2015 VOLVO S60 Problems

VIN Decoder

Premium Report

Complaints Reported

Radar Detector GPS Tracker OBD2 Scanner Car Refrigerator Jump Starter Dash Cam

As an Amazon Associate, ForCar.org earns from qualifying purchases.

Complaints by Component

ENGINE

12 complaints

Requesting reimbursement from Volvo Cars USA for a known defect in the engine’s piston rings. This defect has resulted in excessive oil consumption and necessitated costly repairs. Volvo reached a legal settlement in May 2023 regarding this defect—which affects the piston rings, pistons, and/or piston heads in certain 2013–2016 models. I never received a recall notice or any communication from the company informing me of the issue and the extension of warranty for my car. Had I received a letter before the expiration of the 8-year extended warranty, I would have had the opportunity to have the oil consumption test performed and the piston ring repair completed, all at no cost to me per Volvo quality notice P10207. Vehicle: •Year/Model: 2015.5 Volvo S60, VIN [XXX] •Current Mileage: 92,850 •Purchase: Purchased new in 2015 from Volvo of Princeton, NJ (Princeton Volvo) and delivered at the factory in Gothenburg, Sweden May 2023 then shipped to Princeton Volvo in July 2023. •Maintenance History: The vehicle has been consistently serviced at either the Princeton Volvo dealership or at a local AAA-approved repair center. Defect Timeline (for details and costs incurred see full letter attached) 1.[XXX] (47,044 miles): “low oil” light came on. 2.April 2019–November 2024: oil additions needed each 750 to 1,000 miles. 3.September 01, 2023: Replaced oil trap. 4.January 8, 2024 (83,582 miles): Stage 1 oil consumption test. 5. January 29, 2024: Failed stage 2 of oil consumption test. Needed piston ring repair. 6.January – June 2024: Volvo Princeton and Volvo USA refused to cover full costs of repair. 7. November 2024: Piston rings replaced. Total Costs Incurred to Date: $1,431.68 Total Costs Incurred and Anticipated Costs: $2,065.68 I respectfully request full reimbursement from Volvo Cars USA for expenses incurred and anticipated due to this issue, totaling $2,065.68. Thank you for your attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Dec 02, 2024

Alternator belt shredded and got underneath the timing belt causing the engine timing to go off and severe engine damage that I will now have to total the car or spend $13-15K to replace. The car stalled after leaving a stop sign so I wasn't going fast. I spoke to my local mechanic and he had another Volvo S60 T5 in his shop with the same issue showing up but that owner was lucky enough to not have the engine destroyed in the process. From what he is saying is that every other car has some kind of timing belt protection that the Volvo S60 is missing. In searching the Internet this is a very common issue that occurs. I registered a complaint with Volvo today.

Apr 02, 2024

Was on the highway driving back from my aunts house and there were no signs anything was wrong with my car. No alerts on the dash besides low pressure tire which I filled up. As I was almost home, an alert randomly came up with “no oil pressure” along with a check engine light flashing and the car started shaking (misfiring). The car flashed a message that said something about reduced engine performance. As my car was shaking fervently, it was slowing down and failed to accelerate, causing cars behind me to almost crash. No oil pressure can also cause fires and put my life at risk. I had much time left to get my oil changed and yet I had oil message lights come on. I believe this is a problem with the piston rings that are defective & there was just recently a class action suit of them. I have had to continually fill up oil, and now I suddenly have an engine that does not work and threatened the safety of myself and others on the road. Volvo diagnosed the issue as being valve broken, piston ring damage, along with other engine components. I now need an entire new engine.

Jan 10, 2024

I have been getting a low oil level sign in my car after 5 months of doing an oil change. This is not the first time this has happened. It is suspected this may be a oil consumption issue and not an oil leak as there is no visible sign of oil leak. The oil consumption problem has been confirmed by an independent mechanic.

Oct 03, 2023

I have a 2015 Volvo S60 T5 that I purchased 08 -2021 from Volvo that is consuming oil. I have had the oil changed (out of pocket) 3 times within 10,000 miles because the low oil light was on and I had purchased a extended warranty and wanted to play it safe. Never once did any Volvo service staff mention that this model car had a issue with oil consumption. After researching this cars history I came across a bulletin on the NHTSA webpage that Volvo has known about the issue on or around 11-02-2020. Webpage ( https://static.nhtsa.gov/odi/tsbs/2020/MC-10184147-9999.pdf) I received a letter from Volvo about Excessive oil consumption dated February 3, 2023 and I contacted their customer service department. I was told that my car original delivery date was Sept 2014 and that the car is now out of warranty and I would have to pay for anything related to the oil consumption issue. I when to my extended warranty that I purchased with the car ($5000 for 4 years). Within the language of the service contract under "EXCLUSIONS" #17 reads "The correction of oil consumption" It seems to me the Volvo purposely withheld this information from Volvo owners and only sent out a letter to most owners after the factory warranty expired. In my case my car was 5 months out of warranty and they were a wear of the issue in 2020 and failed to notify millions of Volvo owners. *All service records are available but contain personal information for this complaint. Thank you for your time in this matter and this letter may be forwarded to the appropriate department for review.

