2002 MITSUBISHI Montero Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
VIN Decoder
174
Complaints Reported
As an Amazon Associate, ForCar.org earns from qualifying purchases.
Complaints by Component
SERVICE BRAKES, HYDRAULIC
51 complaints
TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS ENGAGED AND THE VEHICLE FAILED TO SLOW DOWN. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY APPLYING FORCE TO THE BRAKES, SHIFTING INTO NEUTRAL, AND APPLYING THE EMERGENCY BRAKE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHO INFORMED THAT THE BRAKE BOOSTER WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THERE WAS A RECALL ASSOCIATED WITH A NHSTA CAMPAIGN ID NUMBER 01V254001 (SERVICE BRAKES, HYDRAULIC); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 105,451....UPDATED 07-10-13 *BF THE CONSUMER STATED THE BRAKES LOCKED UP, BECAUSE THERE WAS NO FLUID GOING TO THE BRAKES. THE REPAIR SHOP INFORMED THE CONSUMER, THE ABS BOOSTER AND HYDRAULIC PUMP NEEDED TO BE REPLACED. UPDATED 07/16/13
May 24, 2013
MY MONTERO WAS MAKING A CHIRPING NOISE. I CALLED MITSUBISHI AND TWO DEALERDS AT SAN ANTONIO TEXAS TO FIND OUT MORE ABOUT THE ISSUE. THEY TOLD ME MY VIN DID NOT HAVE ANY RECALLS OR SAFETY RECALLS AT THE TIME. LATER AFTER THE SYSTEM FAILING I CONDUCTED RESEARCH ON THE WWW AND FOUND THE HYDRAULIC BRAKE BOOSTER ACCUMULATOR WAS THE ONE LEAKING NITROGEN GAS A CAUSING THE FAULT AND THE NOISE. I CALLED MITSUBISHI AGAIN WITH INFO BUT I WAS TOLD THAT MY VEHICLE EVENTHOUGH IT WAS SHOWING THE SIGNS AND SYMPTOMS OF A BAD HYDRAULIC BRAKE BOOSTER ACCUMULATOR MY VEHICLE'S VIN WAS NOT LISTED ON THE RECALL LIST. SO THEY WERE NOT GOING TO HONOR THE SAFETY RECALL FOR MY MITSIBISHI MONTERO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
Sep 27, 2011
TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO. THE CONTACT STATED WHEN THE BRAKES WERE APPLIED, THEY MADE A SQUEAKING NOISE, THE STEERING COLUMN WOULD VIBRATE AND THE ANTI LOCK BRAKE WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER AND MANUFACTURER ADVISED THE CONTACT OF NHTSA RECALL CAMPAIGN ID NUMBER: 01V254001 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM), BUT THE VIN WAS NOT A PART OF THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 121,000 AND THE CURRENT MILEAGE WAS 121,030.
Aug 03, 2011
MY 2002 MITSUBISHI MONTERO HYDRAULIC ACCUMULATOR WAS REPAIRED DUE TO THE RECALL OF THE PART. THE HYDRAULIC BRAKE ACCUMULATOR WAS RECALLED BECAUSE IT CAN RESULT IN A LEAK OF NITROGEN GAS FROM THE ACCUMULATOR. A COUPLE DAYS AGO ON MY WAY TO WORK MY BRAKES FAILED ME ONCE AGAIN AS I WAS IN A SCHOOL ZONE FULL OF CHILDREN AND APPROACHING TRAIN TRACKS THIS TIME IT WAS BECAUSE I HAVE A GAS LEAK IN MY POWER BOOSTER WHICH OCCURRED FROM THE ACCUMULATOR WHICH WAS THE PART THAT WAS RECALLED BY MITSUBISHI. I CONTACTED MITSUBISHI TO BE TOLD THAT IT WILL NOT BE REPAIRED BY THEM EVEN THOUGH I COULD HAVE KILLED MYSELF OR SOMEONE'S CHILD. KNOWING THAT THE SAME PROBLEM WILL OCCUR WITH A DIFFERENT PART IN RESULTS OF THE PART THAT WAS RECALLED MITSUBISHI SHOULD HAVE RECALLED THE ENTIRE ABS SYSTEM NOT JUST THE ACCUMULATOR COULD HAVE STILL HAPPENED,AND DEATH COULD HAVE STILL HAPPENED. NOW I HAVE TO REPLACE MY WHOLE ENTIRE ABS SYSTEM AND THE SYSTEM ITSELF COST $1500 DOLLARS NOT INCLUDING LABOR. I DO NOT HAVE MONEY LIKE THAT TO REPAIR MY VEHICLE WHEN IT WAS NOT WEAR AND TARE OF THE VEHICLE BUT WAS CAUSED BY THEIR FAILURE ABS SYSTEM. NOTHING HAVE BEEN DONE TO REPAIR MY TRUCK. *TR
Feb 17, 2011
WHEN ATTEMPTING TO BRAKE THERE WAS A LOUD NOISE COMING FROM THE LEFT SIDE OUT OF MY DASHBOARD. THEN ALL OF A SUDDEN MY BRAKES WOULD NOT WORK. THE ABS LIGHT CAME ON AS WELL AS THE EMERGENCY BRAKE LIGHT.
Dec 29, 2010
+ 46 more complaints for this component
SERVICE BRAKES
23 complaints
I was driving down the highway, without any prior indication the brake light, and break alarm came on and my breaks went out. All at the same.
Mar 06, 2022
A/L BRAKE LIGHT GOES OFF EVERYTIME BRAKE PEDALS IS APPLIED ACCOMPANIED WITH AN ABNORMAL NOISE FROM THE DASH. THERE IS A NHTSA CAMPAIGN #01V254002 ABOUT A BRAKE BOOSTER ACCUMULATOR DEFECT. I TOOK IT TO THE DEALER FOR POSSIBLE RECALL FIX BUT GOT DENIED SINCE ITS NOT PART OF THEIR RECALL CAMPAIGN. SHOULDNT THIS BE PART OF A RECALL CAMPAIGN SINCE ITS A SAFETY ISSUE? DO I NEED TO WAIT UNTIL THE BRAKES FAIL AND GET INTO AN ACCIDENT?
Jun 29, 2018
MY MECHANIC SAID THAT THE HYDRAULIC BRAKE BOOSTER HAS BEEN MANUFACTURED IMPROPERLY WHICH RESULTED IN LEAKAGE OF THE PRESSURIZED NITRGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE RESULTED IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED AND CAN DELAY FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME AND SHOULD BE ON THE SAFETY RECALL LIST NO. SR-01-008REVII. HE SAID THIS BULLETIN SUPERCEDES SR-01-008REVI. HE SAID THAT MITSUBISHI SHOULD REPLACE THE OLD HYDRAULIC BRAKE BOOSTER ACCUMULATOR WITH THE NEW MODEL. AFFECTED VEHICLES ARE 2001-2002 MITSUBISHI MODELS PRODUCED BEFORE 6/20/01. I DON'T KNOW THE EXACT DATE MY CAR WAS PRODUCED BUT THIS IS THE PROBLEM FOR SURE. I TOOK IT TO A SECOND MECHANIC AND HE AGREED. THE CAR DOES NOT STOP PROPERLY AND I AM VERY AFRAID TO DRIVE IT.
