How many problems does the 2001 VOLVO S80 have?

The 2001 VOLVO S80 currently has 180 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2001 VOLVO S80?

The most common problems reported for the 2001 VOLVO S80 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2001 VOLVO S80 problem data come from?

All problem and complaint data for the 2001 VOLVO S80 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

2001 VOLVO S80 Problems

VEHICLE SPEED CONTROL

48 complaints

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED THAT THE RPMS BEGAN TO FLUCTUATE ABNORMALLY AS THE VEHICLE EXHIBITED SIGNS OF POSSIBLE STALLING. THE VEHICLE THEN ACTIVATED IN LIMP MODE AND STOPPED RUNNING. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER: 06V441000 (VEHICLE SPEED CONTROL) THAT DEALT WITH THE DIRTY THROTTLE HOUSING. THE RECALL REPAIR CONSISTED OF A SOFTWARE UPGRADE TO CORRECT THE FAILURE. THE MANUFACTURER STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL, BUT THE VEHICLE EXCEEDED THE WARRANTY STIPULATIONS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 87,000.

Jul 18, 2012

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED WHILE DRIVING 40 MPH THE VEHICLE SHIFTED INTO LIMP MODE AND DECELERATED AFTER THE CHECK ENGINE LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ELECTRONIC THROTTLE MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 170,200.

Feb 09, 2012

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE BEFORE RESPONDING TO ACCELERATION ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT THE THROTTLE MODULE HAD FAILED AND NEEDED TO BE CLEANED AND REPLACED. THE THROTTLE WAS CLEANED BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AFTER THE CLEANING SO THE THROTTLE WAS NOT REPLACED. THE FAILURE RECURRED WITHIN A FEW WEEKS. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. UPDATED 09/27/11 *BF UPDATED 09/30/11

Sep 09, 2011

MY CHECK ENGINE LIGHT WENT ON. I TOOK MY CAR TO MY MECHANIC WHO INFORMED ME THE CODE WAS FOR THROTTLE BODY POSITION SENSOR AND THAT THERE WAS A RECALL. I CALLED THE VOLVO DEALER AND ASKED THEM ABOUT IT. THEY SAID, YES THERE WAS A RECALL FOR SOFTWARE AND THAT MY VEHICLE HAD GOTTEN THE UPGRADE. I ASKED IF THERE WAS ANYTHING ELSE THEY COULD DO ABOUT IT, THE EMPLOYEE IN VOLVO SERVICE SAID NO. I RECEIVED THE SAME ANSWER WHEN I ASKED THEM IN PERSON. ON MARCH 1, 2011, NEARLY A YEAR LATER, I ASKED ANOTHER MECHANIC, WHO INFORMED ME THAT IF THE SOFTWARE UPGRADE DIDN'T WORK, THE DEALER WAS SUPPOSED TO REPLACE THE ENTIRE THROTTLE BODY. I CALLED THE ANOTHER VOLVO DEALER WHO INFORMED ME THAT YES, THIS WAS THE CASE. MY CAR WAS ONE DAY OUT OF COVERAGE FOR THE RECALL NOW. AND SOMETIME WITHIN THE YEAR MY COMPUTER WAS RESET AND THE PROBLEM CODE FOR THE THROTTLE BODY IS GONE. I AM UPSET BECAUSE WHEN IT WAS A PROBLEM FOR ME, THE FIRST DEALER GAVE ME THE INCORRECT INFORMATION ABOUT THE RECALL. I WAS DRIVING FOR A LONG TIME WITH MY CAR IN LIMP MODE AND A MALFUNCTIONING THROTTLE BODY. I AM SURE THAT THE DEALER WAS OBLIGATED TO REPLACE THE THROTTLE BODY, SINCE IT IS PART OF THE ACCELERATION SYSTEM. I THINK YOU SHOULD COMPEL THEM TO REPLACE MY THROTTLE BODY OR GUARANTEE REPLACEMENT IF MY THROTTLE BODY MALFUNCTIONS AGAIN. *TR

Mar 20, 2011

WHILE TRAVELING AT 25 MPH, I APPLIED BRAKES TO STOP ABOUT 30-35 FEET BEHIND ANOTHER VEHICLE, WHEN MY VEHICLE SUDDENLY ACCELERATED (WITH MY FOOT ON THE BRAKES AND) AND LAUNCHED FORWARD AND STRUCK THE VEHICLE AHEAD OF ME, CAUSING INJURY TO THE DRIVER AND THE PASSENGER AND RESULTED IN A LAWSUIT AGAINST ME. THE LAWSUIT IS SET FOR TRIAL ON NOVEMBER 30, 2009. *TR

Aug 09, 2009

Crash: 1

+ 43 more complaints for this component

ELECTRICAL SYSTEM

31 complaints

TOOK CAR TO GET THROTTLE BODY CLEAN AND IT DID NOT RESOLVE ISSUES WITH CAR. *TR

Sep 21, 2009

MY ETM ON VOLVO S80, T6 MODEL (YEAR 2001) HAS A RECALL ON IT ISSUED BY VOLVO BUT THE PROBLEM IS THAT THIS PART ALONG WITH THE THROTTLE BODY IS DEFECTIVE AND NEEDS CONSTANT COMPUTER UPDATE, AND THAN THE ETM FAULTS WITHOUT NOTICE AND TAKES WITH IT THE WHOLE INFRASTRUCTURE DESPITE ETM BEING SERVICED AND NEW SOFTWARE BEING INSTALLED BY DEALER. THE DEALER IS NOT ALWAYS KEEN ON WORKING ON ETM OR THROTTLE BOTTLE ISSUES AS THEY DON'T GET PAYMENT ON TIME FROM VOLVO AND THEY NEED TO DO A LOT OF PAPER WORK TO ET PAID BY VOLVO USA. THE CAR STALLS SUDDENLY AND ONE OF THESE DAYS I AM AFRAID THIS WILL LEAD TO A MAJOR CRASH AS GOV.'T CAN'T STOP WHAT VOLVO USA WANTS TO ACCOMPLISH AND THAT IS PROFITS AND NOT RECALLING THEIR DEFECTIVE EQUIPMENT. HUMAN LIVES ARE SECOND TO CORPORATE PROFITS HAS ALREADY BEING NOTED AD SHOWN. *TR

Jun 29, 2009

TL*THE CONTACT OWNS A 2001 VOLVO S80. WHILE DRIVING 55 MPH DOWNHILL, THE CONTACT SMELLED BURNING AND SAW SMOKE. THE VEHICLE HAD NO ACCELERATION, POWER STEERING, OR BRAKE FUNCTION. THE CONTACT APPLIED THE EMERGENCY BRAKE TO STOP THE VEHICLE. ALL OF THE WARNING INDICATOR LIGHTS ILLUMINATED. THE VEHICLE BURST INTO FLAMES FIFTEEN SECONDS AFTER STOPPING. THE VEHICLE WAS TOWED. THE VOLVO INVESTIGATORS STATED THAT THE FIRE WAS CAUSED BY BIRD SEED DEPOSITS UNDERNEATH THE HOOD. THE CURRENT AND FAILURE MILEAGES WERE 56,000.

Jun 18, 2007

Fire: 1

I PURCHASED MY VOLVO S80 NOT EVEN 1 YEAR AGO AND I AM EXPERIENCING PROBLEMS WITH MY CAR LOSING ACCELERATION IN TRAFFIC AND IDLING WILDLY. THE PROBLEM HAS BECOME SO SEVERE THAT AT ONE POINT AT A COMPLETE STOP, MY CAR SURGED FORWARD AND HIT THE CAR IN FRONT OF ME! THANK GOODNESS THERE WAS NO DAMAGE OR INJURIES TO MYSELF OR TO THE CAR INVOLVED. I TOOK THE VEHICLE TO THE DEALERSHIP AND WAS INFORMED THE PROBLEM LIES WITH THE THROTTLE. HOWEVER, VOLVO REFUSES TO ISSUE A RECALL AND HIDES BEHIND THE "WARRANTY" SONG AND DANCE EVEN THOUGH THEY AGREE THERE IS A PROBLEM WITH THE THROTTLES IN THEIR VEHICLES. I DID MUCH RESEARCH (OR SO I THOUGHT) BEFORE PURCHASING MY VEHICLE. I CHOSE VOLVO BECAUSE THEY ADVERTISE THE FACT THAT THEY MANUFACTURE ONE OF THE SAFEST CARS ON THE MARKET. MY WIFE OWNS A VOLVO S60 AND HAS HAD SIMILAR PROBLEMS. I FEAR FOR THE SAFETY OF MY WIFE AND 6 YEAR OLD SON. I PLAN TO GET RID OF THIS DANGEROUS VEHICLE FIRST CHANCE I GET. *NM

Dec 12, 2006

Crash: 1

FOR 6-12 MONTHS MY WIFE HAS COMPLAINED OF SURGING OR LOSS OF POWER IN OUR 2001 VOLVO T6 S80 (MILEAGE 56,000 MILES). ON 9/10/2006 WHILE DRIVING AT 35/MPH IN TRAFFIC I HAD COMPLETE LOSS OF POWER. I WAS ABLE TO COAST TO RT. SIDE OF HIGHWAY AND RESTART AFTER SHIFTING TO PARK. LOCAL DEALER FOUND NOTHING WRONG. SCARY FOR I-40. *NM

Sep 21, 2006

+ 26 more complaints for this component

ENGINE AND ENGINE COOLING

16 complaints

HESITATION, SURGING, LOSS OF POWER, ETC. THIS CAR RUNS SO ERRATICALLY THAT I AM EVEN AFRAID TO CHANGE LANES IN TRAFFIC BECAUSE I AM JUST AFRAID THAT IT IS GOING TO STOP RIGHT IN THE MIDDLE AND I AM GOING TO BE HIT BY THE CAR BEHIND ME. I AM AFRAID TO STOP AT TRAFFIC LIGHTS BECAUSE THE CAR WONT ACCELERATE AND RUN NORMALLY THEREFORE ILL HAVE UPSET DRIVERS IN BACK OF ME WAITING UNTIL THE CAR DECIDES TO MOVE FORWARD. THIS IS VERY DANGEROUS ESPECIALLY WHEN YOU ARE DRIVING WITH A LOT OF TRAFFIC AROUND YOU. I HAVE TAKEN IT TO THE DEALER BUT THEY JUST SAY THAT IF THERE ARE NO MESSAGES OR CODES THEY CANNOT DO ANYTHING ABOUT IT BECAUSE VOLVO WONT REIMBURSE THEM FOR THE EXPENSE. THIS ERRATIC BEHAVIOR HAS BEEN HAPPENING MORE AND MORE OFTEN AND I DON'T BELIEVE IT HAS BEEN A DAY THAT HAS NOT HAPPENED SINCE IT FIRST STARTED. I HAVE HAD AN UPGRADE, A CLEANING BUT NO REPLACEMENT IN SIGHT. *TR

