2004 MAZDA RX-8 Problems & Complaints
Real owner complaints and problems reported to the National Highway Traffic Safety Administration (NHTSA). View common issues by component.
513
Complaints Reported
Complaints by Component
POWER TRAIN
132 complaints
CLUTCH PEDAL BROKE DRIVING DOWN THE ROAD
Feb 10, 2020
DRIVING DOWN THE ROAD AND CAME TO A STOP LIGHT, ENGAGED THE CLUTCH HEARD A POP AND HAVEN'T BEEN ABLE TO GET INTO GEAR SINCE.I WAS IN THE MIDDLE OF TRAFFIC AND WAS NEARLY REAR ENDED CAUSE THE COUCH WOULDN'T DISENGAGE TO BUT IT IN GREAT CAUSE THE BRACKET HAD BROKEN COMPLETELY.
Mar 08, 2019
VEHICLE IN MOTION (3RD GEAR). SLOWED TO MAKE A LEFT TURN. DEPRESSED CLUTCH PEDAL TO SHIFT INTO NEUTRAL. PEDAL STAYED ON FLOOR. I PULLED IT UP WITH MY FOOT AND ATTEMPTED TO PUMP IT IN AN EFFORT TO BUILD PRESSURE. WITH CLUTCH DEPRESSED VEHICLE COULD NOT BE SHIFTED INTO GEAR UNLESS PUMPED MULTIPLE TIMES, THEN CLUTCH WOULD ENGAGE LESS THAN 2 INCHES OF TRAVEL FROM FLOOR. PEDAL MOVES BACK AND FORTH SIDE WAYS AS WELL..
Apr 09, 2018
I WAS DRIVING DOWN THE ROAD AND I WENT TO SLOW DOWN AT A LIGHT AND WHEN I PRESSED THE CLUTCH PEDAL TO ENGAGE THE BRAKE I HEARD A POP AND MY CLUTCH FELT LIKE IT WAS SHIFTING TO THE SIDE AND IT BARELY CUTS OFF ENOUGH TO COME OUT OF GEAR. I INSPECTED THE THE ASSEMBLY BY LOOKING UNDER THE STEERING WHEEL AND I FOUND THAT A WELD HAD SNAPPED.
Jul 31, 2017
THE CLUTCH PEDAL ASSEMBLY BROKE WHERE IT ATTACHES TO THE VEHICLE. THIS IS THE SECOND TIME THIS HAS HAPPENED. WHEN I BOUGHT THE CARD 21 MONTHS AGO IT WAS BROKEN. I HAD IT REPLACED BY A MECHANIC WITH AN OEM REPLACEMENT AND IT HAS NOW OCCURRED AGAIN BUT IN A DIFFERENT POSITION.
Apr 20, 2017
+ 127 more complaints for this component
ENGINE AND ENGINE COOLING
92 complaints
RUSTED OIL COOLER LINES AND FITTINGS ON MY RX8 DRIVEN IN OHIO WHERE ROAD SALTING IS PREVALENT IN SNOW MONTHS. FILING THIS COMPLAINT SINCE THERE IS A RECALL ISSUED FOR MY SAME MODEL YEAR IN CANADA (SPECIAL PROGRAM 76) FOR THIS EXACT ISSUE DUE TO SNOW AND SALT. MODIFIED LINES ARE AVAILABLE TO ADDRESS ISSUE BUT MAZDA IS NOT EXTENDING RECALL COVERAGE TO U.S. REPAIR COST AT DEALER ABOVE $1K. *TR
Mar 26, 2014
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT WAS DRIVING 5-10 MPH WHEN THE ENGINE STALLED WITH THE ILLUMINATION OF THE ENGINE COOLANT WARNING LIGHT. THE VEHICLE WAS LATER RESTARTED AND TAKEN TO THE DEALER AND A PRIVATE MECHANIC. THE DIAGNOSIS FROM BOTH WAS THAT THE ENGINE WAS FLOODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGE WAS 139,000.
Apr 23, 2012
THE CAR WAS TAKEN TO THE DEALERSHIP DUE TO AN ENGINE RECALL, AFTER THE ENGINE WAS REPLACED UNDER WARRANTY THE DEALER INFORMED ME OF LARGE OIL LEAKS. LEAKS ARE VISIBLE AND ARE COVERING PARTS OF THE WHEELS AND JOINTS WITH OIL. MAZDA HAS ADMITTED TO THIS DEFECT IN CANADA (FIELD ACTION NUMBER 142-36) AND ARE PROVIDING CANADIAN CUSTOMERS WITH A RECALL ON THIS FAULTY AND DANGEROUS PART BUT US CUSTOMERS HAVE YET TO RECEIVE SUCH TREATMENT. MY CAR IS A 2004 MODEL AND IT SHOULD NOT HAVE SUCH ISSUES. THIS IS A HAZARD TO BOTH MY SAFETY AND THE SAFETY OF OTHERS ON THE ROAD DUE TO THE AMOUNTS OF OIL THAT THE CAR IS LEAKING DUE TO POOR ENGINEERING AND BAD DESIGN. THE MAZDA DEALERSHIPS ARE CHARGING CUSTOMER AN UPWARD OF 1,600 DOLLARS TO REPAIR THIS ISSUE WHICH SHOULD NOT BE AN ISSUE TO BEGIN WITH IF THIS CAR WAS DESIGNED IN A RELIABLE WAY. *TR
Nov 10, 2011
VEHICLE WAS BOUGHT NEW,2004. I HAVE EVERY OIL CHANGE, EVERY 2,900-3,000 MILES AND VEHICLE IS PERFECTLY MAINTAINED BY THE DEALERSHIP ( HARRELSON MAZDA -CHARLOTTE,NC ). ONCE 30,000 MILES WERE PUT ON THE VEHICLE, ENGINE BEGAN TO FAIL ( STOPPED AT RED LIGHTS, STOPPED WHILE ON THE HIGHWAY,ETC.). AFTER ABOUT 5 RETURN VISITS TO THE DEALERSHIP TECHNICIANS, MY ENGINE WAS FINALLY 'REPLACED' UNDER WARRANTY. NOW MY NEW ENGINE HAS FAILED AGAIN AT ABOUT 40,000 MILES FOR THE SAME REASON AS ORIGINALLY: MAZDA SPECIFICALLY ADVISES 10W-20 OIL IN THIS VEHICLE. BUT THIS IS ONLY TO SATISFY U.S. EPA STANDARDS. EVERYWHERE ELSE IN THE WORLD, MAZDA STRICTLY ADVISES 10W-30 OIL, BECAUSE ANYTHING LESS WILL ALLOW ENGINE TO OVERHEAT AND FAIL. I WAS NEVER WARNED THIS. I WAS NEVER ADVISED THIS. I SERVICED VEHICLE BY EVERY RECOMMENDATION OF MAZDA, THE OWNERS MANUAL, AND MY MAZDA AUTHORIZED DEALERSHIP/TECHNICIANS. MY SAFETY HAS BEEN PLACED IN JEOPARDY, SOLELY AT THE FAULT OF MAZDA, FOR NOT NOTIFYING BUYERS THAT THE ENGINE HAD INCORRECT MAINTENANCE SPECIFICATIONS,ETC. FEEL FREE TO CONTACT ME ANYTIME FOR FURTHER INFORMATION, RECEIPTS OF SERVICE,MAINTENANCE, AND TECHNICIAN TESTIMONY. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Oct 24, 2011
ENGINE STALLS AND LACK OF POWER. DEALER KEEPS SAYING ITS FINE. CANNOT EVEN DRIVE ANYMORE. IT STARTED WITH NOT STARTING THEN AFTER GETTING IT STARTED HESITATION AND LACK OF POWER KEPT GETTING WORSE. BECAME UNSAFE TO DRIVE. *TR
Aug 30, 2011
+ 87 more complaints for this component
STEERING
62 complaints
The electric power steering randomly pulls hard to one side while driving. There are brief spasms of forceful jerks each jerk is 1-2 seconds the series of jerks lasts 10-20 seconds and usually stops with power steering failure all while driving.
Feb 11, 2024
JULY 2017 WHEN I START THE CAR THE STEERING GEAR TURN TOO THE RIGHT ALL THE TIME. FEW MILE THE STEERING GET HARD AND START SHACKING BY IT SELF. NOW THE STEERING IS HARD WITH ABS AND CONTROL TRACTION LIGHT ON. I SEND IT TOO A MECANIC TOO CHECK THE WIRING AND RACK AND PINON AND THE MECANIC INDICATE THAT IS THE TORQUE SENSOR AND I HAVE TOO CHANGE THE RACK AND PINON.
Feb 24, 2021
STEERING TURN ALONE
Nov 27, 2019
WHILE DRIVING MY 2004, MAZDA RX8 THE ELECTRIC POWER STEERING MODULE FAILED, AND JERKED THE CAR AGGRESSIVELY TO THE LEFT INTO THE ONCOMING LANE OF TRAFFIC. THE FORCE WAS SO STRONG THAT IT CAUSED MOMENTARY LOSS OF CONTROL. FORTUNATELY, THERE WASN'T ANY ONCOMING TRAFFIC AT THAT MOMENT ON THAT PARTICULAR STRETCH OF ROAD. WHEN REVIEWING THE MAZDA FORUM THERE WERE SEVERAL OTHER OWNERS THAT EXPERIENCED THE SAME LOSS OF CONTROL OR FAILURE. ADDITIONALLY, MAZDA HAD POWER STEERING ASSIST RECALLS FOR THE SAME PROBLEMS, REF. MAZDA3/MAZDA5 POWER STEERING RECALL NOTIFICATION 6010H.
Oct 10, 2019
MY POWER STEERING INTERMITTENTLY GOES OUT FROM TIME TO TIME. I HAVE TAKEN IT TO THE SHOP 4 TIMES. THERE IS SOMETHING SERIOUSLY WRONG WITH THIS DESIGN AND THE VEHICLE IS VERY DANGEROUS.
Sep 27, 2019
+ 57 more complaints for this component
AIR BAGS
29 complaints
For a year I have responded to every notice for a recall repair (7 total) Mazda has not repaired my vehicle or scheduled its repair. My recall ID is 016742248 and my Campaign Number is 100409. My car has a DO NOT DRIVE status and Mazda tells me I MUST drive the car 2 hours to get it repaired each way. And they refuse to transport y vehicle even thought I have told them in phone conversations about my cars do not drive status. The latest attempt for filing for a repay was 7-21-25 at 9:40am central time.
Jul 21, 2025
ON 10/19/19 THE VEHICLE WAS INVOLVED IN A CRASH WHEN SWERVING TO AVOID A DEER ON THE ROAD. TWO TREES WERE HIT AND THE VEHICLE WAS FLIPPED ON ITS SIDE. NO AIRBAGS DEPLOYED DURING THIS ACCIDENT AS I WAS EXPECTED. PICTURES SHOW THE FRONT DAMAGE AND INTERIOR.
Oct 21, 2019
THE PASSENGER AIR BAG IS AFFECTING THE DASH CAUSING IT TO CRACK. IF THE AIR BAG IS TO DEPLOY THE DASH COULD SPLINTER FROM THE CRACKS AND CAUSE SERIOUS BODILY ENJURY.
May 12, 2019
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V382000 (AIR BAGS) AND 16V354000 (AIR BAGS). THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 06/13/17*LJ UPDATED 10/11/2017*JS
Apr 19, 2017
TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V382000 (AIR BAGS) AND 16V354000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT PROVIDED.
Aug 17, 2016
+ 24 more complaints for this component
ENGINE
19 complaints
The contact owns a 2004 Mazda RX-8. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine. The dealer determined that the engine had no compression. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 60,000.
May 23, 2024
Engine naturally wears out especially after 200k miles due to friction in the natural design of the Rotary engine, resulting in losing its overall function such as turning off in the middle of a drive due to loss of compression from worn Apex Seals of the Rotary. The rotary engine requires a replacement of the Apex Seals to continue functioning normally to avoid any unpredictable accidents due to engine failure. An event occurred where my RX-8 went into limp mode in the middle of the freeway as i was commuting due a misfire from poor compression, this is more then likely a common event nowadays for RX-8 owners starting at the S1 2004 models with newer models soon to follow the same incident as me. This is completely unsafe especially traveling at 65 MPH
Mar 29, 2023
THE MOTOR LOOSE COMPRESSION TO EASY, AFTER THAT ,THE CAR ITS JUNK.
Jul 03, 2019
VEHICLE MILEAGE UNDER 100,000. HAS HOT START ISSUE, LOW COMPRESSION. ENGINE WARRANTY SHOULD BE MET BY MILEAGE AND NOT BY YEARS. I AM REQUESTING RECALL BE RESPONSIBLE FOR THE ABOVE ISSUE. THANK YOU
Oct 12, 2017
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING THROUGH A DRIVE-THRU WINDOW, THE VEHICLE STALLED. THE VEHICLE WAS PUSHED TO A PARKING SPACE. WHILE ATTEMPTING TO START THE VEHICLE, A LOUD POP SOUND EMERGED FROM THE ENGINE COMPARTMENT. IMMEDIATELY AFTERWARDS, SMOKE AND FLAMES APPEARED. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT EVALUATED BY THE INSURANCE COMPANY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Sep 11, 2017
+ 14 more complaints for this component
FUEL SYSTEM, GASOLINE
11 complaints
The contact owns a 2004 Mazda RX-8. The contact stated that while the vehicle was parked, he noticed a strong gasoline odor originating from the vehicle. There was no warning light illuminated. The contact stated that the failure persisted. The vehicle was taken to the dealer where it was diagnosed that the fuel pump was fractured and needed to be replaced. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 17V354000 (Fuel System, Gasoline); however, the recall repair failed to fix the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they would follow up with him. The failure mileage was approximately 86,000.
Dec 23, 2022
CHECK ENGINE LIGHT COMING ON AFTER A FUEL FILLUP GO OFF AFTER DRIVEN PROBLEM STARTED LATE 2005 EARLY 2006 IN AND OUT OF SHOP CLEARED CODES REPLACED FUEL CAP, UPPER INTAKE, VACUUM PUMP, LATE 2007 THEY CLEARED CODES CLAIMED TO HAVE TIGHTENED A LOOSE CAP, AND STATED IF IT CAME BACK ON WILL NEED FUURTHER DIAGNOSES AT ADDITIONAL COST. I HAVE 8 INVOICES RANGING FROM PROGRAMMING PCM CLEARING CODES ONE FROM 2006 PRINTED ON THE INVOICE, CUSTOMER STATES CAME BACK ON SAME NIGHT SEEMS TO COME ON AFTER FILLUP. THAT WAS WHEN THE VEHICLE HAD LESS THAN 40,000 MILES. NOW THE FUEL GAUGE STOPPED WORKING AND THE CHECK ENGINE LIGHT IS ON CONTINUOUSLY, AND IT WONT PASS STATE INSPECTION. NOW ITS BEEN DIAGNOSED AS A FUEL SENDING UNIT COSTING OVER $600.00 THE PART IS ORDERED AND I INFORMED THEM THAT I WANTED ALL OLD REPLACED PARTS. *TR
Jun 08, 2010
PURCHASED MAZDA RX 8, FEB 28,2009, GULF VIEW AUTO, PORT RICHEY, FL, IMMEDIATELY MOVED TO UPSTATE NY 2 DAYS LATER. GAS GAUGE, INOPERATIVE. FEDERAL RECALL, MAZDA REFUSES TO FIX AFTER RECALL ISSUED DUE TO FIRES.SECTION 30120(1), FAILING TO REPAIR DEFECT, CAN BE PUNISHABLE BY CIVIL FINES. *TR
Sep 10, 2009
I WANT TO GO ON FILE THAT I HAVE A CONCERN WITH THE SOLUTION TO A PROBLEM WITH OUR 2004 MAZDA RX 8. WE PURCHASED IT USED FROM A REPUTABLE FORD DEALER SEVERAL MONTHS BACK AND HAD AN ISSUE WITH STARTING THE CAR. AFTER SOME ONLINE RESEARCH WE FOUND OUT THE CAR IS PRONE TO GAS FLOODING WHEN NOT ALLOW TO RUN UNTIL THE TEMPERATURE GAUGE IS HALFWAY. IF SHUT OFF BEFORE THE ENGINE FLOODS WITH GAS. I TOOK IT TO CORY FAIRBANKS MAZDA WHERE THE VIN WAS CHECKED AND THAT THE CAR DID HAVE THE RECALL 4206F ALREADY DONE AND THE ONLY SOLUTION TO THE PROBLEM IS TO LET THE CAR WARM UP. MY CONCERN IS THE CONSTANT EXCESSIVE FLOW OF GAS DURING START UP, RAW GAS CONSTANTLY FLOWING THROUGH THE CATALYTIC AND THE EXCESSIVE HEAT CREATED BY THESE ENGINES COULD CAUSE A FIRE AND INJURE ALL THOSE IN AND AROUND THE VEHICLE. I HAVE EMAILED MAZDA ALSO ABOUT MY CONCERNS AND FEEL THE SOLUTION IS A DISASTER WAITING TO HAPPEN. THANK YOU. *TR
Jul 06, 2009
MY MAZDA RX-8 HAS STALLED MANY TIMES WHILE AT A TRAFFIC LIGHT AND WHILE GOING ON TRIPS ON THE INTERSTATE AND ALL OF A SUDDEN IT WOULD LOSE POWER AND STALLS AND I WOULD HAVE TO PULL OVER AND START IT AGAIN WHICH IT WOULD TAKE A FEW MINUTES BEFORE IT WOULD START. I HAVE HAD MY MAZDA TOWED FROM MY HOUSE TO THE DEALER BEC IT WOULD NOT START AND I WAS TOLD THAT IT WAS FLOODED. NOW IT WON'T START AGAIN AND IT IS REALLY FRUSTRATING AND STARTING TO WORRY ME HOW DANGEROUS IT IS DRIVING MY MAZDA. I HAVE HAD MY MAZDA FOR A YEAR NOW AND THE ONLY TIME I DRIVE IT IS WHEN I GO ON A LONG TRIP OR TO GO SHOPPING AND MOSTLY ON WEEKENDS OR AFTER I GET OFF FROM WORK. I WOULD LIKE TO HAVE THIS RESOLVE SO THAT I WON'T GET HURT OR SOMEBODY ELSE WILL GET HURT BEC OF THIS. I UNDERSTAND THAT MAZDA RX-8 HAD A RECALL ON FUEL SYSTEM I JUST WONDER IF THIS WAS TAKEN CARE OF FOR THIS CAR. THE DEALER TOLD ME THE CAR IS FINE AND TO MAKE SURE TO WARM IT UP BEFORE YOU SHUT THE ENGINE DOWN ,I HAVE DONE THAT AND NOW MY MAZDA WILL NOT START AGAIN. *TR
Feb 25, 2008
+ 6 more complaints for this component
UNKNOWN OR OTHER
11 complaints
I NOW HAVE REPLACEDCLUTCH PEDAL THE FORTH TIME. IM WRITING THIS TO SEE IFI CAN STILL GET ONE FACTORY REPAIR OF THE PART THE PEDAL WILL BREAK IN WELD SPOT REGARDLESS OF MY TRYING NOT PUT TO MUCH PRESSURE.
Mar 27, 2021
PASSENGER DASH COVER HAS LOST INTEGRITY/CRACKED ALONG THE LINES WHERE THE AIRBAG DEPLOYS AND AM CONCERNED THAT THE FORCE OF POTENTIAL AIRBAG DEPLOYMENT COULD BE AFFECTED AND NOT WORK AS DESIGNED OR DEPLOY WITH TOO MUCH FORCE TO CAUSE INJURY OR DEATH TO THE OCCUPANT IF THE AIRBAG COVER SHOULD FLY OFF UPON DEPLOYMENT. THIS IS AN ISSUE WITH THE DASH OF MANY MAZDA VEHICLES AND SHOULD AT A MINIMUM BE REVIEWED. THE CAR HAS NOT BEEN IN ANY ACCIDENTS AND THE AIRBAGS RECALL HAS RECENTLY BEEN PERFORMED BY A MAZDA DEALER.
Nov 05, 2019
RUSTED OIL COOLER - LINES CAUSING MAJOR LEAKS THAT ARE SOAKING THE BRAKES AND TIRES WITH OIL.THIS COULD ALSO CAUSE THE ENGINE TO SEIZE WHILE DRIVING.