Mar 31, 2023

+ 7 more complaints for this component

UNKNOWN OR OTHER

6 complaints

THE REAR DOOR LOCK IS NOT CLOSING THE DOOR

Mar 17, 2024

While driving on the highway, the rear passenger door unlatched automatically and opened. The vehicle was in the shop for a recall on this part, however it appears that the labor was not done correctly or at all.

Sep 12, 2022

NHSTA RECALL #19V849, THE DRIVER'S DOOR OPENS WITH NO KNOWN ANTECEDENT; EXCEPT NOW THE RECALL

Mar 25, 2020

SUNROOF EXPLODED & SHATTERED AS I WAS DRIVING FOR NO APPARENT REASON!!!!

Nov 23, 2016

STATIONARY VEHICLE EQUIPPED WITH KEYLESS IGNITION AND AUTO ENGINE "START/STOP" FEATURE. VEHICLE WAS STOPPED IN DRIVEWAY. ENGINE STOPPED, DRIVER STEPPED OUT OF CAR, ENGINE RESTARTED AND MOVED FORWARD, DAMAGING HOME AND BARELY MISSED PINNING DRIVER AGAINST WALL. EXPERIENCED DRIVER, MOMENTARILY DISTRACTED, ASSUMED ENGINE WAS OFF, AND HAVING PREVIOUSLY DISABLED START/STOP FEATURE, BELIEVED THAT VEHICLE WAS IN PARK AS PART OF NORMAL SHUTDOWN - OWING TO ALREADY QUIET ENGINE. CALL TO DEALER SERVICE REVEALED "SEVERAL PEOPLE" COMPLAINED OF AUTO START/STOP FEATURE BUT SAID THERE WAS NO WAY TO RESET DEFAULT FOR THIS FEATURE - THE SOLUTION WAS TO REMEMBER TO DISABLE EACH TIME DRIVER ENTERED CAR (VOLVO HAS A DISABLE BUTTON ON CONSOLE WHICH DEFAULTS TO THE AUTO START/STOP AND REQUIRES DRIVER TO MANUALLY DISABLE EACH TIME CAR IS STARTED).

Dec 15, 2015

Crash: 1

+ 1 more complaint for this component

ELECTRICAL SYSTEM

3 complaints

The contact owns a 2015 Volvo S60. The contact stated while driving at approximately 35 MPH, the steering became extremely difficult to turn and several warning lights were illuminated. The contact stated that the "City Safety" light was illuminated and drove over a manhole cover on the road and the vehicle stopped. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the two EV batteries needed to be replaced because the battery could not be charged and tested out at 9 percent. The contact was advised that the battery failure caused the failure of several vehicle systems. The vehicle was repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.

Jan 10, 2024

WHILE DRIVING, ALL POWER (ALL POWER) IS LOST, WITHOUT WARNING. DRIVING NORMALLY IN TRAFFIC, THE CAR SIMPLY SHUTS DOWN. ENGINE STOPS, NO LIGHTS (INTERIOR OR EXTERIOR), NO DASHBOARD DATA, SAFETY SYSTEMS DISABLED, NO TURN SIGNALS, NO POWER STEERING, SAFETY FLASHERS DO NOT FUNCTION, ETC. ESSENTIALLY LIKE THE CAR WAS TUNED OFF. TRY TO RESTART - NOTHING. AFTER 'RESTING' FOR 5 MINUTES, STARTS AND RUNS NORMALLY. HAS REOCCURRED 3 TIMES. VISITS TO THE DEALERSHIP HAVE RESULTED IN NEW BATTERY, AND ALTERNATOR. NO DEFINITIVE DIAGNOSIS, JUST 'HOPE' THAT THE PROBLEM HAS BEEN FIXED. BUT NEITHER OF THOSE REPAIRS HAVE FIXED THE PROBLEM, IT REOCCURED AGAIN (3RD TIME). THE CAR IS EXTREMELY DANGEROUS TO DRIVE IN THIS CONDITION, TO ME AND MY FAMILY BUT ALSO TO OTHER DRIVERS ON THE ROAD. IT HAS BEEN TOWED TO THE DEALERSHIP. NO DIAGNOSIS YET.

Sep 22, 2018

THE INSTRUMENT PANEL GOES COMPLETELY BLANK FOR APPROXIMATELY 5 SECONDS WHILE DRIVING WHICH RENDERS SPEED, SAFETY WARNINGS, ETC. UNAVAILABLE DURING THAT TIME. THERE IS NO PATTERN OF OCCURRENCE. IT HAPPENS WHILE DRIVING AT CITY OR HIGHWAY SPEEDS. IT HAS ALWAYS OCCURRED WHILE THE VEHICLE IS IN A STRAIGHT LINE OF MOTION. THIS STARTS OUT ON AN INFREQUENT BASIS (ONCE OR TWICE A WEEK) UNTIL IT MANIFESTS INTO AN EVENT OF SEVERAL TIMES A DAY. I TOOK THE VEHICLE TO THE DEALER THE FIRST TIME ON 01/13/2017 WITH 12,097 MILES ON THE ODOMETER. IT WAS HOOKED TO THE DIAGNOSTIC COMPUTER, AND WHEN THEY SAW THAT NO CODES WERE STORED, IT WAS "FIXED" WITH A DRIVER INFORMATION MODULE SOFTWARE UPGRADE. WHEN THE PROBLEM STARTED AGAIN, I TOOK THE VEHICLE IN ON 07/20/2017 WITH 16,066 MILES ON IT. ONCE AGAIN, THE CAR WAS CONNECTED TO THE DIAGNOSTIC COMPUTER AND NO CODES WERE FOUND TO BE STORED. THE WIRING WAS CHECKED AND FOUND TO BE OKAY. ANOTHER SOFTWARE UPGRADE WAS USED TO RESOLVE THE ISSUE.