Oct 31, 2008

I WAS DRIVING APPROX. 65 MILES AN HOUR ON I395 AND I WAS IN THE PASSING LANE. I WENT TO ACCELERATE AND MOVE INTO THE TRAVEL LANE AND I WAS NOT ABLE TO ACCELERATE. MY SPEED STARED TO REDUCE AND ALL OF THE POWER SHUT OFF IN THE VEHICLE. NO WARNING LIGHTS CAME ON AND NO INDICATION ON WHAT THE CAR WAS SHUTTING DOWN. I CHECKED FOR VEHICLES BEHIND ME AND AROUND ME AND PUT ON MY HAZARD LIGHTS. I QUICKLY PULLED OFF OF THE BUSY HIGHWAY AND MANAGED TO STOP AT THE SIDE OF THE ROAD (MIDDLE OF THE HIGHWAY - NEXT TO THE MEDIAN). THE POLICE HAD SEEN ME PULL OVER AND CALLED A WRECKER SERVICE. THE CAR WAS BROUGHT TO THE PLACE WHERE I PURCHASED THE VEHICLE (FOREIGN MOTORS EAST IN BROOKLYN, CT) AND THEY KEPT THE CAR FOR THE NEXT 3 DAYS. THEY WERE UNABLE TO DETERMINE THE CAUSE AND THIS JUST HAPPENED AGAIN LAST MONTH (JUNE 20TH 2007). IT WAS THE SAME CONDITIONS...DRIVING ON I395 WHEN THE ACCELERATION STOPPED AND THE CAR STARTED TO SLOW DOWN. I PULLED THE CAR OVER AND TURNED OFF THE CAR. I WAITED 2 MINUTES AND TURNED THE KEY AGAIN AND THE CAR WAS FINE. I DROVE THE NEXT 45 MINUTES WITH NO ISSUES. *TR

Jul 24, 2007

TL* - THE CONTACT CALLED REGARDING THE 2000 VOLVO S80. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT AND THE EMISSION SERVICE LIGHT KEPT TURNING ON, THE FAILURE MILEAGE WAS 32,000. THE LOCAL VOLVO DEALER REFUSED TO DIAGNOSE THE VEHICLE BECAUSE OF PAST PROBLEMS REGARDING THE BILL. THE CONTACT STATED THAT THERE WERE NO OTHER VOLVO DEALERS IN HIS AREA. THE CURRENT MILEAGE WAS 55000. FAILURE MILEAGE WAS 32,000. *AK UPDATED 03/19/07. *JB

Feb 15, 2007

Crash: 1

2001 VOLVO S80 T6. VEHICLE STALLS WITHOUT WARNING WHEN ACCELERATOR IS RELEASED AND VEHICLE RETURNS TO IDLE. PROBLEM WAS FIXED ONCE BUT HAS RETURNED. DEALER & VOLVO N.A. SAY THAT SINCE THERE IS NO COMPUTER CODE FOR THE STALL AND THEY CAN'T DUPLICATE IT THERE IS NO CURE. VEHICLE HAS STALLED ON NUMEROUS OCCASIONS DURING THE LAST 5 MONTHS INCLUDING 12/17/2006 IN HEAVY TRAFFIC THE HOV LANE ON THE LONG ISLAND EXPRESSWAY. HAS ALSO STALLED IN HIGH SPEED TRAFFIC ON I95 IN STAMFORD, CT AND WHILE MAKING TURNS AND GOING THROUGH INTERSECTIONS. *JB

Dec 20, 2006

DT*: THE CONTACT STATED WHILE IN STOP AND GO TRAFFIC THE VEHICLE STALLED THREE TIMES. THE VEHICLE RESTARTED EACH TIME AND WAS TAKEN TO THE DEALERSHIP FOR THE 60,000 MILES CHECKUP. ALTHOUGH THERE WERE NO CODES ON THE COMPUTER, THE DEALERSHIP PERFORMED A SOFTWARE UPDATE FOR THIS PROBLEM. UPDATED 4/19/2006 - 25 MILES AFTER THE 60000 MILE CHECK UP THE VEHICLE STALLED AGAIN AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE VEHICLE HAS NOT STALLED AGAIN SINCE THE SOFTWARE UPDATED WAS PERFORMED. *NM

Mar 17, 2006

+ 11 more complaints for this component

FUEL SYSTEM, GASOLINE

14 complaints

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 09V483000 (FUEL SYSTEM; GASOLINE; DELIVERY; FUEL PUMP) AND WAS TOLD THAT THE VEHICLE COULD NOT BE REPAIRED UNDER THE RECALL BECAUSE IT HAD BEEN TEN YEARS SINCE THE VEHICLE WAS MANUFACTURED. THE RECALL WAS ISSUED DECEMBER 7, 2009. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CURRENT MILEAGE WAS 65,000.

Dec 29, 2011

TL*THE CONTACT OWNS A 2001 VOLVO S80 T6. WHILE DRIVING APPROXIMATELY 25 TO 30 MPH THE CONTACT STATED THAT HE SMELLED FUEL INSIDE THE VEHICLE. HE DROVE HOME AND HAD NOT DRIVEN THE VEHICLE SINCE THE FAILURE OCCURRED. THE VEHICLE WAS PREVIOUSLY OWNED AND PURCHASED ONE WEEK AGO. THE CONTACT CALLED THE DEALER AND THE MANUFACTURER AND WAS ADVISED THAT THE VEHICLE WAS NOT A PART OF NHTSA RECALL CAMPAIGN ID NUMBER: 09V483000, FUEL SYSTEM, GASOLINE DELIVERY, FUEL PUMP. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 155,000.

Jul 20, 2010

2001 S80 VOLVO ETM FAILURE. IT STARTED AS VEHICLE HESITATION, THEN PROCEEDED TO SURGING FORWARD WITH NO THROTTLE INPUT, THEN PROGRESSED TO NO ACCELERATOR RESPONSE WHEN APPLYING THE BRAKE PEDAL, THEN TO STALLING WHEN COASTING LEAVING THE DRIVER WITH NO POWER STEERING OR BRAKES AT SPEEDS UP TO 55 MPH, THEN TO ROUGH IDLE AND CHECK ENGINE LIGHT. ALL SYMPTOMS WERE PRESENT UPON TAKING TO THE DEALER BASED ON SOME WEB RESEARCH TO IDENTIFY TO PROBLEM. THE DEALER RETURNED WITH AN ANALYSIS FOR TIMING BELT REPLACEMENT, ENGINE TUNE UP, ENGINE COOLANT FLUSH, CRANKCASE VENTILATION SYSTEM CLEANING, BRAKE SYSTEM FLUSHING, AND MASS AIR FLOW REPLACEMENT AMOUNTING TO AN INITIAL COST OF $1980.00 US. I REQUESTED A CONFERENCE WITH THE TECHNICIAN, AND A REVIEW OF THE DIAGNOSTICS REPORT. THE END RESULT WAS A MAF REPLACEMENT PAID FOR BY ME (CUSTOMER) AND AMAZINGLY THE TECH NOTES RECOMMENDED CLEANING OF THE CRANKCASE VENTILATION SYSTEM AND THE ETM CLEANING WHICH WAS COVERED BY THE DEALER. TOTAL COST WAS $328.21 TO CONSUMER AND BALANCE COVERED BY DEALER. THE REPAIRS WERE MADE ON 3/07/06, REPLACED MAF UNAVAILABLE. I FEEL THAT I HAVE BEEN TAKEN ADVANTAGE OF AND ESSENTIALLY PAID $328 UNNECESSARILY DUE TO FURTHER WEB RESEARCH IDENTIFYING CLEANING OF THE ETM AND CRANKCASE VENTILATION SYSTEM WOULD IN FACT CAUSE TROUBLE CODES LEADING THE REPLACEMENT OF THE MAF. *JB

Mar 26, 2006

I OWN A 2001 VOLVO S-80. THERE IS A DANGEROUS PROBLEM WITH THIS CAR . IT INVOLVES THE ELECTRONIC THROTTLE MODULE (ETM). THE CAR AT TIMES WILL NOT MOVE EVEN THOUGH THE ENGINE IS RUNNING AND THE CAR IS IN GEAR. IT JUST WILL NOT MOVE. PARTICULARLY WHEN TRYING TO MOVE INTO TRAFFIC. I AM AWARE THROUGH MY READING OF THE FACT THAT THERE ARE HUNDREDS OF THOUSANDS OF VEHICLES WITH THE SAME PROBLEM. VOLVO KNOWS ABOUT THIS BUT TO DATE HAS DONE NOTHING TO CORRECT IT. I ALSO KNOW THAT NHTSA IS INVESTIGATIONS THE PROBLEM AND I WANTED TO LIST MY NAME WITH YOU FOR A COMPLAINT ON THIS. *JB

Nov 30, 2005

WEEK OF 10/10/05 AS TRAVELING UPHILL, MY CAR SPUTTERED AND LOSS POWER. AFTER NEARLY BEING REAR ENDED ON THE BUSY ROAD, I WAS ABLE TO LIMB MY CAR INTO A PARKING LOT AND TURN OFF THE ENGINE. AFTER A FEW MINUTES, I WAS ABLE TO RESTART MY CAR AND CONTINUE DRIVING. TODAY, 10/18/05, AS I WAS ENTERING I-85, MY CAR ONCE AGAIN SPUTTERED AND STALLED. THE ENTRANCE RAMP WAS DOWNHILL, SO I WAS ABLE TO COAST INTO THE EMERGENCY LANE AS TRACTOR TRAILERS AND CARS WHIZZED BY ME. I RESTARTED THE CAR AFTER A FEW MINUTES OF BEING TURNED OFF. I WENT TO A MECHANIC FRIEND AND HE TOLD ME THAT IT WAS PROBABLY THE ETM AND IF IT WAS NOT, IT WOULD BE THE NEXT TIME THE CAR BREAKS DOWN. HE COULD NOT REPAIR IT. HE ESTIMATED THE DEALERSHIP WOULD CHARGE ME $1200.00. HE REPORTED THAT HE SEES THIS AT LEAST ONCE A MONTH IN VOLVOS. I TOOK THE CAR TO THE DEALER. AN HOUR AND A HALF LATER, I WAS INFORMED MY ETM NEEDED TO BE REPLACED AND THE COST WOULD BE $1150.00. I RELUNCTANTLY AGREED TO THE REPAIR. I HAVE RESEARCHED THE ETM PROBLEM OVER THE INTERNET AND HAVE LEARNED THAT VOLVO KNEW OF THIS PROBLEM YEARS BEFORE THEY SOLD THE CAR TO ME. AT A PERSONAL LEVEL, I HAD TO PAY FOR A DEFECTIVE PART THAT VOLVO HAS KNOWN IT HAS A 94%-100% FAILURE RATE! AT A MUCH HIGHER LEVEL, VOLVO IS RISKING PEOPLE LIVES BY NOT INFORMING OR VOLUNTARILY RECALLING THIS DEFECTIVE PART. CARS STALL UNEXPECTIVELY. I WAS FORTUNATE THAT I WAS NOT ON THE INTERSTATE YET. OTHERWISE, THE OUTCOME COULD HAVE BEEN DEADLY.

