Dodge Caravan Recalls

What's wrong. The braun corporation is recalling certain model year 2008 through 2010 chrysler town & country and dodge caravan commercial entervans which were altered by braun between january 21, 2009 and march 19, 2010. During conversion, the chassis was raised and the floor was lowered to accommodate wheelchair accessibility features. In raising the chassis, the fuel fill pipe comes into closer proximity to the left rear tire. In rough or aggressive driving situations, the tire may intermittently contact the fuel fill pipe

Risk. Contact between the tire and fuel fill pipe may wear a hole in one or the other components over time. This may result in loss of vehicle control in the event of tire pressure loss, or a vehicle fire in the event the fuel pipe is compromised

Fix. Braun will notify owners and repair the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun toll-free at 1-800-488-0359

What's wrong. Certain aftermarket replacement fuel filters, models wix filter part numbers 33576, 33577, 33734; napa filter part numbers 3576, 3577, 3734; and carquest filter part numbers 86576, 86577, 86734 used on 1996-2000 daimlerchrysler town & country, dodge caravan, and plymouth voyager vehicles, can cause the fuel lines to leak

Risk. A possible fire can occur in the presence of an ignition source

Fix. Wix will notify its customers and replace the fuel filters free of charge. Note: this does not involve any products manufactured by the daimlerchrysler corp. Nor any dailmerchrysler dealers. Owner notification is expected to begin during november 2003. Owners who do not receive the free remedy within a reasonable time…

What's wrong. Certain aftermarket replacement fuel filters, models wix filter part numbers 33576, 33577, 33734; napa filter part numbers 3576, 3577, 3734; and carquest filter part numbers 86576, 86577, 86734 used on 1996-2000 daimlerchrysler town & country, dodge caravan, and plymouth voyager vehicles, can cause the fuel lines to leak

Risk. A possible fire can occur in the presence of an ignition source

Fix. Wix will notify its customers and replace the fuel filters free of charge. Note: this does not involve any products manufactured by the daimlerchrysler corp. Nor any dailmerchrysler dealers. Owner notification is expected to begin during november 2003. Owners who do not receive the free remedy within a reasonable time…

What's wrong. On certain minivans, the power liftgate (plg) latch may not engage the striker allowing the liftgate to open while driving

Risk. In the event of a crash, an unbelted passenger could be ejected from the vehicle

Fix. Dealers will replace the power liftgate control module free of charge. The recall began april 26, 2005. Owners may contact daimlerchrysler at 1-800-853-1403

What's wrong. This is not a safety recall in accordance with the safety act. However, it is deemed a safety improvement campaign by the agency. Vehicle description: 2001 plymouth voyager, chrysler town & country, and dodge caravan/grand caravan mini vans that are not equipped with the remote keyless entry option. The sliding door latches on these vehicles could release during certain severe accident conditions that involve the sliding door

Risk. This could allow the sliding door to partially open

Fix. Dealer will replace both sliding door key cylinder-to-bell crank links on the sliding doors free of charge (parts and labor). Daimlerchrysler has decided to conduct a service campaign to replace the sliding door key cylinder-to-bell crank links. Owners can contact daimlerchrysler at 1-800-853-1403, concerning this…

What's wrong. Vehicle description: light duty passenger minivans with remote release. This is not a safety recall. There has been no determination that a safety defect exists with the minivan latches. Chrysler is conducting a service campaign to replace the liftgate latch assembly of the affected minivans. In a collision, the rear liftgate latch assembly could open

Risk. If the liftgate latch opens, occupants can be ejected resulting in significantly increased risk of injury or death

Fix. Chrysler will replace the liftgate latch with a new stronger latch assembly without charge. Chrysler began notifying owners during december 1995

What's wrong. After performing the ncap test, it was discovered that on certain minivans equipped without the available "stow 'n go" seating option, the right front seat belt retractor assembly may have been improperly assembled

Risk. As a result, the seat belt may not properly restrain the occupant during certain crash conditions, which can increase the risk of injury