Jul 20, 2017

SERVICE BRAKES

3 complaints

Brake lines blew open while driving

Mar 19, 2023

THIS IS AN ADDITIONAL COMPLAINT REGARDING THE SAME VEHICLE BRAKE PROBLEM FILED UNDER NHTSA SAFETY ISSUE ID 10979689. ON 15 DEC THE SAME VOLVO FAILED TO STOP AT A RED LIGHT ON A CITY STREET IN DRY PAVEMENT CONDITIONS. THE ONLY WAY TO STOP THE VEHICLE WHILE TRAVELING AT APPROXIMATELY 35 MPH WAS BY CONTINUING TO HOLD THE BRAKE PEDAL ALL THE WAY DOWN AND THEN SLAMMING THE GEARSHIFT FROM DRIVE INTO PARK. THE VEHICLE WAS SUBSEQUENTLY TOWED BACK TO THE LOCAL DEALER. WHEN THIS VEHICLE WAS AT THE DEALER THEY DRAINED THE BRAKE LINES AND CHANGED THE MASTER BRAKE CYLINDER BASED ON THIS FIX REPORTEDLY WORKING ON ANOTHER S60 WITH THE SAME PROBLEM ACCORDING TO VOLVO TECH SUPPORT. AFTER EIGHT MONTHS THE BRAKES FAILED AGAIN. VOLVO HAS A BRAKING PROBLEM ON THESE VEHICLES AND DOES NOT NO THE CAUSE NOR THE CORRECTIVE ACRION.

Jan 22, 2018

BRAKES FAILED TO STOP THE CAR ON THREE OCCASSIONS. BRAKES WOULD SLOW THE CAR DOWN;HOWEVER, THE BRAKE PEDAL WAS PUSHED ALL THE WAY DOWN AND THE CAR WAS STILL ROLLING. FIRST TWO FAILURES OCCURRED CONSECUTIVELY. HAD TO SHIFT THE CAR INTO PARK FIRST TIME; SECOND TIME HAD TO PUT THE EMERGENCY BRAKE ON. THIRD OCCASION WAS AFTER TAKING THE VEHICLE INTO VOLVO DEALER IN CHICAGO AND GETTING IT BACK WITH NO REPAIRS COMPLETED BECAUSE COMPUTER DIDNT REGISTER A PROBLEM. THIRD OCCASION WAS FOUR DAYS LATER; CAR WAS SLOWING DOWN BUT WOULDN'T STOP. FORTUNATELY TRAFFIC STARTED TO MOVE AGAIN BEFORE I HAD TO SHIFT THE VEHICLE INTO PARK. FIRST INCIDENT INVOLVED PEDESTRIAN CROSSING THE STREET, LAST INCIDENT INVOLVED ANOTHER VEHICLE. ALL THREE INCIDENTS WERE ON CITY STREETS. TOOK VEHICLE INTO SECOND DEALER IN DETROIT. THEY CONTACTED VOLVO TECH SUPPORT. VOLVO SUPPORT RECOMMENDED CHANGING MASTER BRAKE CYLINDER AND DRAINING BRAKES LINES. APPARENTLY THIS SAME PROBLEM OCCURRED ON ANOTHER S60 AND THIS FIX WORKED. THE DETROIT DEALER DID THE RCOMMENDED REPAIR AND SO FAR VEHICLE IS OK. HOWEVER WE ARE CONCERNED ABOUT OUR SAFETY..NOT BEING ABLE TO STOP THE VEHICLE ON THREE PREVIOUS OCCASIONS IS UNSAFE FOR US AND OTHER MOTORISTS/PEDESTRIANS. WE ARE NOT TOTALLY CONFIDENT THAT THE VEHICLE WILL BE ABLE TO COME TO A COMPLETE STOP 100% OF THE TIME IN THE FUTURE.

Apr 20, 2017

ENGINE AND ENGINE COOLING

2 complaints

The contact owns a 2015 Volvo S60. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle had consumed 3 quarts of oil after driving 2,100 miles. Additionally, the contact stated that the low oil pressure warning light only illuminated after the vehicle had consumed over 3 quarts of oil. The dealer was notified of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that an unknown related extended warranty would not be extended to repair the vehicle. The failure mileage was approximately 90,900.

Dec 10, 2025

The contact owns a 2015 Volvo S60. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and had flashed off and on while driving at highway speeds. The contact stated that the vehicle also stalled on several occasions. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the engine cylinders were faulty, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 117,000.

May 28, 2025

FORWARD COLLISION AVOIDANCE

2 complaints

City Safety Is randomly Malfunctioning. Vehicle will aggressively apply brakes when there are no objects in front of the vehicle. This has happened in town and on a long driveway.

Aug 14, 2024

We were driving down the road automatic emergency braking system engaged without warning and for no reason. This has happened before in the past a few times. We feel this is an safety concern and would like to see it addressed. Thank you.