Oct 18, 2005

+ 9 more complaints for this component

POWER TRAIN

8 complaints

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED THAT THE TRANSMISSION URGENT WARNING LAMP ILLUMINATED AND THE VEHICLE WOULD NOT SHIFT INTO GEAR. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE SOLENOID WAS DEFECTIVE AND THE TRANSMISSION WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 126,741. UPDATED 3/1/12 *CN

May 24, 2011

2001 VOLVO S 80 T6 EX TRANSMISSION FAILURE. BASED ON PERSONAL RESEARCH IT APPEARS THAT THE 2001 VOLVOS HAVE A WIDESPREAD PROBLEM WITH TRANSMISSION FAILURE. TRANSMISSIONS WERE BUILT BY GM FOR VOLVO AND TRANSMISSION PROBLEMS ACROSS THE ENTIRE LINE FOR THAT YEAR ARE EXTREMELY HIGH. IS THERE OR CAN THERE BE AN INVESTIGATION OF THIS PROBLEM. IT APPEARS TO ENCOMPASS THE ENTIRE LINE FOR THAT YEAR. *TR

Sep 30, 2010

I HAVE A 2001 VOLVO S80 T6 WITH 61000 MILES. WITHIN THE LAST TWO WEEKS IT FELT AS THOUGH THE CAR WAS "SLIPPING" OUT OF GEAR ON SEVERAL OCCASIONS... THE RPMS WOULD FLAIR THEN NORMALIZE. YESTERDAY THE CAR JUST QUIT MOVING. IT WAS TOWED TO THE VOLVO DEALER AND I WAS JUST TOLD THE TRANSMISSION IS SHOT AND WOULD COST $4000 TO REPLACE WITH A REMANUFACTURED ONE. MY PROBLEM DOES NOT SEEM TO BE AN ISOLATED INCIDENT. I'VE FOUND THAT ITS WELL KNOWN THE TRANSMISSION IS A PROBLEM AND SINCE THEY TEND TO FAIL AFTER 50000 MILES, VOLVO'S WARRANTY IS EXPIRED. NOW I'M STUCK WITH PUTTING THE SAME WORTHLESS TRANSMISSION BACK INTO THE VEHICLE ONLY TO EXPECT IT TO FAIL AGAIN IN THE FUTURE. VOLVO NEEDS TO RECALL THE TRANSMISSION OR EXTEND THE WARRANTY TO AT LEAST 100000 MILES. *JB

Sep 11, 2007

WHILE DRIVING ON AN INTERSTATE HIGHWAY AT 65-70 MPH, MY 2001 VOLVO S80 T6 DISPLAYED A MESSAGE INDICATING "REDUCED POWER". I WAS ABLE TO STEER THE CAR, BUT PUSHING THE ACCELERATOR PEDAL HAD NO EFFECT. I WAS FORCED TO MANEUVER TO THE SHOULDER AND HAVE THE CAR TOWED TO MY LOCAL DEALER. THE CAR WOULD START AND CONTINUE TO RUN, BUT THE CAR WOULD NOT "GO". IT WAS AS IF THE ACCELERATOR PEDAL HAD BEEN DISCONNECTED. THIS WAS ACTUALLY THE SECOND TIME THAT THIS HAS HAPPENED TO THIS CAR. THE FIRST OCCURRED A MERE 20 MONTHS EARLIER. THE VOLVO MECHANIC INDICATED - DURING BOTH INCIDENTS - THAT THE ELECTRONIC THROTTLE CONTROL MODULE HAD FAILED AND WOULD NEED TO BE REPLACED. MY CAR WAS NOT UNDER WARRANTY EITHER TIME - HAD JUST EXCEEDED WARRANTY MILEAGE WHEN THE FIRST INCIDENT HAPPENED. IN ADDITION TO BEING PUT INTO A DANGEROUS SITUATION ON A CROWDED INTERSTATES HIGHWAY, I WAS FORCED TO PAY MORE THAN $1000 TO HAVE THE PART REPLACED EACH TIME. *NM

Aug 02, 2005

THIS CAR WAS STUCK IN PARK. WE COULD NOT SHIFT THE CAR OUT OF PARK INTO DRIVE. WE WERE STUCK IN A LINE OF TRAFFIC AND IT WAS A DANGEROUS INCIDENT. WE REPEATEDLY CORRECTLY DEPRESSED THE BUTTON ON THE GEAR SELECTOR KNOB AND AND AT THE SAME TIME DEPRESSSED THE BRAKE PEDAL ( WE HAVE DONE THIS THOUSANDS OF TIMES ON THIS VEHICLE FROM 2001 TO PRESENT WITHOUT ANY PROBLEMS) . IT TOOK OVER 15 MINUTES OF TURNING OFF THE ENIGINE AND RESTARTING IT, TURNING THE STEERING BACK AND FORTH TO FINALLY GET IT OUT OF PARK INTO DRIVE. WE ARE FULLY AWARE OF THE BRAKE SHIFT INTERLOCK SAFETY FEATURE. THIS INCIDENT WAS THE RESULT OF EQUIPMENT MALFUNCTION AND NOT OPERATOR ERROR. MY WIFE AND I EACH STRUGGLED TO FINALLY GET IT FROM PARK TO DRIVE. THIS IS A REAL EQUIPMENT PROBLEM THAT NEEDS TO BE INVESTIGATED AND CORRECTED. MY WIFE AND I BOTH DRIVE VOLVOS AND ARE EXPERIENCED VOLVO DRIVERS. ANY SUGGESTION OF OPERATOR ERROR IS FRIVOLOUS DEFENSE.*AK

Dec 05, 2004

+ 3 more complaints for this component

VISIBILITY

6 complaints

BOTH FRONT POWER WINDOW REGULATORS FAILING. *TR

Dec 02, 2010

TL* THE CONTACT OWNS A 2001 VOLVO S-80. THE CONTACT STATED AFTER HAVING THE BATTERY REPLACED, THE CLIMATE CONTROL UNIT BECAME INOPERABLE. THE DEALER WAS UNABLE TO RESET THE UNIT AND ADVISED IT WOULD NEED TO BE REPLACED. THE CONTACT BELIEVED THE MANUFACTURER SHOULD TAKE THE LIABILITY FOR THE FAILURE WHICH COULD POTENTIALLY BECOME A SAFETY ISSUE WHEN TRYING TO DEFOG THE WINDOWS, DISRUPTING VISIBILITY. THE FAILURE MILEAGE WAS 74,610 AND THE CURRENT MILEAGE WAS 74,665.

May 10, 2010

I WAS GOING THROUGH AN AUTOBUFF'S CARWASH IN DOUGLASVILLE, GA AND MY SUNROOF IMPLODED! I TOOK MY CAR TO VOLVO AND THEY SAID THAT THEY WOULD ONLY COVER THE GLASS, NOT THE LABOR, NOR THE CRACKED WINDSHIELD, ETC. THERE ARE MORE THAN 81 OTHER PERSONS WHO HAVE HAD THIS ISSUE WITH THEIR VOLVO, AND YET VOLVO DOES NOT CHOOSE TO CONSIDER IT A NECESSARY RECALL. IT IS A SAFETY HAZARD, AND I WANT SOMETHING TO BE DONE ABOUT IT AS SOON AS POSSIBLE. *TR

Jan 21, 2009

Injuries: 2

TL*THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED THAT THERE WAS A COLOR DIFFERENTIAL ON THE REARVIEW MIRROR, WHICH MADE VISIBILITY DIFFICULT. THE DEALER STATED THAT THE COMPUTER WAS THE CAUSE OF THE FAILURE. AS OF JULY 5, 2007, THE REARVIEW MIRROR HAS NOT BEEN REPAIRED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE IS 87,400 AND FAILURE MILEAGE WAS 87,200.

Jul 05, 2007

CONSUMER WAS REFUSED RENTAL VEHICLE WHILE 2001 VOVLO S80 WAS HAVING RECALL WORK DONE. CONSUMER HAS HAD PROBLEMS WITH FAULTY FUEL SENDING UNIT. *TS ****NO ANSWER REQUIRED*** THE CONSUMER STATED IT TOOK 4 TIMES TO FINALLY GET A WINDOW LIFT MOTOR REPLACED. *JB

Jan 09, 2006

+ 1 more complaint for this component

VEHICLE SPEED CONTROL,EQUIPMENT

5 complaints

2001 S80, MULTIPLE FAILINGS OF THE ELECTRONIC THROTTLE MODULE. THIS HAS HAPPENED REPEATEDLY OVER THE LAST 2 WEEKS. TOO MANY TIMES TO COUNT. CAR W/O NOTICE WILL NOT ACCELERATE BEYOND 20 MPH, IDLES ROUGHLY. HAS ALMOST CAUSED SEVERAL ACCIDENTS.*AK

Jan 23, 2006

MY 2001 VOLVO S-80 SUDDENLY LOST ALL POWER AND CAME TO A STOP AND WOULD NOT RESTART. THIS OCCURRED IN SEPT. 2003. THE DEALERSHIP, BEACH VOLVO IN MYRTLE BEACH, SC, WANTED OVER $600 TO REPAIR THE AUTO SINCE IT WAS BEYOND THE 50,000 MILE WARRANTY. IT HAD 60,000 MILES AT THE TIME. AFTER A LENGTHY DISCUSSION WITH VOLVO AMERICA, THEY AGREED TO SPLIT THE COST BETWEEN MYSELF, THE DEALERSHIP AND VOLVO AMERICA. THE ELECTRONIC THROTTLE BODY WAS REPLACED. ON 12/05/05 THE SAME THING HAPPENED. THE CAR NOW HAS 82,700 MILES. IT IS BEING LOOKED AT BY BEACH VOLVO AT THIS MOMENT. *NM

Dec 06, 2005

WHILE DRIVING LOST STEERING POWER AND ENGINE COMPLETELY SHUT DOWN, UNSAFE ON THE TURNPIKE, I SCARED. TOOK CAR TO DEALERSHIP WHILE UNDER WARRANTY REPLACED THROTTLE UNIT. CAR SHUT DOWN AND LUNGES FORWARD AT A LIGHT/TOOK TO DEALER AND FIXED RESET VALVE STICKING AND GASKET HAPPENED AGAIN REPLACED BOX AND PIPE REMOVED TRAP BOX IN PIPE, SHUT DOWN AGAIN REPLACED DID TOTAL CAN UP GRADE FAILED AGAIN. UNTIL TODAY CAR STILL SHUTS DOWN VERY DANGEROUS THIS CAR IS A DEATH TRAP AND MY WARRANTY IS OVER AND THEY WANT TO PAY 3,000.00 DOLLARS TO FIX, I FEEL THEY ARE RESPONSIBLE THEY SOLD ME A LEMON AND A VERY DANGEROUS CAR. AND THE CUSTOMER SERVICE OF VOLVO CLAIM THEY CARE ABOUT CUSTOMER SERVICE VERY UNTRUE THEY GOT YOUR MONEY AND THE DON'T CARE MY PROBLEMS STILL EXIST AND I GET SCARED JUST GETTING INTO THIS CAR. *NM

Oct 14, 2005

I OWN A 2001 VOLVO S80. I HAVE HAD TROUBLE WITH THE ELECTRONIC THROTTLE MODULE NOT RESPONDING TO THE THROTTLE INPUTS AND SURGING AT IDLE. IT WOULD SOMETIMES KILL THE CAR WITHOUT WARNING WHEN COMING TO A STOP (LOSING POWER-STEERING WHILE IN TURNS) OR MAKE THE CAR LUNGE FORWARD UNEXPECTEDLY. THE LUNGING FORWARD HAS ALMOST CAUSED ACCIDENTS AT INTERSECTIONS. I'VE BEEN LUCKY FOR NOW, BUT I WILL NOT LET MY WIFE DRIVE THE CAR WHILE IT IS DOING THIS BECAUSE SHE MAY NOT BE ABLE TO CONTROL THE CAR WITHOUT POWER STEERING AND BRAKES. I TOOK IT IN FOR REPAIR AND THEY TOLD ME THAT IT WAS THE ELECTRONIC THROTTLE MODULE, AND THEY NEED REPLACING AFTER A WHILE, SO I REPLACED IT. 4 MONTHS LATER, I'M EXPERIENCING THE SAME IDLE PROBLEMS AS WELL AS THE LUNGING PROBLEMS. I AM BEING TOLD THAT IT IS THE SAME PROBLEM WITH THE THROTTLE MODULE. I'VE LOOKED AT MANY WEBSITE FORUMS AND FOUND MANY OTHER PEOPLE HAVE THE SAME PROBLEM THROUGH OUT THE GLOBE. THERE HAVE ALSO BEEN TIMES WHEN IT HAS DIED WHILE IN REVERSE AND I LOOSE POWER BRAKES WHILE BACKING, WITHOUT NOTICE. I WOULD REQUEST A RECALL AND AN IMPROVED PART. USA TODAY IS ALSO REPORTING ON THIS ISSUE AS WELL: HTTP://YAHOO.USATODAY.COM/MONEY/AUTOS/2005-08-01-VOLVO_X.HTM?CSP=1 FORUM WEB SITE: HTTP://WWW.VOLVOXC.COM/FORUMS/SHOWTHREAD.PHP?MODE=HYBRID&T=6026 THANK YOU FOR YOUR TIME. *NM

