEM. HOWEVER, AT THE SPEED I HIT, THERE IS NO EXCUSE FOR WHY THE AIRBAGS SHOULD NOT HAVE DEPLOYED. EITHER THE CAR IS DESIGNED IMPROPERLY IN TERMS OF WHERE THE SENSORS ARE PLACED OR THERE IS A MANUFACTURING DEFECT. AS I UNDERSTAND IT, OTHER S60S (NOT MY VID#) HAVE BEEN RECALLED FOR AN ELECTRICAL PROBLEM THAT COULD CAUSE AIRBAGS NOT TO DEPLOY. *TR

Jan 21, 2014

Crash: 1

Injuries: 2

STEERING,ELECTRICAL SYSTEM

1 complaint

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THERE WAS A LOSS OF STEERING CONTROL AND THE REAR END SPUN UNCONTROLLABLY. THE DYNAMIC TRACTION CONTROL FAILED TO ACTIVATE AND THE VEHICLE CRASHED INTO THE CURBSIDE, CAUSING DAMAGE TO THE FRONT DRIVER AND PASSENGER'S SIDE WHEEL RIMS. IN ADDITION, THE REAR DRIVER'S SIDE RIM AND FRONT BUMPER WAS DAMAGED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. A TROUBLE CODE WAS DETECTED FOR THE SRS MODULE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 18,991.

Sep 11, 2013

Crash: 1

SERVICE BRAKES

1 complaint

BRAKES COMPLETELY GAVE OUT WHILE I WAS DRIVING ON RT. 85 IN ATLANTA. FORTUNATELY I WAS ABLE TO GET OVER TO THE SHOULDER AND I DIDN'T HIT ANYONE. CALLED VOLVO ROADSIDE ASSISTANCE AND THEY SENT A TOWING COMPANY. CAR IS STILL IN SHOP AND NOT YET DIAGNOSED. I'M TERRIFIED TO GET BACK INTO THAT CAR! *TR

Jan 23, 2013

SEATS

1 complaint

PLEASE, PLEASE BACK OFF ON YOUR HEAD REST REQUIREMENTS FOR SAFETY. PLEASE ALLOW THE CONSUMER TO CHOOSE THE POSITION OF THE HEAD REST. NOT ONLY HONDA, BUT FORD, GM, CHRYSLER, ALL MANUFACTURERS ARE CREATING VERY PAINFUL CAR SEATS SINCE 2009 DUE TO THIS AWFUL HEADREST REQUIREMENT. SEATBELTS ARE A LAW, BUT I CHOOSE TO WEAR THEM. MOTORCYCLE HELMETS ARE NO LONGER A LAW, BUT I CHOOSE TO WEAR THEM. NOW LET ME CHOOSE MY HEADREST POSITION. I THINK THESE NEW DESIGNS ARE GOING TO CAUSE FAR MORE INJURIES AND INSURANCE CLAIMS FROM PEOPLE HAVING THEIR HEADS COCKED FORWARD, IN A FORCED IMPROPER POSTURE. I HAD MIGRAINES DUE TO MY HEADREST BEFORE I RESOLVED THIS ISSUE IN MY CAR BY MAKING MODIFICATIONS. I SIT WITH PROPER POSTURE AND MY HEAD IS FORCED FORWARD. THE ONLY CHOICE I HAD WAS TO SIT IMPROPERLY IN ORDER TO TRY TO AVOID THE TERRIBLE DISCOMFORT THIS NEW LAW FORCES ON ME. PLEASE CHANGE THIS LAW. *TR

Dec 08, 2012

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

THE ADAPTIVE CRUISE CONTROL IN MY VEHICLE HAS BEEN OCCASIONALLY MALFUNCTIONING (ABOUT 10-15 TIMES SINCE PURCHASING MY VEHICLE IN MAY) CAUSING IT TO APPLY THE PARKING BRAKE AT SPEEDS OF ABOUT 5 MPH. THIS CAUSES MY VEHICLE TO ABRUPTLY STOP WITHOUT THE BRAKE LIGHTS BEING ACTIVATED. I THEN HAVE TO DEPRESS THE BRAKE PEDAL AND RELEASE THE PARKING BRAKE. THEN MY CRUISE CONTROL IS INOPERATIVE UNTIL I RESTART THE VEHICLE. I WAS NEARLY REAR ENDED AFTER THE MOST RECENT OCCURRENCE. I'VE TAKEN MY VEHICLE TO THE NEAREST VOLVO REPAIR CENTER FOUR TIMES TO BE REPAIRED BUT THE MALFUNCTION STILL OCCURS. VOLVO IS UNWILLING TO REPLACE MY CAR UNDER THE LEMON LAW. *TR