Jan 12, 2024

ELECTRICAL SYSTEM,ENGINE

2 complaints

TL* THE CONTACT OWNS A 2015 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE FAILED TO START-UP. THE VEHICLE WAS TOWED TO LAFONTAINE VOLVO CARS OF FARMINGTON HILLS (24730 HAGGERTY RD, FARMINGTON HILLS, MI 48335, (248)579-1300) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ALTERNATOR AND BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE REPAIRED. SEVERAL DAYS LATER AFTER THE VEHICLE WAS REPAIRED, WHILE DRIVING 80 MPH, THE VEHICLE DECELERATED TO 30 MPH WITHOUT WARNING. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED OF MISFIRES ON TWO CYLINDERS DUE TO OIL CONSUMPTION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.

May 11, 2021

TL* THE CONTACT OWNS A 2015 VOLVO S60. WHILE THE VEHICLE WAS STOPPED AT A TRAFFIC LIGHT, IT STALLED WITHOUT WARNING. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO SUBARU OF MELBOURNE (LOCATED AT 4340 W NEW HAVEN AVE, WEST MELBOURNE, FL 32904, (321) 768-8020) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STARTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 49,999.

Nov 26, 2018

SEAT BELTS

2 complaints

TL* THE CONTACT OWNS A 2015 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V378000 (SEAT BELTS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN DEALER WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.*DT *TR*DT*JB

Dec 15, 2020

DRIVERS SEAT BELT LOCKED IN A POSITION WHERE IT BECAME UNUSABLE WHILE DRIVING. PASSENGERS BELT TENSION WAS VERY LOOSE AND DID NOT RETRACT ON ITS OWN. NO ACCIDENTS OR AGGRESSIVE BRAKING WERE INVOLVED.

Jan 11, 2020

STRUCTURE

2 complaints

WHILE DRIVING ON A HIGHWAY AT 65 MPH (THE LEGAL LIMIT) AT APPROXIMATELY 6:55 AM ON 2 JULY 2018, I WAS TWO OR MORE CAR LENGTHS BEHIND THE CAR AHEAD OF ME WHEN THE SUN ROOF CATASTROPHICALLY SHATTERED. NO ROAD DEBRIS WAS OBSERVED AND THE ROAD WAS DRY AND NOT IN A CONSTRUCTION ZONE. WITH THE SUDDEN EXPLODING SOUND, I DIDN'T KNOW WHAT WAS GOING ON BUT WAS ABLE TO MAINTAIN CONTROL OF THE CAR. I WAS DUCKING DOWN REFLEXIVELY AS THE NOISE WAS ABOVE MY HEAD. FORTUNATELY, THE INTERIOR SUN ROOF SHADE WAS CLOSED AND THE SUN ROOF WAS CLOSED. IN MY REARVIEW MIRROR, I SAW THE CAR DIRECTLY BEHIND BRAKING HARD AND THE CARS IN THE NEXT LANE SLOWING DOWN TO AVOID THE DEBRIS I LATER REALIZED WAS THE EJECTED GLASS FROM MY SUN ROOF. THE NOISE CONTINUED AND THEN THE GLASS BEGAN FALLING INTO THE FRONT AREA OF THE CAR THROUGH THE VENTS IN THE SUN SHADE AND I FINALLY REALIZED THE SUN ROOF GLASS HAD SHATTERED. THE CAR IS MAINTAINED IN EXCELLENT CONDITION AND THERE WERE NO SIGNS OF CHIPPING, CRACKS OR OTHER DAMAGE TO THE SUN ROOF PRIOR TO THE INCIDENT. THERE WERE ALSO NO SIGNS ON THE CAR'S HOOD, WINDSHIELD, OR ROOF THAT SHOWS DEBRIS IMPACTED THE CAR AND CAUSED THE FAILURE.

