2015 MINI Cooper Roadster Problems & Complaints

The fuel filling nozzle turns off repeatedly while trying to fill the fuel tank and spills out causing a safety and environmental hazard, regardless of the pump being used. As a result, no fuel goes into the gas tank, instead it goes all over the car and the ground.

Fuel tank causes gas pump to click off after dispensing a tenth gallon of gasoline. Gas spills from gas tank while removing pump creating a safety and environmental hazard. Fuel tank will not accept gas at pump. No warning lamps, messages, or symptoms were present prior to the failure. Mini Cooper dealership stated that service valve in tank has failed and entire fuel tank must be replaced.

When refueling, fuel is rejected after dispensing about 1/8 US gallons, about 4 oz. Of course, fuel spills are a hazard - both in possibly of fire, and to the environment - by contaminating ground water. Dealer said that there are several solenoid operated valves and replaced fuel tank and fill pipe, a cost to me of $2400.00. There are many reports of this on social media, one person suggested holding the fuel nozzle upside down which made a larger spill.

The fuel filling nozzle turns off repeatedly while filling the fuel tank, regardless of position of nozzle, pressure used, station used. In an attempt to remedy, Mini Service Technicians replaced tank vent valve but it did not correct the issue. I am unable to fill my gas tank.

I can not put gas into my car. I have had the charcoal canister replaced. I am now being told that I need a new fuel tank. I’ve also been informed that this is a reoccurring problem in 2015 mini coopers.

Crankshaft Pulley burnt while driving. Could not accelerate. Car threw overheating codes and AC blew hot air. Battery Charging Malfunction error shown as well.

The contact owns a 2015 Mini Copper The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the fuel tank needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure. The failure mileage was 78,000. The Vin was not available

CRANKSHAFT PULLEY WENT OUT AT 50,000 MILES WHILE IN MOTION MAKING CAR OVERHEAT.

PURCHASED VEHICLE NOVEMBER 2017. CAR WAS PARKED AND WHEN I STARTED ENGINE THERE WAS A LOUD NOISE. I TOOK IT IMMEDIATELY TO MINI COOPER SERVICE. WAS TOLD THE PASSENGER SIDE ENGINE MOUNT HAD COLLAPSED AND IT HAS ALSO CAUSED DAMAGE TO THE HEAT SHIELD FOR THE TURBO. HOW IS THIS POSSIBLE? NO SIGNS OR PRIOR PROBLEMS. MY MAINTENANCE HAS ALWAYS BEEN UP TO DATE. WHEN IT HAPPENED THE VEHICLE WAS PARKED, HEARD THE RADDLEING.

TL* THE CONTACT OWNS A 2015 MINI COOPER. THE CONTACT TOOK THE VEHICLE TO ORLANDO MINI COOPER (350 S. LAKE N. DESTINY DR, ORLANDO, FL) FOR ROUTINE MAINTENANCE AND WAS INFORMED THAT THE ENGINE MOUNTS WERE CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 52,000. THE VIN WAS UNKNOWN.

The sensors do not work. The car does not tell me when oil is needed, when my tires are low. No sensors work in the car. The dealer, Mini Of Edison, states FOUND INTERNAL HARDWARE FAULTS. But are stating its costs 2300.00 to fix. This is a huge safety issue.Ive been having to guess when my oil is low and when my tires are low. This has been going on since September 2023, the car was only bought in May 2023.

While driving on freeway in 109 degree temp the service engine light came on. Proceeded with trip home (approx 2 hrs). Made a service appt online with Mini of Stevens Creek which was for 3 days later. Upon inspection it was found that vehicle had multiple problems. Service Advisor would not allow me to drive vehicle home while awaiting parts that were on B/O. Estimated it could be as long as 2 months before repaired because there were 391 units coming in next delivery but my vehicle was number 403 on the list requiring this part and would have to wait for the following months delivery. I was quite alarmed of the repairs needed since my vehicle has <28,000 miles and well maintained.