Aug 30, 2005

I WAS ON THE RAMP GETTING ON TO THE HIGHWAY, AND ALL OF A SUDDEN THE CAR STALLED. I COULD NOT ACCELERATE, AND A SEMI WAS GOING TO HIT THE BACK OF MY CAR BECAUSE I GOT OUT THERE IN FRONT OF HIM AND THEN I CAN'T MOVE. SO TO AVOID THE ACCIDENT, I DARTED OF THE HIGHWAY UNTO THE SHOULDER WITH THE DISMAY OF THE TRUCK DRIVER. THE INFORMATION IN THE LEFT CORNER GAVE "PERFORMANCE REDUCED". I DIDN'T KNOW WHAT HAPPENED. SO I HAD IT TOWED, AND WITHOUT FINDING ANYTHING THE FIRST DAY, THEY FOUND THAT IT WAS THE ELECTRONIC THROTTLE MODULE. SO I HAD TO PAY OVER $1000 TO GET THIS FIXED. THIS WAS BACK IN MARCH, AND NOW I AM HAVING THE SAME PROBLEM. I AM NOT GOING TO PAY ANOTHER $1000 FOR THE SAME THING. I ALMOST GOT INTO AN ACCIDENT AND I ALREADY PAID OVER $1000 TO GET IT FIXED, AND NOW I HAVE TO COME OUT OF POCKET AGAIN ONLY 4 MONTHS LATER. THIS IS HORRIBLE, AND VOLVO SHOULD RECALL ALL THE CARS WITH THIS ELECTRONIC THROTTLE MODULE. I HAVE ALMOST GOT INTO AN ACCIDENT SEVERAL TIME BECAUSE OF THE RESULT OF THIS DEFECT. I REFUSE TO GET IT FIXED, BECAUSE VOLVO WILL NOT PAY FOR IT. I HAVE HAD IT REPLACED ONCE BEFORE, AND IT IS STILL DOING THE SAME THING. VOLVO NEEDS TO TAKE CARE OF THIS, BECAUSE IT IS OBVIOUSLY A DEFECT ON THEIR END. PLEASE HELP TO GET THIS FIXED. I DON'T HAVE ANOTHER $1000 TO GET THIS FIXED EVERY THREE TO FOUR MONTHS!!! *NM

Aug 15, 2005

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

4 complaints

PLACED MY VEHICLE IN REVERSE TO PULL BACK OUT OF MY GARAGE & MY CAR ACCELERATED OUT OF CONTROL. I WAS FORCED INTO A PARKING SIGN THAT SCRATCHED AND DENTED MY LEFT REAR BUMPER. IN THE LAST 2 1/2 MONTHS RELATED PROBLEMS CONTINUE WHERE MY CAR SURGES & ALSO EXPERIENCES SUDDEN & UNEXPECTED REDUCED PERFORMANCE. WHEN I ACCELERATE MY CAR FEELS LIKE IT IS STUCK IN GEAR & WON'T RESPOND. IT IS A SAFETY HAZARD!! AGAIN!!! THIS DUPLICATES THE SAME ELECTRONIC THROTTLE MODULE PROBLEM I HAD IN AUGUST OF 2005. AFTER TAKING MY CAR IN 4 TIMES (NOT KNOWING WHAT THE PROBLEM WAS), IT WAS FINALLY DETERMINED IT IS THE ETM AGAIN. VOLVO PERFORMED A COMPUTERIZED UPGRADE ON THE ETM & THEN IT WAS FINALLY RECALLED IN JANUARY OF 2006. IT IS ANOTHER SAFETY HAZARD READY TO HAPPEN. VOLVO SHOULD HAVE IN THE BEGINNING & SHOULD AT THIS TIME BE MADE TO REPLACE THE FAULTY ETM! *TR

Jul 20, 2013

Crash: 1

THE CONTACT OWNS 2000 VOLVO S80. PURCHASED IT UNDER AN EXTENDED WARRANTY CERTIFIED USED CAR PROGRAM FROM CLAYTON VOLVO IN KNOXVILLE TENNESSEE IN APRIL 2001. SEVERAL MONTHS LATER, WHILE THE CAR WAS STILL UNDER WARRANTY, THE CAR DIED IN THE MIDDLE OF AN INTERSECTION. AFTER TOWING IT TO THE DEALER IT WAS DISCOVERED THE ELECTRONIC THROTTLE MODULE WASFILLED WITH CARBON. THAT UNIT WAS REPLACED UNDER WARRANTY. A COUPLE YEARS LATER, THE CAR AGAIN DIED. THIS TIME IT HAPPENED IN A PARKING LOT. THANKFULLY, IN BOTH CASES IT HAPPENED IN A SAFE SITUATION. AGAIN, THE ETM WAS DETERMINED TO BE THE PROBLEM. BUT, THE WARRANTY HAD EXPIRED. THE DEALER AND THE MANUFACTURER REFUSED TO RECOGNIZE THAT THE PROBLEM WAS AN ONGOING ISSUE. THIS TIME THE CONTACT WAS FORCED TO PAY NEARLY $1000 FOR REPAIRS. IT WAS THE CONTACT'S UNDERSTANDING THAT INFORMATION WAS BEING COLLECTED ON THIS PROBLEM, SO HE FELT COMPELLED TO ADD THIS COMPLAINT. ALTHOUGH HAD SPECIFIC DATES AVAILABLE , THE CONTACT COULD CHECK MY RECORDS AND PROVIDE THEM IF NECESSARY. *NM. X-REF 10131424, 2 ETMS INSTALLED, SMCH. *AK THE THROTTLE BODY WAS CLEANED TWICE AND THE MASS AIR FLOW SENSOR WAS REPLACED. UPDATED 12/07/05. *JB

Nov 18, 2005

DT: THE CONSUMER WAS EXPERIENCING ENGINE STALLING. THE DEALER REPLACED THE ELECTRONIC THROTTLE MODULE. *AK *JB

Sep 09, 2005

I WAS DRIVING ON I-75 INTERSTATE AND WHEN I WENT TO PASS A VEHICLE IN THE LEFT LANE I FELT A SUDDEN LOSS OF POWER IN MY ENGINE. I THEN HAD TO CUT ACROSS 4 LANES OF EXPRESSWAY TRAFFIC TO GET MY CAR ONTO THE SHOULDER. THEN MY CAR STALLED OUT. WHENEVER I RESTARTED IT, IT WOULD STALL BACK OUT AGAIN. THE AUTO SHOP TOLD ME THAT I NEEDED TO REPLACE MY ELECTRONIC THROTTLE MODULE, MASS AIR FLOW SENSOR, AND GAS PEDAL SENSOR COSTING ME WELL OVER $2000. (THE OLD PARTS ARE AT MY HOUSE, I'VE KEPT THEM). *NM

Aug 10, 2005

SUSPENSION

4 complaints

TL*THE CONTACT OWNS A 2001 VOLVO S80. WHILE DRIVING 5MPH TRAVELING OVER A SPEED BUMP THE LEFT FRONT TIRE SUDDENLY SEPARATED FROM THE LOWER BALL JOINT DAMAGING THE FRONT END OF THE VEHICLE .THE VOLVO MANUFACTURER HAD NOT BEEN CONTACTED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 117,900.

Mar 15, 2010

LAST MONTH, I GOT INTO A CAR ACCIDENT. A FORD ECONOLINE IN THE OPPOSITE DIRECTION TURNED LEFT WITHOUT SEEING ME AND HIT ME IN THE DRIVER'S SIDE FRONT WHEEL AND ALL THE WAY TO THE BACK. I BROUGHT MY BRAND NEW 2001 VOLVO S60 BACK TO MY DEALER BILL GRAY VOLVO FOR REPAIR. I GOT MY CAR BACK JUST LAST WEDNESDAY (4/18). THE DEALERSHIP TOLD ME EVERYTHING WAS FIXED EXCEPT THE MOLDING ON THE WINDOW. WHILE I WAS DRIVING BACK HOME FROM THE DEALERSHIP, I NOTICED THE CAR WAS QUITE A BIT OFF-CENTERED WHEN I WAS ACCELERATING WHICH DIDN'T HAPPENED BEFORE THE ACCIDENT AND THE REPAIR. SO I CALLED BACK THE NEXT MORNING INQUIRING, NOT ONLY DIDN'T THEY WORRIED ABOUT THIS PROBLEM, BUT ALSO ADVISED ME AND MAKE SURE THAT I'M AWARE THAT THIS IS NORMAL FOR FRONT WHEEL DRIVE CARS. DESPITE THE TECHNICIAN'S ADVISE, I WAS STILL VERY WORRIED, SO DUE TO OTHER PROBLEMS THAT DIDN'T HAPPENED BEFORE THE REPAIR , I SCHEDULED TO BRING IT BACK FOR A CHECK ON TUESDAY (4/24). HOWEVER, ON SUNDAY(4/22), AS SOON AS I DROVE OUT FROM MY APARTMENT, I HEARD A CRACK SOUND AND THOUGHT THAT WAS A FLAT TIRE. I STEPPED OUT AND CHECKED THE TIRES, NOTHING WAS WRONG. WHEN I BACKED UP THE CAR, MY FRIENDS SAW PARTS ARE FALLING OUT FROM THE CAR AND THE WHEEL WAS OFF THE AXLE HITTING THE FENDER. THIS ALL HAPPENED ON THE LEFT SIDE OF MY CAR WHICH WAS DAMAGED IN THE ACCIDENT, AND THE DEALER IS SUPPOSED TO HAVE THAT FIXED. THE SERVICE REPRESENTATIVE TOLD ME THIS WAS CAUSED BY BALL JOINT DETACHMENT. HE SAID THIS MIGHT BE AN AFTERMATH OF MY FIRST ACCIDENT. AFTER INVESTIGATION, MY INSURANCE COMPANY TOLD ME THIS DEFECT HAS NOTHING TO DO WITH MY FIRST ACCIDENT BUT MAY HAD BEEN HAPPENING BEFORE IT OR SOMEONE HAS BEEN WORKING ON IT FOR A PERIOD OF TIME TO CAUSE THIS TO HAPPEN. BOTH THE SERVICE AND THE CLAIM REPRESENTATIVES SAID THIS COULD NOT BE IN ANY OF MY ABILITY TO CAUSE THIS TO HAPPEN.*AK

Apr 25, 2001

Crash: 1

WHEN TRAVELING OVER 45 MPH VEHICLE WONDERS TO LEFT OR RIGHT. IF HITTING ANY BUMPS IN ROAD CAR WILL GO IN THAT DIRECTION. *AK

Feb 26, 2001

DEFECT WITHIN STEERING AND SUSPENSION. VEHICLE WILL NOT TRACK STRAIGHT, IT WILL WANDER TO LEFT AND RIGHT, CAUSING AN UNSAFE CONDITION. DEALER ATTEMPTED TO FIX DEFECT 3 TIMES , TIRE PRESSURE,ALIGNMENT AND ADJUSTED SUSPENSION, BUT DEFECT KEEPS OCCURRING. *AK

Feb 23, 2001

STEERING

4 complaints

THE POWER STEERING MAKES A VERY LOUD GROANING NOISE ALL OF THE TIME. I AM CONCERNED THAT THERE COULD BE A STEERING FAILURE. THE DEALER HAS CHECKED THIS COMPLAINT A MANY TIMES DATING BACK TO 2002 AND FOUND NO PROBLEMS AND SAID THE POWER STEERING FLUID WAS NORMAL AND NOT LEAKING. PROBLEM IS GETTING WORSE. *TR

Feb 13, 2010

DT*: THE CONTACT STATED THE POWER STEERING RESERVOIR HOSE CONNECTING CLAMP LEAKED FLUID. THE VEHICLE WAS SEEN BY A DEALER AND CONNECTING CLAMP WAS REPLACED. AFTERWARDS, THE POWER STEERING FLUID CONTINUED TO LEAK AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE SERVICE DEPARTMENT DETERMINED THE CLAMP NEEDED TO BE REPLACED AGAIN.