Sep 06, 2017
TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO. WHILE DRIVING 50 MPH, THE VEHICLE MADE A CHIRPING SOUND. THE BRAKES FAILED TO RESPOND AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE BOTH MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 01V254002 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
May 01, 2017
MY MITSUBISHI MONTERO LIMITED STARTED MAKING A STRANGE NOISE FROM UNDER THE DASH WHILE DRIVING. ONE DAY WHILE DRIVING WHEN I APPLIED THE BRAKE THE PEDAL WENT ALL THE WAY TO THE FLOOR. I DID SOME RESEARCH AND FOUND A RECALL FOR THE BRAKE HYDRAULIC BOOSTER FOR THIS VEHICLE BUT MY VIN NUMBER IS NOT SHOWING A RECALL. WHEN I CONTACTED MITSUBISHI ALL THEY WOULD SAY IS IT'S NOT COVERED UNDER THE RECALL. I DON'T UNDERSTAND
Mar 27, 2017
+ 18 more complaints for this component
ENGINE AND ENGINE COOLING
15 complaints
2000 MONTERO CHECK ENGINE SOON LIGHT ON CONTINUOUSLY STEPS TAKEN, REPLACED PLUGS,WIRES, COILS, TIMING BELT, IDLER PULLEY, THERMOSTAT, ENGINE HEAT INDICATOR RISES TO HOT THAN BACK TO NORMAL, ENGINE RUN'S SLUGGISH, NO POWER, SHIFTING IS DELAYED WHEN ON AN INCLINE AND HEAR A MUFFLED BACK FIRE ON OCCASION NO POWER. THIS SUV HAS HAD PROBLEMS SINCE WE BOUGHT IT. NOT A GOOD BUY FOR SURE. *TR
May 03, 2011
I WAS DRIVING MY 2002 MITSUBISHI MONTERO LIMITED THROUGH TOWN WHEN OUT OF THE BLUE, THE LOUDEST NOISE STARTED COMING FROM THE FRONT OF THE ENGINE. YOU COULD HEAR THE NOISE FROM BLOCKS DOWN THE ROAD. TOOK IT TO A LOCAL MECHANIC WHO DISCOVERED A TECHNICAL SERVICE BULLETIN THAT STATES, "SOME VEHICLES MAY EXPERIENCE A DIESELING-TYPE NOISE WHEN THE ENGINE IS IDLING. THIS MAY BE DUE TO THE PISTON PINS CONTACTING THE CYLINDERS. INSPECT THE CYLINDERS WALLS FOR EVIDENCE OF SCUFFING." IF THIS IS THE CASE, I'M LOOKING AT A NEW ENGINE OF UPWARDS OF $5,000 - PLUS THE COST OF TOWING IT TO THE NEAREST DEALER A FIVE HOUR ONE-WAY DRIVE FROM WHERE I LIVE. I BOUGHT THE CAR AT 59,500. IT ONLY HAS 72,000 MILES NOW. I FEEL LIKE I WAS SOLD A LEMON! THE CAR IS INOPERABLE RIGHT NOW. I STILL OWE $13,000 ON IT. I'M SO SCREWED!!! *TR
Mar 12, 2008
OUR 2002 MITSUBISHI MONTERO ENGINE BLEW UP WHILE MY WIFE WAS DRIVING THE VEHICLE ON A LOCAL HIGHWAY (RT. 680(N)). THERE WAS NO INDICATION THAT THERE WAS SOMETHING WRONG WITH THE VEHICLE PRIOR TO THAT DAY (THE "CHECK ENGINE" WARNING LIGHT HAD NEVER LIT UP). AT THE TIME THIS INSTANCE OCCURRED, MY WIFE WAS DRIVING THE VEHICLE ON THE FREEWAY AS IT WENT UP IN SMOKE, ESSENTIALLY ENDANGERING HER LIFE ALONG WITH THE SURROUNDING MOTORISTS, SHOULD THIS REALLY HAPPEN TO A VEHICLE THAT IS ONLY 5 YEARS OLD. *TR
Jan 10, 2008
CRANSKHAFT BOLT SHEARED OFF WHILE DRIVING AT HIGHWAY SPEEDS CAUSING LOSS OF POWER STEERING ON ICY ROADS. THE INCIDENT ALSO CAUSED DAMAGE TO THE CRANKSHAFT SENSOR, HARMONIC BALANCER, AND TIMING BELT. THE VEHICLE WAS REPAIRED AT A LOCAL AUTOMOBILE REPAIR SHOP AND THE MECHANIC STATED THAT THE SHEARED BOLT WAS CLEARLY A DEFECTIVE PART. RESEARCH ON THE INTERNET IDENTIFIED SEVERAL VEHICLES WITH THE SAME ISSUE INCLUDING RECALLS ON DIFFERENT MITSUBISHI MODELS AND THE SAME MODEL BUT WITH DIFFERENT MANUFACTURING DATE. THE VEHICLE WAS A 2002 MITSUBISHI MONTERO SPORT ES. *TR
Jan 07, 2008
TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. DURING AN OIL CHANGE, FIRESTONE FOUND A LEAK IN THE GASKET AND VALVE. THE MECHANIC BELIEVED THE FLOW ENGINE VALVE CAUSED THE LEAK. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND CURRENT MILEAGE WERE UNKNOWN.
Nov 20, 2007
+ 10 more complaints for this component
AIR BAGS
14 complaints
My horn goes off when I turn the steering wheel or hit bumps when driving and when parked and turned off, if its close to freezing it will go off constantly early in the morning before dawn and I have to disconnect the battery or pull the fuse for the horn under the hood fuse panel to stop it. I can't drive it with a horn fuse in and have tried replacing the steering wheel airbag and it still has the same problem. My neighbor had the same issue on his 04 Jeep and his car was fixed with an airbag actuator recall. No warning lights ever come on. Only my mechanic has looked at the vehicle.
Apr 16, 2024
MY MONTERO HAVE THE TAKATA AIR BAG. THE HORN INSIDE AIR BAG NOT WORKING I ORDER A AIR BAG THE AIR BAG SPECIALIST TOLD ME THAT THERE IS A TAKATA AIR BAG AND HE WILL NOT REPLACE IT BECAUSE HE SAY IS PART OF A NATIONAL RECALL OF TAKATA AIR BAG. SO I'M DRIVING W/O THE HORN .CREATING A SAFETY ISSUE IN CASE OF EMERGENCY I CALL MITSUBISHI AND THEY SAY NO RECALL. PLEASE TELL ME WHAT TO DO. [XXX] E MAIL [XXX] PH [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TR
Jan 26, 2015
TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. WHILE THE VEHICLE WAS STOPPED, ANOTHER VEHICLE REAR ENDED IT AND PUSHED IT INTO THREE OTHER VEHICLES. THE FRONT PASSENGER AIR BAG PARTIALLY DEPLOYED BUT THE DRIVER SIDE FRONT AIR BAG DID NOT DEPLOY AT ALL. THE CONTACT SUSTAINED MULTIPLE INJURIES. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 122,785.
Nov 29, 2010
I WAS IN AN AUTO ACCIDENT AND HIT A CAR IN IT'S SIDE. I WAS GOING APPROXIMATELY 30 MPH. THE VEHICLE ALSO ROLLED ON IT'S LEFT SIDE AFTER IMPACT. I WAS THE ONLY FRONT PASSENGER. MY AIRBAG NEVER DEPLOYED. MY HEAD ENDED UP HITTING THE STEERING WHEEL. *TR
Apr 26, 2010
I WAS A PASSENGER IN A 2002 MITSUBISHI MONTERO AND WE WERE HIT HEAD ON DOING 40+ ON THE HIGHWAY. NEITHER FRONT AIRBAG DEPLOYED. I FRACTURED MY HUMOROUS REQUIRING SURGERY FOR THE INSTALLATION OF HARDWARE TO MEND THE BONE. *TR
Aug 21, 2008
+ 9 more complaints for this component
POWER TRAIN
9 complaints
DRIVE MODE SELECTOR WILL NOT MOVE FROM THE AWD POSITION.
Jun 23, 2018
TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO. WHILE DRIVING VARIOUS SPEEDS, THE TRANSFER CASE WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT TRANSFER CASE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.