Jul 15, 2018

2015.5 VOLVO S60 T5 DRIVE-E, LESS THAN 13K MILES. BOTH THE LEFT AND RIGHT FRONT FENDER SURFACES, JUST BEHIND THE FRONT HEADLIGHTS, ARE EXTREMELY HOT TO TOUCH AFTER NORMAL DRIVING. BENDING DOWN TO LOOK UNDER THE CAR, I HAD PUT MY HAND ABOVE THE FRONT WHEEL AND NOTICED THE FENDER AREA WAS EXTREMELY HOT TO THE TOUCH. THE CAR HAD BEEN DRIVEN NORMALLY AND WAS IN MY GARAGE AT THE TIME; THE CAR WAS NOT IN THE HOT SUN. THE AMBIENT TEMP WAS APPROX. 78F. USING A HAND HELD NON-CONTACT THERMOMETER, THE FRONT FENDER SURFACE TEMPERATURE BEHIND THE FRONT HEADLIGHTS WAS MEASURED - IT APPROACHED 140F AT BOTH FENDER SURFACES. SINCE THESE FRONT FENDERS ARE READILY ACCESSIBLE BY SMALL CHILDREN, THESE SURFACES CAN BE POTENTIALLY DANGEROUS FOR SOME TIME AFTER THE ENGINE HAS BEEN SHUT OFF. AS NOTED IN ASTM C1055, SHORT DURATION BODILY CONTACT AT 140F COULD BE POTENTIALLY DANGEROUS CAUSING 1ST DEGREE BURNS. WHEN ONE OPENS THE ENGINE HOOD, IT APPEARS THE HOT FENDER SURFACES ARE THE RESULT OF VEHICLE DESIGN. A BLACK METALLIC UPPER BODY BRACE CONNECTS THE HOT RADIATOR TO THE LEFT AND RIGHT FENDER AREAS. BASED ON THIS OBSERVATION, ONE CAN ONLY ASSUME ALL 2015.5 VOLVO S60'S HAVE THIS ISSUE AND SHOULD BE EASY TO INVESTIGATE/VERIFY. I DON'T BELIEVE THE TEMP I OBSERVED (140F) ACCOUNTS FOR WORST CASE SCENARIOS, SUCH AS UNDETECTED ENGINE FAULTS (EXCESSIVE ENG TEMPS). UNDETECTED FAULTS COULD CREATE SIGNIFICANTLY HIGHER FENDER SURFACE TEMPS. NO WARNINGS OF HOT FENDER SURFACE TEMPS WERE FOUND IN THE 2015.5 S60 OPERATING MANUAL, NOR WERE THERE ANY STICKERS IN THE CAR NOTING SUCH. NHTSA WEBSITE INDICATED THAT THE MANUFACTURER HAD NOTED EXCESSIVE TURBO COOLANT HOSE TEMPS. SINCE THIS APPEARS TO BE A DESIGN ISSUE ASSOCIATED WITH THE CAR ITSELF AND THIS IS A POTENTIAL BURN ISSUE FOR UNSUSPECTING SMALL CHILDREN, THIS COMPLAINT SHOULD BE INVESTIGATED IMMEDIATELY.

Jul 26, 2016

STRUCTURE,UNKNOWN OR OTHER

1 complaint

The child safety lock is not engaged. The door latches on the rear right passenger door in my car has failed. It fails to unlock when from the inside. In an emergency situation. Passengers won't be able to exit the vehicle quickly. The Problem can be reproduced and there are current door latch recalls in other models but it needs to extend out these models too. It has not been inspected by police but. again there is a recall for similar models. The recall should extend out to these models. No warning signs.

Jan 28, 2024

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

I bought the car as a CPO on 9/25/19 32,860 mi. On 8/19/20 at 50,052 the engine failed. The oscillating dampener rubber separated causing serpentine belt to break, which in turn got caught in timing belt which caused that to break which then caused bent valves and valves to break. The failure was sudden. Had I been on the interstate I’d be severely injured or dead. I was told that I needed a new engine but they could not find one. I was told they would completely re-build my engine. In the end they replaced the cylinder head and starter under warranty. I was never told they didn’t re-build the engine and also used “ good parts” from the old engine. In the following months I had the car in the Volvo shop (Hendricks Volvo Charleston, SC). At 50,277 miles the check engine light showed a problem with the Cam shaft position sensor on 9/3/20. They claim to have driven the car 100 miles and cleared the code w/no repairs. On 3/18/21 w/ 64,485 miles, I took the car into the dealer because it was running and idling rough. They found no codes and they aligned the car. “Couldn’t duplicate”. The right rear door never shut properly and I was repeatedly told it was fine. Re-call on latches. Seat belts on rt rear passenger constantly was stuck. This is where my granddaughter’s car seat was placed. I’ll have to skip some. At 110,024 miles on 11/28/22 the car continued to have bad gas mileage and heavy oil use. I was told that the EGR leak detection pump was faulty and was replaced. At 113,706 miles on 1/19/2023 the cam VVT Solenoid was changed. Cause of poor gas mileage stated. On 3/29/23 at 116,790 miles replaced brakes and had aligned. Service tech noticed oil under the car underside while up on racks. Said it would be fine until next service. On 7/3/23 the engine failed again on the road and was towed to the dealer. Apparently a fuel injector failed causing gas to spray into the engine causing it to lose compression. I’ve never been given a clear answer. Records of services done.

Aug 17, 2023

UNKNOWN OR OTHER,LATCHES/LOCKS/LINKAGES

1 complaint

Driver side door latch does not clamp to secure the door.

Jul 17, 2023

SERVICE BRAKES, HYDRAULIC

1 complaint

The contact owns a 2015 Volvo S60. The contact stated while driving 20 MPH, the brake pedal was depressed however, the vehicle failed to stop until the brake pedal had gone to the floorboard. There was no warning light illuminated. The vehicle was taken to the dealer, but no failure was found. The contact stated that the failure had occurred several times. The contact stated that the vehicle was test driven by the mechanic however, the cause of the failure was not yet determined. The manufacturer was made aware of the failure and no assistance was offered. The failure mileage was approximately 14,000.

Jun 09, 2023

ENGINE AND ENGINE COOLING,ENGINE

1 complaint

The contact owns a 2015 Volvo S60. The contact stated that the vehicle was previously repaired under an unknown recall for the catalytic converter and the check engine warning light illuminated. The contact was told that the catalytic converter had failed due to an oil leak. The contact was informed that the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle had exceeded the mileage. There was no additional assistance provided. The approximate failure mileage was 165,000. The dealer stated the vehicle is outside of the warranty perimeters by mileage.

