2025 KIA EV6 Problems

VIN Decoder

Premium Report

Complaints Reported

Complaints by Component

ELECTRICAL SYSTEM

13 complaints

While driving Friday 4/17/26, I heard a pop and the car displayed a message to "Check electric vehicle system." The car seemed to still drive so I drive it home. That evening the car would not charge. I called Jim Shorkey Kia on 4/18/26, where I bought the car, to schedule the car to be looked at. They told me to bring it in on Monday and they will try to squeeze me in so they can diagnose the issue. Later that morning, I took that car out and made it about a block away before the car displayed a new message to "Stop vehicle and check power supply." At this point, the car went into a limp mode, barely moving. I was able to turn around and drive it home. Had I been on the highway, I might have been put in a dangerous situation. Now that the car has been diagnosed, the service department called and told me that the failed component was the ICCU. From what I've read, Kia claims that 1% of cars suffer from this issue. However, this percentage seems unlikely due to the number of online complaints. I wanted my experience to be an official documented case of this since I've heard that Kia has issued limited recalls in other countries and on older model Kia EV6's in the US.

Apr 21, 2026

I START VEHICLE AND TRY TO PUT TRANSMISSION TO DRIVE ITS NOT WORKING AFTER I TRY TO PUT VEHICLE TO REVERSE TRANSMISSION ITS NOT WORKING

Apr 17, 2026

ICCU and fuse failure when it was being moved out from the garage. Got a “Check electrical system” notification when I turned it on following a level 2 charge the night before. It was with the dealer for exactly one month before I was able to pick it back up.

Apr 11, 2026

While driving on a sunny day on a 35mph road, my dashboard reported “Check Electrical Vehicle System”. A red battery symbol appeared and my cruise control disengaged with a message “requirements not met”. When I got home I read my 12 volt battery monitor that reported the battery was 11.99v and only had a 60% state of charge. Just prior to this short drive from home, my battery was 12.77v and had a 100% state of charge. I put in my ODB reader and it provided two error codes: P1A9096 and P1A961C. The first error code is the result of an ICCU failure in its DC to DC circuit (the one that charges the 12V battery from traction battery). Using a battery charger, I was able to fully recharge the 12volt battery. My monitor says that it’s healthy with 100% state of charge. Turning the car back on resulted in a rapid drain of the battery from 100% to 93% in just five minutes while parked. The electrical system failure warning lights are still lit. I’m having my car towed for repair. If this failure had occurred more than 10 minutes from my home, I would’ve been stranded.

Apr 08, 2026

The ICCU unit failed and the car first slowed and then stopped. I was able to pull off the road at an intersection. A tow truck had to jump charge the battery to allow the car to be shifted into neutral in order to pull it onto the tow truck.

Mar 17, 2026

+ 8 more complaints for this component

POWER TRAIN,ELECTRICAL SYSTEM

5 complaints

ICCU replaced after 5 months of purchasing new and less that 7,000 miles.

Apr 08, 2026

ICCU failure. Car lost power while driving. I heard a "pop" sound and then the car displayed a warning light moments before losing power. Car was towed to the dealership where they diagnosed and replaced the ICCU and a fuse. This is a known problem since the 2022 model year and seems to be a very common failure that the manufacturer is unable definitively repair. Thankfully I was on a local street and not on a highspeed highway when this occurred.

Mar 18, 2026

When shifting from reverse to drive there was a loud pop towards the back up the car. A check electrical system warning popped up, and then eventually a Check Power Supply stop now warning came up. The vehicle would not go above 26MPH and had to be stopped in a parking lot to be towed to the dealership. The ICCU went out and needed to be replaced, was at the dealership for 2 weeks for replacement.

Mar 05, 2026

After 2474 miles, the vehicle Integrated Charging Control Unit (ICCU) failed in my 2025 Kia EV6 making the vehicle undrivable so it had to be towed to the Kia dealer. The ICCU was replaced under warranty. The failure of the ICCU in Kia, Hyundai and Genesis electric vehicles is fairly common and they have yet to come up with a permanent solution.

Dec 29, 2025

ICCU failure caused loss of power on interstate. I almost got in a wreck because of this. Kia dealer refused to look at my car. Took vehicle to independent repair shop who diagnosed issue.