Mar 24, 2006

DT: THE CONSUMER STATED ON 2001 VOLVO S80 THE STEERING WHEEL LOCKED WHILE DRIVING 5 MPH. THIS LASTED FOR ABOUT 3-4 SECONDS AND THEN THE STEERING RESUMED BACK TO NORMAL. THE CONSUMER WAS TURNING THE WHEEL SO HARD THAT IT BROKE THE TURN SIGNAL. THE CONSUMER TOOK THE CAR TO THE DEALERSHIP AND THEY SAID THAT THEY HAD NEVER HEARD OF THIS. THE DEALER CONSTACTED THE MANUFACTURER. THE MANUFACTURER DENIED ANY KNOWLEDGE OF THE PROBLEM. THE DEALER COULD NOT FIND ANYTHING WRONG THE CAR AND RETURNED IT BACK TO THE OWNERS. THE CAR HAS NOT HAD ANY MORE PROBLEMS. *AK *NM

Sep 22, 2005

CONSUMER WAS BACKING VEHICLE OUT THE DRIVEWAY AND STEERING GOT VERY TIGHT. CONSUMER TOOK VEHICLE TO DEALER THE NEXT DAY. DEALER FOUND BOTH SEALS ON STEERING RACK HAD BEEN BLOWN. MECHANIC AT DELAER BELEIVES IT'S A FACTORY DEFECT. *AK

Aug 06, 2001

ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

4 complaints

TL*THE CONTACT OWNS A 2001 VOLVO S80. WHILE DRIVING 35 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE SHUT OFF. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REFUSED TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS TOWED TO ANOTHER FORD DEALER THAT WILL PERFORM THE REPAIR. THE CONTACT STATED THAT THE FAILURE HAS OCCURRED BEFORE AND SHE BELIEVES THAT THE CAUSE IS THE VEHICLE SPEED CONTROL, WHICH IS CURRENTLY UNDER NHTSA RECALL NUMBER 06V441000. SHE ALSO STATED THAT THE RADIATOR WAS REPLACED AT 28,000 AND 56,000 MILES AND CURRENTLY NEEDS TO BE REPLACED AGAIN. THE CONTACT STATED THAT THE RADIATOR FAILS EVERY 28,000 MILES AND THE ENGINE COOLANT LIGHT ILLUMINATES. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 87,000.

Sep 04, 2007

WE BEGAN REPORTING PROBLEMS WITH HESITATION AND SURGING IN OUR 2001 S80 T6 SEVERAL YEARS AGO TO THE SERVICE DEPARTMENT AT OUR NEAREST DEALER, SILL TERHAR MOTORS IN BROOMFIELD, COLORADO. THEY TRIED REPLACING A TURBO VALVE AND A SOFTWARE UPGRADE THAT WAS AVAILABLE AT THE TIME, AND WE WERE TOLD THAT USING THE HIGHEST OCTANE FUEL WOULD BE NECESSARY IN ORDER TO PREVENT THE HESITATION. THE PROBLEM CONTINUED. GIVEN THE INCONVENIENCE OF THE DEALERS LOCATION AND THAT THEY HAD NOT SEEMED TO BE ABLE TO CORRECT THE PROBLEM, WE HAD THE VEHICLE SERVICED FOR A WHILE AT AN INDEPENDENT VOLVO MECHANIC. LAST FALL THE EMISSIONS AND CHECK ENGINE WARNING LIGHTS TURNED ON, AND THEY REPLACED AN OXYGEN SENSOR AND/OR MASS AIR SENSOR. THE WARNING LIGHTS TURNED ON AGAIN, AND THEY RECOMMENDED THAT WE GO TO THE SERVICE DEPARTMENT AT THE DEALER. WE LEARNED OF THE "EXTENDED WARRANTY" VOLVO WAS BEGINNING TO OFFER AS A RESULT OF THE PROBLEMS IN THE DESIGN OF THE ELECTRONIC THROTTLE MODULE. IN EARLY DECEMBER WE LEFT THE VEHICLE WITH THE SERVICE DEPARTMENT AT SILL TERHAR, AND THEY DID THE SOFTWARE UPGRADE. WITHIN DAYS THE VEHICLE WAS RUNNING HORRIBLY AND WAS STALLING IN INTERSECTIONS. SILL TERHAR HAD THE VEHICLE TOWED AND REPORTED THAT THE PROBLEM WAS DUE TO A HOSE THAT HAD NOT BEEN FASTENED SECURELY. DUE TO TRAVEL DURING THE HOLIDAYS AND THE MULTIPLE SNOWSTORMS IN COLORADO IN LATE DECEMBER, WE DROVE THIS VEHICLE IN EARLY JANUARY AFTER HAVING PUT ONLY ABOUT 100 MILES ON THE VEHICLE SINCE THE TIME THAT IT WAS REPORTEDLY FULLY CLEARED OF PROBLEMS WITH REGARD TO THE ETM, THE CHECK ENGINE WARNING LIGHT TURNED ON AGAIN. WE RETURNED TO SILL TERHAR, AND THEY SAID THAT THE PROBLEM WAS DUE TO A FAULTY RIGHT FRONT OXYGEN SENSOR. THEY WERE CERTAIN THAT THIS WAS UNRELATED TO THE ETM PROBLEM. THAT MOST RECENT WORK COST US $400. WE PICKED UP THE VEHICLE LAST FRIDAY EVENING AND, TODAY, ONLY A FEW DAYS LATER, THE CHECK ENGINE WARNING LIGHT HAS TURNED ON YET AGAIN. *JB

Jan 17, 2007

WELL, WELL - LET'S SEE, I BOUGHT A 2001 VOLVO S-80, T-6 IN FEBRUARY 2005 TO REPLACE MY 1996 740 IL BMW - I THOUGHT I WOULD GET A MORE ECONOMICAL AND SAFE CAR. BOY WAS I WRONG! TO MY DISGUST I PAID ALMOST $20,000 FOR THIS USED CAR AND WITHIN WEEKS IT STARTED ACTING UP. IT TURNED OUT TO BE THE MASS AIRFLOW SENSOR AND THE THROTTLE BODY. I FINALLY - 9 MONTHS AFTER PURCHASING THE CAR - HAVE HAD TO GET IT FIXED - OVER $1200.00. I, LIKE ANOTHER PERSON WHO FILED A COMPLAINT, WAS MAKING A LEFT HAND TURN ON A VERY BUSY ROAD, AND THE CAR DIED WHILE IN THE MIDDLE OF MY TURN. LUCKILY I WAS ABLE TO PUT IT IN NEUTRAL QUICK ENOUGH AND RESTART IT BEFORE I GOT HIT. THE CAR ALSO SURGES DANGEROUSLY AT STOPS. IF YOU DON'T HAVE YOUR FOOT ON THE BRAKE 110%, THE CAR WOULD LURCH FORWARD AND HIT THE CAR IN FRONT OF IT. I'M SO DISAPPOINTED IN THIS CAR I WILL NEVER BUY ANOTHER VOLVO. SO MUCH FOR LOOKING FORWARD TO "ONE DAY PURCHASING THIS SAFE CAR". NOW THAT I HAVE DUMPED LOTS OF MONEY INTO THIS CAR, TAKEN VACATION TIME TO PICK IT UP AND DROP IT OFF, IT WORKS OKAY. THE THROTTLE BODY WAS REPLACED ABOUT 2 WEEKS AGO, BUT THE CAR STILL FEELS LIKE ITS NOT GIVING ME 100% - BUT AT LEAST IT ISN'T STALLING OR SURGING. I STILL HAVE MY BMW - THANK GOODNESS. I'LL BE GETTING RID OF THIS VOLVO. FORD BOUGHT VOLVO AND THEY ARE RESPONSIBLE FOR MAKING THIS UNRELIABLE CAR. I ALSO UNDERSTAND THAT THERE A CLASS ACTION LAWSUIT AGAINST VOLVO (FORD) - IT'S TIME THEY DO THE RIGHT THING AND REIMBURSE CUSTOMERS WHO HAVE BEEN SUBJECTED TO THIS DANGEROUS AND POORLY DESIGNED FUEL SYSTEM. *JB

Nov 17, 2005

VOLVO S80 ELECTRONIC THROTTLE MODULE (ETM) PRODUCTION DEFECT NOT COVERED UNDER WARRANTY AS THE DEFECT OCCURRED JUST OUTSIDE OF WARRANTY. DEALER COST TO CORRECT IS OUTRAGEOUS GIVEN THIS IS CLEARLY A MANUFACTURER ENGINEERING DEFECT WITHIN THE THROTTLE BODY MECHANISM ITSELF. *JB

Oct 05, 2005

SERVICE BRAKES, HYDRAULIC

3 complaints

AFTER ABOUT ONE YEAR OF USE THE BRAKE PEDAL GOES TOO LOW BEFORE THE BRAKING EFFECT TAKES PLACE. RESULTED IN ACCIDENT. PROBLEM MANY TIMES REPORTED TO THE DEALER.THE DEALER ADMITS THAT THERE ARE MANY SIMILAR COMPLAINTS FROM CUSTOMERS. STILL DEALER INSISTS THAT THIS IS NOT A PROBLEM BUT THIS IS A CONSTRUCTION DIFFERENCE. *AK

Jun 24, 2004

Crash: 1

CONSUMER STATED THAT 6 MONTHS AGO HE REPLACED REAR BRAKES AND CALIPERS AT 15,000 MILES. CURRENTLY, CONSUMER TOOK VEHICLE TO DEALER FOR REGULAR MAINTENANCE, AND WAS TOLD THAT HE NEEDED TO REPLACE FRONT BRAKES AND ROTORS. *AK

Dec 01, 2003

FAILURE OF POWER BRAKE BOOSTER WHICH LEAKED.. *MR *TT *JB

Jun 17, 2003

SEAT BELTS

3 complaints

THE FRONT SEAT BELTS RELEASED WHEN THE CONSUMER HIT THE BUCKLE WITH HER ELBOW. *NLM *SCC *JB

Sep 12, 2003

CONSUMER STATES THAT THE SPRING STEEL CLIP FAILED CAUSING THE REPLACED RIGHT SEAT BELT ANCHOR TO PULL OUT OF THE FLOOR, CONSUMER BELIEVES THIS IS A DESIGN DEFECT, MANUFACTURER CONTACTED. *TT

Mar 11, 2002

THE REPLACED RIGHT SEAT BELT ANCHOR PULLED OUT OF THE FLOOR BECAUSE A "SPRING CLIP" FAILED. I BELIEVE THE DESIGN MAY BE FAULTY. THERE IS NO HOLE AND BOLT ANCHORING THE SEAT BELT.*AK

Mar 07, 2002

UNKNOWN OR OTHER

2 complaints

MY CAR LURCHES FORWARD WHEN YOU ARE IDLING AS WELL AS DRIVING. I WAS ON A BUSY STREET WHEN I PULLED OUT INTO AN ONCOMING LINE OF TRAFFIC WHEN THE MOTOR COMPLETELY DIED LEAVING ME IN THE MIDDLE OF BOTH LANES OF TRAFFIC. AFTER A TIME I WAS ABLE TO RESTART THE VEHICLE. THIS HAS ALSO HAPPENED IN BUMPER TO BUMPER HIGHWAY TRAFFIC. AS YOU ARE IDLING AT AN INTERSECTION OR AWAITING A TRAIN TO PASS, THE MOTOR RACES AND THEN SLOWS AND ALSO LURCHES AHEAD. FOOT MUST BE HARD ON THE BRAKE OR I COULD REAR END THE VEHICLE IN FRONT OF ME. THIS VEHICLE HAS ONLY ABOUT 65,000 MILES AND I HAVE NO IDEA WHY THIS IS HAPPENING. IT HAS BEEN A GREAT CAR UNTIL THIS STARTED HAPPENING. THE CAR IS NOW SITTING IN THE DRIVEWAY AS AN UNSAFE CONDITION IS CAUSED BY THIS MALFUNCTION.