Jan 03, 2017
I WAS GOING TO START DRIVING A VERY INCLINED HILL APROX. 45 DEGREES, I STOPPED THE CAR, CHANGED THE AUTOMATIC TRANSMISSION TO 3 GEAR, WHEN I GET TO THE TOP OF THE HILL I CHANGED THE TRANSMISSION BACK TO D GEAR, BUT I NOTICED SOMETHING WEIRD WITH THE WAY THE TRANSMISSION WAS RESPONDING BUT I DIDN'T KNOW WHAT IT WAS, SO I KEPT DRIVING ALMOST 100 METERS MORE AND STOPPED THE CAR TO TAKE SOME PICTURES. WHEN I PARKED THE CAR I KNEW SOMETHING WAS NOT RIGHT BUT I DIDN'T KNOW WHAT WAS THE PROBLEM, SO I PULLED THE SAFETY BRAKES REALLY HARD BECAUSE THE CAR WAS ALREADY GOING DOWN THE HILL AND I DIDN'T WANT TO FORCE THE TRANSMISSION TO DO ALL THE BRAKE. MY SON WAS ON THE BACK SEAT OF THE CAR SLEEPING WITH THE SAFETY BELT ON, AND SINCE I REALIZED THAT SOMETHING WAS NOT RIGHT WITH THE TRANSMISSION BEFORE GETTING OFF THE CAR I PULLED EVEN MORE THE SAFETY BRAKE AND GET OFF THE CAR FOR A COUPLE OF PICTURES. WHEN I WAS GOING TO START THE CAR IT DIDN'T START BECAUSE THE CABLE THAT CONNECTS THE TRANSMISSION LEVEL TO THE TRANSMISSION WAS OUT OF THE ROD BECAUSE THERE IS A PLASTIC BUSHING HOLDING THE CABLE WITHIN THE LEVEL ROD THAT WAS BROKEN, IN OTHER WORDS THE ONLY THING PREVENTING THE CAR FROM GOING DOWN HILL WITH MY SON INSIDE WAS THE SAFETY BRAKE, BECAUSE THE TRANSMISSION WAS SET TO 3 GEAR INSTEAD OF PARKING. THERE WAS A LONG WAY DOWN HILL SO MY SON COULD BE DEATH IF MY WIFE WERE DRIVING BECAUSE MAYBE SHE WOULDN'T REALIZE THAT SOMETHING WRONG WAS HAPPENING WITH THE TRANSMISSION AND ALSO SHE DOESN'T HAVE THE STRENGTH TO PULL THE SAFETY BRAKES THE WAY I DID IT. THE ISSUE IS VERY DANGEROUS, AND IT CAN BE FIXED PRETTY EASY WITH A PLASTIC BUSHING. I HAVE PICTURES THAT I CAN PROVIDE IF NEEDED TO CLARIFY THE ISSUE. PLEASE INVESTIGATE TO AVOID PEOPLE FROM GETTING HURT. *TR
Aug 19, 2013
AUTOMATIC TRANSMISSION BEGAN TO MAKE GRINDING NOISES WHEN TRUCK WAS GOING SLOWLY. DESPITE ONLY 90,000 MILES AND WELL MAINTAINED. ESTIMATE TO REPAIR IS $4188. NO LIGHTS WERE ON, CAR DROVE WITHOUT INDICATION, ALL REQUIRED SERVICES WERE PERFORMED. *TR
May 14, 2009
VEHICLE'S 4WD WILL ENGAGE AND DISENGAGE ON IT'S OWN. WHILE IN 2WD, WHILE DRIVING, VEHICLE WILL MAKE A NOISE AND WHILE COMING TO A STOP THE NOISE WILL GET LOUDER UNTIL IT GIVES A HARD JOLT, LIKE IF SOMEONE REAR ENDED YOU. AT THIS POINT THE 4WD INDICATER WILL START BLINKING. IF YOU ATTEMPT TO PUT INTO 4WD THEN THE VEHICLE ALMOST BECOMES IMPOSSIBLE TO TURN AND CAUSES THE TIRES TO SQUELL AS IF YOU WERE DOING A BURN OUT. TOOK TO THE DEALER TWICE IN 2004 WITH NO LUCK. THEY COULDN'T FIGURE OUT WHAT WAS WRONG WITH IT. ALL OF A SUDDEN THE VEHICLE APPEARED TO BE OKAY FOR ABOUT 4 MONTHS WITH NO PROBLEMS UNTIL RECENTLY WHERE IT HAS START TO ACT UP AGAIN.
Jul 06, 2005
+ 4 more complaints for this component
STRUCTURE
9 complaints
I TOOK MY TRUCK FOR A FRAME INSPECTION, FRAME WAS REND ENDEARED UNSAFE AND RUSTED ALL THE WAY THROUGH. BODY & ENGINE ARE INTACT. NEW FRAME IS 10,000.00. THE MECHANIC TOLD ME THEIR WERE NUMEROUS COMPLAINTS ABOUT THIS YEARS FRAME. HE SAID THE METAL WAS DIPPED CORRECTLY. I CAN OBTAIN A WRITTEN REPORT. I ALSO CALLED MITSUBISHI & THEY SAID THEY COULD NOT OFFER ANY COMPENSATION.
Feb 10, 2016
FRAME AND UNDERCARRIAGE ROT/RUST. WAS TOLD BY ONE SHOP ABOUT IN 2013 THAT I HAD ALOT OF RUST ON THE FRAME WHEN THEY REPLACED MY RUSTED BRAKE LINES.. THIS WEEK IN OCTOBER 2014 I HAD TO REPLACE A RUSTY FILL PIPE FOR MY GAS AND THE MECHANIC TOLD ME THAT I HAD MAJOR RUST ON THE FRAME AND UNDERCARRIAGE AND THAT A REAR END COLLISION OF ANY KIND COULD POTENTIALLY TOTAL MY CAR. *TR
Oct 31, 2014
BROUGHT 2002 MONTERO SPORT FOR INSPECTION INSPECTOR TOLD ME THE REAR FRAME AND UNDERCARRIAGE WAS ROTTEN VEHICLE WAS NOT TO BE DRIVEN. WHAT DO I DO WITH VEHICLE NOW THAT I JUST PAID IT OFF AND I CANT DRIVE? *TR
Mar 14, 2014
TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT DURING A ROUTINE INSPECTION, THE CONTACT WAS ADVISED THAT THE FRAME WAS ROTTING AND THERE WERE TWENTY TWO INCH-LONG FRACTURES FOUND IN THE FRAME. A DEALER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 93,000.
May 08, 2013
TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. THE CONTACT STATED WHILE INSPECTING THE VEHICLE, HE NOTICED THAT THE FRAME WAS CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 110,000. *TR
Apr 04, 2013
+ 4 more complaints for this component
ELECTRICAL SYSTEM
5 complaints
MY 2002 MITSUBISHI MONTERO XLS WAS STATIONARY AND PARKED FOR THE NIGHT ON THE STREET IN FRONT OF MY HOUSE. AT APPROXIMATELY 4:00 AM, THE ALARM STARTED TO SOUND AND THE LIGHTS WERE FLASHING. THE FIRST NIGHT, THE NEIGHBORS AND POLICE DISCOVERED IT BEFORE ME, SO THE POLICE BROKE INTO MY CAR, OPENED THE HOOD, AND DISCONNECTED THE BATTERY. WHEN I RECONNECTED THE BATTERY THE NEXT MORNING, THE ALARM CONTINUED TO SOUND, SO I REMOVED THE FUSE FOR THE HORN AND REPLACED IT LATER THAT DAY, TO BE GREETED WITH SILENCE. FOUR NIGHTS LATER, I HAD THE FUSE FOR THE HORN BACK IN THE VEHICLE. I WAS WOKEN UP AT 2:00 AM TO THE SOUND OF MY HORN BLARING. I ONCE AGAIN, HAD TO REMOVE THE FUSE FOR THE HORN. THIS ISSUE HAS TURNED OUT TO BE BOTH A PUBLIC NUISANCE AND UNSAFE.
Feb 08, 2016
WHILE PARKED IN MY DRIVEWAY AT NIGHT, MY 2002 LIMITED MITSUBISHI MONTERO'S CAR ALARM WILL GO OFF AT EXACTLY 4:30 AM EACH MORNING UNTIL WE DISABLE THE ALARM WITH THE REMOTE. WE CHECKED AND NO ONE ELSE OR THING IS BUMPING OR SETTING OFF THE ALARM. *TR
May 07, 2015
TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO. WHILE DRIVING APPROXIMATELY BETWEEN 35-40 MPH, THE CONTACT OBSERVED THAT THE TEMPERATURE GAUGE INACCURATELY DISPLAYED THAT THE VEHICLE WAS HOT ALTHOUGH THE ENGINE DID NOT OVERHEAT. THE VEHICLE WAS CURRENTLY BEING REPAIRED BY AN INDEPENDENT MECHANIC FOR THE REPLACEMENT OF THE FAN CLUTCH AND INSTRUMENT CLUSTER. THE FAILURE MILEAGE WAS APPROXIMATELY 119,000.