Fix. Dealers will inspect the retractor assemblies and any seat belt assembly that does not have the stake will be replaced. Owner notification began on february 23, 2004. Owners should contact daimlerchrysler at 1-800-853-1403

What's wrong. On certain minivans, some trim material can loosen and drop into the rear outboard seat belt assembly, causing the seat belt to become inoperative

Risk. In the event of a crash, the seat occupant may not be properly restrained, increasing the risk of personal injury

Fix. Dealers will replace the trim with foam blockers and inspect and replace all 3rd row seat belt assemblies. Owner notification began june 3, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact…

What's wrong. Vehicle description: certain van, wagon, pickup trucks, passenger and sport utility vehicles, fail to comply with requirements of fmvss no. 209, "seat belt assemblies." the front seat belt retractor may not comply with the requirements of the standard

Risk. If the retractor does not work properly, it will not adequately protect occupants in the event of a crash

Fix. Dealers will replace the seat belt retractor. Owner notification began august 20, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403

What's wrong. Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. These brake cylinders were sold under the brand names of napa, raybestos, aimco, AC delco, carquest, bendix, and wagner. Only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. When subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak

Risk. Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash

Fix. Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. The recall began on march 20, 2006. Owners can contact affina group customer service at 1-800-323-0354

What's wrong. Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. These brake cylinders were sold under the brand names of napa, raybestos, aimco, AC delco, carquest, bendix, and wagner. Only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. When subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak

Risk. Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash

Fix. Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. The recall began on march 20, 2006. Owners can contact affina group customer service at 1-800-323-0354

What's wrong. Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. These brake cylinders were sold under the brand names of napa, raybestos, aimco, AC delco, carquest, bendix, and wagner. Only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. When subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak

Risk. Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash

Fix. Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. The recall began on march 20, 2006. Owners can contact affina group customer service at 1-800-323-0354

What's wrong. Eagle eyes is recalling 11,534 headlamp assemblies, p/nos. Cs090-b001l and cs090-b001r, sold for use as replacement equipment for the above listed passenger vehicles. These headlamps fail to conform to the lower beam photometry requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Risk. Decreased lighting visibility may result in a vehicle crash

Fix. Eagle eyes will notify owners and offer replacement headlamps free of charge. The recall began on september 30, 2008. Owners may contact eagle eyes at 1-800-568-1098

What's wrong. Maxzone is recalling 2,520 headlight assemblies, depo brand, p/nos. 3341103l-as and 334-1103r-as sold for use as aftermarket equipment for 2001-2007 dodge caravan passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment

Risk. Decreased lighting visibility may result in a vehicle crash

Fix. Maxzone will notify owners and offer reimbursement for any noncompliant headlights. The recall began on june 16, 2008. Owners may contact maxzone at the following locations: 1-888-286-1188 (wa, or, ca, id, nv, az, mt, wy, ut, co, ks, nm, ok, tx, ar, la, ak, hi) 1-877-253-8930 (me, nh, vt, ma, ct, ri, ny, nj, pa, md,…

What's wrong. Eagle eyes is recalling 11,534 headlamp assemblies, p/nos. Cs090-b001l and cs090-b001r, sold for use as replacement equipment for the above listed passenger vehicles. These headlamps fail to conform to the lower beam photometry requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Risk. Decreased lighting visibility may result in a vehicle crash

Fix. Eagle eyes will notify owners and offer replacement headlamps free of charge. The recall began on september 30, 2008. Owners may contact eagle eyes at 1-800-568-1098

What's wrong. Chrysler is recalling certain model year 2005-2006 dodge caravan, grand caravan and chrysler town & country vehicles originally sold in or currently registered in the states of connecticut, delaware, iowa, illinois, indiana, kansas, kentucky, massachusetts, maine, maryland, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, west virginia, wisconsin, alaska and the district of columbia. The front crash sensors may crack under certain environmental conditions and allow water to enter into the sensor. This can cause the sensor to become inoperative and illuminate the…

Risk. If the front crash sensors become inoperative, the driver is immediately alerted by illumination of the airbag warning light and the vehicle should be promptly serviced. Until the vehicle is repaired, the airbags may not provide the enhanced protection in the event of a crash