The horn does no longer work. Had to press harder and harder on the horn button and in different places as time went on. Also have the same problem in a 2005 Mini Cooper.

TL* THE CONTACT OWNS A 2015 MINI COOPER. WHILE DRIVING 35 MPH, THE CONTACT STOPPED AT A TRAFFIC LIGHT AND THE ENGINE SHUT OFF. THE CONTACT STATED THAT UNKNOWN WARNING INDICATORS ILLUMINATED AFTER THE FAILURE OCCURRED. AFTER MULTIPLE ATTEMPTS, THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE HOME. THE VEHICLE WAS TOWED TO BMW OF SAN ANTONIO (LOCATED AT 15507 W IH 10, SAN ANTONIO, TX 78249, (210) 732-7121) WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED THREE TIMES. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 37,816.

TL* THE CONTACT OWNS A 2015 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS AND ATTEMPTING TO UTILIZE THE HORN, IT FAILED TO SOUND. THE CONTACT STATED THAT THE HORN WOULD WORK ONLY IN CERTAIN AREAS ON THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS APPROXIMATELY 22,000.

On display I am getting warning " secure vehicle with parking brake when stationary" whereas my car is in park position with hand brake applied. The warning still shows up. The gearbox works fine the car drives fine. Its the warning that doesn't seem to go away. On diagnostics is shows code "420106" . DEFECTIVE GEAR SHIFT LEVER SPRING

Warning light to secure vehicle against rolling when placed in park. Alert of a danger situation.

TL* THE CONTACT OWNS A 2015 MINI COOPER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN PARK, THE GEAR SHIFTER FAILED TO ENGAGE PROPERLY. SECURE GEAR ROLL- A-WAY WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE GEAR BOX NEEDED TO BE REPLACED. MINI COOPER (8360 MIRAMAR PL STE A, SAN DIEGO, CA 92121, (858) 535-9999) WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT UNDER RECALL. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V789000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER HAD NOT BEEN NOTIFIED THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 25,000. THE VIN WAS NOT INCLUDED. ## VIN FAILED ## 2015 MINI COOPER ##

PREMATURE CLUTCH FAILURE 34,500 MILES, WHILE THE DEALER REPAIRED THE PROBLEM UNDER WARRANTY THEY INFORMED ME ABOUT THE CLUTCH BEING TOO SMALL TO DOWNSHIFT THE CAR TO SLOW DOWN. I DIDN'T SPEND NORTHWARDS OF 40K ON A SPORTS CAR ONLY TO BE TOLD ALL SLOWING DOWN SHOULD BE DONE WITH THE BRAKING SYSTEM. YOU BUY A STICK SHIFT CAR TO BE ABLE TO DO THESE THINGS NORMALLY. TO BE TOLD BY THE DEALERS SERVICE REPRESENTATIVE THE CLUTCH IS INADEQUATE FOR THIS NORMAL DRIVING PRACTICE WAS QUITE A SURPRISE HAD THE SALESPERSON TOLD ME THIS I WOULD NOT HAVE PURCHASED THE VEHICLE. I GUESS THE REAL SURPRISE WILL BE WHEN IT GOES OUT AGAIN AND I HAVE TO PAY TO HAVE A DESIGN FLAW REPAIRED AT MY OWN EXPENSE. THIS CLUTCH PROBLEM SEEMS TO BE PREVALENT IN THE ALL WHEEL DRIVE VERSION WHERE APPARENTLY THE FRICTION COEFFICIENT OF 4 WHEELS TO THE PAVEMENT EXCEEDS THAT OF THE CLUTCH.