Mar 17, 2011
HORN BUTTON WHEN THE ACCESSORY SOCKET IS IN USE OR NOT IN USE,THE HORN CONTINUES TO BLOW WHEN THE BUTTON IS RELEASED. THEREFORE THE FUSE TO THE HORN MUST BE DISCONNECTED AT ALL TIMES. I HAD IT PUT ON A DIAGNOSTIC MACHINE AND IN ORDER TO HAVE THIS FIXED IT WILL COST $1300 BECAUSE THE PROBLEM HAS TO DO WITH THE AIR BAG. IF IT WERE THE RELAY SWITCH IT WOULD HAVE BEEN $24. THIS IS NOT FROM WHAT I THINK IS SOMETHING THAT CONSUMERS MUST PAY FOR. I LIVE IN THE STATE OF VIRGINIA WHERE IT IS REQUIRED TO HAVE VEHICLE SAFETY INSPECTION DONE EVERY YEAR AND THE FIRST THING THAT'S CHECKED IS THE HORN. HOW CAN SOMETHING THAT NEEDS TO BE OPERABLE THAT'S OUT OF THE NORMAL WEAR AND TEAR NOT BE A RECALL? THIS HAS BEEN GOING ON SINCE 2007 AND I STILL HAVE NOT GOTTEN A RESPONSE FROM ANYONE ON THIS MATTER. EVERY YEAR I'VE BEEN SKATING BY CROSSING MY FINGERS AND HOPE THAT THE HORN WILL NOT SOUND OFF. HERE RECENTLY I CAN'T PUT THE FUSE IN AT ALL WITHOUT THE HORN CONTINUALLY SOUNDING OFF. IT SOUND LIKE SOMEONE IS JUST SITTING IN MY CAR HOLDING THEIR HAND DOWN ON THE HORN... THIS HAS BEEN GOING ON SINCE 2007 PRIMARILY WHEN IT'S COLD OUTSIDE TO NOW 2010. THERE HAS BEEN NUMEROUS TIMES IN THIS TIME FRAME WHERE I COULD HAVE USED THE HORN TO PREVENT SOMEONE FROM ALMOST HITTING ME. *TR
Feb 22, 2010
DURING COLD WEATHER (APPROXIMATELY 20 DEGREES C AND BELOW) THE HORN STARTS BLOWING AND WON'T TURN OFF UNLESS THE BATTERY IS DISCONNECTED OR THE CAR INTERIOR HAS WARMED UP. THE ONLY WAY I HAVE TO PREVENT THE HORN FROM COMING ON IS TO KEEP THE HORN/AIR/BAG ASSEMBLY WARM. I WRAP AN ELECTRIC BLANKET AROUND THE STEERING WHEEL. *JB
Feb 06, 2007
TIRES
5 complaints
THE DRIVER'S SIDE REAR TIRE DISINTEGRATED, WHICH ALMOST CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. *JB
Apr 04, 2003
WHILE DRIVING AT 30 MPH AND WITHOUT WARNING FRONT PASSENGER SIDE TIRE BLOWOUT. PLEASE PROVIDE THE SIZE AND DOT#. DEALER NOTIFIED. TX
Dec 30, 2002
ON MAY 21, 2002 WHILE DRIVING AT THE SPEED OF APPROXIMATELY 30 MILES PER HOUR MY TWO RIGHT BRIDGESTONE BUELER H/T D689 TIRES BLEW OUT. AS A RESULT OF THAT THE VEHICLE WENT OUT OF CONTROL AND COLLIDED WITH THE GROUND. THE TIRES WERE REPLACED BUT IT WAS THEN DETERMINED THAT A BRAND NEW FRAME WAS NEEDED AS A RESULT OF THE COLLSION WITH THE GROUND. POLICE DID REPORT TO THE SCENE AND DETERMINED THAT THERE WAS NO DEBRIS IN THE ROAD TO CAUSE THE BLOW OUT. I DO HAVE THAT POLICE REPORT. THE CAR IS STILL IN THE SHOP. IT HAS BEEN IN THE SHOP FOR ALMOST HALF A YEAR. DT
Nov 02, 2002
I SENT A DESCRIPTION OF THE ACCIDENT THE ODI NUMBER IS 769218. JUST IN CASE YOU DIDN'T GET IT I'LL GO OVER THE DETAILS AGAIN. ON MAY 21, 2002 MY TWO RIGHT TIRES BLEW OUT WHILE I WAS GOING APPROXIMATELY 30 MPH. AS A RESULT OF THE BLOW OUT MY CAR COLLIDED WITH THE GROUND AND WENT OUT OF CONTROL. LUCKILY THERE WERE NO FATALITIES. ALSO IT WAS DETERMINED THAT A BRAND NEW FRAME WAS NEEDED BECAUSE THE COLLISION WAS SO BAD. POLICE DID REPORT TO THE SCENE AND COULD FIND NO DEBRIS IN THE ROAD TO CAUSE THE BLOW OUT. MY CAR IS STILL IN THE SHOP. IT HAS BEEN THERE SINCE MAY 21, 2002. THANK YOU DT
Nov 02, 2002
BRIDGESTONE, DUELER HT-689, P265/70R16, DOT # ELLJJNM3701, ORIGINAL EQUIPMENT ON A 2002, MITSUBISHI, MONTERO WITH 11400 MILES. PASSENGER'S SIDE REAR TIRE BLEWOUT AT 65-70 MPH. *AK *YH
Aug 07, 2002
STEERING
4 complaints
I HAVE TAKEN THE MITSUBISHI A NUMBER OF TIMES TO DEALER FOR TWO DIFFERENT PROBLEMS CONCERNING STEERING. CONCORD MITSUBISHI KEPT TELLING US THAT THE PROBLEMS WERE EITHER FIXED OR IT WAS NORMAL, BUT THE PROBLEMS RECURRED. *AK
Apr 07, 2007
OUR ACCIDENT OCCURED WHILE TOWING A POP UP TRAILER. WE ARE EXPERIENCED DRIVER'S AND HAVE BEEN TOWING A TRAILER FOR MORE THAN 12 YEARS. WHILE TRAVELING AT APPROXIMATELY 55 MPH, SUDDENLY AND WITHOUT WARNING I WAS UNABLE TO CONTROL THE CAR. WE WERE TRAVELING ON A STRAIGHT SECTION OF HIGHWAY IN THE RIGHT LANE. THE ROAD CONDITIONS AND WEATHER CONDITIONS WERE GOOD. THERE WERE NO TIRE FAILURES ON THE CAR OR THE TRAILER. THE STEERING WHEEL STARTED ROCKING AND SOON WE HAD NO CONTROL OF THE CAR. THE FRONT END FELT AS THOUGH IT WAS NOSE PLOWING. THE CAR SWERVED INTO THE LEFT LANE. THE FIRST IMPACT WAS TO THE TRAILER; IT BRUSHED AGAINST THE CONCRETE MEDIAN DIVIDER. THE CAR THAN PULLED TO THE RIGHT. THE SECOND IMPACT WAS TO THE DRIVER'S SIDE FRONT END OF THE CAR THAT HIT THE METAL GUARDRAIL ON THE RIGHT SIDE OF THE ROAD. THE WEIGHT OF THE TRAILER PULLED US BACK ONTO THE ROAD. THE TRAILER AT THIS POINT JACK KNIFED AND FLIPPED ONTO IT'S ROOF PROCEEDING NORTH ON THE HIGHWAY FOR ABOUT 50 FEET. THE THIRD IMPACT WAS TO THE DRIVERS SIDE REAR OF THE CAR, AGAIN HITTING THE GUARDRAIL AS THE TRAILER PULLED THE CAR BACKWARD. WE FEEL THAT IF WE WERE NOT TOWING THE TRAILER WE WOULD HAVE BEEN ANOTHER VICTIM OF A SUV ROLL OVER ACCIDENT. AFTER EXAMINING THE CAR AFTER THE ACCIDENT IT WAS DISCOVERED THAT THE LEFT TIE ROD WAS SNAPPED IN HALF. THE LEFT FRONT TIRE WAS TURNED OUTWARDS WHILE THE RIGHT FRONT TIRE WAS FACING FORWARDS. MITSUBISHI HAS YET TO BE ABLE TO EXPLAIN WHAT HAPPENED WITH THE CAR. TO DATE THERE HAVE BEEN OVER $21,000 IN REPAIRS TO THE VEHICLE. THEY STILL HAVE OUR CAR!
Feb 08, 2003
A MONTH AFTER MY VEHICLE WAS PURCHASED WE HAD A NUMBER OF PROBLEMS, THE REAR DIFFERENTIAL WAS CRACKED, LEAKING WINDSHIELD WASHER FLUID AND NOW THE STEERING ISN'T WORKING IN THE MANNER IT SHOULD. THE CAR IS ALL OVER THE ROAD AND WHILE STOPPING YESTERDAY THE STEERING WHEEL COMPLETELY ROLLED TO THE LEFT. THEN WHILE ON A GRAVEL ROAD THE WHEEL COMPLETELY SPUN AROUND. I CALLED ANOTHER DEALERSHIP TODAY AND THEY SAID THERE WAS A RECALL ON THE STEERING, BUT THE MITSUBISHI HEADQUARTERS SAID THERE AREN'T ANY RECALLS.