May 11, 2023

VEHICLE SPEED CONTROL,SERVICE BRAKES

1 complaint

The contact owns a 2015 Volvo S60. The contact stated while driving approximately 15 MPH and slowing down for a crosswalk with pedestrians in the crosswalk, the vehicle independently accelerated while depressing the brake pedal. The contact stated that she had not noticed any warning lights being illuminated. The contact stated that the failure was intermittent. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the failure could not be duplicated. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 15,000.

Apr 28, 2023

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

Excessive Oil Consumption resulting in piston damage/failure! This vehicle has burned oil since I bought it used at about 80,000 miles. I checked the carfax prior to purchasing it and it had been maintained routinely. I have to add a liter of oil every couple of weeks. This is with regular in town driving. I have reported the issue numerous times to the Volvo dealer when I bring it in for regular maintenance and repairs. I have been told by the Volvo service advisor to just add oil. It was a known issue. Sometimes I have warning lights telling me it has low oil. I also check the oil level to know to add oil. I always check my oil level before any trip. I always keep oil in my car because of this issue. Otherwise, I have had to stop and buy oil once on a trip. Since it told me to add oil on my way back. However, one serious safety issue was having to pull off on a desert highway to add oil. The car was giving me a red warning triangle that I had never seen before. My child had to shine a light for me to see so I could add oil. She was VERY AFRAID. Although Volvo sent a letter acknowledging this vehicle problem, I have been told that I do not qualify for any warranty. I was told by Volvo service that I have a misfire/loss in power and over $5000 in repairs in Feb 2023. I have already paid for some related repairs when my check engine light came on last year. My check engine light is currently on. In the last year alone (prior to Feb 2023), I have spent over $5000 in repairs. I would have traded it in, but I kept being told how great of a car it was by the service advisor. I am sick! I do not want to continue wasting money on a car that I no longer feel safe in. I am afraid to drive it out of town.

Mar 19, 2023

AIR BAGS,FORWARD COLLISION AVOIDANCE

1 complaint

The contact owns a 2015 Volvo S60. The contact stated that while attempting to park in a parking garage, and applying the brake, her vehicle accelerated and crashed into a concrete wall, causing the air bag to deploy. The contact stated that she did apply the brake to avoid the crash, however, the brakes did not engage. The contact stated that no warning light had been illuminated at the time. The contact stated that she did sustain multiple injuries to her wrist, eyes. and ribs. The contact stated that medical attention was needed and a police report was made. The contact stated that the vehicle was then towed to a tow yard where it had been deemed a total loss. The contact stated that she then contacted the dealer who advised her to contact the manufacturer, who advised her to contact NHTSA. The failure mileage was 60,000.

May 13, 2022

Crash: 1

Injuries: 1

POWER TRAIN

1 complaint

The contact owns a 2015 Volvo S60. The contact stated that the gear shifter would not shift into gear as needed. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 86,709.

Jan 12, 2022

POWER TRAIN,UNKNOWN OR OTHER,ENGINE

1 complaint

MY S60 2015.5 ABRUPTLY CUT OFF WHEN AT A STANDSTILL "STATIONARY" IN TRAFFIC AND ON THE HIGHWAY TRAFFIC THE WARNING SYSTEM SOUND CAME ON, AS IF CLOSE TO AN OBJECT, THEN THE SCREEN FLASHED ON THEN OFF ONE TIME. WITHIN MINUTES OF A COMPLETE STOP, THE CAR CUTS OFF COMPLETELY. THE SCREEN DISPLAYED "TURN ON ENGINE." MY CAR HAD TO BE PLACED IN PARK BEFORE THE ENGINE WOULD START. THIS HAD OCCURRED AT LEAST THREE TIMES IN 2019. I WAS WONDERING IF ANYONE HAD THIS EXPERIENCE. THE ISSUE WAS UNABLE TO BE DUPICATED AND NO FAULT CODE.

Nov 23, 2020

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

LOUD SPORADIC NOISE COMING FROM GAS HOLE.*DT CONSUMER STATED VEHICLE CANNOT ACCEPT GAS.*JB

Oct 06, 2020

LATCHES/LOCKS/LINKAGES

1 complaint

TL* THE CONTACT OWNS A 2015 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V849000 (LATCHES/LOCKS/LINKAGES) HOWEVER, THE PARTS TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO GUNTHER VOLVO CARS COCONUT CREEK LOCATED AT (4350 FL-7, COCONUT CREEK, FL 33073 954-590-3760) WHERE IT WAS CONFIRMED THAT PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Feb 14, 2020

STEERING,ELECTRICAL SYSTEM,ENGINE

1 complaint

WHILE DRIVING, COMPUTER SCREENS ALL WENT BLACK AND ENGINE SHUT DOWN. IF IT HAD HAPPENED 1 MILE PRIOR, WOULD HAVE BEEN GOING 50-55 ON A CURVY TWO LANE ROAD AND WOULD HAVE RESULTED IN SERIOUS INJURY OR DEATH. TOWED TO DEALER AWAITING RESULTS.