WHILE IN BUMPER TO BUMPER TRAFFIC CAR LUNGED WHILE ACCELERATING. WAS AT A COMPLETE STOP THEN LIFTED OFF BRAKE AND BEGAN TO FEED IN GAS WHEN THE TRANSMISSION SHIFTED FROM FIRST TO SECOND (AUTOMATIC TRANSMISSION) THE CAR LUNGED OR JUMPED FORWARD. THE ACTION WAS SO SEVERE MY FIRST ACTION AFTER HITTING BRAKES WAS TO CHECK REAR VIEW MIRROR THINKING I HAD BEEN REAR ENDED. CAR HAS 19700 MILES AND WENT INTO OTTOS MINI FOR EVALUATION AND REPAIR OF OTHER ISSUES AND WAS TOLD TRANSMISSION IS IN NORMAL WORKING ORDER. HOWEVER MY SERVICE ADVISER TOLD ME THAT SHE PERSONALLY HAD EXPERIENCED THE SAME ISSUES AND THAT ITS DUE TO TOO MUCH TECHNOLOGY IN THE CARS.

What component or system failed or malfunctioned, and is it available for inspection upon request? CONTROL ARMS AND BUSHINGS How was your safety or the safety of others put at risk? CONSTANT CREAKING AND CLUNKING OF FRONT SUSPENSION Has the problem been reproduced or confirmed by a dealer or independent service center? MANY OTHER OWNERS OF THE SAME YEAR AND GENERATION HAVE THIS SAME ISSUE Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NOT YET Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO

Engine Mount and right control arm bushings have cracked and need to be replaced below 60,000 miles and only being 4 years old.

TL* THE CONTACT OWNS A 2015 MINI COOPER. WHILE DRIVING AT HIGHWAY SPEEDS, THE CONTACT NOTICED AN ABNORMAL ROARING NOISE FROM THE REAR DRIVER SIDE OF THE VEHICLE. WHEN MAKING A TURN OR DRIVING OVER BUMPS AND DIPS IN THE ROAD, THE TIRES LOST TRACTION WITH THE ROAD AND CAUSED THE VEHICLE TO SKIP. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED AS A SUSPENSION FAILURE. THE VEHICLE WAS REALIGNED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 9,000. UPDATED 09/09/15*LJ UPDATED 11/27/2017*CN

Without any warning lamps,The vehicle started pulling left when the brakes were applied a certified mechanic looked at it and feels that is the due to a defective DSC/ABS control unit. The unit hasn't been otherwise inspected but is available for inspection

TL* THE CONTACT OWNS A 2015 MINI COOPER. THE CONTACT STATED THAT THE BRAKE SENSOR WARNING INDICATOR ILLUMINATED, BUT THERE WAS NO BRAKE FAILURE. THE VEHICLE WAS TAKEN TO HABBERSTAD BMW (945 E JERICHO TURNPIKE, HUNTINGTON STATION, NY 11746) WHERE IT WAS DIAGNOSED THAT THE BRAKE SENSORS NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALSO CONTACTED AND DECLINED TO ASSIST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 58,000. *TT *TR

COMING UP TO AN INTERSECTION, THE CAR STARTED TO SLOW NORMALLY. THEN THE ABS KICKED IN AND THE CAR DID THE SHUDDER LIKE WHEN THE ABS IS ACTIVE. THEN THE ABS TURNED OFF AND THE BRAKES WENT SPONGY. THE CAR ROLLED INTO THE INTERSECTION THROUGH THE STOP SIGN. THIS HAPPENED SEVERAL MORE TIMES. WE BROUGHT THE CAR TO MINI OF AUSTIN IN TEXAS. THEY COULDN'T FIND ANYTHING WRONG. NO CODES WERE THROWN. MY WIFE TOO THE CAR BACK, AND DRIVE BACK TO SALT LAKE CITY, UTAH. SHE EXPERIENCED SUBSEQUENT IDENTICAL BRAKE FAILURES. WE TOOK THE CAR INTO MINI OF MURRAY. THEY HAVE HAD THE CAR A MONTH, AND CANNOT DUPLICATE THE ISSUE. CORPORATE MINI WILL NOT AUTHORIZE ANY PART REPLACEMENT AT ALL. THEY WANT US TO TAKE THE CAR BACK. I DON'T FEEL THAT IS A SMART OR SAFE IDEA.