Aug 16, 2025

UNKNOWN OR OTHER

4 complaints

KIA has created a safety hazard by removing the ability for the driver to select LIGHT or DARK mode for the two 7" data and infotainment screens in their 2025 and forward EV6 electric cars. Like many, I have to drive in very fast busy commuter traffic on highway I-66. (exaserbated by driving into the sun in the AM) The DARK mode screens have insufficient contrast even with the screen lighting turned all the way up. It takes the drivers eyes away from the road longer than is safe, particularly in high speed freeway commuter traffic. This is seriously exacerbated if the driver uses sunglasses because of the sun. This is obviously not an issue confined to highway I-66, or me.

Apr 20, 2026

The battery had an electrical system failure warning after 5900 miles and has been in the shop for over a month.

Mar 15, 2026

Was driving around 45mph when I heard a pop noise, like an over pressurized soda bottle popped open. Moments later car abruptly dropped to under 35mph and reported errors and to check battery system. Brought it into dealer and they confirmed my ICCU failed and had to be replaced.

Feb 02, 2026

Was driving home lost all power. Caution lights came on. The ICCU, relay switch, 2 fuses. went bad. It took 9 weeks for KIA to fix, no compensation.

Jan 20, 2026

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

3 complaints

ICCU failure.

Apr 02, 2026

ICCU failure

Feb 23, 2026

I was driving on the highway when I heard a pop like a loud fuse sound from the back seat area. Suddenly the car dropped 15 mph from 70 mph to 55 mph and the battery and electrical system warning lights came on and the vehicle said check electrical system. I was able to continue with my hazard lights on to exit the highway, at which point the max speed of the vehicle dropped to 45 mph. It would not go faster no matter how hard I pushed the gas pedal. I was able to pull over to a gas station and park in a spot but the vehicle had to be towed. When the tow truck arrived, the vehicle also flashed with the 12V battery low warning. It was diagnosed as a failed ICCU, which rapidly drained the 12V battery. The car is only 4 months old with about 7,300 miles. This is a serious safety concern, especially with the sudden failure and loss of power. I’m lucky I wasn’t hit and that I was able to get off the road before it totally died.

Dec 29, 2025

FUEL/PROPULSION SYSTEM

3 complaints

I was driving my car and the stop immediately and check battery sign came on. I had to have my car towed to the dealership. I read that the ev6 have ICCU problems and commonly need to be replaced. The car lost all acceleration and power and eventually stopped moving all together.

Mar 10, 2026

ICCU failure. Pulled out of driveway, heard a pop, received warning to pull over and check vehicle power. Car had to be towed to dealership but they are experiencing so many of these failures that they are extremely backed up on even being able to check out the car.

Mar 03, 2026

While driving on a busy road at night, my vehicle displayed battery warning lights and went into "limp mode" which slowed me down to 25 mph before stopping completely. I was then stranded until a tow truck could be dispatched. The Kia dealer told me that the issue was an ICCU (integrated charging control unit) which they have to order. I have since learned that this issue is known and is common.

Jan 27, 2026

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

3 complaints

ICCU failure within three (3) days of buying vehicle. Only 300 miles on it. Failed to charge with known working Level 1 charger on day 1, successfully charged with Level 3 charger on day 2, and then failed to charge at same Level 3 charger on day 3. Simply connecting the Level 3 charger on day 3 had the car emitting "charger errors", and then followed that up with an "On board charger" fault. Vehicle no longer charges. Returned to dealer for repair.

Mar 09, 2026

I have experienced a ICCU failure at 7200 miles on my 2025 EV6 GT Line. This failure is a safety hazard as it will quickly disable the vehicle and strand the occupants wherever they be at the time of failure. (highway, back roads, day or night). There are warning lights when this occurs, but there is a very limited time to get to safety, depending on the state of charge of the onboard 12v battery. This issue has been ongoing since this vehicle came out in 2022. There have been a number of recalls to address the problem, but apparently without success. I see postings all the time with others experiencing this failure. When I inquired about the availability of the replacement ICCU, I was told that the part was on national back order. I was also told there were 147 units in transit, 47 were already spoken for. This seems to indicate that this is a very common issue, affecting many drivers.

Feb 09, 2026

Power completely dropped while driving in traffic. This occurred several times. I could have easily been rear ended. Also, I could have been stuck within an intersection, I could have been broadsided. I see researched this issue and found it was widely written about in KIA EV6 online forums. Kia should have checked for issues before I leased the 2025 EV and informed me before I made a decision to lease vehicle. This occured in first weeks I drove the new car.