Jul 21, 2012

VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

1 complaint

THIS IS THE SECOND OCCASION ON WHICH THIS DEFECT HAS APPEARED, THE PRIOR INCIDENT HAPPENING IN APPROXIMATELY MARCH 2012, AT A MILEAGE OF APPROXIMATELY 5000 MILES. I HAVE OWNED THE CAR FOR JUST UNDER SIX MONTHS. I LIVE IN A SOUTHEASTERN US STATE AND TRAVELLED TO MY SECOND HOME IN FLORIDA. THE CAR HAS BEEN PARKED IN FLORIDA FEWER THAN 20 TOTAL DAYS. ON BOTH OF THE LAST TWO OCCASIONS DURING WHICH THE VEHICLE WAS PARKED IN FLORIDA, AN ANIMAL WAS APPARENTLY ABLE TO CLIMB DEEP INTO THE UNDERBODY OF THE CAR AND CHEW ON WIRES CONTROLLING THE DYNAMIC TRACTION STABILITY CONTROL SYSTEM, THE ANTILOCK BRAKING SYSTEM, THE CRUISE CONTROL SYSTEM, AND THE VOLVO CITY SAFETY CRASH AVOIDANCE SYSTEM. ON BOTH OCCASIONS, THE INTERNAL CAR ALERT SYSTEM DETECTED THE PROBLEM, ALERTED ME, AND VOLVO AGREED TO COVER THE COST OF THE REPAIRS, THOUGH TODAY, ON THE SECOND OCCASION, VOLVO INDICATED THEY WILL NOT COVER THIS FORM OF DAMAGE IN THE FUTURE. I PROPOSED TO BOTH MY VOLVO DEALERSHIP AND TO THE NATIONAL VOLVO CUSTOMER CARE CENTER THAT AN APPROPRIATE FORM OF SHIELDING SHOULD BE ADDED TO COVER THE WIRES CONTROLLING THESE SYSTEMS TO PREVENT AN ANIMAL'S ACCESS TO THEM. TO THE BEST OF MY KNOWLEDGE, THIS SUGGESTION WAS IGNORED, AS NO SPECIAL SHIELDING WAS DESCRIBED/OFFERED, DESPITE THE CRITICAL NATURE OF THESE SYSTEMS. THIS PROBLEM HAS NEVER OCCURRED WITH EITHER OF THE OTHER TWO VEHICLES WHICH I REGULARLY TAKE TO THE SAME LOCATION, THUS, I BELIEVE THIS IS A DESIGN FLAW IN WHICH EITHER THE MATERIALS USED IN THESE WIRING SYSTEMS ARE PARTICULARLY ATTRACTIVE TO WHATEVER ANIMAL CHEWED THE WIRES (E.G. SOY-BASED WIRE COATING POLYMERS PERHAPS), OR MORE LIKELY, THE WIRES ARE NOT SUFFICIENTLY SHIELDED/JACKETED TO PREVENT SUCH DAMAGE. IN EACH CASE, SINCE THERE WAS NOT A NEARBY VOLVO DEALERSHIP, I DROVE MY VEHICLE BACK TO THE DEALERSHIP FROM WHICH I PURCHASED IT WITHOUT FUNCTIONAL SAFETY SYSTEMS.

Jun 21, 2012

SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL,EQUIPMENT ADAPTIVE/MOBILITY

1 complaint

THE ACTIVE CRUISE CONTROL STOPS FOR NO REASON. THIS PROBLEM IS INTERMITTENT. ON A NUMBER OF OCCASIONS (~20 TIMES SINCE I PICKED UP THE CAR), THE CAR SLOWS DOWN AS THE TRAFFICS SLOWS DOWN. THE CAR IS ALMOST AT A STOP (5-10 MPH) AND THE EMERGENCY BRAKES COMES ON, THE CARS BRAKES HARD & STOPS AND THE PARKING BRAKE TURNS ON. THE ALERT "CRUISE CONTROL UNAVAILABLE" SHOW IN THE DISPLAY. THEREAFTER THE CRUISE WILL NOT ENGAGE. AFTER I SHUT OFF THE CAR AND RESTART IT, THE CRUISE AGAIN WORKS AGAIN. IN ADDITION TO NOT PERFORMING AS ADVERTISED, THIS REPRESENTS A SAFETY HAZARD. *TR

Apr 10, 2012

4.3/5.0

38 reviews

VOLVO S60 VIN Decoder — Free VIN Check Video Guide

Watch our quick VOLVO S60 VIN decoder walkthrough. Learn how to decode any VOLVO S60 VIN number to get full vehicle history, recall alerts, specifications, fuel economy (MPG), safety ratings, and known problems — completely free on ForCar.org.

Where to Find VIN for Problems Check

To check for problems and complaints on your 2012 VOLVO S60, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 2012 VOLVO S60 for Problems Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Problem Reports

Each character in your 2012 VOLVO S60 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.

2012 VOLVO S60 VIN Structure for Complaint Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 2012 VOLVO S60 Problems in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 2012 VOLVO S60 dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Review by Component

Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.

Check Safety Issues

Review crash and fire incidents for each component to assess safety concerns. Contact your VOLVO dealer or report problems to NHTSA at SaferCar.gov.

Frequently Asked Questions

How many problems does the 2012 VOLVO S60 have?

The 2012 VOLVO S60 currently has 119 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2012 VOLVO S60?

The most common problems reported for the 2012 VOLVO S60 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2012 VOLVO S60 problem data come from?

All problem and complaint data for the 2012 VOLVO S60 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

How do I report problems with my 2012 VOLVO S60?

You can report safety problems with your 2012 VOLVO S60 directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.

Where can I find my VIN to check problems?

Your 2012 VOLVO S60 VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

Is the 2012 VOLVO S60 reliable?

Reliability can be assessed by reviewing the number and severity of owner complaints for the 2012 VOLVO S60. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.