Apr 09, 2019
DRIVING DOWN THE HIGHWAY, WENT TO SHIFT UP INTO A HIGHER GEAR AND UPON DEPRESSION THE CLUTCH PEDAL ASSEMBLY SNAPPED AND BROKE PREVENTING ME FROM DISABLING THE TRANSMISSION AND ALLOWING THE TRANSMISSION TO GO INTO THE NEUTRAL OR ANY OTHER POSITION. I WAS TRAVELING AT APPROXIMATELY 65MPH AND MY CAR HAS ONLY 46,135 MILES ON IT
Oct 06, 2016
PCM FLASH
Jul 10, 2016
+ 6 more complaints for this component
FUEL/PROPULSION SYSTEM
10 complaints
Fuel fumes are leaking into passenger compartment and leaking from tank. Previous recall failed to fix
Aug 02, 2021
RECENTLY PURCHASED THE CAR FROM SOMEONE ELSE AND NOTICED THAT THE CABIN SMELLS LIKE FUEL. I THOUGHT MAYBE HE SPILLED SOME INSIDE IT BUT IT'S BEEN A WEEK AND THE SMELL IS STILL THERE. I DON'T KNOW WHY AND I'M WORRIED ABOUT THE CAR CATCHING FIRE OR ME GETTING CARBON MONOXIDE POISONING.
Feb 22, 2021
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE PERFORMED NORMALLY PRIOR TO BEING REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V354000 (FUEL SYSTEM, GASOLINE). BROEN AND WOOD BUICK GMC MAZDA (329 GREENVILLE BLVD SW, GREENVILLE, NC) DIAGNOSED THAT THE VEHICLE NEEDED A NEW FUEL TANK. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 71,000. *BF UPDATED 8/2/18*JB
Oct 24, 2017
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE THE VEHICLE WAS PARKED, THE CONTACT'S NEIGHBOR NOTICED A STRONG FUEL ODOR EMITTING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO LIBERTY MAZDA (91 W SERVICE RD, HARTFORD, CT 06120), BUT THE CONTACT WAS UNSURE OF THE DIAGNOSTIC RESULTS. THE DEALER STATED THAT THEY WOULD REPAIR THE VEHICLE, BUT WOULD CHARGE FOR LABOR BECAUSE THE REAR CROSS MEMBER WOULD NEED TO BE REMOVED TO GAIN ACCESS TO THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THEY WOULD CALL BACK TO ASSIST IN SCHEDULING AN APPOINTMENT. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 16V793000 (FUEL SYSTEM, GASOLINE) AND 17V354000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 83,800.
Aug 14, 2017
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V793000 (FUEL SYSTEM). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE LOCAL DEALER (KOONS MAZDA OF SILVER SPRING, 3111 AUTOMOTIVE BLVD, SILVER SPRING, MD 20904) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Aug 09, 2017
+ 5 more complaints for this component
VISIBILITY
10 complaints
TL* THE CONTACT OWNS A 2004 MAZDA RX8. THE CONTACT STATED THE CLIMATE CONTROL KNOB FAILED AND WHEN THE AIR CONDITIONER WAS ENGAGED, THE HEAT WOULD ACTIVATE INSTEAD AND VICE VERSA. THE CONTACTS WAS ADVISED BY HIS PERSONAL MECHANIC THAT THERE WAS A FAILURE WITHIN THE CLIMATE CONTROL UNIT AND IT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 24,000. UPDATED 07/08/11*LJ THE CONSUMER STATED IT TOOK FOUR VISITS TO THE DEALER FOR THEM TO FIX THE DEFETIVE HEATER/ AC CONTROLS. UPDATED 10/26/11
May 05, 2011
2004 MAZDA RX-8 PASSENGER SIDE SUN VISOR SLIPPED AT THE SEAMS AND DROPPED AND WOULD NOT STAY BACK UP. THIS IMPAIRED MY VISION WHILE DRIVING MAKING SEEING OUT THE RIGHT SIDE OF THE CAR THROUGH THE FRONT MINIMAL. I HAD TO HOLD IT UP WHILE MAKING TURNS OR CROSSING ROADS WITH TRAFFIC ARRIVING FROM THE RIGHT. I COULD NOT REPAIR THE VISOR AND HAD TO REMOVE IT IN ORDER TO DRIVE THE VEHICLE SAFELY. *TR
Jun 03, 2010
2004 MAZDA RX-8: WHILE ATTEMPTING TO SWING DRIVER SIDE SUN VISOR DOWN FOR USE, THE SUN VISOR SEPARATED AT THE TOP MOLDED PLASTIC SEAM EDGE AND NO LONGER STAYS IN UPRIGHT POSITION, BLOCKING DRIVER'S VISION. VISOR HAD TO BE FORCIBLE REMOVED FROM ROOF ATTACHMENT STEM SINCE IT HUNG IN COMPLETE DOWN POSITION, CREATING A DRIVING HAZARD IF IT WOULD BE ALLOWED TO REMAIN. IT COULD NOT BE SWUNG TO SIDE AS THIS BLOCKED THE SIDE VISION. VISOR WAS RARELY USED, SO FAILURE WAS NOT DUE TO WEAR OR NEGLECT. THIS IS SECOND OCCURRENCE FOR EXACT SAME PROBLEM. LAST OCCURRED APPROXIMATELY 2.5 YEARS AGO, AND WAS REPLACED BY MAZDA UNDER THE ORIGINAL CAR WARRANTY AT NO COST. THE VEHICLE IS NOW BEYOND THE ORIGINAL WARRANTY PERIOD AND BEYOND THE 12 MONTH PART REPLACEMENT WARRANTY. WHEN REQUESTING THIS REPAIR RECENTLY THROUGH THE AT LOCAL MAZDA DEALER TO BE COVERED AS A LATENT DEFECT AT NO COST, EXPLAINING THIS WAS SECOND OCCURRENCE, THE SERVICE WRITER TOOK INFORMATION AND STATED HE WOULD TRY TO HAVE MAZDA COVER REPAIR AGAIN. CONTACTED SERVICE WRITER ON 11-4-09, HE STATED MAZDA DENIED MY REQUEST TO HAVE THE REPAIR COVERED AT NO COST. I HAVE A CURRENT REQUEST INTO MAZDA USA AT 800-222-5500 AGAIN REQUESTING RELIEF FOR THE REPAIR. THIS FORMAL COMPLAINT IS BEING FILED SINCE THIS IS THE SECOND OCCURRENCE FOR THE EXACT SAME PROBLEM. *TR
Nov 04, 2009
I HAVE AN RX-8 AND THE DRIVERS SIDE SUN VISOR JUST FELL OFF. AND I RARELY USE. IT APPEARS TO HAVE SEPARATED AROUND THE EDGES OR CAME UNGLUED. THE MAZDA DEALER WILL NOT REPLACE BECAUSE MY IS AN 04' WITH 32,000 MILES IS NOT UNDER WARRANTY, EVEN THOUGH IT ON THE TSB. *TR
Aug 23, 2009
THE HEATER CONTROL UNITS ARE FAILING ON MAZDA RX8. WHEN DRIVING THE AIR GOES HOT TO COLD BACK AND FORTH. IF YOU MOVE THE KNOB BACK AND FORTH YOU CAN GET YOUR HEAT BACK. I HAVE HAD WINDOWS FOG UP BECAUSE THE HEAT HAS GONE OUT. I HAVE CONTACTED MAZDA AND THEY WILL NOT ADDRESS IT. I AM NOT THE ONLY PERSON THIS AFFECTS. IF YOU DO A SEARCH ON RX8CLUB.COM YOU WILL SEE ALL THE FAILURES. *TR
Jan 27, 2008
+ 5 more complaints for this component
ELECTRICAL SYSTEM
9 complaints
SPORADIC POWER STEERING LOSS, ALMOST GOT INTO 2 ACCIDENTS. WHILE DRIVING I WOULD LOSS POWER STEERING.
Dec 21, 2018
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING 45 MPH, A BURNING ODOR ENTERED THE VEHICLE. THE CONTACT STOPPED THE VEHICLE, LIFTED THE HOOD, AND NOTICED SMOKE. THE CONTACT OBSERVED THAT THE WIRES UNDERNEATH THE HOOD WERE MELTED. THE CONTACT ALSO SMELLED FUEL COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC IN LOUISVILLE, KENTUCKY WHO DIAGNOSED THAT THE WIRING HARNESS HAD MELTED DUE TO A FAULTY ELECTRONIC CONTROL MODULE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND DEALER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 136,777. UPDATED 10/17/17*LJ *TR
Aug 21, 2017
2004 MAZDA RX8 VEHICLE WOULD NOT START IN COLD WEATHER OR DAMP WEATHER. MANY TRIPS TO DEALER TO NO ONE COULD FIND WHAT WAS WRONG. PROBLEM PROGRESSIVELY GOT WORSE WOULD ONLY START WHEN IT WANTED TO, FINALLY GOT TO THE POINT THAT IT WOULD NOT START AT ALL. ONCE THIS HAPPENED, IT WAS DETERMINED THAT IT WAS THE IMMOBILIZER MODULE HOWEVER SERVICE TECH'S AT DEALER CAN NOT SAY FOR SURE THAT IT IS THE ONLY PROBLEM. HAVE READ COMPLAINTS FROM OTHERS THAT OWN THIS VEHICLE HAVE HAD SAME PROBLEM BELIEVE THAT IT IS A DEFECT IN THE VEHICLE. *TR
Jan 07, 2009
MAZDA RX 8 FAILED TO START. SECOND TIME SENT TO DEALER FOR THE SAME PROBLEM. DEALER HAS HAD CAR FOR 5 DAYS WAITING FOR A BATTER FOR MY CAR. *JB
Jan 06, 2006
DT: THE ENGINE JUST TURNED OFF. THE VEHICLE CUT OFF TWICE WHEN TRYING TO GO UP HILL AT 20 MPH. THIS HAPPENED ON JULY 20TH, 2005. THE EVOLUTION WAS ROUGHLY AT 10,000 FEET. THE VEHICLE IS CURRENTLY AT THE DEALER. *AK *SC
Aug 22, 2005
+ 4 more complaints for this component
STRUCTURE
7 complaints
SEVERE OUTSIDE PAINT DEGREDATION WITH 54,000 MILES.
Jul 19, 2019
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT BOTH DOORS ON THE DRIVERS SIDE WOULD NOT OPEN FROM THE INTERIOR OR EXTERIOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 82,000.
Sep 28, 2011
THE CLUTCH PEDAL ON MY MAZDA RX-8 2004 MODEL IS MAKING A STRANGE NOISE EVERYTIME I STEP ON IT. THE CLUTCH DOESN'T FEEL LIKE ITS WORKING RIGHT, AND MYT BREAK SNAP ANYTIME SOON JUST LIKE WHAT ALREADY HAPPEND TO LOTS OF RX-8'S.
Mar 25, 2010
WHILE DRIVING MY 2004 RX-8 6SPEED MY CLUTCH PEDAL BROKE. THE ACTUAL WELDING BROKE ALONG THE INSIDE OF THE CAR UNDERNEATH THE DASH. IT IS NOT THE CLUTCH ITSELF, BUT THE ACTUAL PEDAL ASSEMBLY. IT WAS WHILE I WAS DRIVING AND SEEMS TO BE A PRETTY SERIOUS SAFETY ISSUE. I HAVE GOOGLED THIS ISSUE A BIT AND FOUND A LOT OF OTHER PEOPLE WITH THIS EXACT SAME PROBLEM THANKS *TR
Aug 22, 2009
MY CLUTCH PEDAL BRACKET BROKE FROM MY 2004 MAZDA RX-8 AT 62K MILES. *TR
Aug 17, 2009
+ 2 more complaints for this component
SUSPENSION
7 complaints
WHILE DRIVING AT APPROXIMATELY 45 MILES PER HOUR ON A RURAL ROAD, THE FRONT PASSENGER BALL JOINT SEPARATED FROM THE LOWER CONTROL ARM, CAUSING THE CONTROL ARM TO FIRST DROP ONTO THE INSIDE SURFACE OF THE FRONT PASSENGER WHEEL AND THEN ONTO THE GROUND AS THE WHEEL MOVED OUT OF ITS NORMAL POSITION. IN THE PROCESS, THE PASSENGER SIDE INNER TIE ROD WAS SEVERELY BENT, THE INSIDE SURFACE OF THE WHEEL WAS BADLY SCORED, THE TIRE SURFACE (WHICH CONTACTED THE FENDER) WAS DAMAGED, AND THE PASSENGER FRONT FENDER WAS BENT WHEN THE TIRE CONTACTED IT. I SPOKE WITH MAZDA USA, WHO PUT ME IN CONTACT WITH A LOCAL DEALER. I TOWED THE CAR TO THE DEALER AND DROPPED IT OFF. THEY HAVE REPLACED BOTH CONTROL ARMS (PER THE RECALL) AS WELL AS THE BENT TIE ROD AND PASSENGER FRONT WHEEL BEARING. THEY ALSO PERFORMED AN ALIGNMENT. MECHANICALLY, THEY HAVE REPAIRED THE CAR. HOWEVER, MAZDA IS REFUSING TO REMEDY THE DAMAGED WHEEL OR TIRE OR THE FENDER. SINCE THE CAR HAS BEEN LOWERED, THEIR CLAIM IS THAT THE FENDER MAY NOT HAVE BEEN DAMAGED ON A STOCK CAR AT STOCK RIDE HEIGHT. THEY MAY BE RIGHT, AND THE FENDER DAMAGE IS MINOR, SO I'M NOT WORRIED ABOUT THAT. HOWEVER, SINCE A STOCK VEHICLE WOULD LIKELY HAVE SUFFERED THE SAME WHEEL/TIRE DAMAGE, I WAS TOLD THAT IF THE VEHICLE HAD A STOCK WHEEL & TIRE THEY WOULD REPLACE THE WHEEL & TIRE SINCE THEY WERE BOTH DAMAGED. I'M NOT EVEN SURE WHAT "STOCK TIRE" MEANS ON A 14-YEAR-OLD CAR SINCE ANY CAR WILL HAVE HAD THE TIRES REPLACED MULTIPLE TIMES SINCE THEN, BUT AFTERMARKET OR NOT THE FAILURE OF THE RECALLED PART CAUSED DAMAGE TO THESE PARTS. BESIDES, WITH DAMAGE TO THE TREAD SURFACE OF THE TIRE, IT IS MY OPINION THAT THE SAFETY OF THE TIRE HAS BEEN COMPROMISED (OR, AT THE VERY LEAST, THE LIFE EXPECTANCY OF WHAT IS A NEARLY NEW TIRE HAS BEEN SEVERELY REDUCED).
Nov 01, 2018
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE THE VEHICLE WAS BEING SERVICED FOR ROUTINE MAINTENANCE, THE MECHANIC DISCOVERED THAT THE FRONT PASSENGER SIDE CONTROL ARM LOWER BALL JOINT WAS DETERIORATING WHICH COULD CAUSE A LOSS OF POWER STEERING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 05V325000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
May 28, 2015
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING APPROXIMATELY 35 MPH AND MAKING A RIGHT TURN, THE CONTACT HEARD A LOUD NOISE AND THE BALL JOINTS SEPARATED AND FRACTURED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 05V325000 (SUSPENSION). THE DEALER INSPECTED THE VEHICLE AND DETERMINED THAT THE RECALL REMEDY WAS NOT REQUIRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS PENDING THE MANUFACTURER'S APPROVAL FOR THE RECALL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.
Aug 25, 2014
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT THE FRONT DRIVERS SIDE TIRE WAS BEING REPLACED BY AN INDEPENDENT MECHANIC WHEN THE MECHANIC STATED THAT THE FRONT DRIVERS LOWER CONTROL ARM WAS CRACKED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHERE THE DEALER STATED THAT THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V325000 (SUSPENSION: FRONT: CONTROL ARM: LOWER BALL JOINT) WAS CLOSED AND THE REPAIRS WOULD BE COVERED UNDER A WARRANTY PRICE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 49,000 AND THE CURRENT MILEAGE WAS 50,000.
Aug 10, 2011
TL*THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT WHEN HAVING THE VEHICLE SERVICED, A MECHANIC STATED THE LOWER FRONT BALL JOINT WAS CRACKED WHICH COULD RESULT IN A CRASH. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED AN AUTHORIZED DEALER AND REFERENCED RECALL 05V325000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT); HE WAS INFORMED THAT THE VEHICLE WAS INSPECTED ACCORDING TO THE RECALL IN 2010 AND HAD PASSED INSPECTION; THEREFORE, NO REPAIRS WOULD BE PERFORMED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 78,500.
May 18, 2011
+ 2 more complaints for this component
AIR BAGS,STRUCTURE
6 complaints
FRONT PASSENGER AIR BAG COVER CRACKED AND EXPOSED.
