2002 VOLVO VHD Recalls & Safety Issues
Official recalls, technical service bulletins (TSBs), and safety issues from the National Highway Traffic Safety Administration (NHTSA).
9
Recalls Found
All Recalls
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
NHTSA 12V510000
Consequence: In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
Remedy / Corrective Action
Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
NHTSA 09V173000
Consequence: IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.
Remedy / Corrective Action
VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN TRUCKS, THE WHEEL SPACER MAY BECOME DISTORTED FROM HEAT WHICH POTENTIALLY COULD LEAD TO A LOSS OF CLAMP THAT MAY RESULT IN LOOSE WHEEL NUTS.
NHTSA 06V213000
Consequence: IF THE WHEEL NUTS LOOSEN FOR ANY REASON, DAMAGE TO THE WHEEL STUDS AND WHEEL MAY OCCUR, AND MAY LEAD TO A COMPLETE SEPARATION OF THE WHEELS FROM THE TRUCK WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy / Corrective Action
DEALERS WILL REPLACE THE WHEEL SPACERS AND THE WHEEL EQUIPMENT (WHEELS,STUDS, AND HUB) WILL BE INSPECTED FOR DAMAGE AND REPLACED IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2006. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY DUTY CLASS 8 AXLE BACK VEHICLES, THE TELESCOPING STEERING SHAFT IN SOME DRIVING SITUATIONS COULD BOTTOM OUT AND SIDE LOAD THE STEERING GEAR INPUT SHAFT WHENEVER THE ADJUSTABLE STEERING COLUMN IS ADJUSTED TO THE LOWER POSITION.
NHTSA 02V156000
Consequence: OVER TIME, THIS CONDITION COULD DAMAGE THE STEERING GEAR INPUT SHAFT RESULTING IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH.
Remedy / Corrective Action
DEALERS WILL INSTALL A RE-DESIGNED STEERING SHAFT, WHICH WILL NOT BOTTOM OUT DURING VEHICLE OPERATION REGARDLESS OF WHERE THE ADJUSTABLE STEERING COLUMN IS POSITIONED. OWNER NOTIFICATION BEGAN JUNE 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS WITH VOLVO B-RIDE REAR SUSPENSION, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT COULD BREAK ALLOWING THE AFFECTED AXLE TO SHIFT OUT OF ALIGNMENT.
NHTSA 02V317000
Consequence: THIS CONDITION COULD RESULT IN LOSS OF AXLE STABILITY, INCREASING THE RISK OF A CRASH.
Remedy / Corrective Action
DEALERS WILL REPLACE THE UPPER AXLE SEAT ON BOTH REAR DRIVE AXLES. OWNER NOTIFICATION BEGAN JANUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH AN OPTIONAL TWO-MAN PASSENGER BENCH SEAT FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." ON THE TWO-MAN PASSENGER BENCH SEAT INBOARD (CENTER) POSITION, SEAT BELT D-RING MOUNTING BRACKET WELDNUT, THE WELD IS NOT SUFFICIENT TO MEET THE SEAT BELT PULL REQUIREMENTS .
NHTSA 03V108000
Consequence: THESE TRUCKS DO NOT COMPLY WITH THE REQUIREMENTS.
Remedy / Corrective Action
DEALERS WILL REPLACE THE SEAT BELT D-RING MOUNTING BRACKET. OWNER NOTIFICATION BEGAN ON APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.
NHTSA 03V204000
Consequence: IF LEFT UNDETECTED OR CORRECTED IT COULD LEAD TO THE SEPARATION OF THE FIFTH WHEEL TOP PLATE FROM ITS MOUNTING STRUCTURE, POSSIBLY RESULTING IN A CRASH.
Remedy / Corrective Action
DEALERS WILL REPLACE THE BRACKET PINS AND REPAIR INSTRUCTIONS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JOST INTERNATIONAL AT 616-846-7700 OR BY EMAIL TO [email protected] OR VOLVO TRUCK AT 800-528-6586.
ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.
NHTSA 04V457000
Consequence: IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.
Remedy / Corrective Action
DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY-DUTY CLASS 8 TRUCKS, THE ASSEMBLED ENGINE PRE-HEATER JUMPER WIRING HARNESS WAS INCORRECTLY ASSEMBLED.
NHTSA 04V077000
Consequence: THE ENGINE PRE-HEATER COULD OVERHEAT RESULTING IN DAMAGE TO THE PRE-HEATER AND OTHER ENGINE HEAT SENSITIVE COMPONENTS NEAR THE PRE-HEATER AND THE ABILITY TO RE-START THE ENGINE COULD BE COMPROMISED, INCREASING THE RISK OF A CRASH.
Remedy / Corrective Action
DEALERS WILL REPAIR THE AFFECTED CIRCUITS IN THE JUMPER WIRING HARNESS CONNECTOR. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Frequently Asked Questions
How many recalls does the 2002 VOLVO VHD have?
The 2002 VOLVO VHD currently has 9 recalls according to NHTSA records. All recall information is sourced directly from the National Highway Traffic Safety Administration database.
Are 2002 VOLVO VHD recalls free to fix?
Yes! All safety recalls for 2002 VOLVO VHD vehicles must be repaired free of charge by authorized dealers, regardless of vehicle age or mileage. Contact your local VOLVO dealer to schedule a recall repair.
How do I check if my 2002 VOLVO VHD has open recalls?
You can check for open recalls by entering your VIN (Vehicle Identification Number) in our VIN decoder tool. The 17-character VIN can be found on your vehicle registration, insurance card, or on the driver's side dashboard visible through the windshield.
Other Years - VOLVO VHD
2025 Recalls
2024 Recalls
2023 Recalls
2022 Recalls
2021 Recalls
2020 Recalls
2019 Recalls
2018 Recalls
2017 Recalls
2016 Recalls
2015 Recalls
2014 Recalls
2013 Recalls
2012 Recalls
2011 Recalls
2010 Recalls
2009 Recalls
2008 Recalls
2007 Recalls
2006 Recalls
2005 Recalls
2004 Recalls
2003 Recalls
2001 Recalls
2000 Recalls
Other VOLVO Models
240 Series
260 Series
740 Series
760 Series
780 Series
850 Series
940 Series
960 Series
9700
ACL
B10M
B12B
B12M
B12R
B13R
B5R
B5TL
B7R
B8L
B8R
Similar Brands
ZNEN
87 models
MASERATI
14 models
KTM
95 models
JAYCO
5 models
TAOTAO
181 models
RENAULT
5 models
RAM
109 models
COLORADO
5 models
MAHINDRA
4 models
GENESIS
13 models