Aug 10, 2020

CONTACT STATES: CONSUMER RECEIVED A RECALL NOTICE ABOUT THE OWNERS VEHICLE. CONSUMER WAS UNABLE TO GET IT SERVICED IN HIS AREA AS OF LAST WEEK, AND WAS BEING SENT OUT OF STATE TO OREGON TO CORRECT THE RECALL. THERE WERE VOLVO MECHANICS LOCALLY THAT WERE CERTIFIED TO FIX THE CAR. LOCAL DEALERSHIP SOLD OUT. ACTUAL COMPLAINT CONCERNED VOLVO NOT ALLOWING THE CERTIFIED MECHANICS TO DO THE WORK AND REQUIRING CONSUMER TO GO OUT OF STATE.*AK

May 03, 2005

POWER TRAIN,UNKNOWN OR OTHER

2 complaints

MOST RECENT IS AN UPPER IDLER ARM WENT CAUSING THE TIMING BELT TO SKIP DAMAGING THE MOTOR: COST 4K TO FIX OR 5K TO INSTALL A USED MOTOR. PRESSURE TEST CAME BACK (NO PRESSURE)PISTONS ARE OK. SUNROOF CAVED IN ON MY HEAD. I DID GET CUTUP WITH THE GLASS. CAR STALLED, NEED NEW ALTERNATOR, FUEL LINK SHIELD FELL OFF BOTTOM OF CAR CAUSING THE FUEL LINE TO DRAG ON ROAD. I HAD TO TAPE THE RUBBER FUEL LINE UP UNTIL GARAGE TO INSTALL A NEW SHIELD. PASSENGER SIDE SAFETY BELT LINKAGE BROKE (NO PASSENGER SIDE SEAT BELT) THERE ARE OTHER 'ROUTINE MAINTAINENCE' TIRES/BRAKES/ ETC THAT I DID HAVE DONE. I'VE TAKE GOOD CAR, BUT THESE LARGE TICKET ITEMS CONTINUE. THERE ARE ALWAYS LIGHTS OUT SOMEWHERE ON THIS CAR. ONE OF THE TIRE RIMS CRACKED AND I NEED A NEW ONE (DANGEROUS TO DRIVE HIGHWAY WITH THAT). I DID NOT THINK VOLVO WOULD EXCEPT SOMETHING LIKE THIS, WHEN I BROUGHT THE CAR TO GENGRIS VOLVO DEALER THEY TOLD ME THAT THAT 'WOULD NOT TOUCH' THIS CAR AND TRADE-IN WAS NOT AN OPTION. THIS CAR IS WORTHLESS WHAT WITH ALL THESE PROBLEMS. THEY TOLD ME THAT THIS MODEL (2000/2001) OF THE S80 T6 ARE LEMONS AND SHOULD NEVER HAVE BEEN MADE ROAD WORTHY. IS THERE ANYTHING YOU ARE ABLE TO DO... I STILL OWE 13K ON THIS WORTHLESS CAR. I SHOULD HAVE NEVER BOUGHT A VOLVO - THIS IS MY SECOND AND AND VERY WILLING TO SHARE THIS WITH OTHER POTENTIAL BUYERS IF NOTHING IS DOME BY VOLVO WITH THIS MATTER... THERE ARE MORE PROBLEMS I CAN SHARE IF YOU ARE INTERESTED. *TR

Mar 07, 2009

RE: VOLVO S80 T6 2001 HAVE HAD ENGINE SURGING FOR A WHILE. NOW THE TRANSMISSION FAILED WITH A MAJOR MELTDOWN AND DAMAGE. ALWAYS DID FREQUENT MAINTENANCE. ALSO HAD A CATALYTIC CONVERTER GO OUT. MUST BE A DEFECT. SAW OTHERS WITH SIMILAR PROBLEMS ON LINE. *TR

May 02, 2008

EXTERIOR LIGHTING

2 complaints

2001 S80 VOLVO, HEADLIGHTS GATHER MOISTURE ANYTIME IT RAINS. HAD TO REPLACE BEFORE PASSING INSPECTION. *TR

Jun 11, 2007

THE 2001 VOLVO S80 HEADLIGHT & DAYTIME RUNNING LIGHT SYSTEM. THE 2001 VOLVO S80 HEADLIGHT & DAYTIME RUNNING LIGHT SYSTEM. THE DASHBOARD LIGHTS AND DAYTIME RUNNING LIGHTS ARE ON AT START UP. DURING DARKNESS THERE IS NO INDICATION THAT THE NIGHT TIME HEADLAMPS ARE IN THE OFF POSITION (BECAUSE THE DASHBOARD LIGHTS ARE ON AND DAYTIME LAMPS ILLUMINATE THE ROAD TO SOME EXTENT). THE UNSAFE CONSEQUENCE IS THAT BY NOT TURNING ON THE NIGHT TIME HEADLAMPS IN DARKNESS, THE 2001 VOLVO S80 OPERATES VOID OF TAIL LAMP ILLUMINATION.MY WIFE IS THE PRIMARY DRIVER OF OUR VOLVO. SHE COMBATS THE PROBLEM BY LEAVING THE NIGHT TIME HEADLAMPS ON AT ALL TIMES. WHEN I DRIVE THE VOLVO, I HAVE A HABIT OF TURNING THE LIGHTS OFF AFTER USE. MANY TIMES, MY WIFE HAS FORGOTTEN TO TURN THE NIGHT TIME HEADLAMPS BACK ON IN DARKNESS AND HAS BEEN IN HARMS WAY AS SHE DRIVES VOID OF TAIL LAMP ILLUMINATION IN DARKNESS! THIS IS A SAFETY ISSUE. THIS TAIL LAMP PROBLEM WHICH APPEARS TO BE A CARELESS OVERSIGHT BY THE DESIGN TEAM. THIS IS A PROBLEM WHICH SHOULD BE ADDRESSED AND RETROFITTED TO THE CURRENT VEHICLES AFFECTED IMMEDIATELY. DT

Dec 02, 2002

ENGINE AND ENGINE COOLING,POWER TRAIN

2 complaints

INITIALLY LACK OF ACCELERATION AND SPUTTERING ON ACCELERATION, CHECK ENGINE LIGHT AND EMISSION SYSTEM ERROR MESSAGE. CODES RESET. THEN PROBLEM RECURRED APPROXIMATELY ONE MONTH LATER. DEALER PROVIDED ETM SOFTWARE DOWNLOAD. APPROXIMATELY 3 WEEKS AFTER DOWNLOAD, CHECK ENGINE LIGHT ON, WEAK ACCELERATION, HESITATION OR SLIPPING ON SHIFTING. *NM

Jul 03, 2006

COOLING SYSTEM PROBLEM MESSAGE DISPLAYED AT 29,500 MILES ...DEALER FOUND AND REPLACED CRACKED HOSES THAT CAUSED COOLANT LEAK. TRANSMISSION SERVICE URGENT MESSAGE CAME UP. DEALER REPLACED TRANSMISSION VALVE BODY PER VOLVO. TRANSMISSION FAILED AGAIN 36 HOURS LATER. NOW IN SHOP HAVING COMPLETE TRANSMISSION REPLACED AT 31000 MILES! TRANSMISSION PROBLEM OCCURRED RIGHT AFTER 30,000 MILE SERVICE AT VOLVO AT COST OF $600. I ASKED VOLVO FOR DISCOUNT ON EXTENDED WARRANTEE... THEY REFUSED SAYING IF THEY DID IT FOR ME THEY WOULD HAVE TO DO IT FOR OTHERS.

Jan 15, 2004

POWER TRAIN,VEHICLE SPEED CONTROL

2 complaints

2001 VOLVO S80 T6 1. FAILURE VEHICLE SPEED CONTROL/ELECTRONIC THROTTLE CONTROL MODULE 2. TRANSMISSION FAILURE - GM TRANSMISSION. *JB

Nov 23, 2005

DT: THE VEHICLE IS A 2001 VOLVO S80. THE CONSUMER'S DAUGHTER WAS DRIVING THE VEHICLE IN TRAFFIC WHEN IT STALLED IN THE MIDDLE OF THE FREEWAY. SHE WAS ABLE TO GET THE VEHICLE TO RESTART BUT WHEN SHE PUT THE VEHICLE INTO DRIVE IT WENT BACKWARDS. WHEN THE CONSUMER GOT THERE HE TRIED TO GET IT TO GO FORWARD AND IT WENT BACKWARDS. THEY CALLED FOR A TOW TRUCK TO TAKE IT TO THE DEALER. WHEN THE CONSUMER TOOK IT TO THE DEALER THEY TOLD HIM THAT IT WAS THE THROTTLE BODY- ETM THAT FAILED. THIS WAS BECAUSE THE BANJO FITTING HAD CARBON BUILD UP. THE THROTTLE BODY IS COVERED BY WARRANTY. AND THE CLEANING OF THE BANJO FITTING IS NOT. THE CONSUMER FEELS THAT IT SHOULD BE PART OF THE MANUFACTURES PREVENTIVE MAINTENANCE. WHEN HE CONTACTED THE MANUFACTURE THEY TOLD HIM THAT HE COULD NOT SPEAK TO THE PEOPLE THERE THAT DECIDE WHAT IS COVERED AS NORMAL WEAR AND TEAR. THE VEHICLE HAS NOT BEEN REPAIRED AS OF YET, ALTHOUGH HE DOES INTEND TO HAVE IT REPAIRED. *NM

Jul 20, 2005

AIR BAGS

1 complaint

Takata recall. The contact owns a 2001 Volvo S80. The contact received a notification for NHTSA Campaign Number: 21V766000 (Air Bags). The dealer had been notified about the recall; however, the contact was informed that the part was not yet available. The manufacturer was then notified and informed him that they were unaware of when the parts may have become available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnection.