Jun 21, 2017
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V362000 (AIR BAGS). AFTER THE REPAIR, THE DASHBOARD BEGAN TO CRACK IN THE LOCATION WHERE THE PASSENGER SIDE AIR BAGS WERE REPLACED. THE VEHICLE WAS TAKEN TO DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
Mar 01, 2017
MY PASSENGER SIDE DASHBOARD OVER THE AIRBAG IS CRACKED REALLY BAD LIKE YOU CAN SEE THE AIR BAG I AM AFRAID TO HAVE ANYONE IN THE PASSENGER SEAT I FEEL LIKE IT IS GOING TO SET THE AIR BAG OFF FOR NO REASON THE DEALERSHIP IS TELLING ME ITS GOING TO COST AROUND 700.00 TO FIX I HAVE DONE SOME RESEARCH ON THIS IT SEEMS TO BE A COMMON PROBLEM WITH THIS CAR. *TR
Mar 12, 2015
RX-8 CRACKED PASSENGER DASHBOARD. CRACKED IN THE OUTLINE OF THE FAULTY AIRBAG SHAPE. I AM TAKING IN FOR RECALL OF AIRBAG BUT AM REQUESTING DASH COVER REPLACEMENT AS IT IS CLEARLY CAUSED BY AIRBAG LEAKAGE/FAULT. *TR
Feb 17, 2015
DASH BOARD NO PASSENGER SIDE WHERE AIR BAG IS FOR ABOUT THE LAST 2 YEARS DASH STARTED CRACKING IN THE SHAPE OF A H EVERY SUMMER WHEN ITS HOT THE DASH LOOKS LIKE ITS GOT A BOW IN IT LIKE THE AIRBAG IS GOING TO JUST POP OUT IT HAS GOTTEN WORSE EACH YEAR NOW DEALER SAID NO RECALL BUT THERE IS A DEFECT IN THE AIRBAG TO DEPLOY WITHOUT A CRASH OCCURRING MANY RX-8 OWNERS ARE HAVING THIS CRACKING WHERE AIR BAGS ARE IN PASSENGER SIDE BUT MAZDA WANT DO ANYTHING TO FIX THE ISSUE UNTIL SOMEONE GETS HURT OR KILLED FROM THESE DEFECTIVE AIR BAGS ON THE RX8. *TR
Oct 27, 2014
+ 1 more complaint for this component
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM
5 complaints
I HAVE OWNED A 2004 MAZDA RX7 SINCE OCT 07 SINCE THEN THE ENGINE HAS BEEN REPLACED AT 26,000 MILES 2 SET OF COILS SPARK PLUGS AND WIRES, SENSORS, TRANSMISSION, RADIATOR RESERVOIR JUST FOR STARTERS. NOW THE CAR IS STALLING AT LOW RPM'S OR WHEN IT GETS HOT LEAVING ME STRANDED IN INTERSECTIONS AND ON BUSY FREEWAYS. MAZDA HAS A BULLETIN OUT ON THIS CAR BUT BECAUSE THEY DO NOT CONSIDER IT A SAFETY ISSUE THEY WILL NOT RECALL THE CAR. I BEG TO DIFFER!! BEING STRANDED IN AN INTERSECTION OR ON A BUSY HIGHWAY INCREASES MY ODDS GREATLY THAT I AM GOING TO BE HIT BY ANOTHER CAR AND POSSIBLY KILLED. THERE HAS GOT TO BE SOME TYPE OF GOVERNMENT BODY OUT THERE THAT CAN ENFORCE THESE MANY CLAIMS OF ENGINE FAILURE AGAINST MAZDA AND THERE ROTARY ENGINE BECAUSE THE LATEST DIAGNOSIS IS THAT I NEED TO REPLACE THE ENGINE AGAIN!! PLEASE HELP! *TR
Apr 06, 2010
I PURCHASED MY 2004 MAZDA RX-8 IN MARCH 2005 AND PROBLEMS WITH THE CHECK ENGINE LIGHT COMING ON DID NOT START UNTIL APRIL 2006. AT THAT TIME THE CAR HAD APPROXIMATELY 26,000 MILES ON IT (I HAVE A LONG COMMUTE 90% OF WHICH IS FREEWAY). THE FIRST SEVERAL TIMES BACK TO THE DEALER MINOR THINGS WERE ADJUSTED OR CLEANED SUCH AS THE SPARK PLUGS AND A SMALL VALVE A KIT TO A BUTTERFLY VALVE IN A CARBURETOR ENGINE. EVENTUALLY THE VALVE WAS REPLACED, BUT THE LIGHT STILL CAME BACK ON. IN FACT, ON ONE OCCASION THE CAR WAS PULLED OUT OF THE SHOP DOORS PRONOUNCED FIXED AND UPON MY STARTING IT AGAIN THE LIGHT WAS BACK ON. EVENTUALLY MAZDA APPROVED THAT THE INTAKE MANIFOLD BE REPLACED, WHICH IT WAS. THE CHECK ENGINE LIGHT HAS STAYED OFF SINCE THAT REPLACEMENT (ABOUT 3-MONTHS) , BUT OTHER PROBLEMS HAVE ARISEN. FIRST, EITHER THE INTAKE OR EXHAUST HEADS WERE NOT SEALED CORRECTLY SINCE THE ENGINE SOUNDS LIKE IT IS COMING THROUGH THE DASH. THIS HAS BEEN POINTED OUT BUT NEVER PROPERLY REPAIRED. NOW, AS OF AUGUST 3, 2007 THE CAR'S ELECTRICAL SYSTEM COMPLETELY SHUTS DOWN. THIS HAS HAPPENED ON 3 OCCASIONS WHERE WITHOUT ANY WARNING THE CAR SHUTS DOWN. THE NEEDLES IN THE DIALS ON THE DASH BOUNCE WILDLY BACK AND FORTH WHILE A CLICKING SOUND IS COMING FROM THE FUSE BOX IN THE ENGINE. NEEDLESS TO SAY THE CAR IS BACK IN FOR IT'S 10TH VISIT TO THE MAZDA DEALERSHIP IN CLEVELAND. I HAVE STARTED THE BUY BACK PROCEDURE WITH MAZDA. *JB
Aug 15, 2007
3 MONTHS AFTER PURCHASE OF 2004 RX-8 BATTERY AND SPARK PLUGS NEEDED TO BE REPLACED. *TS ONE SEVERAL OCCASIONS THE VEHICLE WOULD NOT START. THE VEHICLE'S BATTERY WAS REPLACED TWICE AND HAD TO BE CHARGED THREE TIMES. THE SPARK PLUGS WERE REPLACED THREE TIMES. THE COMPUTER WAS REPROGRAMMED. THE ENGINE WAS REPLACED TO ALLEVIATE STALLING. THE CATALYTIC CONVERTER, 02 SENSOR, AMPLIFIER AND STARTER WERE ALSO REPLACED. *NM
Feb 21, 2006
I PURCHASED THE CAR IN MARCH 2004. DURING THE TIME SPAN OF JULY 2004-OCTOBER 2005 THE CAR HAS BEEN IN THE SERVICE DEPT. FOR FAILURE TO START AND ENGINE FAILURE DURING DRIVING THE CAR. OCTOBER 5, 2005 THE DEALERSHIP TOLD ME TO PICK UP THE CAR THAT IT WAS FIXED. I WENT AND PICKED UP THE CAR AND STARTED HOME IN THE CAR THE CAR QUIT RUNNING ON THE INTERSTATE AT 70 MILES PER HOUR AND MYSELF AND TWO CHILDREN WERE ALMOST HIT BY TWO BIG TRUCKS. *JB
Oct 18, 2005
IF THE CAR STALLS AFTER A COLD START, IT IS EITHER VERY DIFFICULT OR IMPOSSIBLE TO RESTART. USING THE PROCEDURE IN THE OWNERS MANUAL FOR THIS SITUATION WILL WORK, IF THE BATTERY DOES NOT FAIL FIRST. I HAVE HAD THIS HAPPEN TWICE, ONCE THE CAR WAS TOWED. THE SECOND TIME, THE BATTERY DIED WHILE ATTEMPTING A RESTART PER THE OWNERS MANUAL, BUT THE CAR WAS IN THE GARAGE AND I RECHARGED THE BATTERY AND EVENTUALLY GOT THE CAR STARTED.*AK
Feb 25, 2004
STEERING,ELECTRICAL SYSTEM
4 complaints
MY POWER STEERING GOES IN AND OUT AS IT PLEASES; ONLY WORKS WHEN IT WANTS TO AND CUTS UP WHEN DRIVING AND HAD TO TURN OFF CAR TO MAKE IT WORK TO ONLY MAKE IT REPEAT AGAIN. DOES THIS ONLY WHEN DRIVING. AND NOT SAFE FOR ANYBODY WHO IS DEALING WITH THE NO POWERSTEERING ISSUES OR HAVE STEERING BUT WITH MANY FAULTS THAT CAN LEAD TO ACCIDENTS/DEATH MAZDA FIXED OTHERS BY WIRE TAPPING ALL DELETING THE POWERSTEERING CONNECTIONS. BUT ONLY HAVING THE ISSUE LATER DOWN THE ROAD THEY DID THIS AROUND FEBRUARY/MARCH OF LAST YEAR AND HAD IN AND OUT POWERSTEERING AFTER 3 MONTH OF THEIR REPAIR.
Jan 26, 2018
POWERS STEERING FAILED. *TR
Dec 23, 2012
I HAVE BEEN GOING BACK AND FORTH TO THE DEALER FOR MY RX8'S POWER STEERING FAILURE WHILE DRIVING AT VARIOUS SPEEDS. WHEN IT SHUT OFF TWICE OF THE MANY TIMES, IT PULLED MY CAR TO THE HARD RIGHT AND I ALMOST RAN OFF THE ROAD BECAUSE OF IT. THE DEALERSHIP CHARGED ME THE FIRST TIME TO REPLACE THE BATTERY TERMINAL BECAUSE IT WAS LOOSING POWER TO THE STEERING UNIT. THEN MULTIPLE TIMES LATER, HUNDREDS MORE, THEY SAID THAT REPAIRING THE WIRING HARNESS CONNECTORS WAS RECOMMENDED BY THEIR TECH LINE AND THEY SAID THAT MAY NOT BE THE LAST THING NEEDED. FIRST OF ALL, THE DEALERSHIP, HERITAGE MAZDA OF LUTHERVILLE, MD, SEEM TO BE WORKING HARD ON THIS PROBLEM, BUT THIS TRULY IS A TRAFFIC SAFETY ISSUE AND ITS COSTING ME HUNDREDS IN A SHOT IN THE DARK TO FIX THE PROBLEM. CAN YOU PLEASE LOOK INTO THIS SAFETY MATTER, EVEN MIKE WITH THE SERVICE DEPARTMENT ADDED THAT IT WAS DEFINITELY A SAFETY ISSUE THAT NEEDED TO BE ADDRESSED. ON THE RX8 CLUB WEBSITE, THERE ARE NUMEROUS COMPLAINTS ABOUT THE SAME POWER STEERING FAILURE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Oct 18, 2012
I JUMPED INTO MY 2004 MAZDA RX-8 AFTER WORK STARTED IT UP AND WENT TO DRIVE AND NOTICED IT WAS REALLY HARD TO TURN AND I LOOKED AND NOTICED THAT A LIGHT THAT WAS A STEERING WHEEL WITH AN EXCLAMATION MARK NEXT TO IT SO I DROVE IT HOME NOT EVEN A MILE AWAY AND READ ABOUT IT ONLINE AND FOUND OUT IT HAPPENS A LOT. PROBABLY GOING TO TAKE IT TO THE DEALER VERY VERY SOON. *TR
Jul 16, 2012
POWER TRAIN,VEHICLE SPEED CONTROL
4 complaints
AS MY WIFE AND I WERE DRIVING HOME MY CLUTCH PEDAL STUCK TO THE FLOOR. I COULDN'T SHIFT GEARS SO I HAD TO COAST TO THE EMERGENCY LANE. *TR
Jun 12, 2011
1. CLUTCH PEDAL ASSEMBLY WOULD MAKE POP NOISE WHEN BEING DEPRESSED AND RELEASED. 2. CLUTCH PEDAL BRACKET TO FIREWALL SNAPPED CAUSING CLUTCH PEDAL TO NOT RETURN. COULD NOT CHANGE GEARS OR STOP WITH CAR ON. 3.HAD TO REPLACE WITH FACTORY PEDAL (THE SAME PEDAL THAT CAUSED THE PROBLEM). *TR
May 26, 2011
EVERYTHING STARTED FINE. WHILE DRIVING MY CLUTCH PEDAL FAILED ON ME AND I WAS UNABLE TO PROPERLY MANEUVER THE VEHICLE. CLUTCH PEDAL STICKS TO THE GROUND AND THE GEARS GET STUCK AND I HAVE TO RIP THEM OUT. IT HAPPENED ONCE, BECAUSE NOW THE CAR IS INOPERABLE. TO CORRECT THE FAILURE I'M GOING TO REPLACE CLUTCH PEDAL BRACKET ASSEMBLY AND POSSIBLY AN NEW CLUTCH ALTOGETHER. *TR
Jun 15, 2010
1. CLUTCH PEDAL FELT ABOUT A 1/2" LOW (AS IF HYDRAULIC FLUID HAD AN AIR POCKET AND NEEDED BLEEDING) ABOUT TWO BLOCKS BEFORE FAILURE. 2. I WAS STOPPED AT A LIGHT BEHIND 3 CARS IN THE RIGHT HAND LANE, SHIFTED INTO FIRST WHEN THE LIGHT TURNED GREEN; ACCELERATED VERY SLOWLY AND TRIED SHIFTING TO SECOND GEAR BUT THE PEDAL MADE A SNAPPING SOUND AND WENT TO THE FLOOR, THE ENGINE STALLED AND THE TRANSMISSION WAS STUCK IN FIRST UNTIL I LET THE CAR ROLL BACK A LITTLE AND GOT IT IN NEUTRAL. I WAS STUCK IN A MAJOR INTERSECTION AND THERE WAS GRIDLOCK, LOTS OF HONKING AND YELLING AND A FEW CARS CAME VERY CLOSE TO HAVING ACCIDENTS. I PUSHED MY CAR TO THE EDGE OF THE INTERSECTION AND WAITED FOR THE TOW TRUCK. THE TOW TRUCK HAD TO HAVE SMALLER PICKUP BROUGHT IN TO WINCH MY CAR OUT OF THE INTERSECTION BECAUSE HE SAID IT WAS UNSAFE TO SET UP THE TOW RIGHT IN THE MIDDLE OF THE INTERSECTION. 3. MY CAR WAS TOWED TO MY MECHANIC AND AFTER INSPECTION HE SAID IT WOULD HAPPEN AGAIN TO A NEW PEDAL FROM MAZDA. HE WAS SURPRISED IT LASTED FOR 60K MILES. AFTER SOME RESEARCH I ORDERED A REINFORCED CLUTCH PEDAL BRACKET ASSEMBLY FROM HERE: HTTP://WWW.FLUIDMOTORSPORTS.COM/P-188-TRANSMISSION-AND-ACCESSORIES.ASPX TURNS OUT HERE ARE THREE AFTERMARKET COMPANIES MANUFACTURING REINFORCEMENTS, MAZSPORT, BHR AND RACE ROOTS; EACH HAS THEIR OWN DESIGN AND THEY ARE SELLING HUNDREDS OF THEM BECAUSE ALL THE PEDALS FAIL IN 40 - 80K MILES. *TR
Oct 27, 2009
EQUIPMENT
4 complaints
OWN A 2004 MAZDA RX8 AND THE CLUTCH PEDAL ASSEMBLY BROKE WHILE DRIVING. I HAVE READ OF EVIDENCE ONLINE THAT WOULD LEAD ME TO BELIEVE THAT THIS PART IS A DEFECT BY THE MANUFACTURER. I TOOK MY CAR TO PAUL MILLER FORD AND THEY TOLD ME THE REPLACEMENT OF THE CLUTCH PEDAL ASSEMBLY WOULD BE NEEDED TO DRIVE THE CAR AS IT WAS BEFORE THIS INCIDENT. THE COST TOTAL IS $440.98 THIS SEEMS RIDICULOUS SINCE I HAVE READ THAT IT IS IMPOSSIBLE FOR THE DRIVER TO EXERT TOO MUCH FORCE ON THE PEDAL. THE RESISTANCE IS DETERMINED BY THE CLUTCH, NOT THE DRIVER. I THINK THEIR ARE A LOT OF PEOPLE WHO OWN RX8'S AND EXPERIENCE THIS SAME PROBLEM. HOW CAN IT BE THAT WITH ALL THE ACCOUNTS OF PEOPLE THAT I HAVE REAL ONLINE ALONE THAT A RECALL HAS NOT ALREADY BEEN ISSUED. *TR
May 10, 2010
TAKING OFF (SMOOTHLY) FROM A TRAFFIC LIGHT, I ACCELERATE THE CAR TO 15 MPH AND BEING TO SHIFT IN 2ND GEAR. AS I DEPRESS THE CLUTCH PEDAL I HEARD A LOUD THUD AND REALIZED THAT MY CLUTCH PEDAL HAD COMPLETELY SNAPPED OFF AT THE FRAME OF THE CAR. I WAS IN CITY TRAFFIC WITH NO WAY TO SHIFT THE CAR BACK INTO GEAR (I HAD ALREADY PULLED THE GEAR SHIFT OUT OF FIRST GEAR). I MANAGED TO COAST THE CAR TO A PARKING LOT BUT BECAUSE OF THIS FAILURE OF EQUIPMENT - TRAFFIC WAS BACKED UP FOR AT LEAST A 1/2 MILE. 1. EVENT THAT LEAD TO FAILURE: NORMAL OPERATION 2: THE FAILURE: CLUTCH PEDAL 3: THE REPAIR: NEW CLUTCH PEDAL ASSEMBLY. *TR
Dec 02, 2008
I HAVE GONE INTO MY DEALERSHIP ON MORE THAN 6 TIMES DUE TO MY 2004 RX-8 AIR CONDITIONING NOT WORKING PROPERLY. I HAVE A CHILD IN THE BACK SEAT OF THE CAR, AND IN THE SUMMER TIME TEMPERATURES CAN REACH 105 OUTSIDE, AND MUCH HOTTER INSIDE MY CAR. MY AIR CONDITIONER FAILS TO WORK. EACH AND EVERY TIME I'VE TAKEN IT IN, IT HAS BEEN ON A DAY WHEN IT'S NOT THAT HOT OUTSIDE, AND THE TECH. SAYS THE OUT PUT OF THE A/C IS UP TO PAR. IT'S NOT TRUE CONSIDERING I'M DRIVING, AND SWEAT IS POURING DOWN MY FACE, AND MY BACK STICKS TO MY LEATHER SEATS. THE DEALERSHIP EVEN STATED THAT BY PUTTING IN A NEW A/C IT WOULD DO NO GOOD...THAT MAZDA WAS HAVING PROBLEMS WITH ALL OF THE A/C AND A NEW ONE WOULD HAVE THE SAME PROBLEMS. THE IS INCREDIBLY FRUSTRATING CONSIDERING THIS IS A NEW CAR. THIS IS A BIG ENOUGH PROBLEM THAT I WILL NEVER PURCHASE THIS VEHICLE AGAIN, AND I TELL ANYONE WHO ASKS NOT TO PURCHASE ONE AS WELL. WHAT GOOD IS A CAR IF IT WON'T COOL DOWN??*JB
Apr 06, 2006
A NEW MAZDA RX-8 WAS PURCHASED IN THE FALL OF 2003. THERE HAVE BEEN PROBLEMS STARTING IT IN THE COLD WEATHER. I RECEIVED AN EMAIL FROM MAZDA THAT THEY ARE AWARE OF THE PROBLEM AND IT EXISTS FOR ANYONE THAT LIVES IN THE NORTHEAST. WHY WASN'T THIS DISCLOSED PRIOR TO BEING PURCHASED> ANY IDEA WHAT CAN BE DONE TO HAVE THE CAR RETURNED AND THE MONEY I GAVE THEM REFUNDED? THANKS IN ADVANCE. *AK
Mar 05, 2004
AIR BAGS,UNKNOWN OR OTHER
3 complaints
FRONT PASSENGER AIRBAG CRACKED DASH AND PUSHED OUT GLOVE BOX.
Apr 28, 2021
PASSENGER SIDE DASH NEAR AIRBAG AREA (ABOVE GLOVE BOX VISUALLY) IS CRACKING HORIZONTALLY AND VERTICALLY. VERY CONCERNED ABOUT SAFETY OF THE PASSENGER, PREMATURE RUPTURE OF AIRBAG, RANDOM DEPLOYMENT OF AIRBAG. GARAGE KEPT CAR. CRACK HORIZONTAL HAS OVER TIME PROGRESSIVELY GOTTEN WORSE. VERTICAL CRACK BEGAN 12.13.16. IN GARAGE. HAVE APPOINTMENT WITH MAZDA DEALERSHIP TO REPAIR 16V-354-BUT RECALL PAPERWORK DOES NOT ACKNOWLEDGE THE AREA(S) OF DASH INCLUDED WITH REPAIR THAT WILL RESOLVE ISSUE AND POTENTIAL HAZARDS-INCLUDING ENCASEMENT OF AIRBAG. RECALL NOTICE DOES NOT ARTICULATE POTENTIAL PARTS ASSOCIATED. "PASSENGER FRONTAL AIR BAG INFLATOR" IS ALL DESCRIBED.
Dec 18, 2016
CRACKS IN THE DASH IMMEDIATELY ABOVE THE PASSENGER AIRBAG WHICH IS CURRENTLY A RECALL ISSUE. IT SEEMS THAT A LARGE NUMBER OF RX8 EXPERIENCE CRACKING IN THE SAME SPOT ON THE DASH, GENERALLY FOLLOWING AN "H" SHAPE. REPORTS ARE THAT THE CRACKS FOLLOW THE AIRBAG MODULE ASSEMBLY UNDERNEATH THE DASH, AND THE CRACKS FOLLOW THE SEAM THAT WOULD BE CREATED IN AN IMPACT FOR THE AIRBAG TO DEPLOY. IN MY CASE IT BEGAN WITH A 4" LEFT TO RIGHT CRACK. IN 2015 A RECALL WAS PERFORMED INVOLVING A TEMPORARY AIRBAG FIX UNTIL A PERMANENT FIX COULD BE DESIGNED. AFTER THIS INTERIM AIRBAG RECALL WAS PERFORMED, THE CRACKS INTENSIFIED. JUST RECEIVED ANOTHER RECALL NOTICE THAT THE "FINAL" AIRBAG FIX IS READY TO BE PERFORMED AT THE DEALER WHICH WITH ALL THE REMOVAL AND JOSTLING OF THE DASH TO MAKE THE FINAL AIRBAG REPAIR, WILL PROBABLY CREATE MORE CRACKS. THE RECALL WAS DUE TO THE POSSIBILITY THAT AIRBAG PARTS COULD BECOME PROJECTILES AND CAUSE INJURY. WOULD NOT A POORLY DESIGNED DASH SIMPLY BREAK INTO PIECES UPON AIRBAG DEPLOYMENT AND BECOME PROJECTILES AND INJURY? NUMEROUS RX8 OWNERS ARE SEEING NEARLY IDENTICAL H SHAPED CRACKS.
