Owners have filed 46 complaints on the Toyota GR86, covering 2022–2025. The system named most often is Engine (20 reports). Worst years by volume: 2022, 2023, 2025; cleanest: 2024, 2025, 2023. 1 reports describe a crash, 1 a fire. On average the car was 1.1 years old when the problem happened.
What breaks on Toyota GR86
Grouped by the system owners named — percentages are shares of all 46 GR86 complaints. Open any row for the full reports in owners' own words.
Engine 20 Read
The contact owned a 2022 Toyota GR86. The contact was at a complete stop when the vehicle exploded into flames. The contact was able to exit the vehicle safely before the vehicle was completed destroyed. The fire department arrived on the scene and extinguished the fire. The police arrived on the scene and filed a…
Myself and others online have noticed unusual wear on fuel lines located in the engine bay. There are 3 fuel lines on the right side of the engine bay to the right of the intake manifold that can become chafed. Because these are fuel lines I find the fact that they have wear to be very concerning and a potential fire…
Engine blew around May, what caused this issue would be unknown even though the dealership said it was excessive RTV on the oil pan, there was no RTV on the oil pan (i have a picture). I was driving on the highway and slowing down to take my exit, it happened around 25mph, car got stuck on 3rd gear if im not mistaken…
Fuel/propulsion System 7 Read
Fuel line is rubbing under the hood. I have seen where this is the cause of fires so I went to check mine and it has been rubbing
1. The problem is the alleged “rubbing” of the fuel lines I have encountered among the other GR86 owners that are having the same issue. 2. Could possibly cause a fire while operating the vehicle as it has allegedly been the cause of a few already. 3. No. 4. No. 5. No since it is a hose issue
There seems to be wear in the fuel lines under the hood. Possibly caused from rubbing against something
Exterior Lighting 5 Read
One day I noticed something dangling near the rear license plate while parked. It was the right-side license plate light. Upon inspection of the (good) left-side license plate light, everything seemed pretty secure. The right-side license plate light has a plastic bracket on the one side and a plastic clip on the…
The dome light on the driver side has failed. This is not due to a dead bulb, but instead the circuit area seems to die if the car sits in the sun. This has been confirmed by a dealer but I haven't yet scheduled an appointment to replace the electrical parts. There were no safety warnings
When the rear of my vehicle is directly facing the sun slightly after sunrise or before sunset (when the angle of the sun is low), my rear turn signals fail to function properly. When this happens, the turn signals hyperflash on the dash, and in the front of the vehicle. However the main concern is that the rear turn…
Power Train 3 Read
While driving on the highway at approximately 80–90 mph, the vehicle experienced an unexpected RPM increase as I came off the accelerator, an engine-misfire warning, sudden loss of power, and engine shutdown. I immediately pulled over. Smoke came from the engine compartment, engine oil had been expelled throughout the…
It was an afternoon, I’m from [XXX] going to tempe my friends house which is estimated 34 miles. I took the loop XXX driving mid way there all of sudden my car made loud werid rattling noise coming from the engine area. When accelerating it made rattling sound and when i let go of the gas it also made loud noises…
The engine on my GR86 failed when I was accelerating onto a freeway. This has been confirmed by the dealership and the car is in need of a short or long block repair. The vehicle has just over 9000 miles on it and the manufacturer and the dealership are refusing to cover this under warranty. Gasket material was found…
Tires 2 Read
My daughters were involved in a highway accident on 2-4-2023 when their rear passenger tire came apart. The vehicle is a 2022 Toyota gr86 premium, came with Michelin Pilot Sport 4 tire, was purchased new in August 2022 and had 3008 miles on the odometer just after the accident
215 45 R 17 tire flew off the rim on a straight paved highway road going 45 mph. The sidewall separated all the way around and the tire was not torn anywhere else. The mileage was 29395
Electrical System 2 Read