Sep 14, 2025

STEERING

1 complaint

Steering rack need to replace after drive almost 1900 miles. It has knocking nosie when turn the wheel, the car had been in the shop for three weeks.

Apr 20, 2026

VISIBILITY/WIPER

1 complaint

Windshield cracking on new Kia EV6 with only 2700 miles. Was 53 degrees outside so no defroster excuse. Seems to be a stress crack and looking online in KIA EV6 Forums, I've noticed it is not a one-off problem as many owners have had to deal with this.

Mar 13, 2026

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

1 complaint

The ICCU unit failed. Limited speed and no charging capabilities. The Dealer has been informed and an appointment has been made 3 weeks out as they are too busy. The ICCU has not been inspected yet. No warning lamps or messages appeared before the problem started. After a loud POP or bang in the rear of the car 1 warning light appeared and 1 message. (See Attached) POP happened at 16:15 hrs on the attached graph.

Feb 25, 2026

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

1 complaint

initially filed XXX (1/2/2026) 2nd (additional info) filed XXX (2/10/2026 3rd (3 page service report) XXX (2/11/2026) Vehicle is registered to Christopher Rojik, however it is my car that I drive, etc. today I am filing this for you folks that since I filed the complaint with Kia Corp. and sent them the service report, etc. Today, 2/19/2026 I received a formal Settlement Agreement and General Release to sign and accept. I am not signing it, as well as it fully releases Kia from any future issues, etc. outside of the warranty and whatever other details it claims. This will or should be the last for me to file. I had no idea they send me this kind of offer. As it is listed specifically as a "GOODWILL GESTURE" and they are not accepting fault or something like that. I attached inidividual pages, hopefully I can upload them as pdfs, we will see. If not I'll take quick pics and attach. thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Feb 19, 2026

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

1 complaint

initial filed #11708370 (1/2/2026) 2nd filed #11717025 (2/10/26) Yesterday afternoon (2/10/26), I was told by Jim Shorkey Kia Wexford PA that no error codes are on the EV6, it is ready for pick up. Before I received this call, there was a software update done on the EV6 (see service records) I attached 2 photos of the software update as well. ICCU ASSY was replaced, etc. was told per Shorkey Kia since there are no issues with my EV6, as of Friday when they initially called to say my vehicle was ready for pick up, Kia considers my problem resolved. I know I’ll be paying for the car rental for X number of days, even though the EV6 did not get the software update until this past Tuesday, yesterday 2/10/26, which cleared the 3 codes that were still showing on the Kia app earlier morning yesterday, screenshot of that attached as well. I have my car, no codes visible now.

Feb 11, 2026

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

1 complaint

prior case 11708370 filed 1/2/2026 spoke with [XXX] 1/22/2026. Friday 2/6/2026 Shorkey Kia Wexford calls and tells me my EV6 is fixed I can pick it up. I go into the Kia App and still have the same 3 codes as before; P056216 VCU, C160404 FR_Radar, and C28B186 ADAS_DRV. I tell them later that day when I had time to open the app to make sure the codes were corrected, called them back and said until these codes are cleared, my vehicle is not fixed. Tuesday 2/10/2026 I get a called from same person at Shorkey Kia in Wexford, telling me my vehicle is fixed, I can pick up my vehicle, same person her name is Maggie. I told Maggie to hold while I bring up the Kia app, I still see the same 3 codes: P056216, C160404, C28B186. I told her the codes are still active, and as long as these codes are present, the car isn’t fixed. She wouldn’t tell me what was done to the car, so I don’t know if the ICCU was replaced or not. However from browsing the EV6 Owners USA group, [XXX] had the same issue, and his car was fixed per whatever Kia place that is around him. He still has the P056216 alert and was told it will go away after whatever period of time. This is what the Kia repair place told him. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Feb 10, 2026

POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

1 complaint

Erratic behavior before pulling out of parking lot: STOP vehicle check power, check 12V battery Stop safely engage parking brake. All dash lights started flashing, going black, power couldn’t be maintained, thankfully not on highway yet. Complete car failure, had to have 2025 EV6 jumped 4 times, battery still showed 41% charged, couldn’t keep charge to even get car in neutral for tow or doors locked. After each jump from tow company, power would last for less than 3-5 seconds, then dead, completely dead vehicle nothing worked.