Dec 31, 2015
LATCHES/LOCKS/LINKAGES
3 complaints
THE DRIVERS SIDE DOOR WILL NOT UNLOCK. THIS IS AN APPARENTLY KNOWN ISSUE WITH MAZDA AS SEVERAL PEOPLE HAVE TALKED ABOUT IN CLUB SITES AND THERE ARE EVEN VIDEOS ON THIS ISSUE ON YOUTUBE. THE FACT OF THE MATTER IS THIS IS A VERY SERIOUS SAFETY ISSUE BECAUSE IF YOU CANNOT EXIT A VEHICLE QUICKLY AFTER AN ACCIDENT OR FIRE PEOPLE COULD DIE. SOMEONE ALREADY MENTIONED THIS ISSUE BACK IN 2010 AND FROM HOW I READ HIS INFORMATION NOTHING HAS BEEN DONE. PLEASE INVESTIGATE THIS ISSUE WITH THESE DOORS NOT BEING ABOUT TO UNLOCK AND OPEN. *TR
Oct 27, 2014
MY MAZDA RX8 DRIVERS DOOR LATCH BECAME DEFECTIVE. YOU CAN'T OPEN THE DOOR UNLESS YOU CLIMB OUT THE PASSENGER SIDE. A LOT OF MAZDA RX8 OWNERS HAVE HAD SIMILAR COMPLAINTS. YOU CAN GO ON RX8CLUB.COM AND SEE FOR YOURSELF. I HAVE BROUGHT IT TO MANY PLACES TO TRY TO HAVE IT FIXED AND NO ONE CAN DUE TO THE DESIGN OF THE DOOR. IF I WAS INVOLVED IN A ACCIDENT THERE WOULD BE NO WAY FOR ME TO ESCAPE THE VEHICLE. THIS IS VERY DANGEROUS AND I HAVE CALLED MAZDA TO COMPLAIN AND THEY ESSENTIALLY LAUGHED AT ME AND SAID I WAS ON MY OWN. IF I HAD ENOUGH MONEY I WOULD SUE THEM BECAUSE I HAVE A LEGITIMATE CASE. PLEASE KEEP IN MIND THAT THIS HAS EFFECTED HUNDREDS OF MAZDA RX8 OWNERS AND I AM NOT THE ONLY ONE. PLEASE INVESTIGATE THIS! SOMEONE IS GOING TO BE SERIOUSLY INJURED OR KILLED DUE TO THE FAILURE OF THE LATCH SYSTEM AND THE DESIGN FLAW THAT PREVENTS YOU FROM FIXING IT WITHOUT RIPPING THE DOOR OFF! *TR
Sep 14, 2010
MY DRIVERS SIDE DOOR LATCH IS DEFECTIVE. I CAN'T OPEN THE DOOR. I HAVE TRIED TO GET IT REPLACE, BUT THE AUTO BODY SHOP AND DEALER CAN'T DO SO. *TR
Jul 23, 2009
EXTERIOR LIGHTING
3 complaints
DEFECTIVE TAIL LIGHT ASSEMBLY;ALLOWS WATER/RAIN TO ENTER ASSEMBLY SECONDARY TO DEFECTIVE TAIL LIGHT GASKET WHICH DEGRADES WITH AGE. 2004 MAZDA RX-8. CONSUMER OBSERVED TAIL LIGHT ASSEMBLY RETAINING WATER AFTER A RAIN EVENT. CONSUMER RESEARCHED ONLINE AND FOUND THAT MAZDA ISSUED A "SERVICE RECALL" TO REPLACE THE DEFECTIVE GASKET IN THE TAIL LIGHT ASSEMBLIES. CONSUMER DID NOT RECEIVE RECALL NOTICE BECAUSE, ACCORDING TO THE DEALER, MY WARRANTY HAD EXPIRED AND THE RECALL WAS NOT A SAFETY ISSUE. MY QUESTION TO YOU, NHTSA, IS WHY, WHEN A SERVICE RECALL INDICATES THAT WATER IN THE TAIL LIGHT COULD RESULT A SHORT, OR, THE TAIL LIGHTS NO LONGER WORKING, IS THIS A SERVICE RECALL AND NOT A "SAFETY RECALL?" IT SEEMS TO ME THAT IF I WERE ON A CROSS-COUNTRY TRIP AND AT 2AM, ENCOUNTERED A SEVRE WINTER THUNDER STORM - RAIN AND SLEET - AND MY TAIL LIGHTS ACCUMULATED WATER, AND SHORTED OUT, THAT THIS IS NOT, ACCORDING TO YOUR AGENCY, A SAFETY ISSUE, BUT A SERVICE RECALL, WHICH IS NOT VALID UNLESS THE VEHICLE IS UNDER WARRANTY. SINCE THE PROBLEM IS A DEFECTIVE GASKET - WHICH DEGRADES OVER-TIME, AND WHEN IT FAILS, RESULTS IN THE FAILURE OF THE TAIL LIGHTS TO ILLUMINATE, IS NOT CLASSIFIED AS SAFETY ISSUE BY YOUR DEPARTMENT; I RESPECTFULLY REQUEST THAT YOU PROVIDE ME WITH THE DOCUMENTATION (AUTHORITY) THAT PERMITS AN AUTOMOBILE MANUFACTURER TO CLASSIFY THE POSSIBILE FAILURE OF THE VEHICLES TAIL LIGHTS AS A "SERVICE RECALL," AND NOT A SAFETY (ISSUE) RECALL. I WOULD APPRECIATE IF YOU WOULD FORWARD MY (THIS) INQUIRY TO MR. LAHOOD'S OFFICE BECAUSE HE RECENTLY IDICATED BEFOR A CONGRESSIONAL THAT HE TAKES, AND CONSIDERS EVERY INQUIRY TO HIS DEPARTMENT SERIOUSLY.
Feb 25, 2010
THE AUTO LEVELING HEADLIGHTS IN MAZDA RX8S AND CERTAIN OTHER MAZDA VEHICLES ROUTINELY MALFUNCTIONS DUE TO CORROSION. THIS CAUSES THE HEADLIGHTS TO AUTOMATICALLY RETURN TO THEIR LOWEST POSITION IN MOST CASES TOO LOW FOR DRIVING CONDITIONS CAUSING A MAJOR HAZARD TO ALL DRIVERS BOTH OF THE MAZDA AND OTHER VEHICLES. MAZDA RECOGNIZED THIS ISSUE WITH A SERVICE BULLETIN IN 2007 HOWEVER NEVER RECALLED THE VEHICLES FOR REPAIR AND WEATHERPROOFING. EVEN IF THE HEADLIGHTS ARE MANUALLY ADJUSTED THEY WILL RETURN TO THE LOWEST POSITION ONCE THE CAR IS STARTED AND THE MALFUNCTIONING AUTO LEVELING SENSORS KICK IN. THE DEALERSHIP THAT WE PURCHASED OUR MAZDA RX8 FROM DOES NOT SEE THIS AS A SAFETY ISSUE AND THEREFORE WILL NOT REPAIR OR REPLACE THE SENSORS. AFTER CONFERRING WITH STATE LAW ENFORCEMENT INSPECTORS, THEY DIFFER IN OPINION AS TO THE AUTO LEVELING MALFUNCTION BEING A HAZARD ESPECIALLY IF THE VEHICLE IS TRAVELING AT HIGHER SPEEDS. MAZDA SHOULD BE FORCED TO RECALL AND REPLACE THE MALFUNCTIONING SENSORS TO PREVENT ACCIDENTS DUE TO LACKING VISIBILITY. *TR
Oct 13, 2009
THE REAR PASSENGER TAIL LAMP ON THE 2004 MAZDA RX-8 IS KNOWN TO COLLECT WATER INSIDE THE LAMP, SOMETIMES AS MUCH AS 2 INCHES OR MORE. THIS IS A KNOWN ISSUE WITH MAZDA AND THEY WILL REPLACE THE LAMP ONLY IN UNDER WARRANTY. BUT ACCORDING TO THE MAZDA DEALER WHERE I PURCHASED MY VEHICLE, WATER IN A TAIL LAMP IS CONSIDERED A SAFETY HAZARD AND WILL NOT ALLOW THE VEHICLE TO PASS THE ANNUAL TEXAS DEPARTMENT OF PUBLIC SAFETY INSPECTION IN THE STATE OF TEXAS. ACCORDING TO THE DEALER, ALTHOUGH IT IS CONSIDERED A SAFETY HAZARD BY THE TEXAS DEPARTMENT OF PUBLIC SAFETY, THE REPLACEMENT OF THE LAMP WOULD NOT BE COVERED BY MAZDA SINCE MY VEHICLE MILEAGE EXCEEDS THE WARRANTY. IF IT IS CONSIDERED A SAFETY HAZARD BY THE TEXAS DEPARTMENT OF PUBLIC SAFETY AND IS NOT ACCEPTABLE TO THEIR INSPECTION PROCEDURES AND IT IS A KNOWN DEFECT BY MAZDA, I BELIEVE THAT MAZDA OWNS THE RESPONSIBILITY IN REPLACING THE TAIL LAMP. *TR
Jun 30, 2007
STEERING,FUEL/PROPULSION SYSTEM
2 complaints
WHILE DRIVING ON THE HIGHWAY,THE POWER STEERING OF THE VEHICLE FAILED SND 2 MADE IT EXTREMELY HARD TO STEER. I'VE HEARD OTHERS HAVE THIS SAME PROBLEM BUT MAZDA HAS NOT ADDRESSED IT
May 22, 2019
STEERING WHEEL VIOLENTLY SHAKES UPON TURNING AND NOW ON STRAIGHT-AWAY DRIVING. HAS BEEN SMELLING OF EXCESSIVE GAS FOR OVER 4 YEARS UPON START UP, DESPITE DEALER CORRECTING RECALL ISSUE WITH FUEL PUMP DISCHARGE PIPE.
Nov 27, 2018
AIR BAGS,ENGINE,FUEL/PROPULSION SYSTEM
2 complaints
TAKATA RECALL I RECEIVED A CALL REGARDING AN 'ESCALATION' OF MY RECALL AND WHEN I CALLED BACK THE INDIVIDUAL ON THE PHONE SAID THEY COULD NOT FIND MY INFORMATION. THE LAST TIME I TRIED TO GET MY RX8 REPAIRED I WAS TOLD I HAVE TO DRIVE THE CAR OVER AN HOUR TO THE SHOP TO GET AIRBAG FIXED - THIS IS AFTER I RECEIVED A VERY GRAPHIC POSTCARD SHOWING AND TELLING ME HOW I WILL BE INJURED OR KILLED IF I DON'T GET MY CAR REPAIRED. I AM TRYING TO GET THIS CAR REPAIRED, HOWEVER I WILL NOT DRIVE THIS CAR OVER AN HOUR IN HEAVY TRAFFIC IN SOUTH TEXAS HEAT AND HUMIDITY IN ORDER TO MAKE THE REQUIRED 100% COMPLIANCE EASY FOR TAKATA THERE ARE MULTIPLE OTHER RECALLS ON THIS CAR, INCLUDING ON THE ENGINE THAT I HAVE REPLACED 4 TIMES. DEALERS WERE TOLD TO INSTALL THE OLD ENGINES THAT WERE IN THEIR INVENTORY AND NOT INSTALL THE NEW DESIGN. THE OLD ENGINES CONTINUED TO LOOSE COMPRESSION OVER TIME AND EVEN THOUGH MAZDA EXTENDED THE WARRANTY TO 100K ON THE VEHICLE, EVENTUALLY I EXCEEDED 100K - AND THE 4TH ENGINE WENT BAD @102K. MAZDA NEVER REPLACED THE ENGINE WITH AN ENGINE THAT DID NOT HAVE COMPRESSION ISSUES. THE DEALERS USED THE SAME ENGINE AND MAZDA WAITED FOR CONSUMERS TO EXCEED THE 100K MILEAGE AND THEN REFUSED TO PROVIDE ANY FURTHER ASSISTANCE. I HAVE A BEAUTIFUL RX8 THAT IS BASICALLY A ROLLING CHASIS BECAUSE IT WILL NOT RUN, OVERHEATS THE FUEL SYSTEM (CAN EXPLODE OR CATCH FIRE), AND AIRBAGS THAT CAN INJURE OR KILL ME AT ANY MOMENT. I CANT EVEN OPEN THE DOOR ON THIS CAR FOR FEAR OF INJURY OR DEATH. IF THE AIRBAGS WERENT AN ISSUE, I CANT DRIVE THE CAR BECAUSE THE ENGINE LOOSES COMPRESSION AND POWER AND CAN PUT THE DRIVER IN A VERY DANGEROUS SITUATION IN TRAFFIC, AND FINALLY IF ALL ELSE WERE FUNCTIONING, THE EXHAUST CAN OVERHEAT THE FUEL TANK CAUSE EXPLOSION AND/OR FIRE. AT ONE POINT THE INTERIOR OF MY TRUNK MELTED. MY CAR HAS ZERO VALUE BECAUSE OF MAZDA AND TAKATA.
Feb 28, 2019
TAKATA RECALL AFTER RESPONDING TO NUMEROUS NOTICES REGARDING THIS RECALL AND THE DEADLY DANGER OF THE AIRBAGS, MAZDA STILL INSISTS THAT I DRIVE THE VEHICLE AN HOUR AWAY AND IN HEAVY CITY TRAFFIC TO HAVE THE SERVICE DONE TO CORRECT THE AIRBAG ISSUE. IN ADDITION, FOR YEARS THE ENGINE HAD COMPRESSION ISSUES AND I FOUND OUT THAT AFTER REPLACING THE ENGINE 4 TIMES UNDER WARRANTY, MAZDA WAS REPLACING THE ENGINE WITH THE SAME ENGINE THAT HAS COMPRESSION ISSUES AFTER A TIME. I WAS TOLD THAT I COULD BUY A $7,000 GEN II ENGINE THAT DID NOT HAVE COMPRESSION PROBLEMS, OR TAKE THE REPLACEMENT WITH THE POTENTIAL FOR COMPRESSION ISSUES AS A WARRANTY REPAIR. THEY WERE ABLE TO DEPLETE THEIR STOCK OF BAD ENGINES BY USING THEM AS REPLACEMENTS, AND AS SOON AS MY WARRANTY EXPIRED I STILL HAVE A FAULTY ENGINE WHICH ALSO KEEPS ME FROM SAFELY DRIVING DRIVING FOR SERVICE WORK. THE ENGINE WILL LOOSE COMPRESSION AND POWER IN TRAFFIC AND CAUSE A SAFETY ISSUE. I KEEP MY VEHICLES WELL PAST THE 100K MARK BECAUSE I TAKE CARE OF THEM AND KEEP THEM ON THE ROAD. HOWEVER, THAT HAS NOT BEEN THE CASE WITH THIS CAR, DUE TO A COMBINATION OF MAZDA'S BAD FAITH METHOD OF REPLACING FAULTY ENGINES, AND THE POTENTIALLY FATAL AIRBAG ISSUE. APPARENTLY THE CAR ALSO HAS ISSUES WITH THE EXHAUST OVERHEATING AND CAUSING A FIRE HAZARD, WHICH I HAVE NEVER BEEN NOTIFIED OF. ALTHOUGH A BEAUTIFUL CAR THAT I WOULD LOVE TO BE ABLE TO DRIVE, THIS VEHICLE IS UNSAFE IN MORE THAN ONE WAY AND HAS A CURRENT VALUE OF $0. IM EVEN AFRAID TO OPEN THE DOOR OF THE VEHICLE BECAUSE ACCORDING TO THE NOTICES I HAVE RECEIVED, THERE IS NO WAY TO KNOW WHEN OR WHAT MIGHT CAUSE THE AIRBAG TO DEPLOY. I REALLY CANNOT PUT A SPECIFIC DATE ON WHEN THE ISSUES OCCURRED, OTHER THAN THE SERVICE RECORDS FOR ENGINE REPLACEMENTS UP UNTIL THE 100K MARK. AT 102K MAZDA REFUSED TO REPLACE ANOTHER ENGINE THAT HAD GONE OUT.
May 08, 2018
STEERING,SUSPENSION
2 complaints
ON SEPTEMBER 15TH, 2016 I HAD STOPPED TO VACUUM OUT MY CAR AT A CAR WASH ON HIGHWAY 11 IN ATTALLA, AL. UPON LEAVING THE CAR WASH I TURNED LEFT ONTO PLEASANT VALLEY RD AT A SLOW SPEED IN FIRST GEAR. AS I WAS TURNING I SHIFTED INTO SECOND GEAR I HEAR A BREAKING NOISE AND THE STEERING WHEEL ABRUPTLY SPUN TO THE LEFT AS THE CAR WENT IN A DEEP DITCH FLIPPING ONTO ITS ROOF, THEN HITTING A SMALL CULVERT AND LANDING ON IT'S SIDE. AS I WAS INSPECTING THE VEHICLE TO SEE WHAT MIGHT HAVE HAPPENED, THE PASSENGER LOWER CONTROL HAD BROKEN AND THE BALL JOINT HAD SEPARATED FROM THE CONTROL ARM.
Feb 04, 2018
DRIVER CAME UPON A DEER AND SLAMMED THE BRAKES, MISSING THE DEER. WHILE SLAMMING THE BRAKES THE FRONT END COLLAPSED UPON THE LEFT FRONT WHEEL CAUSING SEVERE FRONT END DAMAGE AND MAKING THE CAR INOPERABLE. THE FRONT END REQUIRED NEW LEFT LOWER CONTROL ARM, STABILIZER BAR CONTROL LINK, NEW SHOCK/STRUT ASSEMBLY, NEW TIE RODS (INNER AND OUTER), NEW SWAY BAR LINK AND 4 WHEEL ALIGNMENT. THE ORIGINAL CAUSE OF THIS DAMAGE WAS A CRACK IN THE LEFT LOWER CONTROL ARM. THE LOWER CONTROL ARM WAS THE SUBJECT OF RECALL # 36261. I WAS NOT NOTIFIED OF THIS RECALL. UPON TALKING WITH MAZDA ([XXX]... FILE #[XXX]) ON MAY 14, 2013 I WAS INFORMED THAT WHILE THIS RECALL DID AFFECT OTHER RX8'S OF THE SAME YEAR, MY RX8 WAS NOT COVERED. I BELIEVE MY RX8 SHOULD HAVE BEEN COVERED UNDER THIS RECALL FOR THE SIMPLE FACT THAT THE DAMAGE WAS CAUSED BY THE SAME DEFECTIVE PART WHICH WAS THE SUBJECT OF RECALL #36261. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
May 14, 2013
ELECTRICAL SYSTEM,EQUIPMENT
2 complaints
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING 60 MPH, THE VEHICLE STALLED WHEN SHIFTED INTO NEUTRAL AND THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE AIR CONDITION PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
Aug 04, 2015
MAZDA RX8: SIR, I HAVE BEEN THE SOLE OWNER OF THIS VEHICLE SINCE THE DAY I PURCHASED IT, AND EACH TIME I'M ON A BUSINESS TRIP FOR ONE WEEK OR MORE, THE CAR HAS TO BE TOWED FOR SERVICES. EITHER FOR FLOODING OUT OR RECHARGING THE BATTERY. LAST MONTH I BOUGHT AN ADVERTISED DEVICE, CAR MD, TO HELP DIAGNOSE THE PROBLEM AND IT INDICATES THERE'S AN ELECTRONIC SENSOR ISSUE, WHICH MAZDA CHOOSE NOT TO ADMIT. MY CAR HAS LESS THAN 24,000 MILES ON IT AND HAS BEEN A LIVING NIGHTMARE SINCE I PURCHASED THE VEHICLE. NOW, THE COMPANY WANTS ME TO PAY FOUR THOUSAND DOLLARS FOR REPAIRS WHEN I BEEN COMPLAINING ABOUT THIS SAME ISSUE. REQUEST YOUR ASSISTANCE IN RECTIFYING THIS MATTER OR POINT ME IN THE RIGHT DIRECTION OF WHAT AGENCY HAS OVERSIGHT OF THESE MATTERS. *TR
May 14, 2011
POWER TRAIN,EQUIPMENT
2 complaints
2004 MAZDA RX-8 TOURING WITH 6-SPEED MANUAL HAS A BROKEN CLUTCH PEDAL. THE ALUMINUM CLUTCH PEDAL WEAVES LEFT AND RIGHT. IT IS ON THE VERGE OF SNAPPING IN HALF. PLACED THE CAR AT JAX AUTOMOTIVE WHILE I PURCHASE A NEW OEM CLUTCH PEDAL WITH REINFORCED BRACKETS FROM RACE ROOTS. *TR
Feb 24, 2013
THE BRACKET FOR THE CLUTCH PEDAL ON MY 2004 MAZDA RX-8 BROKE WHILE I WAS DRIVING THE VEHICLE. OVER THE PAST FEW WEEKS, THE CLUTCH WOULD SQUEAK A LITTLE BIT WHILE I WAS DRIVING IT. I NOTICED THAT THE BRACKET WAS LOOSE ONCE, SO I TIGHTENED THE BOLT ON IT, BUT THAT DIDN'T CHANGE THE SQUEAKING. LITTLE DID I KNOW THAT THE WHOLE BRACKET WAS ABOUT TO FAIL! I TOOK A CLOSE LOOK AT THE BROKEN BRACKET, AND IT APPEARS THAT A WELD BROKE. IT OCCURRED ONE MORNING ON MY WAY TO WORK. AS I DOWNSHIFTED FROM THIRD TO SECOND GEAR, I HEARD A 'CRACK' AND THEN MY CLUTCH WOULDN'T WORK PROPERLY. I LOOKED DOWN, AND THE CLUTCH PEDAL WAS NEXT TO (AND TOUCHING) THE BRAKE PEDAL (IT SHOULD NOT BE THAT CLOSE). I WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD WITHOUT THE ABILITY TO SHIFT. NOW, I CANNOT DRIVE THE VEHICLE, AS THE CLUTCH WILL NOT ENGAGE WITH THE BROKEN BRACKET. I BELIEVE THIS IS A SAFETY ISSUE, ESPECIALLY IN CASES LIKE MINE WHEN IT HAPPENED WHILE DRIVING THE VEHICLE. *TR
Oct 21, 2009
STEERING,AIR BAGS
2 complaints
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THE DRIVER WAS TRAVELING 35 MPH WHEN A VEHICLE CROSSED THE CENTER LANE CRASHING INTO A VEHICLE IN FRONT OF THE CONTACT CAUSING THAT VEHICLE TO CRASH INTO THE CONTACT. THE VEHICLE WAS HIT ON THE DRIVERS SIDE DOOR. THE AIR BAG IN THE STEERING WHEEL DID NOT DEPLOY AS THE STEERING WHEEL DETACHED FROM THE STEERING COLUMN. THE SIDE AIR BAGS DID DEPLOY. THE PASSENGER SIDE AIR BAGS DID NOT DEPLOY. THE DRIVER SUFFERED A CRUSHED PELVIS, TAIL BONE SHATTERED, AND THEIR URETHRA WAS SEVERED IN HALF. THE CONTACT STATED THE SIDE AIR BAG DID VERY LITTLE TO PROTECT THE DRIVER. THERE WAS NO MENTION OF A POLICE REPORT BEING FILED. THE FAILURE MILEAGE WAS UNKNOWN.