Jan 23, 2020

FUEL/PROPULSION SYSTEM

1 complaint

THE LOW PRESSURE FUEL SENSOR ON THESE VEHICLES IS KNOWN BY MANUFACTURER TO FAIL. THIS FAILURE CAN CAUSE HARD START CONDITIONS, TAKING OVER 5 SECONDS AT TIMES TO START THE VEHICLE. THE MAIN DANGER OF THIS COMES FROM THE FACT THIS IS A VEHICLE EQUIPPED WITH AUTO STOP/START TECHNOLOGY. I HAVE EXPERIENCED NEAR MISSES DUE TO COMING TO A STOP AT A STOP SIGN AND THEN TAKING OVER 5 SECONDS ON OCCASION FOR THE VEHICLE TO RESTART THE ENGINE. ON VEHICLES WITH WORN FUEL PUMPS THIS ISSUE COULD MANIFEST AS LOSS OF POWER UNDER HEAVY ENGINE LOAD, SUCH AS CLIMBING A HILL OR ACCELERATING FROM A STOP. THE FAILURE MODE IS OPEN CIRCUIT, MEANING AT SOME POINT PRIOR TO FAILURE THERE IS ALSO A CHANCE OF HIGH RESISTANCE WHICH ON A FUEL SYSTEM COMPONENT COULD LEAD TO EXCESSIVE HEAT AND FIRE. THE MANUFACTURER IS AWARE OF THE ISSUE AND HAS ISSUED AN EXTENDED WARRANTY FOR THE PART WAS OFFERED FOR 8 YEARS 80,000 MILES. I DO NOT BELIEVE THIS IS AN APPROPRIATE RESPONSE AND A RECALL SHOULD BE ISSUED FOR THE PART DUE TO ITS SAFETY RELATED CONSEQUENCES.

Aug 12, 2019

STEERING,POWER TRAIN,WHEELS

1 complaint

BOUGHT USED VOLVO ONLY HAD 66,000 MILES ON IT 1ST SHIFTER STUCK IN PARK, THERE APPARENTLY IS A SLOT IN BEHIND SHIFTER IN THE CUBBY TO STICK KEY IN AND MANUALLY UNLOCK SHIFTER, 2ND SERIOUS WABBLE AT 50+ MPH WAS TOLD BY VOLVO IT WAS WASHER SYSTEM NEEDED IN ALL WHEEL DRIVE, THE WAS NOT THE ISSUE NEEDED DRIVERS AXEL. ONLY 1 MONTH AFTER REPLACING FRONT DRIVERS AXEL I ALREADY HEAR THE TELL TAIL CLICKING OF AXEL BEARING GONE BAD ON A NEW 750.00 AXEL, 3RD FOG / RUNNING LIGHT ON BUMPER FLICKERS OVER BUMPS. 4TH HAD THE REPLACE BEARINGS ON STRUTS ALL UNDER 70,000 MILES ON THE CAR NOT IMPRESSED VOLVO

Jun 06, 2019

TIRES,UNKNOWN OR OTHER

1 complaint

I GOT A FLAT TIRE. THE CAR IS EQUIPPED WITH A CONTINENTAL EMERGENCY TIRE INFLATOR KIT. I HOOKED IT UP AS THE INSTRUCTIONS STATED. IT DID NOT FILL THE TIRE AND EXPLODED COVERING MY CAR, INTERIOR (DOOR WAS OPEN FOR THE COMPRESSOR TO PLUG INTO CIG LIGHTER), AND MYSELF INCLUDING IN MY FACE.

Apr 25, 2019

VISIBILITY

1 complaint

SUNROOF GLASS EXPLODED WHILE DRIVING ON THE FREEWAY IN HOT WEATHER. THERE WAS NO SIGN OF A ROCK OR ANY OTHER OBJECT HITTING THE VEHICLE. I HAVE DONE MY RESEARCH AND THIS IS A KNOWN ISSUE WITH VOLVO.

Jun 21, 2018

TIRES,WHEELS

1 complaint

I WAS SOLD THIS CAR BY VOLVO OF NORTH MIAMI ON 4/11/18. I HAD TO TAKE THE CAR FOR SERVICE ON 4/13 DUE TO OTHER REPAIRS THEY DID NOT TAKE CARE OF UNDER WARRANTY TO GUNTHER VOLVO , DELRAY BEACH , FLORIDA. I WAS TOLD I SHOULD HAVE NEVER BEEN ALLOWED TO DRIVE THE CAR OFF THE LOT DUE TO THE CONDITION OF THE TIRES THAT WERE EXTREMELY DANGEROUS AND COULD HAVE CAUSED A SERIOUS ACCIDENT AND AFFECTED OTHERS. I WAS TOLD BY RICKY MENENDEZ WHO SOLD THE CAR THAT ALL THERE CARS ARE INSPECTED THOROUGHLY BEFORE BEING SOLD.