Dec 19, 2002
AT 25 MPH SOMETHING BROKE AND THE VEHICLE MADE A SUDDEN LEFT TURN. *JB ***DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS****770767
Dec 18, 2002
ELECTRICAL SYSTEM,AIR BAGS
3 complaints
TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. WHEN THE STEERING WHEEL WAS TURNED LEFT OR RIGHT AT A CERTAIN ANGLE, THE HORN OF THE VEHICLE ACTIVATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT AN UNKNOWN MODULE RELATED TO THE AIR BAG AND A RELAY SWITCH NEEDED TO BE REPLACED. THE RELAY SWITCH WAS REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 155,000.
Oct 21, 2015
AGING OF THE COSMETIC VINYL COVERING ON STEERING WHEEL THAT COVERS AIR BAG MODULE WILL CONTRACT TOO MUCH IN COLD WEATHER, APPROXIMATELY 40 DEGREES F OR LOWER CAUSING CAR HORN TO GO OFF EVEN WITHOUT ENGINE RUNNING. THE VINYL COVERING SQUEEZES THE CAR HORN CONTACTS THAT ARE JUST UNDER THE COVER AND ON TOP OF AIR BAG MODULE. *TR
Nov 08, 2014
2002 MITSUBISHI MONTERO SPORT; THE CAR HORN/ALARM GOES OFF USUALLY WHEN A DROP OF TEMPERATURE OCCURS IN THE MIDDLE OF THE NIGHT. TO FIX ... HAS SOMETHING TO DO WITH A SHORT IN THE ELECTRICAL OF THE AIR BAG AND THE STEERING WHEEL COLUMN. VERY EXPENSIVE FOR A MECHANIC, OVER $1200. I HAVE TO UNHOOK MY BATTERY EVERY NIGHT AND ON COLDER DAYS. RESEARCHING ONLINE.....A LOT OF PEOPLE ARE DISABLING THE HORN/ALARM SYSTEM AND DRIVING WITHOUT HORNS. OR THEY ARE TAMPERING WITH THE AIR BAG TO TRY AND FIX. IT IS A VERY COMMON PROBLEM....... TODAY I COULD NOT DRIVE THE CAR BECAUSE EVERY TIME I HOOKED THE BATTERY CABLE BACK UP THE HORN STAYED ON. I AM CONSIDERING DISABLING THE HORN ALTOGETHER. *TR
Dec 21, 2013
VISIBILITY
3 complaints
THE REAR VIEW MIRROR CHANGES AUTOMATICALLY TO NIGHT VISION YOU CAN NOT CHANGE IT BACK. IT VERY DIFFICULT TO SEE CARS BEHIND YOU WITH THE WAY IT CHANGES AND HOW CLOSE THEY ARE TO YOU. MY DAUGHTER BACKED INTO SOMEONE BECAUSE SHE COULD NOT TELL THEY WERE BEHIND HER. I HAVE HAD PROBLEMS WITH THIS ALSO. I THINK IT IS A SAFETY HAZARD. YOU SHOULD BE ABLE TO ADJUST THE MIRROR YOURSELF. AND YOU CAN'T. *TR
Aug 26, 2013
TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. HE STATED THAT WHILE DRIVING 60 MPH WHEN IT WAS RAINING AND THE WIPERS WERE ON, THE LEFT SIDE WINDSHIELD WIPER EXTENDED OFF OF THE WINDSHIELD BUT IT WAS STILL ATTACHED TO THE WIPER MOTOR. HE NOTICED THAT THE WIPER WAS ALSO SLIGHTLY DETACHED FROM THE METAL MOUNTING. THE DEALER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. NO REPAIRS HAVE BEEN MADE AT THIS TIME. THE FAILURE MILEAGE WAS 10,8069 AND THE CURRENT MILEAGE WAS 10,8085.
Feb 25, 2010
DT: THE WINDSHIELD WIPER ARM WOULD STICK ON DRIVER'S SIDE OF THE WINDSHIELD, AND THEN IT WOULD COME BACK. THIS HAPPENED 5 OR 6 TIMES, THEN THE WINDSHIELD WIPER ARM GOT STUCK OVER THE WINDSHIELD MOLDING. WHEN THE CONSUMER GOT OUT OF VEHICLE TO ADJUST THE PROBLEM HE NOTICED IT WAS LOOSE FROM THE BOLT MOUNT. CONSUMER THEN DROVE VEHICLE TO A REPAIR SHOP, AND THEY TOOK THE WIPER OFF, AND FOUND THAT THE WIPER HAD TORN LOOSE OF THE SHEET METAL MOUNTING.*AK THIS FAILURE OCCURED WHILE DRIVING IN THE RAIN AND CAUSED COMPLETE LOSS OF VISIBILITY. *NM
Jun 15, 2005
FUEL SYSTEM, GASOLINE
3 complaints
TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. THE CONTACT NOTICED A FUEL LEAK WHILE SHE WAS ADDING FUEL TO THE VEHICLE. SHE TOOK THE VEHICLE TO A MECHANIC WHO DIAGNOSED THE FAILURE AS THE FUEL STORAGE TANK. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VIN WASN'T INCLUDED IN RECALL 04V319000 FUEL SYSTEM, GASOLINE: STORAGE. THE VEHICLE WILL BE TAKEN TO A DEALER TO BE REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 67,037.
Aug 12, 2010
I STARTED TO SMELL GAS WHEN NEAR THE MONTERO. I THOUGHT IT WAS ANOTHER RECALL NOTICE ABOUT A VALVE SEALING BUT IT GOT WORSE, AND I STARTED NOTICING A GAS PUDDLE UNDER THE MONTERO. I REMOVED THE PLASTIC SHIELD FROM AROUND THE TANK AND FOUND AN AREA ABOUT 9" X 7" HAD SURFACE RUST ON IT AND THE LEAK IS FROM THIS. THE PLASTIC SHIELD TRAPS DIRT AND MOISTURE IN THIS LOCATION AND CAUSED THIS HIGHLY DANGEROUS SITUATION. *TR
Dec 30, 2008
THE CONSUMERS VEHICLE WAS INCLUDED IN RECALL /FUEL LEAKAGE. HOWEVER, THE VEHICLE STARTED TO LEAK GAS ONCE AGAIN. THE CONSUMER TOOK THE VEHICLE IN AGAIN FOR THE SAME RECALL. THE VEHICLE IS IN THE REPAIR SHOP NOW. *JB THE VEHICLE IS STILL LEAKING GAS, WHICH CAUSED IT STALL. *SC
Feb 07, 2005
ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM
2 complaints
I checked and there's several recalls on the vehicle and I purchase it last year from the dealership and I never received anything about the recalls and now my vehicle doesn't want to start it lock me out.
Sep 04, 2022
THE CLUSTER WAS REPAIRED IN THE MONTERO BUT IT ONLY WORKS ONCE IN AWHILE. THE PANEL WILL TELL ME EVERY NOW AND THEN IF I HAVE FUEL OR NOT. ALSO, WE HAD TO PAY TO HAVE AN ISSUE RESOLVED THAT SHOULDN'T HAVE COST US ANYTHING BECAUSE IT WAS SHOWN HERE AS A DEFECT FOR OUR MAKE AND MODEL. OUR CAR WAS LEAKING GAS, AND MITSUBISHI REFUSED TO FIX IT, AT THEIR EXPENSE, EVEN THOUGH IT WAS LISTED HERE AND THERE WERE VERY MANY COMPLAINTS FILED. WE HAD TO TOW THE CAR IN BECAUSE OF THE LEAK, AND THE FIRE DEPARTMENT WAS CALLED. AMAZING THAT SO LITTLE CARE WAS SHOWN BY MITSUBISHI FOR SOMETHING THAT COULD HAVE CAUSED A SERIOUS ACCIDENT. THIS WAS THE COMPLAINT AND THE RECALL (NHTSA RECALL ID 01V254001) ABOUT THE CAR BEING PARKED AT AN UPWARD SLOPE, THE FUEL TANK LEVELING VALVE NOT MAINTAINING PROPER SEALING IN THE EVEN THAT THE FUEL EXPANDS FROM THE RISE IN AMBIENT TEMP. LEAKAGE OF PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR, ETC. PLEASE CHECK THE RECALL NOTICE.