Lower Engine Support and Passenger Engine Mount damaged as per routine inspection by dealer in Feb2025. Never diagnosed before. Repair done by independent service center in Feb2025 and I have receipt of approximately 1K. Also, since 22feb2025, I am not able to add fuel to the tank because the pump stops constantly and causes spill of fuel. This can cause fire. Never happened before. Tried at least 4 different gas station and same result. Dealer charges over $200 to perform inspection/diagnostics. Not done yet. Repairs to fuel tank are in the thousands. No warning in the car dashboard for none of the issues. Car with less than 80k miles.

EXCESSIVE CARBON BUILD UP ON ENGINE INTAKE PORTS AT 35K MILES. CAR PURCHASED NEW, HAS OIL CHANGES BY DEALER EVERY 5K MILES, AND IS FILLED WITH 92 OCTANE GAS. LOTS OF PEOPLE POSTED ON INTERNET OVER LAST 7-8 YEARS THAT MINIS ARE PRONE TO THIS ISSUE AND BMW HASN'T RESOLVED IT. WHEN ASKED IF THIS SHOULD BE ROUTINE MAINTENANCE, IF THIS WAS DRIVING OR FUEL ISSUES, DEALER SAID NONE OF THE ABOVE. YET RESOLVING THIS ISSUE IS ABOUT A $600-1000K REPAIR! THIS EITHER NEEDS TO BE A ROUTINE MAINTENANCE, RECALL OR SERVICE BULLETIN PUT OUT TO OWNERS/DEALERS. BMW NEEDS TO OWN UP TO THIS ISSUE.

While driving the rear view mirror suddenly tilted downward (drooped). What happened, was that the tension ring popped off. As it turns out, this is a known issue per internet Mini Cooper pages. On hot days the ring loosens and, since the design does not include anything to prevent the ring from sliding off, it does slide off, resulting in the rear view mirror drooping. I reinstalled the ring. This occurred again the next day. I ended up uninstalling the rear view mirror, reinstalling the ring and gluing it in place. Thus far this has held.

The contact owns a 2015 Mini Cooper. The contact stated that while driving at an undisclosed speed, the rear convertible glass suddenly separated from the convertible compartment and fell on the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or local dealer. The contact stated that while searching online, he became aware that the failure had been a very well-known failure since 2017 with similar vehicles. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 62,000.

On July 12 early morning hours I left Maryland drove to Augusta GA and continued on to Decatur GA totaling 704 Miles. Within an hour of me arriving to Atlanta, I attempted to leave the house again and the car would not crank. I had it towed to Global Mini there in Chamblee, GA. The key stopped communicating with the car, and I was asked to give them my spare key-I did not travel with my spare key and the key fob design does not have a replaceable battery per the dealership the fob is designed to charge while driving. I had to pay for someone to overnight my second key-which did crank the car. I had to purchase another key and I had to rent a car until they ordered another key to have sent to the dealer because the dealer does not make keys. This is a safety issue because i made several stops for gas and restroom breaks and what if this happened in the middle of nowhere? It was a scary situation and I feel that we should have been notified as owners that this could be a possible event. I purchased this vehicle brand new in 2015.

CPSC:

The contact owns a 2015 Mini Cooper. The contact stated that after the vehicle was taken to a local dealer for a routine oil change, the mechanic also determined that the valve cover gasket needed to be replaced and an unknown engine software needed to be updated. The vehicle was not repaired. The manufacturer was made aware of the failure, and the contact was advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 78,000.

When refueling, nozzle kept shutting off, a gallon was pumped after nine attempts, also fuel erupted as the fill tube was filled with gas. reluctant to drive this car not knowing how much gas is in the tank. The needle shows less than 1/4 and miles remaining fluctuates between 80 and 110 miles. We are told that this problem exists in many mini automobiles, dealer has replacement gas tanks, but same problem exists Parking our Mini, indication of "roll back" is possible when car is parked. Shifter unit was replaced due to torsion spring.