Jun 13, 2012
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT THE DRIVER WAS TRAVELING 35 MPH WHEN ANOTHER VEHICLE CRASHED INTO THE VEHICLE PRECEDING THE CONTACT. THE PRECEDING VEHICLE THEN SPUN INTO THE FRONT DRIVER'S SIDE DOOR OF THE CONTACT'S VEHICLE. THE AIR BAGS DID NOT DEPLOY AND THE STEERING WHEEL WAS DETACHED FROM THE STEERING COLUMN UPON IMPACT. THE DRIVER SUSTAINED SEVERE INJURIES AND SUFFERED A CRUSHED PELVIS, SHATTERED TAIL BONE AND A SEVERED URETHRA. THE CONTACT STATED THAT THE SIDE AIR BAGS DID VERY LITTLE TO PROTECT THE DRIVER. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Jun 12, 2012
VEHICLE SPEED CONTROL
2 complaints
FAILURE OF THE CLUTCH PETAL AS IT ATTACHES TO THE FIREWALL UNDER EMERGENCY DECELERATION. THE METAL ATTACHING THE PETAL TO THE FIRE WALL SHEARED ON THE VERTICAL ATTACHMENTS. CAUSED A NEAR ACCIDENT, DANGEROUS CONDITIONS OF A VEHICLE STRANDED IN A TRAVEL LANE, AND SUBSEQUENT TOWING ON THE VEHICLE. *TR
Sep 13, 2011
THE DUMMY PEDAL ON THE LEFT HAS A DESIGN FLAW WHICH ENABLES HIGH HEELS TO BE TRAPPED BETWEEN THE PEDAL AND THE FLOORBOARD. MY FOOT HAS BEEN TRAPPED FORCING ME TO STALL THE CAR AND PULL OVER FIVE LANES ON THE FREEWAY AND OFF THE ROAD TO REMOVE MY FOOT. THIS IS A HUGE SAFETY ISSUE THAT MAZDA DOESN'T SEEM TO WANT TO ACKNOWLEDGE! THIS WILL AFFECT WOMEN WHO WEAR HIGH HEELS AND DRIVE A STANDARD MAZDA RX-8.*AK
Mar 22, 2004
POWER TRAIN,VISIBILITY
2 complaints
TL*THE CONTACT OWNS A 2004 MAZDA RX8. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE CLUTCH PEDAL BROKE AND THE CONTACT COULD NOT SHIFT; HE HAD TO BE ASSISTED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP WHERE THE CLUTCH PEDAL BRACKET WAS REPLACED AT THE CONTACT'S EXPENSE. THE SUN VISOR ALSO BROKE TWICE; THE FIRST TIME, IT WAS REPLACED UNDER WARRANTY. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE SUN VISOR FAILURE AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 37,728. THE CURRENT MILEAGE WAS APPROXIMATELY 38,400.
Apr 28, 2010
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING APPROXIMATELY 10 MPH, HE ENGAGED THE CLUTCH AND THE PEDAL EXTENDED TO THE FLOOR. HE STATED THAT THE ENGINE STALLED AND HE HAD TO PUSH THE VEHICLE ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CLUTCH PEDAL ASSEMBLY WAS REPLACED. THE CONTACT HAD NOT CALLED THE MANUFACTURER WHEN THE COMPLAINT WAS FILED. THE CURRENT MILEAGE WAS APPROXIMATELY 37,800. THE FAILURE MILEAGE WAS APPROXIMATELY 37,600. UPDATED 06/08/10. *LJ THE CONSUMER ALSO STATED THE DRIVER SIDE SUN VISOR BROKE AND OBSTRUCTED HIS VISION. UPDATED 08/11/10
Apr 01, 2010
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM
2 complaints
2004 MAZDA RX-8, UNDER 45K MILES. DRIVEN ON A 78 DEGREE DAY FOR 2 HOUR TRIP. STOPPED TO REFUEL AND 30 MIN SHOPPING. GET INTO CAR ONTO HIGHWAY WHERE I NEED MY ENGINE'S SPEED TO ACCELERATE ONTO HIGHWAY. I FEELS LIKE HALF THE POWER IS GONE. IT REMINDS ME OF VAPOR LOCK, IT'S GASPING FOR FUEL OR SPARK. THIS HAS BEEN EXPERIENCED MANY TIMES BEFORE AND NEARLY DANGEROUS WHEN IN BUSY TRAFFIC, AS HAD TO PULL OVER TO BIRM. I KNOW DEALER REPLACED COIL PACKS ONCE OR TWICE SO FAR...ALONG WITH PLUGS. THIS IS THE MOST DANGEROUS CAR I EVER OWNED. THE MOST RE-CALLED CAR I'VE EVER KNOWN OF. RIGHT NOW IT'S RUNNING FINE, MATTER OF FACT HAS POWER TO SPARE AS COMPARED TO IT'S 'WHIMPING OUT SYNDROME ". THERE MUST BE A CORPORATE SOLUTION FROM MAZDA TO ME. I AM READY FOR A LAWYER. *TR
Apr 13, 2010
PROBLEMS WITH ROTARY ENGINE STARTING. USUALLY HAPPENS AT A TEMPERATURE BELOW 25 DEGREES FAHRENHEIT. POOR IGNITION SYSTEM FOR COLDER WEATHER. I HAVE HAD ISSUES WITH IT EACH WINTER I HAVE OWNED THE CAR(2004 TO PRESENT DAY). A TRIP TO THE DEALER HAS BEEN NECESSARY EACH TIME AND WHILE THE WARRANTY IS STILL VALID, THIS IS AN INCONVENIENCE BUT IT'S AFTER THE EXPIRATION IS WHEN I WORRY. A RECALL WAS NOTED AND REPAIRS WERE COMPLETED THE FALL OF 2006 BUT THE SAME THING HAPPENED YESTERDAY. THIS RECALL INCLUDED SPARK PLUG REPLACEMENT, BATTERY REPLACEMENT, STARTER MOTOR REPLACEMENT, AND REPROGRAMMING THE ONBOARD COMPUTER CHIP FOR IGNITION CHANGES. THE NEW STARTER MOTOR MADE SIGNIFICANT CHANGES TO STARTING TIME BUT DIDN'T CHANGE IT'S CONDITION IN COLDER WEATHER. THE MAZDA DEALER HAS BEEN LITTLE HELP IN RESOLVING THE SITUATION. THEIR REMEDY HAS BEEN JUST TREATING THE SYMPTOMS AND NOT FIGURING ON A SOLUTION TO THE IGNITION PROBLEM. THEY HAVE TOLD ME REPEATEDLY THAT "THESE CARS DO NOT LIKE COLD WEATHER" AND "THESE CARS DO NOT LIKE SHORT TRIPS". I WOULD FIGURE THAT IF A COMBUSTION MOTOR CANNOT START IN TEMPERATURES BELOW 25 DEGREES F, THEN THEY SHOULD OFFER A BETTER CAR/MOTOR REPLACEMENT. *NM
Jan 16, 2007
TIRES
2 complaints
BRAND NEW GOODYEAR TIRE WITH LESS THAN 100 MILES ON IT BLEW WHILE GOING DOWN HIGHWAY. *TR
Jan 13, 2010
I JUST HAD MY TIRES CHECKED AT 10,000 MILES DURING AN OIL CHANGE AT MY DEALERSHIP. NO PROBLEM WAS FOUND. I NOW HAVE 11,000 MILES ON MY CAR AND TIRES. MY TIRES ARE MICHELIN RADIAL XSE P215/50 R17. I WAS ON MY WAY TO WORK AND WITHOUT WARNING MY DRIVERS SIDE BACK TIRES BLEW OUT. IT SEPARATED FROM THE TIRE AND THE CORDS WERE SHOWING. I AM CONVINCED THAT THIS IS THE FAULT OF THE MICHELIN TIRE BECAUSE OF THE TREAD WEAR AND THE MILES ON IT. I DID NOT HIT ANYTHING IN THE ROAD NOR WAS THE TIRE PUNCTURED. WHEN THE TIRE BLEW I WAS ON WEST BOUND ON I-70 TO DOWNTOWN INDIANAPOLIS AND WITHOUT WARNING I SPUN AROUND SEVERAL TIMES IN THE MIDDLE OF I-70 AND GOT INTO AN ACCIDENT AND HAD TO BE TAKEN TO THE HOSPITAL VIA AMBULANCE FOR NECK AND BACK INJURIES. MY MAZDA 6 RECIEVED 6,000 DOLLARS IN DAMAGE THAT I KNOW OF SO FAR NOT TO MENTION THE PERSON THAT I CRASHED INTO. MY INSURANCE WILL NOT PAY FOR THE TIRE BECAUSE THAT WAS THE REASON FOR THE ACCIDENT. I THINK MICHELIN SHOULD PAY FOR 4 NEW TIRES OF A DIFFERENT BRAND, MY HOSPITAL VISIT, MY DEDUCTABLE AND MY RENTAL CARE EXPENSE AND MY LOST WAGES. ALSO MY TIRE PRESURE WAS CHECKED BY MY DEALER AGAIN THE WEEK OF JUNE 27,2005. I'M VERY LUCKY THAT I DIDN'T GET HURT WORSE OR SOMEONE GETTING HURT. I STILL DON'T KNOW THE EXTENT OF MY INJURIES BECAUSE I'M STILL HAVING A LOT OF PAIN SINCE THE ACCIDENT HAPPENED ON JULY 4, 2005. IS IT ANY WONDER THAT THE F1 DRIVERS DIDN'T WANT TO RACE AND FACE AN ACCIDENT OR WORSE YET DEATH?
Jul 11, 2005
ENGINE AND ENGINE COOLING,POWER TRAIN
2 complaints
I WAS DRIVING MY 2004 MAZDA RX-8 ON THE HIGHWAY AT APPROXIMATELY 60MPH AND WENT TO SHIFT FROM 5TH GEAR INTO 4TH GEAR WHEN I FELT A "POP" AT WHICH POINT MY CLUTCH FELL TO THE FLOOR AND I NO LONGER HAD ANY ABILITY TO ACCELERATE. FORTUNATELY TRAFFIC WAS LIGHT AND I WAS ABLE TO COAST OFF ONTO THE NEXT EXIT RAMP AND PULLED TO THE SIDE OF THE ROAD. I CALLED MAZDA ROADSIDE ASSISTANCE WHO TOWED THE CAR TO MAZDA BEDFORD. I WAS TOLD THAT THE CLUTCH WAS "BLOWN" AND NEEDED TO BE COMPLETELY REPLACED. THE MAZDA FORUM IS FULL OF SIMILAR EPISODES AND I WAS ENCOURAGED TO FILE A COMPLAINT. *TR
Apr 30, 2009
2004. *TR
Nov 15, 2007
ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE
2 complaints
THE 2004 RX8 HAS INTERNAL SEALS FAIL PREMATURELY. THIS CAUSES THE ENGINE TO "BLOW" BY A LOSS OF COMPRESSION IN ONE OF THE TWO ROTOR CHAMBERS. THE PROBLEM BEING THE CAR WITH STILL RUN WITH HALF POWER. I CONTINUED TO DRIVE TO FIND HELP OFF THE HIGHWAY. THE ROTOR THAT IS NOT WORKING IS DUMPING GAS INTO THE CATALYTIC CONVERTER. BY THE TIME I PARKED, I COULD SMELL BURNING FIBER AND PLASTIC AND THE EXHAUST SHOT OUT SEVERAL LARGE CHUNKS OF RED HOT CERAMIC MATERIAL. THE CATALYTIC CONVERTER WAS BRIGHT ORANGE AND THE ENTIRE UNDERSIDE OF MY CAR IS MELTED. LOOKING ON INTERNET UNDER "2004 RX 8 ENGINE FAILURE" I HAVE SEEN SEVERAL OTHER STORIES WITH SIMILAR RESULTS BUT WORSE. IS IT POSSIBLE THAT THE FUEL TANK COULD EXPLODE WITH SUCH HEAT SO NEAR IF YOU CONTINUED TO DRIVE. THIS HAPPENS ANYWHERE FROM 12,000 MILES TO 100,000 MILES AND BEYOND. MAZDA KNOWS OF THE ENGINE DEFECT AND HAS EXTENDED THE WARRANTY ON THE MOTOR AS OF MAY 2008. MY CAR IS AT HANCOCK MAZDA IN DALLAS. THEY SAID DAMAGE AMOUNTED TO $9,500.00 FROM HEAT. *TR
Jun 25, 2008
I AM CURRENTLY IN THE PROCESS OF TRYING TO RESOLVE AN ON-GOING ENGINE STARTUP /VEHICLE STALL PROBLEMS WITH MY 2004 RX-8. THIS CAR HAS ONLY 15,000+ MILES AND HAS BEEN DRIVEN FOR SHORT, DAILY RUNS TO WORK AND RECREATIONAL DRIVES. THE ROTARY ENGINE HAS A REQUIRED ENGINE WARM-UP PROCEDURE BEFORE SHUTTING IT OFF. A DEFLOODING PROCEDURE IS ALSO REQUIRED IF ENGINE FAILS TO START IN THE MANUFACTURERS MANUAL. MAZDA HAS ALREADY HAD A RECALL ON THE FUEL SYSTEM COMPUTER WITH UPDATE SOFTWARE. THE CAR HAD TO BE TOWED FROM MY GARAGE TO THE DEALER TO HAVE THIS DONE BECAUSE OF A NONSTART SITUATION. THE PROBLEM SEEMED TO BE CORRECTED BY THEM ALTHOUGH A STALLING WHILE A RED LIGHTS OR NO STARTUP AFTER REFUELING AT GAS STATIONS PROBLEMS RECURRED. THE CAR AGAIN HAD TO BE TOWED FROM MY GARAGE TO THE DEALER TO BE CHECKED FOR THE NONSTART-UP ISSUE. A REPLACEMENT OF BATTERY, ALTENATOR AND SPARK PLUGS WERE DONE. THE PROBLEM SEEMINGLY CLEARED FOR HALF THE DAY UNTIL A TRIP FOR FUEL CAUSED ANOTHER NONSTART INCIDENCE(STUCK AT THE PUMP) IN A $34,000 CAR! IT FINALLY RESTARTED AFTER 10 MIN AND WAS DRIVEN BACK TO THE DEALER THE NEXT AFTERNOON WHERE THE PROBLEM THEN RECURRED IN THEIR GARAGE. THE DEALER HAS NOW TOLD ME I MUST WAIT LONGER AFTER THE MANUFACTURER'S REQUIRED ENGINE WARM-UP TIME TO SHUT OFF THE CAR AND NOT TO RESTART ENGINE IN SHORT PERIODS OF TIME. IS THIS INSANE OR WHAT! THIS EXPLANATION DIDN'T FLY WITH ME, SO THE CAR HAS BEEN NOW RECHECKED AND OK'D TO DRIVE AGAIN BY THEIR TECHNICIANS WITH NO CHANGES MADE. THEY WISHED ME "GOOD LUCK!" *NM
Feb 02, 2006
AIR BAGS,EQUIPMENT
2 complaints
WE WERE BROADSIDED BY A VEHICLE THAT RAN A RED LIGHT AT FULL SPEED. THE IMPACT WAS ON THE PASSENGER SIDE. THE CAR FLIPPED OVER AND SKIDDED ONTHE PASSENGER SIDE THEN FLIPPED BACK ONTO THE DRIVERS SIDE AND SKIDDED BEFORE ROLLING OVER AT LEAST ONCE. NOT ONE AIR BAG DEPLOYED. THANK GOD FOR THE SEAT BELTS. THEY SAVED OUR LIVES. INJURIES WERE CONCUSSIONS, SPRAINED NECK, INJURIES TO LOWER NECK, BACK AND SHOULDER OF PASSENGER. WE LANDED UPSIDE DOWN, RELEASED OUR SEAT BELTS AND CRAWLED TO SAFETY WITH THE HELP OF POLICE AND FIRE. OUR SPEED WAS ABOUT 25-30 MILES /HOUR. OUR CAR WAS TOTALLED. THE OTHER DRIVER WAS CITED IN THE ACCIDENT.
May 25, 2007
CONSUMER WAS DRIVING AND WHILE ADJUSTING THE RADIO VEHICLE WENT DOWN A 6 FOOT EMBANKMENT AND ROLLED OVER. UPON IMPACT, AIR BAGS FAILED TO DEPLOY. VEHICLE WAS TOTALLED. *AK *TC
Dec 08, 2004
SERVICE BRAKES, HYDRAULIC
2 complaints
DT*: THE CONTACT STATED WHILE PERFORMING GENERAL MAINTENANCE, THE BRAKES WERE OBSERVED TO BE CORRODED. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE BRAKES WERE CORRODED DUE TO NORMAL WEAR AND TEAR AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALERTED. THE CONSUMER STATED THE ROTORS WERE CORRODED. UPDATED 11/30/06. *JB
Nov 09, 2006
MY BRAND NEW 2004 MAZDA TRIBUTE'S BRAKE FAILED AT 300 MILES, AFTER ONLY 4 WEEKS OF OWNERSHIP. BOTH ABS AND BRAKE LIGHTS CAME ON. *LA
Oct 07, 2003
SEAT BELTS
2 complaints
2004 MAZDA 3 PASSENGER SEAT BELT MALFUCTION. MY MAZDA 3 SEAT BELT LOCKING MECHANISM FAIL TO RELEASE.
Aug 24, 2005
WHILE DRIVING 55 MPH DRIVER LOST CONTROL OF VEHICLE, AND IT HIT A POLE. AIR BAGS DEPLOYED, BUT DRIVER'S SEAT BELT BROKE. *AK
Mar 15, 2004
STRUCTURE,SERVICE BRAKES,ENGINE
1 complaint
SEAT BUILTS NEED TIGHTING
Oct 21, 2019
STRUCTURE,ENGINE
1 complaint
I SENT MY MAZDA IN TO THE DEALERSHIP TO FIX RECALLS AND MAKE A KEY. IN EXCELLENT SHAPE. ONE AREA WITH SLIGHT BODY DAMAGE. ON 3/16/2018 WAS RETURNED A CAR THAT DOESN'T RUN. WITH. CRACKED DASHBOARD, TORN SEATS, MULTIPLE DENTS, CHARGED 345 DOLLARS ON 6/10 2019. I WAS SENT A TOW BILL AS NOTIFICATION TO PICK IT UP.
Jul 19, 2019
ELECTRONIC STABILITY CONTROL (ESC),ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
MULTIPLE TROUBLE CODES ALL AT ONCE AFTER NOT HAVING ANY TROUBLE CODES AFTER A LONG PERIOD. AS OF NOW 56,000 ORIGINAL MILES. TRACTION CONTROL IMPROPERLY FUNCTIONING CAUSING VEHICLE,S MAXIMUM SPEED TO 3 MPH. MULTIPLE MISFIRE,S WITH NEW SPARK PLUG, NEW SPARK PLUG COIL PACKS AND NEW SPARK PLUG WIRES. GASOLINE LEAK NOT YET NARROWED DOWN TO SPECIFIC LOCATION. NO ENGINE POWER AFTER SHIFTING TO 2ND GEAR. CHECK ENGINE LIGHT IS CONSTANTLY ON HOWEVER WILL GO OUT FOR NO MORE THAN 2 DAYS. VERY STRONG GASOLINE ODOR INSIDE OF THE VEHICLE AFTER STARTUP. LOSS OF ENGINE COMPRESSION. GOODNESS KNOWS WHAT IS NEXT!!!