Nov 29, 2016
EXTERIOR LIGHTING,FUEL/PROPULSION SYSTEM
2 complaints
My car has 2 recalls and my local Mitsubishi dealer refused to fix the recalls.
Nov 01, 2021
NHTSA RECALL ID: 04V319000 MITSUBISHI MONTERO 2002 (02) MITSUBISHI RECALL CAMPAIGN NO.: SR-04-009 COMPONENT: FUEL SYSTEM, GASOLINE:STORAGE RECALL DATE (Y/M):2004/07 DEFECT: ON CERTAIN SPORT UTILITY VEHICLES, WHEN THE FUEL TANK IS FULL AND THE VEHICLE IS PARKED FORWARD ON AN UPWARD SLOPE, THE FUEL TANK LEVELING VALVE MAY NOT MAINTAIN PROPER SEALING IN THE EVENT THE FUEL EXPANDS FROM THE RISE IN AMBIENT TEMPERATURE. NHTSA RECALL ID: 01V254001 MITSUBISHI MONTERO 2002 (02) MITSUBISHI RECALL CAMPAIGN NO.: COMPONENT: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM RECALL DATE (Y/M):2001/08 DEFECT: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN IMPROPERLY MANUFACTURED. OVER A PERIOD OF TIME, THIS COULD RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR.
Jun 23, 2016
UNKNOWN OR OTHER
2 complaints
TAKATA RECALL I HAVE PROBLEM WITH MY SECURITY ALARM SYSTEM IT GOES OFF FOR NO REASON AND ALSO THE HORN WHEN THE WEATHER DROPS COLD THE HORN GOING OFF CONTINUOUSLY MY MECHANIC CHANGE THE HORN RELAY MORE THAN 3 TIMES BUT THE ISSUE STILL THE SAME. I DON'T UNDERSTAND THESE TWO ISSUES ARE CONNECTED OR NOT BUT I NEED HELP.
Jan 18, 2018
RE SAFETY RECALL SR-04-008 FM MITSUBISHI FOR 2002 MONTERO, HAVING SAFETY NOTICE AUTHORIZED BY DEALERSHIP IN ROTA, SPAIN. *BF THE CONSUMER WAS INFORMED THAT THE RECALL DID NOT APPLY TO HER VEHICLE ANY LONGER. *SC
Nov 23, 2004
EXTERIOR LIGHTING
2 complaints
BOTH HEAD LIGHT BEAMS SOMETIMES DISAPPEAR WHEN SWITCHING TO HIGH BEAM WHILE DRIVING LEAVING YOU DRIVING IN THE DARK WITHOUT ANY LIGHTS.
Mar 12, 2017
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS AT NIGHT WITH THE HEADLIGHTS ILLUMINATED, THE HEADLIGHTS INTERMITTENTLY FAILED TO ILLUMINATE WITHOUT WARNING. AFTER SEVERAL ATTEMPTS OF TURNING THE HEADLIGHT SWITCH ON AND OFF, THE HEADLIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS INSPECTED BY A DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE PROBLEM PERSISTED, AND THE MANUFACTURER WAS ALERTED.
Oct 13, 2006
EQUIPMENT
2 complaints
ANTENNA RAISING MOTOR BROKE AND NOW WHEN CAR IS TURNED ON OR OFF, IT MAKES A VERY LOUD NOISE AS IT ATTEMPTS TO RETRACT/EXTEND THE ANTENNA. PAID TO HAVE THIS REPAIRED AT DEALERSHIP. *TR
Feb 22, 2009
THE WHEEL JACK DID NOT FIT UNDER THE CROSS BEAM WHEN THE TIRE WAS TOTALLY FLAT. THE BASE OF THE JACK WAS VERY SMALL. THE CONSUMER STATED THE JACK WAS INADEQUATE AND UNSAFE. *JB
Apr 29, 2004
ENGINE
1 complaint
I have a 2002 Mitsibishi Montero Sport.I was driving home from work, and all the sudden i couldn't steer. I had no steering, Lost power to vehicle and battery light came on. Wasnt sure what happened, looked under the hood and noticed belts were off. Went and got new ones and noticed when trying to put the mew belts on the bolt on the crankshaft pulley was loose and the pin was broken making that pulley loose.I was lucky that I decided to take a street with less traffic otherwise I could of gotten into an accident.This should definitely be a RECALL.
Aug 03, 2021
ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ENGINE
1 complaint
WE HAVE THE CAR FOR THE PAST 17 YEARS AND WE ALWASY HAVE A ELECTRICAL, ENGINE AND HEAD LIGHTS PROBLEMS. THE DEALERSHIP SAID THE THEY CAN FIX IT . WE PAID GOOD MONEY FOR THEM TO FIX IT
Jul 24, 2019
STRUCTURE,SERVICE BRAKES,FUEL/PROPULSION SYSTEM
1 complaint
THE HOOD FLEW UP WHEN SAFETY LATCH FAILED TO HOLD IT,, PLUS BRAKE LINE TROUBLES AS WELL AS GAS TANK FILL PIPE ALL RUSTED OUT,, HOOD WAS ON HIGHWAY AT ABOUT 30MPH AN WRAPPED ARROUND WINDSHIELD,,
Sep 09, 2017
AIR BAGS,STRUCTURE
1 complaint
TAKATA RECALL - MY LATE HUSBAND AND I WERE IN A SUV ROLLOVER ACCIDENT IN MAY 4, 2006. OUR VEHICLE WAS REAR-ENDED BY ANOTHER SUV AND ULTIMATELY INVOLVED FOUR (4) VEHICLES TOTAL. THE AIRBAGS IN OUR VEHICLE DID NOT DEPLOY AND MY HUSBAND DIED LATER FROM COMPLICATIONS INDUCED BY INTERNAL BLEEDING. POLICE REPORT FILED AND SENT TO MANUFACTURER WITH NO RESPONSE OR COMMENT. NOTICED THAT THERE ARE SEVERAL AIRBAG COMPLAINTS WITH NTSB FOR MY VEHICLE TYPE WITH NO OPEN INVESTIGATIONS. MY HUSBAND'S DEATH SHOULD TRIGGER SOME TYPE OF INVESTIGATION OR CONCERN FROM BOTH NTSB AND THE MANUFACTURER.
Nov 22, 2015
STEERING,SERVICE BRAKES,ENGINE
1 complaint
I WAS DRIVING HOME FROM WORK AND NOTICE MY TRUCK HAD DIED WHILE SLOWING TO MAKE A RIGHT TURN AT A LIGHT..NOTICED THE BRAKE AND BATTERY LIGHT CAME ON...I RESTARTED THE CAR THEN TRIED TO MAKE A QUICK LEFT ON MY STREET AND COULDN'T STEER MY CAR...I HAD TO USE ALL MY STRENGTH TO TURN THE STEERING WHEEL...HAD TO MAKE A HARD TURN BECAUSE ON COMING TRAFFIC WAS COMING AND I COULDN'T SPEED UP OR REALLY BRAKE...LUCKILY I MADE THE TURN COASTED A BIT HEARD A LOUD CLACKING UNDER MY HOOD COASTED TO SIDE OF ROAD WHERE I WOULDN'T BE IN MIDDLE OF ROAD...I LOST ALL POWER STEERING...TRIED TO CRANK IT WOULDN'T START...LOOKED UP UNDER HOOD DIDN'T SEE ANYTHING...CALLED MY STEPDAD AND MOM WE TRIED TO GIVE IT A BOOST WITH CABLES DIDN'T WORK...SO LOOKED UNDER THE CAR WHERE THE TRAP IS NOTICED A FAIRLY LARGE BOLT SHEARED IN HALF AND WHAT I FOUND OUT LATER TO BE THE HARMONIC BALANCER AND BELT TO IT...PULLED ALL THIS OUT FROM ATOP HOOD...HAD IT TOWED TO A MECHANIC AND THEY SAID THE CRANKSHAFT PULLEY BOLT HAD BROKE AND PART OF IT WAS STILL IN THE CRANKSHAFT SAID PRAY I CAN GET THIS BOLT OUT IF NOT YOU HAVE TO REPLACE THE WHOLE MOTOR... *TR
Apr 30, 2013
ELECTRICAL SYSTEM,EQUIPMENT
1 complaint
2002 MITSUBISHI MONTERO SPORT. THE HORN SOUNDS FOR NO REASON, WHEN THE TEMPERATURE DROPS BELOW 55DEGREES. I MUST REMOVE THE FUSE TO SILENCE IT. IT IS STATE REQUIRED SAFETY EQUIPMENT. I CONTACTED THE LANCASTER, PA MITSUBISHI DEALER BUT THEY WON'T REPLY. THE PROBLEM STARTED IN THE WINTER WHEN THE TEMPERATURE DROPPED BELOW 18 DEGREES. IT IS 8 MONTHS LATER AND A COLD AUGUST NIGHT TRIGGERED IT. *TR
Aug 23, 2011
SERVICE BRAKES, HYDRAULIC,UNKNOWN OR OTHER
1 complaint
I ALSO OWN A 2002 MITSUBISHI MONTERO LTD. I HAVE OWNED IT FOR 6 YEARS AND HAVE HAD TO REPLACE THE BRAKES 6 TIMES. I DRIVE UP AND DOWN THE SOUTHERN CA MOUNTAINS, AND HAVE EXPERIENCED THE SAME SAME SHAKING A SHIMMING AS I HAVE HEARD OTHER OWNERS EXPRESS. THE BRAKES CONTINUALLY WEAR WITH BLACK "DUST" AROUND THE WHEELS, AND MAKE THE GRINDING AND GROANING SOUNDS AS WELL. I HAVE NOT ATTEMPTED TO CONTACT MITSUBISHI REGARDING THIS PROBLEM, BUT HOWEVER, AM REALIZING THAT IT HAS BECOME A REAL ISSUE, AND CONTINUES TO COST UPWARDS OF $600 EACH TIME I HAVE TO REPLACE THE BRAKES. ANY ASSISTANCE REGARDING THE BRAKES WOULD BE GREATLY APPRECIATED.