The proportioning value that controls brake function had a catastrophic failure and caused the brake calipers especially the left front to lock suddenly. The caused the left front wheel to lock and caused the car to pull hard to left and become difficult if not impossible to control. The car pulled hard left and risked the car moving uncontrollably into on coming traffic. The failed part was saved and is available for inspection. The safety of the driver(my wife) was put at risk during the loss of control of the car. Other cars in the area were also put at risk simply due to the loss of control of our car. The problem was confirmed by the independent service center. The vehicle was not drivable and was towed to the dealership. The dealership thought the root cause was the brake master cylinder. This turned out not to be the case. The root cause was the failed proportioning valve. This caused the calipers to lock. The discs, rotors, calipers and proportioning value were replaced. There were no warning lights and the car had been taken for regular service at the dealership which was included in the purchase of the car. We were told that there is no warning light for a failure of this part.

12/19/19 I BROUGHT MY VEHICLE TO HAVE 2 FRONT TIRES REPLACED HAD THEM MOUNT AND BALANCED AND A FRONT ALIGNMENT DONE. THE DEALER ALSO COMPLETED MULTI POINT VEHICLE CHECK. I GET HOME. THE CAR SITS STILL SATURDAY. I START IT SATURDAY AT 1:30PM AND GET READY TO PULL OUT OF DRIVE WAY. WARNING LIGHT COMES ON DASH STATING BATTERY IS NOT CHARGING. STOP CAREFULLY. CONSULT NEAREST SERVICE CENTER. I CONTACTED SERVICE ADVISOR. HE STATED TO DRIVE IT BACK AND THEY WILL GIVE A LOANER. I SAID NO! THE VEHICLE ISN'T DRIVE ABLE AND I DON'T FEEL SAFE. HE STATED THEY CLOSE IN 30 MINUTES. I WANTED TO SPEAK TO UPPER MANAGEMENT. NO ONE WAS AVAILABLE HE STATED. I SAID I WOULD CALL BACK MONDAY DECEMBER23 2019. I SPOKE TO RECEPTIONIST WHO MAKES APPOINTMENTS. SHE HAD AVAILABLE SPOT ON THURSDAY DECEMBER26,2019. I TOLD HER I WILL HAVE IT TOWED THAT THURSDAY. I GET THERE TOLD THEM ABOUT THE MESSAGE THAT CAME ON DASH. I WAS GOING TO HAVE TO REPLACE BATTERY AND NEEDED A BRAKE FLUSH AND OH BY THE WAY LOOKS LIKE YOUR PULLEY WENT OUT. THE VEHICLE ONLY HAD 37,502 MILES. I HAVE NEVER HEARD OF A PULLEY BEING REPLACE AT THIS MILEAGE. I CONTACTED CUSTOMER RELATIONS FOR BMW MINI THAT FRIDAY. THEY SAID THEY WILL CONTACT IN 1 BUSINESS DAY. THEY DID SAY THERE IS AN OPEN CASE. THEY WILL CONTACT JAN 7. I WAS IN A LOANER FOR 6 DAYS. I SPOKE TO SERVICE MANAGER TUES 31,2019 WHICH WAS NEW YEAR'S EVE. SHE STATED THE DEALERSHIP WILL GIVE 20% DISCOUNT AND BMW MINI WILL STILL CONTACT ME IF THEY ARE GOING TO ASSIST. I MENTIONED TO THEM ABOUT THE DEFECTED PULLEYS ON 2002 THRU 2006 MODELS. THEY WILL LOOK INTO IT.