Fix. Chrysler will replace the front airbag sensors with a new design. This service will be performed free of charge. The safety improvement campaign will begin during june 2010. Owners may contact chrysler at 1-800-853-1403

What's wrong. Chrysler is recalling certain model year 2005-2006 dodge caravan, grand caravan and chrysler town & country vehicles originally sold in or currently registered in the states of connecticut, delaware, iowa, illinois, indiana, kansas, kentucky, massachusetts, maine, maryland, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, west virginia, wisconsin, alaska and the district of columbia. The front crash sensors may crack under certain environmental conditions and allow water to enter into the sensor. This can cause the sensor to become inoperative and illuminate the…

Risk. If the front crash sensors become inoperative, the driver is immediately alerted by illumination of the airbag warning light and the vehicle should be promptly serviced. Until the vehicle is repaired, the airbags may not provide the enhanced protection in the event of a crash

Fix. Chrysler will replace the front airbag sensors with a new design. This service will be performed free of charge. The safety improvement campaign will begin during june 2010. Owners may contact chrysler at 1-800-853-1403

What's wrong. Certain minivans are being recalled that were originally sold in or currently registered in the 27 states plus the district of columbia that use greater amounts of salt for winter road deicing. The up-front (uf) air bag sensors that contain brass bushings installed in these vehicles may corrode and crack allowing water to enter the sensor. These sensors provide enhanced air bag performance in certain types of frontal crashes

Risk. In one of these crashes, with one or both of the vehicle's uf sensors inoperative, the occupants will not benefit from the enhanced air bag protection that these sensors would provide

Fix. For vehicles registered in the recall states, dealers will replace the original uf air bag sensors with ones with greater corrosion resistance. Vehicles registered in other states will obtain a lifetime free replacement of any uf sensor that fails. The campaign began on july 2, 2007. Owners may contact daimlerchrysler…

What's wrong. Certain curved tempered replacement glass manufactured by hangzhou safety glass ltd and supplied to safelite by auto temp inc., identified as DOT-430, and sold for use on certain domestic and foreign vehicles may not break into small pieces as expected of tempered glass and fails to conform to federal motor vehicle safety standard no. 205, "glazing materials."

Risk. In the event of a vehicle crash, the occupant(s) may be seriously injured by shattered glass

Fix. Safelite will notify its retail customers and replace the glass free of charge. Retail customers can contact safelite toll free at 1-888-843-2906. Safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their customer's glass. Wholesale…

What's wrong. Certain curved tempered replacement glass manufactured by hangzhou safety glass ltd and supplied to safelite by auto temp inc., identified as DOT-430, and sold for use on certain domestic and foreign vehicles may not break into small pieces as expected of tempered glass and fails to conform to federal motor vehicle safety standard no. 205, "glazing materials."

Risk. In the event of a vehicle crash, the occupant(s) may be seriously injured by shattered glass

Fix. Safelite will notify its retail customers and replace the glass free of charge. Retail customers can contact safelite toll free at 1-888-843-2906. Safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their customer's glass. Wholesale…

What's wrong. On certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break

Risk. During certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash

Fix. Dealers will inspect and replace the windshield wiper motor free of charge. The recall began on june 19, 2006, to dodge durango owners. Minivan owners will be notified during july 2006. Owners may contact daimlerchrysler at 1-800-853-1403

What's wrong. Curt mfg is recalling certain class 3 receiver hitches, p/n 13347, sold as aftermarket equipment for use on 1997-2007 chrysler town and country vans, 1996-2007 dodge caravans, and 1996-2004 plymouth voyager vans. When the hitch is loaded to the maximum rating, the hitch may fracture or break at the bend location where the main body of the hitch meets the hitch muffler strap

Risk. If the area in question fractures or breaks, this could cause an unstable driving condition, possibly resulting in a crash

Fix. Curt mfg will notify owners of record and will replace the hitch free of charge. The safety recall is expected to begin during august 2010. Owners may contact curt mfg at 1-715-831-8713