Jul 19, 2019
POWER TRAIN,UNKNOWN OR OTHER
1 complaint
AS I PRESSED MY CARS CLUTCH TO CHANGE GEARS (6 SPEED MANUAL ) WHILE DRIVING ON MY REGULAR SUNDAY DRIVE IN A CITY STREET, I HEARD AND FELT A VERY LOUD EXPLOSION AND NOISES OF METAL PIECES EJECTING FROM UNDER MY CAR. I WAS IN THE 60KM/H ZONE SO WAS NOT SPEEDING OR GOING FAST SUCH AS ON A FREEWAY ETC. I WAS ABLE TO PULL OVER SAFELY WHILE ROLLING AS THE ENGINE HAD BEEN DISABLED IN THE EXPLOSION. I COULD FEEL MY LEFT FOOT WAS IN EXTREME PAIN. MY CAR WOULD NOT START. I FEARED THAT THE ENGINE HAD BLOWN UP. MY CAR IS VERY WELL MAINTAINED AND SERVICED REGULARLY WITH NO MODIFICATIONS. WHAT I DISCOVERED WAS THAT THE TRANSMISSION HAD DETONATED, THE GEARBOX BELL HOUSING WAS TORN APART (GOT PICTURES TO PROVE IT) AND I FOUND PARTS OF THE CLUTCH IN MANY TINY PIECES ALL OVER THE ROADS. THE CLUTCH WAS REPLACED BY MAZDA 30,000KMS AGO AND AT A MAZDA DEALERSHIP USING OEM CLUTCH KIT. THE FORCE OF THE GEARBOX EXPLOSION WAS SO GREAT THAT THE CLUTCH PEDAL IMPACTED MY LEFT FOOT AND SHATTERED THE BONES OF THE LEFT FOOT IN PIECES (YES I WAS WEARING THICK SOLED SNEAKERS) AND CAUSED SEVERE TRAUMA TO MY FOOT IN GENERAL. AT THE HOSPITAL, THE SURGEONS WORDS WERE " IT LOOKS REALLY BAD". I WAS OPERATED ON AND TITANIUM PLATES AND 4 SCREWS WERE INSERTED TO TRY TO HOLD MY SHATTERED BONES IN PLACE. 8 MONTHS AND A LOT OF HOSPITAL VISITS LATER, I AM STILL RECOVERING FROM THE DAY. I HAD FURTHER SURGERY FEW WEEKS AGO TO PERFORM A BONE GRAFT BECAUSE ONE BREAK WASN'T HEALING. I HAVE APPROACHED MAZDA REGIONAL HEAD OFFICE. INITIALLY MAZDA CONTACTED ME VIA PHONE ASKING FOR DETAILS OF THE CRASH. I SENT THEM PHOTOS VIA EMAIL. I HAVE NOT HEARD FROM THEM SINCE. I THEN ALSO CONTACTED THE DEALERSHIP. THEY PROMISED TO RING BACK AND THEY TOO, HAVE STOPPED. IT'S BEEN DIFFICULT TO FIND A LAWYER WHO CAN SEE THE OBVIOUS PROBLEM, THAT A VEHICLE SHOULD NOT BLOW UP, OR CATCH FIRE ETC NO MATTER WHAT AGE IT IS. HELP!
Feb 07, 2019
STEERING,SUSPENSION,ELECTRICAL SYSTEM
1 complaint
ELECTRIC-ASSIST POWER STEERING, RANDOMLY IN THE PARKING LOT THE WHEEL WILL TURN ALL BY ITSELF, ONE WAY TURNS EASIER THAN THE OTHER, SOMETIMES YOU HAVE NO POWER STEERING AND OTHER TIMES YOUR STEERING WHEEL TURNS LIKE BUTTER, I LIVE IN THE MOUNTAINS WITH A VERY WINDY AND DANGEROUS ROADS, I'VE TAKEN IT TO SEVERAL MECHANICS FINALLY ONE MECHANIC JUST UNPLUG THE WIRING HARNESS SO THERE IS NO POWER STEERING. IT IS VERY SCARY TO DRIVE ESPECIALLY WITH A NEWBORN BABY. THERE ARE A LOT OF CARS ON THE ROAD WITH THIS ISSUE I KNOW 10 DIFFERENT PEOPLE THAT HAVE SOME SORT OF POWER STEERING ISSUE. THIS IS VERY DANGEROUS AND I'M SURPRISED THERE IS NOT A RECALL YET ON IT. I'VE HAD TWO FRIENDS THAT ARE CLOSE TO ME THAT HAVE THIS ISSUE AS WELL, ONE FRIEND WRECKED HIS CAR THE OTHER FRIEND SOLD IT I BELIEVE TO PICK-N-PULL SO IT WOULD NOT HURT ANYONE, PLEASE HELP AND MAYBE HELP SAVE A FEW LIVES, THANK YOU FOR YOUR TIME AND I LOOK FORWARD TO SPEAKING WITH YOU
Dec 18, 2018
ELECTRICAL SYSTEM,AIR BAGS,SEATS
1 complaint
I BOUGHT A CAR THAT HAD A RECALL OF THE AIR BAG THE PASSENGER SEAT AIR BAG HAD BEEN DEPLOYED WAS TOLD BY DEALER IT WAS UNDER RECALL.AFTER CHECKING WITH THE DEALER THE SIDE SEAT AIR BAG WAS NOT PART OF THE RECALL WAS NOT REPLACED OR EVEN LOOKED AT .SO WE TOOK THE SEAT OUT TO SEE ANT OBVIOUS ISSUES AND WE FOUND ALL THE WIRES THAT PLUG INTO SEAT ALL WAY TO UNDER CARPET AGAINST FRAME ALL THE WIRES WERE MELTED.WITCH IS AN OBVIOUS MANAFATURING PROBLEM.WE HAVE READ MUPLTILE FORUMS WHERE TONS OF PEOPLE HAVE HAD SAME PROBLEM BUT YET NO RECALL WE COULD FIND ON THIS ISSUE.MY MOTHER IS ON OXYGEN AND IF MY CAR CATCHES FIRE TO DO THIS AND NO ONE LOOKING INTO THIS IT CAN BE FAR WORSE.THIER IS ANOTHER RECALL ON FRONT END SUSPSION THAT THEY ARE NOT WILLING TO REPLACE AT THIS TIME.THEY TELL ME THEY ARE WAITING TO SEE IF THEY COME UP WITH A BETTER SOLUTION TO FIX IT.IM GOING TO MAZDA DEALER TOMORROW MORNING TO EXPLAIN TO THEM WHAT I'M EXPLAIN TO YOU AND SINCE THIS IS A MAJOR SAFETY ISSUE IF THEY REFUSE TO DO ANYTHING I'M TURNING THIS OVER TO LAWYER.I FEEL WHEN I MENTIONED IT TO THEM THE FIRST TIME AND THEY DID NOTHING TO FIND OUT WHAT THE ISSUE WAS THEY HAVE NO INTENTION OF FIGURING THIS OUT BUT I WILL TRY AGAIN.THE AIR BAG WAS DEPLOYED WHEN I BOUGHT IT AND THE PERSON SAID THEY WERE DRIVING DOWN THE ROAD.THATS HOW I KNEW ABOUT AIR BAG RECALL .WHEN I TOOK CAR TO BE FIXED THE TECH TOLD ME IT DIDN'T COVER MY SEAT. AND NEVER BOTHERED CHECKING IT.
Jun 24, 2018
ELECTRICAL SYSTEM,AIR BAGS,FUEL/PROPULSION SYSTEM
1 complaint
"TAKATA RECALL"-CAR STARTS WHEN COLD,THEN IT DIES IN THE TRAFFIC,GOT ENGERYS PUSHING CAR OUT OF TRAFFIC,LIKE CAR BUT IT HAS LOTS OF RECALLS AND NEEDS TO BE FIXED RIGHT AWAY.WON'T DRIVE MADZA 2004 AFTER THIS HAPPENED. *TT THE CONSUMER STATED WHILE ATTEMPTING TO PUSH THE CAR OFF OF THE HIGHWAY, AFTER IT DIED, HE LOST HIS GRIP AND WAS DRAGGED BEHIND THE VEHICLE. *JS
Mar 26, 2018
SUSPENSION,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER (MODERN MAZDA DODGE RAM, 68 WATERBURY RD, THOMASTON, CT, 06787, 860-283-4304) TO BE SERVICED PER NHTSA CAMPAIGN NUMBERS: 17V355000 (SUSPENSION), 16V793000 (FUEL SYSTEM), AND 17V354000 (FUEL SYSTEM). THE CONTACT WAS INFORMED THAT THE RECALL REPAIRS WOULD TAKE ONE DAY TO COMPLETE; HOWEVER, IT TOOK FOUR DAYS. THE CONTACT RETRIEVED THE VEHICLE AND, WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND WAS INFORMED THAT THEY WOULD REPAIR THE FAILURE. ONE WEEK LATER, THE DEALER STATED THAT THE CONTACT COULD RETRIEVE THE VEHICLE, BUT THEN DIAGNOSED THAT THE COMPRESSOR FAILED AND IT WOULD ONLY LAST APPROXIMATELY TWO MORE YEARS. THE DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED. WHEN THE CONTACT RETRIEVED THE VEHICLE AGAIN, THE VEHICLE FAILED TO START EVEN WITH A JUMP. THE VEHICLE WAS NOT REPAIRED AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES, PERFORMED AN INVESTIGATION, AND CONFIRMED THAT THE DEALER'S INFORMATION WAS CORRECT. NO ADDITIONAL ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS APPROXIMATELY 144,000. *JS
Oct 16, 2017
STEERING,POWER TRAIN,AIR BAGS
1 complaint
"TAKATA RECALL" MY POWER STERING GOES OUT ALL THE TIME DOESNT MATTER IF IM SITTING STILL OR IM GOING DOWN THE HIGH WAY. IT DOES EVENTUALLY COME BACK ON BUT DOES GO BACK OFF. IT ALSO WILL CAUSE MY STERING WHEEL TO JURK LEFT AND RIGHT BY ITSELF CAUSE ME TO SWERVE IN AN OUT OF LANES. IT GOT TO THE POINT NOW WHERE I HAVE THE POWER STERING UNPLUGGED SO THAT IT DOESNT JERK MY WHEEL WHILE DRIVING. I JUST NEED TO KNOW IF THERE IS A RECALL THAT WILL PAY TO FIX THIS CAUSE ITS GETTING DANGEROUS. PLEASE CONTACT BACK WITH ANY INFO
May 20, 2017
AIR BAGS,FUEL/PROPULSION SYSTEM
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V354000 (AIR BAGS) AND 16V7963000 (FUEL SYSTEM). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT AND VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Jan 31, 2017
POWER TRAIN,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER
1 complaint
THE CLUTCH PEDAL (ALREADY A KNOWN PROBLEM BY MAZDA, BUT NO RECALL HAS YET BEEN ANNOUNCED) CRACKED WHILE I WAS DRIVING LAST YEAR. I WAS ON HWY 13 IN MINNESOTA AND BARELY GOT CONTROL OF MY SPEED (WAS BARELY ABLE TO MAINTAIN USE OF THE CLUTCH) IT SAT UNTIL I COULD GET IT REPAIRED, THE SAME PEDAL IS NOW CRAKING IN ANOTHER SPOT, WORKING ON GETTING IT REPAIRED BEFORE IT BREAKS AGAIN, THIS TIME WILL REINFORCE IT.
Sep 20, 2016
STEERING,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES
1 complaint
TAKATA RECALL AFTER COMPLETING THE "INTERIM REPAIR" THE CARS POWER STEERING WILL INTERMITTENTLY GO OUT WITHOUT WARNING, OR PULL TO THE RIGHT ELECTRONICALLY AND FORCEFULLY WITH NO NOTICE, THIS IS A SERIOUSLY DANGEROUS PROBLEM AS, IN ADDITION TO THE CAR PULLING HARD RIGHT WITHOUT NOTICE, SOMETIMES WHILE CORRECTING FOR THE PULL THE POWER STEERING COMES ON WITHOUT NOTICE FORCING THE STEERING CORRECTION TO SWERVE LEFT. ALSO THE ABS AND TCL LIGHTS TURN ON AN OFF INTERMITTENTLY SINCE THE 'INTERIM REPAIR' . THE POWER-STEERING WILL GO IN AND OUT WHILE STOPPED, IN MOTION IN EITHER CITY OR HIGHWAY, AND WHILE GOING IN A STRAIGHT LINE OR WHILE TURNING. ' THIS IS GOING TO KILL SOMEONE
Mar 14, 2016
STEERING,AIR BAGS,STRUCTURE
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING AT 70 MPH, THE STEERING WHEEL INDEPENDENTLY TURNED IN BOTH DIRECTIONS. AS A RESULT, THE CONTACT CRASHED INTO A CURB AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. IN ADDITION, THE CONTACT NOTICED THAT THE REAR PASSENGER WHEEL WELL WAS CURVED AND FRACTURED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000. THE VIN WAS UNAVAILABLE.
May 27, 2015
ELECTRICAL SYSTEM,AIR BAGS
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT THE ENTIRE CENTER CONSOLE OVERHEATED TO THE POINT THAT IT WAS UNABLE TO BE TOUCHED. THE CONTACT MENTIONED THAT THE PASSENGER SIDE AIR BAG COVER WAS BULGING AND COULD CRACK AT ANY MOMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,010.
May 27, 2015
SUSPENSION,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT NOTICED STRONG EXHAUST FUMES IN THE VEHICLE. IN ADDITION, WHILE MAKING A LEFT TURN AT A LOW SPEED, THE CONTACT HEARD A LOUD NOISE UNDERNEATH THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO REMAIN IN POSITION. THE CONTACT HAD TO CONTINUOUSLY MANEUVER THE STEERING WHEEL IN ORDER TO MAKE THE VEHICLE REMAIN IN POSITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBERS: 05V325000 (SUSPENSION) AND 05V317000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 82,000.
Apr 30, 2015
POWER TRAIN,FUEL/PROPULSION SYSTEM
1 complaint
THE CLUTCH PEDAL ASSEMBLY BROKE AS I WAS DRIVING IN THE FREEWAY. *TR
Mar 25, 2015
ELECTRICAL SYSTEM,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE ATTEMPTING TO START THE VEHICLE DURING COLD WEATHER, THE MOTOR FLOODED WHICH CAUSED THE STARTER TO FAIL. THE FAILURE RECURRED MULTIPLE TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER. THE STARTER WAS REPLACED, BUT THE FAILURE RECURRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.
Feb 02, 2015
STEERING,WHEELS,SERVICE BRAKES
1 complaint
I TYPICALLY DRIVE MY RX8 LIKE IT SHOULD, ONE DAY I COME HOME PARK MY CAR PER USUAL. NEXT MORNING I GO TO TURN ON MY CAR, THE DSC LIGHT STAYED ON, THOUGHT NOTHING OF IT, THEN ON MY WAY TO WORK, I WAS DRIVING CAUSALLY, THEN WHILE IN THE MIDDLE OF A TURN, MY STEERING BECAME VERY HEAVY AND ALMOST IMPOSSIBLE TO TURN, MY POWER STEERING HAD WENT OUT. AFTER DEALING WITH ABOUT 2 FULL DAYS AT THE DEALERSHIP, SPENDING THOUSANDS, STILL NO POWER STEERING, AND I'M NOT CREDITED ANY PORTION OF WHAT I PAID TO GET FIXED AND ITS STILL NOT FIXED. THIS IS A KNOWN ISSUE AND A RECALL MUST BE DONE IMMEDIATELY BEFORE PEOPLE SERIOUSLY GET INJURED, INJURE OTHERS, OR EVEN DIE. THIS IS ALL POSSIBLE, IF I DIDN'T HAVE BOTH HANDS ON THE WHEEL, AN ACCIDENT MOST DEFINITELY WOULD HAVE TAKEN PLACE. *TR
Nov 03, 2014
AIR BAGS,ENGINE
1 complaint
HORRIBLE IN 2004 YEARS OF THIS VEHICLE AIR BAG LIGHT POPPED UP SUDDENLY FOR NO APPERANT REASON. *TR
Aug 01, 2014
POWER TRAIN,ENGINE
1 complaint
I PURCHASED THE CAR IN 5/14/2013 AFTER A WEEK OR SO IT STARTED TO LOSE POWER AND MISFIRING , POPPING NOISE, TRANSMISSION WARMS UP. THE GEAR THAT I HOLD AND SHIFT JUST WARMS UP ALL THE TIME IT FEELS LIKE IT MIGHT FIRE UP. THEN I TOOK THE CAR TO A MECHANIC THEY COULDN'T DO ANYTHING. I TOOK IT TO MAZDA MECHANIC THEY CHARGED AROUND 900$. THEN IT DIDN'T FIX ANYTHING I WENT ANOTHER ONE AND THEY TOLD ME LOSS COMPRESSION IT WAS 115 THAT TIME. I KEPT DRIVING IT AND THEY SAID I NEED TO REBUILD THE TRANSMISSION TOO.. I PAID THIS CAR 6500. AND NOW IT S ALL BAD. AND APPARENTLY I NEED TO BUY NEW ENGINE AND TRANSMISSION. I BELIEVE IT WILL COST ME ABOUT 6000$ .NOW ITS ON 129,000MILES. *TR
May 26, 2014
STEERING,POWER TRAIN,ENGINE
1 complaint
POWER STEERING STOPPED WORKING WHEN I WAS TURNING ON TO THE HIGH WAY. MAKING IT STIFF AND HARD TO TURN. CLUTCH PEDDLE COLLAPSED MAKING IT HAD TO SHIFT GEARS AND THE CLUTCH RATIO IS OFF, *TR
Mar 03, 2014
POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE
1 complaint
WAS DRIVING NORMAL CONDITIONS DOWN A 35 MPH ROAD WHEN I WENT TO UPSHIFT GEARS AND DEPRESSED THE CLUTCH PEDAL, I HEARD A LOUD POP AND THE PEDAL WENT TO THE FLOOR. THE CLUTCH PEDAL BRACKET CRACKED AND POPPED OFF DUE TO POOR QUALITY AND BAD ENGINEERING, IN MY OPINION. THIS COULD HAVE CAUSED THE TRANSMISSION TO LOCK UP AND CAUSE AN ACCIDENT THROUGH LOSS OF CONTROL. I WAS NOT ABUSING THE VEHICLE/ HAVE NOT ABUSED THE VEHICLE.. THIS ITEM SHOULD NOT BREAK IN THE MANNER IT DID. *JB
Sep 03, 2013
ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM
1 complaint
I PURCHASED MY 2004 AUTOMATIC RX8 IN SEPTEMBER OF 2011. IT BEGAN GIVING ME TROUBLE WITH THE TYPE OF GAS IT TOOK. I FINALLY FIGURED OUT THAT BP PREMIUM SEEMED TO KEEP IT FROM "COUGHING". I THOUGHT THAT I HAD FIXED THE ISSUES AND IT DROVE FINE FOR A GOOD WHILE. I CHANGED THE OIL RELIGIOUSLY AT ABOUT 3000 MILES OR LESS. IT WOULD DISPLAY THE OIL LIGHT AFTER ONLY ABOUT 1500-2000MILES. I HAD A DEALERSHIP LOOK AT IT AND THEY SAID THE OIL LEVEL WAS FINE AND THEY DIDN'T UNDERSTAND WHY IT HAD THE LIGHT ON. THE OIL LIGHT NOW COMES ON AT JUST 300MILES INTO THE LAST OIL CHANGE. IN FEB OF THIS YEAR IS WHEN THE CAR STARTED DETERIORATING AT A RAPID PACE, AND I WAS COMPLETELY DUMBFOUNDED TILL I BEGAN DOING SOME RESEARCH AND SAW THAT MANY OTHERS HAVE HAD THE EXACT SAME ISSUES I HAVE HAD. FOR ONE- THE AC NEVER WORKS CORRECTLY. I HAVE TO PLAY WITH THE KNOB FOR A BIT TO MAKE IT COOL, AND STILL EVEN THEN IT DOES NOT WORK. I AM NOT ABLE TO DRIVE IT TO AND FROM THE STORE NOW BECAUSE I AM WORRIED IT WILL NOT START BACK UP. I ALWAYS MAKE SURE THE ENGINE IS WARMED UP AND SOMETIMES JUST LEAVE IT RUNNING INSTEAD OF TAKING THE CHANCE OF TURNING IT OFF. THE ENGINE LIGHT ALSO COMES ON AND RANDOM TIMES, AND I WAS TOLD THAT IT WAS BECAUSE THE GAS CAP WAS NOT ON TIGHT ENOUGH. THAT IS A LIE, I ALWAYS MAKE SURE TO TIGHTEN IT, AND WHY WOULD THE ENGINE LIGHT COME ON AFTER THE OIL LIGHT EVERYTIME IF IT WAS HUMAN ERROR. THE CAR WHINES WHEN AT A STOPLIGHT OR SITTING FOR A BRIEF PERIOD OF TIME. IT SOUNDS AS IF IT IS COMING FROM THE FRONT LEFT SIDE OF THE ENGINE IF YOU ARE SITTING IN IT. NO ONE KNOWS WHAT THAT NOISE IS EITHER. THIS FAULTY CAR SHOULD COME WITH A WARNING ON THE FRONT WINDSHIELD. I AM SCARED TO DRIVE IT, I AM SCARED TO PUT MY FAMILY IN IT, AND I AM DISGUSTED WITH THE WAY MAZDA DECIDED TO TREAT ME WHEN I CALLED THEM TO INQUIRE ABOUT CERTAIN RECALLS. *TR
Apr 26, 2013
FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL,ENGINE
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX8. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH AND SMELLED GASOLINE FUEL COMING FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE OIL PAN, THROTTLE BODY ASSEMBLY, FUEL PUMP ASSEMBLY, CATALYTIC CONVERTER AND SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS FOR THE SAME FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000 AND THE CURRENT MILEAGE WAS 146,000. THE VIN WAS UNAVAILABLE.