The car began throwing alerts about SRS system failure, RAB failure and eyesight (safety system) being disabled suddenly while driving. Dealership said dashcam plugged into the 12v port in the car overloaded the fuse. Issue remains that the dashcam remained functional before and after and fuse for 12v is independent…
There are multiple incidents and confirmed by many different owners across the nation. Toyota GR86 / Subaru BRZ when there is strong sunlight direct towards the taillights, the turn signals (rear) will not operate and hyperflash at the front signal lights This is a safety hazard, and couple owners had been ticketed…
Suspension 1 Read
The Cross- Caster Defect: "A comparative analysis of two alignment sheets proves a structural suspension failure. On June 4, 2026, the vehicle's left front caster was at a factory-healthy 5.9 Following a tire blow out/tire failure just three weeks later the left front caster dropped to 5.6. This creates a severe 0.5…
Lane Departure 1 Read
The BSD or blind spot detection has worked intermittently since purchasing it new. Ive been honked at when merging into other vehicles on the highway several times. I also pay attention to it to see if it will alert on cars in my blind spot. Most times it does but numerous times on each trip it does not alert me. When…
GR86 years to avoid — and the clean ones
Complaints per model year. More reports usually means more cars on the road as well as more trouble, so read the crash and fire columns alongside the count.
| Model year | Complaints | Top system | Crashes | Fires |
|---|---|---|---|---|
| 2025 | Fuel/Propulsion System | — | — | |
| 2024 | Engine, Fuel/Propulsion System | — | — | |
| 2023 | Electrical System, Air Bags, Forward Collision Avoidance | — | — | |
| 2022 | Electrical System, Exterior Lighting | 1 | 1 |
The same model year, different builds
Every complaint carries the first 11 characters of the VIN — plant, year, body and engine. That is a production series, and complaints are spread across them very unevenly.
| Measure | Value |
|---|---|
| Distinct production series | 35 |
| Average complaints per series | 1.3 |
| Worst single series | 3 complaints |
| Average age at failure | 1.1 years |
A model average of 1.3 hides a worst series at 3. Enter a VIN above to see the numbers for that exact build instead of the model as a whole.
Owners reported these. Find out if yours is one of them.
- Complaints matched to the exact production run, not just the model
- What the car is worth given what tends to fail on it
- The original window sticker and factory options
- Full research report as a PDF for the pre-purchase inspection
- No ads, on every page
- No ads, no tracking — and much more
How we count
Every figure here comes from complaints owners filed with NHTSA — 1,109,349 of them, covering 2,013 models built between 1981 and 2026.
A complaint is an unverified report: someone wrote down what happened to their car. It is not a confirmed defect and not a recall. What makes the volume useful is the pattern — when thousands of owners of the same build describe the same failure, that is a signal no marketing brochure will give you.
Two things we do that the source does not. First, we compute the age of the car at the moment of failure from the incident date and the model year. Second, we group complaints by the first 11 characters of the VIN — the production series — so a bad plant run does not disappear into a model-wide average.
Frequently asked questions
What are the worst years for the GR86?
By complaint volume, 2022, 2023, 2025 drew the most owner reports. Bear in mind that popular years put more cars on the road, so check the crash and fire columns too.
Which GR86 years are the cleanest?
2024, 2025, 2023 have the fewest complaints on file. For recent years that can simply mean the cars are young.
How many complaints does the Toyota GR86 have?
46 owner complaints filed with NHTSA, covering 2022–2025. Of those, 1 describe a crash and 1 a fire.
Are these complaints verified?
No. They are unverified reports from owners. NHTSA publishes them as filed and investigates only a fraction. The value is in the pattern, not in any single report.
Can I check complaints for one specific car?
Yes — enter its VIN above. We match the first 11 characters, which identify the plant, year, body and engine, so you get complaints on that exact production series rather than the whole model.
Mark ForCar as a preferred source and our data shows up first in your Google results. One click, no account.