2015 MINI COOPER. CONSUMER WRITES IN REGARDS TO TREAD ON TIRES BEING WORN AT ONLY 10,000 MILES. *LD *TR

I GOT THE AIR BAD WARNING A FEW MONTHS AGO WHILE DRIVING THE SIGNAL WITH A LIL AIRBAG ON MY DASH BOARD. I CALLED THE DEALER TOOK IT IN AND THE DEALER SAID MY CAR WAS OUT OF WARRANTY. THEY DIDN'T CHECK TO SEE IF THIS ISSUE WAS A RECALL THEY JUST CARED ABOUT FIXING IT IF I PAID THEM. SINCE THEN I GET THE AIRBAG WARNING EVERY TIME THE CAR IS ON.

THE REAR VIEW MIRRORS ON THE DOORS ARE BOTH MOUNTED TOO LOW FOR OVER HALF OF THE SEAT HEIGHT ADJUSTMENTS. YOU CAN NOT SEE CARS APPROACHING AS MIRROR IS BLOCKED BY THE DOOR FOR ANYONE UNDER 5FT 9INCHES OR SO.

TL* THE CONTACT OWNS A 2015 MINI COOPER. WHILE ATTEMPTING TO UNLOCK THE TRUNK WITH KEY FOB, THE TRUNK FAILED TO UNLOCK. THE CONTACT STARTED THE VEHICLE IN THE HOPE THAT IT WOULD UNLOCK THE TRUNK. WHEN THE CONTACT BEGAN TO WALK TOWARDS THE REAR OF THE VEHICLE, IT BEGAN TO ROLL DESPITE THE EMERGENCY BRAKE BEING ACTIVATED. THE VEHICLE CONTINUED TO ROLL OVER A LARGE CURB AND LANDED INTO THE FOUNDATION OF A NEIGHBORING HOME. THE VEHICLE RECEIVED DAMAGE TO THE REAR BUMPER AND UNDERCARRIAGE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE BACK HOME. THE CONTACT STATED THAT THE BRAKE AND DRIVE TRAIN WARNING INDICATORS WERE ILLUMINATED. THE CONTACT NOTIFIED THE INSURANCE COMPANY AND DEALER. THE DEALER WAS UNABLE TO IDENTIFY THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 14,000.

I MADE A RIGHT TURN FROM THE MAIN STREET, INTO THE PARKING LOT OF A STRIP MALL, THEN AN IMMEDIATE LEFT TURN, AND ANOTHER RIGHT TURN INTO THE RIGHT ANGLE PARKING SLOT. ALL THE WHILE HAVING MY FOOT ON THE BRAKES, I STARTED TO SHIFT INTO PARK, WHEN IT WAS IN THE RIGHT SPOT. THE MINI INSTEAD COMING TO A STOP, REVVED UP, JUMPED THE CURB AND HIT THE STORE IN THE FRONT. THE AIR BAGS DEPLOYED. I HAD MY FOOT ON THE BRAKES REALLY HARD, ALL THE TIME BUT THE BRAKE PEDALS WERE LOCKED UP. IT WOULD NOT MOVE UP OR DOWN. SAT HARD ON THE FLOOR! WHEN THE TOW TRUCK CAME, THE BRAKES WERE STILL LOCKED UP AND THE GEAR WAS IN PARK AND COULDN'T BE MOVED FROM THERE. THE SEAT BELTS COULDN'T BE RETRACTED EITHER. MINI ENGINEER CLAIMS THAT THERE IS NOTHING WRONG WITH THE CAR AND I CAN SAFELY DRIVE IT AFTER THE BODY IS REPAIRED. I AM HAVING A DIFFICULT TIME WITH THIS CONCLUSION. THE CAR'S BRAKES AND GEAR WERE LOCKED UP, AND HAD TO BE LIFTED ON A FLATBED AND TAKEN TO THE REPAIR SHOP; I STILL MAINTAIN SOMETHING WITHIN THE CAR MALFUNCTIONED. *TR

TL* THE CONTACT OWNS A 2015 MINI COOPER. WHILE DRIVING AT A LOW SPEED, THE CONTACT NOTICED AN ABNORMAL ODOR COMING FROM THE AIR VENTS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ODOR WAS COMING FROM THE MICRO FILTERS IN THE AIR CONDITIONER. THE TECHNICIAN ALSO DIAGNOSED THAT THE AIR CONDITIONING SYSTEM NEEDED TO BE CLEANED. THE VEHICLE WAS REPAIRED MULTIPLE TIMES; HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,670.