Dec 03, 2012
ENGINE AND ENGINE COOLING,EXTERIOR LIGHTING
1 complaint
2004 MAZDA RX8. CONSUMER WRITES IN REGARDS TO SEVERAL DEFECTS IN THE VEHICLE. *SMD THE CONSUMER STATED ABOUT A YEAR AFTER HAVING THE VEHICLE, THE REAR TAIL LIGHTS STARTED FILLING UP WITH WATER. ALSO, THE VEHICLE STOPPED RUNNING WITH NO WARNING. THE CONSUMER WAS INFORMED THE VEHICLE NEEDED A CATALYTIC CONVERTER. WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALER, HE WAS INFORMED THE VEHICLE NEEDED TWO OXYGEN SENSORS. AFTER THE OXYGEN SENSORS WERE REPLACED, THE STALLING CONTINUED. THE CONSUMER HAD THE VEHICLE TOWED THE DEALER, WHERE HE WAS INFORMED THE VEHICLE NEEDED A NEW ENGINE.
Nov 28, 2012
ELECTRICAL SYSTEM,EXTERIOR LIGHTING
1 complaint
PART NUMBERS FE03-51-21YD (REAR) AND FE03-51-22YC (FRONT). I HAVE COMPLAINED TO THE DEALER WHEN THE CAR WAS UNDER WARRANTY THAT THE HEADLIGHTS WERE NOT ILLUMINATING CORRECTLY MY DRIVING AREA AT NIGHT. I TOOK THE CAR IN TO THE DEALER TODAY AND I WAS TOLD THAT THESE PARTS ARE NOT COVERED. THERE HAS BEEN A TECHNICAL SERVICE BULLETIN (TSB) ON THIS CAR CONCERNING THIS ISSUE FOR A LONG TIME. THERE SHOULD BE A RECALL ON THESE SENSORS BECAUSE THIS IS A SEVERE SAFETY ISSUE. THEY WERE FAULTY TO BEGIN WITH. IN ADDITION THEY HAVE KNOWN ABOUT IT FOR A LONG TIME. *TR
Jun 29, 2012
ELECTRICAL SYSTEM,VISIBILITY
1 complaint
MY VISOR LITERALLY FELL OFF THE CAR WHICH SHUT DOWN THE RADIO. AND NOW THE CAR IS STARTING FUNNY. I NEED HELP SOON. *TR
Apr 11, 2011
STEERING,ENGINE AND ENGINE COOLING,POWER TRAIN
1 complaint
MY 2004 MAZDA RX-8 ONLY HAS 53,000 MILES ON IT AND IS AGAIN IN THE SHOP DUE TO MANUFACTURER-RELATED ENGINE FAILURE. THIS IS THE SECOND TIME IN LESS THAN 1 YEAR I'VE BEEN LEFT STRANDED IN HAZARDOUS CIRCUMSTANCES BECAUSE OF ENGINE FAILURE. I'VE ALSO EXPERIENCED POWER STEERING FAILURE AND LOSS OF ENGINE COMPRESSION/ENGINE MISFIRES WHILE DRIVING ON MULTIPLE OCCASIONS. AS A RESULT, I'M BECOMING INCREASINGLY CONCERNED FOR MY SAFETY, AS WELL AS FOR THE SAFETY OF OTHERS WHO OWN/OPERATE THIS TYPE OF MAZDA VEHICLE. PLEASE CONSIDER ORGANIZING A CLASS-ACTION LAWSUIT AGAINST MAZDA TO HOLD THEM ACCOUNTABLE FOR PUTTING MANY VALUABLE LIVES AT RISK. *TR
Jun 30, 2010
POWER TRAIN,EXTERIOR LIGHTING,VEHICLE SPEED CONTROL
1 complaint
TL* THE CONTACT OWNS A 2004 MAZDA RX8. THE CONTACT STATED WHENEVER IT WOULD RAIN, WATER WOULD LEAK INTO THE PASSENGERS SIDE TAIL LIGHT. THE DEALER ADVISED THERE WERE NO RECALLS FOR THE FAILURE AND REPAIRS WOULD BE AT THE OWNERS EXPENSE. IN ADDITION, THE CONTACT STATED WHEN ACCELERATING FROM A COMPLETE STOP THE ACCELERATOR PEDAL WOULD BECOME EXTREMELY RESISTANT TO APPLIED PRESSURE OR WOULD SPORADICALLY LUNGE FORWARD WITHOUT WARNING. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND COULD NOT OFFER A REMEDY. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 34,500 THE CONSUMER BELIEVED THE VEHICLE ALSO HAD TRANSMISSION PROBLEMS, DUE TO IT NOT SHIFTING PROPERLY IN 1ST AND GEAR. UPDATED 07/06/10.*JB UPDATED 07/08/10 *BF UPDATED 07/09/10.*JB
Apr 29, 2010
POWER TRAIN,STRUCTURE
1 complaint
FOR THE PAST 3 YEARS, THE CLUTCH PEDAL ON MY CAR HAS SQUEAKED AND GROANED WHEN DEPRESSED. THIS WOULD NOT BE CONSISTENT, AND VERY HARD TO DIAGNOSE. TODAY, WHILE DRIVING A SHORT DISTANCE TOWARDS WORK (I LIVE AND WORK ON A MILITARY BASE), A METALLIC "POP" CAME FROM MY CLUTCH PEDAL WHILE BEING DEPRESSED AND NO LONGER DISENGAGED THE CLUTCH. THIS ALMOST CAUSED AN ACCIDENT AS IT WAS "RUSH HOUR." I QUICKLY NOTICED WHILE DRIVING THAT MY CLUTCH PEDAL WAS ALMOST TOUCHING MY BRAKE AS I ATTEMPTED TO SLOW DOWN! ALSO, IF I HAD STOPPED MOVING AT ANY POINT, I AND MY CAR WOULD HAVE BEEN STRANDED AS I WOULD NOT HAVE BEEN ABLE TO GET MY CAR BACK INTO GEAR. UPON INSPECTION AT HOME, IT APPEARS A WELD ON THE RIGHT SIDE THAT HOLDS THE CLUTCH PEDAL MOUNT TO THE FRAME OF THE CAR HAS COME COMPLETELY LOOSE MAKING THE PEDAL LEAN LEFT. THERE ALSO APPEARS TO POSSIBLY BE ANOTHER ISSUE WITH THE CLUTCH PEDAL SPRING AS IT NO LONGER RETURNS THE PEDAL TO THE FULLY DEPRESSED POSITION, AND INSTEAD DEFAULTS TO 3 INCHES DEPRESSED OR FULL UPRIGHT DEPRESSED. THIS FAILURE HAS NOT BEEN CORRECTED. *TR
Apr 29, 2010
STEERING,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,AIR BAGS,EQUIPMENT
1 complaint
I DON'T EVEN KNOW WHERE TO BEGIN WITH THE PROBLEM I HAVE HAD WITH MY 2004 MAZDA RX-8. I HAVE OWNED IT SINCE SEPTEMBER 2003 AND IT HAS HAD COUNTLESS ISSUES, PARTS REPLACED AND FAILURES. THE INCIDENT I EXPERIENCED LAST NIGHT PUT ME OVER THE EDGE AND ALMOST COST ME MY LIFE. MY RX-8, WHICH WAS JUST AT THE DEALER 2 WEEKS AGO, HAD AN ENGINE MALFUNCTION WHILE I WAS ON A MAJOR HIGHWAY IN MASSACHUSETTS. THE SPEED OF THE VEHICLE WENT FROM APPROX 50MPH TO 10MPH IN A MATTER OF A FEW SECONDS. LUCKILY I WAS ABLE TO MAKE MY WAY TO THE BREAKDOWN LANE WITHOUT INJURING MYSELF OR ANYONE ELSE; HOWEVER, THIS IS UNACCEPTABLE. EVERY SINGLE PART IN MY RX-8 HAS BEEN REPLACED EXCEPT FOR THE ENGINE MOUNTS AND ENGINE. I HAVE DISHED OUT THOUSANDS OF DOLLARS ALREADY AND THE VEHICLE ONLY HAS 44,000 MILES ON IT. NOT ONLY IS THIS A SAFETY HAZARD TO THOSE OF US DRIVING THE VEHICLE, BUT IT IS ALSO A SAFETY HAZARD TO THOSE AROUND US. HAD THE CAR BEHIND ME NOT BEEN PAYING ATTENTION MY VEHICLE COULD HAVE CAUSED A DEADLY CAR CRASH IN THE MIDDLE OF RUSH HOUR ON A MAJOR HIGHWAY. I HAVE CONTACTED NUMEROUS DEALERSHIPS, THE BBB, AND AM NOW LOOKING INTO A CLASS ACTION LAWSUIT. MAZDA NEEDS TO BE HELD ACCOUNTABLE FOR THEIR ACTIONS. UNFORTUNATELY BECAUSE MY CAR WAS PURCHASED IN 2003, BBB WOULDN'T HAVE ANYTHING TO DO WITH THE CASE, HOWEVER I HAVE 57 PAGES OF DETAILED REPAIRS THAT HAVE BEEN MADE TO THIS VEHICLE SINCE I OWNED IT, WHICH I AM MORE THAN HAPPY TO SEND TO YOU. TONS OF PEOPLE ONLINE HAVE HAD SIMILAR ISSUES; JUST FROM AUTOMOTIVE.COM THERE ARE 30+ EMAIL ADDRESSES OF INDIVIDUALS WHO HAVE EXPERIENCED PROBLEMS SIMILAR TO MINE. PLEASE HELP US GET TO THE BOTTOM OF THIS FAULTY ENGINE AND MAKE MAZDA OWN UP TO THEIR MISTAKES. PEOPLE'S LIVES ARE IN DANGER AND THIS IS NEITHER ACCEPTABLE NOR ETHICAL. PS- AN EMPLOYEE OF NHTSA HAS BEEN CONTACTED PRIOR REGARDING THIS SITUATION. HER NAME IS [XXX] AND HER CONTACT INFORMATION IS [XXX]EXT #: [XXX]. I RECEIVED THIS FROM THE AUTOMOTIVE.COM FORUM. *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Mar 10, 2010
EXTERIOR LIGHTING,VISIBILITY
1 complaint
THE PART NUMBER OF THE ITEM IS MAZDA PART #FE03-51-21YD AND #FE03-51-22YC. THIS PART IS INSTALLED IN THE MAZDA'S VEHICLE THE RX8. THE PART STARTED TO FAIL AT AROUND 57,000 MILES WITHIN JUST LESS THAN TWO MONTHS AFTER THE WARRANTY EXPIRED AND 7,000 MILES AFTER THE VEHICLE'S MANUFACTURER WARRANTY EXPIRED. THIS PART SHOULD BE CONSIDERED A SAFETY COMPONENT BECAUSE IT PRESENTS A DANGEROUS THREAT TO BOTH DRIVERS AND PASSENGERS OCCUPYING THE VEHICLE DURING FAILURE AND MAZDA IS CLAIMING THAT IT IS NOT. THE REASON WHY IS THAT WHEN THIS PARTS FAILS TO FUNCTION PROPERLY THE HEADLIGHT BEAMS CANNOT BE REGULATED PROPERLY IN ORDER TO SEE SAFELY. INSTEAD WHAT WILL HAPPEN IS THAT THE LIGHTS WILL NOT ADJUST TO THE CORRECT HEIGHT AND WILL NOT ILLUMINATE THE ROAD SO THAT THE DRIVER CANNOT SEE AHEAD OF THE VEHICLE. ON MY VEHICLE SPECIFICALLY WHEN THE INCIDENT OCCURRED AND RE-OCCURRED I COULD NOT SEE NO FURTHER THEN A RANGE OF TEN TO FIFTEEN FEET FROM MY VEHICLE. IN THE RESEARCH I'VE DONE I'VE READ IN THE FORUMS THAT THIS IS EXTREMELY COMMON IN ALL THE MODELS BUILT WITHIN THE TIME PERIOD OF 2004-2007 BUILT BEFORE THE DATE OF NOVEMBER 15, 2006 (BEFORE THEY REDESIGNED THE PART). *TR
Aug 05, 2009
SUSPENSION,STRUCTURE,TIRES
1 complaint
TL*THE CONTACT OWNS A 2004 MAZDA RX8. THE VEHICLE HAS BRIDGESTONE ALL SEASON TIRES. THE CONTACT WAS CONCERNED ABOUT THE AIR PRESSURE IN THE TIRES AND NOTIFIED THE MANUFACTURER. MAZDA SUGGESTED THAT HE TAKE THE VEHICLE TO A DEALER FOR INSPECTION. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES, BUT NO REPAIRS WERE MADE. THE DEALER ONLY PLACED AIR IN THE TIRES. ON ONE OCCASION, WHILE DRIVING ALMOST 60 MPH, THE CONTACT FELT A VERY ROUGH VIBRATION IN THE VEHICLE. HE ATTEMPTED TO MOVE THE VEHICLE OFF THE ROAD AND THE REAR PASSENGER SIDE TIRE EXPLODED. THE TIRE AND VEHICLE MANUFACTURERS WERE NOT NOTIFIED OF THE BLOW OUT. THE DOT NUMBER AND TIRE SIZE WERE UNKNOWN. THE FAILURE MILEAGE WAS 14,000 AND CURRENT MILEAGE WAS 23,000. THE TAIL LIGHTS WOULD FILL WITH WATER. THERE WAS A STRANGE CLICKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE MAY HAVE A STRUT PROBLEM. UPDATED 07/30/09.*JB
Jun 23, 2009
FUEL SYSTEM, OTHER
1 complaint
2004 MAZDA RX8 WAS REPAIRED ON 2/27/09 AT HERNANDO MISTUBISHI THE SERVICE DEPARTMENT FOR GULFVIEW MOTORS, DUE TO THE FUEL GAUGE READING INCORRECTLY AND THE VEHICLE RUNNING OUT OF GASOLINE ON A READING OF A 1/2 OF TANK. ON 2/28/09, AFTER VEHICLE WAS SUPPOSEDLY REPAIRED , THE 2004 MAZDA BROKE DOWN DUE TO IN ACCURATE FUEL READING, A DAY AFTER THE VEHICLE WAS SERVICED FOR THIS PROBLEM. THE CHECK ENGINE LIGHT ALSO CAME BACK ON AND HAS CONSISTENTLY STAYED ON. JOHN MORRIS AND LINDA SANFORD WERE BOTH AWARE THAT THIS WAS A MAJOR PROBLEM THAT CLEARLY FAILS THE REQUIRED NYS MOTOR VEHICLE INSPECTION. THE VEHICLE NEEDS TO BE REPAIRED AT MAZDA AND IT IS THE RESPONSIBILITY OF GULF VIEW MOTORS. I HAVE DRIVEN TO SYRACUSE, N.Y. OUT OF MY WAY AND PAYING FOR GASOLINE TO SPEAK WITH MR. PAUL COREY, SERVICE MANAGER FOR MAZDA. *TR
Mar 24, 2009
SUSPENSION,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,WHEELS
1 complaint
TL*THE CONTACT OWNS A 2004 MAZDA RX8. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WILL STALL WITHOUT WARNING. HE TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND A MECHANIC STATED THAT FUEL FLOODED THE ENGINE AND CAUSES THE VEHICLE TO STALL. THE ENGINE WAS COMPLETELY REPLACED. IN ADDITION, IT TAKES SEVERAL ATTEMPTS TO START THE VEHICLE IN COLD WEATHER CONDITIONS. THE DEALER STATED THAT CONDENSATION WAS PRESENT AND A VACUUM NEEDED TO BE INSTALLED, WHICH WOULD PREVENT WATER INTERFERENCE. THE REAR DRIVER'S SIDE EXTERIOR LIGHTING NEEDED TO BE REPLACED DUE TO THE WATER ENTRY. FINALLY, THE FRONT PASSENGER SIDE WHEEL BEARING FAILED, WHICH ALMOST CAUSED THE TIRE TO SEPARATE FROM THE VEHICLE. THE FAILURE MILEAGE WAS 32,000 AND CURRENT MILEAGE WAS 43,000. UPDATED 020209 *BF THE RIGHT FRONT WHEEL BEARING WAS WORN. THE CHECK ENGINE LIGHT ILLUMINATED. THE FRONT AND REAR COILS WERE REPLACED. UPDATED 02/03/09. *JB
Jan 14, 2009
SUSPENSION,ENGINE AND ENGINE COOLING
1 complaint
TL*THE CONTACT OWNS A 2004 MAZDA RX8. WHILE DRIVING 15 MPH, THE VEHICLE MADE A CREAKING NOISE WHENEVER THE STEERING WHEEL WAS TURNED. HE TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THERE WAS A TEAR LINE CRACK IN THE LOWER CONTROL ARM IN THE SUSPENSION. THE CONTACT RECEIVED A RECALL NOTICE IN 2005 FOR NHTSA CAMPAIGN ID NUMBER 05V325000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT) AND THE MANUFACTURER REPAIRED THE VEHICLE FOR FREE. THE FAILURE HAS RECURRED, BUT THE MANUFACTURER REFUSES TO REPAIR THE VEHICLE ACCORDING TO THE RECALL. HE BELIEVES THAT THE COMPONENT THAT WAS USED TO PREVIOUSLY REPAIR THE VEHICLE WAS FAULTY; THEREFORE, THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIRS. THE CHECK ENGINE INDICATOR WOULD RANDOMLY ILLUMINATE WHILE DRIVING VARIOUS SPEEDS. A LOCAL MECHANIC STATED THAT THE VEHICLE EXPERIENCED A RUPTURED OIL COOLING LINE. DURING THE REPAIR, THE TECHNICIAN NOTICED THAT THE OIL PAN WAS PERFORATED AND LEAKING OIL. THE OIL PAN NEEDED TO BE REPLACED; HOWEVER, THE OIL COOLING LINE WAS REPLACED. THE MECHANIC STATED THAT THIS WAS ALL CAUSED BY RUST. THE CONTACT WAS UNABLE TO FIND A RECALL FOR THE FAILURE, BUT BELIEVED IT SHOULD HAVE ALSO BEEN RECALLED BY THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 8,000 AND CURRENT MILEAGE WAS 42,000.