Oct 15, 2021

AIR BAGS,STRUCTURE,UNKNOWN OR OTHER

1 complaint

ON NOVEMBER 9TH MY WIFE WAS DRIVING OUR 2001 VOLVO S80 TO CHURCH. SHE PARKED THE CAR BUT IT BEGAN TO MOVE. IT ACCELERATED AND SHE WOUND UP DRIVING INTO A TREE TO AVOID HITTING OTHER CARS. SHE WAS ALSO WORRIED THAT CHILDREN FROM THE SCHOOL MIGHT BE AROUND. THE CAR WAS IN PARK. THE ENGINE WAS OFF. THE EMERGENCY BREAK WAS ON. THE STEERING WHEEL WAS TIGHT, MAKING IT DIFFICULT TO STEER SINCE THE ENGINE WAS OFF. THE CHURCH SECRETARY OBSERVED THE INCIDENT. SHE SAW SMOKE COMING OUT OF THE BACK OF THE CAR WHICH WOULD INDICATE THE EMERGENCY BREAK WAS ON. WHEN SHE FIRST REACHED THE CAR WITH MY WIFE IN IT SHE NOTED THAT THE CAR WAS IN PARK.

Dec 02, 2017

Crash: 1

Injuries: 1

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

1 complaint

TAKATA RECALL" FRIST I CALLED VOLVO TO INQUIRE ABOUT RECALLS REFERENING TO THE COOLING SYSTEM AND THE FUEL PUMP THE FIRST LADY I SPOKE WITH INFORMED ME THIS PROBLEM WAS UNDER RECALLS AND TO TAKE MY CAR TO GET IT SERVICED AT THE NEAREST DEALER AFTER TAKING MY CAR TO THE DEALER AT 7:15AM 4HOURS LATER AFTER I CALLED THEM FIRST THEY NOW ARE SAYING THAT THERE ISN'T ANYTHING THEY CAN DO WITH MY CAR AND THEY DO NOT KNOW WHO TOLD ME THAT FALSE INFORMATION. ON TOP OF ALL OF THIS MY CAR ACCELERATES BY ITSELF LUCKY WHEN IT HAPPENS I HURRY AND PUSH THE BRAKES AND THE CAR DOSENT START UP ONCE TURNING THE KEY EVEN THE GUY SAY THAT'S ALWAYS BEEN A PROBLEM. BASED ON HOW EXPENSIVE THIS CAR IS IT SEEM THERE WOULDN'T BE MANY PROBLEMS WITH IT OR IT SEEM THAT THEY WOULD AT LEAST TRY TODO SOMETHING ABOUT THE FALSE INFORMATION OVER ALL I WILL NEVER BUY ANOTHER VOLVO AGAIN!

Oct 19, 2017

VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC),ENGINE

1 complaint

TAKATA RECALL- THE VEHICLE BECOME NON RESPONSIVE WHEN PUSHING THE ACCELERATOR, THE ENGINE STARTED RUNNING ROUGH, THE CRUISE CONTROL STOPPED WORKING, THE DSTC (DYNAMIC STABILITY TRACTION CONTROL) FAILED AND THE ENGINE COOLANT TEMPERATURE STOPPED READING. THE VEHICLE STARTED STALLING EVERYTIME I COME TO A STOP. ALL THIS STARTED AT THE SAME TIME WHILE I WAS DRIVING THE VEHICLE. *TR

Jan 03, 2017

SUSPENSION,SEAT BELTS,VEHICLE SPEED CONTROL

1 complaint

I PURCHASED VEHICLE 8 MONTHS AGO I NOW HAVE PROBLEMS WITH THE FRONT AND BACK SUSPENSION. THE AIR TURNS ON ITS OWN, THE AXLE HAS BROKEN, THE SUNROOF OPENS WHEN IT WANTS TO OPEN, CHECK ENGINE LIGHT HAS TURNED ON ALONG WITH MAINTENANCE LIGHT, MY DOORS WILL UNLOCK THEMSELVES WHEN I LOCK THEM AND THE ALARM WILL ENGAGE, THE LEFT WINDOW DOES NOT WORK , SOMETIMES I CANT UNLOCK THE DOORS HAVE TO UNLOCK WITH MY HAND. MY CRUISE CONTROL DOES NOT WORK, THE BATTERY STOPS WORKING OFTEN, THE INSIDE LIGHTS WORK SOMETIMES. IT IS RUNNING TERRIBLE , IDLE UP AND DOWN I KNOW ALL HAS SOMETHING TO DO WITH RECALL PLEASE HELP! *TR

Dec 15, 2012

EQUIPMENT

1 complaint

VOLVO VEHICLES SUDDEN SPEEDS INCREASE THERE IS A AIR-BOX PROBLEM WHICH CAUSES THE ENGINE TO ACCELERATE,AND VEHICLE TO LUNGE FORWARD. SPEEDS THE ENGINE. *TR

Mar 08, 2010

SUSPENSION,FUEL SYSTEM, GASOLINE,POWER TRAIN

1 complaint

UPPER STRUT BUSHINGS CRACKED FRONT LOWER CONTROL ARM BUSHINGS FRONT LINK RODS REAR LINK RODS FLAME TRAP BOX LEAKING OIL THIS 2001 S80 VOLVO IS A PIECE OF JUNK TRIED TO HAVE THIS VOLVO WORK DONE PER THE EXTENDED WARR ULTIMATE I HAVE A PIECE OF JUNK. *TR

Jan 23, 2009

SUSPENSION,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VISIBILITY,TIRES

1 complaint

MY 2001 VOLVO S80 T6 COST ME AROUND $3,500 IN REPAIRS/MAINTENANCE AFTER PURCHASE IN THE LAST 3 MONTHS. THIS CAR HAS SOMETHING GOING WRONG ONE THING AFTER ANOTHER. TO MENTION SOME: FRONT SWAY-BAR LINKS, TURBO CHARGER DRAIN, BAD ALTERNATOR (THAT CAUSE OTHER ELECTRONICS TO MALFUNCTION I.E. THE VEHICLE'S ENTIRE HEATING SYSTEM), IN-CAR SENSOR FAILURE FOR INTERIOR AIR QUALITY , ELECTRONIC THROTTLE MODULE FAILURE THAT CAUSED ME TO HAVE THE VEHICLE TOWED TO THE VOLVO DEALERSHIP FOR $190, CATALYTIC CONVERTER FAILURE, OXYGEN SENSOR FAILURE, THE FRONT STRUTS AND MOUNTS NEED TO BE REPLACED, YET. MAINTENANCE WISE, THE 60K MAINTENANCE, WHICH THE DEALERSHIP NEVER MENTIONED THAT IT HAD BEEN COMPLETED ON THIS VEHICLE ( NO PAPER WORK FOR THE VEHICLE WAS PROVIDED TO ME AT THE TIME OF PURCHASE), THE BRAKES WENT BAD IN TWO WEEKS AFTER PURCHASE, THE TIRES NEEDED TO BE REPLACED, TOTAL COST: AROUND $2,000. I DON'T KNOW WHAT MORE TO EXPECT TO HAVE GONE WRONG ON THIS VEHICLE. THIS CAR HAS PUT ME THROUGH LOTS OF STRESS, WASTE OF TIME, AND LOSS OF MONEY. I BOUGHT THE VEHICLE FOR $14,000 AND HAS PUT IN ALMOST $3,500 AND IT'S NOT EVEN WORTH $17,000 IN THE MARKET AT THIS POINT. VOLVO NEEDS TO HAVE A RECALL ON THEIR SUSPENSION PROBLEMS (STRUTS, SWAY BAR LINKS, BUSHINGS) WHICH HAPPEN QUITE OFTEN AS I HAVE HEARD AND READ ON THE CONSUMER COMPLAINTS ONLINE, AND ALSO FOR THE ALTERNATOR FAILURE AND CAUSE AFTERWARDS. ALSO, IF THE CAR HAD TO BE TOWED BECAUSE OF A RECALL PROBLEM, THEY SHOULD COVER THE COST OF TOW SINCE THE PROBLEM WAS CAUSED BY THEIR RECALL ITEM. *NM

Jan 12, 2007

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

WHILE ON A ROAD TRIP, MY 2001 VOLVO S80 STARTED LURCHING FORWARD AND SPEEDING UP/SLOWING DOWN BY ITSELF. THE CAR WAS IDLING ERRATICALLY AND WOULD STALL OUT. AS I WAS AWAY FROM HOME AND NEEDED TO RETURN SOON, I TOOK MY CAR TO BE CHECKED OUT. I WAS TOLD THAT I NEEDED A NEW ELECTRONIC THROTTLE MODULE. I HAD NO CHOICE BUT TO HAVE THE CAR FIXED AT A COST OF OVER $800.00. NOW I FIND OUT THAT VOLVO KNEW OF PROBLEMS WITH THIS PARTICULAR PART AND THAT THERE MAY BE A RECALL AND I AM VERY ANGRY THAT I HAD TO PAY TO REPLACE A PART THEY (VOLVO) KNEW WAS DEFECTIVE!!! ADDITIONALLY, AND MORE IMPORTANTLY, I WONDER ABOUT THE POTENTIAL DANGER I AND MY FAMILY WERE UNKNOWINGLY SUBJECTED TO DUE TO VOLVO'S DECISION TO NOT INFORM CONSUMERS OF THIS DEFECT. *JB

Jun 22, 2006

FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

1 complaint

SURGING IDLE SPEED. CAR LURCHES FORWARD AT TIMES WHEN ACCELERATING FROM A STOP. CAR ALMOST STALLS WHEN IDLING IN BUMPER TO BUMPER TRAFFIC, REQUIRING YOU TO PRESS ON THE GAS TO KEEP IT FROM STALLING, BUT THIS MAKES THE CAR LURCH FORWARD EVEN MORE. SEVERAL TIMES I HAVE ALMOST HIT THE CAR IN FRONT OF ME. THIS PROBLEM IS DUE TO A FAULTY ETM (ELECTRONIC THROTTLE MODULE) THAT IS DESCRIBED IN THE NHTSA DEFECT INVESTIGATION SHOWN BELOW. THE ETM IN MY CAR WAS REPLACED TWO YEARS AGO AT 46K MILES BUT THE SAME SYMPTOMS ARE RECURRING. NHTSA ACTION NUMBER : PE05041 NHTSA RECALL CAMPAIGN NUMBER : N/A MAKE : VOLVO MODEL: S80 MANUFACTURER : VOLVO CARS OF N.A. LLC. YEAR : 2001 COMPONENT : VEHICLE SPEED CONTROL DATE INVESTIGATION OPENED : JULY 26, 2005 DATE INVESTIGATION CLOSED : OPEN SUMMARY: THE OFFICE OF DEFECTS INVESTIGATION (ODI) HAS RECEIVED ONE HUNDRED AND THIRTY-ONE (131) CONSUMER COMPLAINTS ALLEGING A VARIETY OF CONCERNS RESULTING FROM FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES, INCLUDING A SUDDEN LOSS OF SPEED AND STEERING ASSIST WHEN DRIVING IN HIGHWAY TRAFFIC AND SUDDEN AND COMPLETE STALL WITHOUT WARNING. IN SOME INSTANCES, IT HAS BEEN REPORTED THAT THE VEHICLES WOULD RESTART, AND IN SOME CASES THE VEHICLES WERE TOWED. SOME CONSUMERS ALLEGE THAT AFTER HAVING THE ETM REPLACED THE NEW COMPONENT FAILED IN A SIMILAR MANNER. A PRELIMINARY EVALUATION HAS BEEN OPENED TO DETERMINE THE SCOPE, FREQUENCY, AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT. *JB