Mar 25, 2010
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES
1 complaint
CAR STALLED DUE TO DRINK (WHICH WAS IN DRINK HOLDER) SPILLING ACROSS SHIFT AREA DURING SUDDEN BRAKING - APPARENTLY LIQUID SHORTED OUT WIRING AND CAR WOULDN'T DRIVE AGAIN UNTIL IT DRIED OUT - IF THESE TWO ITEMS MUST BE CLOSE TOGETHER THEN THE GEAR/SHIFT AREA SHOULD BE WATER TIGHT/PROOF - FOR SURE THIS COULD CAUSE DAMAGE/CRASH/DEATH/INJURY. *TR
Apr 14, 2009
SERVICE BRAKES, HYDRAULIC,EQUIPMENT
1 complaint
MY MITSUBISHI MONTERO 2002 IS MAKING THE SAME SOUNDS AS THE LISTING BELOW FROM WHICH A RECALL WAS ORDERED. I CONTACTED MITSUBISHI AND WAS TOLD THAT THE VIN NUMBER DID NOT MATCH THE ONES BEING RECALLED. THEY TOLD ME THAT I HAD TO MAKE A COMPLAINT EVEN IF THE SUV IS THE SAME YEAR AND MODEL. THE RECALL STATES THAT IT CAN CAUSE A CRASH AND IT IS VERY COSTLY TO REPLACE. MITSUBISHI MONTERO 2002 (02) MITSUBISHI RECALL CAMPAIGN NO.: COMPONENT: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM RECALL DATE (Y/M):2001/08 DEFECT: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN IMPROPERLY MANUFACTURED. OVER A PERIOD OF TIME, THIS COULD RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE ACCUMULATOR. CONSEQUENCE: THE LOSS OF THIS GAS PRESSURE COULD RESULT IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED, AND POSSIBLY A DELAYED FIRST TIME BRAKE BOOST ASSIST AFTER THE VEHICLE HAS BEEN PARKED FOR A PERIOD OF TIME, WHICH COULD RESULT IN A VEHICLE CRASH. CORRECTIVE ACTION: DEALERS WILL INSTALL AN IMPROVED ACCUMULATOR. OWNER NOTIFICATION MAILING BEGAN OCTOBER 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. *NM
Feb 23, 2007
AIR BAGS,SEAT BELTS
1 complaint
DT*: THE CONTACT STATED THAT AN ACCIDENT OCCURRED WHILE DRIVING 32 MPH AND THE SEATBELT DID NOT RESTRAIN AND THE AIR BAG DID NOT DEPLOY. A POLICE REPORT WAS TAKEN A THE SCENE OF THE ACCIDENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION HOWEVER THE DEALER HAS NOT DETERMINED THE CAUSE OF THE PROBLEM.
Oct 10, 2006
SERVICE BRAKES, AIR
1 complaint
DT: THE CONSUMER HAS A SAFETY ISSUE WITH HER VEHICLE, THAT HER CAR IS NOT LISTED IN THE RECALL BECAUSE OF THE DATE IT WAS MADE. THE CONSUMER'S CAR HAS THE SAME PROBLEMS AS THE CARS WITH THE RECALLS. THE ABS SYSTEM IS LEAKING GAS AND IS HAVING A DELAY IN THE BRAKE SYSTEM. THE CAR HAS HAD PROBLEMS FOR TWO DAYS.
May 18, 2005
SEAT BELTS
1 complaint
ONE DAY SEAT BELT LIGHT STOPPED FUNCTIONING WHEN SEAT BELT NOT SECURED. WORKS WHEN CAR IS STARTED, FLASHES AS NORMAL, BUT WHEN YOU UNDO THE BELT, YOU GET NO WARNING LIGHT ON DASH. TOOK TO THE DEALERSHIP WHO KEPT TRUCK FOR TWO DAYS ONLY TO CALL ME BACK AND ADVISE FUNCTIONING AS DESIGNED. CALLED MITSUBISHI WHO TELL ME THAT IT IS SUPPOSED TO BE ON WHEN SEAT BELT IS NOT FASTENED -- WELL THANKS.. THAT'S GREAT... BUT HOW DO I GET A DEALERSHIP TO FIX SOMETHING THEY CLAIM IS NOT WRONG? I SHOWED SERVICE MANAGER MANUAL AND WAS TOLD THAT THE MANUAL IS WRONG. SERVICE MANAGER CLAIMS THEY CALLED MITSUBISHI AND HAVE BEEN ADVISED IT IS FUNCTIONING AS DESIGNED. I CALLED AGAIN TO MITSUBISHI WHO ADVISED AGAIN I AM CORRECT. *NM
Jan 18, 2005
FUEL SYSTEM, OTHER
1 complaint
RECALL 04V319000 CONCERNING FUEL LEAKAGE. CONSUMER WAS UNABLE TO GET THIS RECALL HONORED BECAUSE THE DEALER DID NOT HAVE THE SPECIAL TOOL TO DO THE REPAIRS. MANUFACTURER WAS NOTIFIED.*AK
Dec 06, 2004
PARKING BRAKE
1 complaint
AT ALL TIMES EMERGENCY PARKING BRAKE LIGHT STAYS ON. THE DEALER CLAIMS THAT ALTHOUGH THE LIGHT IS ON EMERGENCY BRAKES ARE WORKING.*AK
Aug 05, 2004
SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL
1 complaint
+BRAKE PADS MUST BE CHANGED BECAUSE OF PREMATURE WEAR. MILEAGE: 17,000.IF THE TRUCK IS STOPPED, AND YOU PRESS THE ACCELERATOR, YOU FEEL LIKE IT WOULD STALL, BUT IT KEEPS GOING.*AK
May 21, 2004
POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
DEALERSHIP SAID THERE IS SLUDGE IN ENGINE DUE TO "LACK OF PROPER MAINTENANCE". WE'VE HAD THE OIL CHANGED ACCORDING TO THE MANUAL BUT BELIEVE THAT THE OIL PAN IS POSITIONED WRONG AS THE DEALERSHIPS TOLD US THAT ABOUT 1/4 INCH TO 1/2 INCH IS ALWAYS LEFT IN THE BOTTOM OF THE OIL PAN WHEN YOU CHANGE THE OIL, THEREFORE CREATING SLUDGE. THE OIL PUMP HAS ALSO GONE BAD ON THIS 2002 MITSUBISHI MONTERO SPORT, WITH 62,000 MILES. NO ONE WILL PICK UP THE BILL, EVEN THOUGH WE PAID FOR AN EXTENDED WARRANTY. WE'VE ALSO PUT THREE ALTERNATORS ON IT IN ONE MONTH AND HAD THE CAM SEALS REPLACED. CAM SEALS ALSO SEEM TO BE A COMMON PROBLEM WITH THOSE CARS, ACCORDING TO ONE TECHNICIAN. THESE PROBLEMS HAVE BEEN GOING ON SINCE NOVEMBER 2003. CB
Jan 16, 2004
SUSPENSION
1 complaint
AT ONLY 15 MILES PER HOUR, OUR MITSUBISHI MONTERO SPORT ROLLED OVER AND THE CAR WAS TOTALLED.*AK
Aug 27, 2003
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,FUEL SYSTEM, OTHER
1 complaint
