The Chevrolet Aveo has 4 NHTSA recall campaigns on record covering 2004–2010. On average a defect was admitted 6.13 years after the car was built, the slowest took 10 years. The most recalled system is Service Brakes, Hydraulic (1 campaigns). Owners also filed 1,050 complaints on this model — see what breaks.
What was recalled on the Chevrolet Aveo
Grouped by system. Open any row for the campaigns themselves — what failed, what it risks and how the dealer fixes it, straight from the NHTSA filing.
Service Brakes, Hydraulic 1 Read
What's wrong. General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Aveo and 2009 Pontiac G3 vehicles. The vehicles may contain brake fluid which does not protect against corrosion of the valves inside the anti-lock brake system (ABS) module, affecting the closing motion of the valves
Risk. If the ABS valve corrodes it may result in longer brake pedal travel or reduced performance, increasing the risk of a vehicle crash
Fix. GM will notify owners, and dealers will replace the ABS module, free of charge, in any vehicle that did not have its module replaced under a previous customer satisfaction campaign. The recall began in late September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), and 1-800-762-2737…
What's wrong. General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Aveo and 2009 Pontiac G3 vehicles. The vehicles may contain brake fluid which does not protect against corrosion of the valves inside the anti-lock brake system (ABS) module, affecting the closing motion of the valves
Risk. If the ABS valve corrodes it may result in longer brake pedal travel or reduced performance, increasing the risk of a vehicle crash
Fix. GM will notify owners, and dealers will replace the ABS module, free of charge, in any vehicle that did not have its module replaced under a previous customer satisfaction campaign. The recall began in late September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), and 1-800-762-2737…
Exterior Lighting 1 Read
What's wrong. General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module
Risk. If the DRL module melts due to the heat generation, it could cause a vehicle fire
Fix. GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020…
What's wrong. General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module
Risk. If the DRL module melts due to the heat generation, it could cause a vehicle fire
Fix. GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020…
What's wrong. General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module
Risk. If the DRL module melts due to the heat generation, it could cause a vehicle fire
Fix. GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020…
Fuel System, Gasoline 1 Read
What's wrong. On certain passenger vehicles equipped with a 1.6l engine, during a ncap severe frontal crash test, the fuel line in the engine compartment developed a fracture. In addition, the crash damage caused four short circuits in the fuse block, the combination of which allowed the fuel pump to continue running and fuel leaked onto the ground
Risk. If these conditions occurred in an actual crash, a vehicle fire could occur
Fix. Dealers will replace the fuse block and install a new section of fuel line that has been redesigned free of charge. The recall began on november 16, 2006. Owners may contact chevrolet at 1-800-630-2438
Seat Belts 1 Read
What's wrong. On certain passenger vehicles, the rear safety belt can become twisted
Risk. If this occurs the safety belt retractor may lock in position so that the belt cannot be used. In the event of a vehicle crash, personal injury to the seat occupant could occur
Fix. Dealers will install a safety belt webbing guide to prevent the belt from twisting. The recall began on october 15, 2004. Owners should contact chevrolet at 1-800-630-2438. Vehicle owners located in guam should contact gm customer assistance at 1-671-648-8453
How long a defect stays unadmitted
Campaign numbers encode the year of the announcement, so each recall on this model can be dated against the car it applies to.
| Measure | Value |
|---|---|
| Average gap before admission | 6.13 years |
| Slowest campaign | 10 years |
| Admitted 5+ years later | 75% |
| Campaigns on record | 4 |
Which Aveo years were recalled most
Campaigns per model year. A year with more campaigns is not automatically worse — it may simply have sold in far greater numbers.
| Model year | Campaigns | Most recalled system |
|---|---|---|
| 2010 | Service Brakes, Hydraulic | |
| 2009 | Service Brakes, Hydraulic | |
| 2008 | Exterior Lighting | |
| 2007 | Fuel System, Gasoline | |
| 2006 | Exterior Lighting | |
| 2005 | Exterior Lighting | |
| 2004 | Seat Belts |
Check your own car
A campaign applies to a range of production, not to every car of the model. The only way to know whether yours is affected — and whether the repair was already done — is by VIN.
| Step | What you get |
|---|---|
| Enter the VIN above | Open campaigns for that exact vehicle, straight from NHTSA |
| Check the repair status | Whether the free fix has already been carried out on this car |
| Book at any franchised dealer | Recall work is free regardless of age, mileage or owner |
Go deeper
A campaign covers a production range. Yours is one car.
- Check whether this exact VIN is affected — and whether the fix was done
- Alerts if a new campaign lands on a car in your garage
- Full research report as a PDF you can hand to a mechanic
- Decode a whole list of VINs at once
- No ads, on every page
- No ads, no tracking — and much more
Frequently asked questions
How many recalls does the Chevrolet Aveo have?
4 NHTSA campaigns on record, covering 2004–2010. Not every campaign applies to every car — coverage is by production range, so check your VIN.
Is recall work free?
Yes. Safety recall repairs are free at any franchised dealer regardless of the car's age, mileage or how many owners it has had. That is a federal requirement, not a courtesy.
How do I know if my Aveo still has an open recall?
Enter its VIN above. We show campaigns that apply to that exact vehicle and whether the repair has already been recorded as done.
Why did a defect take years to be recalled?
On this model the average gap between the car being built and the defect being admitted is 6.13 years, and the slowest campaign came 10 years later. Defects usually surface as they accumulate in the field: complaints pile up, an investigation opens, and only then is a campaign issued.