Dec 05, 2008
VISIBILITY,EQUIPMENT
1 complaint
AC AND GENERAL CABIN TEMPERATURE PROBLEMS. I AM HAVING A COMBINATION OF PROBLEMS WITH THE HEATING AND COOLING OF THE CAR. IN THE SUMMER WHEN IT IS VERY HOT THERE IS A NOTICEABLE "PULSING" OR ON/OFF SYMPTOM OF THE COLD AIR GENERATED BY THE AC. I TIMED IT AND VERY COLD AIR COMES OUT OF THE VENT FOR ABOUT 30 - 45 SECONDS. THEN IT IS FOLLOWED BY ABOUT THE SAME DURATION OF REGULAR AIR (THE AC SEEMS TO SHUT OFF) SO ON HOT DAYS YOU GET A PULSE OF COLD FOLLOWED UP BY A PULSE OF WARM AIR. THE EFFECT IS THAT THE CABIN HEATS UP AND THE AC CANNOT KEEP UP WITH IT. IT THE WINTER WHEN IT IS COLD OUT THERE IS A DIFFERENT ISSUE. IT SEEMS THAT THE VENTS ARE ALLOWING OUTSIDE AIR TO GET INTO THE MIXTURE. IN THE WINTER ICE COLD AIR IS BEING MIXED IN WITH THE HEAT WHICH HAS THE SAME EFFECT WHERE THE HEATER CANNOT KEEP UP WITH HEATING THE CABIN OF THE CAR. THERE IS ALSO AN ANNOYING FEATURE ON THE DEFROSTER. YOU CANNOT DEFROST THE WINDOW WITH INSIDE AIR AS SOON AS YOU TURN ON THE DEFROSTER IT FLIPS THE OUTSIDE AIR VENT OPEN. SO WHEN IT IS VERY COLD YOU HAVE TO CHOSE BETWEEN SEEING OUT THE WIND SHIELD AND FREEZING OR HEAT THE CABIN AND THE WIND SHIELD FOGS UP. I HAVE TAKEN THE CAR IN THREE TIMES AND HAVE SINCE GAVE UP. THE TECH'S OBVIOUSLY CANNOT OR WILL NOT FIX IT. THE TECH ACTUALLY HAD A THERMOMETER IN THE VENT OF THE CAR AND OF COURSE THE CAR IS INSIDE THE GARAGE IN THE SHADE. SO HE POPS IN THE THERMOMETER AND COMES BACK AND CHECKS IT A - OK. I GAVE THEM A DETAILED DESCRIPTION, DO YOU THINK THEY TOOK THE CAR OUT AND DROVE IT WHEN IT IS ABOVE 85 DEGREES OUTSIDE? NOPE *TR
Nov 14, 2007
STEERING,ENGINE AND ENGINE COOLING
1 complaint
PURCHASED USED VEHICLE IN APRIL 2007, FIRST INCIDENT 8/14/2007 ENGINE STALLED (ENGINE INTERNAL FAILURE) AT 45,107 MILES ENGINE REPLACED BY MAZDA DEALERSHIP. SECOND INCIDENT SEPTEMBER 2007 POWER STEERING GOES OUT (POOR CONNECTION ON ENGINE ROOM HARNESS) CONNECTION FIXED STEERING GEAR REPLACED; THIRD INCIDENT OCTOBER 2007, STEERING PROBLEM (STEERING SHAFT TORQUE SENSOR MALFUNCTION) BROKEN WIRE REPAIRED--LEARNED THAT THE VEHICLE HAD BEEN SERVICED 15 TIMES PRIOR TO MY PURCHASE. *JB
Oct 25, 2007
SUSPENSION,ENGINE AND ENGINE COOLING,POWER TRAIN,AIR BAGS,EQUIPMENT
1 complaint
ENGINE FAILURE, PURCHASED CAR 3/11/2006, A COUPLE OF WEEKS LATER THE CAR STARTED IDLING ROUGHLY, THEN STALLING, THE COMPUTER MODULE HAS BEEN REPLACED TWICE, THE ENGINE ONCE, I STILL HAVE PROBLEMS WITH ACCELERATION, THE LAST INCIDENT HAPPENED LAST WEEK 7/29/2007, I WAS IN THE CENTER LANE PULLING OUT INTO THE PASSING LANE AND THE CAR LOST ALL POWER BUT DID NOT STALL MY HEAD WAS SLAMMED FORWARD ALMOST HITTING THE STIRRING WHEEL AND A FEW SECONDS LATER SHOT OFF LIKE A ROCKET SLAMMING MY HEAD BACK AGAINST THE DRIVERS SEAT, CAUSING MY NECK TO WHIP LASH I HAVE HAD A BAD HEADACHE SINCE, AND I WAS ALMOST HIT BY A BIG DIESEL TRUCK. THE CAR IS IN THE SHOP AGAIN GETTING THE OIL AND TIRES CHANGED, AND ALSO GETTING CHECKED FOR THIS PROBLEM BUT THEY ARE SAYING THEY COULD NOT FIND ANYTHING ON THE ROAD TEST. WELL IT HAPPENS TO ME QUITE OFTEN WHEN I GO TO PASS SOMEONE ON THE INTERSTATE, IT HESITATES BEFORE IT KICKS IN AND SOMEONE IS GOING TO GET KILLED. I AM PAYING FOR A CAR THAT SPENDS MORE TIME IN THE SHOP THAN OUT. I BOUGHT IT 3/11/06 IT STAYED IN THE SHOP ALMOST CONTINUALLY UNTIL 7/18/2006, AND I WAS MAKING PAYMENTS. NOW IT IS STARTING ALL OVER AGAIN WITH THE ROUGH IDLE AND HESITATION. I AM GETTING TO THE POINT THAT I WANT MY MONEY BACK AND I'LL GIVE THEM THE CAR BACK. I AM GETTING TO SCARED TO DRIVE IT. NOW I FIND OUT TODAY ABOUT OTHER RECALLS THE CONTROL ARM I WAS NOT AWARE OF, I GUESS THAT IS WHY MY CAR IS STARTING TO PULL HARD TO THE RIGHT, NOW I HAVE TO HAVE THAT TAKEN CARE OF. I HAVE MOVED 350 MILES AWAY AND I CAN'T LEAVE UNTIL MY CAR GETS FIXED AND OUT OF THE SHOP, THIS IS STARTING TO BE BULL!!! SOMEONE NEEDS TO DO SOMETHING I HAVE A FRIEND WHO ALSO HAS AN RX8 WE PURCHASED OURS ON THE SAME DAY AND SHE IS HAVING THE SAME PROBLEMS AND HERS IS A 2006 WHERE MINE IS A 2004, SO MAZDA HASN'T FIXED THE PROBLEM.*JB
Aug 05, 2007
ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM
1 complaint
ENGINE FAILURE, AFTER DRIVING SHORT DISTANCES ENGINE DOES NOT ALWAYS WANT TO RESTART; DURING TIMES OF SITTING IN TRAFFIC, CAR WILL IDLE ROUGHLY AND SPUTTER, SOMETIMES DIE AND WON'T IMMEDIATELY RESTART; CAR HAS DIED WHILE ATTEMPTING TO START OUT INTO TRAFFIC; TRANSMISSION DOESN'T CHANGE GEARS PROPERLY... I HAVE HAD MY CAR SINCE FEB. 04 AND IT HAS BEEN SERVICED OVER A DOZEN TIMES FOR ENGINE FAILURE AND TRANSMISSION ISSUES ALONE. IT HAS HAD A NEW TRANSMISSION, LINKAGE, GEAR BOX, STARTER, BATTERY, AND THEY ARE CURRENTLY PUTTING IN THE 2ND REPLACEMENT ENGINE. NO ONE SEEMS TO KNOW WHY THESE CARS HAVE SO MUCH TROUBLE, BUT I WOULDN'T HAVE ANOTHER ONE IF IT WAS GIVEN TO ME. *NM
Jan 05, 2007
ENGINE AND ENGINE COOLING,POWER TRAIN,UNKNOWN OR OTHER
1 complaint
CAR STALLS AT LIGHTS DOES NOT RESPOND WHEN ACCELERATING HAVE GONE TO BACK UP AND NO RESPONSE THEN CAR WILL JUST TAKE OFF HAVE HAD 2 ACCIDENTS DUE TO NO ACCELERATION FOG AND BUGS IN TAILLIGHTS AIRBAG LIGHT ON/OFF FOR NO REASON CAR HAS BEEN TO DEALERSHIP FOR ALL RECALLS I AM TOLD I AM NOT DRIVING THE CAR FAST ENOUGH AND AM TOLD I NEED TO CHECK MY OIL WHEN I GET GAS. TOO MANY PROBLEMS TO LIST DEALER WILL FIX BUT CANNOT DUPLICATE SOME OF THE PROBLEMS I EXPERIENCE HAVE TRIED TO CONTACT MANUFACTURER ONLY TO BE PUT ON HOLD TO LISTEN TO ZOOM ZOOM MUSIC OVER AND OVER. *JB
Oct 06, 2006
ENGINE AND ENGINE COOLING,STRUCTURE
1 complaint
DT*: THE CONTACT STATED WHILE DRIVING IN NORMAL CONDITIONS AND NO PARTICULAR SPEED, THE ENGINE VIBRATES. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP FOR INSPECTION. THE DEALER DISCOVERED TWO MOTOR MOUNTS WERE BROKEN. THE REPAIR PARTS ARE ON BACK ORDER AND NO REPAIRS WERE MADE.
Feb 07, 2006
ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,VISIBILITY,STRUCTURE
1 complaint
2004 MAZDA RX 8 HAS MANY DESIGN DEFECTS, BATTERY WAS REPLACED, SPARK PLUGS AND OIL FILTER WAS REPLACED 3 MONTHS AFTER PURCHASE. *TS THE STARTED WAS REPLACED. THE VEHICLE WAS STALLING IN TRAFFIC AND WAS TAKING MULTIPLE TIMES TO TRY TO RESTART THE VEHICLE. AFTER NUMEROUS TIMES OF THE VEHICLE BEING TOWED, THE DEALERSHIP DECIDED TO REPLACE THE ENTIRE ENGINE. AFTER THE REPLACEMENT OF THE ENGINE, THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE WAS STILL NOT STARTING SMOOTHLY. THE DASH LIGHTS WERE BLINKING ON AND OFF AND THE HEAT WAS NOT WORKING. THE CATALYTIC CONVERTER, 02 SENSOR, AND A/C AMPLIFIER. THE HEATER CONTROL SWITCH WAS REPLACED. THE SUN VISOR WAS REPLACED. *JB
Jan 03, 2006
SUSPENSION,ENGINE AND ENGINE COOLING,TIRES
1 complaint
I RECEIVED 2 SAFETY RECALL NOTICES ON MY RX8. I TOOK THE CAR TO THE DEALER WHERE I LEASED THE VEHICLE AND I THOUGHT THEY CORRECTED AND/OR INSPECTED THE PROBLEM. OVER THE COURSE OF THE PAST 60 DAYS, THE SERVICE I HAVE RECEIVED HAS BEEN UNSATISFACTORY AND I HAVE BEEN LEAD TO BELIEVE THAT THE DEALER MAY NOT HAVE ADDRESSED THE SAFETY RECALL ISSUES. (CRACKED BALL JOINT AND HEAT INSULATION). I HAVE A CHECK ENGINE LIGHT PROBLEM AND I THINK THEY DON'T KNOW WHAT TO DO, TO THE POINT THEY WILL REPLACE THE ENGINE. THIS WILL INEVITABLY CAUSE MY VEHICLE TO LOSE VALUE. *JB
Nov 10, 2005
ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL
1 complaint
DT: THE CONTACT OWNS A 2004 MAZDA RX8. THE CONTACT STATES THAT WHILE DRIVING WITH CRUISE CONTROL SET AND HITTING THE BRAKES TO SLOW DOWN OR STOP , AND IF PRESSING THE RESUME BUTTON ,THE CAR WILL ACTUALLY SET ITSELF 5 MPH MORE THAN WHAT ORIGINALLY HAD THE SPEED SET FOR. ONCE THE CAR GOES TO 5 MPH OVER THE SPEED THE CAR WAS SET FOR THE CAR WILL ACT AS IF IT WAS TRYING TO MAKE ITSELF GO BACK DOWN TO THE SPEED THAT WAS ORIGINALLY SET ,AND THE VEHICLE WILL JERK VIOLENTLY. THE CONTACT WAS TAKING THE VEHICLE TO THE DEALERSHIP ON THURSDAY TO SEE IF THEY COULD DIAGNOSE THE PROBLEM BECAUSE THIS HAS BEEN OCCURRING FOR A COUPLE OF MONTHS. THE ONLY WAY TO MAKE THIS PROBLEM STOP IS TO TURN OFF THE CRUISE CONTROL AND RESET IT AND THEN IT WILL STOP. THIS PROBLEM WITH THE VEHICLE AT HIGHWAY SPEEDS WILL HAPPEN AT ABOUT 60% OF THE TIME THAT THE CRUISE CONTROL IS SET. ALSO, THE ENGINE FAN WILL STAY ON ALL THE TIME. THE DEALERSHIP IS UNABLE TO DUPLICATE THE PROBLEM. THEREFORE , IT CANNOT BE FIXED AT THIS TIME. THE ELECTRIC FAN WILL ACTUALLY STAY ON WHILE THE VEHICLE IS TURNED OFF. THEN BY TURNING THE IGNITION BACK ON AND OFF IT THE VEHICLE WILL STOP RUNNING. THIS MOSTLY OCCURS IF THE VEHICLE IS DRIVEN FOR ABOUT 30 MINUTES. *AK
Sep 06, 2005
ENGINE AND ENGINE COOLING,EQUIPMENT,UNKNOWN OR OTHER
1 complaint
I JUST BOUGHT A 2004 MAZDA RX8 AND A PIECE OF ROAD DEBRIS HIT MY AC CONDENSER CAUSING ALL THE FREON TO LEAK OUT. THIS HAPPENED DUE TO THE GAPING HOLE IN THE FRONT AIR DAM OF MY VEHICLE. I LIVE IN SOUTHERN TEXAS WHERE TEMPS CAN CLIMB WELL OVER 100 DEGREES. (HIGHER INSIDE THE CAR) I WORRY MY 3YR OLD SON IS AT RISK OF HEAT STROKE OR WORSE FROM THE TEMPS. MAZDA WILL NOT COVER THIS IN THEIR WARRANTY YET THEY DO NOTHING TO PROTECT THE HIGHLY VULNERABLE CONDENSER, OIL COOLER, AND RADIATOR FROM BEING PELTED FROM ROAD DEBRIS. AS A MATTER OF FACT THE AIR DAM IS SO POORLY DESIGNED THAT IT ACTUALLY FUNNELS ROCKS INTO THE AC CONDENSER ITSELF. I AM NOW WORRIED THAT A PIECE OF ''ROAD DEBRIS'' MAY HIT MY OIL COOLER AND SPILL OIL ALL OVER THE HIGHWAY. THAT IS DEFINITELY NOT CONSIDERED SAFE UNDER ANY CIRCUMSTANCES. MANY PEOPLE ONLINE I HAVE SPOKEN TO HAVE HAD THIS SAME PROBLEM AND THE SERVICE PERSON AT THE DEALERSHIP STATED, ''WE SEE CARS IN HERE FOR THIS ALL THE TIME''. THE TOTAL REPAIR COST IS OVER 800$. EVEN HAVING TO PAY MY DEDUCTIBLE IS ASKING A LOT FOR THIS TYPE OF ''MALFUNCTION''. MAZDA ADVERTISES THIS CAR AS A 4-DOOR COUPE AND SELLS THE CAR ON ITS ''PRACTICALITY''. HOW PRACTICAL IS IT TO HAVE ''ROAD DEBRIS'' DESTROY YOUR AC A WEEK AFTER PURCHASE? I PURCHASED THE CAR FROM INGRAM PARK AUTO CENTER HERE IN SAN ANTONIO, TX. FROM A GENTLEMAN NAMED JUAN LEON. THEY WERE OF NO HELP IN THE MATTER.
Jul 12, 2005
ELECTRONIC STABILITY CONTROL
1 complaint
THE VEHICLE FISHTAILED ALL THE TIME IN INCLEMENT WEATHER. THE CONSUMER WAS MAKING A RIGHT TURN AND THE VEHICLE DID A NINETY DEGREE TURN ON THE ROAD. THE TRACTION CONTROL WAS NOT WORKING PROPERLY. THE DEALER FOUND NO DEFECTS. *AK *SC
Mar 30, 2005
POWER TRAIN,SEATS
1 complaint
1.WHEN ADJUSTED DRIVER'S POWER SEAT CONTINUES TO MOVE FORWARD EVEN AFTER ADJUSTMENT SWITCH IS RELEASED, RESULTING IN A POTENTIALLY DANGEROUS UNINTENDED AND UNCONTROLLABLE DRIVING POSITION FOR THE DRIVER.*AK 2.WHILE IN THE 'NEUTRAL' POSITION, THE AUTOMATIC TRANSMISSION SHIFT LEVER IS TOO EASILY MOVED UINTENTIONALLY INTO THE REVERSE POSITION RESULTING IN THE VEHICLE ABRUPTLY AND DANGEROUSLY REVERSING ITS POSITION AND MOVING REARWARD UNINTENTIONALLY AND WITHOUT WARNING. THE GEAR SELECTOR 'GATE DESIGN' IS FAULTY.
Mar 10, 2005
ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES,UNKNOWN OR OTHER
1 complaint
DRIVER'S SIDE SUN VISOR CRACKED AND SEPARATED FROM POST. IT WAS HANGING AND WOULD NOT STAY UP, OUT OF FIELD OF VISION. THE DEALER REMOVED THE VISOR WHILE WAITING FOR THE REPLACEMENT PART. AFTER STARTING THE CAR LATER THE SAME DAY, THE CHECK ENGINE LIGHT CAME ON AND THE CENTRAL DISPLAY AND DOOR LOCKS DID NOT WORK. WHILE DROPPING OFF PASSENGER BEFORE RETURNING TO THE DEALER, PASSENGER FOLDED DOWN PASSENGER-SIDE SUN VISOR, WHICH ALSO CRACKED AND SEPARATED FROM THE POST. TOOK CAR BACK TO DEALER, WHO IS TRYING TO SAY THIS IS NOT UNDER WARRANTY, AND HAS CALLED MAZDA REP TO EXAMINE BUT IS KEEPING MY CAR. SEVERAL REPORTS OF THIS ON EDMUNDS AND OTHER AUTO CONSUMER SITES. I MERELY WANT VISORS REPLACED AND ELECTRICAL SYSTEM FIXED UNDER WARRANTY.*AK
May 03, 2004
ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER
1 complaint
I PURCHASED MY AUTOMATIC RX8 IN LATE JAN. 2004. AS I WRITE THIS, I HAVE AVERAGED 14.3 MPG WITH MIXED DRIVING CONDITIONS (CITY AND HIGHWAY) DURING MY FIRST 3000 MILES. MY WORST TANKFUL WAS 12.3 MPG. MAZDA NORTH AMERICA REFUSES TO ADDRESS MY ISSUE, WHICH IS: MY FUEL ECONOMY IS WELL BELOW THE ESTIMATED FUEL ECONOMY ON THE STICKER. EITHER THERE IS SOMETHING WRONG WITH MY RX8 OR MAZDA HAS INTENTIONALLY MISREPRESENTED THE FUEL ECONOMY OF THE RX8.
Apr 28, 2004
FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM
1 complaint
MAZDA RX-8 WITH LESS THAN 3000 MILES HAS TWICE SHUT OFF AND FAILED TO START. MAJOR PROBLEM WITH FUEL DELIVERY AND/OR SPARK IGNITION SYSTEM. *AK
Dec 19, 2003
SEAT BELTS,EQUIPMENT
1 complaint
IN THE NEW MAZDA RX8, THE REAR SEAT DESIGN WITH THE HIGH CENTER CONSOLE MAKES IT VERY HARD TO LATCH THE SEAT BELT WITH A CHILD BOOSTER SEAT, AND IMPOSSIBLE TO DO SO FOR AN OLDER PERSON OR A PERSON WITHOUT GOOD MANUAL DEXTERITY AND A STRONG BACK. IT IS COMPLETELY IMPOSSIBLE FOR THE CHILD TO LATCH THEMSELVES IN. NOTE THAT THIS IS NOT A PROBLEM FOR ATTACHING INFANT OR CHILD SEATS WITH SEAT BELTS INSTALLED IN THE SEAT ITSELF - IT'S A PROBLEM FOR OLDER CHILDREN (30-80 LBS) THAT SIT IN A BOOSTER AND USE THE 3 POINT SEAT BELT INSTALLED IN THE CAR. I HAVE CONTACTED MAZDA AND RECOMMENDED THAT THEY CREATE A SEAT BELT EXTENDER SO THAT THE BELT LATCH CAN BE RAISED UP HIGH ENOUGH TO REACH AROUND THE SIDE OF THE CAR SEAT, AND THEY SAID THEY WOULD INVESTIGATE, BUT THERE WAS NO REMEDY IN THE FORSEEN FUTURE. I HAVE ALSO SHOPPED AROUND FOR BOOSTER SEATS, AND HAVE YET TO FIND A MODEL THAT WORKS IN THIS CAR.*AK
Oct 27, 2003
Frequently Asked Questions
How many problems does the 2004 MAZDA RX-8 have?
The 2004 MAZDA RX-8 currently has 513 owner-reported complaints according to NHTSA database. These complaints are organized by component to help identify common issues.
What are the most common problems with 2004 MAZDA RX-8?
The most common problems reported for the 2004 MAZDA RX-8 are organized by component above. Each component section shows owner-reported issues, crash reports, and fire incidents to help identify patterns and problem areas.
Where does this 2004 MAZDA RX-8 problem data come from?
All problem and complaint data for the 2004 MAZDA RX-8 comes directly from the National Highway Traffic Safety Administration (NHTSA) database. These are real complaints submitted by actual vehicle owners.
Other Years - MAZDA RX-8
2025 Problems
2024 Problems
2023 Problems
2022 Problems
2021 Problems
2020 Problems
2019 Problems
2018 Problems
2017 Problems
2016 Problems
2015 Problems
2014 Problems
2013 Problems
2012 Problems
2011 Problems
2010 Problems
2009 Problems
2008 Problems
2007 Problems
2006 Problems
2005 Problems
2003 Problems
2002 Problems
2001 Problems
2000 Problems
Other MAZDA Models
Similar Brands
ST
3,555 models
RS
3,484 models
NC
2,822 models
ND
2,385 models
Z
1,951 models
MOTO
1,583 models
NU
1,189 models
RC
1,122 models