Jan 02, 2026

STRUCTURE

1 complaint

The rear door of my KIA EV6 intermittently fails to open even when the vehicle is unlocked. The issue has been recorded on video and reported to an authorized KIA dealer, but it has not been repaired. A child safety seat is installed in the rear seat, and this defect creates a serious safety risk in an emergency where immediate access to the child is required. The vehicle is unsafe due to this defect.

Dec 22, 2025

ELECTRICAL SYSTEM,ENGINE

1 complaint

Driving down local (residential) roads, the ICCU died; towed to dealership 12/3/2025. All 12 volt electrical was inoperable. So no hazard lights, no shift to neutral, no locking the doors. It was towed to the dealer. ICCU is now being ordered. The Master Warning light and 12V battery warning light illuminated. I was fortunate to be able to park in a parking lot just before all electrical died. An Internet search shows that this is a known issue; and, even after the replacement the situation can happen again. Took delivery 6/28/25. So, not even 6 months old.

Dec 06, 2025

POWER TRAIN

1 complaint

Issue Description: When parking facing downhill, I put the car in reverse but the car rolls forward. Feels like the car is either in drive or neutral. Concern is intermittent, and I confirmed each time it happens, gear selector is in reverse. When trying to re-engage reverse, the display shows "gear already selected." Safety risk: Car almost hit car in front of us while trying to reverse. Car was inspected by dealer service center. Could not duplicate, but found an error code. Dealership found multiple software updates available on the brand new car and installed.

Oct 26, 2025

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

1 complaint

I was driving over to walk my friends dog and I was pulling into the overflow parking area and my car just speed up and it would not stop. I went up a curb and I hit a small tree went down another curb crossed the street and then up another curb and the break would not stop the car. I finally just cut the car off

Sep 02, 2025

4.7/5.0

58 reviews

KIA EV6 VIN Decoder — Free VIN Check Video Guide

Watch our quick KIA EV6 VIN decoder walkthrough. Learn how to decode any KIA EV6 VIN number to get full vehicle history, recall alerts, specifications, fuel economy (MPG), safety ratings, and known problems — completely free on ForCar.org.

Where to Find VIN for Problems Check

To check for problems and complaints on your 2025 KIA EV6, you'll need the VIN number. Find your VIN in one of these 4 common locations.

Where to Find VIN Number on 2025 KIA EV6 for Problems Lookup - Dashboard, Door Jamb, Engine Bay, Documents

Understanding VIN Structure for Problem Reports

Each character in your 2025 KIA EV6 17-digit VIN helps identify specific complaints and problems affecting your vehicle model.

2025 KIA EV6 VIN Structure for Complaint Verification - WMI, VDS, Check Digit, Model Year, Plant Code

How to Check 2025 KIA EV6 Problems in 3 Steps

Locate Your VIN

Find the 17-character VIN on your 2025 KIA EV6 dashboard (visible through windshield), door jamb, engine bay, or vehicle documents.

Review by Component

Browse owner-reported complaints organized by vehicle component (engine, transmission, brakes, electrical) to identify common issues and problem patterns for this model year.

Check Safety Issues

Review crash and fire incidents for each component to assess safety concerns. Contact your KIA dealer or report problems to NHTSA at SaferCar.gov.

Frequently Asked Questions

How many problems does the 2025 KIA EV6 have?

The 2025 KIA EV6 currently has 42 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.

What are the most common problems with 2025 KIA EV6?

The most common problems reported for the 2025 KIA EV6 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.

Where does this 2025 KIA EV6 problem data come from?

All problem and complaint data for the 2025 KIA EV6 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.

How do I report problems with my 2025 KIA EV6?

You can report safety problems with your 2025 KIA EV6 directly to NHTSA at SaferCar.gov or call 1-888-327-4236. Your complaint helps identify patterns and may lead to recalls or investigations.

Where can I find my VIN to check problems?

Your 2025 KIA EV6 VIN is located in 4 places: (1) Dashboard near windshield on driver's side, (2) Driver's door jamb sticker, (3) Engine bay, (4) Vehicle registration and insurance documents.

Is the 2025 KIA EV6 reliable?

Reliability can be assessed by reviewing the number and severity of owner complaints for the 2025 KIA EV6. Check complaints by component, crash reports, and fire incidents above to evaluate potential issues and problem patterns.