THIS CAR HAVE A LOT OF PROBLEM THAT THE DEALER CANNOT RESOLVED OR FIX, IT FIRST STARTED ON NOV 15,2002 WHEN THE CAR STALLED WHEN ON IDLE. I CALLED THE DEALER THE NEXT DAY NOV 16,2002 AND ADDRESS THE PROBLEM, BUT THEY TOLD ME IF THE SAME PROBLEM HAPPEN, BRING IT TO THE NEAREST DEALER. ON JANUARY 1, 2003 THE CAR STALLS AGAIN AND THE CHECK ENGINE LIGHT IS ON, ON JANUARY 2,2003 I WENT TO THE DEALER AND THEY DIAGNOSED THE CAR AND THEY TOLD ME THE PROBLEM IS MISFIRE AND THEY RESET THE LIGHTS AND ADJUST THE IDLE. ON JANUARY 14,2003 THE CAR STALLS AGAIN, THE NEXT DAY I WENT TO THE DEALER AND THE CAR STALLS AGAIN AND I GOT ALMOST HIT AT THE FREEWAY. AND THEY REPLACED THE IDLE SPEED CONTROL AND TOLD ME THEY FIX THE PROBLEM. BUT AFTER A WEEK ON JANUARY 14, 2003 THE CAR STALLS AGAIN, AND WHEN I GOT HOME A GAS IS LEAKING UNDER THE GAS TANK IT ONLY STOP LEAKING WHEN I OPEN THE THE GAS CAP. THE NEXT DAY ON MY WAY TO THE DEALER THE CAR STALLS AGAIN ON THE FREEWAY AND I GOT ALMOST GOT AN ACCIDENT ON THE FREEWAY BECAUSE THE CAR JUST STOP AND HESITATE TO START AFTER SEVERAL ATTEMP IT STARTS AND I CALLED THE DEALER AND MITSUBISHI CUSTOMER RELATIONS AND DRIVE TO THE DEALER, THEY ADVICE ME TO LEAVE THE CAR FOR THE DAY AND THEY WILL CONTACT THE FACTORY TECHNICIAN REGARDING THE PROBLEM, THE NEXT DAY I WENT BACK TO THE DEALER TO PICK UP THE CAR BUT THEY TOLD ME THAT THEY CANNOT DUPLICATE THE PROBLEM SO THEY NEED ANOTHER DAY, ON THE THIRD DAY I JUST CALLED THEM AND ASK ANY DEVELOPEMENT BUT THEY TOLD ME THAT THE DISTRICT MANAGER IS GOING TO THE DEALER TO LOOK IN TO THE PROBLEM, AND THEY WILL GIVE ME AN ANSWER. THE NEXT DAY ON THE FOURTH DAY I CALLED THE DEALER AND THEY TOLD ME TO PICK UP THE CAR AND THEY CANNOT DUPLICATE THE PROBLEM, SO HOW IS MY SAFETY WITH THIS CAR WHILE I AM DRIVING IT AND STALLS ON THE ROAD WITHOUT WARNING AND GOT AN ACCIDENT, AND WHEN WILL THEY FIND A SOLUTION TO THIS PROBLEM IF THEY CANNOT DUPLICATE THE PROBLEM
Jan 25, 2003
ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER,VISIBILITY,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
THIS VEHICLE HAS HAD MULTIPLE PROBLEMS WHICH THE DEALERSHIP, ON MULTIPLE ATTEMPTS TO FIX, HAS NOT BEEN ABLE TO FIX FAILURE. INITIALLY, THE VEHICLE WAS LEAKING FUEL AT THE PASSENGER REAR WHEEL WELL. THIS HAS OCCURRED ON 3 SEPARATE OCCASIONS. NO REASON FOR THIS WAS FOUND UPON INSPECTION. THE 3RD TIME THERE WAS FUEL LEAKAGE, THERE WAS ALSO A FAILURE OF THE ENGINE IN WHICH HESITATING AND STALLING OCCURRED. THE SES LIGHT DID INITIATE. INITIALLY THE SOLENOID WAS REPLACED. 6 DAYS LATER THE SAME THING OCCURRED AND THE SES LIGHT DID AGAIN COME ON. THE VEHICLE WAS AGAIN TAKEN TO THE DEALER AND THE REAR CAMSTER AND FILTER WAS REPLACED. WE REQUESTED A MEETING WITH THE DISTRICT MANAGER TO DISCUSS THE PROBLEM. WE WERE TOLD HE WOULD BE BACK FROM VACATION AFTER 10/1 AND WE WOULD BE CONTACTED. AFTER THE LAST REPAIR, THE VEHICLE HAD A PROBLEM WITH LOSS OF POWER AT TIMES. THIS INCLUDED SLOW RESPONSE WHEN STEPPING ON THE FUEL (TO INCLUDE FLOORING IT) WHEN TRYING TO PASS. IT WAS TAKEN TO THE DEALER ON 10/4. THE SERVICE MANAGER DROVE IT AND STATED "COULD NOT DUPLICATE COMPLAINT". IT WAS TAKEN TO THE DEALER A SECOND TIME APPROX. 1 WK LATER AND EVEN THOUGH FLOORING IT AT 35 MPH INITIATED A SLUGGISH RESPONSE IN WHICH THE RPM NEVER JUMPED UP BUT JUST STEADILY INCLINED AT A SLOW RATE, THE SERVICE MANAGER AGAIN SAID HE FELT THERE WAS NO PROBLEM. THIS LOSS OF POWER HAPPENED ONCE WHEN TRYING TO MERGE ONTO THE FREEWAY AND I ALMOST GOT HIT BEFORE I COULD PULL BACK OVER AND OUT OF THE WAY. ON 10/21 THE VEHICLE AGAIN EXHIBITED PROBLEMS WITH ACCELERATION FROM A STOP THIS TIME STALLING. AFTER 3 ATTEMPTS, I WAS STILL UNABLE TO RESTART THE VEHICLE. IT SAT FOR 65 MINUTES WAITING FOR MITSUBISHI'S TOWING SERVICE. AT THAT TIME, MY HUSBAND CAME AND STARTED THE VEHICLE. IT STARTED ON THE 2ND ATTEMPT AND BLUE-BLACK SMOKE CAME OUT FROM THE EXHAUST. WE DID DRIVE IT DOWN TO THE DEALERSHIP WITH ONLY TWO INSTANCES OF SOME LOSS OF POWER. PROBLEM STILL NOT CORRECTED. DT
Oct 29, 2002
STEERING,SERVICE BRAKES, HYDRAULIC
1 complaint
WHILE DRIVING, BRAKES WILL LOCK UP, AND THEN STEERING LOCKS UP. THIS CAN HAPPEN AT ANY TIME. CONTACTED DEALER, AND THE DEALER CANNOT FIND THE CAUSE. *AK CONSUMER STATES BRAKES AND STEERING LOCKED ON HIGHWAY TWO TIMES IN FIVE MONTHS. *YH
Apr 15, 2002
Frequently Asked Questions
How many problems does the 2002 MITSUBISHI Montero have?
The 2002 MITSUBISHI Montero currently has 174 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2002 MITSUBISHI Montero?
The most common problems reported for the 2002 MITSUBISHI Montero are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2002 MITSUBISHI Montero problem data come from?
All problem and complaint data for the 2002 MITSUBISHI Montero comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - MITSUBISHI Montero Problems
2025
2024
2023
2022
2021
2020
2019
2018
2017
2016
2015
2014
2013
2012
2011
2010
2009
2008
2007
2006
2005
2004
2003
2001
2000
Other MITSUBISHI Models
3000GT
Cordia
Diamante
Eclipse
Eclipse Cross
Endeavor
Expo
FE140 (FECZTS)
FE160 (FEC7TS)
FE160 (FEC7TW)
FE180 (FEC9TS)
FE434
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models