IN NOV-2014 MY SON WAS DRIVING OUR '05 MINI COOPER DOWN THE INTERSTATE AT 55MPH AND ALL OF A SUDDEN THE STEERING STOPPED WORKING. HE WAS BARELY ABLE TO CONTROL THE CAR AND GET IT TO THE SIDE OF INTERSTATE. HE WAS 17 YRS OLD AND IT WAS VERY HARD FOR HIM TO STEER IT AND GET OUT OF TRAFFIC. HE WAS EXTREMELY FRIGHTENED. WE THEN GOT THE CAR TO A REPAIR SHOP (NOT THE LOCAL MINI SHOP, SINCE THEIR LABOR RATE WAS TOO HIGH), WE HAD TO PAY $1,201.75 TO REPAIR THE STEERING. AFTER RECEIVING A LETTER REGARDING THE STEERING RECALL FROM MINI CORPORATE IN EARLY 2016, WE WERE TOLD TO CALL/GO TO THE LOCAL MINI DEALER AND THEY WOULD HANDLE THE CLAIM. AFTER SEVERAL CALLS, EMAILS, AND A PERSONAL VISIT TO THE KNOXVILLE, TN MINI COOPER DEALER, I HAVE GOT NOWHERE. THEY REFUSE TO HANDLE THE CLAIM (ONCE TELLING ME THAT IT HAD BEEN SUBMITTED TO MINI CORPORATE, BUT THEN IT TURNS OUT THEY ADMITTED THAT IT NEVER WAS SUBMITTED)... THEN MOST RECENTLY BASICALLY THEY TOLD ME TO LEAVE THEM ALONE. THEY WILL NOT GIVE ME PROOF THAT THE CLAIM WAS SUBMITTED (WHICH I AM GUESSING IT HAS NOT BEEN), AND NOW THEY WILL NOT ANSWER MY EMAILS. CAROL HWANG AT KNOXVILLE MINI HAS BEEN VERY RUDE AND UNCOOPERATIVE. THEY REFUSE TO GIVE ME A CONTACT AT CORPORATE, AS I'VE REQUESTED, TO CONFIRM THE CLAIM HAS BEEN SUBMITTED AND TO FOLLOW UP ON GETTING REIMBURSED FOR THIS REPAIR RELATED TO THE RECALL. WHEN I CALLED CORPORATE MINI, THEY SAID I HAVE TO DEAL WITH THE LOCAL MINI SHOP. LOCAL MINI SHOP IN KNOXVILLE SAYS CORPORATE WILL HANDLE THE CLAIM. SO I AM GETTING NOTHING BUT A RUN-ROUND. THIS INCIDENT WAS VERY SCARY FOR US! MY SON COULD'VE BEEN KILLED WHEN THE STEERING WENT OUT. HE WAS TERRIFIED AND THOUGHT HE WAS GOING TO GET HIT AND CRUSHED BY A SEMI TRUCK. THE WHOLE THING WAS AWFUL. NOW ALL I WANT TO DO IS GET REIMBURSED FOR THE REPAIR, BUT I CANNOT GET MINI COOPER TO COOPERATE. PLEASE HELP.