Apr 15, 2018

WHEELS

1 complaint

WE PURCHASED THIS CAR NEW FROM THE DEALER AND ITS GREAT. HOWEVER, AS I HAND WASH ALL OF OUR CARS, I COULDN'T HELP BUT NOTICE THAT THE RIGHT FRONT WHEEL ALWAYS HAS AN UNUSUAL DISCOLORATION, A MIX OF SOME KIND OF FLUID WITH THE BRAKE DUST. THE OTHER 3 WHEELS EXHIBIT ONLY THE USUAL BRAKE DUST; BUT ON THE RIGHT FRONT THIS MIX OF FLUID AND DUST DOESN'T JUST WASH OFF. ROTATE WHEELS, THE NEW WHEEL ON THE RIGHT FRONT EXHIBITS THE SAME DISCOLORATION. THE DEALER INSISTS IT IS ONLY BRAKE DUST. NOW, 2 YEARS ON, MOST OF WHATEVER FLUID WAS SECRETING TO THE RIGHT FRONT WHEEL SEEMS TO BE GONE BUT, AFTER RETRIEVING THE CAR FROM ITS 20K SERVICE, I COULDN'T HELP BUT NOTICE A RUMBLE COMING FROM THE RIGHT FRONT. SOUNDS LIKE A WHEEL BEARING TO ME (IN MY DAY, I'VE REPLACED EM). THE DEALER SAYS ITS THE TIRES; CONTINUES TO SAY THAT THE DISCOLORATION ON ONLY THE RIGHT FRONT, IS BRAKE DUST. EVEN SAID IT MIGHT BE RUST FROM THE DISC BRAKES. OK, FINE, THEN WHY NONE ON THE FRONT LEFT? OR EITHER OF THE REARS? WHY ONLY THE RIGHT FRONT. I HAVE TAKEN SWABS OF ALL 4 WHEELS AND HAVE THEM IN SEPARATE LABELED ZIP LOCK BAGS IF ANYONE WANTS TO RUN THEM THROUGH A SPECTROMETER. I'VE NEVER REPORTED ANYTHING TO THE NHTSA BEFORE BUT, IN LIGHT OF THEIR INSISTENCE THAT IT IS ONLY BRAKE DUST ... WELL, I'VE REBUILT MY SHARE OF BRAKE SYSTEMS, WORKED ON A RACE TEAM ETC., AND I'M FINDING THIS ALL A BIT INSULTING IF NOT DISMISSIVE. THIS CAR IS PRIMARILY USED AS MY WIFE'S DAILY COMMUTER (30 MILES ROUND TRIP) IN THE SUBURBS WITH AN OCCASIONAL ROAD TRIP ON THE BOOKS. *BF*JB 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

Jul 20, 2017

AIR BAGS,VEHICLE SPEED CONTROL

1 complaint

TL* THE CONTACT OWNS A 2015 VOLVO S60. WHILE DRIVING 5 MPH PULLING INTO THE GARAGE, THE VEHICLE INDEPENDENTLY ACCELERATED TO 60 MPH. THE VEHICLE CRASHED INTO THE GARAGE AND THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

Jul 06, 2016

Crash: 1

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

1 complaint

BY DEFAULT, THE AUTO STOP/START FUNCTION IS ENGAGED EVERY TIME YOU START THE 2015.5 VOVO S60. THE CAR HAS ABOUT 1,800 MILES AND WAS PICKED UP AT THE END OF AUGUST, 2015, LEASED AS NEW. MY WIFE WAS STOPPED AT A TRAFFIC LIGHT, ON A RELATIVELY FLAT ROAD. THE CAR TURNED OFF THE ENGINE USING THE AUTO-STOP/START. WHEN SHE TOOK HER FOOT OFF THE BRAKE AND PUT IT ON THE ACCELERATOR, THE CAR TURNED OFF COMPLETELY. THE DASH TURNED OFF. SHE HAD TO PUT ON HER HAZARD WARNING LIGHTS, PUT THE CAR INTO PARK AND PRESS THE STOP/START BUTTON TO START THE CAR. SHE THEN WAS ABLE TO PUT IT BACK INTO DRIVE AND CONTINUE. THIS IS NOT HOW THIS IS SUPPOSED TO FUNCTION. THIS REPRESENTS A VERY SERIOUS PROBLEM THAT COULD RESULT IN SOMEONE GETTING REAR-ENDED OR NOT BEING ABLE TO ACCELERATE FROM A STOP IN AN EMERGENCY SITUATION--IMAGINE IF AN AMBULANCE, FIRETRUCK OR POLICE CAR WAS COMING THROUGH AND YOU HAD TO MOVE THROUGH AN INTERSECTION OR TO THE SIDE OF THE ROAD BUT THE CAR DIED?

Nov 12, 2015

4.2/5.0

85 reviews

Where to Find VIN for Problems Check

To check for problems and complaints on your 2015 VOLVO S60, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 2015 VOLVO S60 for Problems Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Problem Reports

Each character in your 2015 VOLVO S60 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.

2015 VOLVO S60 VIN Structure for Complaint Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 2015 VOLVO S60 Problems in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 2015 VOLVO S60 dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Review by Component

Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.

Check Safety Issues

Review crash and fire incidents for each component to assess safety concerns. Contact your VOLVO dealer or report problems to NHTSA at SaferCar.gov.

Frequently Asked Questions

How many problems does the 2015 VOLVO S60 have?

The 2015 VOLVO S60 currently has 55 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2015 VOLVO S60?

The most common problems reported for the 2015 VOLVO S60 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2015 VOLVO S60 problem data come from?

All problem and complaint data for the 2015 VOLVO S60 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

How do I report problems with my 2015 VOLVO S60?

You can report safety problems with your 2015 VOLVO S60 directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.

Where can I find my VIN to check problems?

Your 2015 VOLVO S60 VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

Is the 2015 VOLVO S60 reliable?

Reliability can be assessed by reviewing the number and severity of owner complaints for the 2015 VOLVO S60. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.