What's wrong. Curt mfg is recalling certain class 3 receiver hitches, p/n 13347, sold as aftermarket equipment for use on 1997-2007 chrysler town and country vans, 1996-2007 dodge caravans, and 1996-2004 plymouth voyager vans. When the hitch is loaded to the maximum rating, the hitch may fracture or break at the bend location where the main body of the hitch meets the hitch muffler strap

Risk. If the area in question fractures or breaks, this could cause an unstable driving condition, possibly resulting in a crash

Fix. Curt mfg will notify owners of record and will replace the hitch free of charge. The safety recall is expected to begin during august 2010. Owners may contact curt mfg at 1-715-831-8713

What's wrong. Curt mfg is recalling certain class 3 receiver hitches, p/n 13347, sold as aftermarket equipment for use on 1997-2007 chrysler town and country vans, 1996-2007 dodge caravans, and 1996-2004 plymouth voyager vans. When the hitch is loaded to the maximum rating, the hitch may fracture or break at the bend location where the main body of the hitch meets the hitch muffler strap

Risk. If the area in question fractures or breaks, this could cause an unstable driving condition, possibly resulting in a crash

Fix. Curt mfg will notify owners of record and will replace the hitch free of charge. The safety recall is expected to begin during august 2010. Owners may contact curt mfg at 1-715-831-8713

What's wrong. On certain minivans equipped with 3.3 or 3.8l v-6 engine, the upper power steering cooler hose may split and cause a fluid leak

Risk. Power steering fluid leakage in the presence of an ignition source can result in an under hood fire

Fix. Dealers will replace the upper power steering cooler hose. This recall began on september 27, 2004. Owners should contact daimlerchrysler at 1-800-853-1403

What's wrong. On certain minivans equipped with 3.3 or 3.8l v-6 engine, the upper power steering cooler hose may split and cause a fluid leak

Risk. Power steering fluid leakage in the presence of an ignition source can result in an under hood fire

Fix. Dealers will replace the upper power steering cooler hose. This recall began on september 27, 2004. Owners should contact daimlerchrysler at 1-800-853-1403

What's wrong. On certain minivans equipped with 3.3 or 3.8l v-6 engine, the upper power steering cooler hose may split and cause a fluid leak

Risk. Power steering fluid leakage in the presence of an ignition source can result in an under hood fire

Fix. Dealers will replace the upper power steering cooler hose. This recall began on september 27, 2004. Owners should contact daimlerchrysler at 1-800-853-1403

What's wrong. The braun corporation is recalling certain model year 2008 through 2010 chrysler town & country and dodge caravan mobility conversions which were altered by braun between january 21, 2009 and march 19, 2010. During conversion, the chassis was raised and the floor was lowered to accommodate wheelchair accessibility features. In raising the chassis, the rear spring hats come into closer proximity to the rear tires. In rough or aggressive driving situations the tires may intermittently contact the rear spring hats

Risk. Contact between the tire spring hat may wear a hole in the tire over time. This may result in loss of vehicle control in the event of tire pressure loss increasing the risk of a crash

Fix. Braun will notify owners and repair the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun toll-free at 1-800-488-0359

What's wrong. Vehicle description: minivans. The lower control arm pivot bolt could fracture

Risk. If the bolt fractures, the lower control arm could separate from the crossmember, causing a loss of vehicle control

Fix. Dealers will replace the left and right lower control arm bolts and nuts. Owner notification began april 30, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403

What's wrong. Federal mogul is recalling 6,903 aftermarket ball joint assemblies shipped between november 9, 2007 and march 26, 2008, which may have been packaged with incorrect nuts. The part numbers packaged with incorrect nuts are: k7147, k7329, k8683, and 104353. These parts were made for use on the various vehicles listed above

Risk. The nuts included in the packaging for these ball joint assemblies are missing the intended prevailing torque (self-locking) feature. If the incorrect nut was to become loose, the joining members may loosen leading to a separation of the ball joint. This may result in loss of vehicle control, possibly resulting in a…

Fix. Federal mogul will notify owners and replace the parts free of charge. The recall began on may 22, 2008. Owners can contact federal mogul at 877-489-6659