Oct 24, 2005

POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

DT: THE BATTERY WAS DEFECT. THE TRANSMISSION FAILED. THREE TIMES WHILE DRIVING IN HEAVY TRAFFIC THE VEHICLE STALLED. EACH TIME THE CONSUMER WAS ABLE TO INTO A PARKING AREA. TWO OF THE THREE TIME THE DEALER REPLACED THE MASS AIR DETECTOR THE THIRD TIME THE PROBLEM WAS IDENTIFIED AS THE ELECTRONIC THROTTLE SENSOR. *AK *NM

Aug 30, 2005

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

1 complaint

ON OR ABOUT MAY 3RD, 2005, MY WIFE WAS DRIVING OUR 2001 VOLVO T6 WHEN SHE SUDDENLY LOST ENGINE PERFORMANCE. SHE WAS TRAVELING ALONG A BUSY INTERSTATE AND SHE MANAGED TO GET THE CAR INTO THE EMERGENCY LANE WHILE HOLDING UP TRAFFIC BEHIND HER. THE FOLLOWING MSG APPEARED ON THE DASH, "ENGINE PERFORMANCE REDUCED". WHEN SHE GOT THE CAR TO THE SIDE OF THE ROAD, SHE TURNED THE CAR OFF AND CALLED ME TO INFORM ME THE CAR WAS NOT WORKING PROPERLY. SHE STARTED THE CAR AFTER A FEW MINUTES AND IT PERFORMED OKAY ON THE WAY HOME. AT THIS TIME, I THOUGHT IT MIGHT HAVE BEEN A FUEL OR GAS CAP PROBLEM. SHE WAS VERY CLOSE TO HAVING A SERIOUS ACCIDENT. THE NEXT DAY SHE WAS TRAVELING WITH OUR CHILDREN ON A VERY BUSY BYPASS AND THE SAME PROBLEM OCCURRED. THIS TIME, I MADE A CALL TO THE VOLVO DEALER AND THEY INFORMED ME TO LEAVE THE CAR OFF FOR A MINUTE AND THE COMPUTER WOULD RESET. NOT A GOOD SOLUTION. NEEDLESS TO SAY, SHE HAD TO NAVIGATE THE CAR FROM THE INSIDE LANE TO THE EMERGENCY LANE WHILE TRAVELING NO FASTER THAN 20 MPH. AGAIN, THIS WAS A VERY BUSY BYPASS AND LUCKILY SHE MANAGED TO GET THE CAR TO THE SIDE OF THE ROAD. FINALLY, I DROVE THE CAR THE NEXT DAY TO SEE HOW IT PERFORMED FOR ME. AGAIN, THE CAR FAILED (I.E. SLOWED TO 20 MPH ON A 70 MPH INTERSTATE) WHILE I WAS DRIVING. I CALLED THE DEALER AGAIN THE NEXT DAY AND THEY INFORMED ME THEY WOULD NEED TO SEE THE CAR IN ORDER TO DIAGNOSE. I INFORMED THEM I NEEDED RECALL WORK PERFORMED ON AN ELECTRICAL FAN SO THEY COULD CHECK INTO MY "ENGINE PERFORMANCE REDUCED" PROBLEM AT THE SAME TIME. ALL THIS SAID, THE CAR FAILED APPROXIMATELY 8-10 TIMES BEFORE I COULD GET THE CAR TO THE SHOP AND REPAIRED ($933.00). THE PROBLEM PART WAS DETERMINED TO BE AN ELECTRONIC THROTTLE MODULE. LUCKILY, MY WIFE, AS WELL AS MYSELF, WERE ABLE TO GET THE CAR TO THE SIDE OF THE ROAD WITHOUT GETTING RAN OVER BY TRAFFIC. THIS PROBLEM DEFINITELY NEEDS THE ATTENTION OF THE NHTSA. THANKS FOR ANY HELP YOU CAN PROVIDE. *JB

Aug 16, 2005

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,EQUIPMENT

1 complaint

MY ELECTRONIC THROTTLE MODULE FAILED ON MY 2001 VOLVO V70 AT APPROXIMATELY 48,000 MILES. I WAS LUCKY THAT PERFORMANCE WAS ONLY REDUCED AND I WAS ABLE TO GET THE CAR TO THE DEALER FOR THE APPROXIMATELY $1200 REPAIR, BUT I DID CONSIDER IT TO BE A VERY DANGEROUS FAILURE IN THAT THE CAR APPARENTLY CAN CONVERT INTO A "LIMP HOME" MODE WHICH WOULD REDUCE SPEED TO A MAXIMUM OF ABOUT 20 MPH WITHOUT ANY ADVANCE WARNING, WHICH COULD BE VERY DANGEROUS IN EXPRESSWAY DRIVING, OF WHICH I DO A LOT. I AM CONCERNED THE NEW REPLACEMENT ETM IS THE SAME DEFECTIVE PART AND IS NOT PERFORMING PROPERLY AFTER ONLY ABOUT 2 WEEKS OF USE, AND CONSIDER THE CAR TO STILL BE DANGEROUS AND THE PART DEFECTIVE. *JB

Aug 03, 2005

ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,EXTERIOR LIGHTING,VISIBILITY,LATCHES/LOCKS/LINKAGES,EQUIPMENT

1 complaint

PURCHASED A VOLVO S80 IN 2001;VEHICLE CURRENTLY HAS 60700 MILES AND 3 AUTOMATIC TRANSMISSIONS & THROTTLE BODY REPLACEMENT.

Jul 15, 2005

STEERING,SUSPENSION,PARKING BRAKE,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1 complaint

2001 VOLVO S80 SERIES DEVELOPED PROBLEMS WITH THE STEERING AND THE BRAKING SYSTEM.***NO ANSWER REQUIRED***. *MR WHILE EXITING A PARKING LOT, THE VEHICLE CEASED TO OPERATE. THE VEHICLE TOWED AND THE CONSUMER WAS ASSURED THE PROBLEM HAD BEEN RESOLVED, HOWEVER 8 MONTHS LATER THE INCIDENT HAPPENED AGAIN. THE CONSUMER HAD SEVERAL ELECTRICAL REPAIRS DONE ON THE VEHICLE, SUCH AS THE INTERIOR LIGHTS, THE POWER WINDOWS, THE BATTERY WAS DEFECTIVE WHICH HAD TO BE REPLACED TWICE, THE ALARM WOULD GO OFF FOR NO REASON, THE HEAD LIGHT BULBS AND TAIL LIGHT BULBS WERE REPLACED. THE KEY WOULD NOT TURN IN THE IGNITION, THE ENGINE LIGHT ILLUMINATED, THERE WAS A FRONT SUSPENSION NOISE WHEN GOING OVER BUMPS. THERE WAS A POWER STEERING LEAK DUE TO A LOOSE HOSE CLAMP. THE PARKING BRAKE NEEDED TO BE ADJUSTED, IT DID NOT HOLD ON AN INCLINE. *JB

Jul 08, 2005

STEERING,SUSPENSION,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,VISIBILITY,SEAT BELTS,STRUCTURE,TIRES,EQUIPMENT,UNKNOWN OR OTHER

1 complaint

PROBLEMS WITH VOLVO HEAVY DUTY TRUCK: SINCE THE VERY FIRST WEEK OF OWNERSHIP WE HAVE HAD NOTHING BUT PROBLEMS WITH OUR BRAND NEW $130,000 RIG. IN A NUT SHELL HERE IS A LIST OF THE MAJORITY OF PROBLEMS THAT WE HAVE HAD SINCE MARCH 2001: -5 ALTERNATORS...THE FIRST TWO ACTUALLY FELL OFF WHILE DRIVING DOWN THE HIGHWAY!!?? -3 CAM SHAFTS (DETROIT DIESEL)... THE FIRST ONE WENT @ APPROXIMATELY 40,000 MILES -MAJOR VIBRATION/LOUD RATTLE COMING THROUGH THE GEAR SHIFTER **HAS BEEN CONSTANT SINCE I DROVE IT OFF OF THE LOT...THEY SAY THAT IT IS NORMAL?? -DESPITE THE LARGE RED WARNING LABEL ON THE TRUCK THAT STATES THAT PRE-MATURE WEAR WILL OCCUR, THE VOLVO MECHANICS HAVE ADJUSTED THE DRIVELINE ANGLES NUMEROUS TIMES. EVEN IF THEY EVER DID GET THE NOISE TO GO AWAY, DAMAGE HAS ALREADY OCCURRED! -TRANSMISSION WILL NOT SHIFT PROPERLY... VOLVO MECHANICS SAY IT SHIFTS NORMAL AND THAT IT IS ALL IN MY HEAD!!!!!!? (TRUST ME, MANY MECHANICS WHO DO NOT WORK FOR THE MANUFACTURER AGREE WITH ME!!) -2 ECM COMPUTERS -3 ON BOARD DISPLAY COMPUTERS -3 SETS OF STEER TRIES (FIRST SET LASTED 90,000 MILES) -2 SETS OF WHEEL BEARINGS. EVEN THOUGH THEY HAVE BEEN ADJUSTED AT THE SPECIFIED INTERVALS! -THE PAINT ON THE HOOD BEGAN PEELING OFF BEFORE I GOT THE TRUCK HOME!! -PASSENGER SIDE DOOR LOCKS MALFUNCTIONED ON THE FIRST TRIP OUT!! -4 NEW BATTERIES HAD TO BE BOUGHT 1 DAY AFTER THE 1 YEAR WARRANTY EXPIRED!!! I HAD PROBLEMS WITH THE BATTERIES PRIOR TO THE WARRANTY EXPIRING, HOWEVER MANY VOLVO MECHANICS TOLD ME THAT THEY TESTED FINE...I HAVE PROOF THAT THEY WERE NOT OK! ...AND VOLVO SAYS THAT THIS IS NORMAL??!!

Jan 15, 2004

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

1 complaint

AS THE CONSUMER WAS PULLING AWAY FROM CURB AT 3 MPH VEHICLE SUDDENLY ACCELERATED WITHOUT TOUCHING THE GAS. BRAKES WERE NOT FUNCTIONAL, AND VEHICLE SHOT THROUGH THREE INTERSECTIONS BEFORE THE EMERGENCY BRAKE WAS PULLED. MECHANIC INFORMED THE CONSUMER THAT MASS AIR FLOW SENSOR WAS FAULTY.*AK

Aug 19, 2003

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

ELECTRONIC THROTTLE ON 2001 VOLVO S80 FAILED AS I ATTEMPTED TO PASS SOMEONE. ENGINE WAS PROGRAMMED TO SHUT DOWN COMPLETELY. I WAS LEFT SPEEDING DOWN THE FREEWAY AT 70MPH WITHOUT STEERING!*AK

Jul 28, 2003

TIRES

1 complaint

THE FRONT LEFT TIRE WAS EASILY TORN BY ROUGH CURBING WHILE PULLING OUT OF PARKING SPACE, THE FRONT RIGHT TIRE ALSO WENT FLAT ON A SEPARATE OCCASION WHILE DRIVING. (MICHELIN SIZE 225/50R17) *YH

Jun 03, 2002

STRUCTURE

1 complaint

WHILE DRIVING FENDER PROTECTOR HAD DISLODGED AND WAS RUBBING AGAINST WHEEL OF VEHICLE. DEALER CONTACTED. PLEASE ADD VIN. *AK

Feb 19, 2002

2001 VOLVO S80 Problems & Complaints

Complaints by Component

Frequently Asked Questions

How many problems does the 2001 VOLVO S80 have?

What are the most common problems with 2001 VOLVO S80?

Where does this 2001 VOLVO S80 problem data come from?

Other Years - VOLVO S80

Other VOLVO Models

Similar Brands