I PURCHASED MY MINI COUNTRYMAN ON FEBRUARY 14, 2015 FROM THE LOCAL MINI DEALERSHIP. AT APPROX. 1447MILES, 7 MONTH INTO OWNERSHIP, I BEGAN HAVING TROUBLE WHEN TURNING ON THE CAR (THE CAR WAS STATIONARY) THE WARNING LIGHTS CAME ON FOR BRAKES, ABS AND TRACTION CONTROL AND REMAINED ON UNTIL CAR WAS TURNED OF REPEATEDLY OR DIVEN FOR A MILE AND THEN TURNED OF. I TOOK MY CAR BACK TO THE DEALERSHIP FOR REPAIRS ON: 10/02/2015 NO FAULTS IN THE ELECTRICAL SYSTEM WAS FOUND AND I WAS ASKED TO RETURN WHEN IT REOCCURS. 12/03/15 A FAULT MEMORY AND FAULTY R/F WHEEL SPEED SENSOR WAS DIAGNOSED, SENSOR WAS NOT IN STOCK. 12/04/15 I RETURNED WITH MY CAR TO HAVE THE FAULTY WHEEL SPEED SENSOR EXCHANGED. 12/05/15 TO 12/10/15 FAULTY RELUCTER WHEEL ON THE R/F WHEEL HUB, WHEEL SPEED SENSOR READINGS OFF, SIGNAL SCOPED AND R/F WHEEL HUB REPLACED. 12/28/15 AND ONGOING. ON 1/05/2016 MINI USA HAS GIVEN ME VERBAL ASSURANCE THAT I WILL GET THE CAR REPLACED WITH A NEW MINI OF MY CHOOSING.

MY 2015 MINI COOPER 4 DOOR HARDTOP WAS PARKED IN MY GARAGE. I STARTED IT BUT HAD NOT PUT IT INTO GEAR YET. I OPENED THE DOOR AND GOT OUT (CAR DIDN'T BUDGE) AND AS I WALKED BACK TOWARDS THE REAR, THE CAR LURCHED OUT OF PARK AND REVERSED WHICH CAUSED IT TO PIN ME IN BETWEEN THE CAR AND THE GARAGE BEAM AS IT CONTINUED TO ROLL QUICKLY BACKWARDS AS IF SOMEONE WAS ACCELERATING. WHEN CONTACTING MINI, THEY HAD ONE OF THEIR INSPECTORS COME (NO DOCUMENTATION PROVIDED TO ME). I WAS CALLED (AGAIN NO DOCUMENTATION) AND TOLD THAT THE ENGINEER FOUND NO FAULT IN THE TRANSMISSION OR ELECTRICAL SYSTEM AND THAT THIS WAS NOT A DEFECT. THEY HAVE SINCE BEEN UNRESPONSIVE WITH PROVIDING DOCUMENTATION, HAVEN'T BEEN ALE TO ACQUIRE PARTS TO FIX MY DAMAGED VEHICLE AND REFUSE TO ACKNOWLEDGE THAT THERE IS SOMETHING WRONG WITH SELLING A CAR THAT CAN KILL PEOPLE AND TO NOT HAVE PARTS FOR 4 MONTHS! I HAD MY CAR FOR A TOTAL OF 2 MONTHS TOTAL DRIVE TIME. IT'S BEEN IN THE SHOP FOR 4 MONTHS WITH NO RESOLUTION IN SIGHT.

TL* THE CONTACT OWNS A 2015 MINI COOPER. THE CONTACT STATED THAT HE NOTICED THAT THE FRONT PASSENGER AND THE DRIVER SIDE CARPET WAS EXTREMELY WET. THE VEHICLE WAS TAKEN THE DEALER WHERE THE TECHNICIAN DRAINED THE TUBE LEADING FROM THE AIR CONDITION UNIT, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 4,500.

CPSC: MINI COOPER: CONSUMER STATED THE CRUISE CONTROL WOULD DISENGAGE. *SS THE CONSUMER STATED DISCOVERED WHEN USING THE CLUTCH AND DOWN SHIFTING THE CRUISE CONTROL DID NOT DISENGAGE. THE FIRST TIME HE TRIED THE CRUISE CONTROL, WHILE DOWN SHIFTING THE VEHICLE MAINTAINED SPEED AND SHOT FORWARD INSTEAD OF SLOWING DOWN. *JB